Word Pro - WC18INavrGB.lwp
Contents
1. ration the wine cellar reject outside some air arround 20 C above aspiration temperature This air si rejected in indoors well ventilated or outside the house This op ration is made with isolated s ducts in the wine cellar 1 1 HOT AIR OUTLET If the WINEMASTER hot air outlet is indoors the room must be well ventilated to ensure that the temperature does not exceed 35 C The ideal temperature is arround 20 C It is preferable to discharge the hot air outside if possible via ducts The air intake and outlet ducts must not be connected to each other nor obstructed to avoid overheating the unit The two openings intake and outlet must therefore be at least 200 mm apart The maximum length of each duct must not exceed 10 metres This lengh as to be reduced according to number of bends 1 meter per bend The radius of the bends must be upper than 300 mm The diamter of the ducts musn t be reduced 1 2 THE CELLAR 1 2 1 INSULATION Insulation of the 4 walls the door the ceiling and the floor is essential for the Winemaster to work properly Adequate insulation helps to obtain the stability of the temperature and the humidity The board on the next page choice of insulati can be used to determine the type and the thickness of insulation needed according to the internal volume of the cellar and a cellar temperature of 12 C Insulation continuity Insulating components must be assembled preferably by interlocking panels2. rodents mice rats It is therefore essential to make sure that the walls of the cellar do not contain holes which would allow rodents access to the insulation This insulation must be lined on the inner surface of the cellar with a protective facing Polyurethane insulation because of its chemical composition is not attacked by rodents 1 2 3 FLOOR INSULATION The cellar floor must be able to support shelves and the wine stored on them You should therefore choose an insulating material with adequate compression resistance for this part Manufacturers recommend appropriate insulation or materials designed specifically for floor insulation in their documentation Page 25 WINEMASTER C18 IN USER GUIDE Puncture resistance feet of shelves in particular is provided 04 2003 by using complex insulation panels lined on the upper surface with a strong panel by facing the insulation with a panel of chipboard approx 15 mm thick or any other suitable covering plaster and slab for example 1 2 4 THE DOOR It is part of the continuity of insulation There are two possible solutions to insulate the existing door using the same type as insulation as was used for the cellar walls Insert a seal such as foam between the door panel and the frame all around the edge use a FONDIS ISOTHERMAL DOOR lined with polyurethane foam It includes a seal around its periphery with a magnetic closure 1 2 5 INS
3. the setting simply press on the symbol 4 for 5 seconds The display ref 5 then displays SET Press the symbol J once again briefly The set temperature is displayed To increase it press the up arrow To reduce it press the down arrow When The temperature on the display is correct confirm by pressing to symbol 4 until it shows again SET Light 2 indicates that the device is defrosting Light 3 indicates that it is in heating mode Light 4 indicates that the compressor is running When there is no light lit the cellar temperature is close to the set temperature After changing a setting because of a fitting which prevents it from starting up too frequently the compressor will only start up after a few minutes Page 29 WINEMASTER C18 IN USER GUIDE 04 2003 3 3 AUTOMATIC DEFROST The program of the thermostat will run an automatic defrost time several times a day During this position the compressor cannot sart Only the fan in the cellar can function The condensate water produced during this period will be evacuated through the tube 4 MAINTAINING THE WINEMASTER AIR CONDITIONER THE DUST FILTER It is essential to replace the dust filter which is outside the cellar as soon as necessary and at least once a year If it is clogged the air conditioner may be seriously damaged 4 1 CHANGING THE FILTER e Unscrew the 2 four black plastic screws under the air conditioner 1 e Remove the cover 2 Pull
4. 4 2 nana o x Rod ua PR 5 1 TWO YEAR CONTRACTUAL GUARANTEE 5 2 TERMS OF APPLICATION OF THE GUARANTEE 5 3 EXCLUSIONS AND LIMITS OF GUARANTEE 04 2003 Page 22 WINEMASTER C18 IN USER GUIDE 04 2003 FROM VINEYARD TO WINE In former times good french cellars were built to maintain a temperature not exceeding 14 to 16 C in all seasons Today this is rarely the case Nevertheless a cellar worthy of the name must be protected against wide variations in temperature be as damp as necessary and ventilated dark and free of vibration This is why for more than fifteen years we have used the expertise of specialists and enthusiastic amateurs to design develop test and produce thousands of air conditioners destined to help in the storage and ageing of wine If you follow our advice and respect our recommendations Winemaster will provide the optimal ageing conditions for your treasured wine collection Don t hesitate to read the installation and operating guide for your FONDIS WINEMASTER cellar air conditioner Contact us if you have any questions So even if there may be long years to wait before the wine reaches perfection the great day will come when you face the delicate job of uncorking Hold the bottle carefully do not remove the capsule on a level with the mouth use a good quality tool or lever remov
5. E COUNTRY In the following section please specify the insulation characteristics of your cellar Type of material and thickness Type of insulation and thickness Wall Floor Ceiling Door How did you learn about FONDIS WineMaster cellar air conditioning systems 0 through a trade show O through a vendor O through an editorial article O through an advertisement other please specify Dann 2A
6. ULATION OF OTHER ITEMS A fridge or another appliance producing heat must not be placed inside the cellar For example any hot water pipe going through the cellar must also be insulated 2 INSTALLING THE WINEMASTER AIR CONDITIONER IN THE WINE CELLAR Make sure you have chosen the best place for fitting the air conditioner chose the best place in order that the lengh of the flexible ducts will be shorter as possible put the wine cellar on the ground or on his horizontal support there should not be any obstacle in front of the ventilation grid to facilitate air flow the support or floor must be level and not transmit vibrations 2 1 DRILLING THE WALL 2 1 1 2 1 2 GRIDS Draw the grid s site on the wall which divide the wine cellar to the reject indoor Pierce 2 holes 130 mm Install the 2 grids in the wall Connect the duct at the back of grids 2 3 The seal between the ducts and the insulation must be filled with polyurethane foam for example WALL HOLDER Two squares are delivered together with the Winemaster Open them out and fix them as per herewith drawing Select the adequate screws with regards to the wall material you are using Page 26 WINEMASTER C18 IN USER GUIDE 04 2003 2 2 DIMENSIONS NEA m Y ES wre N u 97 NV i m 250 P T 2 3 FIXING THE WINEMASTER Install the Winemaster on the wall holder e Sc
7. WINEMASTER C18 IN USER GUIDE INSTRUCTIONS FOR USE TABLE OF CONTENTS Introduction From Vineyard to wine 1 LAYOUT OF PREMISES ea aei os 1 1 HOT AIROUTLET niece via Gale IR eI 1 27 THE CELLAR x une e dtes gate meto ae tact era T 2 1 INSULATION ouo eet t eot des e edo rg 1 2 2 WALLS AND CELLING INSULATION 1 2 3 FEOOR INSULATION 22 422242 hati er er Selena aes 1 24 ione a a a ER Eee 1 2 5 INSULATION OF OTHER ITEMS 2 INSTALLING THE WINEMASTER AIR CONDITIONER 2 1 DRILLING THE WALL 244424 ss se deu pe 3 E aude 2 1 GRIDS cure serene Rer ee ae Rena ee 2 1 2 WALELE HOLDER 2 2 2 DIMENSIONS iiie En tema Ri rete o ng ia 2 3 FIXING THE WINEMASTER 2 24 INSTALLING THEDUCTS 2 5 INSTALLING THE WATER DRAINAGE SYSTEM 3 USING THE WINEMASTER AIR CONDITIONNER 3 1 CONNECTING THE AIR CONDITIONER 3 2 SETTING THE TEMPERATURE 3 8 AUTOMATIC DEFROST 4 MAINTAINING THE WINEMASTER AIR CONDITIONER 4 1 CHANGING THE FILTER ex a e ROCCO OEC o n n a ehe EC RC acta B GUARANTEE 2
8. e the cork without shaking the bottle and examine the mirror But that s another story SERVICE CLIENTS FONDIS Tel 0 389 377 500 Fax 0 389 377 589 E mail contact fondis com Attention Wait for 24 hours before switching on the air conditioner Page 23 WINEMASTER C18 IN USER GUIDE 04 2003 CHARACTERISTICS WINE C18IN Setting the temperature Preset to 13 C adjustable between 4 and 15 C Maximum outdoor temperature 39 Ct Cooling power 550 W at 15 C Electricity supply 230 240 C 50 Hz with earth connection supplied with 3 m cable Electrical power 450W Heating power 250W The circuit breaker must be at least 16 Amps The insulation quality and thickness has to be in accordance with the volume of the cellar and the set temperature The cooling performance is dependant from the outside temperature Therefore the set temperature of 12 C for the cellar cannot be maintained if the outside temperature of the cellar is maintained at 35 C If the thermal safety functions to often there is a risk for the condensator and starter to be damaged all the cases it must be avoided that the outside temperature remains at 35 C This high temperature should be limited to the summer period 1 LAYOUT OF PREMISES The air conditioner is installed entirely in the wine cellar it can be fitted on the floor or on a suitable support which can bear the weight of the unit For a correct op
9. igence poor maintenance defective or inappropriate use of the WINEMASTER Part exchanges or replacements under guarantee will not have the effect of extending it FONDIS SA cannot be held responsible under any circumstances for the direct or indirect consequences of the air conditioner s failure to function The guarantee is limited only to the product supplied by FONDIS SA Page 31 GERTIFICAT DE GARANTIE WINEMASTER FONDIS Pour valider votre garantie contractuelle de 2 ans conform ment aux conditions de garantie pr cis es dans le guide d utilisation merci de nous retourner ce bon d ment rempli dans les 15 jours suivant votre achat Pour renvoyer votre bon de garantie FONDIS il vous suffit de le mettre dans une enveloppe sans l affranchir l adresse suivante FONDIS SA LIBRE REPONSE 90010 68804 THANN C dex CacHET DU POINT DE VENTE DATE D ACHAT DATE D INSTALLATION INSTALLATEUR Nous vous remercions de nous pr ciser ci dessous les conditions d installation de votre climatiseur de cave Caract ristiques de l isolation Volume climatis m Descriptif mat riaux et paisseur d isolant et paisseur Plafond Porte Comment avez vous connu le Winemaster FONDIS Par le revendeur O Par une foire Par un article r dactionnel C Par la publicit Autre pr ciser CD GARANTIESCHEIN F R WINEMASTER FoNDIS Damit Ih
10. or glueing the panels together to ensure perfect continuity of insulation Page 24 WINEMASTER C18 IN USER GUIDE 04 2003 This is very important it prevents heat and humidity entering from the outside which would counter the effects of regulation IMPORTANT The validity of the WINEMASTER guarantee depends on the values in the Choice of insulation table being strictly respected for all the cellar walls including floor and ceiling door as well as perfect continuity of insulation CHOICE OF INSULATION MINIMUM THICKNESS OF INSULATION mm for 12 C cellar temperature EXPANDED EXTRUDED POLYURETHANE CELLAR POLYSTYRENE POLYSTYRENE FOAM VOLUME 3 my Y 0 044WIm C 0 030W m C 0 025W m C WINE C18 IN 6 40 30 20 8 50 40 30 10 60 40 40 12 80 50 40 14 90 60 50 15 100 70 60 16 110 80 70 17 120 90 80 18 130 100 90 1 2 2 WALL AND INSULATION The manufacturers propose their insulating panels in several forms insulation alone complexes the insulation is lined with a facing plaster mineral sandwiches the insulation is lined on each side with a wooden or plaster panel The panel facing is important it protects the insulation from shocks and guarantees long life Do not use mineral fibre insulation Glasswool stonewool because it stores humidity and loose its insulation capacity Protection against rodents Some insulating materials are damaged by
11. re vertragliche 2 Jahres Garantie wirksam werden kann m ssen Sie gem den in der Gebrauchsanleitung beschriebenen Bedingungen diesen Garantieschein ausf llen und innerhalb von 2 Wochen nach dem Kaufdatum an FONDIS einsenden Sie k nnen den Garantieschein in einem frankierten Umschlag an folgende Adresse schicken FONDIS S A F 68801 THANN CEDEX STEMPFEL DES FACHGESCHAFTES MODELL SERIENNUMMER KAUFDATUM Bitte geben Sie hier an wie Ihre Weinklimaanlage installiert wurde Beschaffenheit der D mmung Klimatisierter Rauminhalt m Materialbeschreibung und Dicke Art des D mmstoffs und Dicke T r Wie sind Sie auf WINEMASTER von FONDIS aufmerksam geworden Durch meinen Fachh ndler Auf einer Verbrauchermesse C Durch einen Zeitungsartikel C Durch Werbung O Sonstiges bitte erl utern Dann 22 Warranty GERTIFICATE FONDIS In order to validate your 2 year contractual warranty in accordance with the specified warranty conditions stated the WineMaster user manual please complete and return this warranty certificate within 15 days from the date of purchase to the following address FONDIS S A F 68801 THANN CEDEX Model POINT OF SALE STAMP Serial number Purchase date Installation date Installer The volume of your wine cellar in meters squared FIRST NAME LAST NAME ADDRESS POSTAL COD
12. rew the unit with 10 key Page 27 WINEMASTER C18 USER GUIDE 2 4 INSTALLING THE DUCTS 04 2003 The connections must be sealed to prevent condensation forming on the walls of the air conditioner flue collar across the flue collar and the duct E Place the inside duct the Stick the adhesive tape Take it round several times Position the insulation duct to ensure a good seal then the ring clamp Example Page 28 WINEMASTER C18 IN USER GUIDE 04 2003 2 5 INSTALLING THE WATER DRAINAGE SYSTEM e Slide on the PVC tube on the condensate container 1 e Open the ring 2 and slide along the tube e Setthe ring as near as possible Important Wait for 24 hours before switching on the air conditioner 3 USING THE WINEMASTER AIR CONDITIONER 3 1 CONNECTING THE AIR CONDITIONER When you plug it into the electrical socket The fan in the cellar starts up immediately The compressor may not come on until 2 minutes later if the temperature of the cellar is higher than the set temperature If the temperature of the cellar is the same as the setting on the thermostat the compressor will not come on 3 2 SETTING THE TEMPERATURE I 12 o The thermostat is equipped with a joystick on the right hand side ref 1 which can be used to change the setting To change
13. the tab to release the filter Replace it with a FONDIS filter only You can then replace the cover Page 30 WINEMASTER C18 IN USER GUIDE 04 2003 5 GUARANTEE 5 1 TWO YEAR CONTRACTUAL GUARANTEE The air conditioner is guaranteed for two years against manufacturing defects During the contractual guarantee period FONDIS will replace any part recognized as defective following the intervention of a qualified representative In the event of an electrical breakdown FONDIS will replace any part recognized as defective following the intervention of a qualified stockist or his representative In the event of cooling system breakdown FONDIS can ask for the part to be returned for repair following the intervention of a qualified representative The equipment will be packed and held available for the FONDIS carrier to collect it Operations and returns must be made with the written agreement of FONDIS after sales service 5 2 TERMS OF APPLICATION OF THE GUARANTEE The contractual guarantee applies to all devices installed and used in accordance with the Installation and operating guide Application of the contractual guarantee depends on the guarantee card at the back of the booklet being returned within 15 days of purchase 5 3 EXCLUSIONS AND LIMITS OF GUARANTEE The guarantee is refused in the following cases The cellar and installation have not been insulated in accordance with this guide The damage is due to negl
Download Pdf Manuals
Related Search