Portable Buddy
Contents
1. GAS CONTAINERS 3 Never leave heater unattended when in use CAUTION accessible parts may be very hot Keep young children away 4 Always use oven mitts oven gloves when handling the heater after use Installation operation and maintenance instructions Safety information if you smell gas e If there is a leak on your appliance smell of gas immediately attempt to turn off e Remove the appliance to a well ventilated location away from any ignition source e Only check for leaks outdoors using soapy water e Do not try to detect leaks using a flame e When leak has stopped ventilate and disperse gas from the area before continuing IMPORTANT read this instruction for use carefully Familiarise yourself with the appliance before connecting it to the gas bottle This appliance is for use with disposable propane cartridges only e Do not remove regulator connect to high pressure canister or use adaptors e When changing gas cartridge ensure that it is undertaken in a well ventilated area preferably outside and away from sources of ignition such as naked flames pilot flames electrical and heating equipment and people e To check if cartridge has sufficient gas pick up cartridge and shake from side to side If there is movement or the sounds of liquid moving inside the cartridge then it will contain gas FOR OUTDOORS USE ONLY ONLY USE IN WELL VENTILATED AREAS This appliance shall only be used i2. H9BX w 32004 Red 6 32032 Burner Assy 75194 Panel Back Metal Housi ight Plasti w32004 Yelow Se0o1 Housing Pit Paso Bak 75196 Panel Back Metal Suh ees w 32004 Green 8 32068 Orifice Assy with O Ring Troubleshooting Instructions Problem Remedy Check spark electrode if defective replace ODS Oxygen Depletion Sensor Check igniter wire is correctly attached to spark If Spark electrode does not produce electrode spark Check igniter wire if damaged replace Check piezo igniter if defective replace control valve No gas to heater install disposable cylinder or connect hose and filter where required and turn on valve at remote cylinder If Spark electrode produces spark but pilot does not light Check if PILOT position is properly aligned turn gas control knob to PILOT position and depress Check is pilot is blocked from spider web or dirt clean pilot see MAINTENANCE Check if control knob in PILOT position not completely depressed or held in long enough to purge air from lines If Pilot flame does not stay lit when knob if pilot flame is not surrounding thermocouple clean is released pilot see MAINTENANCE Check if pilot assembly is defective replace Check if tip switch wires are disconnected connect Check if main burner orifice is blocked clean burner see MAINTENANCE Check if pilot is bloc
3. Mic Heater by PRIMUS Portable Buddy COMPACT PROPANE HEATER Part No MH9BX User Manual and Product Specifications IMPORTANT Read these instructions for use carefully Familiarise yourself with the appliance before connecting it to its gas container Keep these instructions for future reference DO NOT Operate this appliance before reading the instruction booklet DO NOT Place articles on or against this appliance DO NOT Store chemicals flammable materials or spray aerosols near this appliance DO NOT Operate with panels covers or guards removed from this appliance DO NOT Operate in an enclosed area without ventilation DO NOT Operate in a boat caravan or tent Image for representation purposes only and may differ from actual product Safety Instructions 7 Important 1 Please read all instructions carefully 2 Dispose of all polythene packaging carefully and keep out of the hands of young children Safety warning Please read all safety warning and assembly instructions before use Retain all information for future reference Failure to follow the instructions may cause personal injury and or damage 1 Never use in unventilated or enclosed areas This heater consumes air and could endanger life if used in unventilated or enclosed areas 2 Only non refillable 468g disposable cylinders are to be used with this appliance CAUTION IT MAYBE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPES OF
4. POOR COMBUSTION AND HIGHER LEVELS OF CARBON MONOXIDE MAY RESULT Shut Down Instructions a e To shut off heater slightly push down and turn Control Knob clockwise to OFF position e CAUTION After turning heater off wire guard will remain hot Allow to thoroughly cool before storing e Do not operate store or remove cylinder near flammable items or ignition sources e LP GAS CYLINDERS MUST BE DISCONNECTED FROM HEATER WHEN NOT IN USE Push knob to ignite pilot After lit hold for 30 sec Release and turn to desired setting Maintenance Appliance is only to be serviced or repaired by an authorised service centre Return appliance to place of purchase or contact Pilot Flame Oxygen Depletion Sensor Primus Customer Service contact details on back cover Always keep the heater area clear and free from combustible materials gasoline and other flammable vapors and liquids Keep the vent areas slots in the bottom and the top at the front and rear of heater clear at all times Visually inspect the pilot flame and burner periodically during use The pilot flame should be blue in color not yellow and will extend beyond the thermocouple The flame will surround the thermocouple just below the tip A slight yellow flame may occur where the pilot flame and main burner flame meet The burner should be bright orange with a slight blue color around the border a red or
5. ange haze that is visible on the ceramic tile is acceptable and without a noticeable flame A blue flame that rolls out at the top of the ceramic tile indicates an accumulation of dust lint or spider webs inside the casing assembly and main burner assembly If the pilot is yellow or the burner has a noticeable flame cleaning may be required Use the following procedure to inspect the casing assembly and main burner assembly Replacement Parts List N a Z g Dan WL Y x J No Part Description No Part Description No Part Description 1 32017 Knob Valve Safety Red 8 32027 Brkt Valve 19 32052 Orifice Holder 32019 Knob Valve Safety Green 9 32028 Heat Shield 20 32023 Floor Panel Metal 2 32054 Valve Assy Control 0 32015 Handle Back Plastic Gray 21 73403 Switch Tipover 3 32056 Tube Burner Main 32074 Handle Back Plastic Black 22 32046 Brkt ODS 4 32053 Tube Inlet Assy 1 32014 Handle Front Plastic Gray Oxygen Depletion Sensor 5 32051 Guard Wire 32072 Handle Front Plastic Black 23 73404 ODS Pilot Assy 32061 Guard Wire Heavy 2 75198 Assy Regulator w Support 24 32057 Tube Pilot Assy 6 33092 Panel Front Metal Red 3 32080 Housing Left Plastic Gray 25 32067 Magnet Tank 33094 Panel Front Metal Yellow 32085 Housing Left Plastic Black 33093 Panel Front Metal Green 4 32021 Reflector Metal 7 75191 Panel Back Metal 5 33088 Tile Replacement Kit M
6. e below ground level or in areas where unburned gas could build up e Do not move appliance while operating e Clean after use e Do not use this appliance if it is leaking damaged or does not work properly e Do not use this appliance if it has damaged or worn seals e This appliance must only be serviced by an authorised person e Store the gas cartridge outdoors in a well ventilated area or in a storage area compliant with AS1596 NEVER assemble or operate the unit on unstable or uneven ground Always operate in open and well ventilated areas NEVER operate inside a tent caravan camper trailer vehicle or boat NEVER leave the unit unattended whilst operating NEVER open the control panel or dis assemble unit This appliance is not intended for use by young children or infirm person unless they have been adequately supervised by a responsible person to ensure that they can use the appliance safely Young children should be supervised to ensure that they do not play with the appliance This appliance is to be installed as per local regulation and in accordance with AS5601 AG601 Product Identification 1 Control knob 2 Burner tile 3 Folding carry handle 4 Propane cartridge cavity Safety Instructions ka This appliance shall only be used in an above ground open air situation with natural ventilation without stagnant areas where gas leakage and products of combustion are rapid
7. for easy tank installation Screw 468g disposable LP Gas supply cylinder clockwise from bottom into portable heater until hand tight e Check cylinder connection for leaks with soapy water at the threaded connection under the domed plastic cover where the cylinder screws into the regulator SEE WARNING ON THE UNDERSIDE OF THE DOMED PLASTIC COVER Step 3 e Slightly depress and turn Control Knob counterclockwise to PILOT position and depress to light e If heater does not light hold down for approximately 30 seconds release and depress again Repeat until pilot lights E N Step 4 e After pilot lights hold down for 30 60 seconds and then release knob Knob should return to fully extended position e To operate heater slightly depress Control Knob and gently turn to lock in the HI position to light burner tile Leave on HI position until burner tile turns bright orange 4 e After burner tile has turned bright orange adjust heat output by turning Control Knob to desired position LO or HI setting Bdo do NS J A Warning DO NOT OPERATE HEATER UNLESS CONTROL KNOB IS LOCKED IN A POSITION MARKED HI LO or PILOT NEVER SET CONTROL KNOB BETWEEN LOCKED POSITIONS
8. ked clean pilot see MAINTENANCE Tip over switch may have been activated from bumping heater Re light If Main burner does not ignite If Heater keeps shutting OFF during normal operation Check if regulator is defective Replace regulator Check for internal contamination Replace control valve and regulator Call Technical Services for additional information Specifications Part No MH9BX Dimensions 330 x 204 x 343mm Net Weight 3 69kg excluding cylinder Injector Size 0 93mm Gas Consumption 9 5 Mj hr 189 g hr This Appliance Must only be serviced by an authorised person Suitable for camping use only Shall NOT be exposed to moisture or rain Shall only be used with a propane gas cartridge certified to DOT2P UN2037 EN417 May be hazardous to attempt to fit other types of gas containers Only be used in a well ventilated area Can produce carbon monoxide which has no odor Using it in an enclosed space e g caravan tent car mobile home may cause death Gas Safety Certified AS 2658 2008 Cert GSCS20193 SAI Global PRIMUS CUSTOMER SERVICE 1300 555 197 PT ei enquiries primusaustralia com au Bundoora Victoria 3083 www primusaustralia com au
9. ly dispersed by wind and natural convection Any enclosure in which the appliance is used shall comply with one of the following A An enclosure with walls on all sides but with no overhead cover B Within a partial enclosure that includes an overhead cover and no more than two walls C Within a partial enclosure that includes an overhead cover and more than two walls the following shall apply 1 At least 25 of the total wall area is completely open 2 30 or more in total of the remaining wall side back and front wall areas is open and unrestricted 3 In the case of balconies 20 or more of the total wall area shall remain open and unrestricted Lighting and Operating Instructions Step 1 WARNING Always inspect propane cylinder and heater propane connections for damage dirt and debris before attaching propane cylinder Do not use if head of cylinder is damaged punctured or deteriorated e Use only LP Gas cylinders marked in accordance with the U S Dept of Transportation DOT e Use only 468g disposable cylinders that mate with No 600 valve connection Push knob to ignite pilot e Heater and attached cylinder must be in an After lit hold for 30 sec A are A Release and turn to upright position during operation desired setting e Make sure four position Control Knob is in OFF position Step 2 e Swivel regulator outward
10. n an above ground open air situation with natural ventilation without stagnant areas where gas leakage and products of combustion are rapidly dispersed by wind and natural convection CARBON MONOXIDE HAZARD THIS APPLIANCE CAN PRODUCE CARBON MONOXIDE WHICH HAS NO ODOUR USING IT INAN ENCLOSED SPACE FOR EXAMPLE CARAVAN TENT CAR MOBILE HOME MAY CAUSE DEATH THIS APPLIANCE IS ONLY TO BE USED ON SOLID AND STABLE HORIZONTAL SURFACES Safety after installation Caution The purpose of this section is to direct your attention to the possibility of accidents that can be avoided e This appliance is not to be used in enclosed areas and must be operated away from any type of flammable material or liquid e This appliance must be operated a minimum of 100mm from all solid or non combustible surfaces e During the operation of this appliance all air openings and vents must be kept free from obstructions to ensure correct operation e Remember the appliance produces heat therefore some parts will get hot Allow to cool before touching e Do not leave children unattended near the appliance when in use e Do not store or use petrol or other flammable liquids in the vicinity of this or any other appliance e Do not modify this appliance e Do not use adaptors e Do not allow clothing to pass over or lay on the appliance e Protect the appliance from wind and drafts when in use e Do not operate applianc
Download Pdf Manuals
Related Search