FUM - 1205CBP 3 stage switching mode battery charger
Contents
1. Fullat FUM 1205CBP 3 stage switching mode battery charger User s manual Introduction This compact portable battery charger gives a fast and complete charge to sealed and wet types of lead acid battery within the capacity range of 25Ah to 50Ah Bulk Absorption Float Charge The bulk stage charges the battery at a full constant current SA until the battery voltage reaches a slightly higher level then followed by the absorption stage at which the battery is kept at this high voltage while charging current decreases to a low value When the battery is fully charged it is then switched to the float voltage where it can be maintained indefinitely Safety precautions ae Be aS 11 12 13 14 0 Check the rating label of battery charger for correct AC mains 180 260V 50Hz It is only for charging of 12V lead acid battery with capacity within 25Ah to 50Ah Do not charge the battery with any load connected to the battery Do not plug in the charger before connection to the battery Make sure the all the connections between the charger output and the battery are secured before plug in to AC mains Do not move cables during charging as loosen cable connections will cause spark Double check for correct polarity connection between charger and battery before plug in to the AC mains socket Always unplug the charger before disconnecting the battery Do not smoke strike a match place metal tools on battery or cause2. a spark in the vicinity of the battery When removing battery cables remove ground cable first Lead acid battery contains highly corrosive sulphuric acid Avoid contact with eyes skin and clothing while working with battery Working in vicinity of a lead acid battery is dangerous Batteries generate EXPLOSIVE gases during normal operation Do not expose charger to rain snow and wet conditions Use charger only for lead acid batteries Do not attempt to repair the battery charger Incorrect re assembly may result in a risk of electric shock or fire Control and indicators Ca STATUS BATTERY TYPE Red Charging Green Full SEALED WET Output terminals for connection to battery Battery type switch for selection charged battery sealed or wet type Charging status LED When charger is connected to a battery Green means battery full or float When charger is connected to a battery Red means charging in progress When charger is not connected to a battery Green means charger is powered on User s manual 1 FUM 1205CBP Instalation procedures Use switch 2 to select the correct type of battery for charging Turn on the charger and take note of the green LED 3 MOE oS e Specifications AC input voltage 180 260V 50Hz AC input current at full load at 230V AC Output charge voltage selections 2 battery type Sealed battery Absorption 13 8 14 1V Float 13 2 13 5V Wet battery Absorpti
3. 7673 2105 0000 Rev 1 1 12 2006 TR 1205CBP Rev 1 0 02 2008 FUM 1205CBP
4. on 14 1 14 4V Float 13 4 13 7V Maximum output charging current continuous Line regulation 180V to 260V for charging current Ripple and noise peak to peak Efficiency at maximum power Protection Short circuit protected Overload protection automatic reset Reverse polarity protection automatic reset Over temperature protection automatic reset OVP Output Over Voltage Protected automatic reset Battery under voltage protection automatic reset when battery voltage lt 7 5V charger will stop charging battery CE approval and standards Charge indication 1 led Anodised aluminum casing Size in mm Width x Height x Depth Weight in gm Included accessories cable mounting clips Recommended battery capacity range Remark 11OVAC 60Hz input on request Unplug the AC mains to the charger before disconnecting battery Fullat Connect the positive charger terminal to the positive battery terminal Connect the negative charger terminal to the negative battery terminal Double check for correct polarity and all the connecting joints are secured FUM 1205CBP Yes 0 8A Yes Yes 5A lt 0 6 120mV 84 Yes Yes Yes Yes Yes Yes EN60335 EN55014 Red charging Green charged or float Yes 142 x 75 x 32 380g Yes 25 50 Ah All values are based on the standard ambient temperature 25 C and pressure 0 1Mpa SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT PRIOR NOTICE User s manual D OR
Download Pdf Manuals
Related Search