ODK U500 Electric Bicycle
Contents
1. not ride up very steep inclines Do not ride off roads or jump the electric bicycle Always use kickstand or center stand when not on the bicycle Do not ride down very steep hills Do not exceed the carrying capacity Do not ride on the sand Do not race or taunt other cyclist The motor can get hot do not touch the body of the motor for at least 2 hours after riding 18 ODK U500 Electric Bicycle User Manual Battery Safety Information Use only the charger supplied with bicycle Improper usage can cause explosion or fire Do not short circuit terminals Do not use if temperature is over 60 C 140 F Do not disassemble the battery pack Do not submerge the battery in liquid Do not set flame to the battery Do not expose battery to cold temperatures for a extended period of time Keep battery out of reach of children 19 ODK U500 Electric Bicycle User Manual Technical Specifications Type Power System Total Weight Drama Wheels and Tires Fork Fork and Steering Loading Capacity Worrantee ODK Utility Un ty Bicycle Gray White ee NOW Mahang AM Hanap paren fad reenter Pathar MOV NAAN La Ae Wap abad PAKA Comas JIA Twn frote coroed Choya Sees SOD NOD SA Tape Any Cate Vinta CNN tar Range win padang 46 50 mi 05 80 are maan made Manga shat padang N4 ve AN trey cree renter kikay ty kap ated NG eh OY a 605 31 5 tg Aare COS Liity frama tegrat2. Juiced RIDER Sn ODK U500 Electric Bicycle Owner s Manual f U 500 Juiced Riders Inc 8724 Approach Road San Diego CA 92154 U S A mail juicedriders com Tel 1 619 746 8877 JuicedRiders com ODK U500 Electric Bicycle User Manual How to use your electric bicycle The U500 works a lot like a normal bicycle The main difference is the inclusion of a battery and motor system A twist throttle controls how much assistance the motor provides You can pedal along with the motor to increase the battery s range Preparing for your first ride Be sure the battery is fully charged Plug the charger into an 110V electrical outlet and insert the round connector into the charge terminal on the battery pack The battery may need up to 6 8 hours to charge if it is fully depleted The charge is complete when the green LED is illuminated and the fan stops Notice Always unplug the charger from the AC power source when not in use ODK U500 Electric Bicycle User Manual The battery should be locked to the bike and the key removed before riding Notice Put the keys in a safe place as it will be very difficult to get a replacement Starting your electric bicycle Push the red ON OFF button once The system will power up and is ready to ride after about 3 seconds Power ON OFF Battery Charge Level Max Speed Limiter Get on the bicycle and pedal to get moving Slowly twist the throttle towar
3. battery does not began charging the fan does not start the charger will need to be reset Unplug the charger from the 110V outlet wait 10 seconds and try again The more you have discharged the battery the longer it will take to recharge The charger will shut off automatically when the battery is full About the Lithium battery Your Lithium battery does not have a memory effect associated with older battery technologies It is highly recommended to charge your battery after every ride even if the battery is only lightly used The battery can not be overcharged when using the supplied charger Charging a partially flat battery is not considered a full cycle 10 ODK U500 Electric Bicycle User Manual How to remove the battery pack The battery pack is the most expensive and sensitive component of the electric bicycle Take care when handling the battery pack Turn key counter clockwise to unlock a To remove the battery from the bicycle insert the key and turn it counter clockwise This will unlock the battery Use both hands when removing the battery _ ODK U500 Electric Bicycle User Manual Using the handle at the rear of the battery pack carefully pull and slide the battery out completely Handle the battery pack securely with both hands Do not snatch the battery by the handle If the battery does not come out it may be locked Notice Always handle battery with both hand
4. ds you and the electric motor will propel you forward Twist throttle to accelerate EN ODK U500 Electric Bicycle User Manual Speed settings The farther you twist the throttle backwards the faster bike will travel You can select between Low Medium and High speed settings by pressing the MODE button The approximate top speeds under the three settings are shown below LOW 10 mi h 16 km h MED 14 mi h 23 km h HIGH 18 mi h 30 km h Applying the brakes There are two brake levers The right lever controls the front disk brake The left lever controls the rear disk brake ODK U500 Electric Bicycle User Manual Controlling the bike under breaking When you squeeze the lever the brake pad will make contact the disk rotor and reduce the speed of the bike The front brake has more stopping power than the rear brake However the rear brake will give you more control under braking Apply the rear brake first before applying the front brake for maximum control Notice The brake rotor will become extremely hot for brief periods after slowing the bicycle down do not touch the brake rotor after braking When you apply the brakes the power to the motor will automatically cut out the motor will freewheel until the brake is released and the throttle is activated Notice This system is required at point of sale by law The brake cutout system can be deactivated by the user and will not void the warran
5. ed rack ang feo Cre Glen Oro cor patbie From Tasa hovets N0DAM Roty Ree Tayo NO Man Pond Pedal Oniy 429 Ba 105 ngi kapara Teatro 1200 Aonais wais tot wc re aa Wide a oten Vielen tO lhad Pahina 1 A wen Paka Tamad aro 127 Maga Gee Ivan SOT Poort rr rg 20 Dodis sal IA NAG 1 See TU aT TY Kana TIAN oa we hme maan gt st oom ere ebd puba pr pa De ae Ce ee ne Eu NA Pen a ee feed poh eet pami Pewee ere Dur cord ete Cart kw osve Carter Had auld ao aard Prot are rear LED kti Ned t ka Taapanaor tort Aue suite ator Neamt tanda ba abaw Panaad TITA NYO bagi mar o kara ag corpemerts Teer on Eu 20 ODK U500 Electric Bicycle User Manual Warranty information Juiced Riders Inc provides a Limited Warranty for one year covering the frame components and electronics including the battery A battery pack that has been damaged disassembled submerged in liquid used to power another device or short circuited will void the battery Warranty A bicycle modified to increase speed over volted used off road submerged in liquid incinerated heavily crashed or jumped will void the bicycle warranty The manufacturer reserves the right to refuse any warranty claim in an event of damage or misuse The manufacturer is not responsible for property and bodily damage associated with using this product Contact information for warranty claims Juiced Riders Inc 8724 Appr
6. g the motor cable Turn the bicycle upside down and lay it flat on the ground Use a 18 mm wrench to loosen both nuts on the axle Cut the zip ties retaining the motor cable to the frame Carefully remove the wheel and mount the wheel s drive side to the non drive side dropout This will create a work stand for replacing the tire or tube Change the tire or tube Replace the wheel into the normal position Use a wrench to tighten both bolts as tight as possible Use zip ties to secure the motor cable Important Notice The nut retaining the axle must be very secure If the nut is loose the axle can spin inside of the dropout under acceleration This will damage the motor wires and the dropout 17 ODK U500 Electric Bicycle User Manual Important Safety Information Basic Bicycle Safety Always wear a helmet Use a light and wear reflective clothing when riding at night Reduce speed when riding on a wet surface Properly inflate tires Apply rear brake before using front brake in low traction conditions Do not follow other vehicles too closely Brake disk rotors can get extremely hot for brief periods after braking Electric bicycle safety For maximum stability avoid accelerating or braking while turning Avoid riding in extremely wet conditions Discontinue use of the electric bicycle if the battery pack is damaged due to a crash or drop Do not use the charger outdoors in wet conditions Do
7. n wet conditions Adjust brake cable tension and brake pad clearance Check spoke tension every 100 miles especially on the rear wheel as it handles the most load Tighten any loose spokes to prevent breakage Check tire pressure Properly inflate the tires within the limits of the tire pressure rating 15 ODK U500 Electric Bicycle User Manual Every 500 miles Check for tire wear replace the tire if the tread appears to be worn The rear tire will wear 3x faster than the front tire as the motor powers the rear wheel Check break pads for wear Replace brake pads if they appear worn Every 1500 miles Have the bicycle cleaned and adjusted by qualified bicycle mechanic Battery care Charge the battery after every use even if only used briefly Partial charges are not considered full charge cycles Charge the battery at least every 2 months Storing the battery for long periods of time will reduce the storage capacity and or damage the battery completely Do not leave the battery outside exposed to weather elements Charge the battery in a sheltered environment Do not store battery inside a car under direct sunlight Discontinue the use of the battery if it is damaged for any reason When the battery has reached its lifespan completely discharge the pack and take to a battery recycler 16 ODK U500 Electric Bicycle User Manual Changing the Rear tire The tire can be changed without disconnectin
8. oach Road San Diego CA 92154 U S A mail juicedriders com Tel 1 619 746 8877 http www juicedriders com 21
9. s Do not carry the battery pack by the handle e Only use the handle to slide the battery away from the bicycle Do not pull on the battery if it is locked to the bicycle To replace the battery pack be sure the lock is in the OPEN position Align the battery on the tracks of the slider Slide it forward completely Turn the key clockwise to lock the battery to the bike If the key can not turn push the battery more securely froward and try again Notice If the battery can not connect with the bicycle the lock may be in the CLOSED position before the battery is in place Do not push the battery forward forcefully 12 ODK U500 Electric Bicycle User Manual Understanding your electric vehicle s range All electric bicycles have a riding range that can vary greatly depending on how it is ridden terrain payload and wind After a few rides you will get a sense of the vehicles range Factors that will decrease your range Rapid accelerations using the motor e Uphill riding Heavy payloads e Headwinds Under inflated tires Extreme hot or cold weather How to increase your range Pedal to start instead of only using the motor e Pedaling to help the motor up steep hills Reduce speed and pedal along with the motor e Reduce payload weight e Properly inflating your tires Coast to avoid sudden stops unless necessary Notice Riding downhill or pedaling when not using the throttle
10. ser Manual Notice The battery s charge state can not be read accurately when using the throttle to propel the bicycle Depleting the battery s charge Eventually the battery will become depleted when riding The power and speed will feel reduced It is not healthy for the battery to reach a completely flat state The battery will automatically shut down to protect the cells if it gets too depleted Notice If the battery reaches the shutdown state the battery must be removed from the bike to reset the battery management system before charging This will require using the key Tip Use a bicycle speedometer to measure your trip distance and plan your trips accordingly Turning off your electric bicycle To turn off the electric bicycle push red ON OFF button again The e bike will also automatically power down if not used for 5 minutes Recharging the battery pack Charge the battery after every ride to maintain the health of your battery The battery can be charged even when installed on the bicycle The battery can also be removed from the bike and charged at another location Notice Do not activate the motor when the battery is charging ODK U500 Electric Bicycle User Manual Plug the charger into an 110V electrical outlet and insert the round connector into the charge terminal on the battery pack The battery may need up to 6 8 hours to charge if it is fully depleted Important Notice lf the
11. ty ODK U500 Electric Bicycle User Manual Shifting the gears You can select a comfortable gear to pedal in using the left twist gear shifter Twisting the shifter backward will select an higher gear for moving at faster speeds Twisting the shifter forwards will select a lower gear used for climbing hills and starts Handle Bar Left Side Gears can not be changed when the bicycle is stationary Reduce pedaling pressure while shifting for smoother gear changes Notice The motor has a freewheeling clutch which must be broken in to operate optimally It will take more than 100 miles 160 km before a new rear motor can spin completely freely when pedaling ODK U500 Electric Bicycle User Manual How to read the battery level There are 4 LED lights on the display panel which will give you an indication of the battery s voltage The voltage will decrease temporarily when using the throttle This is normal operation To read the battery s charge state let off the throttle The display will illuminate to give an indication of the battery level 4 LED Battery Charge Level LED Status Guide eeee ALights The battery is between 80 and 100 charged eee 3 Lights The battery is in AA 40 and 80 charged Speed will feel reduced ee 2 Lights The battery level is low and should be recharged soon 1 Light Stop using the throttle recharge the battery pack ODK U500 Electric Bicycle U
12. will not recharge the battery pack Do not over inflate the tires 13 ODK U500 Electric Bicycle User Manual How to remove the fuse The battery has a fuse to protect against overload To replace the fuse first remove the battery pack Locate the fuse holder at the front of battery enclosure Use a screwdriver and carefully remove the fuse cap Remove the fuse and replace it with a new 40A fuse Replace the fuse cap and use a screwdriver to tighten securely Battery light switch The battery has a switch under the rear cover This switch is used to power down the light circuit when storing the battery Put the switch in the OFF position O if the battery will not be used for long periods of time 14 ODK U500 Electric Bicycle User Manual Taking care of your electric bicycle Electric bicycles will travel many more miles than normal bicycles The weight is heavier and average speed is much faster than what you may be used to As a result components will wear faster Bicycle setup The bicycle should be lubricated and tuned up before using it the first time If you purchased the bike from the dealer they will have performed the basic setup Every 100 Miles Have the bicycle serviced after the first 100 miles as the parts have had a chance to run in and may loosen Lubricate the chain and transmission to reduce the wear on the chain and freewheel The chain needs to be lubricated after every ride i
Download Pdf Manuals
Related Search