Portable Generator Small Generator
Contents
1. Consumption 0 7 Liter 6 DIMENSIONS amp WEIGHT Dimensions mm L 368 W 264 H 385 Weight kg 22 0 7 NOMENCLATURE 1 Input power cable Optional 2 Start Switch 3 Output Terminal 4 Power Lamp 5 Generator GU 1000K 6 Choke Lever 7 Starting Rope Ground Rod Portable Generator Small Generator 8 DESCRIPTION amp USE OF PARTS FRONT Figure 8 1 Front of Generator LABELS ARE WRITTEN IN KOREAN ON THE GENERATOR TRANSLATION IS IN RED HERE BELOW FUNCTION a Green light is on in operation mode WF UAE A Protects against power surge circuit overload AC Surge Protector To restore press on the button generator and change oil every 250 hours 4 WRES GAH Connect the cable AC oupa temimi On A SUA RAE Protects against power surge circuit overload ARSA AA Connect the generator to charge the battery IISA Up position ON fuel is supplied to engine Start Switch Down position STOP fuel is blocked BACK Figure 8 2 Generator Back Fine adjustment of the flow rate for the control of Flow Control Valve combustion efficiency Use a screwdriver to place it in the best conditions Zo ala To operate and regulate the amount of air Choke Lever temperature during operation START position pull lever up eS Adjusting the voltage of the rotational speed of the Speed Control engine To adjust the frequency use the screwdriver to turn right to increase amp lef2. _ Portable Generator INDUSTRIAL amp DOMESTIC SMALL GENERATOR USER S GUIDE Translated from the Korean User s Manual February 2014 l Portable Generator Small Generator February 2014 TABLE OF CONTENTS ACKNOWLEDGMENT IMPORTANT INFO INSTALLATION SITE GENERATOR S GENERAL CHARACTERISTICS GENERATOR S ELECTRICAL CHARACTERISTICS DIMENSIONS amp WEIGHT NOMENCLATURE DESCRIPTION amp USE OF GENERATOR PARTS TROUBLESHOOTER OPERATION SEQUENCE OF GENERATOR Se tee eS SS j gt 1 ACKNOWLEDGEMENT The generators were manufactured based on South Korean rigorous standards to meet international quality and design Strict quality tests have also been made on temperature shock vibration amp noise This user manual should always be kept next to the generator 2 IMPORTANT INFO The generator rated output is 220V AC or 28V DC voltage and has to be used as designed Therefore depending on the output selected connect the plug to the generator in the correct terminal Further the generator is fueled by petrol Industrial bioethanol E5 E100 can also be used purity 99 when available Portable Generator 3 INSTALLATION SITE gt The generator must be used in a well ventilated and dry place gt When used outdoors the generator should not be placed under direct sunlight It can only be used when effectively protected from it gt It should be placed far from flammable materials or fire st
3. heck the air filter and replace with new one if dirty 1 Check the silencer check for debris or dirt and replace if necessary 10 OPERATION SEQUENCE OF THE GENERATOR STARTING SEQUENCE 1 When all operation switches are at stop off position 2 Pull the generator choke lever 6 up to the on position 3 Turn the start switch 2 up from STOP position to the on position 4 Pull the starting rope 7 to start If this does not help to start up the generator try again 2 3 times at 5 10 seconds interval after checking again that the choke lever 6 is in ON position 5 When the choke lever 6 start to driving position three minutes left and no load operation fuel oil leaks excessive vibration and grinding noise etc and check it STOP OPERATION 1 Do not restart the generator for 3 minutes after the start switch was put in the off position 2 Do not use the generator until it has cooled completely Place it in a well ventilated place
4. ove or heater The floor should be flat Yy gt Itshould be placed at least 50 cm or more from the wall NOTE gt The generator s engine is air cooled through a cooling system Therefore the cooling fan should always be checked as in case of failure the engine can get damaged gt The engine oil s level should be checked at all times It is recommended to replace it every 250 hours gt You should avoid making work the generator for a long time avoid direct sunlight Use it at ambient temperatures below 30 C and in well ventilated areas 4 GENERATOR S GENERAL CHARACTERISTICS gt Lightweight portable generator convenient and efficient gt Astroke air cooled petrol engine long life with easy maintenance 5 GENERATOR S ELECTRICAL CHARACTERISTICS Rated output 1 000 W Maximum output 1 200 W Rated voltage AC 220 V 10 Operating Temperature 32 C 50 C Noise 65 dB 7m distance Engine 4 stroke air cooled petrol engine Cooling Air cooled by 220 V fan Phase Single Fuel Tank Capacity 3 2 Liter Direct Current 28 V battery charging Small Generator Hours of Continuous Operation 4 Hours Engine TM 120 1 Number of cylinders 1 2 Cylinder diameter 53 mm 3 Cylinder stroke 42 mm 4 Exhaust amount 92 cc 5 Lubricated Oil Capacity 0 35 Liter 6 Lubrication System Forced Lubrication System 7 Fuel Bio Ethanol or petrol unleaded 8 Fuel
5. t to decrease TOP SIDE Figure 8 3 Top Side of Generator No Regulators amp FUNCTION Indicators SEHI Fuel Level Indicator L to H a 1 2 HEFT Open the lid for injecting fuel Fuel Injection LEFT amp RIGHT SIDES Figure 8 4 Right amp Left Side of the Generator No Regulators amp FUNCTION Indicators 1 25 Exhaust gas is discharged to decrease the noise 2 dO To purify the air entering the engine eerie O Oee 3 A Engine starter gt Starter lance Portable Generator 09 TROUBLESHOOTER PROBLEM POSSIBLE CAUSE CORRECTIVE ACTIONS Generator does 1 Fuel Malfunction not start Starts and then stops does not continue to work Engine stopped suddenly Engine output decreases Bad starter Spark Plug Tank filter is bad Air filter failure Bad spark plug Lack of fuel Lack of engine oil Air filter failure Defective silencer Small Generator 1 Check that the start switch is in ON position 2 Check that the choke lever is in ON position 3 Check that there is enough fuel 1 Check the engine oil and refill if low level 1 To check if good condition 1 Check the filter and if bad change it 1 Open the cover check the air filter and replace with new one if dirty 1 Replace if does not work 1 Check the level and replenish with fuel 1 Check the gauge if level low fill up to level and restart engine Open the cover c
Download Pdf Manuals
Related Search