ActivOTM User Manual for Europe - Dri
Contents
1. Check power cord connections Check fuse picture below If fuse is blown replace it If it blows a second time STOP and call Ecozone for assistance mr Doo Doorn mJ ror i Display prompts Ready but keypad does not function Q Disconnect and reconnect power cord O Wait for Ready prompt Press STOP button red on keypad O Press hard RESET button yellow on keypad Red light fault indication is ON and the display indicates one of the following fault codes a AL Presso Stat b AL Micro Switch Make note of fault code indicated on the display O Disconnect power cord CALL ECOZONE service Display shows Needs Service This notification will appear every 500 hours of use Upon notification please refer to Section 6 above page 15 Other Call local ECOZONE distributor for technical support 19 7 Warranty WARRANTY ECOZONE warrants to the original retail purchaser or licensee of the ActivO Purchaser that the ActivO will conform to and perform in accordance with the published technical specifications and any accompanying written materials supplied by ECOZONE and will be free from defects in materials and workmanship under normal use and conditions for the applicable warranty period indicated below This warranty does not extend to ActivO s that have been subject to misuse accident exposure to corrosive substances tampering or use2. Continued Next Page Note the tubes used in the ActivO are unlike tubes used in competitive ozone machines which are often fragile and easily broken The ActivO tubes are specially designed for use in rugged DR disaster recovery environments 17 g Re mount each Singlet on its leading screws slide in parallel Be sure to re insert Singlets so that the 3 tubes are on the side facing you h Re attach the electrical connector to each Singlet purple circles below Be sure the connectors are dry i Re screw on the two nuts to each Singlet Aluminum Stand 16 Ekctrical Connector to Singlet Connecting Screws for Filtering unit Ozone Filtering Unit 17 Step 3 Close black front grill panel 26 picture above page 16 a Replace the front grill making sure the dust filter is on the inside of the unit Make sure the earth cable to the grill is completely inside the unit b Re screw the 6 screws around the frame of the panel Step 4 Replacing Ozone Filtering Unit 17 a Open all screws at 3 locations connecting the used Ozone Filtering Unit 17 b Remove the used Ozone Filtering Unit and replace it by the new Unit c Screw and tight all screws at exactly all 3 locations to re connect the new Ozone Filtering Unit inside the machine d You may through the used Unit to the garbage 18 6 Troubleshooting Problem Possible Solution Display is blank and keypad does not function
3. flashing Important The system will begin generation of ozone after a 60 second delay in order to allow you to leave the room Q You must leave the room immediately Windows and doors should be closed to prevent ozone leakage Remaining in the treated area while unit is in operation or entering before completion of cycle may be hazardous to your health e Outside the room you will hear a prolonged audio alert signal indicating that ozone generation has begun e After the full operation cycle is completed including removal of the ozone you will hear a second audio alert signal indicating that operation is completed Upon entering the treated room the display should read Operation Complete and the amber light should have stopped flashing CAUTION In the event indications do not correspond to the above leave the room immediately and call for ECOZONE service D After the operation has ended and before moving the machine elsewhere be sure to disconnect the power cord from the power socket ATTENTION If at any time you need to reset the keyboard settings press STOP button red O on keypad 13 Activation Deactivation and Total Operating Times I Total Cycle Time T Short Inter Long r a ha Room Volume Small lt 30m 11 15 25 18 45 118 60 180 Medium 60m 6 22 30 34 24 60 268 90 360 Large lt 1 20m 20 38 60 126 52 180 1318 120
4. 1440 X Large 120m 120 300 598 120 720 2698 180 2880 Keyboard Controlled Maximum Change From Default Time Short Inter Long Room Volume Small 30m 11 30 70 18 90 28 60 90 Medium 60m 22 45 154 24 180 88 90 180 Large 120m 38 90 666 52 720 598 120 720 X Large 120m 120 360 1318 120 1440 1258 180 1440 14 5 Maintenance and Service Maintenance of your ActivO is required every 500 hours in order to insure trouble free performance The ActivO keyboard will display a message indicating that 500 hours of operation have been reached by displaying Needs Service The ActivO is equipped with a special Ozone Filtering Unit This Unit assures that upon completing the odour treatment cycle there will be no residual ozone left inside the room The efficiency of this Unit will degrade in time and therefor it is mandatory to replace it after every 1 000 hours of operation If you have a good pair of hands and follow these instructions carefully this 3 step procedure should take you about 1 hour CAUTION DISCONNECT POWER FROM THE ACTIVO BEFORE BEGINNING PROCEDURE BEGINS NEXT PAGE 15 Step 1 Clean Dust Filter 225 in picture at bottom of this page a Remove black front grill panel 26 by unscrewing 6 screws What you will then see is shown in the picture at the bottom of this page b Loosen 6 screws i
5. ActivO User Manual for Europe 2008 Activated by ECO T User Manual Table of contents AAN 26 oeco eaa ure o EE a na EV tu PM EPI VV TEn 2 General NA 3 Declaration of Conforiity een esc ere e reap rab a a yr FE eer PUPA 4 Safety Precautions amp Warnings cccccscsccssccsssccsscccsccscccccscosecsccns 4 The ActivO control panel and other indicators sees 5 Technical Specifications sexes sese ee Ye ya ea eySE EX VES EAE EE SY WEE eS E ee YE VP UE 6 OP Me 8 Controller setimgs i seres ep ee ose ees pen oppo pa a PoEeu EPOR CE E EOS aT Fa PEpeiUEP 8 Activation Deactivation and Total Operating Time 13 Maintenance and Service 4 eese eese enean boe pa ape sa E aoa R aea E Pee a oobhe 14 TroubleshoDUHig lesen oisi eux wok RYE UKROE E EC EEUEF VR UNNIREREN FE DINSEESA V RU TEE 15 by rich M PH n vss 16 UNPACKING Oo Open top flaps of carton Gently place carton on its side Lift unit up slightly and then pull out by rolling on its wheels eo Place handle on top panel and fasten 3 hex screws on each side Handle Front Grill Panel 1 General Information Ecozone s ActivO is a mobile and easy to use deodorizing system for indoor use This robust computer controlled and automatic system is characterized by high safety standards The system incorporates ECOZONE s unique ADA system a double stage operating
6. U THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE Contact information Ecozone Technologies Ltd Hasharon Industrial Park P O B 5014 info ecozone technologies com Kadima 60920 www ecozone technologies com Israel Phone 972 98 91 24 41 Fax 972 98 91 24 45 21
7. VENTILATE ROOM AFTER USE Connect power cord to socket on ActivO s rear panel bottom and only then connect it to the power source socket 6 1 Controller settings Press the STOP Red button to Reset o STOP RESET The display will present a code followed by the alternating prompt Ready and Set Room Size eo Select Room Size by pressing the respective keypad button Note You may choose between the following 4 room sizes Bn Small for room volumes below 30m e Medium for room volumes between 30m and 60m LH Large for room volumes between 60m and 120m X Large for room volumes from 120m to 500m The display will now prompt Set Time e Select the Short Intermediate Long time cycle by pressing the respective button on keypad Note Select length of cycle to correspond with the odour level in the room 3 Short Cycle Time Light odor 33 E Intermediate Cycle Time Average odor 333 Long Cycle Time Strong odour 4 Refine Time setting optional by pressing the Up or Down blue arrow buttons to extend or to shorten the operation cycle time respectively Please refer to reference chart on page 13 lA Up to extend cycle time v Down to shorten cycle time Note Time is indicated on LCD in hours and minutes h hours and m minutes For example 3 hours and 20 minutes would be indicated so 3h20m 10 Press green 1 button for START CAUTION B
8. ation amp Deactivation Cycles Cycle time Minimum 15 minutes Maximum 48 hours With special input code 72 hours ozone generation only Control Digital keyboard Display LCD 16 Digits Safety Circuit breaker overload switch 4A Amber Flashing Light Indicator ActivO in operation Red Fault Indicator Buzzer Alarm operation has begun operation has ended Differential Pressure Regulator air flow obstructed Door Interlock front panel not closed Dimensions 50 x 40 x 100 cm with handle attached 53 x 65 x 94 cm packed for shipping handle detached Ozone outlet duct 4 diameter Weight 37 kg packed for shipment 40 kg Enclosure Metal and ABS Wheels leave no tracks Low EM Noise Certification CE amp FCC 5 3 Normal Environmental Conditions Indoor use only Temperature 0 C to 35 C Humidity maximum relative humidity 95 ECOZONE Technologies has a policy of continuous product improvement and reserves the right to modify or change this specification at any time without notice 4 Operation Preparation and Connections A CAUTION OZONE IS A POWERFUL OXIDIZER USE THIS EQUIPMENT WITH CARE AND IN UNINHABITED AREAS ONLY READ ALL OPERATING INSTRUCTIONS BEFORE USING THIS MACHINE RE OCCUPY TREATED ROOM ONLY AFTER PRESET OPERATING TIME HAS ELAPSED AND THE AMBER FLASHING LIGHT HAS STOPPED FLASHING INDICATING THAT THE MACHINE IS NO LONGER IN OPERATION DO NOT ATTEMPT TO ENTER THE ROOM WHILE MACHINE IS IN OPERATION
9. cycle that creates ozone and subsequently removes it allowing the immediate reoccupation of treated spaces In the first stage the room is enriched with ozone generated from the air using Ecozone s multi patented technology at a particularly high rate in order to reach homogeneous conditions and a high concentration level within the shortest possible time In the second stage any after treatment residual ozone is decomposed into oxygen so as to leave the treated room well within the regulated levels 2 Declaration of Conformity Model No POCS 500 POCS Portable Odour Control System This unit fully complies with CE amp FCC rules of EMC regulations EN 61000 61 EN 61000 62 EN 61010 1 EN 5501 EMC FCC Part 15 Safety of Low Voltage Directive 73 23 EEC as Amended EN 61010 1 Federal Communications Commission Safety Precautions amp Warnings Read this manual carefully before operating the unit Do not expose this equipment to rain or moisture Should any liquid come into contact with the system unplug it and have it serviced by qualified personnel before operating it further Unplug the system power plug when it is not in use When unplugging never pull the plug by the cord itself DO NOT enter the treated room during the operation of the system or before hearing the completion of cycle audio alert signal This system is equipped with a ventilation inlet and a ventilation outlet DO NOT BLOCK inlet ou
10. efore starting operation verify that the treated area has been vacated of people animals plants and items containing natural rubber EXAMPLES OF USE OF ITEMS CONTAINING NATURAL RUBBER Items made of natural rubber gum are many and differ in their rubber content the more rubber content the greater their susceptibility to degradation by ozone Among the common items that may contain natural rubber are computer keyboards rubber under the keys floor squeegees tubes for bicycles crepe soles for shoes rubber bands various gloves Latex smoked sheets underlay and more The common sense rule when in doubt about whether the item contains natural rubber remove the item before treating the space Or alternatively smear the item s surface with Vaseline or equivalent before exposing it to ozone N gt FOR SHOE SOLES 11 a START Operation Place unit in CENTER of room When treating smaller rooms you do not need to use air movers in order to circulate ozone since your ActivO sends ozone at a high rate of 265 CFM to the ceiling where it spreads out and drifts downward to cover all surfaces Note If treating a crawl space attach 4 diameter ducting to ActivO Outlet page 5 When using ActivO in this manner there will be no ozone deactivation However ozone in the crawl space will deactivate naturally typically in 3 6 hours The display will prompt you to Get Out of Room and the amber Hazard light will begin
11. in a manner not approved by ECOZONE in writing The Ozone Filtering Unit shown in the picture on page 18 as 17 is a consumable and is expressly excluded from this warranty Warranty period is 1 year commencing on the date of purchase Under this warranty Purchaser must first return the ActivO to ECOZONE together with proof of purchase from an authorized dealer of ECOZONE a Dealer either directly or through the Dealer from whom Purchaser purchased the ActivO for examination by ECOZONE of entitlement under the terms of this warranty All shipping handling travel service call and or other incidental and or related charges are fully payable by Purchaser only and are not included in this warranty THIS WARRANTY IS IN LIEU OF ANY OTHER WARRANTIES EITHER EXPRESS OR IMPLIED INCLUDING BUT NOT LIMITED TO ANY WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE ALL OF WHICH ARE EXPRESSLY EXCLUDED AND DISCLAIMED ECOZONE WILL NOT BE LIABLE FOR LOSS OF PROFITS ANY SPECIAL INCIDENTAL OR CONSEQUENTIAL DAMAGES WHICH PURCHASER MAY SUSTAIN OR PUNITIVE DAMAGES EVEN IN THE EVENT OF NOTICE OF THE POSSIBILITY OF SUCH DAMAGES IN NO EVENT SHALL LIABILITY UNDER THIS WARRANTY EXCEED THE PURCHASE PRICE OF THE ACTIVO PRODUCT SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN 20 IMPLIED WARRANTY LASTS OR THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YO
12. n frame around dust filter 25 so you can slide filter out Do not remove the earth cable connected to the grill c Gently slide filter up and out of its frame see picture d Place the filter under warm tap water and wash out dust It is ok to use a mild liquid soap if needed to loosen the dust Rinse and dry ok to use hair dryer e Slide Dust Filter back into its frame and retighten loosened screws Grill s ground cable amp Ground connection Front Grill 26 Leading Screws for Singlet Dust Filter 25 Electrical Connector to Singlet Ozone Filtering unit 17 16 Step 2 Clean Ozone Generating Cores Singlets 15 below a There are two 2 Singlets to remove and clean They are shown side by side as 15 in this picture Singlet PentaRod 15 2 Nuts Ee for Singlet Ozone Filtering j ti unit 17 2 of 3 Screws for Filtering unit b Remove the electrical connector from each purple circles picture on next page c Unscrew the 2 nuts holding each Singlet unit white circles above d Gently pull out in parallel each Singlet from its leading screws exposed in white circles in picture below shown after removal of Singlets Handle unit carefully e Clean the units under warm tap water especially the gaps between the tubes You may use a soft brush to remove any accumulated dirt Use care not to wet the electrical connector f Dry the Singlet units with a soft towel
13. tlet or place foreign objects in their vicinity which may block air flow Place unit in the CENTER of the room I w DO NOT disconnect cable cord from mains socket before the operation of the system is completed N AVOID ELECTRICAL SHOCK This unit is supplied with a earthed cable Attempting to bypass the earth or to connect the unit to an un earthed socket is strictly prohibited Under no circumstances should the unit be operated with the front panel grill loose or missing Prior to removing the grill for maintenance always disconnect the unit from power There are no user serviceable parts inside the ActivO removal of back panel by unauthorized personnel will result in voiding the WARRANTY 3 The ActivO control panel and other indicators so ActivO Display n Room Size A ley Cycle 7 Time Refine Time us Stop Reset Flashing In Operation 3 Technical Specifications 5 1 Description The ActivO system is a portable high duty and rugged system It features the most advanced technology in the field of odour control and air treatment The ActivO employs Ecozone s state of the art and patented Singlet Unit which is characterized by relatively high activation rate and enhanced reliability 5 2 Technical Specifications Input Voltage 230V 60Hz Air Flow Rate 450 m h Ozone output 12g h 12 000 mg h Operation Fully Automatic Activ
Download Pdf Manuals
Related Search