Whynter FM-62DZ Use and Care Manual
Contents
1. Whynter com2. the ambient temperature is lower than 41 F Food Storing e Fresh foods should NOT be stored together with frozen foods e When the temperature is set below 32 F do not keep glass bottled drinks such as beer and lemonade or soda cans as the glass and cans might shatter Defrosting and Deodorizing When the ice layer on the inner cabinet sides is over 0 2 the defrosting operation should be performed to improve the refrigerating efficiency To do this follow these steps below 1 Turn off the power and remove all items inside the freezer 2 Allow the ice to completely melt 3 Remove the drain plug and drain all water Once the unit is defrosted and all the water has drained out clean the interior with a soft rag before using the unit Tip To remove unpleasant odors place a piece of charcoal in the chest Never remove ice with a sharp object or screwdriver Page 7 Normal Operating Sounds and Functions It is normal to hear gurgling sounds caused by the flow of refrigerant when each cooling cycle ends The surface temperature of the compressor can reach 158 194 F when running The noise emitted by the cooling fan on the condenser is a normal function It is normal for the fan in the power supply to run all the time e Always disconnect the power supply before cleaning Clean the inside of the cabinet whenever necessary using a solution of warm water and baking soda 1 tablespoon to every 2 liters of w
3. ater Dry with a soft cloth e Do not use steel brushes or harsh detergents to clean the inner liner e Dirt from the condenser should be cleaned by a qualified technician when necessary Page 8 TROUBLESHOOTING The compressor runs for 1 to 5 The voltage is not in the minutes and stops correct range when the power is normal The ambient temperature is too high The operating temperature of this unit is lt 90F If temperature is higher than SOF the unit need longer to cool to the set temperature email at service whynter com evaporator is too thick and closed too frequently as possible The inner liner is very cold and The freezer is overloaded Remove some products from the continuously The condenser is not well ventilated ventilated place The temperature sensor Contact service department via tube is out of the email at service whynter com evaporator or the controller is faulty The controller is faulty the power indicator is not on email at service whynter com The compressor does not run The thermostat is set too Sette teorrioalover high and the ambient Set the freezer to a lower temperature is too low temperature The freezer is noisy The freezer is not level surface Switch off the power and restart correct range when the power is normal Can the unit plugged into both Yes If both AC and DC are plugged AC and DC power supply in at the same time then the unit will primarily operat
4. e on AC If the AC power source fails DC will become primary source of power supply Page 9 The compressor runs but the inner liner does not get very cold ONE YEAR LIMITED WARRANTY This WHYNTER Portable Fridge Freezer is warranted to the original owner within the 48 continental states for one year from the date of purchase against defects in material and workmanship under normal use and service Should your portable fridge freezer prove defective within one year from the date of purchase return the defective part or unit freight prepaid within two months of purchase after two months to one year customer will be responsible for freight cost to Whynter s service department along with an explanation of the claim to Whynter LLC Please package the portable fridge freezer carefully in its original packaging material to avoid damage in transit Please retain the original box and packaging material Under this warranty Whynter will repair or replace any parts found defective This warranty is not transferable After the expiration of the warranty the cost of labor and parts will be the responsibility of the original owner of the unit THIS WARRANTY DOES NOT COVER e Acts of God such as fire flood hurricanes earthquakes and tornadoes e Damage accidental or otherwise to the portable fridge freezer while in the possession of a consumer not caused by a defect in material or workmanship e Damage caused by consumer mi
5. e this appliance to rain or excessive moisture Do not turn the portable freezer upside down on its side or 45 or more off level Never pull the power cord to disconnect the unit from an outlet Grasp the plug directly and pull it from the outlet Never lift or carry the freezer by the power cord Keep the power cord away from heated surfaces This portable freezer is designed for non commercial use only Do not plug this portable freezer into the power socket before setup is completed An empty portable freezer can be dangerous for children or small animals If disposing of the portable freezer remove gaskets latches lids and the entire door from your unused appliance so that children or small animals cannot become trapped inside Do not cut or remove the third prong the grounding prong from the power cord The cord should be secured behind the unit and should not be left exposed or dangling Do not move this portable freezer without securing the lids in a closed and latched position Performance may vary based on operational and ambient conditions Page 3 PARTS AND FEATURES Your Whynter portable freezer is supplied with all the accessories you need to enjoy refrigeration almost anywhere Below is an image of the freezer features and standard accessories Latch Insulated lids Wire baskets Side handle DC power cord AC power cord Drain plug lf you want to protect and provide additional insulation for your Whyn
6. eep the freezer away from direct sunlight heaters and corrosive gases chemicals 3 Clean the interior surface with lukewarm water and a soft cloth 4 When inserting the AC power cord into the power socket make sure the power socket is a grounded 115V AC 60Hz socket Also make sure that the units grounding prong has not being tampered with Note When inserting the DC power cord make sure the input is a 12V DC 24V power source OD When moving the freezer always use both handles to the carry the unit as level as possible This is in order to protect the compressor and the sealed system Page 5 OPERATING YOUR PORTABLE FREEZER DC input power When powering your portable freezer with a standard 12 V socket the unit will not work if socket has a voltage of less than 10 4 V The unit will restart when the voltage is 11 8V or greater When powering your portable freezer into a standard 24 V socket the unit will not work if the socket has a voltage of less than 22 5 V The unit will restart when the voltage is 24 2 V or greater UNDERSTANDING THE TEMPERATURE CONTROL SETTING Your portable freezer uses a digital control system for adjusting the thermostat Q Smali Zone Temp SET Temperature setting Press the set button once to set desired temperature of the Small zone Press the set button twice to set desired temperature of the Large zone Battery cut out voltage setting This function sets the minimu
7. m voltage that the unit will run Press the SET button 3 times to set the Battery cut out voltage To select different cut out voltage 10V 10 7V 11 8V press the buttons Button for increasing the temperature setting Button for decreasing the temperature setting ECO button Press the ECO button to set the unit in ECO mode For use when the unit will not be accessed for an extended period of time The unit maintains the internal temperature up to a 2F degree variation to conserve energy ECO light Indicates when the ECO mode is on RUN light When the RUN light is green it indicates the unit is running Battery display Shows battery condition in DC power supply only When battery level is too low the battery display will flash Page 6 Temperature Adjustment 1 When the freezer is plugged in to a power outlet press the Set button The LED will display the factory pre set temperature of 0 F 2 To adjust the temperature a Press the Set button again b While the LED is flashing press the A or Y buttons to reach the desired temperature c Once the desired temperature is set the LED stops flashing The current internal temperature will then be displayed After the LED has stopped flashing you can check the set temperature by pressing the set button again d To change the preset temperature again repeat steps a b and c Note Do not use the refrigerator freezer as a refrigerator when
8. s including the following Do not use if the power supply cord is damaged If damaged it must be replaced by qualified technician electrician This portable freezer is not intended for use by young children or infirm persons without supervision Young children must be supervised to ensure they do not play with the appliance Ensure the freezer is unplugged before cleaning or if not in use To clean the freezer use only mild detergents or glass cleaning products Never use harsh chemicals or solvents Do not use this portable freezer with an extension cord or power strip Please ensure that the appliance is plugged directly into the electrical outlet When positioning the portable freezer ensure that there is at least a 6 clearance at the sides of the portable freezer This will allow for adequate ventilation of heat from the back of the freezer Close the freezer lid s immediately after putting in any items to maintain the internal temperature of the unit Avoid placing the freezer near external heat sources or direct sunlight Make sure the freezer is placed on a flat level and solid surface Make sure that the surface on which the freezer is placed is strong enough to hold the freezer once it is fully loaded with items The portable freezer is an electrical appliance To avoid serious injury from electrical shock do not operate the freezer with wet hands while standing on a wet surface or while standing in water Do not expos
9. suse tampering or failure to follow the care and special handling provisions in the instructions e Damage to the finish of the case or other appearance parts caused by wear e Damage caused by repairs or alterations to the product by anyone other than authorized by the manufacturer e Freight and Insurance cost for the warranty service DISCLAIMER OF IMPLIED WARRANTIES LIMITATION OF REMEDIES CUSTOMER S SOLE AND EXCLUSIVE REMEDY UNDER THIS LIMITED WARRANTY SHALL BE PRODUCT REPAIR OR REPLACEMENT AS PROVIDED HEREIN CLAIMS BASED ON IMPLIED WARRANTIES INCLUDING WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED TO ONE YEAR OR THE SHORTEST PERIOD ALLOWED BY LAW BUT NOT LESS THAN ONE YEAR WHYNTER SHALL NOT BE LIABLE FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES SUCH AS PROPERTY DAMAGE AND INCIDENTAL EXPENSES RESULTING FROM ANY BREACH OF THIS WRITTEN LIMITED WARRANTY OR ANY IMPLIED WARRANTY SOME STATES AND PROVINCES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSE QUENTIAL DAMAGES OR LIMITATIONS ON THE DURATION OF IMPLIED WARRANTIES SO THESE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU THIS WRITTEN WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE To obtain service or information contact Whynter LLC via email at service whynter com or call 866 WHYNTER Product contents and specifications may change without notice Copyright 2012 Whynter LLC www
10. ter portable freezer the Whynter insulated flexible transit bag is your best solution The transit bag comes custom tailored with openings for your freezer s handle grips air vents and power cords to allow operation with the bag in place The transit bag also comes with a fast open top flap for quick and easy access to the freezer compartment A convenient side pocket also allows you to tote any cords and accessories with the bag ee ee T Please feel free to contact our Sales Team at info whynter com for purchase information Page 4 Proper Location e Position your portable freezer in a location where there is compressor based Because this unit is proper air circulation and electrical connections appliance ample e Keep the portable freezer away from heat and direct space is required sunlight if possible around the unit to e This portable freezer is suitable for vehicle use and allow it to exhaust camping however the appliance should never be exposed to rain e This portable freezer should not be placed in a built in or recessed area It is designed to be freestanding e The normal operation of the freezer depends on heat radiation from the condenser For the initial use remove all packaging and allow at least 6 of clearance around the perimeter of the freezer Movement and Installation Instructions 1 Remove all interior and exterior packaging 2 Position the freezer in a dry and well ventilated place K
11. ve Whynter 62 QT DUAL ZONE PORTABLE FRIDGE FREEZER MODEL FM 62DZ Instruction Manual Congratulations on your new WHYNTER product To ensure proper operation please read this Instruction Manual carefully before using this product Keep this manual in a safe place for future reference TABLE OF CONTENTS SAFETY FEEGALTIONE ae ed ee E ee ee ee 3 PARIS AND FEATURE 5 des ef es ee ie E er Ge ie er ee eg ei ei 4 PROPER LOCATION 00 20 ccc ee ee ee cece EEE ee ee ee ee ee GR ee GR ee ER ee TON ee ee ee ee ee ee 5 MOVEMENT AND INSTALLATION INSTRUGCTIONS esse ee see ees ee ee ee ee ee 5 OPERATING YOUR PORTABLE FREEZER cceceeee eee ee ee ee ee ees 6 8 WEIR RE EE RE RE EE 6 UNDERSTANDING THE TEMPERATURE CONTROL SETTING ees see 6 TEMPERATURE ADJUSTMNET ee ee ese ee se ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee ee if FOO STORAGE si se Ee REDE Ee ae Sen ee DE ee Re ee n Ee De eke T DEFROSTING AND DE ODERIZING ee ee ese ee see ee ee ee cece tees ee ee ee eens ee ee T NORMAL OPERATING SOUNDS AND FUNCTIONG ccc see ee ee eee es 8 CLEANING AND MAINTAINING YOUR PORTABLE FREEZER 8 TROUBLESHOOTING 3 osse os see ee sie ee ee Ba ee Re sko RE Te 9 WARRAN I AE ET RE ER EE N RE N EE N 10 Page 2 SAFETY PRECAUTIONS Read all of the instructions before using this appliance When using this appliance always exercise basic safety precaution
Download Pdf Manuals
Related Search