green star juice extractor green star juice extractor
Contents
1. If the material you are trying to process is cut too large or is too hard try using the reverse switch to clear the machine Check the fuse and replace if necessary Make sure the Twin Gears are correctly aligned Noisy gears Check to see if there is any hard material lodged in the gears If so disassemble the machine rinse and try again lt ng Check to see if the Twin Gears are seated properly Give them a ea S 0 Pulp is too wet Tighten the Outlet Adjusting Knob Pulp comes out with juice Make sure the screen is in position Low amount of juice Tighten the Outlet Adjusting Knob Dr Flip the switch to the reverse position once or twice Material jammed If it doesn t clear disassemble the machine to clear any blockage Machine stops while running Changing the Fuse 1 Unplug the juicer and store the cord in the Cord Storage Compartment 2 Locate the square plate on the bottom of the GS Juice Extractor Using a small Phillips Head screwdriver remove the two screws that hold the plate in position Remove the square plate 3 Find the round capsule shaped milky colored fuse casing There is a white wire extending from each end of the capsule 4 Grasp one end of the fuse casing between your thumb and forefinger of one hand and the other end of the fuse casing in the other hand Push both ends toward the center and twist to open the fuse holder Release both ends 5 Remove the old fuse from the casing an2. A Green Power Juice Extractor COMPLETE GUIDE To GREEN STAR ICE EXTRACTOR Dos TECHNOLO rive s A if 4 OPERATION MANUAL o INSTRUCTIONS o DO S AND DON TS o WARRANTY o WHEN YOU NEED SERVICE o OWNERSHIP REGISTRATION o RECIPES o IMPORTANT SAFETY INSTRUCTIONS SAVE THIS MANUAL KEEP IT HANDY FOR QUICK REFERENCE Congratulations You are now the proud owner of a Green Star Juice Extractor the ORIGINAL Twin Gear Juice Extractor With Green Star you can juice a wide variety of fruits and vegetables from carrots and apples to wheatgrass and pine needles all without having to stop and change any parts You can also use your Green Star Juice Extractor to make other delicious foods such as pastas baby foods breadsticks nut butters p tes frozen fruit sorbets and much more The revolutionary Heavy Duty Twin Gear design incorporates an impeller press system that rotates at a low 110 rpm and generates little heat while juicing The patented twin gears also have magnetic and bioceramic technology that produces fresher juice that can be stored longer with minimal loss of the precious enzyme and vitamin content in the juice After unpacking your Green Star and checking that all of the specified parts are there take some time to become familiar with your new juicer before you start juicing It is a good idea to disassemble and reassemble your machine a few times to become familiar with how all of the parts f
3. Repeat as necessary 2 The Screen Hold the screen under running water while brushing the pulp residue from inside the screen first and then the outside of the screen For pulp that has been imbedded firmly in the holes of the screen try soaking the screen for a couple of hours in water after brushing away as much pulp as possible You may also try using the DULL side of a table knife to rub along the inner surface of the screen and then brushing from the outside with the Cleaning Brush 3 The Main Body Motor Unit To clean the motor unit of your juicer position the front two legs over the edge of the sink With either the sink top sprayer a spray bottle filled with water or an empty detergent bottle filled with water and equipped with its squirt top spray water directly onto the front plate of the juicer where the drive shaft mounting peg and free wheel gear seats to remove pulp residue Wipe any other exterior surfaces with a damp cloth DO NOT SUBMERGE THE MOTOR UNIT INTO WATER AT ANY TIME 4 Other Helpful Hints Use the narrow pointed end of the cleaning brush to push food through out through the pulp discharge outlet Dried fruits and nuts can be very sticky on the inside surfaces of the juicer To remove the residue more easily run a couple of stalks of celery through before disassembling the machine To help the Twin Gears retain their shine alternate between running one tablespoon of carrot pu
4. within ten 10 days of the date of the original purchase The warranty is only good for the original purchaser for value This warranty is non transferable 2 If the GS exhibits defects while in normal household use we will upon our actual receipt of a written notice of such defects from you during the warranty period either repair or replace at our option the GS that has verifiable manufacturing defects However we have no such obligation to repair or replace the machine until after you have by insured mail and in properly protective packaging delivered the GS to the location of your service center as set forth on page 5 Replacement GS may be either new or like new Repaired GS may contain re manufactured or re conditioned parts which are equivalent to new in performance or may have been subject to incidental use 3 We do not warrant that the operation of the GS will be uninterrupted or error free In no event shall our liability exceed the retail value of the GS 4 All warranty and repair services must be performed at a warranty service center which is located within the country where the GS was originally purchased However in the event that I the machine must be serviced at a service center which is not located within the country where the machine was purchased or II there is no service center within the country where the machine is located and must be shipped to a service center in another country then those service centers
5. Lifespan of the Juice Extractor e Since the GS extracts minerals such as calcium from the produce so well we recommend cleaning all of the juicer parts immediately after use to prevent mineral build up which can cause problems e Completely disassemble the Pulp Discharge Casing and Twin Gear Housing sections Immerse them in water and clean them with the Cleaning Brush which is provided for your convenience e After cleaning the juice extractor let it air dry thoroughly To Remove Calcium and Mineral Deposits from the Twin Gears e After using the machine for some time you may notice a calcium or mineral deposit on the surfaces of the Twin Gear unit To remove calcium or mineral deposits from your Twin Gears After juicing carrots feed some of the carrot pulp back through the machine and then add some granulated sugar Ratio one tablespoon of carrot pulp to one or two teaspoons of granulated sugar Alternate pulp and sugar several times and then run the machine Make sure to disassemble and thoroughly clean all of the juicing parts Cleaning Green Star Make sure the machine is switched off and unplugged from the wall Store the cord in the Cord Storage Compartment e Because your Green Star Juicer extracts calcium and other minerals from the fruits and vegetables it is essential to wash your juicer parts immediately after use otherwise mineral deposits may form and cause problems e Rinse and scrub your parts under warm runn
6. are responsible for the parts and service only and any and all costs relating to the shipping delivery and handling of the machine to and from those service centers shall be the sole responsibility of the owner This Warranty does not cover damage resulting from a failure to operate the GS in accordance with the instructions b the use of parts or supplies not provided or authorized by the manufacturer c negligent improper or inadequate maintenance d service performed or attempted by unauthorized service person e damages accidental or otherwise to the GS which are not directly caused by us or the manufacturer or f damages resulting from abuse tampering misuse commercial use or unauthorized modification of the GS WE MAKE NO OTHER EXPRESS OR IMPLIED WARRANTY OR CONDITION WHETHER WRITTEN OR ORAL TO THE EXTENT ALLOWED BY LOCAL LAW ANY IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE OR IMPLIED WARRANTY OR CONDITION OF MERCHANTABILITY IS LIMITED TO FIVE 5 YEARS In the event that such limitation or exclusion on the duration of an implied warranty is not allowed in the state or county wherein you reside the above limitation or exclusion may not apply This warranty gives you specific legal rights and protection and you may also have other rights that vary from state to state or county to county TO THE EXTENT ALLOWED BY LOCAL LAW THE REMEDIES IN THIS WARRANTY STATEMENT ARE YOUR SOLE AND EXCLUSIVE REMEDIES EXCEPT AS IND
7. 1 dot between the 2 dots and insert them into the twin gear housing 1 Slide the Twin Gear Housing onto the main body with the Latching Arm Knobs loosened and the Latching Arms open Insert the Feeding Chute into the Twin Gear Housing neck with the small rectangular tab toward the rear of the machine Note Before putting your machine away for future use cover the Feeding Chute with its protective lid once it has been cleaned and dried Simply place the Feeding Chute Lid on top of the Feeding Chute with the two ears pointing to the sides of the juicer and the oval end of the lid toward the front of the machine Gently push it down into position Remove lid before using the juicer 2 Very Important Assemble the Twin Gears as follows Find the Locating Dots marked on the end surface of each gear Position the single dot on one gear between the two dots on the other gear Holding the Twin Gears in this position and with the Free Wheel Gear on the right slide them into the Twin Gear Housing Once the gears come to a stop slowly turn the gears and continue to push in until the gears lock into position Hint To check whether the Twin Gears are seated properly try to turn the gears with your hands If you can turn the gears they are not seated properly Also look down the feeding chute if any part of the drive shaft in front of the drive gear is visible the gears are not seated properly Rotate the g
8. ICATED ABOVE IN NO EVENT WILL WE BE LIABLE FOR DIRECT SPECIAL INCIDENTAL CONSEQUENTIAL INCLUDING LOST PROFIT OR OTHER DAMAGE WHETHER BASED IN CONTRACT TORT OR OTHERWISE Some States or counties may not allow the exclusion or limitation of incidental or consequential damages If you reside in such a state or county the above limitation or exclusion may not be applicable Do not send your GS back to the service center without return authorization Save Original Shipping Box Green Star Juicer Registration TRIBEST CORP P O Box 4089 Cerritos CA 90703 USA e Do you have Internet Service Yes No e Have you ever purchased any products through Internet Stores Yes No e Doyou use e mail at work Yes No E mail Address e Do you use e mail at home Yes No E mail Address e Please check all that apply to your household Regularly Purchase Items Though Support Health Charities Have a VCR the Mail Subscribe to Cable or Satellite Have a DVD Player Military Veteran in Household TV Have a DVR Member of Frequent Flyer Program Have a Microwave Oven Have a CD Player Use a Personal Computer Thank you for taking the time to fill out this questionnaire Your answers will be used to help us better serve you in the future Periodically we would like to send you important product information and special offers Be assured your privacy is important to us and your informa
9. SP EXTRA VIRGIN OLIVE OIL 1 Prepare steamed rice 2 Add olive oil into the Feeding Chute while running the machine 3 Slowly feed steamed rice into Feeding Chute 4 The rice cake will come out of the Rice Cake Guide Note Before processing mix spices such as minced garlic or onion with the rice to flavor your rice cake Slice the rice cake into diagonal slices Dehydrate them and add to your soup 27 PASTA AND NOODLES MACHINE SETUP Attach the Twin Gear Housing to the main body 2 Insert the Pasta Screw onto the motor drive shaft left side as you are looking into the body 3 Place the Pasta Guide over the Pasta Screw making sure the long side of the Pasta Guide is on the left 4 Select the pasta shape desired from the two shapes available on the Pasta Screen and fit it onto the Twin Gear Housing See diagram on page 16 5 Tighten the Latching Arm Knobs snugly 6 Place a plate under Pasta Screen Pasta 1 PACKAGE READY MIX PASTA DOUGH 1 TSP EXTRA VIRGIN OLIVE OIL 1 Prepare pasta dough according to the instructions on the package of the pasta dough mix 2 Put a few drops of olive oil into the Feeding Chute while running the machine 3 Feed your pasta dough into Feeding Chute 4 Collect your pasta onto a plate Variations If you use carrot juice when preparing the dough you will get red pasta Use kale juice for green pasta and water for plain pasta Note A whistling sound may occur in
10. TBSP HONEY 1 Mix wheat berries soaked sunflower seeds soaked cashew and poppy seeds together then grind through the machine 2 Collect the ground mixture from the Juice Outlet into a bow 3 Add vanilla and honey and mix 4 Roll into balls and place on a plate Uncooked Banana Blueberry Ice Cream Pie 1 CUP SOAKED ALMONDS Z CUP SESAME SEEDS 1 CUP CASHEWS Yo CUP RAISINS Yo CUP PITTED DATES Yo CUP PECANS 1 TSP VANILLA 2 TBSP HONEY 7 FROZEN BANANAS peeled 1 CUPS FROZEN BLUE BERRIES 1 KIWI sliced 2 LARGE STRAWBERRIES sliced 1 Grind almonds cashews sesame pecans dates and raisins together 2 Mix in the vanilla and honey knead to form dough then press into a 9 pie dish to form a crust Let crust sit for 3 to 4 hours or place in a food dehydrator for about 3 4 hour 3 Grind frozen bananas and frozen blueberries together to make ice cream 4 Put ice cream into the crust top with slices of strawberries and kiwi Slice and serve PRODUCT STANDARD ITEM VEGETABLE JUICER MODEL GREEN STAR ELECTRICITY RATING USA Models 120Vac 60Hz 180W EUROPE ASIA 220 240Vac 50 60Hz 120 140W SIZE 476mm x 165mm x 306mm WEIGHT 8 7kg V0711GS Updated in July 2011 This version supersedes all former manuals issued before this date
11. Tray CJGP5 037A Wooden Plunger CJST1 038A Feeding Chute CJGP5 027A Drive Gear CJST1 044A Feeding Chute Cover CJGP5 025A Screen Pulp Discharge Casing Free Wheel Gear CJST1 045A FEATURES AND PARTS Safety Tray Convenience Handle Feeding Chute Twin Gear Housing Main Body Motor Unit Power Cord Storage Compartment Latching Arm Speed Reducer Cover GS 2000 includes GS 1000 parts plus Coarse Screen S S Strainer Drip Tray CJST1 035A CJST1 042A CUGP5 038A GS 3000 includes GS 2000 parts plus Optional Bread Stick Bread Stick Pasta Screen Pasta Screw Pasta Guide Outlet Adjusting Blank Closed Guide Knob Soft Fruit Blank CJGS5 027A CJST1 033A CJGS5 042A CJGS1 041A CJSTI 030A CJST1 031A D gt Ee QP ED gt CY GREEN STAR PARTS GREEN STAR PARTS amp Order Form please call your service center for parts prices NO Ordered PartNumber Standard with GS Unit Price Quantity Total Wain Body Wih Motor CIGSTOs7A 70002008 7 Tin Gear Housing CJGSEOMA 1000 20003000 o Pulp Discharge Casing CJGS502A 100020008300 Outlet Adjusting Knob Regular CJGS5 026 A 1000200800 o Dive Gr osmom moveo Free Wheel Gear CUSTIOMSA 100020003000 Fine Screen ossosa tooo Homogenizing Blank PcusTr oa2a 1000720003000 oo Ju
12. am try refrigerating your gears before juicing wheatgrass and spraying the wheatgrass with cold water before juicing Note Please refer to Wheatgrass Delight on page 22 Making Pasta 1 Attach the Twin Gear Housing to the juicer body 2 Insert the Pasta Screw onto the motor drive shaft left side as you are looking at the front of the body 3 Put the Pasta Guide over the Pasta Screw making sure LAS the long side of the Pasta Guide faces to the left side 4 Select the pasta type that is desired from the two e ES Pad shapes provided on the Pasta Screen and fit it onto the Pasta Guide NGA 5 Tighten the Latching Arm Knobs A P 6 The machine is now ready to make pasta KE e 7 Be sure the dough is Se O Pasta Screw not too Moist N Pasta Guide Pasta Screen Making Breadsticks Bagels Rice Cakes Mochi etc 1 Assemble Green Star with the Bread Stick Blank instead of the fine screen 2 Attach the Pulp Discharge Casing to the Twin Gear 7 Housing thus locking the Bread Stick Blank into position lt 3 Unscrew the Outlet Adjusting Knob not shown here from the Pulp Discharge Casing and replace it with the Bread Stick Guide 4 Place the Safety Tray into position 5 Add ingredients to be used into the Feeding Chute Soaked grains are great for making raw dough Use cooked sticky white rice to make rice cakes CLEANING AND MAINTENANCE Proper Cleaning Lengthens the
13. ay from the body of the machine Note The Twin Gears on your juicer never need sharpening They are not blades that cut chip or tear the produce which can lead to heat that may destroy enzyme activity Instead the Twin Gears work by biting off small bits of produce at a time much like your teeth and does not heat up your juice MACHINE SETUP Which Screen Do You Use 1 Fine Screen makes the clearest juice by separating the most pulp from your juice The pressure built up inside the machine may push a minimal amount of pulp into the juice Use to juice most types of produce including carrot parsley kale wheatgrass other green leafy vegetables and herbs apples and all other types of produce Coarse Screen allows some pulp to mix with the juice Use it any time you want more pulp to mix into your juice optional for GS 1000 Homogenizing Blank Open Blank to puree make frozen desserts baby foods nut butters apple sauce pat relish etc Use with grains garlic banana strawberry nuts etc To use the Homogenizing Blank insert side A first with hole B facing downwards over the Twin Gears and into the Twin Gear Housing Using the Plastic Plunger The Plastic Plunger is specially designed to push food down the Feeding Chute without the plunger touching the gears To use the plastic plunger make sure that the safety tray is attach
14. ces If pineapple is not organically grown remove the outer skin before Juicing LEAVES STALKS STALKS DON fF Ow Oriental Express NAPA CABBAGE cut lengthwise BOK CHOY WITH LEAVES cut lengthwise ANISE FENNEL with GREEN STEM and LEAVES MEDIUM CARROTS cut into 4 pieces APPLES YELLOW DELICIOUS FUJI OR GRANNY SMITH cut into 4 to 6 pieces 1 Juice Napa Bok Choy and fennel first 2 Juice Apples second 3 Juice Carrots into the rest of the juice BREADSTICKS AND MOCHI RICE CAKE MACHINE SETUP 1 Place the Twin Gears in position 2 Use the Rice Cake Blank Closed Blank instead of Screens 3 Put the Pulp Discharge Casing into position 4 Tighten the Latching Arm Knobs snugly 5 Remove the Outlet Adjusting Knob from the Pulp Discharge Outlet and replace it with the Rice Cake Guide 6 Put a plate under the Rice Cake Guide Rye Breadsticks 2 CUPS RYE soaked overnight CUP SUNFLOWER SEEDS soaked overnight 2 TBSP CARAWAY SEED TSP SEA SALT 1 Mix all ingredients together in a bowl 2 Feed into machine a little at a time 3 Collect bread sticks as they emerge from the Pulp Outlet formed into bread sticks by Rice Cake Guide 4 Before drying these sticks can be shaped into pretzels braided together etc for a variety of shapes 5 Dry in the dehydrator until crisp Can be served with dips soups etc Mochi Japanese Rice Cake 2 CUPS STEAMED RICE medium grain rice recommended 1 T
15. d discard properly Place a new fuse into the casing Close the fuse casing by reversing the procedure in Step 4 above 6 Replace the square bottom plate and the two screws to secure to plate If your Green Star Juice Extractor still experiences problems after troubleshooting please contact your nearest authorized service center Green Star requires special repair procedures Repairs beyond the scope of the Troubleshooting Chart should never be attempted by anyone other than an authorized service center Repairs made other than by an authorized service center will void your warranty If the machine has stopped running please wait 10 minutes and try turning it on again In the unlikely event that the Feeding Chute becomes jammed while juicing or processing any food items A Put the ON OFF switch in the REVERSE position to dislodge the food B If this does not work TURN THE MACHINE OFF AND DISCONNECT IT FROM THE ELECTRICAL OUTLET FOR SAFETY Use a blunt tool to loosen whatever food is lodged in the Feeding Chute WARNING Never stick a knife spoon or other foreign object down the feeding chute while the machine is in operation HELPFUL HINTS NOISES Even though the Green Star juicer is very quiet some noises are normal during operation If you are unsure whether the noises you are hearing are normal 1 Completely disassemble your Green Star and turn on the motor You will hear a normal humming motor sound If
16. ears while pushing them in until they lock into position WARNING Failure to properly seat the Twin Gears could result in damage to the Gears and the Drive Shaft which may not be covered under the warranty GREEN STAR ASSEMBLY Conta 3 Slide the desired Screen or Blank over the Twin Gears and into the Twin Gear Housing 4 Slide the Pulp Discharge Casing over the Twin Gear Housing 5 Close each Latching Arm and tighten by turning both Latching Arm Knobs clockwise 6 Attach the Outlet Adjusting Knob by inserting it into the Pulp Discharge Casing and turning it clockwise until it is snug Do not over tighten 7 Attach the Safety Tray to the Feeding Chute GREEN STAR DISASSEMBLY Safety Reminder Make sure to unplug from the outlet before disassembly 1 Remove the Safety Tray by lifting it vertically from the Feeding Chute 2 Turn the Outlet Adjusting Knob counter clockwise until it separates from its threads then pull it out from its grooves 3 Turn the Latching Arm Knobs counter clockwise to loosen Open the Latching Arms horizontally outward on their hinges 4 Remove the Pulp Discharge Casing GREEN STAR DISASSEMBLY Conta 5 Remove the Screen The Twin Gears may come out with it Be careful not to drop the Twin Gears 6 Slide the Twin Gears out 7 Remove the Twin Gear Housing by gently pulling it aw
17. ed and press down with the plunger NEVER USE THE PLASTIC PLUNGER WITHOUT THE SAFETY TRAY ATTACHED Using the Wooden Plunger Don t be afraid of the wooden plunger touching the twin gears while juicing Touching the plunger to the twin gears will not harm the gears or the plunger The plunger is made from the same high quality wood as many fine chopping blocks so any accidental particles of cellulose scraped off by the Twin Gears are non toxic and will pass harmlessly with the pulp Using the Drip Tray Position the drip tray with the narrow end underneath the pulp discharge outlet Rest the front two legs of the juicer on top of the corners of the wide end of the drip tray Place the juice pitcher on top of the drip tray to collect juice Juicing Wheatgrass Also Barley Grass Alfalfa amp Others 1 Assemble Green Star with the Fine Screen for maximum juice extraction and pulp separation 2 Tighten the Outlet Adjusting Knob completely 3 With the power switch in the on position place a handful of wheatgrass approx 3 4 inch in diameter tip down into the Feeding Chute MACHINE SETUP Conta 4 After a few drops of juice come out from the Pulp Discharge Outlet loosen the Outlet Adjusting Knob about halfway 5 Carrots apples and other fruits and vegetables can be added to create a milder tasting combination for those who have not yet acquired a taste for pure wheatgrass juice 6 If you notice excess fo
18. essions without disassembling the machine completely remove the Outlet Adjusting Knob place a large bowl under both the Juice Outlet and the Pulp Discharge Outlet and pour about 16 ounces of water through the feeding chute while the machine is running before and after each juicing session Make sure to thoroughly clean the juicer after the last juicing session of the day 1 Stains and Mineral Deposits Colored stains and mineral deposits on parts are normal usage signs of a product But to remove color stains and mineral deposits 1 Stains NEVER use harsh chemicals such as bleach to remove food stains from the juicer Use a 25 50 white vinegar water solution and soak the parts overnight This may be repeated if necessary Juicing green honeydew or cantaloupe melons may also lighten stains 2 Mineral Deposits Soak in a Baking soda solution 1 Mix 4 tablespoons of baking Soda with 2 cups 16 oz of lukewarm water 2 Soak the parts in the solution of water and baking soda overnight to loosen the mineral deposits and to remove stains Wash with soap and water and use a hard bristled brush to remove mineral deposit Wipe with cloth to dry Mineral Deposits may be removed from the tips of the Twin Gears by running soaked almonds through the machine Another excellent way to remove mineral scales is to soak the affected parts in a pure vinegar bath overnight This loosens the scaling and much of it can be brushed off
19. ice Pitcher ossoa 100020003000 Wooden Plunger ossosa ooo Plastic Plunger CIGPSOSA 1000720003000 Cleaning Brush ossoa 1000720003000 Safety Tray CIGPSOSTA 100020003000 Coarse Screen ossosa 20008000 Stainless Steel Strainer CISTA 20003000 Drip Tray CIGPSOSA 2000800 o om Bread Stick Blank Ta Bread Stick Guide cessa a o po Pasta Soreen TOGA 00 I Pasta Screw osno a o po Pasta Guide GISTA 500 o TT Outlet Adjusting Knob Soft Fruit CJGS5 027A Oon po o Twin Gear Sei Includes 1 Free Wheel Gear 8 1 DrveGear Ti Pasta Sei Includes 1 Pasta Screen 1 Pasta Sorew amp 1 Pasa Gude Bread Stick Maker Sei Includes 1 Bread Stick Blank amp Bread Stick Guide S PSS TAX resns r Shipping Hand Total Encsed SSCS Payment Method Check Money order payable to Tribest enclosed Visa MasterCard Discover Amex Card Number Expiration PI DI cl DD Na LL Card Holder s Name Authorized Signature Date Business Name Billing Address Shipping Address if different from billing Phone Number Call 714 879 7150 for pricing information and send this order form along with your method of payment in a stamped envelope to the nearest Green Star Service Center or to Tribest Corp P O Box 4089 Cerritos CA 90703 DO NOT SEND CASH GREEN STAR ASSEMBLY Safety Reminder Make sure to unplug the machine before assembling AJ Drive Gear Free Gear Position the
20. ing water and use a mild detergent to clean the parts Disassemble the juicer as shown on page 13 14 and immerse each component in lukewarm water Clean out all the pulp with the multipurpose Cleaning Brush provided using the thinner end to force out the pulp which normally collects in the Pulp Discharge Outlet e When using the Fine Screen brush away from the corners avoiding a build up of pulp which will be difficult to remove later Under no circumstances should you allow water to enter the main body of the machine Please refer to HELPFUL HINTS page 20 Rinse all soapy water from the components dry them thoroughly before they are reassembled e You will notice that some of the inside surfaces may get stained during operation by natural pigments found in your vegetables This is considered normal and may not be able to be removed e NEVER use harsh chemicals such as bleach to remove food stains from the Juicer NEVER drop any of the components particularly the Twin Gears Our warranty does not cover accidental damage Do not put any parts into the dishwasher O TROUBLESHOOTING Make sure the power supply is active the plug is correctly Machine doesn t turn on positioned in the electrical outlet and the machine is switched on Check the fuse and replace if necessary Make sure the machine is correctly assembled If the machine is overloaded use the reverse switch to dislodge some of the ingredients
21. it together properly Many parts have been included as standard parts to make your juicing experience easier and to enhance the versatility of the food preparation capabilities We recommend that you rinse all of the parts in lukewarm water before you first use your Green Star Juice Extractor Now you are ready to begin juicing with your Green Star Juicer We hope you enjoy your Green Star experience as it helps you embark on your journey to better nutrition and better health WARRANTY Please read carefully We warrant to you the end user customer who has properly registered after purchasing the Green Star Juice Extractor hereinafter referred to as GS for a valuable consideration that the plastic parts motor and the Twin Gears of this GS will be free from defects in materials and workmanship for a period of five 5 years from the date of purchase All other parts including but not limited to the Juice Pitcher Cleaning Brush Wooden or Plastic Plunger and the Strainer are not subject to any warranty In order for you to receive the benefits of this warranty you are required to register for warranty service by a completing and mailing the warranty registration card next 2 pages to us within ten 10 days following the purchase of your GS or b registering online at www greenstar com 1 No warranty will be provided until after we have actually received the proper registration with all of the requested information
22. itially but will disappear after some dough has been fed through the machine PATE AND CROQUETTES MACHINE SETUP 1 Place the Twin Gears in position 2 Instead of the Juicing Screen use the Homogenizing Blank 3 Tighten the Latching Arm Knobs snugly 4 Tighten the Outlet Adjusting Knob 5 Place a bowl under the Juice Outlet Cashew Curry Croquettes 2 CUPS CASHEWS 1 CUP SPROUTED WHEAT soak for 12 hours and let small tips emerge by sprouting 3 TBSP CURRY PASTE available from gourmet food stores TSP VEGE SALT TO TASTE Put the cashews and sprouted wheat berries into the Feeding Chute Add curry paste and vege salt a little at a time while texturizing Collect the texturized mixtures from the Juice Outlet Mix together by hand or with a wooden spoon Form into croquettes and garnish with tomatoes radish and cucumber ork GN HINT For asmoother consistency use the Bread Stick Blank instead of the Homogenizing Blank and remove the outlet adjusting knob Collect the mixture from the pulp discharge outlet Pecan Pleasers 2 CUPS PECANS 1 CUP SPROUTED WHEAT BERRIES soak 24 hours VA CUP SPANISH ONION 1 TSP POULTRY SEASONING VA TSP VEGE SALT 1 Put pecans wheat berries and onion into the Feeding Chute 2 Collect mixture in a bowl 3 Add the poultry seasoning and vege salt 4 Mix thoroughly by hand or with a wooden spoon 5 Shape into small wafers and serve on cucumber slices with tomato or avocad
23. lp and one teaspoon of granulated white sugar through the machine several times JUICES AND DRINKS MACHINE SETUP FOR ALL JUICES AND DRINK RECIPES 1 Place the Twin Gears in position 2 Use the Fine Screen 3 Tighten the Latching Arm Knobs snugly 4 Tighten the Outlet Adjusting Knob completely 5 Put glass Juice Pitcher under the Juice Outlet 6 Put container under the Pulp Outlet to catch pulp Notice When juicing a combination of hard fibrous vegetables such as carrots or beets with leafy greens such as herbs or grasses be sure to push any remaining bits of the hard vegetables completely through the Feeding Chute before introducing any of the leafy greens Citrus Blend 2 SMALL GRAPEFRUIT peeled and cut into 4 to 6 pieces 3 MEDIUM SIZE ORANGES peeled and cut into 4 pieces SMALL LEMON peeled and cut into 2 pieces SMALL LIME peeled and cut into 2 pieces Note for sweeter taste use less lemon and lime Apple Lemonade 3 FIRM APPLES FUJI PIPPIN OR GRANNY SMITH cut into 6 pieces 3 MEDIUM SIZE ORANGES peeled and cut into 4 pieces LEMON peel is optional for sweeter flavor Wheatgrass Delight HANDFULS WHEAT GRASS CARROTS cut in 2 to 4 pieces FIRM APPLE cut into 6 pieces THIN SLICE GINGER ao AR JUICES AND DRINKS Conta See page 15 for machine set up Ambrosia Nectar 2 BUNCHES GRAPES APPLES FUJI GRANNY SMITH OR PIPPIN cut into 6 pieces KIWI peeled and cut int
24. not possible turn the motor off and disassemble the juicer to remove the remaining food 14 For household use only 15 Please refer to INSTRUCTIONS before operating 16 Please refer to When You Need Service in case your juicer is functioning abnormally 17 Do not disassemble any parts other than those necessary for normal operation or cleaning of your juice extractor such as housing twin gears screen 18 Your Green Star Juice Extractor must be grounded electrically for proper safe operation Use only the 3 prong plug provided Or use a proper plug or adapter according to the electrical safety code in your country 19 Do not use the appliance for other than its intended use 20 Always make sure that all juicing parts are fastened in place by the latching arms and that the latching arm knobs are tightened securely before the motor is turned on Do not loosen latching arms while the machine is in use SAVE THESE INSTRUCTIONS DO S AND DON TS DO e Very important When combining the Twin Gears for assembly make sure to align the locating dots marked on the surface of the gears DONT e Do not lift your Green Star Juice Extractor with wet hands because itis heavy and it may accidentally slip from your grip e Do not keep the juice extractor where children can reach it Soak grains in water for 6 hours or more Drain the grain and put into the machine a little at a time togethe
25. o 2 pieces 1 1 SLICE HONEYDEW cut into cubes 1 SLICE PINEAPPLE cut into cubes 1 WHOLE LEMON peeled and cut into 4 pieces CUP CRANBERRIES 1 Alternate juicing grapes kiwi pieces melon cubes pineapple cubes apple pieces and cranberries 2 Juice lemon separately and add to taste Note Quantities of ingredients may be varied with good results Do not be afraid to experiment according to your own taste Watermelon Quench Watermelon with seeds If organically grown add rind also JUICES AND DRINKS Cont d See page 15 for machine set up Mellow Melon Punch JA CANTALOUPE cut into cubes JA HONEY DEW cut into cubes 2 SLICES WATERMELON cut into cubes Juice all together and enjoy Snappy Apple 7 APPLES FUJI GRANNY SMITH YELLOW DELICIOUS cut into 4 to 6 pieces JALAPENO JA LIME 1 KIWI peeled and cut into 2 pieces 1 Juice Kiwi and Lime first 2 Next juice Jalapeno 3 Finish by juicing the Apples Dr Walker s Choice 61 10 oz CARROTS cut into 4 pieces 6 oz FRESH SPINACH 1 Juice Spinach 2 Juice Carrots JUICES AND DRINKS Conta See page 15 for machine set up 2 1 SPRIG 3 HANDFULS Ya 1 SLICE 1 Juice wheatgrass 2 Juice mint 3 Juice lemon Green Tang PINEAPPLE WEDGES cut into smaller pieces MINT WHEATGRASS LEMON GINGER FOR FLAVOR 4 Juice pineapple cubes Note A Pineapple wedge is a 1 round slice of whole pineapple cut into quarters 4 pie
26. o on top SOUP MACHINE SETUP A To Juice Carrots Lemon And Apple 1 Place the Twin Gears into position 2 Use the Fine Screen 3 Tighten the Latching Arm Knobs snugly B To Grind Beets And Scallions 1 Place the Twin Gears into position 2 Use the Homogenizing Blank 3 Tighten the Latching Arm Knobs snugly Beet Borscht JUICE A 1 APPLE cut into 4 to 6 pieces 8 CARROTS cut into 4 lengthwise pieces if the carrot is thick Vp LEMON cut into 2 pieces GRIND B 2 BEETS 2 GREEN SCALLIONS 1 CUP FINELY SHREDDED CABBAGE 1 DOLLOP AVOCADO YOGURT 1 Juice carrots lemon and apple Keep juice in a glass or the Juice Pitcher 2 Remove the Fine Screen and replace with the Homogenizing Blank to grind beets and scallions into a separate bowl 3 Add ground beets and scallions to the carrot lemon and apple juice and mix 4 Fold in the finely grated cabbage 5 In a blender blend avocado and yogurt together To serve Place borscht in a bowl Top with a dollop of avocado yogurt DESSERT MACHINE SETUP 1 Place the Twin Gears in position 2 Use the Homogenizing Blank 3 Put the Pulp Discharge Casing into position 4 Tighten the Latching Arm Knobs snugly 5 Tighten the Outlet Adjusting Knob 6 Place a bowl under the Juice Outlet Cashew Poppy 1 CUP SPROUTED WHEAT BERRIES soak for 12 hours until small sprout tips emerge Ya CUP POPPY SEEDS Ya CUP SOAKED SUNFLOWER SEEDS 1 CUP CASHEWS A TSP VANILLA 4
27. play Recommendation Owner Demonstration Information Through the Mail e Annual Household Income Other Less than 15 000 i 15 000 25 000 e What factors most influenced your decision to o 3 a 25 000 50 000 purchase this juicer please check up to three 50 000 75 000 Green Star Reputation Consumer Magazine 75 000 100 000 Style Appearance Article more than 100 000 Value for the Price Reputation ofthe Special Product Features Dealer e Which credit cards do you use regularly Warranty Friend s Relative s ere ee Rebate or Sale Price Recommendation Diner p o 5 i iner s Club Quality Durability Salesperson s amp MasterCard Recommendation PR en Visa Other Discover e Primary residence Department Store Gasoline Company etc Own a House Do not use credit cards Own a Townhouse or Condominium Rent aHouse Rent an Apartment Townhouse or Condominium WHEN YOU NEED SERVICE In the unlikely event that you need service on your GREEN STAR JUICE EXTRACTOR or if it fails to function properly while within the warranty period during normal household operation contact the Green Star Warranty Service Center SERVICE CENTERS For all service inquiries please first contact the Main Service Center for a return merchandise authorization RMA number and proper routing instructions Main Service Center Regional Service Centers Tribest Cor
28. poration West 1143 North Patt Street 3800 Happy Lane Suite A Anaheim CA 92801 Sacramento CA 95827 9721 TEL 888 254 7336 FAX 714 879 7140 East Midwest 47 Miry Brook Road 21355 Highway 179 Danbury CT 06810 Jamestown MO 65046 If you need service 1 Call the Main Service Center 888 254 7336 to get a return merchandise authorization RMA number to send your unit to the service center Returns will NOT be accepted without an RMA number clearly written on the box 1 Pack your Green Star securely in the original shipping box Make sure all affected parts are enclosed 1 Fill out the service request form below detach it and enclose it in the shipping box 1 Seal the shipping box securely with packing tape 1 Address the box to the service center Be sure to put your return address on the outside of the package 1 It is always wise to insure the package against possible damages or loss in transit Ship prepaid SERVICE REQUEST FORM First Name Initial Last Name Address Stret At Ciy CS tate Zip Phone Serial _ Modelf amp Date of Purchase S rie of Purchase Name of parcel post carrier In case of damage during delivery Reason for service request use additional paper if more space is needed O IMPORTANT SAFEGUARDS When using electrical appliances basic safety precautions should always be followed including the following 1 Please read all instructions carefully 2 To protec
29. r with a small amount of water e When you operate your Green Star Juice Extractor continuously stop operation for 10 minutes after each 30 minutes of use and then resume operation 10 minutes of rest after 30 minutes of operation e Do not assemble or disassemble while the power cord is plugged in e Do not put any articles such as knives spoons or forks into the e Always put the Feeding Chute into the Twin Gear Housing before using Directions for assembling the Feeding Chute can be found on page 11 e Do not put fingers or hands into the Feeding Chute Always use the Plunger e Do not operate Green Star Juice Extractor on an unstable surface e Do not disconnect the power plug from the electrical outlet with wet hands e Do not forcibly operate the juice extractor or overload the Feeding WARNING NEVER REMOVE THE TOP SECTION OF THE FEEDING CHUTE WHILE THE JUICER IS IN USE GREEN STAR JUICE EXTRACTOR Outlet Adjusting Knob Standard Parts for GS 1000 Homogenizing Blank Open Blank CJST1 032A Twin Gear Housing CJGS5 024A Fine Screen CJST1 034A Pulp Discharge Casing CJGS5 028A Juice Pitcher CJST1 040A Outlet Adjusting Knob CJGS5 026A We Pulp Outlet Cleaning Brush CJST1 039A Latching Arm Knob CJGP5 006A Juice Outlet Plastic Plunger CJGP5 036A Safety
30. t against risk of electric shock do not put the motor base in water or any other liquid 3 Close supervision is necessary when any appliance is used by or near children 4 Unplug the appliance from the electrical outlet when not in use before assembling or disassembling and before cleaning 5 While the machine is in operation avoid touching its moving parts 6 Do not operate any appliance with a damaged cord or plug or after the appliance malfunctions is dropped or is damaged in any manner Return the appliance to the nearest authorized service center for examination and possible repair to prevent electrical shock or injury 7 The use of attachments not recommended or sold by the manufacturer may cause fire electrical shock or injury 8 Do not use outdoors 9 Do not let the cord hang over the edge of a table or counter 10 Do not let the cord come in contact with any hot surfaces such as the stove 11 Always make sure the two latching arm knobs are fastened securely in place before the motor is turned on Do not unfasten the knobs while the juicer is in operation 12 Be sure to turn the switch to the OFF position after each use Make sure the motor stops completely before disassembling 13 Do not put your fingers or other objects into any juicer openings while it is in operation If food becomes lodged in the feeding chute use the wooden plunger or another piece of fruit or vegetable to push it down When this method is
31. tion is never shared or sold to third parties unless it is required for us to conduct regular business with you or unless it is required by law Please initial here if you would not like us to send you important product updates and announcements If you have comments or suggestions about our product please write to Green Star Customer Relations P O Box 4089 Cerritos CA 90703 PUT GLUE HERE TO SEAL IMPORTANT GREEN STAR JUICER REGISTRATION FORM PLEASE FILL OUT AND RETURN WITHIN THE NEXT IO DAYS Please write all information legibly Customer Information Mr Mrs o Ms Miss First Name Initial Last Name Street Apt No City State Zip 3 Phone E mail Address 2 Date of Purchase E Dealer Information Month Day Year i Dealer Product Information a Model number b Color Address GS1000 GS 3000 White Green GS2000 GP E1503 Off White Ivory c Senial Phone OPTIONAL SURVEY e How did you learn of Green Star e Occupation Please check only one Homemaker Clerical or Service Worker Received as Gift Consumer Magazine Professional Technical Tradesman Machine Magazine Advertisement Article Upper Management Operator Laborer Newspaper Advertisement Friend s Relative s Executive Retired TV Advertisement Recommendation Middle Management Student Radio Advertisement Salesperson s Sales Marketing Self Employed Business In store Dis
32. wly rotating gears Cut thicker carrots into lengthwise halves for easier juicing The Plastic Plunger does not reach all the way to the gears try using the Wooden Plunger to push that last bit of carrot for complete juicing 2 Wheatgrass To minimize the amount of foam produced refrigerate the gears and wheatgrass for about 2 hours or overnight before juicing As you are juicing spray some cold water on the wheatgrass If you do not mind wheat grass juice mixed with carrot juice you will get maximum yield on the wheat grass juice with minimum foam by alternating wheat grass and carrot while juicing Note Certain batches of wheatgrass may cause more foam than others If you notice that your wheatgrass is generating excess foam try finding a new source for your wheatgrass 3 Leafy Vegetables To juice leafy vegetables easily simply roll the leaf into a cylindrical shape and insert into the Feeding Chute 4 Apples Always use crisp varieties of apples for juicing such as Fuji Apples or Granny Smith Avoid softer varieties of apples like Red Delicious or any other apple that has a powdery consistency when biting into it HELPFUL HINTS CLEAN UP Keeping your juicer clean is extremely important for both your health and the peak performance of the machine We recommend cleaning the juicer immediately after each use before food particles have a chance to dry out However if you want to juice throughout the day in multiple s
33. you hear squeaking your juicer may need lubrication between the Drive Shaft and the rubber seals Do not be intimidated by this noise It does not affect the juicer s performance and will not damage any other parts on your juicer Please call your service center for instructions on how to lubricate your juicer 2 Fully assemble your juicer and turn it on without adding any produce You will hear the Twin Gear sound You may hear a repetitive thumping sound which is normal The Twin Gears may have minor variations and the thumping sound is considered normal This minor variation will not affect the function and will not damage any parts 3 While you are juicing you may hear a squeaking or chirping sound that is also considered to be normal MOVEMENTS A great deal of pressure is built up in the juicing chamber while in operation In order to alleviate some of this pressure Green Star was designed to wiggle and flex while juicing to prevent damage to other parts of the machine The flexing is normal and will not cause damage JUICING Remember that your juicer needs time it is revolving at only 110 rom The most nutritious juice is made slowly allowing the produce to come into contact with the magnetic field focused only in the tiny space between the gears for a maximum length of time Also slow juicing is gentler creating less heat build up 1 Carrot The Twin Gears are not blades you will need to firmly push carrots into the slo
Download Pdf Manuals
Related Search