User Manual
Contents
1. HURRICANE 1100 User Manual Value Innovation Performance TABLE OF CONTENTS T Before You BEN ee 3 MASE 3 YNDACKING INSTUGTONS gt 3 A 3 FO NN 3 Sale ISU 4 ZIMIO sa 5 Product OI ona Ai 5 Fo CDI SI ON eo 5 ND a En E E A A EE 7 AGC e ds UB ML ML A dL e eo 7 ERNST T NO EEE EEE OO 8 iaculo ED I I UI mt 8 FAG HG RR dee tala DS 8 4 Oberaling INSTUCIONS Re 9 Manual Remote Operation FC M Standard sese 9 Timer Remote Operation FC T 00 0 9 Wireless Controller FC W Optional 10 General assi 11 CO LACE TOM 5 Technical WAN YATE eec Len 12 Eee ee EE RE NE rS S ada IN bL cis ictediuf eife uta 12 O PRODR DR PH 12 REN POE e Ae o i iocis 13 Techhical SpecilicatiOHS en 14 Hurricane 1100 User Manual 2 Rev 6 1 BEFORE YOU BEGIN What Is Included 1 x Hurricane 1100 1 x FC M Wired Manual Remote 1 x Warranty Card 1 x User Manual Y Y Y Y Unpacking Instructions Immediately upon receiving a fixture carefully unpack the carton check the contents to ensure that all parts are present and have been received in good condi2. Data pin configurationpin1 LED pin2 control pin3 5V pin4 ground pind none ground none ORDERING INFORMATION PIU Cae LUIS F1100 Wired manual remote included FC M Wired timer remote OPINA Siria AAA AA ARA FC T Wireless manual remote optional rr rre dane FC W SPARE PARTS ORDERING INFORMATION Master PO B ure vit rr eiet P170 F1MSPCB Heater P120 HT7 EIH T I UU UT P200 F1PUMP PICO AIN RN HR LE P170 F1FLC Fluid sensor P170 F1FLOS Thermal switch m I I m P170 THEF11 Bracket O P111 F1BKNOB Fuse holder P170 FUSEHOL araktog BUT P111 F1FOGB WARRANTY INFORMATION L Iz Va 1 year limited warranty Hurricane 1100 User Manual 14 Rev 6
3. or dimmer circuit even if the rheostat or dimmer channel is used solely for a 0 to 100 switch Before applying power to a fixture check that the source voltage matches the fixture s requirement Check the fixture or device carefully to make sure that if a voltage selection switch exists that it is set to the correct line voltage you will use Fuse Replacement N Unplug the IEC power cable before replacing the fuse Always replace with same type of fuse This product has a replaceable fuse In the event that the fuse needs to be replaced follow the instructions provided below 1 2 3 Using a flat head screwdriver remove the fuseholder from the IEC housing Remove the bad fuse from the fuseholder Insert the new fuse into the fuseholder Install the fuseholder in the IEC housing The fuse is located inside this compartment Remove using a flat head screwdriver Hurricane 1100 User Manual T Rev 6 Mounting Orientation This fixture should only be mounted used on a flat surface This fixture may not be tilted Rigging It is important never to obstruct the vents pathways Mount the fixture using a suitable C or O type clamp e When selecting installation location take into consideration the fluid reservoir access and routine maintenance e Safety cables must always be used utilizing the provided safety eye bolt e Never mount in places where the fixture will be exposed to rain high hu
4. S MANUAL Timer Latching And Button Continuous Latching Button Hurricane 1100 User Manual 9 Rev 6 Wireless Controller FC W Optional This mode will allow you to control the fogger using the optional wireless controller This consists of the transmitter and the receiver You may control up to 4 independent fog machines or many more if you run them simultaneously See the below instructions on setting up your fogger to operate with the FC W 1 Plug the wires receiver into the fog machine 5 pin port labeled Wireless Controller 2 There are 4 buttons on the wireless remote transmitter which act as triggers Each button can be assigned to a different fog machine You may only choose 1 dipswitch on each receiver See the below configuration for setting the receivers to operate with the transmitter remote Mode Dipswitches CH1 1 On 2 4 Off CH2 2 On 1 3 4 Off CH3 3 On 1 2 4 Off CH4 4 On 1 2 3 Off 3 Press the fog button and the fog machine will output fog momentarily for as long as you hold down the button LED indicator LED indicator ready heating Dipswitches Wireless Transmitter Wireless Receiver Hurricane 1100 User Manual 10 Rev 6 General Troubleshooting Symptom Solution s No Power Check mains power Check external fuse Check internal fuse No fog output Check fluid level Check remote If using wireless check batteries If using wireless check dipswitches on re
5. ceiver Dealer distributor for further instruction Check that the fog machine is plugged into the correct voltage Fog machine is not heating up Check the external fuse Check the internal fuse Possible bad part Contact Chauvet or a Chauvet Dealer distributor for further instruction Remote does not work Make sure connector is firmly connected to device Try using another controller Possible bad controller Check the internal fuse Check the external fuse Fluid indicator states no fog but Try resetting the fog machine by turning the power off and then on the container if full again Possible bad part Contact Chauvet or a Chauvet Dealer distributor for further instruction If you still have a problem after trying the above solutions please contact CHAUVET Technical Support at the location listed below Contact Information World Headquarters United Kingdom amp Ireland CHAUVET CHAUVET Europe Ltd General Information General Information Address 5200 NW 108th Avenue Address Unit 1C Sunrise FL 33351 Brookhill Road Voice 954 929 1115 Pinxton Nottingham UK Fax 954 929 5560 NG16 6NT Toll free 800 762 1084 Voice 44 0 1773 511115 Technical Support Fax 44 0 1773 511110 Voice 954 929 1115 Press 4 Email uktech chauvetlighting com Fax 954 756 8015 World Wide Web World Wide Web www chauvetlighting com www chauvetlighting co uk Hurricane 1100 User Manual 11 Rev 6 9 TECHNICAL INFORMATION Gene
6. ep this User Guide for future consultation If you sell the unit to another user be sure that they also receive this instruction booklet e Always make sure that you are connecting to the proper voltage and that the line voltage you are connecting to is not higher than that stated on the decal or rear panel of the fixture e This product is intended for indoor use only If applicable e To prevent risk of fire or shock do not expose fixture to rain or moisture Make sure there are no flammable materials close to the unit while operating e The unit must be installed in a location with adequate ventilation at least 20in 50cm from adjacent surfaces Be sure that no ventilation slots are blocked e Always disconnect from power source before servicing or replacing lamp or fuse and be sure to replace with same lamp source e Secure fixture to fastening device using a safety chain Never carry the fixture solely by its head Use its carrying handles e Maximum ambient temperature Ta is 104 F 40 C Do not operate fixture at temperatures higher than this e Inthe event of a serious operating problem stop using the unit immediately Never try to repair the unit by yourself Repairs carried out by unskilled people can lead to damage or malfunction Please contact the nearest authorized technical assistance center Always use the same type spare parts e Never connect the device to a dimmer pack e Make sure the power cord is never c
7. midity extreme temperature changes or restricted ventilation Hanging Clamp Note Clamp is sold separately Angled Down Hurricane 1100 User Manual 8 Rev 6 4 OPERATING INSTRUCTIONS This mode will allow you to control the fogger manually set the fog machine to run continuously or to set the fog machine to run off bursts with adjustable interval and duration settings Manual Remote Operation FC M Standard 1 Plug in the fog machine to power 2 Plug in the M remote to the Manual Controller socket on the rear of the fog machine 3 Press the single button located on the remote to trigger the fog output The button is momentary which means that the fog machine will only output while the button is pressed Once the button is released the fog will stop outputting Timer Remote Operation FC T Optional 1 Pluginthe fog machine to power 2 Plugin the timer remote to the Manual Controller socket on the rear of the fog machine 3 Press the TIMER ON OFF button on the timer remote The LED above the button should light indicating activation of function 4 You may now set the INTERVAL amp DURATION adjustment knobs to the desired position The INTERVAL is the time between bursts of fog E The DURATION is the time that the fog machine will run during the burst Interval Duration Adjustment Adjustment Timer LED HSS Indicator Momentary LED Manual Power LED Manual control Momentary TIMER CONTINUOU
8. ral Maintenance Do not allow the haze machine to become contaminated After every 40 hours of continuous operation use Chauvet Fog Cleaner Quart or a solution of 80 distilled water and 20 distilled vinegar through the system to prevent the accumulation of particulate matter in the heating element is recommended The recommended cleaning regimen is as follows 1 Empty all haze liquid from the machine 2 Add cleaning solution to tank 3 Plug unit in and allow it to warm up 4 Run the unit in a well ventilated area until the tank is almost empty Do not allow the pump to run dry 5 Cleaning is now complete Refill with haze liquid Run the machine briefly to clear any cleaning solution from the pump and heater Hurricane 1100 Make sure you use FCQ regularly to increase the life of your E Fog Cleaner Quart FCQ was specifically developed by Chauvet to clean your product Before storing this product FCQ through the system as described in the cleaning method above This will help to avoid any particles condensing inside the pump or heater Test run your Hurricane 1100 on a monthly basis to achieve the best performance Storage Hurricane 1100 User Manual 12 Rev 6 Return Procedure Returned merchandise must be sent prepaid and in the original packing call tags will not be issued Package must be clearly labeled with a Return Merchandise Authorization Number RMA ft Products returned without a RMA will be ref
9. rimped or damaged e Never disconnect the power cord by pulling or tugging on the cord e Avoid direct eye exposure to the light source while it is on attempt any repairs yourself In the unlikely event your unit may require service There are no user serviceable parts inside the unit Do not open the housing or please contact CHAUVET at 954 929 1115 Hurricane 1100 Make sure you use FCQ regularly to increase the life of your Ei FCQ Fog Cleaner Quart was specifically developed by Chauvet to clean your fogger Hurricane 1100 User Manual 4 Rev 6 2 INTRODUCTION Product Overview Hanging bracket Fluid container Safety cable eye bolt Tilt Adjustment knob Heater Nozzle Manual Fog button Low Fluid indicator Fluid level indicator Manual Controller N 5 G Wireless MANUAL Controller CONTROLLER CONTROLLER Nene Power input hardwired Fuse holder Hurricane 1100 User Manual 5 Rev 6 Product Dimensions 242 mm 9 5 in 258 mm 10 2 in 225 mm 8 9 in Rev 6 Hurricane 1100 User Manual 6 3 SETUP AC Power To determine the power requirements for a particular fixture see the label affixed to the back plate of the fixture or refer to the fixture s specifications chart A fixture s listed current rating is its average current draw under normal conditions All fixtures must be powered directly off a switched circuit and cannot be run off a rheostat variable resistor
10. tion Notify the shipper immediately and retain packing material for inspection if any parts appear damaged from shipping or the carton itself shows signs of mishandling Save the carton and all packing materials In the event that a fixture must be returned to the factory it is important that the fixture be returned in the original factory box and packing Claims The carrier is responsible for any damage incurred during shipping to this product or any part that shipped with it Therefore if the received merchandise appears to have damages caused during shipping the customer must submit the damage report and any related claims with the carrier not CHAUVET The customer must submit the report upon reception of the damaged merchandise Failure to do so in a timely manner may invalidate the customer s claim with the carrier For other issues such as missing components or parts damage not related to shipping or concealed damage the customer must make claims to CHAUVET within seven 7 days of receiving the merchandise Product at a Glance Auto Programs Auto ranging Power Supply Q Replaceable Fuse v Use on Dimmer Outdoor Use Sound Activated DMX Master Slave User Serviceable Duty Cycle Hurricane 1100 User Manual 3 Rev 6 Safety Instructions N Please read the following notes carefully because they include important safety information about the installation usage and maintenance of this product e Please ke
11. used Call CHAUVET and request a RMA prior to shipping the fixture Be prepared to provide the model number serial number and a brief description of the cause for the return Be sure to properly pack fixture any shipping damage resulting from inadequate packaging is the customer s responsibility CHAUVET reserves the right to use its own discretion to repair or replace product s As a suggestion proper UPS packing or double boxing is always a safe method to use If you are given a RMA please include the following information on a piece of paper inside the box 1 Your name 2 Your address 3 Your phone number 4 The RMA Z 5 A brief description of the symptoms Hurricane 1100 User Manual 13 Rev 6 TECHNICAL SPECIFICATIONS WEIGHT amp DIMENSIONS LENGI M E MPEG 10 2 in 258 mm Aue i TERR 9 5 in 242 mm Og 8 9 in 225 mm A E H 8 3 Ibs 3 8 kg POWER A PON T e 120V 60Hz AC or 230V 50Hz RUSCA TT 8A 250V Seda HI ee 774W 5 9A max 120V MUA dais 6 5A at 120V FM NON 0 99 at 120V AA 5A 250V Power ConsUmPUON 722 2W 3 14A max at 230V MUSTE T 3 14A at 230V OS ee EE 0 99 at 230V THERMAL Maximum ambient temperature 104 40 C CONTROL 8 PROGRAMMING Data NADU EEE tube esc 5 pin amp ground DIN5 female socket
Download Pdf Manuals
Related Search