PDF Flow Manual
Contents
1.2. 6 stream User s Manual TECHNOLOGY MEETS PURITY Stream Flow Plus FP1 A 130317 Stream Drinking Water Systems Thank you for choosing a Stream filtration system It is our commitment to provide our valued customers the very best in water quality and we look forward to serving you for many years Here s how to connect Stream and begin enjoying quality water for less Table of Contents General Information ccccesssseeesseeeeeeee 3 Connecting the A Operation amp Maintenance Sec Drinking Water System c cccssceeesseeees 12 01 Specifications 06 A Adapter Connection B Installation Overview amp Parts B Tubing Connection C Ice Maker Connection D Placing Stream Flow Plus Under the Sink Preparing the HOUSING c ccessseeeesseeeeeees Start up AN USC eecccssseesssteeseseeeessseees 14 02 A Filter Cartridge Installation A Filter Life Below the Sink Installation 00008 Performance Certification c cc0ce 15 03 A Required Tool List B Attaching the Adapters to the Housing C Housing Assembly Installing the Faucet cccessseeeeeeeeeesseeees 8 Performance Data Sheets ccceesssee 16 04 A Drill the Hole or Use Existing Hole 09 A Aesthetic Effects B Mounting the Faucet B Operational Specifications C California Certification Connect to Plumbing c ccccsseeeessseeeeeee
3. The filter is designed to slow and restrict flow when the filter is clogged with contaminants When the flow rate slows it is time to change your filter Allow the water to run through the unit for about 30 minutes Troubleshooting amp FAQs Comments Soft water is good for bathing laundering and may extend the life of hot water heaters and boilers However soft water should not be used for watering plants or lawns You should not use a water softener for drinking water Stream Systems are designed to be used on treated water systems they are not meant to be used where the water is unsafe or with water of unknown quality without first disinfecting the water However systems certified for cyst reduction can be used on water that may contain filterable cysts The carbon block filter may adopt the tastes and odors that it is absorbing You should keep 2 filters on hand When one begins to smell remove it and let it dry upside down on a paper towel Once the sulfur smell dissipates you can reuse the filter Rotating filter cartridges like this will also help extend the life of your filters Just reduce the water pressure at the feed water adapter below the sink You should replace your filters at least every twelve months or when its capacity is reached whichever comes first You can also try turning up the water pressure or turning off other faucets or sprinklers that may be on The black color is from
4. carbon dust and is nothing to worry about Simply flush the system Troubleshooting amp FAQs 21 B Maintenance Problems Flushing Disinfecting the Unit Housing You should not let water sit for more than 10 days without being used If you do the System may need to be flushed or disinfected before you start using it again 1 Make sure the water to the unit is turned off 2 Lessen the water pressure Cif below sink unit by opening the unit faucet 3 Remove and throw out the used filter 4 Rinse out the inside of the unit s housing 5 Add 5 to 7 drops of bleach like Clorox or Purex to the bottom canister 6 Reconnect the housing top and bottom without the replacement filter 7 Turn on the water and let the unit housing fill up with the water bleach solution 8 Let the unit soak for at least 30 minutes a To disinfect the spout remove it and put it in a container with 1 quart of water and 5 drops of bleach Allow this to soak for 30 minutes 9 After the housing has soaked for 30 minutes disassemble the top and bottom and pour out the water bleach solution then rinse out the inside of the housing 10 Replace the filter cartridge 11 Once the new filter is installed follow the instructions to reconnect and flush your unit 22 Troubleshooting amp FAQs Stream believes in improving your water and your life which is why we ve tailored our warranty for you to make your life just a little
5. gt 98 gt 99 gt 97 gt 99 gt 99 8 gt 99 8 gt 99 98 gt 99 4 gt 99 99 gt 99 8 99 95 99 95 98 gt 99 95 gt 99 gt 99 8 gt 99 gt 99 gt 98 95 gt 99 gt 99 gt 99 gt 99 gt 99 99 gt 99 99 99 95 gt 99 gt 99 gt 99 gt 99 95 Influence Challenge Concentration 0 05 107 to 108 fibers L 0 1 0 081 OFS 0 3 0 19 0 078 0 04 10 0 077 0 015 0 300 30 minimum 50 000 ml minimum 50 000 ml 0 110 0 052 0 088 0 083 0 300 0 052 0 08 0 04 0 088 0 083 0 17 0 086 0 08 0 079 0 17 0 044 0 053 minimum 50 000 ml 0 088 0 044 0 19 minimum 50 000 ml Maximum permissible product water concentration 0 001 99 reduction requirement 0 003 0 001 0 015 0 015 0 001 0 0018 0 002 0 001 0 0002 0 015 99 95 99 95 0 0017 0 00002 0 0048 0 001 0 015 0 00002 0 001 0 001 0 0048 0 001 0 0005 0 001 0 001 0 001 0 0002 0 00002 0 00059 99 95 0 001 0 00002 0 001 99 95 Percent reduction reflects actual performance of Stream product as specifically tested at 200 of capacity Percent reduction shown for VOCs reflects the allowable claims for volatile organic chemicals compounds as per tables Chloroform was used as a surrogate for VOC reduction claims the Stream Systems actual reduction rate of chloroform was gt 99 8 as tested 16 Performance Data Sheets HALOACETONITRILES HAN BROMOCHLO
6. gt 99 gt 99 gt 99 gt 99 gt 92 9 99 95 99 gt 99 95 gt 99 gt 99 gt 99 8 98 8 gt 99 gt 99 gt 99 0 022 0 024 0 0096 0 015 0 0072 0 0082 0 025 0 0107 0 044 0 060 0 15 10 0 15 10 0 055 0 006 10 0 006 10 0 050 0 078 0 077 0 015 20 0 01 10 0 081 0 096 0 044 0 080 0 120 0 270 0 15 0 084 0 180 0 081 0 081 0 078 0 015 10 minimum 50 000 ml 0 270 0 042 0 160 0 084 0 150 0 180 0 300 30 11 1 NTU 0 160 0 150 0 070 0 0005 0 0006 0 0002 0 0003 0 0001 0 0003 0 00001 0 0002 0 001 0 000002 0 010 0 010 0 00001 0 002 0 002 0 0001 0 001 0 001 0 005 0 0005 0 001 0 001 0 001 0 001 0 004 0 0016 0 0005 0 0046 0 0010 0 001 0 001 0 001 0 003 99 95 0 0016 0 001 0 0005 0 0046 0 0005 0 0010 0 015 0 5 NTU 0 0005 0 0005 0 001 Note This addresses the U S Environmental Protection Agency USEPA Primary and Secondary Drinking Water Regulations in effect at its time of publication as they relate to Stream s performance in conformance to the industry performance criteria These regulations are continually being updated at the Federal level Accordingly this list of MCLs will be reviewed and amended when appropriate Performance Data Sheets 17 A NSF ANSI 42 AESTHETIC EFFECTS The system has been tested according to NSF ANSI 42 for reduction of the substances listed below The
7. installed the adapters see Section 3B on page 6 B Tubing Connection Be sure to provide sufficient tubing for conveniently changing the filter when it is time to replace it 1 Using wire cutters or a knife cut the tips off of both the blue tube connected to the faucet and the clear tube you previously connected to the plumbing 2 Insert the clear 1 4 plumbing tubing into the small hole in the inlet connector as far as it will go Ultimately this 1 4 tubing should be inserted about 5 8 Then pull to make sure that the tubing is secure Disconnecting the tubing If you ever need to disconnect the tubing for maintenance you should first make sure that the system is depressurized Push the collar against the face of the fitting then you can remove the tubing C Ice Maker Connection Not only can you use your Stream Flow Plus Drinking Water System for quality water at the sink but you can also connect that same unit to your refrigerator for quality ice Here s how Connecting to Your Unit 1 Determine whether or not you have access to your refrigerator from your sink 2 Cut 3 from the end of the blue faucet tubing 3 Insert the tubing still connected to the faucet into the top of the ice maker tee Make sure you insert the tubing all the way even past the point of resistance and then pull to make sure it is secure Ultimately it should be inserted about 5 8 4 Insert one end of the loose blue tubing i
8. ribs under the spot you ve selected b If you have an extra hole in your sink for a spray hose you can disconnect that hose and use its hole for your drinking water faucet O u 2 Make an indentation with the center punch by tapping gently with the hammer on the ceramic porcelain where the hole will be drilled 3 Use the 1 2 carbide tipped masonry drill bit to grind the porcelain down to the metal so that you won t damage the porcelain when drilling 4 Carefully use the 7 16 high speed steel drill bit to completely drill a hole through the metal sink Make sure you don t let the drill bit grab the porcelain Stainless Steel or Metal Surface Here you can simply follow the same first two steps listed above then 1 Use the 1 8 high speed steel drill bit to drill a pilot hole 2 Use the 7 16 high speed steel drill bit to completely drill a hole through the stainless steel sink 8 Installing the Faucet B Mounting the Faucet Small Black Washer Cover Plate Large Black Washer Counter top Plastic Washer Lock Washer Wing Nut lg Blue Tubing 1 Make sure the blue tubing is attached to the faucet 2 From the sink counter top place the following over the faucet hole a The larger soft black rubber washer b The cover plate c The smaller soft black rubber washer d The faucet with blue tubing attached 3 From under the sink slide ove
9. the Owner s Manual for installation and operating procedures 6 In compliance with New York law New York residents should have their water supply tested to determine their actual water treatment needs before purchasing a water treatment system Please compare the capabilities of the Stream unit with your actual water treatment needs 7 While testing was performed under standard laboratory conditions actual performance may vary 8 The list of substances that this device reduces does not necessarily mean that they are present in your tap water B Operational Specifications Model Number Stream Flow Plus FP1 Replacement Filter Type Stream Flow Cartridge FC1 Approximate Filter Capacity 750 gallons Approximate Flow Rate at 60 psi 0 75 gpm Maximum Working Pressure 100 psi 8 8 kg cm Minimum Working Pressure 30 psi 2 1 kg cm Maximum Operating Temperature 100 F 38 C for cold water use only Minimum Operating Temperature 32 F O C for cold water use only 18 Performance Data Sheets C California Certification Department of Public Health California Department of Public Health Certification Number 13 2190 For conditions of use health claims certified by the CA Department of Public Health and replacement parts see Product Data Sheet Owner s Manual State of California Department of Public Health Water Treatment Device Certificate Number 13 2190 Date Issued October 3 2013 Trademark Model Designatio
10. the bracket from the screws by lifting it straight up 4 To install the bracket bands with worm screws first unscrew the worm clamp by turning the screw with a slotted screwdriver counter clockwise until it is fully open 5 Thread each band through the two slots on the bracket there will be one for the top and one for the bottom slot 6 Install the bands around the housing top above the v band Position the slotted end of the band at the mouth of the worm clamp opening Then turn the screw of the worm clamp clockwise as you turn the screw the band will close around the housing top until it is secured tightly Repeat for the second band 7 Attach the bracket and unit to the wall by hanging the bracket on the two screws you installed Step 2 Connect The Drinking Water System 13 Sec 03 Start up and Use 1 Dry off all the plumbing connections and the drinking water unit 2 Make sure all of the connections are tight but not over tight 3 Turn on the shut off valve under your sink where water enters your residence 4 Turn the handle on the shut off valve that you ve installed see Section 5 to turn on the water to your Drinking Water System 5 Turn the operating lever to open the drinking water faucet 6 Let the water run through the unit and faucet for about 10 minutes so that all air can escape 7 Adjust the handle on the shut off valve so that the water flow will be minimal To be precise it shou
11. ROACETONITRILE DIBROMOACETONITRILE DICHLOROACETONITRILE TRICHLOROACETONITRILE HALOKETONES Hk 1 1 DICHLORO 2 PROPANONE 1 1 TRICHLORO 2 PROPANONE HEPTACHLOR HEPTACHLOREPOXIDE HEXACHLOROBUTADIENE Perchlorobutadiene HEXACHLOROCYCLOPENTADIENE LEAD pH 6 5 LEAD pH 8 5 LINDANE MERCURY pH 6 5 MERCURY pH 8 5 METHOXYCHLOR Methylbenzene see TOLUENE Monochlorobenzene see CHLOROBENZENE MTBE methyl tert butyl ether POLYCHLORINATED BIPHENYLS PCB Aroclor 1260 PCE see TETRACHLOROETHYLENE PENTACHLOROPHENOL Perchlorobutadiene see HEXACHLOROBUTADIENE Propylene Dichloride see 1 2 DICHLOROPROPANE SIMAZINE Silvex see 2 4 5 TP STYRENE Vinylbenzene 1 1 1 TCA see 1 1 1 TRICHLOROETHANE TCE see TRICHLOROETHYLENE 1 1 2 2 TETRACHLOROETHANE TETRACHLOROETHYLENE TOLUENE Methylbenzene TOXAPHENE Toxoplasma see CYSTS 2 4 5 TP Silvex TRIBROMOACETIC ACID 1 2 4 TRICHLOROBENZENE 1 1 1 TRICHLOROETHANE 1 1 1 TCA 1 1 2 TRICHLOROETHANE TRICHLOROETHYLENE TCE TRIHALOMETHANES TTHM Chloroform bromoform bromodichloromethane dibromochloromethane TURBIDITY Unsym Trichlorobenzene Vinylbenzene see STYRENE XYLENES TOTAL 98 98 98 98 99 96 gt 99 98 gt 98 gt 99 gt 99 3 gt 99 3 gt 99 96 6 96 8 gt 99 gt 99 gt 99 96 6 97 2 gt 99 gt 99 gt 98 gt 99 gt 97 99 gt 99 95
12. ated capacity is reached Cc the flow rate diminishes or d the filter becomes saturated with bad tastes and odors The rated capacity of the filter cartridges is shown above 3 This system is not intended to be used where the water is microbiologically unsafe or with water of unknown quality without adequate disinfection before or after the unit Systems certified for cyst reduction may be used on disinfected waters that may contain filterable cysts 4 Do not allow water to freeze in the unit If unit is exposed to freezing temperatures drain water from unit and remove filter 5 Do not allow water to sit in unit for extended periods of time 10 or more days without being used If unit is to be left unused for more than 10 days drain all water from the system and remove the filter Upon your return reconnect the filter in the housing and continue use In the event water does sit in the unit for 10 or more days the system should be flushed by allowing water to flow to waste for about 3 minutes then continue use as normal 6 To dispose of the used filter remove it from the housing and place the old filter in your normal refuse General Information 3 B Installation Overview amp Parts Faucet Assembly with blue tubing attached Wing Nut Blue Tubing connects outlet adapter to plumbing Clear Tubing connects inlet adapter to plumbing Inlet and Outlet Adapters Housing Top Black Rubber Cushio
13. bit easier Stream will repair or replace any System at absolutely no charge baring the transportation to Stream headquarters during the warranty period On top of that all exterior hoses and attachments to the System are warranted for defects in material and workmanship for one year and your Drinking Water System Housing is warranted for a lifetime while you re changing the filter once a year That s a lifetime of clean water The Stream solid carbon block filters are warranted for defects in material and workmanship under normal care Unless it is expressly stated above Stream Corporation makes no warranties expressed or implied arising by law or otherwise This includes the implied warranties of merchantability and fitness for a particular purpose to any person This limited warranty may not be changed or extended unless it is expressly executed by Stream Corporation The repair or replacement as provided under this limited warranty is exclusive In no event will Stream Corporation be liable for any consequential or incidental damages to any person including in cases of manufacturer negligence This includes without limitation damages of loss of use cost of substitution property damage or other monetary loss The warranty is only valid if the Drinking Water System is operated within conditions listed herein Stream Laboratories Inc 2520 Shell Road Ste B Georgetown TX 78628 Phone 888 615 5733 StreamFilters com
14. concentration of the indicated substances in water entering the system was reduced to a concentration less than or equal to the permissible limit for water leaving the system as specified in NSF ANSI 42 CHLORAMINE as Aesthetic Effect As Monochloramine gt 97 3 0 mg L 10 0 5 mg L CHLORINE as Aesthetic Effect gt 97 2 0 mg L 10 gt or 75 PARTICULATE Normal Particulate Reduction Class Class gt 99 At Least 10 000 gt or 85 Particles 0 5 TO lt 1 UM particles mL 1 Stream Drinking Water Systems have been certified by NSF International for compliance to NSF ANSI Standard Nos 42 and 53 Stream Drinking Water Systems have been certified by the State of California Department of Public Health for the reduction of specific contaminants listed herein 2 Chloroform was used as a substitute for claims of reduction of VOCs where the Stream System s actual reduction rate of chloroform was greater than 99 8 when tested at 200 capacity 3 Do not use with water that is microbiologically unsafe or of unknown quality without adequate disinfection before or after the system Systems certified for cyst reduction may be used on disinfected waters that may contain filterable cysts 4 Stream s housing is warranted for a lifetime Cwith annual cleaning all exterior hoses and attachments to the System are warranted for one year Please see the owner s manual for complete product guarantee and warranty information 5 Please see
15. dapt a Valve Installation e 8 Adjustable wrench e Wire cutter or knife B Attaching the Adapters to the Housing Stream Flow Plus models are shipped with all of the adapters and connectors needed for the filter system Here is how to connect them to the housing top To Connect Straight Adapters 1 Connect the 1 4 outlet adapter to the outlet opening on the housing by turning it clockwise You can tighten it by hand and then give it one to two more turns with a wrench 2 Connect the 1 4 inlet adapter to the inlet opening on the housing by turning it clockwise Again tighten it by hand and then with a wrench 6 Below the Sink Installation C Housing Assembly Inlet Connector B Outlet Connector k M Q Below Sink Installation Includes E Housing Top ra Rubber Cushion iy on i Ka V Band a Stainless Steel Faucet with blue tubing attached b 1 4 Inlet and Outlet Connector Filter Jit O Ring Adapt a Valve Assembly Wall Bracket Housing Bottom a Adapt a Valve b Threading Adapter Acrylic Sleeve Faucet is not included as part of the NSF Unit Certification Below the Sink Installation 7 Sec 04 Installing the Faucet A Drill the Hole or Use Existing Hole Porcelain or Ceramic Surface 1 Choose and then mark the spot you d like to mount the faucet on your sink top a Make sure there aren t any reinforcing
16. enol 2 4 5 TP silvex Performance Certification 15 Performance Data Sheets MODEL FP1 Stream Drinking Water Systems have been tested according to NSF ANSI Standard No 53 for reduction of the substances listed below The concentration of the indicated substances in water entering the system was reduced to a concentration less than or equal to the permissible limit for water leaving the system as specified in NSF ANSI 53 Health Effects ALACHLOR ASBESTOS ATRAZINE BENZENE BROMODICHLOROMETHANE TTHM BROMOFORM TTHM CARBOFURAN Furadan CARBON TETRACHLORIDE CHLORDANE CHLOROBENZENE Monochlorobenzene CHLOROPICRIN CHLOROFORM TTHM surrogate chemical Cryptosporidium CYST CYST Giardia Cryptospordium Entamoeba Toxoplasma 2 4 D DBCP see Dibromochloropropane 1 2 DCA see 1 2 DICHLOROETHANE 1 1 DCE see 1 1 DICHLOROETHYLENE DIBROMOCHLOROMETHANE TTHM Chlorodibromomrthane DIBROMOCHLOROPROPANE DBCP o DICHLOROBENZENE 1 2 Dichlorobenzene p DICHLOROBENZENE para Dichlorobenzene 1 2 DICHLOROETHANE 1 2 DCA 1 1 DICHLOROETHYLENE 1 2 DCE CIS 1 2 DICHLOROETHYLENE TRANS 1 2 DICHLOROETHYLENE 1 2 DICHLOROPROPANE Propylene Dichloride CIS 1 3 DICHLOROPROPYLENE DINOSEB EDB see ETHYLENE DIBROMIDE ENDRIN Entamoeba see CYSTS ETHYLBENZENE ETHYLENE DIBROMIDE EDB Furadan see CARBOFURAN Giardia Lamblia see CYST Percent Reduction
17. hrough tiny pores of carbon This reduces a wide range of hazardous contaminants as well as tastes and odors not typically removed by loose granular systems Comments Filter life will vary depending on the amount of water used and the amount of impurities in the water N A Mineral components expressed as acidity and alkalinity determines the pH Neutrality is 7 below 7 is acidity and above 7 is alkalinity N A To connect a single Drinking Water System to both your sink and refrigerator request an ice maker tee from your dealer If your water source might be contaminated it should be disinfected before use Add 1 4 tsp of household bleach per gallon of water the Stream System will remove this solution from the water Hand pump kits are available from Stream Natural minerals are good for you in normal quantities and so when you see them in your drinking water don t be alarmed The materials used in Stream Drinking Water Systems are specially designed to react with chemicals in the water but not with natural minerals that are actually good for you The Stream System contains a triple filter The outside material is a pre filter that helps protect the solid carbon block surface from clogging with large sediment The Water Quality Association reports that an activated carbon filter can reduce organics and solid particles as well as offensive tastes and odors Only pre coat and solid carbon b
18. ld not exceed 1 0 gpm It takes about 15 seconds to fill a quart at 1 0 gallon per minute 8 Close the drinking water faucet and check for leaks a Check the v band to confirm that it is secured evenly around the housing top and bottom b Hand tighten the black knob on the v band until it is as tight as possible 9 Let the water run through the unit for about 30 minutes to flush any loose carbon fines 10 Shut off the water and check for leaks The Stream Flow Plus Drinking Water System is now ready for use You can enjoy having great tasting high quality water for drinking cooking beverages food preparation and more A Filter Life Filter life will vary depending on the amount of water used and the amount of impurities being processed in your water If your Stream Flow Plus clogs it may be because it is protecting you from the contaminants and physical matter in your drinking water If this happens see Section I A Operation and Maintenance Specifications For the best performance possible and to maintain your warranty you should replace your filter when the first of the following occurs a annually b when you ve reached the unit s rated capacity c the flow rate slows or lessens or d the filter starts to taste or smell bad 14 Start Up and Use Performance Certification MODEL FP1 Stream Drinking Water Systems Product Performance Tested and Certified Stream Drinking Water System Tested and Certified b
19. lock filters are designed to provide 0 5 micron mechanical filtration with efficient adsorption on very fine sized activated carbon particles Question What is the difference between a water softener and the Stream Drinking Water System Can the Stream System be used on untreated water What should I do if my water starts to smell or taste bad What does it mean if my water starts to smell like rotten eggs What does it mean if there is a milky color in my water What do do if the flow rate is too slow What should I do if my water is black Answer Softeners are not used to treat drinking water they are used only to change the water s hardness They put sodium into the water in exchange for magnesium or calcium ions Stream Drinking Water Systems don t remove dissolved minerals so the pH is not changed If the water source is questionable you should disinfect it before use Just add 1 2 tsp of bleach per gallon of water then the Stream System will remove this solution from the water Ask your nearest public water utility for assistance or guidelines on the proper treatment of untreated water Change your filter This is typically a sign of hydrogen sulfide gas which is not uncommon and can occur at any time This milky color is actually just small bubbles caused by a higher than normal water pressure flowing through the system This won t affect the performance of the System
20. n Stream Flow FL Stream Flow Plus FPL Inorganid Ra 4 f tb Uf 1 A v Wea J Alachlor Se A Atrazine tyre Benzene Carbofuran Carbon Tetrachloride Chlorobenzene Chloropicrin 2 4 D DBCP o Dichlorobenzene p Dichlorobenzene 1 2 Dichloroethane 1 1 Dichloroethylene cis 1 2 Dichloroethylene trans 1 2 Dichloroethylene Lindave 1 2 Dichloropropane Methoxychlor cis 1 3 Dichloropropylene MTBE Shisrodibromomethane Dinoseb Pentachlorophenol Xylenes Rated Service Capacity 750 gallons Rated Service Flow 0 75 gpm Conditions of Certification Do not use where water is microbiologically unsafe or with water of unknown quality except that systems for cyst reduction may be used on disinfected waters that contain filterable cysts Stream Laboratories Inc 2520 Shell Road Ste B Georgetown TX 78628 Phone 888 615 5733 StreamFilters com Performance Data Sheets 19 Sec Troubleshooting amp FAQs A Troubleshooting amp FAQs Question When should replace my filter cartridge Where do get a replacement filter Will low pH or acidic water affect the Stream filter Does de ionized water or soft water af fect Stream water Can the Stream Flow Plus System be connected to an automatic ice maker Can the Stream Flow Plus System be used during an emergency or when the water is turned off What causes white particles to appear in Stream water when it is frozen or boiled Wh
21. n inside housing top Carbon Block Filter V band Knob V band O ring Wall Bracket Housing Bottom Acrylic Sleeve SBGBBOOOdDOOO6OO0900O OX O Stream Drinking Water Systems have been tested and certified so you know that they will perform at the highest level possible Please read this manual before installing your Stream Flow Plus System as installation operation and maintenance will aid in your System s performance Not following these instructions carefully could lead to product failure or possible damage If you need help or assistance contact us at StreamFilters com or 888 615 5733 Faucet is not included as part of the NSF Unit Certification 4 General Information Preparing the Housing Please prepare the housing as outlined in this section before moving on to Section 3 Be sure to gather all all recommended tools for the Stream Flow Plus below the sink installation before you begin A Filter Cartridge Installation S urn to connect T Bottom The filter cartridge is shipped outside of the unit housing in most cases to protect your filter and drinking water system from damage during shipping Be sure to insert the filter cartridge into the drinking water system housing before proceeding with the installation First remove the plastic wrapper and instruction
22. nding on your plumbing 3 With your wrench connect the Adapta a Valve to the pipe where you removed the slip joint nut Make sure the rubber washer is in place and then turn it clockwise until it is tight but not over tight 4 Connect the plumbing supply line to the Adapta a Valve with the slip joint nut If necessary you can trim the supply line before connecting to make sure the supply line doesn t block the shut off valve on the side 5 Connect your 1 4 clear plastic tubing to the Adapta a Valve by inserting the tubing as far as it will go through the same small hole in the adapter that you attached to the shut off valve a Cut square cut the tip ends off the tubing using a sharp knife Do not use scissors b Push the tubing through the small hole in the valve until you feel resistance at this point the tubing is still not fully inserted so you ll need to push firmly until the tubing is inserted as far as it will go Ultimately the 1 4 clear tubing should be inserted about 5 8 6 Make sure that the unit shut off valve attached to the Adapta a Valve is off by turning the handle clockwise until it stops Connect to Plumbing 11 Sec Connect The Drinking Water System Now that you have installed the filter adapters and faucet and connected the device to the plumbing you are ready to complete the installation of your Stream Flow Plus Drinking Water System A Adapter Connection If you have not already
23. nto the bottom port of the 1 icemaker tee Again make sure you insert the tubing all the way Jt even past the point of resistance and then pull to make sure it is Ls secure Ultimately it should be inserted about 5 8 5 Connect the other end of the blue tubing to the outlet connector 6 Connect a separate 1 4 poly tube available through your dealer or a plumbing supplier to the side port of the tee Make sure you have enough tubing to reach your refrigerator and service unit 12 Connect The Drinking Water System D Placing Stream Flow Plus Under the Sink You can either set your Stream Flow Plus System on the cabinet floor or mount the unit on the cabinet wall with the bracket included in your kit If you do mount the unit on the cabinet wall make sure it can support the unit s weight about 7 5 with a dry filter and even more with a wet filter Either way be sure to provide enough tubing to conveniently change the filter when you need to 1 Make sure you ll have enough room to remove the stainless steel housing from the bracket to change the filter in the future before beginning installation 2 Position the bracket so that you will be able to get to it when needed Hold the bracket in place and then fasten it there with only the top screws Don t fasten the screws tight against the bracket leave enough space to hang and later remove the bracket from the screws 3 Remove
24. r the blue tubing a The hard black plastic washer with the small side up b The lock washer c The wing nut 4 Hand tighten the wing nut to secure the faucet Using vice grips secure the wing nut and faucet below the sink Faucet is not included as part of the NSF Unit Certification Installing the Faucet 9 The Adapt a Valve assembly includes an Adapt a Valve and adapter NOTE When attaching the Adapt a Valve to straight pipe threads use Teflon tape on the threads Wrap the tape around the pipe only once Before Included Water supply line before installation After Choose the configuration 3 8 or 1 2 that fits your plumbing A Use the 3 8 configuration on a water supply line with a 3 8 slip joint Water supply line with Adapt a Valve in 3 8 configuration 10 Connect to Plumbing B Use the 1 2 configuration if you have a water supply line that either does not have a slip joint nut or has a 1 2 slip joint nut at the angle stop valve i i Water supply line with Adapt a Valve in 1 2 configuration Install on the cold water line only 1 Turn the angle stop valve completely off to turn off the cold water supply 2 Turn the slip joint nut counter clockwise with an 8 adjustable wrench to disconnect the cold water supply line This will either be located at the angle stop valve or at your faucet pipe depe
25. s 10 Sec Sec Troubleshooting amp FAQS uses 20 10 05 A Troubleshooting amp FAQs B Maintenance Problems Stream Laboratories Inc 2520 Shell Road Ste B Georgetown TX 78628 Phone 888 615 5733 StreamFilters com 2 Table of Contents General Information A Operation amp Maintenance Specifications Model Number Replacement Filter Type Housing Composition Rubber Items Approximate Filter Capacity Approximate Flow Rate at 60 psi Maximum Working Pressure Minimum Working Pressure Maximum Operating Temperature Minimum Operating Temperature Inlet Outlet Particle Retention Size Certified by Stream Flow Plus FP1 Stream Flow Plus Cartridge Part FC1 Stainless Steel Nitrile 750 gallons 0 75 gom 100 psi 8 8 kg cm 30 psi 2 1 kg cm 100 F 38 C for cold water use only 32 F O C for cold water use only 1 4 NPTF x 1 4 tube 1 4 NPTF x 1 4 tube sub micron 0 5 micron NSF International CA Dept of Public Health Cert 13 2190 1 The Stream Flow Plus Drinking Water System is installed below the sink and connects to a separate faucet included in the installation materials 2 Replacement filters can be purchased at StreamFilters com Filter life will vary in proportion to the amount of water used and the level of impurities in the water being processed Replace the filter cartridge when the first of the following occurs a annually b when the system s r
26. wrap from around the filter 1 With the housing positioned upright open the unit by unscrewing the black knob on the locking v band Spread it apart and remove the v band 2 Separate the unit leaving the black rubber o ring in place on the housing 3 Screw the new filter cartridge in the housing top turning it until firm Filter needs to make 4 5 complete revolutions in order to ensure a firm seal Be sure that the filter has been screwed in straight DO NOT OVER TIGHTEN 4 Reconnect the housing top with bottom and replace locking v band replace black knob and turn until tight Be sure that the locking v band is fastened tightly by a Checking the v band to confirm that it is secured evenly around the housing top and bottom b Hand tightening the black knob on the v band until it is as tight as possible Preparing the Housing 5 Below the Sink Installation A Required Tool List The following tools are required to install Stream Flow Plus Drinking Water System below the sink Installation of Faucet Spigot Installation of Faucet Spigot Stainless Steel Sink Ceramic Porcelain Sink e 3 8 Reversible electric drill e 3 8 Reversible electric drill 7 16 High speed steel drill bit 7 16 High speed steel drill bit e Hammer e Hammer e Center punch e Center punch e 8 Adjustable wrench 8 Adjustable wrench e Pliers or vise grips e Pliers or vise grips e 1 8 High speed drill bit A
27. y NSF International to NSF ANSI Standards 42 and 53 for the reduction of claims specified below Standard 42 Aesthetic Effects Standard 53 Health Effects e Chloramine e Asbestos e Chlorine taste and odor e Chlordane e Nominal Particulate Reduction e Cyst Class e Lead e Mercury e MTBE e PCB e Toxaphene e Turbidity e VOC listed below Volatile Organic Chemicals VOC include Disinfection By Products e chloropicrin e carbofuran e benzene e haloacetonitriles HAN dibromochloropropane DBCP e carbon tetrachloride bromochloroacetonitrile e o dichlorobenzene e chlorobenzene dibromoacetonitrile p dichlorobenzene e 1 2 dichloroethane dichloroacetonitrile e endrin e 1 1 dichloroethylene trichloroacetonitrile e ethylene dibromide EDB e cis 1 2 dichloroethylene e haloketones HK e heptachlor e 1 2 dichloropropane 1 1 dichloro 2 Propanone e heptachlor epoxide e cis 1 3 dichloropropylene 1 1 trichloro 2 Propanone e lindane e ethylbenzene e trihalomethanes THMs TTHMs e methoxychlor e hexachlorobutadiene bromodichloromethane e hexachlorocyclopentadiene bromoform e simazine chloroform e styrene dibromochloromethane 1 1 2 2 tetrachloroethane e tribromoacetic acid e tetrachloroethylene e toluene e alachlor e trans 1 2 dichloroethylene e atrazine e 1 2 4 trichlorobenzene z 2 4 D 1 1 1 trichloroethane e dinoseb e 1 1 2 trichloroethane e trichloroethylene e xylenes total pentachloroph
28. y does the Stream System reduce volatile organic compounds but not natural minerals Should remove sediment with a standard filter before using Stream Why is the compressed activated carbon block filtration system more efficient than loose granular systems 20 Troubleshooting amp FAQs Answer You should replace your filter annually or when the capacity is reached whichever occurs first for rated capacity see Section 1A You can order replacement filters from your local water treatment dealer No No Yes the below sink models can be connected to your sink refrigerator and or any kind of water dispenser or ice maker Yes you can hand pump or siphon water through the Stream System during an emergency But remember the Stream System isn t meant to be used where the water is microbiologically unsafe or with water of unknown quality When water is frozen the natural minerals solidify and they can appear as white flakes or specks when the ice melts Minerals are totally dissolved in the solution and do not have an actual physical size and so the minerals pass through the filter unchanged If you are in an area with excessive sedimentation in the water pre filtering can help extend the life and efficiency of your Stream cartridge but in most areas this is not necessary Stream s solid carbon block filters are compacted into a dense structure so that every molecule of water will be forced t
Download Pdf Manuals
Related Search