Home

USER MANUAL & CARE GUIDE - Kokomo

1. TOTAL BTU 60 000 BTU PRIMARY IGNITION SURE LIGHT IGNITION SECONDARY IGNITION FLASH TUBE COOKING GRIDE 920 SQ IN ei EUN INCLUDES WORMING RACK SEARING BRIQUETTE FLAME TAMER SYSTEM ROTISSERIE KIT MOTOR amp FORKS 5 STAINLESS PIPE BURNERS ALL GRILLS ARE SHIPPED LP EACH SHIPMENT E CONTAINS NG CONVERSION KIT LIFETIME LIMITED WARRANTY KOKOMO GRILLS HAVE A LIFETIME LIMITED WARRANTY ON GRILL HOUSING AND HOOD AGAINST MANUFACTURE DEFECTS AND WARRANTY WORKMANSHIP 10 YEAR LIMITED WARRANTY ON BURNERS AND GRATES 2 YEARS ON ALL OTHER PARTS 30 DAYS ON ALL GRILL ACCESSORIES KoKoMo quio PG3 Installation Method for Propane Vented on BOTH SIDES _ 9f Island E gt MN Se SOE x QUA y 7 NS ioe te 7 T mn ENS Stainless Naj E de SRM 3 E 2 i tt po V d a i Flexline Pc Pn Ner Se ie wet 9 pd M JE os pue fl rre O iid CSA Approved d 7 Rubber Gas Hose CAN 2 Non combustible Construction Connection Method for Dual Side Burner When connectin Installation Method for Natural Gas Natural Gas Regulator IMPORTANT Regulator must be on the Barbecue or your warranty is void CSA Approved e i Yellow Teflon Pipe Thread Sealant is recommended f
2. KoKoMo Guill USER MANUAL amp CARE GUIDE Gas Grill Model KO BAK3BG LP NG KO BAKABG LP NG KO BAKSBG LP NG DANGER IF YOU SMELL GAS 1 Shut off the gas supply to the appliance at its source 2 Extinguish any open flames 3 Open grill hood to release any accumulation of gas vapor 4 If a gas odor persists Keep away from your appliance and contact your gas supplier or fire department immediately ATTENTION CONSUMER Side Burner Model 1 LP NG KO BAK2BG LP NG WARNING Do not store or use gasoline or other flammable liquids or vapor in the vicinity of this or any other appliance A LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliances PLEASE READ amp RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE AND BEFORE INSTALLING OR OPERATING Kokomo Grills Outdoor Products USA Nationwide Help Desk www kokomogrills com THIS MANUAL APPLIES TO THE FOLLOWING KOKOMO GRILLS amp SIDE BURNERS Kokomo Grills Outdoor Products Instructional Book Version 2 8 PG1 KoKoMo qui MODEL KO BAK3BG LP NG MODEL KO BAK4BG LP NG 3 BURNER KOKOMO GRILL 4 BURNER GRILL U CUTOUT CUTOUT LODE I KOS W 23 1 2 H 7 5 8 D 20 1 4 W 30 7 8 7 5 8 D 20 1 4 BTU OUTPUT UM OUTPUT 12 000 PER BURNER X4 INFERRED BACK INFERRED BACK BURNER NONE BURNER 12 000 BTU PER BURNER X1 TOTAL BTU 36 000 T
3. PG 12 KoKoMo quio Safety and Installation Warnings Please read all instructions before installing or operating your gas grill to prevent injury and appliance damage Before installation or service disconnect the power supply to the work area by removing the fuse tripping the circuit breaker or unplugging the unit gas grills will get hot during use Use extreme caution when operating the grill Do not touch hot surfaces Always use the handle to open or close the grill Close supervision is necessary when this or any appliance is used near children Keep children away from the grill during operation and until the grill has cooled off Do not store any LP cylinder or tank not connected for use with the grill in the area of this grill or any other appliance Never store an LP cylinder or tank indoors or within the reach of children Keep any electrical supply cord and fuel supply hose away from any heated surfaces sharp edges and dripping grease Be certain your appliance is properly installed and grounded by a qualified technician in accordance with applicable codes To guarantee the electrical safety of this appliance continuity must exist between the appliance and an effective grounding system It is imperative that this basic safety requirement be met The manufacturer cannot be held responsible for damages caused by the lack or inadequacy of an effective grounding system Do not twist the gas supply hose Before
4. over the countertop or tabletop where it can be pulled or tripped over unintentionally Outdoor extension cords should be used with products suited for outdoor use They are surface marked with suffix letters W or W A and with a tag stating Suitable for Use with Outdoor Appliances To protect against electrical shock the power cord and plug should be kept dry and off of the ground Do not clean this product with water spray do not spray cleaners into the lamp socket area Do not operate any appliance with a damaged power cord or power plug and do not operate any appliance after the appliance malfunctions or has been damaged in any manner If this should occur return the appliance to the nearest authorized service facility for examination repair or adjustment Be certain your appliance 1s properly installed and grounded by a qualified technician in accordance with applicable codes To guarantee the electrical safety of this appliance continuity must exist between the appliance and an effective grounding system It is imperative that this basic safety requirement be met The manufacturer cannot be held responsible for damages caused by the lack of or inadequacy of an effective grounding system This appliance conforms to all uniform electrical safety codes and electrical grounding regulations Install unit according to I A W local codes or with National Electrical Code ANSI NFPA 70 or CSA C22 1 in their absence General Safety and Care
5. G Unit The grill is not getting any gas Check the line There is a chance that there is foam at the entrance of your gas line located in the back right corner of the grill It might have a fouled regulator There might be a gas leak plugging your regulator for safety The grill is not getting hot enough Regulator might be restricting too much gas The flame is low Valve might need replacing Regulator might be restricting too much gas Fire is coming out of the front of the grill by the knobs Burners either need to be cleaned or there is something disturbing the flow of the gas making the gas travel back towards the valve and with the ignition igniting the gas you are getting fire right by the knobs They can smell gas when the grill is off Check all connections to the grill if there are no leaks then there is a chance that there is actually a leak right underneath the grill To check it is easy get in front of the grill and look at the valves from underneath There is one screw that holds each valve into place Tighten each one snuggly this should be the solution The burners will light with a match only 99 of the time Valves need to be replaced the ignitions system has failed PG 27 KoKoMo quio BBQ Parts Warranty Order BAKBG Staines Seel Bumer BAKABG 009 Rotisserie Spit Bracket PG 28 KoKoMo quib
6. each use visually inspect the gas supply hose for cracks cuts or excessive wear Replace the hose if necessary Never test the grill for gas leaks using a lighted match or any other open flame see leak test procedures using soap water solutions included in following pages of this manual The use of accessories regulators or components not recommended by the appliance manufacturer may cause injuries and will void warranty Never light the grill with the hood closed and be certain that the burners are positioned and seated over the gas valves and on the burner support Never lean over the cooking surface when lighting or operating the grill Use barbecue tools with wood handles and insulated oven mitts when operating the grill Gas Specifications Be sure that the gas supplied to the grill conforms to the model you purchased A Natural Gas grill requires natural gas to operate an LP grill requires liquid propane gas to operate Check the rating label on the left hand side of the unit RATING PLATE LOCATION PG 13 KoKoMo quio Never connect the appliance to an unregulated gas supply line Grills operated without a regulator are unsafe and will not be serviced until installed properly and safely Unsafe operation without a gas regulator will void warranty of the grill Grills operated with NG natural gas gas must be installed with the NG regulator supplied with the unit and set to 4 0 water column pressure Grills opera
7. leave the grill unattended while in use e Do not use water on grease fires A violent steam explosion may result Instead smother the fire with a dry chemical or foam fire extinguisher Unit Installation Your Kokomo Grill comes pre assembled and requires very little setup We do however recommend the use of professional help during the installation of your unit as improper installation may affect your warranty Remove the unit from the box along with all accessories and check that no damage has occurred to the unit or any parts Burners Check the burner tubes and remove any obstructions that may be in the ports or holes Using cold water and a brush will be sufficient Make sure all foreign particles are removed from the burner before use Make sure the air shutter on the burners is slightly opened to about 1 8 for NG and 1 4 for LP N WARNING For proper operation burners must be aligned with the valve orifice and seated in the bracket slot This is accomplished by first placing the burner tube shutter hole securely over the valve orifice and then secure with the cotter pin at the rear of the barbecue PG 21 KoKoMo quio Locating the Product Serial Number The serial number for your KOKOMO appliance 1s located on the left hand side of the Firebox You will need this number to properly register your grill and activate coverage Write this information in the space provided below for your records Barbecue model Bar
8. orifice change out is the same for both gases You must remove all cooking grills and flame tamers to expose the main burners in the grill On the bottom rear of each burner 1 a screw Remove screw To remove burner slide burner to the rear of the grill and upward Repeat for each burner Where the burner was previously located connecting to the main valve through the hole in the basin should now be evacuated space Inside the space you will find the end of the valve toward the front of the erill with an orifice brass fitting screwed into the end of the valve stem Carefully remove the orifice with a 7mm socket set and extension These are extremely fragile When unscrewing be extremely gentle for you could easily break the brass fitting and have to replace the valve Once the orifice is removed replace it with the new change out orifice repeat for all burners When re installing orifice do not over tighten or you will strip the brass fitting Little pressure is needed Replace burners and test for proper flame height Flame should stand between 1 tall on LOW and 1 5 2 on HIGH To adjust the LOW flame setting simply light the grill on the LOW setting and adjust the screw which 15 located under the knob on the front of the valve PG 25 KoKoMo quio Warranty What follows is a simple and general outline of the warranty for our gas grills Please refer to your specific product owner s manual to confirm
9. repair or replacement Warranty Claim Procedure If you require service or parts for your KoKoMo Grill please contact our website to use the help desk Our hours of operation are 6AM to 2 30PM MST Please direct all correspondence to www kokomogrills com ATTN Service Desk Product repair as provided under this warranty is your exclusive remedy KoKoMo Grills shall not be liable for any incidental or consequential damages for breach of any express or implied warranty on its products Except to the extent prohibited by applicable law any implied warranty or merchantability or fitness for a particular purpose on this product to the duration of the above warranty Some states do not allow the exclusion or limitation of incidental or consequential damages or allow limitations on how long an implied warranty lasts so the above limitations or exclusions may not apply to you This warranty gives you specific legal rights and you may have other rights which vary from state to state PG 26 KoKoMo quio Here is a list of our most frequently asked questions If there is something you need help with and it is not listed below please visit our help desk www kokomogrills com How do you hook up the side burner Note Use Teflon tape on all threaded connections 1 Connect a short double ended 3 8 female flare gas line to the back of the BBQ 2 Then connect a 3 8 Flare T Fitting to the gas line 3 From that connection you will have two rema
10. your specific warranty details Limited Warranty Grills KoKoMo Grills warrants to the original purchaser of the Outdoor Gas Grill that when subject to normal residential use it 15 free from defects in workmanship and materials for the periods specified below This warranty excludes grills used in rental or commercial applications It does not apply to rust corrosion oxidation or discoloration which may occur due to moisture or overheating It does not cover labor or labor related charges There will be shipping and handling charge for the delivery of the warranty part s The warranty is only valid at the original site of delivery with proof of purchase of item s Component Warranty Period Welded Stainless Steel amp Tube Bar Burner 10 Years Stainless Steel Flame Tamer Grates 10 Years Grills Gas Valves 2 Years Igniter system and others 2 Years Stainless Steel Frame Housing Lifetime Under this warranty our obligation is limited to repair or replacement at our discretion of the product during the warranty period The extent of any liability of KoKoMo Grills under this warranty is limited to repair or replacement This warranty does not cover normal wear of parts damage resulting from any of the following negligent use or misuse of the product use of improper fuel gas supply use contrary to operating instructions or alteration by any person other than our factory service center The warranty period is not extended by such
11. 53042 9 seyenbuq SUEY 10 pexy SNS Gi 19 05 uid Buug 2 XoqaJy JO seAjeus epis YIO 2 ejpueu poou i pe joued yea 40 YORI 3oeq e p c e Joney ie joued xoeq O Q 10 00 oU YI dij yoeq e 499 4 epis ejgonp jeas ssojuiejs Ge we NES JeujJeAooxoeq y 7 N i a d epe onoueud Wy joued yoeg ejquiesse 99 X 3 A 49 03 289 XOq9Jl 9 ozoq H eouejeq 1ejunoo qe lt yor 1 A 2 i 7m 65 ud in m Jaysem Aaya o xoeuJ J0jouu t E y Go Nx k JO seAjeus epis Z 2 poou 6 Jeyoo 9 4 N wejsqunu d 440 OY i jojow Wy ONOMO p PG 7 KOKOMO KO BAKIBG LP NG KO BAK2BG LP NG SIGLE SIDE BURNER DOUBLE SIDE BURNER p O Cutout W 11 1 2 H 0 D 15 Cutout W 11 H 6 3 4 D 20 Total BTU 12 000B TU 1Bnr Total BTU 24 000BTU 2Bnr FOE EE NEN Number of 1 Number of 2 mes mme Aluminum amp Brass Aluminum amp Brass SURE LIGHT SURE LIGHT L e Aluminum amp Brass Aluminum amp Brass SURE LIGHT SURE LIGHT Gas Type Burners are shipped LP Gas Type Burners are shippe
12. GAS FLOW OBSTRUCTION WHICH COULD RESULT IN A FIRE IN AND AROUND THE BURNER TUBES THIS TYPE OF FIRE IS KNOWN AS FLASH BACK IT IS THE MOST COMMON CAUSE AND FREQUENT INSPECTION AND CLEANING OF THE BURNER TUBES IS NECESSARY Checking for Gas Leaks Perform a leak test at least once a year whether the gas supply cylinder has been disconnected or not In addition whenever the gas cylinder 1 connected to the regulator or whenever any part of the gas system 1s disconnected or replaced perform a leak test As a safety precaution remember to always leak test your grill outdoors in a well ventilated area Never smoke or permit sources of ignition in the area while doing a leak test Do not use a flame such as a lighted match to test for leaks Use a solution of soapy water 1 2 3 4 5 6 Prepare a leak testing solution of soapy water by mixing in a spray bottle one part liquid soap to one part water Make sure all the control knobs are in the OFF position Turn on the gas On Natural Gas systems turn the main feed valve to the grill On LP systems turn the cylinder valve knob counter clockwise one turn to open Apply the leak testing solution by spraying it on joints of the gas delivery system a Bubbles in the soap solution indicate that a leak 1s present Stop a leak by tightening the loose joint or by replacing the faulty part with a replacement part recommended by the manufacturer Do not attempt to repair the cylinde
13. NOTE The manufacturer cannot be held responsible for damage or injury caused by improper use of this appliance e Gasoline lighter fluid or other flammable liquids and vapors should never be stored in the area of this grill or any other appliance e Do not store anything in the grill Make sure food is not forgotten in the grill forgotten items could melt or catch fire when the appliance is turned on e To prevent injuries do not use accessories that are not recommended by the manufacturer e Before cleaning the appliance disconnect the rotisserie and trip the circuit breaker e Never use the grill in windy conditions If located in a consistently windy area oceanfront mountaintop etc a wind break will be required Winds blowing into or across the back hood gap can cause poor performance and or cause the control panel to get dangerously hot PG 20 KoKoMo quio e Always open the grill hood carefully using only the handle the hood may be hot e Children should not be left alone or unattended in an area where any appliance is in use They should never be allowed to touch sit or stand on any part of the appliance e Do not store items of interest to children in cabinets above the grill or in the grill Children climbing on the appliance to reach these items could be seriously injured e Wear proper clothing when operating appliances Loose fitting or hanging garments should never be worn while using the grill e Do not
14. OTAL BTU 60 000 BTU PRIMARY PRIMARY ICNITION SURE LIGHT IGNITION Co SURE LIGHT IGNITION SECONDARY SECONDARY CATION FLASH TUBE a FLASH TUBE COOKING GRIDE COOKING GRIDE ONE 22 1 2 X 18 1 4 DIMPNSIONS 30 1 4 X 18 1 4 560 SQ IN TOTAL COOKING TOTAL COOKING 740 SQ IN AREA N PARAAN AREA INCLUDES WARMING RACK SEARING BRIQUETTE SEARING BRIQUETTE FLAME TAMER SYSTEM FLAME TAMER SYSTEM ROTISSERIE KIT S OPTIONAL UPGRADE MOTOR amp OPTIONAL UPGRADE MOTOR amp FORKS FORKS 3 STAINLESS PIPE BURNER BURNERS BURNER 4 STAINLESS PIPE BURNERS E ALL GRILLS ARE SHIPPED LP GAS TYPE GAS TYPE EACH SHIPMENT CONTAINS CONVERSION KIT CONVERSION KIT LIFETIME LIMITED LIFETIME LIMITED WARRANTY WARRANTY KOKOMO GRILLS HAVE A KOKOMO GRILLS HAVE A LIFETIME LIMITED LIFETIME LIMITED WARRANTY ON GRILL WARRANTY ON GRILL HOUSING AND HOOD HOUSING AND HOOD AGAINST MANUFACTURE AGAINST MANUFACTURE DEFECTS AND DEFECTS AND WARRANTY WORKMANSHIP WARRANTY WORKMANSHIP 10 YEAR LIMITED 10 YEAR LIMITED WARRANTY ON BURNERS WARRANTY ON BURNERS AND GRATES AND GRATES 2 YEARS ON ALL OTHER 2 YEARS ON ALL OTHER PARTS PARTS 30 DAYS ON ALL GRILL 30 DAYS ON ALL GRILL ACCESSORIES ACCESSORIES PG 2 KoKoMo quio MODEL KO BAKSBG LP NG 5 BURNER GRILL CUTOUT _ DIMENSIONS W 37 3 4 H 7 5 8 D 20 1 4 BTU OUTPUT 12 000 BTU PER BURNER X4 INFERRED BACK BURNER 12 000 BTU PER BURNER
15. becue serial number Type of fuel being used Date purchased Date installed Kokomo grills dealer s name and address Kokomo dealer s phone number Kokomo Product Registration Please take a minute to let us know what you bought This makes sure we keep you up to date and have your info ready if you ever need warranty help _State Province Region_ MEN Country City Zip Postal Code What is the model number of the Kokomo Product purchased What 1 the serial number on the Kokomo product only on grills and side burners Where did you buy your Kokomo product Help Desk www kokomogrills com PG 22 KoKoMo quio Lighting Instructions Caution Never operate the grill unattended Prior to using your grill verify that all of the following 1 correct The burner tube 1s free of any debris or obstruction The proper gas type and regulator settings were installed The proper gas connection is complete Minimum clearances are maintained packaging has been removed parts and components are properly in place An installer supplied manual gas shut off valve 1 fully accessible LP hose 1 clean and inspected for cuts wear abrasion or leaks Replace if necessary with a suitable UL ETL or CSA listed part with internally threaded connector LIGHTING YOUR GRILL Become familiar with the safety instructions at the front of this manual Do not smoke while lighting the grill or checking the gas supply c
16. d NG Each shipment contains Each shipment contains an an NG LP Conversion Kit Conversion Kit PG 8 Kokomo Gull burner hood hinge burner pedestal igniting pin burner mount stainless steel gasline sus cooking grill control panel control MSO knob bezel valve gas manifold rear Qu SUUM i _ a burner hes ner p Um z burner hood brass burner assembly J MI i pm oy 298 9 f control knob Ax 2 m s n er e staimimss steel gas line drip tray m T s is manifold PG 9 Kokomo Guill BUILDING BbQ SPECIFICATIONS ALL BBQ ISLANDS MUST BE MANUFACTURED FROM NON COMBUSTIBLE MATERIAL Minimum clearance to adjacent combustible construction at 14 from sides amp 16 from back A plenum wall is required to create a sepa rate compartment for LP Tank source LP REGULATOR MUST BE USED WITH ALL PROPANE BARBECUE PG 10 KoKoMo quib Safety and Installation Instructions NWARNING To reduce the risk of fire electric shock or injury read and follow these basic precautions before operating your gas grill or side burners GRILL INSTALLATION This gas grill must be installed in accordance with all local codes If installation 1 planned in an area with no local codes the gas grill must be installed in accord with the National Fuel Gas Code ANSI Z223 1 an
17. d storage and handling of liquefied petroleum gases ANSI NFPA 58 or CSA B149 1 natural gas and propane installation code CALIFORNIA PROPOSITION 65 WARNING The burning of gas cooking fuel generates some by products which are on the list of substances which are known by the State of California to cause cancer or reproductive harm California law requires businesses to warn customers of potential exposure to such substances To minimize exposure to these substances always operate the unit according to the use and care manual ensuring you provide good ventilation when cooking NWARNING Improper installation adjustment alteration service or maintenance can cause injury or property damage Read the installation operating and maintenance instructions thoroughly before installing or servicing this equipment NWARNING EXPLOSION HAZARD Do not use the grill as storage area for flammable materials Keep area clear and free from combustible materials gasoline and other flammable vapors and liquids Failure to do so can result in death explosion or fire PG 11 KoKoMo quio Instructions Overview Location of your Barbecue Most importantly this is an outdoor appliance Ensure your barbecue is positioned safely away from anything that can catch fire Under no circumstance is this barbecue to be used indoors This includes garages or any other enclosed area e Clearance from Combustibles Ensure your barbecue remains at a distanc
18. e of at least 18 from any combustible material such as wood rock paper and plants Do not store combustible materials gasoline or flammable liquids or vapors around the barbecue e Adequate Ventilation Ensure there is adequate ventilation for both the barbecue and cylinder This 1s required not only for proper combustion but also to prevent gas build up e Firm Level Surface Use your barbecue only on a firm level surface This barbecue 15 not designed for recreational vehicles and should not be installed on a boat or marine craft e Protection from Weather Keep the barbecue protected from adverse weather including rain and high winds Polyvinyl covers are available that have been specially designed for this range of barbecues Allow clear access to the entire gas supply hose and regulator e Maintenance Access When your barbecue 1s installed you should be able to access the eas supply line including the gas piping or hose gas regulator gas cylinder and any shut off valves e Partial Enclosures Many backyards have areas that are partially closed off such as balconies and pergolas In some cases it 1 hard to decide whether these partially enclosed areas should be classified as indoor areas particularly in terms of permanent non closable ventilation The gas safety authorities have agreed on the definition of partial enclosures below IMPORTANT Consult the AHJ Authority Having Jurisdiction or local contractor of any uncertainty
19. ful attention to the location of the gas line It should be routed away from sources of heat sharp edges and should make as few bends as possible e Check to see if the gas line connection will be accessible when grill is installed If the gas line connection is not easily accessible when the grill is installed support the grill above counter level and attach the gas line to the grill When the gas connection is made slide the grill into the cut out If the gas line connection is accessible when the grill is installed slide the grill into the cut out and then attach the gas line o very careful not to kink the gas line when lowering the grill into the cut out Keep your fingers away from where the grill will be supported on counter Your fingers could become trapped and a serious injury could occur Check to make sure the grill is level and is supported around the entire outside edge If the grill is not level or is unstable use non combustible shims under the outside lip to stabilize Perform the leak test procedure as described earlier in this manual PG 19 KoKoMo quio Electrical Precautions Extension cords are available and may be used if care is exercised in their use If an extension cord is used e The marked electrical rating of the cord set or extension cord should be at least as great as the electrical rating of the appliance e The cord should be arranged so that it will not touch hot surfaces sharp edges or drape
20. ining access points one for the side burner and one for the Incoming gas 4 Make your connections and light it up How do you light the backburner 1 Make sure the gas is on 2 Turn the knob slowly but stop before the ignition snaps when you stop hold the knob for 7 10 seconds This allows the gas to flow thru the Infrared Backburner for 7 10 seconds allowing the gas to migrate to the opposite side of the Backburner where the ignition is located 3 After doing so proceed turning the knob to complete the snap 4 Once you hear the snap the gas will be ignited Does the fire pit have a hole for drainage KoKoMo Grills currently does not cut any holes for drainage but when your plumber hooks up the gas to the burner you have to drill a hole into the cement board in order to get to the burner So that provides an out for water How can I tell if I have a gas leak A good test is to mix a bit of water with dish soap Then with a brush dab your connections with the soapy water if you do indeed have a leak you will see your connection start to bubble The flame in the grill is higher in the back than in the front Needs some cleaning Take the burners out remove the cotter pins that are behind and beneath the BBQ and shake them or air gun them and get all the dirt out of the burners Keep in mind that if your burners are bowed it is time for new ones If your grill is brand new out the box and your running L P gas then you might have a N
21. ions Ensure that the service supplying the grill is fitted with a shut off valve conveniently positioned near the grill and giving ease of access The grill must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 0 5 psi 3 5 kPa The grill and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressure in excess of 0 5 psi 3 5 kPa PG 14 KoKoMo quio 1 2 3 4 Connection Slide the grill forward to gain access to the regulator and gas connection point in the rear Connect a suitable natural gas flex connector to the grill regulator Check the grill controls to ensure all control valves are in the full OFF position Turn on the main gas supply and check all connections for leaks using soapy water as described in the leak testing procedure section Warning If you see bubbles in the soapy solution at any of the connections turn off the gas supply and tighten the connection If tightening the connection does not seal the leak it may be necessary to replace the flex hose SAFETY BEWARE OF SPIDERS CAUTION BURNER TUBES MUST BE INSPECTED AND CLEANED BEFORE USE SPIDERS AND SMALL INSECTS OCCASIONALLY SPIN WEBS OR MAKE NESTS IN THE BURNER DURING WAREHOUSING AND TRANSIT THESE WEBS CAN LEAD TO
22. linder Valve ms a Ve j Pressure Reliet Valve Coupling Nut 38 r1 Turn clhickwise bo E connect Bleed Off Valve i BE a d Turn clockwise to close Regulator 43 SR re i ud S WA TO reer h j 1 Mu 2 i 1 Fs k P hi a j d m 4 d E ri ra E Lou Leak Testing gas piping and connections must be tested for leaks after installation or service leaks must be corrected immediately Remember before exchanging an empty bottle for a new one make sure all control valves in the off position e Open the valve shut off or LP tank e Apply liquid soap solution to all joints e Bubbles forming indicate gas leak NEVER USE AN OPEN FLAME TO CHECK FOR LEAKS PG 18 KoKoMo quio NFOR YOUR SAFETY 1 Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance 2 Do not store any propane butane G31 G30 cylinder that 1s not connected for use in the vicinity of this or any other appliance Installing the Grill in a BBO Island e You will need a second person to help you avoid damaging the grill or your barbecue island e Before installing a grill in any island or cut out make sure that the opening is not bigger than the outside frame of the grill unit The grill should rest on the lip of the frame o Pay care
23. not use standard matches or cigarette lighters to perform match lighting procedures Serious burns can occur and lighters can explode l 2 pe xb xe z Open the hood If you have just attempted to light the burner allow five minutes for any accumulated gas to dissipate Keep your face as far away from the burners as possible Light and insert a long stem match holding it near the Lighting Tube Push in and turn the control knob to HIGH If the burner does not light after five seconds turn the control knobs to the OFF position Wait five minutes until the gas clears before attempting to light it again If the burner does not light after several attempts immediately close all gas valves and consult an authorized service technician PG 24 KoKoMo gulls WARNING Flashback may occur in or around the burner tubes Flashback exhibits a characteristic whooshing sound If this should occur immediately turn off your burners then remove and clean them with soap and water and a brush until all foreign objects are removed Fuel Gas Conversion Instructions for KoKoMo Gas Grills CAUTION This should only be performed by a licensed gas professional Propane to Natural Gas Conversion Main Burners Currently all grills are supplied with a regulator set at a pressure of 4 water column Fuel Conversion of Main Burners 1 Determine the existing gas type LP or Propane gas The process for changing the gas type
24. onnections Make sure that all gas connections are securely tightened and have been leak tested with a soapy water solution never with a flame FIRST TIME OPERATION Before cooking with your grill for the first time burn off any foreign matter and rid the unit of any odors by burning the unit on HIGH with the lid down for about 10 minutes When lit the flame should have a bluish color to it It may have a tint of yellow and adjustment to the air shutters can be made to obtain a blue flame and proper gas glow This grill should be preheated with the main burner control settings on HIGH for five minutes with the hood closed PG 23 KoKoMo quio p or oi Lighting the Grill Open the hood Keep your face as far away from the burners as possible Slowly rotate the burner knob counter clockwise to the high position You will hear a loud click as the electric lighter produces a spark Listen for the sound of the gas igniting If the burner does not light on the first try repeat immediately If the burner does not light in five seconds then wait five minutes until the gas clears before attempting to light it again Repeat the procedure or try the manual lighting procedure below Upon successful lighting repeat the process on the other burners you wish to light To shut off the burners rotate the knob and turn to OFF It is normal to hear a popping sound when the burners are turned off Manually lighting the grill WARNING Do
25. or use on all pipe thread connec tions EXCEPT flared threads S S pos Close S upply Shut off Valve 1 2 1 2 our Side Burner to LP No Regulator is required on the Side Burner I Adapter 3 8 Threaded To grill located 3 8 Fittings H Kokomo quio To Propane Tank or Natural Gas PG 4 BBQ Specifications NOTE ALWAYS have equipment measured by Contractor before building NOTE CHECK WITH CITY AND FIRE DEPARTMENT FOR LOCAL BUILDING CODES A PERMIT MAY BE REQUIRED FOR OUTDOOR KITCHEN CONSTRUCTION PG5 Kokomo gull 14 Infis red amp 9 Be i Thermometer e M M aas AAA 19 Hood Handle pM 13 Knob teret voto on mu CORIO E om E da Stainless steel burner H arl MM Bark burner vives A 7 COO knobe revues 4 Dip PG 6 jeuedjoauoo ew qoux josuoot 0 jaued Nig ___ lt 9 dup jo Senjays apis 2 _ WENA i BERS OYE ee di e T __ amp 0 eipueu e dup se6 Oe N NH Jopeuuoo 4299050 ie re D 1ojejn604 09 E Wu v x jaued uoa mu S 22 J sowie awe dn lt H2 194 jeued Tuy foued 9
26. r valve if it is damaged The cylinder must be discarded to a proper LP tank location and then replaced PG 15 KoKoMo quio 7 Turn all control knobs back to the full OFF position a If you are unable to stop a leak turn all control knobs back to the full OFF position shut off the gas supply to the grill and release pressure in the hose and manifold by pushing in and turning any of the control valves one quarter turn counter clockwise 8 On LP systems remove the cylinder from the grill 9 Call an authorized gas appliance service technician or an LP gas dealer 10 Do not use the appliance until the leak 1s corrected E i KoKoMo qul PG 16 Liquid Propane LP Gas Requirements LP TANK REQUIREMENTS e Acollar to protect the cylinder threads on the customer supplied tank e An arrangement for gas vapor withdrawal e A safety relief device having direct communication with the vapor space of the cylinder e A method of mounting e When not in use the tank shut off valve should be turned off NWARNING purging and refilling of LP gas cylinders must be performed by qualified personnel in the LP gas industry Never store a spare LP gas cylinder under or near this appliance Never fill the LP gas cylinder beyond 80 percent full Failure to follow these instructions may result in explosion personal injury or death Filling and Refilling LP Gas Cylinders e Turn control knobs and cylinder val
27. ted with LP liquid propane gas must be installed with an LP regulator not supplied with the unit and set to 11 water column pressure The gas valves used in the grills are preset at the factory for LP operation Please contact your dealer and use a licensed contractor or installer to convert your grill to the different gas type The self contained LP system barbecue grill is design certified to be used with a standard 20 Ib 12 1 4 diameter 18 high cylinder with right handed connection threads and this is the maximum size LP tank to be used The cylinder must be marked in accordance with the latest U S Department of Transportation specifications for LP gas cylinders DOT CFR49 or National Standards of Canada CAN CSA B359 Cylinders Spheres and Tubes for the Transportation of Dangerous Goods a Propane Tank with an ODP Overfill Prevention Device must be used at all times Natural Gas Requirements Always check the Rating Plate to make sure the gas supply you are hooking up to 1 the gas type the grill is manufactured for IMPORTANT Never connect the grill to an unregulated gas supply The installation of this appliance must conform with local codes or in the absence of local codes to the national fuel gas code ANSI Z223 1a 1998 Installation in Canada must be in accordance with the standard CAN CGA B149 2 Propane Installation Code A licensed contractor or local gas company representative must perform all natural gas connect
28. ve to the OFF position e Unscrew valve e Remove cylinder and have it filled at your local qualified propane dealer e Once filled carefully connect the valve and make sure it is secure and not leaking e With the control knobs in the OFF position turn on the cylinder valve o If you smell gas or hear the hiss of gas escaping from the tank get away from the tank and do not attempt to correct the problem yourself Call the Fire Department immediately o If your grill has no leak at the cylinder then re check for loose connections and retest for leaks using the method detailed in the following pages with soapy solution o Do not subject your LP gas cylinder to excessive heat and always store the cylinder in an upright position Never store your LP cylinders indoors o Make sure that when attaching components all connections are secured and fully tightened to prevent leakage If one is not already available it 1s recommended that an ON OFF shutoff valve be installed at the gas supply source and that the gas supply be turned off when either Natural Gas or LP Gas grills are not in use PG 17 KoKoMo quio Transporting and Storing LP Gas Transport only one cylinder at a time Ensure the cylinder 1 secured in an upright position with the control valve turned off and the dust cap in place Be sure to store cylinders outdoors and out of the reach of children Do not store cylinders in a building garage or any other enclosed area C l Cy

USER MANUAL & CARE GUIDE - Kokomo

Contents

Download Pdf Manuals

Related Search

Related Contents

USER MANUAL &amp; CARE GUIDE - Kokomo

Contents

Download Pdf Manuals

Related Search

Related Contents

USER MANUAL & CARE GUIDE - Kokomo