Q-Series UV Magnifier Lamps
Contents
1. 5 75 x 2 25 in 14 6 x 17 8 x 5 7 cm All tubes are 4 Watt UV A tubes are integrally filtered Long Wave UV A 365nm UL listed CSA approved All models are ISO 9001 2008 certified Disposal A WARNING LAMP TUBES CONTAIN MERCURY Manage in Accordance with Disposal Laws See www lamprecycle org 2200 INS LAB RevA15 6 LIMITED WARRANTY SCOPE OF WARRANTY GF Health Products Inc GF warrants to the original purchaser only that it will replace or repair components at GF s sole discretion that are defective in material or workmanship under normal use and service All warranties are conditioned upon the proper use of the products strictly in accordance with good commercial practice and applicable GF instructions and manuals including proper use and maintenance To the extent that a component is warranted by a third party GF conveys all of its rights under that warranty to the original purchaser to the extent permitted This limited warranty shall only apply to defects that are reported to GF s customer service team within the applicable warranty period and which upon examination by GF or its authorized representative prove to be a warranty item This limited warranty is not transferable Within the guidelines set forth in this document this product is warranted for one 1 year The applicable warranty period shall commence from date of shipment to the original customer unless there is an expiration date on t2. INJURY TO EYE Never look directly into the lamp Exposure can cause eye and skin allergy and allergic reactions Medications or cosmetics may increase your sensitivity to ultraviolet radiation Consult physician before operating this product if you are using medications or have a history of skin problems or believe yourself especially sensitive to sunlight FOR LABORATORY USE ONLY Z WARNING If components are damaged or missing contact your dealer immediately DO NOT use substitute parts Use only Grafco replacement parts Non Grafco replacement parts could cause personal injury and or damage to the lamp Z WARNING GF Health Products Inc assumes no responsibility for any damage or injury caused by improper installation or use of this product 2200 INS LAB RevA15 3 UNPACKING AND INSPECTION Your device will include the following components Lamp Unit Operation Manual 2200 Two 4 Watt Integrally Filtered UV A Tubes 2223A 2203 Two 4 Watt Integrally Filtered UV A Tubes 2223A and Two 4 Watt White Light Tubes 2223C Carefully unpack and inspect the lamp for possible damage in shipment If any damage is noted immediately notify the carrier and supplier before attempting to use the lamp Save the shipping carton and packing materials for future storing and shipping of the lamp Check the lamp s electrical performance as soon as possible according to the following General Function Checks OPERATION INSTRUCTIONS
3. Please refer to illustration below The inner bulb side is shown switches are on the outer side White Bulb aa Housing N Ultraviolet Bulb s s lt Hande gt lt t Power Cord ___ gt Model 2200 Model 2203 Q Series Long Wave Q Series Long Wave Ultraviolet Ultraviolet Magnifier Lamp with White Light Magnifier Lamp 2200 General Functional Checks Perform Before Use 1 2 3 Connect the plug to a power outlet that complies with the electrical requirements specified on the lamp s label Press the white power switch The tubes should become energized and emit a steady glow of light The light may initially flicker especially if the lamp is cold but should stabilize after a few seconds To turn the lamp off press the switch or disconnect from electricity ee 2200 INS LAB RevA15 4 2203 General Functional Checks Perform Before Use 1 Connect the plug to a power outlet that complies with the electrical requirements specified on the lamp s label 2 Press the white power switch to operate white light bulbs or the black switch to operate UV A bulbs 3 The tubes should become energized and emit a steady glow of light The light may initially flicker especially if the lamp is cold but should stabilize after a few seconds 4 To turn the lamp off press both switches to off position or disconnect from electricity Info The 2203 white switch controls white light ope
4. EANING 000 c cee eee 5 TUBE REPLACEMENT 3 isiccs ce isauds aad enauren dates wags wae ee 5 SPECIFICATIONS ids ates alae aaa aitvacnaid ae She vad at ayer ar a aes wa oa 6 ENVIRONMENTAL SPECIFICATIONS 0000 c eevee cease 6 ELECTRICAL SPECIFICATIONS 2 00 00 e eee eee eee 6 DISPOSAL oi cisaiis asst cick tagi E ard cat i a ed aa cae ati are aver ara eave cate soa 6 LIMITED WARRANTY 00000 c cece eee eee eee 7 GF Health Products Inc is not responsible for typographical errors For the most updated and current information on packaging warranties products and specifications including the most current version of these instructions please visit our website at www grahamfield com Graham Field and Grafco are registered trademarks of GF Health Products Inc 2015 GF Health Products Inc INTRODUCTION This operation manual contains important information and safety precautions for the Grafco 2200 2203 Q Series Ultraviolet Magnifier Lamp Before using the lamp please read and understand this entire user manual Take special note of all safety precautions marked DANGER and WARNING Save this operation manual for future reference Intended Use The Grafco 2200 2203 Q Series Ultraviolet Magnifier Lamp is intended to provide visual magnification during fluorescence analysis in an indoor laboratory 2200 INS LAB RevA15 2 IMPORTANT SAFETY PRECAUTIONS Z IMPORTANT Before using the lam
5. Graico MODEL 2200 2203 Q SERIES ULTRAVIOLET MAGNIFIER LAMP Ex Model 2200 Model 2203 Q Series Long Wave Q Series Long Wave Ultraviolet Ultraviolet Magnifier Lamp with White Light Magnifier Lamp OPERATION MANUAL Info The most current version of this manual can be found online at www grahamfield com Z WARNING Important Read and understand these instructions before using the 2200 2203 Q Series Ultraviolet Magnifier Lamp If you do not understand any part of these instructions contact a healthcare professional for direction in the use of this product If the lamp is not properly installed and operated personal injury and or damage to the lamp could result PLEASE SAVE THIS MANUAL FOR FUTURE USE UL 2200 INS LAB RevA15 CONTENTS INTRODUCTION sgu nseni ae east aan aa sia dinate E dos ae eg rn olds wa ane a 2 INTENDED USE cociran apaa aaiae eee 2 IMPORTANT SAFETY PRECAUTIONS 0 000 c eee e eee eee 3 SIGNIFICANCE OF SAFETY STATEMENTS 0055 3 UNPACKING AND INSPECTION 00 0000 cece eee eee 4 OPERATION INSTRUCTIONS 2 0 c cece eee eee eee 4 2200 GENERAL FUNCTIONAL CHECKS PERFORM BEFORE USE 4 2203 GENERAL FUNCTIONAL CHECKS PERFORM BEFORE USE 5 OPERATOR MAINTENANCE 00 000 e cee eee eee 5 MAINTENANCE cccisiiccccacisd w a a ae ave aaa aim aca ae aR wa A aaa 5 HOUSING AND MAGNIFIER LENS CLEANING 5 TUBE AND REFLECTOR CL
6. OPERATION section If the problem persists and it is necessary to replace a tube unplug the lamp from its power source before proceeding 2200 INS LAB RevA15 5 1 Lay the lamp housing on a flat level surface with the tubes facing up 2 Grasp the tube by the metal bases located at each end Applying even pressure gently rotate the tube a quarter turn until it loosens The tube may now be easily removed from its sockets Install the new tube by reversing the above procedure 4 If installation of the new tube fails to yield correct lamp operation check to ensure the two pins at each end of the tube are properly connected with the two copper contacts in each socket Info The tubes in all Q Series lamps are wired in series Therefore if one tube fails the other tube of the same wavelength will not illuminate even though it may be in good operating condition SPECIFICATIONS Environmental Specifications Grafco Q Series lamps are designed to be used under the following conditions e Indoor use e Altitude to 2 000 m 6 562 ft e Temperature 5 C to 40 C 41 F to 104 F e Maximum relative humidity 80 for temperatures up to 31 C 88 F decreasing linearly to 50 relative humidity at 40 C 104 F e Mains supply voltage fluctuations not to exceed 10 of the nominal voltage e Installation category II e Pollution degree 2 w Electrical Specifications All models are 120V 60Hz Housing dimensions W x L x H
7. he component in which case the warranty shall expire on the earlier of warranty period or the expiration date OBTAINING WARRANTY SERVICE This limited warranty shall only apply to defects that are reported to the Distributor from whom the Customer purchased the product within the applicable warranty period If there is not a Distributor you must contact GF directly by calling 770 368 4700 sending a fax request to 770 368 2386 or by e mailing a request to cs grahamfield com Specific directions will be provided by the Customer Service Representative Failure to abide by the specific directions will result in denial of the warranty claim EXCLUSIONS The warranty does not cover and GF shall not be liable for the following 1 Defects damage or other conditions caused in whole or in part by misuse abuse negligence alteration accident freight damage tampering or failure to seek and obtain repair or replacement in a timely manner 2 Products which are not installed used or properly cleaned and maintained as required in the official manual for the applicable product 3 Products considered to be of a non durable nature including but not limited to casters filters fuses gaskets lubricants and charts 4 Accessories or parts not provided by GF 5 Charges by anyone for adjustments repairs replacement parts installation or other work performed upon or in connection with such products which are not expressly authorized in wri
8. p please read and adhere to the following safety precautions and warnings Failure to do so could result in serious personal injury or damage to the lamp If you experience any malfunction contact your GF authorized distributor immediately as a hazardous condition could result causing personal injury or damage to the lamp Maintenance MUST be performed by qualified personnel ONLY Significance of safety statements Please note the following special statements used throughout this manual and their significance Z DANGER Indicates a potential hazard situation or unsafe practice that if not avoided will result in death or serious personal injury Z WARNING Indicates a potential hazard situation or unsafe practice that if not avoided could result in death or serious personal injury Z CAUTION Indicates a potential hazard situation or unsafe practice that if not avoided could result in minor or moderate personal injury A NOTICE Indicates a potential hazard situation or unsafe practice that if not avoided could result in product or property damage Info Provides application recommendations or other useful information to ensure that you get the most from your product Z DANGER Ultraviolet radiation is emitted from this product Avoid exposure ALWAYS WEAR PROTECTIVE CLOTHING EXPOSURE MAY CAUSE PREMATURE AGING OF THE SKIN AND CANCER ALWAYS WEAR PROTECTIVE EYEWEAR FAILURE TO DO SO MAY RESULT IN SEVERE BURNS OR LONG TERM
9. ration while the black controls UV A If you operate the other switch while one is on it will power the other one off Operator Maintenance The following maintenance instructions are intended for limited maintenance of the lamp Do not perform any maintenance other than that contained in these instructions Return the lamp to your GF authorized distributor for other maintenance not covered in this section MAINTENANCE Z WARNING To avoid the risk of electrical shock always unplug the lamp from its power source before performing maintenance or cleaning A NOTICE DO NOT use abrasive cleansers on any part of lamp DO NOT immerse lamp in any liquid Housing and Magnifier Lens Cleaning The polycarbonate lamp housing protects the internal parts Immediately clean spills from the housing and magnifier lens with water and a mild detergent and wipe dry with a clean soft cloth Do not allow any liquids to leak into electrical components Clean the lens as needed with glass cleaner and a clean soft cloth Tube and Reflector Cleaning Clean the reflector as needed with glass cleaner and a clean soft cloth Clean the tubes as needed with a mild detergent solution Wipe dry with a clean soft cloth Tube Replacement Info Replacement tubes are available at www grahamfield com 2223A Tube UV A 4 Watt 2200 2203 2223C Tube White Light 4 Watt 2203 If a tube fails to operate correctly review the procedures outlined in the
10. resents that it has not relied on any representation assertion guarantee warranty collateral contract or other assurance except those set out in this document For additional information on this product or this warranty please contact a GF Customer Service Representative NOTES 1 Additional terms and conditions may apply 2 Freight claims must be notated on the appropriate shipping documents and must be made with immediacy International federal and state regulations govern specific requirements for freight claims Failure to abide by those regulations may result in a denial of the freight claim GF will assist you in filing the freight claim 3 Claims for any short shipment must be made within thirty 30 days of the invoice date ees 2200 INS LAB RevA15 T Manufactured for GF Health Products Inc 2935 Northeast Parkway Atlanta GA 30360 tel 770 368 4700 fax 770 368 2386 GRAHAM FIELD www grahamfield com Made in USA except bulbs
11. ting in advance by GF 6 Any labor or shipping charges incurred in the replacement part installation or repair 7 Costs and expenses of regular maintenance and cleaning and 8 Representations and warranties made by any person or entity other than GF ENTIRE WARRANTY EXCLUSIVE REMEDY AND CONSEQUENTIAL DAMAGES DISCLAIMER THIS WARRANTY IS GF S ONLY WARRANTY AND IS IN LIEU OF ALL OTHER WARRANTIES EXPRESS OR IMPLIED GF MAKES NO IMPLIED WARRANTIES OF ANY KIND INCLUDING ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IF ANY MODEL OR SAMPLE WAS SHOWN TO THE CUSTOMER SUCH MODEL OR SAMPLE WAS USED MERELY TO ILLUSTRATE THE GENERAL TYPE AND QUALITY OF THE PRODUCT AND NOT TO REPRESENT THAT THE PRODUCT WOULD NECESSARILY CONFORM TO THE MODEL OR SAMPLE IN ALL RESPECTS THIS WARRANTY IS LIMITED TO THE REPAIR OR REPLACEMENT OF THE DEFECTIVE PARTS GF SHALL NOT BE LIABLE FOR AND HEREBY DISCLAIMS ANY DIRECT SPECIAL INDIRECT INCIDENTAL EXEMPLARY OR CONSEQUENTIAL DAMAGES INCLUDING BUT NOT LIMITED TO DAMAGES FOR LOSS OF PROFITS OR INCOME LOSS OF USE DOWNTIME COVER OR EMPLOYEE OR INDEPENDENT CONTRACTOR WAGES PAYMENTS AND BENEFITS The warranties contained herein contain all the representations and warranties with respect to the subject matter of this document and supersede all prior negotiations agreements and understandings with respect thereto The recipient of this document hereby acknowledges and rep
Download Pdf Manuals
Related Search