AFH-600 hazer user manual
Contents
1. Insert the suction hose of the hazer back into the fog fluid container and let the device again produce haze for about 20 seconds This will rinse the lines The cleaning is completed themann MUSIC IS OUR PASSION 34 Protecting the environment 12 Protecting the environment Disposal of the packaging mate rial For the transport and protective packaging environmentally friendly materials have been chosen that can be supplied to normal recycling Ensure that plastic bags packaging etc are properly disposed of Do not just dispose of these materials with your normal household waste but make sure that they are collected for recycling Please follow the notes and markings on the packaging Disposal of your old device This product is subject to the European Waste Electrical and Electronic Equipment Directive WEEE Do not dispose with your normal household waste Dispose of this device through an approved waste disposal firm or through your local waste facility When discarding the device comply with the rules and regulations that apply in your country If in doubt consult your local waste disposal facility themann MUSIC IS OUR PASSION 35 Notes themann 36 Notes themann 37 Notes themann 38 Musikhaus Thomann Hans Thomann Stra e 1 96138 Burgebrach Germany www thomann de2. G Risk of burns from flammable liquids The use of flammable liquids in this device may cause severe burns and damage to property Always use approved fog fluids Never fill flammable liquids into the tank of the device WARNING Risk of slipping caused by condensation Fog machines can produce condensation Do not direct the fog to floors Floors and surfaces can become slippery by condensed fog Check at regular intervals whether it is possible to walk on the floors without a slipping hazard and if necessary remove the condensation themann MUSIC IS OUR PASSION Safety instructions WARNING Health hazard caused by fog fluid handling Fog fluid does contain glycols complying with the regulations for foodstuffs However it may be harmful if swallowed Do not induce vomiting Seek medical advice immediately Keep fog fluid in a safe place If the fog fluid comes into contact with eyes rinse thoroughly with water CAUTION Possible respiratory problems The device can be operated safely only with the approved fog fluid The use of other fluids can release toxic gases Claims for damages caused by the use of non approved fluids shall be excluded Do not create fog in closed or poorly ventilated areas Do not expose persons with health problems such as allergic respiratory condi tions asthma to artificial fog themann MUSIC IS OUR PASSION 10 Safety instructions NOTICE Risk of fire Do not cove
3. OUR PASSION 19 Connections and operating elements Rear panel themann 20 vv A U N Fog fluid container with screw cap Fog fluid feed line from fluid container to vaporiser Carrying handle OUT DMX output IN DMX input POWER IEC chassis plug with fuse holder for the power supply Display and control panel Button FUNC Opens up the main menu Button Y Decreases the displayed value by one AFH 600 21 Connections and operating elements themann MUSIC IS OUR PASSION 22 Operating 7 Operating Filling the unit NOTICE Possible damages caused by unsuitable fog fluid Fog liquids not approved by the manufacturer may permanently damage the unit Only use the fog fluids listed on www thomann de and follow their instructions for use First make sure the unit is switched off Open the screw cap of the liquid container and fill in the fog fluid Make sure that no fluid is spilled or gets into the device The easiest way is using a funnel The container capacity is 2 3 litre Screw the cap firmly back on themann MUSIC IS OUR PASSION 23 Operating Turning the unit on Operating modes themann MUSIC IS OUR PASSION NOTICE Fire hazard Do not operate the machine unattended Connect the device to the power grid and turn it on with the main switch The unit is heating up and the display shows UP As soon as the required operating temperatu
4. S THIAWICULE AFH 600 hazer themann user manual MUSIC IS OUR PASSION Musikhaus Thomann Thomann GmbH Hans Thomann Stra e 1 96138 Burgebrach Germany Telephone 49 0 9546 9223 0 E mail info thomann de Internet www thomann de 19 08 2015 ID 306309 Table of contents oo OnN Au A WN Table of contents General OCS isis iii iaa diia liada 4 Safety instructions Features Installati n coooioninni ica SAUNA anotan 15 Connections and operating elements unnnsnenesenssennseennssunssennssennssnnssennssnnnssunnee 18 OPerating iii in iii 23 Technical specifications cecccssssssssssssssssesssecsesssscssesssssssessessssssscssseesscsascsncssseesscssssssesseesseesseenes 29 Plug and connection assignMent cccsscsssscsssscssessseecsseceseecssecesecssscessecssscesseessceeaneceseeesies 30 Troubleshooting indicada 31 Caa OA EEE AA TUE EIERN EEE E 33 Protecting the EnvironMent cccsssscsssssssccssecssecssecessecsseccescesssccescceseecssccssaeessescsseessecsneeeseeesses 35 th mann MUSIC IS OUR PASSION General notes 1 General notes This user manual contains important information on safe operation ofthe device Read and follow all safety notes and all instructions Save this manual for future reference Make sure that it is available to all persons using this device If you sell the device to other users be sure that they also receive t
5. ck to see if the DMX cables run near or alongside to high voltage cables that may cause damage or interference to DMX interface circuits AFH 600 31 Troubleshooting If the procedures recommended above do not succeed please contact our Service Center You can find the contact information at www thomann de themann MUSIC IS OUR PASSION 32 Cleaning 11 Cleaning NOTICE Possible damages caused by unsuitable cleaning agents Cleaners not approved by the manufacturer may permanently damage the unit Only use the fog machine cleaners listed on www thomann de and follow their instructions for use Clean the appliance after every 30 operating hours or if it was not in use for a longer period of time Procedure 1 Make sure that the device is turned off disconnected from the mains and completely cooled down 2 Position the unit in a well ventilated place 3 Insert the suction hose of the hazer into the bottle with the fog machine cleaner 4 Connect the device to the mains and switch it on with the main switch The unit is heating up and the display shows UP themann MUSIC IS OUR PASSION 33 Cleaning 5 _ As soon as the required operating temperature is reached the display shows a value between F001 and F100 The device is now operational Use the arrow keys to set the value F700 for maximum haze output and let the device produce haze for about 20 seconds 6
6. his manual Our products are subject to a process of continuous development We therefore reserve the right to make changes without notice themann MUSIC IS OUR PASSION General notes Symbols and signal words This section provides an overview ofthe symbols and signal words used in this user manual Signal word Meaning DANGER This combination of symbol and signal word indicates an immediate dangerous situation that will result in death or serious injury if it is not avoided WARNING This combination of symbol and signal word indicates a pos sible dangerous situation that can result in death or serious injury if it is not avoided CAUTION This combination of symbol and signal word indicates a pos sible dangerous situation that can result in minor injury if it is not avoided NOTICE This combination of symbol and signal word indicates a pos sible dangerous situation that can result in material and environmental damage if it is not avoided themann MUSIC IS OUR PASSION General notes Warning signs Type of danger Warning high voltage Warning flammable substances Warning harmful or irritating substances Warning danger zone gt PEE themann MUSIC IS OUR PASSION Safety instructions 2 Safety instructions Intended use Safety This device is intended to be used to produce fine haze by vaporising fog fluid Use the device only as described in this user manual Any other use or use
7. kaging or your own packaging material suitable for transport or storage respectively The unit requires 20 cm clearance on the sides and above Place the unit on a flat stable sur face The device must not be positioned with more than 15 inclination during operation 14 Starting up 5 Starting up Establish all connections as long as the unit is switched off Use the shortest possible high quality cables for all connections themann MUSIC IS OUR PASSION 15 Starting up Connections in DMX mode Connect the DMX input of the device to the DMX output of a DMX controller or another DMX device Connect the output of the first DMX device to the input of the second one and so on to form a daisy chain Always ensure that the output of the last DMX device in the daisy chain is terminated with a resistor 1100 1 4 W themann MUSIC IS OUR PASSION 16 Starting up Connections in Master When you configure a group of devices in Master Slave mode the first unit will control the Slave mode others Connect the DMX output of the master unit to the DMX input of the first slave unit Then connect the DMX output of the first slave unit to the DMX input of the second slave unit and so on themann MUSIC IS OUR PASSION 17 Connections and operating elements 6 Connections and operating elements Front panel PN themann 18 Connections and operating elements themann MUSIC IS
8. mode DMX themann MUSIC IS OUR PASSION This mode can only be selected when no DMX controller is connected and turned on Press FUNC repeatedly until the display shows SLNd Press ENTER Now you can use the arrow keys to choose from the following options m NASt The device works as Master and controls other devices that follow as Slave m SLAu The device follows as Slave exactly the operation of the Master to which it is con nected Press ENTER to confirm and to start operation in Master Slave mode Press FUNC repeatedly until the display shows Addr Press ENTER Now you can set the number of the first DMX channel to be used by the device DMX address Use the arrow keys to select a value between 1 and 512 Press ENTER to save the value and to start operation in DMX mode Make sure that this number matches the configuration of your DMX controller 26 Operating DMX assignment Turning the unit off Turn off the power using the main switch Transport the device only when it is completely cooled down To avoid leaking fog fluid during transport you should transport the device only with empty fluid container themann MUSIC IS OUR PASSION 27 Operating Menu overview themann 28 8 Technical specifications Heater power Haze output Fog fluid container capacity Warm up time Operating supply voltage Fuse Power co
9. nsumption Dimensions W x D x H Weight 600 W approx 850 m min 2 3 approx 2 min AC 230 V 50 Hz 4A 250V fast blow 5 mm x 20 mm 1290 W 290 mm x 450 mm x 265 mm 5 5 kg AFH 600 29 Plug and connection assignments 9 Plug and connection assignments Introduction DMX connections themann MUSIC IS OUR PASSION 30 This chapter will help you select the right cables and plugs to connect your valuable equip ment so that a perfect light experience is guaranteed Please take our tips because especially in Sound amp Light caution is indicated Even if a plug fits into a socket the result of an incorrect connection may be a destroyed DMX controller a short circuit or just a not working light show The unit offers a 3 pin XLR socket for DMX output and a 3 pin XLR plug for DMX input Please refer to the drawing and table below for the pin assignment of a suitable XLR plug 10 Troubleshooting In the following we list a few common problems that may occur during operation We give you some suggestions for easy troubleshooting Symptom Remedy The unit does not work Check the mains connection and the main fuse No haze output 1 Check the fluid level in the fog container 2 Switch the device off and check the hose that leads into the fluid container for flow No response to the DMX controller 1 Check the address settings and the DMX polarity 2 Try using another DMX controller 3 Che
10. r the device nor any ventilation slots Do not place the device near any direct heat source Keep the device away from naked flames NOTICE Operating conditions This device has been designed for indoor use only To prevent damage never expose the device to any liquid or moisture Avoid direct sunlight heavy dirt and strong vibrations themann MUSIC IS OUR PASSION 11 Safety instructions NOTICE Power supply Before connecting the device ensure that the input voltage AC outlet matches the voltage rating ofthe device and that the AC outlet is protected by a residual current circuit breaker Failure to do so could result in damage to the device and possibly injure the user Unplug the device before electrical storms occur and when it is unused for long periods of time to reduce the risk of electric shock or fire themann MUSIC IS OUR PASSION 12 Features 3 Features This hazer is suitable to be used in clubs bars discotheques and on stages Special features of the device E Compact design Suitable for mobile use Large liquid container for the fog liquid themann MUSIC IS OUR PASSION 13 Installation 4 Installation themann MUSIC IS OUR PASSION Unpack and carefully check that there is no transportation damage before using the unit Keep the equipment packaging To fully protect the device against vibration dust and moisture during transportation or storage use the original pac
11. re is reached the display shows a value between F001 and F100 The device is now operational The device supports the following operating modes that you can select with the buttons on the device Manual control Master Slave mode E DMX control The haze volume that you have set either directly on the device on the Master or with your DMX controller is uniformly ejected In all modes 24 Main menu Operating mode Manual con trol Operating Press FUNC to activate the main menu and select an operating mode When the display is flashing use the arrow keys to change the respectively displayed value When the display shows the desired value press ENTER To return to the main menu without any changes press FUNC or wait a minute All previous settings are retained even when you disconnect the device from the mains This mode can only be selected when no DMX controller is connected and turned on Press FUNC repeatedly until the display shows out Press ENTER Now you can use the arrow keys to adjust the desired haze amount between F007 no haze output and F700 maximum haze output Press ENTER to confirm To suspend haze output press FUNC the display shows read To resume haze output press FUNC again The display shows the last selected value again themann MUSIC IS OUR PASSION 25 Operating Operating mode Master Salve Operating
12. under other operating conditions is considered to be improper and may result in personal injury or property damage No liability will be assumed for damages resulting from improper use This device may be used only by persons with sufficient physical sensorial and intellectual abilities and having corresponding knowledge and experience Other persons may use this device only ifthey are supervised or instructed by a person who is responsible for their safety DANGER Danger for children Ensure that plastic bags packaging etc are disposed of properly and are not within reach of babies and young children Choking hazard Ensure that children do not detach any small parts e g knobs or the like from the unit They could swallow the pieces and choke Never let children unattended use electrical devices themann MUSIC IS OUR PASSION Safety instructions DANGER Electric shock caused by high voltages inside Within the device there are areas where high voltages may be present Never remove any covers There are no user serviceable parts inside DANGER Electric shock caused by short circuit Always use proper ready made insulated mains cabling power cord with a pro tective contact plug Do not modify the mains cable or the plug Failure to do so could result in electric shock death or fire If in doubt seek advice from a regis tered electrician themann MUSIC IS OUR PASSION Safety instructions WARNIN
Download Pdf Manuals
Related Search