Freestanding Track FST300 Manual
Contents
1. 330051 Step 3 Make sure not to loose any part Step 4 Fold and place the track on the floor or on a secure table Bring the trolley to the opening of the track Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 27 Trolley Disassembly Continued i i a J mp l n tps iy a x w Ay i i r Step 5 Use a screw driver and push the trolley lock button Step 6 Remove the trolley down to allow the trolley to come out Removing Trolley P 300 Prism part number 330052 Step 1 Follow the step 1 to 6 from the removing trolley Note Make sure not to loose any part C 300 Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 28 Trouble Shooting Should problems arise with the use of the Free Standing Track review the following chart Find the fault and complete the recommended solution If the fault 1s not found and or the solution does not correct the problem contact your local authorized dealer for service immediately Visually the system is not aligned 1 Post is not set straight 1 Set up the post following Post Assembly in straight 2 Floor is not leveled structions Note Make sure the track is seating completely flat on the track holder 2 Foot pads must be seating completely flat on the floor There should be no gap between the foot and floor pads If problem persists contact your local authorized dealer immediately Feet are slipping after instal2. and Cautions Cautions AN Failure to observe cautions listed below could result in serious injury or death e The Free Standing Track system must be assembled prior to use Should you have any questions during assembly contact your local authorised dealer e The Free Standing Track system parts should not be loose broken or bent If any part is missing or dam aged do not install Contact your local authorised dealer immediately e Under no circumstance should the track lift and sling s or entire system be put in control of a person who has not been properly trained in the use and care of this equipment Failure to adhere to this warn ing may result in serious injury to the operator and or the individual being lifted transferred e Never expose the Free Standing Track directly to water Warranty does not cover any misuse or abuse of the Free Standing Track system e Any accessories used with the Free Standing Track including lift and sling s should be checked to en sure that they are in good working order Check for signs of wear or fraying prior to use Report any un usual wear or damage immediately to your local authorised dealer e The Free Standing Track and associated lift and sling s are intended only for lifting and transferring of a person Vancare will not be responsible for any damage caused by the misuse neglect or purposeful destruction of the lift and or its associated components e The installation of the Free
3. load and pull the lift down to be able to remove the lift from parking spot and use it Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 18 Raising up the Free Standing Track 5 zr Step 1 Grab The Post Centre to open the post clamp Step 4 Raise the Post Up using the height Step 3 Grab The Inner Post with one ri indicators hand and grab the Outer Post section with the other hand Note When Raising the Post from Lowest setting it is recommended to raise in 1 Foot increments Step 5 Repeating steps 1 5 raise the oth er Post Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 19 Raising up the Free Standing Track Continued B a Note Free Standing Track will be in a AN Note a caution sign at the 7 feet indi slanting position as shown in figure Set up cates that you are approaching the the Free Standing Track by raising the post end of the post Carefully extend the assemblies one by one post until you approach the stop sign or 7 5 feet if desired or applicable Max Height of Free Standing Do not extend post after 7 5 Feet height mark Note Maximum height of Free Standing Track is 7 5 Feet DO NOT EXTEND WE POST SEYOND M reer FP Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 20 Raising up the Free Standing Track Continued Completely Installed Free Standing Track AN Always Before Use check
4. the following steps 1 Make sure the height indicator shows the same number on both posts 2 No Gap between Track and track Holder 3 No Gap Between Foot Pads and Floor Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 21 Attaching the Skirt Optional Accessory Step 1 Rap the skirt around the legs and close it using the Step 2 Use the pocket as a storage for the sling or as you Velcro hooks require Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 22 Disassembly of Free Standing Track Step 1 Before disassembly make sure the lift and or Trol Step 2 Grab The Post Centre to open the post clamp and ley is in parking spot fully open the clamp Step 3 Grab The Post and press the Ratchet with thumb Step 4 Bring down the Free Standing Track by sliding down the inner Post while keep pressing down the Ratch et Lock Note When Lowering down the Post from highest setting it is recommended to lower in 1 Foot increments To prevent sudden drop of the post you should release the ratchet in at least every 12 or eve ry 6 holes Failure to do this step might cause injury or damage to the floor Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 23 Disassembly of Free Standing Track Note Free Standing Track will be in a slanting Note Make sure the posts are parallel and not position as shown in figure Bring down the other twisted inside each oth
5. 12 Page 12 Assembly of the Track Step 2 Track should automatically locks itself in place with a click sound Note Ensure Track is locked and fully straight Step 1 Place the track on the floor Unfold the track as shown in figure until it is fully straight Note If you do not hear the click sound Step 3 Lay Track Flat on the floor press the lock with hand until it is in locking position Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 13 Assembly Mounting the Track Step 1 Place the Track against the floor Step 2 Grab the handle and pull the hook inside the track slightly out using a finger and Twist the handle towards the unlock direction until the lock is fully opened Step 3 Repeat the same step for other side handle Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 14 Assembly Mounting the Track Step 4 lift the track with both hands and Place one end of Step 5 Track should fall into place and sit flat on the track the track on the Post Assembly as shown in figure holder of the Post as you see in next figure Note always make sure that handles are in open position before placing the track on the post CADTIONS i irid dii do dd A Bitia Step 6 Place the other end of the track on the other Step 7 Both ends should lay completely Flat on the Post top of post assemblies Note Make sure there is no gap between the Track and Track Holde
6. Standing Track lift accessories and sling are certified to a maximum load Do not exceed the maximum rated load of any of the components e Ensure that a clear space is maintained around the Free Standing Track Remove all furniture and other obstacles out of the way before performing a transfer e The Free Standing Track has been designed to lift vertically at its maximum load and at maximum height Do not attempt to lift an individual at an angle to the track e Do not install The Free Standing Track on an uneven floor Do not install on a sloped floor greater than 5 degree e Ensure floor area is clear off dirt and debris e Do not drop product it may cause breakage Protect the Free Standing Track and its accessories during transport e Prior to each use of the equipment complete a visual inspection A monthly maintenance inspection must be done in order to ensure good operating conditions e Make sure the Lift is in Parking spot before raising or lowering the Posts Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 7 A Check Requirements and Cautions continued Cautions After Installation e Ensure that the Handle lock are fully in locked position as per labels e Make sure track is sitting properly on the posts There should be no gap between Track and Track Holders e Make sure all four foot pads are sitting flat on the floor There should be no gap between the foot pads and floor e Make sure clamp lever
7. UAL BEING LIFTED AND OR THE CAREGIVER OR DAMAGE TO THE LIFT AND OR THE FREE STANDING TRACK Step 2 Grab the lift and drag it to the parking spot Note always make sure that the lift is in No parking spot before raising the posts Apply load and pull the lift down to be able to remove the lift from parking spot and use it Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 17 Mounting the P 300 Lift Ln Caution Prior to mounting the P 300 lift onto the P 300 trolley read the owners manual of the P 300 lift Be sure that the instructions on the use of the lift and any accessories such a slings are thor oughly understood before attempting to use them with the Free Standing Track Free Standing Track is rated only for 300lbs Do not exceed the limit of the Free Standing Track ZX FAILURE TO COMPLY WITH THIS MAY RESULT IN INJURY TO THE INDIVIDUAL BEING LIFTED AND OR THE CAREGIVER OR DAMAGE TO THE LIFT AND OR THE FREE STANDING TRACK Grab the Trolley eyelet and bring it to the parking spot Once the trolley is in parking spot Place the Portable lift in secure and comfortable position Pull enough strap out of the lift to be able to hook the carabineer comfortably to the eyelet of the trolley Put the carabineer of the lift strap into the eyelet of the trolley as shown in figure above Raise the lift to the track height Note always make sure that the lift is in parking spot before raising the posts Apply
8. We move body and mind Free Standing Track TE n amp Owner s Manual Use and Care Trouble Shooting VANCARE INC 1515 1ST STREET AURORA NE 68818 T 800 694 4525 F 402 694 3994 info vancare com www vancare com Table of Contents Free Standing Track Introdu chon eiae E etude ui Gi cewseenes icles OE ETEN 3 OVEEVICW arado aa aa aa a e a eieaa 3 Placement of the Free Standing Track cccccccsssssssssssccccccccsssssssscccsssseeeees 4 COMIPONETIES of Syste Meusnnas a e secc esas tececehececcesbitessectice 5 Component TSC sssyeivescercsicwscystececdeticssayeivesceesccces E 6 SPC CIMIC ALI ONG Soroa S 6 Cautions soinn cic ev bebe bec sees eaves leas E i ieteescutecs 7 Assembly OPENING OF PACK AG Caicos siscceacsccnswesevaceSacivassosisscsuacensuawerevacsdacicassdssiascsvaccssuswesusess 11 Assembling the Side Supports scccccccsssssssssccccsscssssscsssscccsscccsssscssssocssssceeees 12 ASSemibly Of the Frack sessccckesetesscersserevedestet set sverevedeietosevseauevedustebsetseanevedsceesecssines 15 Assembly Mounting the Track cccccscccsssssssssssssccccccccssssssssccccsssseesssssees 17 Mounties th C300 LIE sicet sisi iui readovashiasstbapeasobaivascceni teadovashsasetbapeassbaiwasscnnivenseys 20 Mounting thie P2300 Tone einna aaa 21 Raising up the Free Standing Track System sssssscccececcccosssssssssssseeecsessossooso 22 Full raised Free Standing Track cseeccocs
9. ature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 05 01 2012 Page 33 Service Record History Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Free Standing Track User Guide Part 633282 Complete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspecti
10. d dealer immediately Trolley does not park Parking hole is filled with dirt or 1 Clean the hole with cloth and remove dirt or debris debris Trolley spring is damaged 2 Contact local authorized dealer Trolley lock button is damaged 3 Contact local authorized dealer immediately The folded track is not locking on the Track Handle Lock hook dam Do not use the system Post assembly aged or broken Contact your local authorized dealer immediately Track Handle Lock Push button damaged or broken Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 29 Ratchet sticks out when lowering or Ratchet spring is damaged Do not use the system Contact your local au raising and dose not lock thorized dealer immediately Track Lock Not working Physical damage to track lock Unfold the Track and the fold it together to see assembly if the track lock set it self in locking position Track Lock Spring breaks or or not If not then contact local authorized deal damaged er immediately Do track assembly steps and see the if the track locks or not If not then contact local authorized dealer immediately Ratchet can be pushed out when the 1 Clamp bolt is loose Open the Clamp Lever and use a 3 16 Allen clamp lever is locked key to tight the bolt one turn at a time Close the clamp lever and then push the Ratchet to see if it opens up Note Do not over tight the bolt You should be still able to close the clamp lev
11. e Free Standing Track System Serial Date of Purchase Date Installed Purchased From Address City Post Code Telephone No Comments SERVICE INFORMATION Contact the following company for service Company Address City Post Code Telephone No Comments Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 32 Service Record History Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Free Standing Track User Guide Part 633282 Complete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Sign
12. e used to lift and transfer indi viduals from a bed chair or similar fixture It needs basic level of expertise to assemble or setup It is easy to assemble and can be completed by just one person in a short period of time Additionally no tools are re quired It is also light weight and once dismantled can be moved to another location Its quick setup less than 5 minutes and lightweight assemblies allows the caregiver to transport and transfer the client with minimum effort Please review the following pages that outline the parts included with your package Should you have any questions about this product or its use contact your local authorised dealer Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 3 General Placement Portable Lift Side Support Assembly General Placement Requirements 1 The Bases of the Free Standing Track must always be placed on a hard level surface 2 Do not place the Bases on surfaces that will cause them to wobble or be unstable Make sure the surfaces are free of any obstacles that may cause the Bases to be unstable 3 Never place the Bases on wet surfaces 4 Assemble the Free Standing Track so that the Track 1s directly over the location where the transfer will occur For beds this is generally between 39 45 1000mm 1145mm from the head of the bed For wheelchairs living room chairs recliner chairs and similar furniture this is directly above the middle center of
13. er Failing to do that user side of the Free Standing Track following steps 2 might experience resistance in lowering down the posts Step 5 Bring the Free Standing Track to the shoulder height Step 6 Push the safety lock button to unlock the track from and dismantle the lift from the trolley following the user manu Post assembly al of the lift Step 7 Press the Push button and Twist handle in unlock di Step 8 Repeat step 11 amp 12 for other end to unlock the track rection at the same time from both ends Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 24 Disassembly of Free Standing Track Step 9 Lift The track up from post assembly and place it on Step 10 Press the Track lock hook as shown in figure to fold the floor the track While holding the lock slightly fold the track Step 11 Let go of the lock and fold the track Step 16 Close the track fully Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 25 Disassembly of Legs Step 1 Pull the hinge slightly upwards as shown AN Caution Do not place your finger in figure underneath the hinge Step 2 Grab The side leg and press in as shown Step 3 Fully closed legs Repeat the steps 1 to 3 in figure Repeat the step 1 and 2 for the other side for the other leg and post assembly Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 26 Trolley Disassembly Removing Trolley C 300 Prism part number
14. er without any problem If problem persists contact your local authorized dealer immediately Question The Free Standing Track seems unstable Should I be worried Answer No you should not be worried concerned Provided the Free Standing Track has been in stalled per the manuals specifications After spending some time with the device especially once a client has become accustomed to the device the lateral stability issue will be less obvious Question How stable is the device Answer This device has been tested as per ISO 10535 requirements for Free Standing Hoists This testing includes a 10 degree tilts test on all four sides with 375lbs 300lbs safe working load x 1 25 The hoist has passed all testing procedures Question Is the device strong enough to stand the load of 300Ibs Answer This device has been tested to maximum load of 450lbs 300lbs safe working load x 1 5 The hoist has passed the test with no sign of defect Question Ifthe floor has a slope will the trolley slide towards the direction of slope by itself Answer A braking mechanism 1s integrated to the design of the trolley which prevents it from slid ing unintentionally You need to apply force to be able to move the trolley to the desire location Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 30 General Inspection and Maintenance A Failure to follow inspection and maintenance instructions below may result in serious in
15. free of dirt amp debris Clean all 8 Rubber pieces Wipe off the dirt with a wet cloth as shown in picture Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 9 Assembly of the supporting Post Step 1 Place the Post in Standing Position Step 2 Grab the Side leg to open the foot Always support the post with one hand and open the leg with the other hand Step 3 Open the other leg of the post Make sure that the Step 4 Completed Post assembly both hinges are flat and they can not go further down Note Follow Steps 1 4 to finish 2nd post assembly Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 10 Completed Post Assembly of Free Standing Track Track Holders Must face each other J F Distance the 2 posts at 8 Feet apart from each other and completely parallel Track Holder Must face each other as shown in above Figure Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 11 Trolley Installation Step 1 Detach the hook eyelet of trolleys as per step 1 in Step 2 Fold and place the track on a secure place Insert the trolley disassembly page 27 by removing the split ring and trolley into the middle of the track pin Step 3 Using a screw driver push the trolley lock button io to be ue to fit the trolle into the a openin ate dae ae raat ed open y aoe using the pin and split ring Free Standing Track User Guide Part 633282 Rev 05 01 20
16. g loops to the hanger bar hooks Use the same loops on each side Double check the sling attachment to the lift Lift the resident only as high as necessary Moving the lifter with a patient in the sling 1 person pushes lift while the other controls the resident using the hand loops Lower the lift until the resident is sitting on the chair or lying on the bed Remove the sling loops from the hanger bar hooks and prevent the hanger bars from coming in contact with the patient Back the lift away from the resident and remove the sling Make certain the resident is safe and comfortable before leaving KNOWLEDGE CAN THE EMPLOYEE O OW WOUODOUUOUOU Identify lifting capabilities maximum weight Identify location and use of Emergency Stop Switch Identify location and use of Emergency Lowering Identify location and use of Auxiliary Up Down Switch Identify Low Battery Indicator light and or LCD Battery Display Demonstrate how and when to recharge batteries Properly use the Scale attachment Identify sling parts head support shoulder loops leg supports leg loops stabilizing handles Demonstrate ability to adjust angle of recline to maintain hip precautions Demonstrate transfer of patient using Vancare ceiling lift from bed to to chair chair to bed and floor to bed Demonstrate proper understanding of how to clean the sling and lift Refer to Operator s Manual for more detailed description of tran
17. jury or death Periodic general inspection and maintenance should be performed by a person who is properly qualified and trained with the use and care of The Free Standing Track System Any defects and damage to the Free Standing Track that have lead to corrective actions should be noted and dated by the inspector The defects and corrective actions report should be submitted in written form to the dealer Upon Receipt of The Free Standing Track system e Ensure all the received components are according to the component list e Ensure the user manual is present otherwise do not install the Free Standing Track system e Ensure all the components are in working condition and not damaged e Ensure service record history forms are included in the package to record any completed service and re pairs e Complete the Purchase and Service Information as soon as this equipment 1s installed Each Use Io be completed by user Prior to each use the Free Standing Track and associated lift accessories and sling s must be visually in spected Refer to the lift accessory and sling user guides for specific details regarding their inspection Should any of these items below fail the inspection do not use the Free Standing Track Contact your local authorized dealer for service Visually check for the following O Ensure all the components of Free Standing Track System are in working condition If damaged please contact the dealer for replace
18. lation 1 Feet are not cleaned 1 Clean the feet as per Cleaning Rubber Feet 2 Floor is not cleaned Instructions 2 Ensure floor area is dry and free of debris If problem persists contact your local authorized dealer immediately Clamp Lever can not be fully closed 1 Clamp bolt is tight Open the Clamp Lever and use 3 16 Allen key to loose the bolt one turn each time Close the clamp lever and see if closes fully After clos ing the clamp press the ratchet You should not be able to open the ratchet If the ratchet gets open while the clamp is fully closed it means that you have loosen the bolt too much Tight the bolt back till you are not able to open the latch Note Do not loose bolt too much If problem per sists contact your local authorized dealer immedi ately The Folded Track does not sit properly 1 Physical damage to track Check for physical damage to track If so con on the post assemblies 2 Handle lock is in lock position tact local authorized dealer immediately Follow the track assembly instructions and open the handle lock Posts are not parallel or not standing complete ly straight Trolley does not move smoothly along 1 Physical damage to track or trol Visually make sure tracks and wheels are not the adjustable track ley wheels damaged Track slots or trolley wheels are Ensure that tracks are cleaned with cloth and not cleaned free of dirt If problem persists contact local authorize
19. ment before use O All 4 feet are on a stable level surface and the supporting post assemblies are secure E Check rubber feet for damages If damage is noticed please contact dealer for replacement Make sure that they are clean before placing them on the floor refer to cleaning rubber feet instruction The Post clamps are locked The ratchets are locked The handles are locked The trolley moves easily along the track The adjustment track is placed in the correct location for transferring Ensure the labels are legible and in good condition If not contact dealer for replacement Record the service record history form for any completed service and repairs Ensure that the service record is signed and dated each time it is used The portable lift has been inspected as outlined in it s owners manual q0 0U O0 uu H0U 0 AA The sling s has been inspected as outlined in it s owners manual Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 31 Service Record History Initial Information Complete the following section Purchase and Service Information as soon as this equipment is installed Use the service record history to record any completed service and repairs Ensure that the service record is signed and dated each time it is used Be sure to have this piece of equipment serviced on a regular basis as described in the General Inspection and Maintenance Section PURCHASE INFORMATION Product Nam
20. on o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 05 01 2012 Page 35 Free Standing Track User Guide If you have any questions about the manufacture or operation of this equipment please contact Vancare or your local authorized dealer We move body and mind Manufactured for Vancare Inc 1515 Ist Street Aurora NE 68818 Telephone 402 694 4525 Fax 402 694 3994 Toll Free 1 800 694 4525 Rev 2 06 09 Page 36 We move body and mind VANCARE Ceiling lift Skills Observation Assessment Staff Member Observed Date PROCEDURE DID THE EMPLOYEE DU OW OO UUW OOOD DUCS Have the required number of staff members present Select the correct size sling Inspect the sling and lift for damage and proper operation If DAMAGED did the employee get another lift sling and notify charge nurse Correctly position the sling so that the bottom center of the sling is at the tailbone Perform environment assessment and move objects that would impede operation of lift Move the lift into position with the hanger bar in the H position in front of the resident and the base properly opened Properly use the locking casters locking only on ramped surfaces Lower the lift using the Pendant Switch Connect the slin
21. on o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 05 01 2012 Page 34 Service Record History Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Free Standing Track User Guide Part 633282 Complete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspecti
22. r Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 15 Assembly Mounting the Track Continued Step 8 Grab Track Lock handle A big gap should be visible after locking handle Spring should be visible after locking handle AA gt 7 AA Step 10 Twist until you hear a click indicating that Note Above picture shows that the track track is locked in position and the Safety lock pops is not completely locked You should hear out Note Big gap between the Track and the safety lock indicates that track is locked as shown above a click sound and spring should be visible Step 12 Repeat steps 9 11 to lock the other side of the Track Note Read instructions for mounting a Portable lift to the Free Standing Track on the next page For ease of assembly Track should be raised up untill your eyelevel before mounting the Portable lift Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 16 Mounting the C 300 Lift Ln Caution Prior to mounting the C 300 lift onto the C 300 trolley read the owners manual of the C 300 lift Be sure that the instructions on the use of the lift and any accessories such a slings are thor oughly understood before attempting to use them with the Free Standing Track Free Standing Track is rated only for 300lbs Do not exceed the limit of the Free Standing Track Ln FAILURE TO COMPLY WITH THIS MAY RESULT IN INJURY TO THE INDIVID
23. s are locked always when in use e During the use of Free Standing Track do not bump or lean against the posts This might cause system to become unstable e In places where more than one operator will be responsible for using the Free Standing Track associated lift and sling s it is imperative that all operators be trained in its proper use e To maintain optimum function the Free Standing Track should be inspected and maintained on a regular basis See the section titled General Inspection and Maintenance e The manufacturer s warranty is void if persons unauthorized by Vancare perform work on the Free Standing Track System Do not attempt to lift the patient at an angle See below picture Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 8 Assembly A Caution Before using the Free Standing Track the Post assembly and track must be visually checked to ensure that they are not damaged Should anything look unusual contact your local deal er prior to use Failure to comply with this caution could result in serious injury to the operator the individual being lifted and or damage to the Free Standing Track and or portable lift unit Cleaning Rubber Feet Prior to each installation clean the rubber feet with wet cloth soaked with water Note After cleaning Make sure the rubber feet are clean and dry with no residue of dirt or dust left on them Also ensure Floor area is cleaned and
24. sfer technique LI Pass LJ Fail Observations Observer s Name Observer s Signature VANCARE INC PHONE 800 694 4525 1515 FIRST STREET FAX 402 694 3994 AURORA NE 68818 WEB www vancare com
25. sssccccccccssssseccecoossssesecccoossssesceecossssse 25 Disassembly of Free Standing Track sssssssccccccsssssseccccocssssssccccoosssssseeesossssse 26 Dis ssemDply OF POST scxcewsisscveccssticescossctasacececeiees Soraa uosa OTENE SVOTE ETERS ei aaa E 30 Packaging of POSI oooi a a aaa 31 Packasing OF LraCK coscceinror vai debsodecesevavevdaucadeuscebivan vetdadetecateveivevensensetx 32 Packaging of Roling Bag ice cccecscscsiscraencechceccssiin aes aa 33 Trouble SNOOUWN Gee csiccs testis cesceeatoceteteusend dd e r is 34 General Inspection and Maintenance ccccssssscscccsssssscccccccssssscccsesssscccsseees 36 Service Record History Initial Information sssccsssssccccccscssssssssccceees 38 Service record History sissies aean aaa aa 39 Contact Informatio Msns aea a Er Ea 42 Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 2 CAUTION DO NOT ATTEMPT TO USE THIS EQUIPMENT WITHOUT FIRST UNDERSTANDING THE CONTENTS OF THIS MANUAL Introduction Before using this equipment and to ensure the safe operation of your Free Standing Track system carefully read this entire manual especially the section on Cautions The Free Standing Track system is designed to be used in conjunction with Vancare portable lift units accessories and slings Please refer to any user guides supplied with these components and reference them while reviewing this manual Should any questions arise from reviewing
26. the seat Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 4 Components of the Free Standing Track Track Assembly Locking Handle 433200 E Post Assembly Right hand 433201 Leg Assemblies 433203 Post Assembly Left hand 433202 u Ratchet G Figure 1A Disassembled Free Standing Track Minimum Maximum Dimensions 3 Wide W x 5 7 5 Adjustable Height H x 8 Length L Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 5 Component List The following components are included with your Free Standing Track CAUTION DO NOT EXCEED THE CAPACITY OF THE FREE STANDING TRACK Maximum Safe Working Load of 300 LBS Specifications of the Free Standing Track e High strength lightweight Aluminum Track weight is 15 lbs Post and leg assembly weight 12 Ibs Unit weight is 41 Ibs including trolley e Portable installation e Eliminates the mounting of a connection system in the ceiling e One person set up less than 5 minutes e Addresses a number of different set ups e Weight capacity Maximum Safe Working Load of 3001b e Adjustable in height Minimum height 5 feet Maximum height 7 5 feet Height adjustable in 2 inches increments Model Table for the FST 300 System 341400 Free Standing Track Free Standing Track User Guide Part 633282 Rev 05 01 2012 Page 6 AN Before you start Check Requirements
27. this manual contact your local authorised Vancare deal er Failure to comply with warnings in this manual may result in injury to the operator or the individual being lifted transferred Damage to the lift and or related components may occur Be sure that the contents of this manual are completely understood prior to using this piece of equipment Store this manual with the documents included with the lift system and sling s Contents of this manual are subject to change without prior written notice Overview of the Free Standing Track System The Free Standing Track system is a lifting aid to help lift position and transfer clients or a disabled family member The Free Standing Track system is part of what is termed overhead lift technology which takes ad vantage of lifting from above and not from below or the side The Free Standing Track system makes it possi ble to move mobility impaired individuals with minimal strain or risk to the caregiver while providing com plete safety dignity and comfort for the client or family member The Free Standing Track system is designed to work with a Vancare portable lift system such as the P C 300 Free Standing Track Maximum Safe Working Load is 300lbs Use of other portable lift units with this system may be possible However please contact your local authorised Vancare dealers in order to obtain approval before use The Free Standing Track system is a floor based free standing system that can b
Download Pdf Manuals
Related Search