2. - MagicFX
Contents
1. PIC 307 Danger high voltage A warning must be given about the machine s high voltage by using the caution sign PIC 307 This sign must be attached to the Stadium Shot See also the added photo Page 9 7 ONDERDELEN 02 gt N OT LO User documentation MAGICFX Stadium Shot 8 ACCESSOIRIES MFX0404 Compression Tape MFX0407 Pressure Caps amp Lifiting cores Table 8 1 You can order these parts and accessories from MAGIC FX B V Schouwrooij 27 NL 5281 RE BOXTEL The Netherlands 31 0 411 63 50 13 31 0 411 63 50 12 W http www magictfx eu info magicfx eu Page 11 Version 1 0 9 PREPARATIONS Unpack the Stadium Shot Dispose of the packaging material without harming the environment Inspect the machine for any damage If damage is noticed this must be reported to MAGIC FX Take a carton lifting core and lower this to the bottom of the shooting tube to close off the hole Check if the lifting core lies flat Now fill the shot pipe with the required type s and colour s of confetti and or streamers For an extra effect try to mix streamers and confetti When the shot pipe is fully filled you take for maximal effect a pressure cap and place this over the end of the shooting tube to close it off Tape the edge of the pressure cap with the special pressure cap tape Page 12 User documentation MAGICFX Stadium Shot 10 INS2. suggestions and advice regarding easier or more convenient ways to carry out certain tasks CAUTION The machine can be damaged if you do not follow these procedures carefully DANGER WARNING The MAGICFX Stadium Shot may only be installed by adults and authorised persons The Stadium Shot may only be operated if all parts are completely and correctly installed connected For using the Stadium Shot take the following steps The Stadium Shot will release a shot as soon as the magnetic valve is powered by a 220V electricity source Take a 220V switch and make sure that the electricity is switched off Then insert the plug into the socket of the switch Press the switch to the on ON position to enable the Stadium Shot to shoot Immediately after the shot press the switch again to the off OFF position FIRE SWITCH FIRE Page 17 Version 1 0 12 SWITCHING OFF To switch off the Stadium Shot take the following steps Disconnect the power cable the emergency stop and the switch and put these away Disconnect the air hose and remove the compressor Check to make sure there is no more pressure on the tank Remove any remaining pressure by opening the venting valve Unscrew the shot pipe from the screw thread integrated in the tank and store these in their flight case holder STADIUM SHOT Page 18 User documentation MAGICFX Stadium Shot Lastly check if the machine is co
3. 0V 50 60Hz Usage 100W Confetti Tot 20m Output Streamers Tot 30m Stadium streamers Tot 50m Design and product specifications can be changed without prior notification 15 MAINTENANCE To achieve the maximum service life of the Stadium Shot you must regularly clean the Stadium Shot and test if it is working correctly Should the Stadium Shot not work for some reason then please contact MAGIC FX DANGER WARNING Do not replace parts yourself always consult MAGIC FX if necessary 16 GUARANTEE A manufacturer s guarantee of 3 years applies to the MAGIC FX Stadium Shot guarantee expires if the Stadium Shot is used for improper purposes and for applications which are not stated in this manual guarantee also expires if the machine is used incorrectly or in violation of the regulations guarantee expires if the machine is altered without permission from the supplier Page 20
4. ACCESSORIES as 6 5 3 STREAMERS E 7 6 SAFETY SSD aaa aaa 8 6 1 INTRODUCTION is o E a OE as 8 6 2 GENERAL SAFETY RULES a a e 8 6 3 WARNINGS azi 9 7 ONDERDELEN 10 8 11 9 12 105 INSTALLATION o 13 Tie USAGE errr ter rere errr 17 12 os 18 13 TROUBLESHOOTING 20 14 TECHNICAL SPECIFICATIONS oo 20 18 a 20 16 GUARANTEE 20 Page 5 Version 1 0 5 INTRODUCTION 5 1 DESCRIPTION AND APPLICATION OF THE STADIUM SHOT The Stadium Shot is a confetti shooting system which has been specially developed for shooting confetti or streamers in a stadium or at another outdoor location Any use other than that described above will exclude your supplier from any liability 5 2 NECESSARY ACCESSORIES The following parts belong to the Stadium Shot Manual MFX0405 Compressor MFX0407 Pressure Caps amp Lifiting cores Table 5 1 Confetti of Streamers Page 6 User documentation MAGICFX S
5. TALLATION CAUTION The machine can be damaged if you do not follow the procedures carefully DANGER WARNING The MAGICFX Stadium Shot may only be installed by adults and authorised persons Prepare the Stadium Shot for use as follows Place the Stadium Shot on an even solid and stable surface Open the cover of the Stadium Shot Page 13 STADIUM SHOT mec STADIUM SHOT ee earn LEA STADIUMSHOT ol ie Version 1 0 Take the filled shot pipe from the holder in the flight case Screw the shot pipe on the screw thread integrated on the tank Turn it securely until the end of the thread Check to make sure there is no more pressure on the tank Determine the required direction for the best effect Secure the tank by turning the two fastening buttons Make sure to twist these buttons properly until the tank is entirely secured Always check to make sure the tank is firmly secured Page 14 User documentation MAGICFX Stadium Shot Page 15 Put all 4 wheels on their brakes and check if the entire flight case is standing stably and securely Note during a shot a backlash is created through which the flight case can move if it has not been properly secured Take a compressor with a maximum pressure output of 8 bar which meets the safety requirements and standards concerned and connect the hose to the quick connect coupling of the tank and the
6. TMT AG MANUAL MAGICFX STADIUM SHOT VERSION PRODUCT CODE MFX0401 1 0 DATE 11 01 2013 User documentation MAGICFX Stadium Shot 1 CONGRATULATIONS You have bought a great new product from MAGICFX MAGIC FX is a Dutch manufacturer of professional special effects machines and equipment We have been experts in special effects since our establishment in 1995 All our products are made under the brand name MAGICFX which by now has acquired a great reputation on account of its quality and reliability All products are made in accordance with the European Machinery Directive MAGIC FX manages the entire production process in house from the design stages and prototyping to production In short we cover everything from concept to ready to use product Moreover MAGIC FX is Europe s largest supplier of high quality and fireproof confetti products and streamers Thanks to our very large stock levels we can deliver quickly and at low prices MAGICFX is used by special effects professionals all over the world and our products are distributed through a dealer network which covers more than 80 countries Congratulations and enjoy your purchase 1 Version 1 0 2 MARKING PLEASE NOTE We presume that you your employees and others who use or come into contact with the machine are familiar with how the machine must be dealt with This includes the correct use main
7. ction in which the shot pipe on the Stadium Shot is pointed The output distance depends on the content and pressure of the Stadium Shot sure that children unauthorised people and animals not obtain access to the Stadium Shot Do not take hold of the Stadium Shot while it is working or is switched Also when the Stadium Shot is not working the electric cannon may still be filled Safety devices may not be removed or disabled All required safety devices must be in good condition and function properly Ensure sufficient lighting of the surroundings Keep the workplace clean Only authorised persons may carry out work with the Stadium Shot Page 8 User documentation MAGICFX Stadium Shot 6 3 WARNINGS Warning texts have been attached to the Stadium Shot With regard to these the following rules apply These texts may not be removed or damaged The operator must regularly check if this is the case operator must ensure that the texts and remain clearly visible and legible DANGER WARNING One must replace texts or signs if these are absent damaged or illegible Sign and explanation PIC 616 Follow the instructions The operator must be told that he she may only operate the Stadium Shot after reading the user manual A warning is given for this by means of the command sign of PIC 616 This sign should be attached to the type sign See also the photo Sign and explanation
8. mplete and if this is the case then place the cover back on the flight case Page 19 Version 1 0 13 TROUBLESHOOTING The Stadium Shot leaks from the tube Remove the pressure from the tank and close the valve Then connect the compressor close off the tube with your hand and start the compressor Let the pressure rise to 2 bar and then take your hand off the tube the pressure in the Stadium Shot should now increase to rise to 8 bar If not repeat this process The Stadium Shot leaks from the flap Remove the pressure from the tank and close the valve Make sure that the Stadium Shot is not connected to an electricity source Remove the bolts with a wrench and then remove the part of the flap that is loose Remove the rubber membrane from the flap Clean the metal part of the membrane Then mount this back again and firmly screw the flap back on Repeat these steps for the large part of the flap 6 bolts The Stadium Shot is still malfunctioning after troubleshooting Always contact your dealer or the technical service of MAGIC FX first in case of uncertainties questions about the Stadium Shot works or other issues with regard to the Stadium Shot 14 TECHNICAL SPECIFICATIONS Length 770mm 30 3 Width 580mm 22 8 Height 750mm 29 5 Measurements Pipe length 650mm 25 6 and weight Pipe diam 110mm 4 33 Weight 70 154 5lbs Contents 33 Liter Max pressure 8 Bar 115 PSI Input AC 23
9. quick connect coupling of the compressor Activate the compressor and fill the tank until the compressor turns off or the manometer indicates that the pressure in the tank is 8 bar Make sure that the pressure does not exceed 8 bar You may disconnect the compressor after filling the tank Watch the pressure closely The pressure in the tank can increase in case of high temperatures If the pressure exceeds 8 bar then use the ventilation valve to remove some air and bring the pressure back to 8 bar or less Version 1 0 CAUTION Always attach the tank properly with the fastening buttons Only work with an inspected and certified professional compressor with an air output of no more than 8 bar Carefully read the manual of the compressor prior to use When the Stadium Shot is ready for use never leave the Stadium Shot the emergency button and the switch unattended Make sure that the surroundings of the Stadium Shot are free of people or moving objects Keep at a safe distance from the public The recommended distance is at least 25m Never leave the tank under pressure for more than 15 minutes Regularly check to make sure the pressure in the tank is stable The pressure can rise through heat Should this happen then immediately open the venting valve and let the air escape until the pressure level drops below 8 bar Page 16 User documentation MAGICFX Stadium Shot 11 USAGE TIP Gives you
10. read this user manual carefully from beginning to end MAGIC FX also insists that all new users operators installers maintenance workers and cleaners receive a training course in which this user manual can serve as a starting point MAGIC FX advises that the original of this user manual including appendices is kept at a safe and central place It is best that another original or copy is kept close to the Stadium Shot at the workplace If you are familiar with these matters then you can use this manual as a work of reference The following standard markings are used in this manual for drawing attention to certain subjects or actions TIP Gives you suggestions and advice regarding easier or more convenient ways to carry out certain tasks PLEASE NOTE A comment with additional information alerts you to certain problems CAUTION The machine can be damaged if you do not follow the procedures carefully DANGER WARNING You can get seriously hurt if you do not carefully carry out the procedures Page 4 User documentation MAGICFX Stadium Shot CONTENTS 1 CONGRATULATIONS Sinise EE E E E a 1 2 CE MARKING 2 3 DECLARATION OF CONFORMIT Y ee 3 4 PORE WORD 4 5 INTRODUCTION 6 5 1 DESCRIPTION AND APPLICATION THE STADIUM 6 5 2 NECESSARY
11. t the technical department of your supplier for extra information with regard to for example maintenance and repair This user manual has been drawn up with the utmost care MAGIC FX cannot be held responsible for any mistakes made in this publication or for any consequences thereof Page 2 User documentation MAGICFX Stadium Shot 3 DECLARATION OF CONFORMITY DECLARATION OF CONFORMITY Module B C1 Art 9 10 Att Il Directive 97 23 EC COMPRESSED AIR TANK Code Drawing MFX0401 671844 Manufacturer Year MAGIC FX B V Type Mark STADIUM SHOT 510 16 1 Design pressure Pneumatic pressure test 8 0 bar 8 8 bar Min Design metal temperature Max Design metal temperature 0 70 C Capacity Category 33 0 L Approval nr 03 05 07 01 dtd Applied norms VSR pressure calculations AD Merkblatt Fatigue Stress AD Merkblatt Pressure test Notified Body ICEPI SpA EU nr 0066 Approved MAGIC FX drawing PED Module 680927 rev A B C1 Pressure test Test time Pressurizing fluid 8 8 bar 3 minutes Filtered air The Stadium Shot passed the MAGIC FX test procedure Page 3 Version 1 0 4 FOREWORD This manual describes the MAGICFX Stadium Shot The information in this manual is important for the proper and safe functioning of the Stadium Shot If you are not familiar with the installation operation preventative maintenance etc of the Stadium Shot then please
12. tadium Shot 5 3 CONFETTI amp STREAMERS The Stadium Shot offers the possibility to shoot various loads The following fillings are possible CONTENTS WEIGHT OUTPUT PAPER CONFETTI METALLIC CONFETTI 5m x 0 85cm 30 Polybags STREAMER 1500 streamers me STREAMER 800 streamers 10m x 5cm 12 Polybags STREAMER 120 streamers 20m x 5cm 8 Polybags STREAMER 80 streamers 7 Table 5 2 CAUTION Metallic products are somewhat heavier and will therefore achieve a larger output Page 7 Version 1 0 6 SAFETY 6 1 INTRODUCTION The Stadium Shot has been designed and constructed in such a manner that it can be used safely This applies to the use the circumstances and the regulations as described in this documentation Reading this documentation and following the instructions are therefore necessary for everyone who is authorised to work with the Stadium Shot The Stadium Shot must be placed and used in surroundings that preferably Have areasonably stable temperature of between 0 and 30 C Have a relative humidity degree of no more than 75 Are reasonably free of dust corrosive gases and high concentrations of organic vapours not situated in the vicinity of a source of vibration 6 2 GENERAL SAFETY RULES Only use the Stadium Shot if there are no people animals or other objects in the direction of the shot pipe within the output distance The shooting direction is the dire
13. tenance and repair of the machine as described in this user manual This also means that the employees are familiar with the use of machines through training or experience DANGER WARNING Only use the Stadium Shot in accordance with the regulations and instructions in this manual Consult MAGIC FX in case of doubt Disclaimers MAGIC FX B V excludes liability for unsafe situations accidents and damage that are the result of Disregard for the warnings or regulations as set out on the Stadium Shot in this documentation Use for other purposes or under other circumstances than those set out in this documentation Alterations to the Stadium Shot This also includes the use of replacement parts other than the Original ones Insufficient maintenance Unauthorised removal of safety caps and or safeguards Incompetent operation of the machine MAGIC FX B V is not liable for any consequential loss the event of a Stadium Shot breakdown Copyright 2012 All rights are reserved Nothing from this manual may be duplicated or kept in an automated data file or made public or in any form or manner whether electronically mechanically by photocopying by incorporation or in any other manner duplicated without the permission of MAGIC FX B V MAGIC FX at all times retains the right to make alterations without the direct knowledge of the client The contents of this user manual can also be changed Please contac
Download Pdf Manuals
Related Search