User Manual
Contents
1. FJ TDEO07 Warning FJ TDEO7 Please pay attention to the following safety advices in order to enjoy a safe driving experience First of all you need to charge your batteries fully before using it Read carefully this User Manual and before riding check if the vehicle is in perfect working condition Overloading is strictly prohibited In order to insure the battery s lifespan a charge should be done after each use Total discharges are harmful It is forbidden to touch the electric contacts in the battery box Touching with wet hands or metal objects sim ultaneously in the positive and negative contacts could cause injuries and or burns and short circuit in the vehicle Please pay special attention to this point Please do not disassemble or repair without technical assistance from an Authorized Dealer and always use original parts A poorly performed maintenance can cause damage and or accident This vehicle can run normally since the water level does not exceed the center of the electric motor at the risk of water infiltration and short circuit damage and accidents Use of a bicycle helmet regular checks on brakes tyres steering rims and caution concerning possible increased braking distances in wet weather Index FJ TDEO7 Parts description 1 Daily checks MMMM MMMM MMMM MMMM M 2 Assembling instructions2. the socket in the battery box 4 Then connect the input plug 110V 220V terminal to the power outlet and the charging will Start 5 After the charging has finished first unplug the input plug terminal 110V 220V and then the output plug About Charging FJ TDEO7 Charger socket When the battery is charging on the bike 1 Please switch off the power and remove the key 2 Remove rotate to open rubber stopper in the charging hole and the stopper should be kept well Then first plug in output plug 24 36V terminal of charger to the socket of battery box after that plug in power input plug 110 220V terminal to household power socket to start charging 3 After charging is finished first pull out the power input plug 110 220V terminal and then pull out the output plug Duration ifcharging ft 1 When the input and output terminal are connected the red indication light of the charger will be turned on showing that the power is being connected 2 When the battery is charged for the first time 8 10 hours should be spent for charging When the green indication light of the charger is turned on showing that the battery basically full and it will switch to trickle charge mode to ensure that over charging will not occur it takes 2 8 hours for normal charging 3 This charger has the protection device for over charging Long time charging should not be more than 24 hours without affecting the life time of the bat
3. ad protection If on overload energy will be cut automatically and restored when it returns to normal 5 While driving avoid using the throttle as you brake as it may damage the motor 6 The maximum load is 90kgs Avoid driving with superior weights Do not drive too fast Important tips when parking I 1 When pushing the vehicle manually turn off the power to avoid accidental acceleration and accidents 2 It is recommended t o park indoors Do not forget to switch off the power and remove the key 3 In a public place the vehicle must be parked in accordance with local traffic rules Do not forget to switch off the power and remove the key Driving FJ TDEO7 How to start up the vehicle E A Insert key and turn it tothe ON position At this point the charge indicator light will turn on indicating that the vehicle is powered on Off LOCK Press ON FF to start the power Press 6km h to start 6km h speed automatic riding without pedals Press mode to select the pedal assistant power with pedals Low Med High Low 60 of max speed Med 80 of max speed High 100 of mex speed L H is indicating the battery power Option Please check the LCD display manual for details Continual mileage FJ TDEO7 Continual mileage on one time changing 25 40km active state Conditions of the testing wind speed level 2 3 normal atmosphere temperature 25 degree load 90kg atmospheric pressure 3 5k
4. g cm flat bitumen concrete surface battery full and leave factory with the bike Driving condition 20km 30km wind level 2 3 normaltemperature 25T normal load against wind level 2 3 normaltemperature 25C normal load degree of slope 2 degree wind level 2 3 normaltemperature 25 C EN APSE RD LITE normal load Max speed 25km h miles of journey Economy speed 10km h miles of journey Power consumption of one time charge lt 0 5kw h rated load 90kg Economical speed 18km h Dead load 30kg The load haul is related with road road surface times of start uo times of braking wind diresction atmospheric temperature air pressure in the tyre and correct way of charging please note this during driving Basic maintenance FJ TDEO7 For a safe driving experience please keep your vehicle in perfect condition making maintenance and washing regularly Regular self checks N 1 Tightening and correct operation of both wheels frame and front fork 2 Tire pressure and conditions 3 Gearshift correct operation 4 Bell and reflectors conditions and correct operation 9 Braking system correct operation 6 If you do not use the vehicle for long periods of time charge the battery at least once a month to avoid reducing its lifespan Maintenance and cleaningtips E 1 Do not wash withhigh pressurejets to prevent water infiltration into the electrical system 2 Dirt on painted surfaces should be removed with a neut
5. meter indicates the voltage is low switch to manual power and avoid using the battery so you don t shorten the battery life 9 If the battery is being stored remove the battery from the bicycle and recharge it every month
6. of FJ TDEO7 3 Battery charging 44 4444 9 About cCharging 6 Driving 444mm HH nn 8 Continual mileage 10 Basic maintenanCe 11 Diagnose an troubleshooting 12 Recommended torque values for threaded fasteners 13 Minimum saddle height and the way to measure 14 The wiring diagram for FJ TDEO7 with 3 speed display 19 The wiring diagram for FJ TDEO7 with LCD display 16 Battery maintenance and saving tipS 17 Useful tipS 18 Parts description FJ TDEO7 Saddle Height Adjusting Battery tube a Adjusting tube lock Z Front shock absorber f f Pedal Power switch Rear wheel adjuster Daily checks FJ TDEO7 To ensure your safety make the following functional checks before driving 1 Normal operation of
7. r 1 Adjust the tire pressure 2 Check the connections and or fully charge the battery 3 Help with the pedals 4 Replace the battery 5 Make a prolonged battery charge 1 Adjust the connections 2 Replace the fuse 3 Reconnect repair the wiring 1 Replace the bearing 2 Adjust replace the rim For your safety do regular maintenance and tightening checks If you find any abnormality The wiring diagram for FJ TDE07 with 3 speed display FJ TDE07 Battery Brake lever Note 1 HYXF MOTOR 2 3 speed with hall controller 7 a x s i WORT RR pr Remark 1 Except label wire diameter other 0 30mm R red B blue Bk balck G green Y yellow Pr purple W white Pink pink O orange 2 All connector terminal is elextrolytic tinning Cam blue cambridge blue 3 All wires are national standard wires Battery maintenance and saving tips FJ TDEO7 Frequent braking and starting ridinguphill traveling against a strong wind starting from a standstill and riding on rough or muddy roads and carrying more than one person or heavy loads will consume extra battery power and shorten the range A few tips to prolong the battery life during these conditionsis as follows 1 Frequent Braking try to look ahead and coast rather thanstop and go frequently 2 Riding uphill or against a stiff wind pedal to supliment the battery power 3 When starting from a standstill use the pedals to help bring you up to speed 4 When the battery
8. ral product Then wipe with a dry cloth 3 Lubricate the vehicle with suitable lubricant after washing 4 Do not apply lubricant on the brakes brake levers rims tires battery and controller HO Symptoms It doesn t work Irregular accelera tion and or reduced top speed When powered on the motor doesn t respond Reduced range The battery won t charge Driving wheel makes strange noises repair immediately Diagnose and troubleshooting FJ TDE07 Possible causes 1 Insufficient battery power 2 Faulty connections 3 Key in wrong position 1 Insufficient battery power 2 Loose throttle magneto 3 Damaged throttle spring 1 Loose wiring 2 Loose throttle magneto 3 Loose or damaged motor wiring plugs 1 Low tire pressure 2 Low or faulty battery charge 3 Driving with too many hills headwind braking depar tures and or excessive load 4 Battery discharged for long period of time without regular charges aged or damaged 1 Charger not well connected 2 Battery cases fuse blown 3 Battery wiring disconected or with a bad contact 1 Damaged motor bearing 2 Bent or misaligned rim Most common solutions 1 Charge the battery 2 Clean the connections 3 Turn the key into the correct position 1 Charge the battery 2 Weld and adjust 3 Contact an Authorized Service Center 1 Repair and or reconnect 2 Weld and adjust 3 Contact an Authorized Service Cente
9. tery Switch About charging FJ TDE07 If charging with the battery removed t 1 The charger does not need to be connected to be grounded 2 Keep the charger in a safe place away from children 3 Do not use the battery when not fully charged That will decrease its lifespan 4 Do not charge the battery with other chargers than the original 5 The charger works with 110 220V Please do not open it without permission 6 Avoid charger contact with liquids and or metal objects Always be sure it is safely stored placed so that it can not suffer damage from a fall impact 7 When in use the charger should not be covered to prevent overheating damage or fire 8 The charger is only for indoor use Please keep it in dry and ventilated place 9 If you notice a strange smell coming from the charger or it is too hot please stop charging and contact an Authorized Center Driving FJ TDEO7 important tips while driving 1 In order to reduce consumption increase autonomy and extend the motors lifespan use the pedals during the startups and climbs 2 Do not push the throttle too fast The vehicle should accelerated slowly reducing consumption and risk of damage to the electrical system It s better to use the pedals to help during startups 3 To increase security and reduce power consumption is advised to avoid sudden stops and startups 4 The vehicle controller has a charge overlo
10. the light brake and power cut systems 2 Tire pressure low pressure will influence both autonomy and speed 3 Wheel axle tightening 4 Battery charge level 5 Braking system adjustment and free operation Assembling instructions of FJ TDE07 1 Carefully take out the electric bike from it s carton 2 Please tighten the handlebar stem with the following instruction A Use M6 spanner to tighten B Press the rubber after tightening Wse MS spannerto tighten y gt e e E aftemtightening Y Tn Assembling instructions ofFJ TDEO7 FJ TDEO7 Please tighten the handlebar stem with the following instruction Setp1 Setp2 Setp3 Battery charging FJ TDEO7 Charging methods pa The vehicle battery must be recharged when finished using or when running low You can charge the battery eitherassembled or removed from the vehicle Please take proper attention to the following charging methods 1 remove the battery case 2 with the key unlock the battery case at its base 3 remove the battery pulling the battery boxs handle With the battery removed 1 When the battery is removed do not touch the and contacts especially with wet hands or metalic objects 2 Do not recharge the battery in the inverted position If you do you risk drastically reducing it s lifespan 3 Place the charger in a flat secure place and connect the output plug 24V 36V terminal to
Download Pdf Manuals
Related Search