PDF - Fri-Jado
Contents
1. Hence there is an equal temperature everywhere in the unit and the products will be prepared nicely and equally The intelligent control keep the temperature inside the unit fixed to level set by the operator During the entire process the interior of the unit will be illuminated In order to generate steam inside the unit pulses of water will be sprayed by the fans and guided along the heating elements The number of pulses and the exact moment of injection can be set by an service technician so that there is a well defined level of humidity during every single step of the baking process The grids or GN pans are put on guiding rails so the unit depending on the height of the products can always be set to its highest efficiency The intelligent control has a capability to store 250 different programs Each program can consist of a preheat step with additional maximum 9 steps in which the baking time temperature steam intensity and the Clima Safe can be set Once a program is completely executed the control can apply an automatic baking correction to each next run of the baking program to get an identical baking result Depending on the temperature flow during the baking process the unit determines a time correction which will be added to or subtracted from the adjusted baking time This way an identical end result will always be guaranteed regardless of the load of the unit and whether the products were s2. C 95 F 39 3 16 83 9 16 83 3 8 82 11 16 il A Il DIA D A 57 94 A o gt i SE AAA du 15 15 16 2 3 8 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 17 fri jado Placing and Connecting TRC 8 ON UNDERFRAME Te l R JN UN TH IS i Li 62 5 16 lt J DESCRIPTION OF THE LABELS 1 Power cable 100 inch 2a Watersupply inlet G 34 Tube length 60 inch 2b Filtered watersupply inlet G 34 Tube length 60 inch 2a 4 Fume outlet vent oven 12 6 Drain pipe 32mm 1 1 4 7 7a Space between the oven and a wall USA 3 a Canada 10 s i Europe 2 e 7b Space between the back and a wall USA 10 Canada 10 Va DS Europe 2 Note that the minimum space between the unit and a wall differs from country This is because of local legislation The unit itself needs 2 space to any wall at a maximum ambient temperature of 35 C 95 F 39 3 16 39 1 16 42 3 16 33 11 16 rr _e_ u__o_0o0uo n jnj jpjn nn 15 7 8 I AZZ AZZ ZZ wae 30 9 16 1 7 8 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 For technical support call 1877 374 5236 z fri jado Fri Jado Inc s 1401 Davey Road Suite 100 e Woodridge IL 60517 e USA e fax 1 630 689 1424 e us info frijado com e www frijado com e USA e toll free 877 FRI JADO
3. CON ssaa 3 General technical Data TT 5 Technical Data TTT 5 Sello ala 7 PVE OG GUI ON areali 7 Description OF LNG CIE TTT 8 Unpacking and removing the unit from the pallet iii 9 Installation and POSION TTT 11 Before MIU 12 Connecting and SWITCHING ON the UNI d 13 Operation and Use siae tele ne ee ene na 14 FIFSUNCITU Place 15 Pliacing and CONNECTING aiar elisa erariali 16 TRES Stana altri diia 16 TOR ONTRC son 17 TRS ON UNdEr ame Lincei 18 Page 4 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 GENERAL TECHNICAL DATA 2 iri jado This manual covers the TRC 8i oven The TRC 8 intelligent is a boilerless combi steamer with 8 levels for GN pans or 40x60 racks All of the information illustrations and specifications contained in this manual are based on the latest product information available at the time of printing TECHNICAL DATA STANDARD MODELS Power Standard plug from factory 2x NEMA 15 50P Default cable 24 10 16 1125 mm 83 11 16 2125 mm minimum 1 2 40 mm minimum 1 2 40 mm Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 5 gt fri jado General technical data Page 6 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 INSTALLATION PROCEDURES z fri jado INTRODUCTION Outdoor use restrictions To avoid short circuiting the units may not be used outdoors unprotected Placing under a screen is allowed Figure 1
4. off Rotation pad This pad is used for e Navigating through the menu items in the screen e Changing the settings Changing the settings quickly e Increase value rub the pad clock wise with one finger e Decrease value rub the pad counter clock wise with one finger Screen The following tabs are present e Operate Choose between programs see section 5 e Program Creating programs see section 7 e Settings Change settings of programs see section 6 Page 14 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Installation procedures z fri jado FIRST HEAT UP To remove both the oil and metal odour that will appear at first use the unit must be heated at the maximum temperature for at least half an hour Press ON OFF for 3 seconds on to switch on the unit Press OK the display the menu Create a new program containing ONE step of 250 C 482 F and a duration of at least 30 minutes see section 7 Select tab Operate to return to the operation field Select the new program and press START PAUSE to start see section 4 Allow the unit to fully execute the program After the program stops the control switches to the snoozing mode AI Si The unit is ready for use Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 15 2 iri jado PLACING AND CONNECTING
5. pallet are two tie straps Dismantling of the pallet Before you can unpack the unit the pallet must be taken apart See below Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 9 ae Installation procedures z fri jado Additionally Remove all remaining packing materials from the unit Remove the protective foil from the metal parts Take off the standard accessories dI All packing materials of this unit can be recycled After unpacking check the state of the unit In case of damage store the packing material and contact the supplier within 15 days after receiving the goods Page 10 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Installation procedures z fri jado INSTALLATION AND POSITIONING WARNING The unit must be installed by a certified electrician Figure 4 Positioning e The user must have sufficient freedom of movement to properly operate the unit e The ambient temperature of the unit must be between 10 and 30 C 50 and 86 F e Use proper lifting and transport tools to move the unit e Place the unit using a spirit level flat on a solid surface Mind the weight of the unit e The distances between the sides and other units or walls must be at least 4 inch e The minimum distance between the operator side and possible glass panes or wooden partition walls must be at least 10 inch e The space between the unit and the surface it is p
6. with a two step unlocking device To open the door move the handle first clock wise then counter clock wise IS Opening the door will switch off the heating to secure the safety of the operator The baking process will resume after closing the door When loading the unit carefully use the available space inside the oven The total mass of the products must be equally divided over the baking trays and plates Loading the unit with baking plates or GN pans The oven is foreseen with two inner racks with 9 levels of supports The GN pans must be positioned between the two slides of a support Grids 600x400 and GN grids must be positioned on top of a support Start placing GN pans at the second support from the bottom Loading the unit with baking plates and GN pans If you want to load the TRC using two different accessories at the same time always fill the unit with ONE accessory fewer than the maximum allowed quantity See to it that accessories of the same type are placed consecutively For example 2 baking plates 3 GN pans Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 13 L Installation procedures gt 3 tri jado AAIA A AKAK OPERATION AND USE Control panel SELECTION BUTTONS DISPLAY SCREEN START NO FUNCTION PAUSE ON OK BUTTON OFF STOP CANCEL ROTATION PAD DIAL SELECTION BUTTONS Selecting tabs in display screen ON OFF Switching the unit on and
7. Hygiene The quality of a fresh product always depends on hygiene Especially grilling products With the risk of salmonella contamination especially for chicken products you must make sure that grilled products can never be mixed with uncooked products Also contact between grilled products and hands or tools that have been in contact with raw chicken meat must be avoided at all times Hands or tools that have been in contact with raw chicken meat must be cleaned thoroughly Service and technical support The electrical schematics of your unit is included In case of malfunctions you can contact your dealer service agent Make sure you have the following data available e Model e Serial number This data can be found on the identification plate Storage If the unit will not be used temporarily and will be stored follow these instructions e Clean the unit thoroughly e Wrap the unit from getting dusty e Store the unit in a dry non condensing environment Disposal Dispose of the machine any components or lubricants removed from it safely in accordance with all local and national safety and environment requirements Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 7 L Installation procedures gt 3 fri jado DESCRIPTION OF THE UNIT Technical description The TRC uses electrical heating elements that heat up the air inside the unit The hot air is equally divided over the interior by four fans
8. INSTALLATION MANUAL Turbo Retail Combi MODELS TRC 8 stand alone TRC 8 on underframe TRC 8 stacked with TDR 7 Model TRC 8 NOTICE This manual is prepared for the use of trained Service Technici ans and should not be used by those not properly qualified If you have attended a trianing for this product you may be quali fied to perform all the procedures in this manual This manual is not intended to be all encompassing If you have not attended a training for this product you should read in its entirety the repair procedure you wish to performto determine if you have the necessary tools instruments and skills required to perform the procedure Procedures for which you do not have the necessary tools instruments and skills should be performed by a trained technician Reproduction or other use of this Manual without the express written consent of Fri Jado is prohibited ER 1 NTER TEx gt 3 fri jado di E Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 1 SE ee Page 2 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 TABLE OF CONTENTS 2 iri jado Versions Version Issue date Remarks dd mm yy 202 15 02 2012 First release 302 07 02 2013 Update of installation drawings 304 09 04 2013 TRC on underframe added page 18 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 3 K a fri jado Table of contents HE e OFCOM
9. TRC 8 STAND ALONE LAS A E AS MY DESCRIPTION OF THE LABELS 1 Power cable 100 inch 2a Watersupply inlet G 34 Tube length 60 inch 2b Filtered watersupply inlet G 34 Tube length 60 inch 4 Fume outlet vent oven 6 Drain pipe 32mm 1 1 4 7a Space between the oven and a wall USA 3 Canada 10 Europe 2 7b Space between the back and a wall USA 10 Canada 10 Europe 2 Note that the minimum space between the unit and a wall 4 differs from country This is because of local legislation The unit itself needs 2 space to any wall at a maximum ambient temperature of 35 C 95 F 39 3 16 28 13 16 _ 4 ee 44 15 16 44 5 16 21 21 32 Page 16 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Placing and Connecting z fri jado TDR 7 ON TRC 8 DESCRIPTION OF THE LABELS 1 Power cable 100 inch 2a Watersupply inlet G 34 Tube length 60 inch 2b Filtered watersupply inlet G 34 Tube length 60 inch 4 Fume outlet vent oven 6 Drain pipe 32mm 1 1 4 7a Space between the oven and a wall USA 3 Canada 10 Europe 2 7b Space between the back and a wall USA 10 Canada 10 Europe 2 Note that the minimum space between the unit and a wall differs from country This is because of local legislation The unit itself needs 2 space to any wall at a maximum ambient temperature of 35
10. till frozen before the baking process or not To prevent undesired changing the baking programs can be protected by means of a password The unit has a semi automated cleaning program that cleans the unit after a cleaning agent is injected The plating of the unit is made of stainless steel The mains cable is provided with a plug Communication through RS232 enables easy read out re work and creating of programs via a PC For this special software is available at Fri Jado Service Intended use The TRC has been designed for preparing and warming various sorts of vegetables and meat and raising and baking off bread Any other use will not be regarded as intended use The manufacturer accepts no liability whatsoever for loss or injury caused by failing to strictly adhere to the safety guidelines and instructions in this manual or due to carelessness during installation use maintenance and repair of the unit referred to in this manual and any of its Use the unit in perfect technical condition only Accessories Your unit contains the following standard accessories e Fat Filters 4 e User manual Page 8 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Installation procedures z fri jado UNPACKING AND REMOVING THE UNIT FROM THE PALLET Unpacking the unit Your unit is shipped using a plastic cover with protecting corners covered by a carton box All units are placed on a wooden pallet Around the box and
11. ut on must be kept clear for proper ventilation of the electrical compartment e Keep a distance of at least 20 inch of free space above the unit e Incase of a wheeled unit the floor must be flat and levelled e The products inside the unit must be clearly visible e Keep children away from the operating side of the unit Installation e The unit has a mains plug and must be connected to a wall socket with the proper mains voltage The wall socket must be mounted by a certified electrician e A water connection with an aerated valve with a inch thread connection must be available near the unit The water pressure must be between 200 en 500 kPa 2 and 5 bar e An open drainage with a diameter of at least 1 5 inch must be available near the unit Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Page 11 sa Installation procedures gt fri jado BEFORE FIRST USE When using the unit for the first time clean the interior thoroughly with soap suds and heat up the unit Clean the interior Page 12 Installation Manual Turbo Retail Combi form 9123866 rev 04 2013 Installation procedures gt 3 fri jado CONNECTING AND SWITCHING ON THE UNIT Loading the unit WARNING To protect the operator for possible hot gases the door is equipped
Download Pdf Manuals
Related Search