Manuel utilisateur série 8 rev5 0AP301-UK
Contents
1. Dear customer You have just taken possession of your new AIXAM and we thank you for your trust AIXAM vehicles are designed to bring you the greatest satisfaction on board and our network of authorized distributors is at your service to ensure the best service to you Please get acquainted with the programme the terms of the guarantee as well as the explanations contained in this manual they will allow you to familiarize yourself with your new vehicle We remind you four important safety rules that will allow you to ensure your security as well as that of your passengers Never drive under the influence of alcohol medications or drugs Always respect the speed limits indicated and never drive faster than traffic conditions allow it Always use the safety belts and the appropriate holding back devices for children Always explain to your passengers how to correctly use the safety devices Good driving AIXAM The after sales service THE VEHICLE S CHARACTERISTICS The undersigned declares to have accepted the vehicle the serial number of which appears opposite in a flawless state Customer s signature Serial Engine Reverser gearbox Registration plate 1 traffic circulation date Owner of the vehicle Street and Postal or zip code City Telephone CONTENTS Windscreen wiper Front windscreen washer Rear windscreen wiper Hazard warning lights Reversing gear Parking brake Re2. one to the right and one to the left VERSION WITH DIGITAL SCREEN ON THE LEFT 4 3 4 Partial mileage totaliser and maintenance indicator 1 Fuel indicator gauge The fuel level display is a BBB Hb of bar graph type 6 lt BEBEBE a bars as the fuel level y lowers in the reservoir the bars disappear 1 The minimum fuel is displayed when the last bar blinks and the indicator 1 of previous page lights up In this case fill up with fuel as quickly as possible Gear selection indicator Indication of the gear engaged forward neutral reverse Coupled with the neutral position an indicator 2 of the previous page lights up General or partial mileage totaliser version with a single digital screen located on the left of the dashboard Display of the vehicle s total mileage To obtain the display of the daily mileage lightly press button 17 of the previous page To reset to zero the daily totaliser lightly press the same button for a few seconds To return to the general totaliser lightly press the same button and in the same way to return to the daily totaliser Version with two digital screens one on the right and one on the left of the dashboard Partial mileage totaliser display of the daily mileage A maintenance indicator will allow you to foresee the moment when the maintenance of your vehicle will have to be carried out Two parameters will enter in the calculation to foresee you
3. air recirculation so as to optimize the AC efficiency c The air recirculation may also be used to improve the heating efficiency or to prevent from external pollution like before entering a tunnel Be aware turning the recirculation on to the MAX position may generate condensation on the windows inside the car mainly on the windscreen The air conditioning shall be revised every two years DIRECTIONS OF USAGE You shall park the vehicle in the shade to lower the need for air conditioning to cool the vehicle Before switching on the cooling system you should open the windows to evacuate the maximum heat and then close them as soon as the A C is turned on Do not orientate the vents directly to the head to prevent sore throat You shall switch the A C on at least 15 minutes per week whatever the outside temperature to ensure a correct lubrication of the system limit the cooling fluid leaks and keep the A C in proper order A WARNING A To operate on an A C system that contains refrigerant and especially to open or to drain it any technician must have a specific habilitation and its workshop must be homologated to operate on A C systems It is strictly forbidden to discharge the refrigerant into the atmosphere The air entering the cabin is cooled and dried by condensation of the moisture it contains The water is then stocked in the condenser and evacuated by a pipe under the vehicle Therefore it is normal to find water
4. flowing under the vehicle when the air conditioning system is in operation FUSE BOX AFFECTATION OF FUSES WARNING When you replace a fuse always respect the position Calibre Colour Affectation___ Not attributed WHITE Centralized closing central electric windows 20a Yettow Engine stopping amperage risk of fire BLUE lem iea j ste pipe pedia ROUGE Hazard warning lights dashboard za e Domei 15A BLUE Horn car radio cigar lighter 25A WHITE Electric windows Not attributed YELLOW Windscreen wiper washer Cabin ventilator 15A PNK Reverse radar reverse ighis 20A YELLOW Prehesting spark plug supply __ 75A MAROON stoptigs 3A Dashboard centralized closing de icing relay AFFECTATION OF RELAYS Position Affectation Starter safety relay Depending on the version the number of relays EE Y may vary C16 ngine stopping relay Rear window de icing relay REPLACING A LIGHT BULB 1 Parking light bulb Pivot the bulb s support a quarter turn toward the left and remove it Remove the bulb by pulling on it to replace it Place the bulb support back taking care that the polarizer one big one small are located facing the corresponding notches on the back of the headlight Make it pivot a quarter turn to the right by applying pressure so as to pin the joint 2 Dipped and full beam bulb Remove the headlight
5. s cover To unlock it press the upper clip and remove tt Remove the sealing bonnet from the rear of the headlight and by pulling on it remove the bulb s socket Press the bulb s locking wire by sliding it to the right and lowering it Remove the bulb Put the new bulb in place making sure that its pins enter correctly in their housing do not touch the glass part of the bulb with the fingers Put the locking wire back and press on it while making it Slide to the left Reposition the sealing bonnet on the bulb s socket Insert the bonnet on the headlight s rear part ATTENTION take great care in doing the two previous procedures otherwise water will penetrate in the headlight and damage it Insert the protection cover on the bonnet taking care that the notch allowing the passage of the electric bundle is quite vertical otherwise the clip cannot engage and you risk losing the cover Direction lights Pivot the bulb support a quarter turn to the left and remove it Press on the bulb while pivoting it to the left and remove it Place the new bulb on the support by aligning its pins facing the notches of the support press on it while making it pivot to the right Put the bulb support back on the headlight by positioning its polarizer one big one average one small facing the headlight s notches Press on the bulb s support and make it pivot a quarter turn to the right REPLACING A FOG LIGHT BULB
6. speed Ii 2 Left switch By turning it toward the right You increase the warm air temperature Pulsed in the passenger compartment Ventilation switch 0 Mechanical ventilation off 1 Low speed 2 Medium speed 3 High speed Air direction switch By turning to the left you increase the air flow directed toward the feet by turning to the right the air flow is directed upward to obtain the windscreen s demisting To obtain maximum demisting close the two central aerators AERATORS SETTING Direct the air flow by handling the fins and by turning the vent Switch the fins to stop the flow ASHTRAY The ashtray is of nomad type it can be removed and placed elsewhere WARNING When emptying the ashtray make sure there are no incandescent ashes that could start a fire CIGAR LIGHTER Completely push the cigar lighter It is ready to be used when it comes back to normal position by issuing a click Pull the lighter out of its housing to use it WARNING Hold the cigar lighter by the button do not touch the metal jacket risk of burns Do not use a non origin cigar lighter risk of fire If the cigar lighter does not come out after 30 seconds it is defective quickly remove it risk of fire RECOMMENDATIONS FOR BREAKING IN For the breaking in period of the first 1000 kilometres drive the vehicle by respecting the following precautions so as to ensure a long service life with economical driv
7. tightened position STEERING e Steering type rack TECHNICAL FEATURES continued BODY Body light quadricycle with engine L6e heavy quadricycle with engine intended to carry people L7e Materials making up the body Thermoformed ABS Number of seats 2 light quadricycle of L6e category 4 heavy quadricycle of L7e category Seats 2 and a bench seat heavy Quadricycle of L7e category Number of doors 2 Nature of the materials used for the windows Windscreen laminated glass Side windows tempered glass Rear window tempered glass LIGHTING AND SIGNALLING e Front lights Indicators 12V 21W parking lights 12V 21W Low beam and full beam 12V 50W 60W Fog lights 12V 35W Daytime LED lights 12V 4W e Rear lights Rear lights and stop 12V 21W 5W Fog lights 12V 21W Backup lights 12V 21W CHECKS CARRIED OUT BEFORE THE DELIVERY OF THE VEHICLE After all the care brought to the making of your AIXAM vehicle your authorized distributor carries out a list of checks so that you can fully benefit from your new vehicle Check of the closing and locking of all the openings doors windows bonnet tailgate gloves compartment open top Check of onboard tools Check of levels Engine oil inverting unit oil Windscreen washer fluid brake liquid Cooling liquid and antifreeze protection control Sealing check braking circuit cooling circuit Tyre p
8. ND CONTROLS CARRIED OUT AT First revision at Revision at 5000 km or Additional works at REVISIONS 1000 km or 1 year 1 year and every 5000 km 10000 km and every 10000 km Engine drain and oil renewal with replacement of the oil filter Drain of inverting unit and renewal of oil O Oil level check of inverter unit complete if necessary O O Cooling liquid level check complete if necessary Cooling circuit sealing check Brake liquid level check complete if necessary Check braking circuit sealing Brakes operating check including had brake Cleaning and dusting of brakes replacement of lining if necessary Check of electrolyte level of the battery complete with demineralised water if necessary Adjustment of inverter lever Grease battery terminals Check the condition of belts and replace if necessary WARNING Maintenance works to perform regularly in addition to the advised revisions Annually renew the brake circuit liquid Every two years renewal of cooling liquid Never use high state petrol as antifreeze in the gas oil Use the products recommended on the market Maintenance 1 000 km or 1 year Date 11 LILI LILI Day month year Mileage ILLL LABOUR FREE OF CHARGE Stamp and signature authorized distributor Maintenance 15 000 km or 1 year Date JL LILI LILI Day month year Mileage _JLJLJLILI Stamp and signature authorized distributor Maintenanc
9. Remove the bulb s support by making ii pivot to the left The bulb is an integral part of the support Place the bulb s support back taking care that the attachment pins correspond to those at the rear of the headlight and make it pivot to the right REPLACEMENT OF A REAR LIGHT BULB Open the tailgate Move aside the lining of the back quarter light Unblock the connector Remove it and change the bulb 1 Rear light and stop light bulb 2 Bulb of flickering light 3 Reverse drive light 4 Rear fog light bulb REPLACING THE BULB OF INTERIOR LIGHTING Unclip the dome light s interior lighting to replace the bulb ENGINE OIL ENGINE OIL LEVEL All engines consume a certain quantity of oil It is thus important to check the oil level at regular intervals or before a long trip Do the check while the engine is warm and stopped Park the vehicle on a flat surface and stop the engine Wait a moment to allow the oil to go back to the oil carter so as to measure the exact quantity Remove the gauge and wipe it with a clean cloth Put it back by pushing it at maximum Then remove it and read the quantity of oil appearing between the two marks If the oil level is inferior to the maximum limit remove the filling cap 1 and complete it with the specified oil page 16 Efficiently close the filling cap EVERY 5000 km ENGINE OIL DRAIN pI The engine should be warm Remove the filling cap 4 a Remo
10. TI E RR E DT E e wema IE II RI IC Maximum power 0 CE 2 Maximum power rating rpm 3200 3600 5000 TECHNICAL FEATURES continued TRANSMISSION OF MOVEMENT BRAKING e Service brake Type of gear continuous variable transmission CHARACTERISTICS FRONT REAR Clutch type centrifugal Control mode automatic Type of transmission a E Engine variable reduction inverter unit wheels The front and rear lining are driven by hydraulic pistons Maximum speed 45km h light quadricycle of L6e controlled by a double circuit master cylinder The category 75km h heavy quadricycle of L7e category master cylinder with a brake liquid reservoir in its upper part is controlled from inside the vehicle by a pedal at SUSPENSION SYSTEM the driver s right foot A limiter allows automatically lessening braking efficiency at the rear end e Front e Hand brake Independent wheels pseudo Mac Pherson type double A lever located within the reach of the driver s right effect hydraulic telescopic shock absorbers and hand between the vehicle s two seats mechanically helicoidal springs activates through the intermediate of a cross bar and of e Rear two cables the rear brakes The adjustment of this Drawn arm independent wheels double effect hydraulic brake is mechanical and is performed by a screw at telescopic shock absorbers and helicoidal springs each of the rear wheels or of the cross bar A ratchet allows maintaining the brake in
11. alisation of the sole works performed under the guarantee provided that the said works inevitably require an immobilisation of the vehicle for at least 7 consecutive days Law of January 18th 1992 Art 4 The manufacturer is by right owner of documents deposited for guarantee GENERAL TERMS OF GUARANTEE continued 8 The warranty does not cover e Any parts and equipment that are not genuine AIXAM parts e The maintenance procedures including equalizing and wheels alignment settings the engine and headlights settings the replacement of glow plugs of spark plugs bulbs belts transmission belts the parts needed for the maintenance of regulators brake disc pads and linings brake discs and drums lubricants and liquids e The damages and breakdowns caused by Incorrect use accident theft fire vandalism Industrial fallouts acids alkaline chemical resins bird droppings salt hail storm lightning and others The non respect of the maintenance program at the dates foreseen A badly performed intervention Interventions out of the AIXAM network The use of non AIXAM approved parts and accessories The use of incorrect fuel or lubricant or containing foreign bodies or fuel that does not correspond to that advised Overload even temporary e The whole vehicle if it has undergone modifications or transformations not approved by the manufacturer especially when the vehicle no longer corresponds to the approve
12. and activate the WARNING window contactor till it is either open or closed and Set the seat before taking the road maintain the contactor for another two seconds After setting check that the seat is effectively locked in position REA If you wish to fold down the rear bench of your car you must lock the safety belts During handling make sure that they cannot get caught or damaged To lift the rear bench seats insert your hand towards the safety belt locks raise the seat and tip it towards the front of the vehicle then unlock the back of the rear bench with the two locks located in the luggage compartment lift it and then place it flat behind the seat If you carry material in the luggage compartment always make sure that it cannot damage the safety belts SAFETY BELTS Three point safety belts with winders This type of belt needs no length adjustment Once fastened the belt freely adjusts to the users movements but in case of a strong or brusque jolt it automatically locks itself to retain the body Before fastening your safety belt seat yourself well in the back of your seat set the seat s advance according to the pedals When you put on your safety belt hold yourself against the back of your seat The thorax strap should be as close as possible to the neck without however bearing on it The basin strap should bear flat on the thighs and against the basin The belt should bear most directly on th
13. ar view mirrors Heating ventilation Cigar lighter ashtray Recommendations for breaking in Fuel filling Starting stopping the vehicle Driving advice and car body maintenance Car body cleaning CHECKS AND MAINTENANCE GENERAL INFORMATION The vehicle s characteristics Contents General terms of guarantee Technical features Checks carried out before delivery Maintenance program Maintenance record Lubricant and quantity Vehicle identification INSTRUCTION MANUAL Locking unlocking doors Tailgate opening closing Bonnet opening closing Window openers Air conditioning Fuse box and relays Safety belts Bulbs replacement For children s safety Levels Dashboard Change of direction controls Lighting controls Fog lights controls Rear window de icing control GENERAL TERMS OF GUARANTEE All new vehicles of the AIXAM range are guaranteed for a period of 24 months from the date of delivery to the customer against any defect relating to material fitting or manufacturing fault Any spare part or accessory sold by AIXAM is guaranteed for a period of 12 months from the date of invoicing to the customer against any defects or manufacturing flaws To benefit of the AIXAM guarantee The user manual should be filled in with the vehicle s identification the name and address of the user as well as the stamp of the authorized agent The guarantee is recorded on the Internet by the AIXAM authorized distributor
14. creating additional clearance When the belt is used the straps should not be twisted Do not move the abdominal strap under your arm or behind your back Safety belts were designed to be used by occupants having an adult s size Do not modify or transform the safety belts or their anchorage on the chassis or the vehicle s seats Only use the manufacturer s origin equipment Babies and children can in no case be carried on the knees of occupants of the vehicle lt is particularly dangerous to strap a child sitting on your knees Never use a single belt to hold two persons at the same time Never leave a child or an animal in a car exposed to sunlight windows closed FOR CHILDREN S SAFETY e Never leave the keys within the reach of children inside the vehicle e The use of devices to retain babies and children is regulated e You must imperatively respect the laws in force in the country you are driving in particularly as concerns the age conditions for the transport of children in the front seats Generally children under 12 years under 1 50 metres tall and weighing under 36 kilos should be attached on an authorized device adapted to the weight and size of the child The driver is responsible of the correct use of these devices It is thus advised to select an authorized device according to European regulation EEC 44 Such devices obligatorily include an orange label with the letter E followed by a number that of the country where
15. d origin criteria e The normal wear of any element including muffler belts and shock absorbers as well as the wear of linings seats paint and embellishers Any vehicle the instrument head of which was replaced or changed so that the real mileage cannot be clearly established among which the serial number or the engine number were corrupted e The indirect consequences of any fault including but not limited to loss of business length of time off the road 9 Documentations relative to the guarantee the maintenance and the driving Every beneficiary of the AIXAM guarantee receives a user s manual at the delivery of the new vehicle The application of the terms of guarantee is subordinated to the presentation of the user s manual 10 In any case the AIXAM vehicle benefits of the legal guarantee against any hidden flaw in accordance with the stipulations of articles 1641 and following of the Civil Law TECHNICAL FEATURES GENERALITIES CITY CROSSLINE CROSSOVER COUPE Light quadricycle of L6e category infront In front ino 1345 500 Maximum ae O OO N y Empty weight of the vehicle 400 On front axle 245 TECHNICAL FEATURES GENERALITIES CROSSLINE CROSSOVER Heavy Quadricycle L7e category Type and version ST62AF ST92AF ST65AF ST95AF Steering wheels DIMENSIONS mm CROSSLINE caossovea W D L Front rack w TECHNICAL FEATURES en coana or ae category Henny acre of Te category ATIT RR IE RR RR o o
16. e 5 000 km or 1 year Date JL LILI LILI Day month year Mileage Stamp and signature authorized distributor Maintenance 20 000 km or 1 year Date J LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 10 000 km or 1 year Date 11 LILI LILI Day month year Mileage _JL JL JLJLI Stamp and signature authorized distributor Maintenance 25 000 km or 1 year Date J LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 30 000 km or 1 year Date JL LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 45 000 km or 1 year Date JL LILI LILI Day month year Mileage JJ Stamp and signature authorized distributor Maintenance 35 000 km or 1 year Date 11 LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 50 000 km or 1 year Date J LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 40 000 km or 1 year Date QU LILI LILI month year Mileage LULL Stamp and signature authorized distributor Maintenance 55 000 km or 1 year Date 11 LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 60 000 km or 1 year Date 11 LILI LILI Day month y
17. e body Avoid very thick clothing and inserted objects To fasten the belt slowly unroll the strap and without jolts and make sure of the bolting in the box Check the efficient bolting by pulling on the bolt If there is locking of the strap before the locking return backwards and unroll again To unfasten the belt press the red button on the box the belt winds back into the reel Accompany the bolt to facilitate the procedure SAFETY BELTS e Whatever the length and distance of the drive you perform always fasten your safety belt Furthermore you should comply with the local legislation of the country where you are The safety belt was designed to retain a single person Never place a child on your knees and fasten the safety belt Do not use devices allowing to introduce free movement into the straps example clothes peg etc because a safety belt that is too loose risks causing wounds in the event of an accident Following a serious accident it is necessary to replace the safety belts which were in service at the time Or even if a belt is damaged and shredded it is imperative to replace it If you have to clean your safety belts do it with some soap and water Any other product is prohibited Badly adjusted safety belts risk causing wounds in the event of an accident Pregnant women should use their safety belt In that case make sure that the basin strap does not exert too much pressure on the stomach bottom without
18. e during 12 minutes WINDSCREEN WIPER WINDSCREEN WASHER By pressing down the lever the windscreen washer operates once By lifting the lever 1 Intermittent 2 Low speed 3 High speed By pulling the lever towards you you activate the windscreen washer REAR WINDOW WIPER U Rear window wiper off Turn the control toward the front cu Rear window wiper operating INTERIOR LIGHTING 0 Not operating 1 Operates in permanence 2 Operates at the opening of doors When opening a door the interior lighting lights up progressively and remains lit for 30 seconds When closing a door or following the ignition the lighting remains lit for 10 seconds while progressively switching off HAZARD WARNING LIGHTS Controls simultaneously and in permanence the four direction lights Use only in case of danger When the vehicle is running following a brutal deceleration case of brutally braking the warning lights activate automatically for 10 seconds According to version REVERSING GEAR N Neutral point D Forward drive R Reverse drive To select the desired gear 1 Press the lever while advancing it Example to pass from reverse drive to forward drive or to pass from neutral point to forward drive Simply pull the lever toward the rear to pass from forward drive to neutral point Press on the lever and pull towards you to engage the reverse drive To select a gear it i
19. ear Mileage LULL Stamp and signature authorized distributor Maintenance 75 000 km or 1 year Date 11 LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 65 000 km or 1 year Date 11 LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 80 000 km or 1 year Date 11 LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 70 000 km or 1 year Date JL LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor Maintenance 85 000 km or 1 year Date J LILI LILI Day month year Mileage LULL Stamp and signature authorized distributor EN d AIXAM Recommends the use of synthetic oils ENGINE 100 synthetic oil KUBOTA z402 1 8 litres KUBOTA Z602 2 5 litres LOMBARDINI 523 MPI 1 3 litres INVERTER UNIT 100 synthetic oil 1 litre COOLING LIQUID 2 0 litres BRAKE LIQUID 0 3 litres IDENTIFICATION OF THE VEHICLE LOCKING AND UNLOCKING 1 COLD HEADING OF THE SERIAL PACK version NUMBER Four keys are supplied two keys for the door locks the two other keys for the fuel filling stopper of the fuel tank Keep one of each in a safe place in case of need The serial number is imprinted on the right side rail inner side of the vehicle under the right seat Slide 2 MANUFACTURER S PLATE The manufacturer s pla
20. et the The brightness will intensify at each impulsion to hours Terminate the setting of the hours by a arrive at its maximum and return to its minimum long press e Proceed in the same way as for the hours to set the tenths of minutes and the minutes To exit the setting system terminate with a long press According to version DASHBOARD continued MEANING OF THE INDICATORS Y Battery s charge indicator It lights on the ignition position and should switch off when the engine starts If it lights up in permanence quickly contact the AIXAM network Engine oil pressure indicator It lights up in the ignition position and should imperatively switch off as soon as the engine starts If it lights up while driving stop the engine immediately Check your oil level and complete if necessary If it remains lit in spite of a correct oil level stop your engine and quickly contact the AIXAM network Cooling liquid temperature alarm indicator It lights up in the ignition position and should switch off as soon as the engine starts If it lights up while driving stop immediately Wait 30 minutes before checking the cooling liquid level risks of serious burns If it lights up again contact the AIXAM network Parking brake and brake liquid level indicator Lit it indicates that your hand brake is not released or that there lacks brake liquid in the brake circuit Complete the level with the advised liquid see page 16 Front brake di
21. gage compartment in a basket Inside it is a box containing the jack The wrench for removing tyres is fixed under the right seat TO CHANGE A TYRE IN CAS OF PUNCTURE Place the vehicle on flat and resistant ground Put on the parking brake use wedges if necessary Take the wrench under the right seat and loosen the spare wheel basket bolt located at the entrance of the luggage compartment Remove the spare tyre and the jack from its box With the wrench remove the 4 nuts from the wheel Place the jack under the car making sure that it is positioned on the outer side rail and not under the flooring Lift the vehicle by turning the handle so that BATTERY the tyre is above the ground by a few centimetres Remove the tyre s nuts Remove the tyre Place the spare tyre by proceeding in reverse sense and locking the nuts after having lowered the vehicle Put the damaged wheel in the basket and affix it correctly Have the damaged tyre rapidly repaired and check the inflating pressure The battery is located under the engine s bonnet a CONDITION OF TYRES ATTACHMENT SCREW The life expectancy of a battery is closely linked to external factors driving conditions electric equipment weather conditions In extreme cases e g while driving less than 10km the battery will not be enough charged from the normal use of the vehicle In such a case you Shall plug your battery on a charger that can be
22. gency tailgate opening MOpen the plastic panel that is used to replace left Pull the safety handle blue cable in order to unlock the tailgate chest OPENING THE FRONT BONNET CLOSING THE FRONT BONNET Pull the unlocking control located under the dashboard to the left Lift the bonnet while pressing the safety lock To hold the bonnet open insert the Release the prop and affix it then lower the bonnet bonnet prop in the some fifty centimetres and drop it so that it closes hole foreseen to that under its own weight effect CONTROLS FOR OPENING DOOR SEATS AND SAFETY BELTS WINDOWS ADJUSTING THE FRONT SEATS WINDOW HANDLE Adjust the drivers seat at a position easily allowing activating the pedals the wheel and the various dashboard controls Lift the lever and move the seat frontward or backward up to the desired position After setting release the lever so ELECTRIC wow that the a locks in position The two electric window control switches are located at the bottom of the dashboard s central facade HEADREST The deluxe version is equipped sequential driver window A Press the setting button and lower or lift long impulsion on the control the headrest to set it to your button controls the automatic convenience complete opening or closing After unplugging the battery from the vehicle it is necessary to reinitialise the automatic windows control to do so switch on the contact
23. ing and a good level of performance e Do not drive the vehicle at high speed e Avoid quick starts accelerations too frequent braking Note that the speeds indicated by road signs must be respected FUEL THE FUEL TO USE IGNITION CONTROL OF THE STARTER Diesel engine vehicle gas oil hexadecane index DIN 51601 Petrol engine vehicle unleaded petrol 95 98 STEERING LOCK To unlock the steering slightly turn the WARNING when you fill in the tank of your car please be wheel while turning the key without very careful that the fuel does not come in contact with forcing the car body elements If this should happen we advise oly you to immediately spray the parts concerned with C running water and then dry it with a soft cloth ACCESSORIES Q CONTACT SUPPLYING Contact is on Do not leave it in this position when the 1 Stop the engine before engine is stopped Possible discharge of the battery filling the tank 2 Remove the tank s STARTER stopper after having Starts once the key in this position unlocked it 3 Insert the nozzle and fill STARTING AND STOPPING THE ENGINE the tank ee ce AA es 4 After the first automatic e First check that the parking brake is tightened and that the interruption of the nozzle do inverter lever is on neutral not continue to fill more than e Bring the key on the contact position and wait till the 9 seconds preheating indicator switches off 9 Remove the nozzle e Start the engine by put
24. it is authorized and the year of authorization Before using a child s seat push back the passenger seat to the maximum AGE OF THE CHILD THE CHILD S WEIGHT CHILD S SEAT APPROVAL CATEGORY birth to about 9 months ieee weight under 13 kg U universal back towards the road only 9 months to about 3 years a A weight 9 kg to 18 kg U universal 3 years to about 12 years tee weight 15 kg to 36 kg U universal Before using a child s seat make sure that its installation is correct in the vehicle Comply with the seat manufacturer s specifications see the operating instructions supplied with the seat Check if the approval class of the child s seat corresponds to the child s weight DASHBOARD 1 2 3 4 O 6 T 8 9 Neutral position indicator Fuel reserve indicator Battery charge indicator Left steering indicator Speed indicator Right steering indicator Parking brake indicator Full beam indicator Dipped headlights indicator 10 Rear fog lights indicator 11 Cooling liquid temperature indicator 12 Right setting button 13 Hazard warning lights indicator 14 Diesel engine preheating indicator 15 Window de icing indicator 16 Left setting button 17 Oil pressure indicator 18 Front brake disk pad wear indicator According to version DASHBOARD continued According to vehicle versions there exist two dashboards one with a single digital screen and another with two digital screens
25. on the day of purchase The guarantee can be requested from any authorized distributor of the AIXAM network The customer shall present his user manual bearing the stamp of the vehicle s seller the date of delivery to the customer and the stamp of the AIXAM authorized distributor having carried out the maintenance and checks between 500 and 1 000 km foreseen by the manufacturer To be covered under warranty the customer shall be able to justify the proper maintenance of its vehicle as per the Manufacturer recommendations defined in the below section MAINTENANCE PROGRAM In addition the customer shall bring in his vehicle between 500 and 1 000 km to his authorized AIXAM distributor who will carry out for free except consumables and small supplies the checking regulating tightening foreseen by the manufacturer at that mileage After performing the work on the vehicle the authorized AIXAM distributor will stamp the corresponding box below and indicate the date and the exact mileage This warranty covers the cost of repair or replacement of defective parts to repair a material assembly or manufacturing defect recognised by the manufacturer when carried out by a member of the AIXAM Network Expenses on the spot of repair or towing are not included Interventions performed under warranty will not result in a prolongation of the duration of it Nevertheless the use of guarantee extends the delay during period equal to that necessary for the re
26. ordered from your Authorised Repairer imperatively remove it from the car and charge Would you like to charge your battery you should A it in ventilated premises ABS braking system Your vehicle may be equipped with an Anti lock Braking System ABS that allows you to keep control of your vehicle regardless of grip conditions An Electronic Brake force Distribution EBD is also integrated and will manage permanenily the distribution of the braking power between rear and front brakes Upon activation of the ABS a vibration is felt at the brake pedal This vibration is normal and due to the operation of the system The use of ABS should not lead to non compliance of the Highway Code especially regardin safety distance between two vehicles Two signals on the dashboard will display the status of your braking system ABS warning signal it turns on at ignition and turns off a few seconds later to ensure the system Is operational If this light turns on while driving you shall go to the nearest Authorized Repairer as your ABS is facing a minor failure ABS amp Braking warning signals if these two signals light up simultaneously your braking system is facing a major failure ABS and EBD functions are deactivated You shall stop your vehicle as soon as possible and call your nearest Authorized Repairer Air Conditioning functionning Turn the ventilation button to the desired speed a Switch the A C on b Adjust the
27. r next revision the time and the mileage Examples 1000 km or 1 year 5000 km or 1 year This indicator will display the distance remaining before the next revision for 5 seconds after having switched on the ignition as well as the key symbol marker 4 If the distance term is reached or passed the key symbol and the mileage and the sign will blink for 5 display seconds and the key symbol will remain displayed If the time length is reached the key symbol and the 1 year message blink for 5 seconds and the key symbol will remain displayed To have your car quickly revised we advise you to make an appointment with your authorized distributor According to version DASHBOARD continued VERSION WITH DIGITAL SCREEN ON THE RIGHT 5 The clock Temperature indicator It flashes when the The clock s settings temperature nears 3 degrees to indicate a risk of can only be done black ice vehicle stopped This setting is done Total mileage totaliser according to the following procedure Setting of the dashboard s brightness When the vehicle s lighting system is switched off the dashboard s brightness cannot be set At night once the vehicle s lighting operates you can e Press button 12 for three seconds see page 25 set the intensity of the dashboard s lighting To do so and the hours will flash briefly press several times button 12 see page 25 e Press by impulsion on the same button to s
28. ressure check including spare tyre Tyres tightening check pivots engine regulator inverter unit and bolts in general Operating control of electrical equipment and of the lighting Idle speed adjustment Wheel alignment check Vehicle tryout Inside and outside vehicle cleaning e Battery charge level check of starter and of tightening of clips For the maintenance and repair of your vehicle AIXAM only uses origin AIXAM parts INTERVENTIONS AND CHECKS TO CARRY OUT AT REVISIONS Dusting of the whole regulator MAINTENANCE PROGRAM Additional works at 10000 km and every 10000 km Revision at 5000 km or 1 year and every 5000 km First revision at 1000 km or 1 year O Check of regulator clearance and replacement of bearings if necessary O Check of screws tightening wheels engine O replacement or cleaning of air filter o cleaning replacement of fuel filter O Tyres pressure control y including spare tyre O Check sealing of shock absorbers O Check the condition of suspension bearings engine exhaust Check the condition of bellows steering sockets and racks Reprogramming of maintenance indicator Check of load circuit Check the efficient operating of the lighting and of electric instruments Clean the cooling radiator s cooling fins Check and adjust wheels alignment Vehicle trial run MAINTENANCE PROGRAM CHECKS A
29. rs of certain substances may entail uneasiness or intoxication For all chemical products read the instructions on the can before use Open doors and windows while using these products indoors The following products are not advised for the maintenance of the vehicle Petrol Benzene Naphtha Acetone Carbon tetrachloride Paint diluents Turpentine Varnish diluents Nail polish diluents Etc These products are dangerous and risk damaging the vehicle CLEANING THE CAR INTERIOR Dust the interior with a vacuum cleaner Clean plastic elements with soap and For the seats and carpets use the products found on the market for that use CLEANING THE CAR BODY Rapidly wash the vehicle if it is exposed to stains susceptible of favouring corrosion notably Seawater chemical products used to de ice roads in winter Soot and dust iron powder in factory smoke chemical products acid substances basics tars etc Bird droppings debris of insects tree resins etc WASHING Only use water and liquid soap Avoid doing it in full sunlight or if it is freezing Do not pass the vehicle in automatic washing stations with brushes Do not use a high pressure cleaner CLEANING THE WINDOWS Clean the windows with soap and water or with a special cleaner for glass taking care that it does not touch the car body SPARE TYRE This vehicle is equipped with a spare tyre under the lug
30. s imperative that the vehicle is completely immobilized that the engine is at idle speed The gearbox lever is equipped with a plug to activate the gear change To move forward or backward Lift the ring 1 Push the lever to the desired direction Release the ring once the gear selected 2 Never switch from drive to reverse without lifting the ring Failure to this procedure would result in permanent damage to your vehicle PARKING BRAKE 1 To put on the brake completely pull the lever without pressing the button at the end of the lever 2 To remove it lightly pull the lever while pressing the button and lowering the lever INTERIOR REAR VIEW MIRROR The lever located in the lower part is used to reduce the dazzle of 1 Normal 2 Anti dazzle Yi A headlights of following vehicles 2 when driving at night AS O OUTER REAR VIEW MIRROR Outer mirror adjustable from inside with the lever button Upward adjusting Downward adjusting Right adjusting Left adjusting HEATING VENTILATION The heating only works if the engine is running The performance of the heating appliance directly depends on the temperature of the cooling liquid It is thus advisable to only use the heating when the engine has reached its normal operating temperature In cold weather it is useless to start the engine and to let it run at idle speed for several minutes before driving for the heating does not operate at idle
31. sc pad wear indicator It lights up when you brake check or change your front brakes disc pads as soon as possible Left turn signal Full beam indicator Right turn signal Rear fog lights indicator Neutral point indicator Hazard warning lights indicator Fuel reserve indicator Rear de icing indicator Dipped headlights indicator Diesel engine preheating indicator according to version CHANGE OF DIRECTION CONTROL e Press down the lever before turning left e Raise the lever before turning right For a change of direction engage the control beyond the hard point automatic return and stop with the wheel For your safety we remind you to always anticipate your movements sufficiently in advance by clearly indicating them Press the extremity of the control LIGHTING CONTROL Q All lights switched off Turn the control frontward NEI TA Parking lights Turn the control frontward ECO his dipped full beam Dipped full beam inversion pull the control towards you Warning light By impulsions by pulling towards you NOTE When opening the doors after stopping the vehicle a sound signal indicates that you have not switched off the lights FOG LIGHTS CONTROL Q Lights switched off Turn the control toward the front Fog lights Front fog lights Turn the control toward the front REAR WINDOW DE FROZING CONTROL To activate it give an impulsion qa On the extremity of the control It will operat
32. te is riveted on the right side rail inner side of the vehicle next to the serial number engraving DELUXE version Two keys are supplied with integrated remote control pictograms clearly indicate opening and closing procedures NOTE In case deficient operating of the remote control you can always lock and unlock with the keys LOCKING AND UNLOCKING FROM OUTSIDE OF THE VEHICLE 1 Insert the key 2 Lock 3 Unlock LOCKING AND UNLOCKING FROM INSIDE THE VEHICLE 4 Unlocking 5 Locking OPENING THE TAILGATE Pull the handle located under the safety belt on the left inner panel Raise the tailgate to its maximum position without forcing the two jacks will hold it open CLOSING THE TAILGATE Lower the tailgate three fourths of the way and release it Make sure that it is correctly locked OPENING THE TAILGATE Depending on the version ELECTRIC OPENING Outside vehicle remote key Keep the opening doors button activated for 3 seconds Drivers and passenger doors will immediately unlock maintain the button activated and after 3 seconds the tailgate will open ELECTRIC OPENING Inside vehicle A button is located on the left inner panel behind the safety Ps belt Activating this button r 1 will result in opening the we tailgate from inside of the Car MECHANINC OPENING Safety handle In case of failure of the electric doors opening you shall go to the nearest Authorized Workshop Emer
33. ting the key in the starter 6 Put the stopper back and position Release the key Do not accelerate during this lock it procedure or lightly in very cold weather e To stop the engine bring the key in the locked position Warning fuel is a flammable and explosive product Keep away from flames and do not smoke DRIVING ADVICE Before starting check The correct setting of rear view mirrors The adjustment of your seat The fuel level Fasten and adjust your safety belt Drive with a single foot to avoid stepping on both pedals brake and accelerator at the same time which corresponds to accelerating and braking at the same time thus premature wear of brakes and all the transmission organs Voluntarily limit your speed in descents If you try to climb on a sidewalk only do it on lowered parts otherwise you risk upsetting the front axel assembly and entailing the premature wear of tyres The roof bars of the Crossline vehicle are trim_and are not made to carry loads In case non application of these instructions the responsibility of AIXAM MEGA cannot be engaged for any deterioration or accident generated by the carrying of any object on the roof of a Crossline CAR BODY MAINTENANCE WARNING Chemical products can be dangerous Some are toxic others catch fire near a flame or if one uses them ona part of the vehicle that is still hot In badly ventilated premises the inhalation of vapou
34. ve the draining cap 2 and let the oil drain Replace the drain joint Tighten the drain cap Fill with engine oil according to quantity page 16 Check that the level is correct with the oil gauge Correctly close the filling cap INVERSING UNIT OIL 5 filling cap INVERSING UNIT OIL continued ade J 3 Level screw 4 Draining cap Every 10000 km oil drain of the inversing unit Procedure to carry out after having used the vehicle Respect the quantity of oil used page 16 WINDSCREEN WASHER LIQUID Complete with windscreen washer liquid without alcohol COOLING LIQUID Must be done engine cold so as to avoid burns The cooling liquid should cover the radiator s upper grid To check it remove the radiator cap 6 Correctly close the radiator cap NB it is advised to replace the cooling liquid every two years BRAKE LIQUID BRAKE LIQUID LEVEL The level should be between the two marks Complete if necessary See page 16 NB it is advised to replace the brake liquid every year In case of immobilisation of the vehicle Out of the sector of your dealer Please call 04 79 61 42 45 By specifying the department where the car is found We shall indicate the closest agent MAIN OFFICE AND PLANT 56 route de Pugny B P 112 F 73101 AIX LES BAINS CEDEX Tel 33 0 4 79 61 42 45 Fax 33 0 4 79 35 06 11
Download Pdf Manuals
Related Search