3102661 PS135 Users Manual
Contents
1. PS135 2 21 3 4 29 height 3102665 Caster Non pressure locking set of 5 3102670 Cylinder PS135 3 24 34 height 00 3102666 Seat ASSOMDIY cccccccssseecseeeeceseeeesseeseeseeens 3102672 LIMITED WARRANTY Warranty Brewer shall manufacture the Products in accordance with the requirements of all applicable law including without limitations the regulations promulgated by and for the Federal Food and Drug Administration and industry standards Brewer warrants its Products to be free from defects in parts and workmanship under normal use and service for a period detailed in the table below from the date of delivery to original end user Brewer will not be responsible for any Product failure due to abuse modification or improper use or for any use which exceeds the published capacity of the Product Do not discard parts before contacting Brewer for warranty service as Brewer may require the customer to send in defective parts for examination to determine the applicability of these warranty provisions If this occurs the customer will be invoiced against a new purchase order for the replacement part If the part is found to our satisfaction to have been defective under the terms of the warranty the customer will be credited the amount of the replacement part and outbound shipping costs If the part is found not to be defective under the terms of this warranty the customer is liable2. up slowly on height adjustment lever Lever action should Yes replace cylinder change from loose to firm No replace seat assembly but continue to move against activation button on cylinder as it is pulled Is this the action the lever makes Seat will not lower Defective cylinder or seat Check the 4 seat screws fig Seat screws loose 16 with a 6mm Allen wrench Tighten seat screws if loose Seat is loose Grasp seat and wiggle it side Seat is damaged to side to check for broken seat Rep aes sean COMpOnelts are broken components Yes no movement with Sit on stool and move stool weight off of stool is normal around to test Does stool roll operation normally No replace defective casters Optional non pressure locking casters operate only when weight is applied to stool Casters not rolling Build up of floor wax dirt Casters leaving marks on floor and other debris on treads of casters Inspect casters for build up Use stiff bristled brush with mild soap to remove build up Dirt build up on casters Casters don t roll smoothly Damaged casters Inspect casters for damage Replace casters August 2014 10 Document 3102661 RevA Brewer SERVICE PARTS Plastic Base without Casters cccceeeeeeeeeees 3102669 Cylinder PS135 1 18 1 2 23 1 2 height 3102664 Caster Standard Set Of 5 cccecceeseeeeeeeeeeees 3102280 Cylinder
3. 88 Brewer 1 Our trained staff will attempt to assist you Brewer Day Month Year in correcting the problem directly over the phone If service XXXXXXX is required please contact your local equipment dealer STOOL XXXXXXX Please have the following information from the product label located under the seat before calling Brewer or your XXXXXXX distributor with questions regarding your unit Order number Important please note prior to use of the Model PS135 Series Stool e Some muscle soreness when adapting to this style of e Work surfaces must be adjusted to the optimal stool stool is normal height Use only with work surfaces that can be adjusted as described later in these instructions e Severe pelvic extremity back or other kinds of pain is not normal See a physician before further use of the e Use of the stool should be stopped if males stool experience discomfort or numbness in the pelvic area SAFETY INFORMATION Failure to follow instructions with these symbols could result in serious personal injury and or Safety Information damage tothe unit The primary concern of The Brewer Company is that the stool is operated and maintained with the safety of the 4 amp 4 DANGER operator in mind To ensure safe and reliable operation Indicates a hazardous situation that if not avoided will result in death or serious injury e Read and understand all instructions in this manual before attempting to assemble or operate the
4. Brewer Poly Saddle Stool Model PS135 Series Stool User Manual I Important Information Stool Adjustments Safety Information Maintenance Specifications Cleaning Component Identification Troubleshooting Unpacking Instructions Service Parts Assembly Instructions Limited Warranty Recommended Usage The Brewer Company LLC N88 W13901 Main Street Suite 100 Menomonee Falls WI 53051 P 1 888 Brewer F 262 251 2332 www brewercompany com August 2014 Document 3102661 RevA Brewer IMPORTANT INFORMATION General The Brewer PS135 stool combines Brewer s clinically researched ergonomic seating with Salli technology to help prevent back pain by inducing natural posture and strengthening back and body core muscles while you work Because of the nature of this stool we recommend that you begin using this stool no more than four hours a day for the first two weeks Intended Users e The PS135 stool is for professional use only This product is not intended for use by untrained personnel e Only adults should use the stool e Individuals with poor balance muscle control or other impairments should not use the stool e Individuals using medications or drugs that can interfere with balance or judgement should not use the stool until cleared by their physician Service Model number Manufacture date lf you require assistance with the assembly or operation Description of your Brewer stool call Brewer Customer Service at 8
5. Document 3102661 RevA Brewer STOOL ADJUSTMENTS Correct Sitting Position and Height The optimal sitting position is where user s knees are ata 135 downward angle and feet are almost under the hips figure 14 Sitting this way allows normal pelvic positioning allowing the lower back to form a natural curve and the shoulder neck area to remain erect and straight Legs should be relaxed and feet should rest on the floor without having a hanging feeling Note the average user will sit higher on the PS135 Stool than on standard stools Correct Working Height The correct height for a conventional work surface is elbow 3 4 height Optimal positioning is with arms parallel to the work Max surface A maximum angle of 3 4 of downward slope as shown in figure 15 is acceptable Fig 15 August 2014 8 Document 3102661 RevA Brewer MAINTENANCE Seat Screws 4 FALL HAZARD Failure to perform periodic inspections of the stool could result in personal injury Seat Screws Periodically check seat screws figure 16 for tightness Tighten with 6mm Allen wrench if loose Casters Inspect casters for cracked chipped loose or missing wheels Casters should roll freely Note optional non pressure locking casters must have weight applied to roll Replace if damaged Caster Base Inspect caster base for cracks or other damage Replace if damaged Cylinder Cylinder defects are indicated by seat
6. S135 COMPONENTS The Brewer PS135 utilizes a unique saddle seat design that offers superior back support comfort and durability Note Make sure that the following components are included and that the stool operates properly before discarding packaging materials e Seat Assembly with Height Adjustment Lever and Quick Start Tag e Pneumatic Cylinder e Caster Base e Casters Qty 5 e User Manual Seat Assembly a Stool Front Height A Pneumatic Cylinder Adjustment Lever Quick Start Tag gt _ Caster Base Casters 5 Ai UNPACKING INSTRUCTIONS NOTICE To avoid damaging the stool s upholstery do not use a knife or other sharp object to open the package Also to avoid damaging the stool do not use the height adjustment lever for lifting August 2014 4 Document 3102661 RevA Brewer ASSEMBLY INSTRUCTIONS Stool assembly a 1 Insert the 5 Casters into the Caster Base figure 1 WA 2 Set Caster Base on floor figure 2 3 Insert wide end of Cylinder into hole on Caster Base figure 3 Lb G Fig 3 a Press Down 3 X 4 Place Seat with Control Plate on top of Cylinder and press down firmly several times to secure components figure 4 Packaging may be discarded once confirmed that all components have been assembled into a properly functioning stool Stool is not yet ready to be sat upon Read Recommended Usage section prior to attempting to sit on st
7. d see recommended height chart under the SPECIFICATIONS section 7 Adjust work surface so the user s forearms are in a horizontal position or sloping downward at a maximum of 3 4 figure 10 NOTICE New users might experience some discomfort within the first few days of use as the body gets used to this improved ergonomic posture Continued severe muscle soreness may be a sign of serious medical condition Consult your doctor if muscle soreness continues after two weeks of using the PS135 Stool August 2014 6 Document 3102661 RevA Brewer RECOMMENDED USAGE continued Standing up from the PS135 Stool To rise from the PS135 Stool move one foot slightly under the stool Shift weight to that foot Rise up from the stool while lifting other foot and swinging it forward Stepping forward in this manner ensures that the stool will remain in place figure 11 FALL HAZARD Exiting the PS135 Stool by rising forward with both feet in contact with the stool can cause the stool to tip forward causing personal injury Desired Direction a naaa SN Moving on the PS135 Stool To move sideways on the PS135 Stool push with one foot while pulling with the other figure 12 A 7 Pull Push _ gt Fig 12 To move forward on the PS135 Stool turn shoulder to the desired direction of movement and push with one foot while pulling with the other figure 13 August 2014 T
8. for the cost of the replacement part shipping and or any repair costs Product oo Warranty Registration Required Warranty Period PS135 Freight Claims Upon receipt merchandise should be carefully examined to ascertain that proper amount has been received in good condition once the delivery receipt is signed free and clear no freight claims can be made Any claim for shortage or damage must be made with delivering carrier within five 5 days from receipt of goods Brewer does not assume any responsi bility for loss or damage in transit and compensation for such loss must be obtained from the freight carrier August 2014 11 Document 3102661 RevA
9. ool Failure to understand proper sitting technique can lead to personal injury August 2014 5 Document 3102661 RevA Brewer RECOMMENDED USAGE Proper Sitting Technique for the PS135 Stool 1 Before sitting on the stool push down on seat with upper body weight while raising seat adjustment lever Release lever when seat will lower no further figure 5 2 Always approach the stool from the back and stand to one side figure 6 3 Shift weight to the leg matching the side of the stool where standing figure 6 For example if standing to the left of stool shift weight to the left leg If standing to the right of the stool shift weight to the right leg 4 Swing other leg over the back of the stool and be seated figure 6 Sitting on the chair this way helps to prevent accidents and will put user into the correct ergonomic position FALL HAZARD When swinging your leg over the stool make sure the stool has not rolled away before sitting 5 Raise the seat to a height where feet are just touching the floor figures 7 amp 8 6 Lift the adjustment lever and slowly lower seat until knees are at a 135 angle and feet remain flat on the floor figure 9 The stool is now at the proper ergonomic height Once proper height adjustment is achieved for a particular user further adjustment is not necessary Note if stool cannot be lowered enough to place feet flat on the floor another model may be neede
10. rising on its own drifting down or failure to raise or lower See TROUBLESHOOTING section for diagnosis Seat Inspect seat unit for cracks damaged upholstery or damaged height adjustment lever Replace if damaged See TROUBLESHOOTING section for diagnosis What may appear to be damage may be an adjustment need See SERVICE PARTS section for part numbers CLEANING Please see the Brewer Cleaning Guidelines in the Resources area of www brewercompany com August 2014 9 Document 3102661 RevA Brewer TROUBLESHOOTING Sit on stool Wiggle height Defective cylinder or adjustment lever Is lever seat control plate loose Some lever looseness is desirable Seat drifts down while seated or drifts up on it s own with no one seated Yes replace cylinder No replace seat control plate Place feet on floor and remove Weight not being removed some body weight as height from seat during raising adjustment lever is pulled up Does seat raise Yes normal operation No go to next Possible Cause Sit on stool Pull up slowly on Seat will not raise height adjustment lever Lever action should change from Defective cylinder or loose to firm but continue to Yes replace cylinder seat move against activation button No replace seat assembly on cylinder as it is pulled Is this the action the lever makes DO NOT SIT ON STOOL Apply weight using method shown in figure 5 Pull
11. unit Ensure that appropriate personnel are informed on Indicates a hazardous situation that if not avoided the manual contents This is the responsibility of the could result in death or serious injury purchaser e Ensure that this manual is located near the stool Indicates a hazardous situation that if not avoided could result in minor or moderate injury August 2014 2 Document 3102661 RevA Brewer SAFETY INFORMATION Continued FALL HAZARD FALL HAZARD e Kneeling on the e Standing on the PS135 stool can cause PS135 stool can cause instability resulting in instability resulting in serious injury serious injury e Do not kneel on stool e Do not stand on stool FALL HAZARD e Horseplay or speeding on the PS135 stool could create a fall hazard causing serious injury e Not intended for use by children FALL and STRAIN HAZARD Failure to use the appropriate PS135 stool as _ModelNumber User Height __ indicated in the chart at the right can cause PS135 1 lt 5 3 e Stool to roll away when sitting on or standing Muscle strains from not being able to attain the correct sitting position SPECIFICATIONS Model Number Height Range Base Diameter Shipping Weight Weight Capacity PS135 1 18 1 2 23 1 2 21 1 2 19 Ibs 250 Ibs PS135 2 21 3 4 29 21 1 2 19 8 lbs 250 Ibs PS135 3 24 34 21 1 2 20 6 Ibs 250 Ibs August 2014 3 Document 3102661 RevA Brewer P
Download Pdf Manuals
Related Search