Standesse technical manual
Contents
1. 8 52 334 VCS4x 10x x 994 1054 VCS4x 15x x 1494 1554 VCS4x 20x x 1994 2054 VCS4x 25x x 2394 2454 5 TECHNICAL PARAMETERS VCS4A 10E 1 0 0 2 1950 45 5 9 5 400 13 7 230 1 1 43 VCS4A 15E 1 0 0 2 2850 47 5 15 400 21 7 230 1 75 61 VCS4A 20E 1 0 0 2 3700 48 3 19 400 27 5 230 2 35 78 VCS4A 25E 1 0 0 2 50 4500 48 9 24 5 400 35 4 230 3 0 96 VCS4A 10V 1 0 0 2 1850 45 5 15 48 gt 230 1 10 45 VCS4A 15V 1 0 0 2 2750 49 7 33 43 230 1 75 63 VCS4A 20V 1 0 0 2 3600 51 0 45 39 230 2 35 78 VCS4A 25V 1 0 0 2 4400 51 5 57 24 230 3 00 98 The distance at which the average velocity of the air current flow drops to 2m s For optimal conditions mum performance of the equipment Acoustic pressure at a distance of 3 m from the curtain With water temperature gradient of 909 70 C and temperature of suctioned air at 18 C 5 TECHNICAL PARAMETERS VCS4B 10S 1 0 0 2 2200 52 1 230 2 25 VCS4B 15S 1 0 0 2 3400 54 5 230 3 50 59 VCS4B 20S 1 0 0 2 4550 55 3 230 4 70 76 VCS4B 25S 1 0 0 2 5500 56 3 230 5 60 93 VCS4B 10E 1 0 0 2 2150 52 1 9 5 400 13 7 230 2 25 46 VCS4B 15E 1 0 0 2 3350 54 5 15 400 21 7 230 3 50 63 VCS4B 20E 1 0 0 2 zy 4550 55 3 19 400 27 5 230 4 70 81 VCS4B 25E 1 0 0 2 5400 56 3 24 5 400 35 4 230 5 60 99 VCS4B 10V 1 0 0 2 2100 51 9 16 97 230 2 25 48 VCSAB 15V 1 0 0 2 3300 53 5 38 47 230 3 50 65 VCS4B 20V 1 0 0 2 4402. Detailed description of water coil regulation by zone valve ZV 3 including it s connection refer the instruction manual for zone valve ZV 3 QM EET vile 6 2 3 Regulating the water coil with an mixing valve MV 3 Air curtains with water coil and DA control module VCS R DA V 2 VCS4x xxV aT d Mixing valve MV 3 is an required accessorie for control module VCS R DA V 2 Detailed description of water coil regulation by mixing valve MV 3 including it s connection refer the instruction manual for mixing valve MV 3 15 6 INSTALLATION 6 3 ELEKTRO INSTALLATION A e The air curtain s electrical connection must be based on a professional design by a qualified elec trical systems engineer e Installation must be carried out by a professionally trained electrical worker All applicable na tional regulations and directives must be observed e The electrical schematics on the product take priority over those presented in this manual e Prior to installation check to see if the terminal markings correspond to the markings on the electrical connections diagram When in doubt contact your supplier and do not connect the air curtain under any circumstances e Never reach inside the air curtain unless the main electrical supply has been turned off e If the product is connected to any control system other than the original one the regulation and measurement components must be connected by the c
3. PARTNER IN VENTILATION STANDESSE comport VCS4x 1 1 Full manual INSTALLATION B01 0208 0511 15 1 BEFORE YOU BEGIN Meaning of symbols in the manual SYMBOL WENNS DO NOT OVERLOOK Important instructions YOU WILL NEED NOTE Practical tips and information TECHNICAL INFORMATION More detailed technical information Refer to other parts sections Before installation thoroughly read the section Safe use of air curtains It con tains all instruc tions on the safe and correct use of the product This manual contains important instructions to ensure correct installation of the air curtain Be fore installation read all of the following instructions thoroughly and then adhere to them The manufacturer reserves the right to make changes including to technical documentation without prior notice Save this user manual for further use The instructions in this manual are a part of the product Declaration of conformity Declatarion of confortmity for air curtains STANDESSE Comfort is located at www 2vv cz 2 1 CHECK THE SHIPMENT After delivery immediately check to see if the packaged product is damaged If the packag ing is damaged contact the delivery service If the complaint is not filed in time your claim may not be valid later Check to see if it is the same product you or dered If there are any discrepancies do not un
4. 0 55 0 52 64 230 4 70 83 VCSAB 25V 1 0 0 2 5250 56 1 65 46 230 5 60 97 VCS4C 10S 1 0 0 2 2850 55 6 230 3 30 48 VCS4C 15S 1 0 0 2 4150 55 8 230 4 60 64 VCS4C 20S 1 0 0 2 5150 56 0 gt 230 5 55 80 VCS4C 25S 1 0 0 2 6300 56 6 230 6 90 98 VCS4C 10E 1 0 0 2 2800 55 6 9 5 400 13 7 230 3 30 53 VCS4C 15E 1 0 0 2 4050 55 8 15 400 21 7 230 4 60 68 VCS4C 20E 1 0 0 2 0 5050 56 0 19 400 27 5 230 5 55 86 VCS4C 25E 1 0 0 2 6050 56 6 24 5 400 35 4 230 6 90 110 VCS4C 10V 1 0 0 2 2750 55 2 20 80 230 3 30 55 VCS4C 15V 1 0 0 2 3900 55 6 43 87 230 4 60 70 VCS4C 20V 1 0 0 2 4800 55 9 56 21 230 5 55 88 VCS4C 25V 1 0 0 2 5950 56 2 72 12 230 6 90 108 The distance at which the average velocity of the air current flow drops to 2m s For optimal conditions and maxi mum performance of the equipment Acoustic pressure at a distance of 3 m from the curtain With water temperature gradient of 90 70 C and temperature of suctioned air at 18 C Air curtains with electrical heater VCS4A 10E 1950 14 54 VCS4A 15E 2850 15 15 71 VCS4A 20E 3700 19 15 32 VCS4A 25E 4500 24 5 16 25 VCS4B 10E 2150 9 5 13 19 VCS4B 15E 3350 15 13 36 VCS4B 20E 4550 19 12 46 VCS4B 25E 5400 24 5 13 54 VCS4C 10E 2800 9 5 10 12 VCS4C 15E 4050 15 11 05 VCS4C 20E 5050 19 11 23 VCS4C 25E 6050 24 5 12 08 5 TECHNICAL PARAMETERS Air curtains with a water coil for a water temperature gradient of 90 70 C and at a suction air temperature of 18 C
5. 26 gt Included in delivery with VCS R DA x Zone valve for water heater regulation Cable Three core cable with diameter of 1 5 mm 230 V 50 Hz 6 4 4 Zone valve ZV 3 For VCS R DM V control modules only Connectors on the DM control modules 1 4 5 A Not included in delivery 6 INSTALLATION 6 4 5 Room thermostat TER P Room thermostat for water coil regulation Cable Two core cable with diameter of 1 5 mm 230 V 50 Hz For VCS R DM V control module only Connectors on the DM control modules 2 3 A Not included in delivery 6 4 6 Mixing valve MV 3 Mixing valve for water heater regulation Cable Three core cable with diameter of 1 5 mm 230 V 50 Hz For VCS R DA V control modules only Connectors on the DA control modules 3 4 5 A Not included in delivery 6 4 6 Thermostatic valve TV1 1 Thermostatic valve for water heater regulation For VCS R SM V control modules only Connectors on the SM control module NOT CONNECTED Not included in delivery 27 I QM EET vile 6 4 7 Exit sign Exit sign marking of emergency exit For all types of VCS4x air curtains Connectors on the control module NOT CONNECTED Not included in delivery 7 INITIAL START UP Before putting the curtain into operation check the following Have any tools or other objects which could damage the curtain been left inside it
6. 58 42 0 34 4 08 VCS4C 20V 4800 36 86 43 0 44 6 06 VCS4C 25V 5950 47 25 44 0 56 10 30 Air curtains with a water coil for a water temperature gradient of 60 40 C and at an intake air temperature of 18 C VCS4A 10V 1850 7 51 0 09 1 17 VCS4A 15V 2750 16 39 2 0 19 2 23 VCS4A 20V 3600 22 47 38 0 27 2 85 VCS4A 25V 4400 28 33 38 0 34 4 48 VCS4B 10V 2100 8 21 30 0 10 1 33 VCSAB 15V 3300 18 72 36 0 22 2 57 VCS4B 20V 4400 25 83 37 0 31 3 49 VCSAB 25V 5250 32 13 37 0 38 5 47 VCS4C 10V 2750 10 00 30 0 12 1 79 VCSAC 15V 3900 21 23 35 0 25 2 94 VCS4C 20V 4800 27 48 36 0 33 3 83 VCSAC 25V 5950 35 22 37 0 42 6 34 a maximum operational water temperature of 100 C and a maximum operating The warm water temperature coil made of copper aluminium alloy is designed for EL pressure of 1 6 MPa 6 1 CHOOSE THE INSTALLATION SITE AND INSTALL THE AIR CURTAIN 6 1 1 Built up dimensions min 200 mm 556mm min 300 mm pag min 100 mm Q e The air curtain must be installed only in a horizontal position The curtain can be installed over the door opening All separation distances for flammable mate rials and safe use of air curtain has to be kept The installed position of the air curtain can be chosen to accommodate the service hood e It must be operated in dry covered indoor spaces with an ambient temperature between 5 C and 435 C and relative humidity up to 80 e The air curtain is not intende
7. VCS4A 10V 1850 15 48 0 18 3 59 VCS4A 15V 2750 33 43 58 0 40 4 87 VCS4A 20V 3600 45 39 60 0 54 8 50 VCS4A 25V 4400 57 24 61 0 68 14 26 VCS4B 10V 2100 16 97 45 0 20 4 19 VCSAB 15V 3300 38 47 56 0 46 5 72 VCS4B 20V 4400 52 64 57 0 63 10 90 VCSAB 25V 5250 65 46 59 0 78 17 98 VCS4C 10V 2750 20 80 43 0 25 5 92 VCS4C 15V 3900 43 87 55 0 52 6 66 VCS4C 20V 4800 56 21 57 0 67 12 19 VCS4C 25V 5950 72 12 58 0 86 21 29 Air curtains with a water coil for a water temperature gradient of 80 60 C and at an intake air temperature of 18 C VCS4A 10V 1850 12 75 0 15 2 62 VCS4A 15V 2750 27 63 51 0 33 3 93 VCS4A 20V 3600 37 63 52 0 45 6 26 VCS4A 25V 4400 47 44 53 0 56 10 38 VCS4B 10V 2100 13 97 40 0 17 3 04 VCSAB 15V 3300 31 72 49 0 38 4 58 VCS4B 20V 4400 43 52 50 0 52 7 93 VCSAB 25V 5250 54 13 52 0 64 12 96 VCS4C 10V 2750 17 09 38 0 20 4 24 VCS4C 15V 3900 36 12 48 0 43 5 31 VCS4C 20V 4800 46 42 49 0 55 8 82 VCS4C 25V 5950 59 54 51 0 71 15 26 5 TECHNICAL PARAMETERS Air curtains with a water coil for a water temperature gradient of 70 50 C and at an intake air temperature of 18 C VCS4A 10V 1850 10 10 0 12 1 82 VCS4A 15V 2750 21 96 44 0 26 3 05 VCS4A 20V 3600 30 00 45 0 36 4 38 VCS4A 25V 4400 37 82 46 0 45 7 13 VCS4B 10V 2100 11 05 35 0 13 2 09 VCSAB 15V 3300 25 15 43 0 30 3 54 VCSAB 20V 4400 34 60 43 0 41 5 48 VCSAB 25V 5250 43 03 44 0 51 8 82 VCS4C 10V 2750 13 50 34 0 16 2 88 VCS4C 15V 3900 28
8. d for moving air that contains combustible or explosive mixtures chemical fumes coarse dust soot grease poisons infectious germs etc 6 1 2 Clearance distance NEN omm 77 e 5 zT MATERIAL 2 MATERIAL 9 2 Dru N LA M n N X S Y 4 N A MATERIAL ea g A 1 i E e 13 4 1 3 O 1 1 O y 1 3 1 3 1 7 4 N ET 4 N 2 Fi S x 4 ES P 1 Sh Le N 2 ww d Ne ww 5e 6 INSTALLATION Only nonflammable materials those that do not burn smoulder or carbonise or fire resistant materials those that do not burn but mainly smoulder e g plaster board can be kept within 100 mm in any direction of the air curtain However these materials should not block the intake or outlet openings For air curtains with an electric heater safe distances from building structural surfaces and flam mable objects are as follows e the safe distance for flammable materials in the direction of the main air flow i e behind the outlet is 500 mm The safe distance for flammable materials above the air curtain is 500 mm e The safe distance for flammable materials in other directions is 100 mm Vv OK E Fea sa Y S OK a a 5 f C CTUM 6 1 3 Measure the instal
9. e 15 there a proper supply of electricity and if necessary heating water Has the air curtain been properly closed Has the control module been connected properly LI Before putting the curtain into operation read carefully Full manual for OPERATION AND MAINTENANCE delivered with control module 7 1 SET AIR FLOW DIRECTION This is set by tilting the air curtain s fan louvers in the desired direction 29 If you have any doubts or questions do not hesitate to contact our sales or technical support de partment Ll Before operation and maintanance thoroughly read the section Safe use of air curtains It con tains all instructions on the safe and correct use of the product Address 2VV s r O Pod bradska 289 530 09 Pardubice Czech Republic Internet http www 2vv cz contact distribution php Copyright c 2005 2011 2VV s r o All rights reserved B01 0208 0511 15 31
10. instaled side by side mechanical chaining it is necessary to connect them by connection couplers delivered with each air curtain 6 INSTALLATION 6 2 CONNECT THE WATER INTAKE AND OUTLET HOSES VCS4 x xxV VCS4x xxV VCS R SM V VCS4x xxV VCS4x xxV VCS R DM V VCS R DA V A flexible hoses with a G3 4 connection A Connection and pressure testing of the heater must be carried out by a person with professional plumbing knowledge who must observe current standards and regulations of the given country The maximum water temperature is 4 100 C The maximum pressure is 1 6 MPa We recommend installing a stop valve on the intake and outlet of the heater to allow the water supply to be shut off 13 6 INSTALLATION 6 2 1 Regulating the water coil with a thermostatic valve TV1 1 Air curtains with water coil and SM control module VCS R SM V 2 TV1 1 VCS4x xxV VCS R SM V Thermostatic valve TV1 1 is an re quired accessorie for control module VCS R SM V 2 Detailed description of water coil regulation by thermostatic valve TV1 1 including it s connec tion refer the instruction manual for thermostatic valve TV1 1 6 2 2 Regulating the water coil with a ZV 3 zone valve Air curtains with water coil and DM con trol module VCS R DM V 2 VCS4x xxV VCS R DM V Zone valve ZV 3 is an required acces sorie for control module VCS R DM V 2
11. lation site Em Choose the location for the installation and measure the installation site Measure out the dimen sions of ceiling installation or for wall mounted brackets For ceiling installation use Ceiling holder SET VCS4 KONZ STR Ceiling holder SET has to be ordered separately as an optional accessorie 4x Ga yr ae vile For wall installation use Wall mounted bracket set VCS4 KONZ STE Wall mounted bracket SET has to be ordered separately as an optional accessorie 470 Measurement Type Spacing of installation L1 wall holes L2 mm mm VCS4x 10x x 994 210 VCS4x 15x x 1494 210 VCS4x 20x x 1994 210 VCS4x 25x x 2394 210 11 6 INSTALLATION Type Spacing of installation L1 cell holes L2 mm mm VCS4x 10x x 994 240 VCS4x 15x x 1494 240 VCS4x 20x x 1994 240 VCS4x 25x x 2394 240 6 1 4 Suspend the air curtain on the threaded bars or wall mounted brackets and ensure that the suspension will not come loose A In consideration of the air curtain weight into account it is necessary to use either a suitable lifting device forklift etc or use two additional individuals to support it as long as it is not securely fastened A Suspension has to carry the weight of the air curtain 6 1 5 Mechanical chaining If the air curtains are
12. ol module module TV1 1 MV 3 Thermostatic Mixing ERN Zone valve a E mmc amm mz m x ox qp VCS4 KONZ STR VCS4 KONZ STR VCS4 KONZ STR VCS4 KONZ STE VCS4 KONZ STE VCS4 KONZ STE VCS4 EXIT VCS4 EXIT VCS4 EXIT 6 INSTALLATION Q When connecting external components the electricity to the air curtain must be turned off e All external control components must be connected according to the electrical schematic The connectors must be connected to the electrical board using reasonable force and always ver tically to the base Header Connector 6 4 1 Door contact DK Isolated switching contact with a maximum voltage of 12V Cable Dual core cable with a diameter of 0 5 mm Maximum length 50 m For DM and DA control modules only Connectors on the DM control modules DK DK Connectors on the DA control modules 27 28 Not included in delivery 25 6 INSTALLATION 6 4 2 Door switch DS Isolated switching contact with a maximum voltage of 230V Cable Dual core cable with a diameter of 1 5 mm Maximum length 50 m For SM control modules only Connectors on the SM control modules DK1 DK2 gt Not included in delivery 6 4 3 External temperature sensor PE OUTSIDE 25 26 Thermally dependent resistive sensor T For DA control modules only Connectors on the DA control modules 25
13. ompany that supplied the system Minimal cable dimensions Fuse specification TYPE Cable dimenti able dimention VCS4x xxS 3Cx1 5 A B c VCS4x xxV 3Cx1 5 ee 15 315A 4 63A VCS4x 10E 5Cx2 5 ax 20 315A 63 8 VCS4x 15E 5Cx4 25 4A 8A 8A VCS4x 20E 5Cx4 VCS4x 256 5Cx6 e The electrical parameters are shown on the man ufacturer s label which is located under the air curtain s service cover Air curtain Type U Voltage Net current f Frequency Output n 5 m Weight ph Phase IP IP rating av Air output ver Serial number 3 400v L1 L2 L3 PE 1 230V L N PE 6 INSTALLATION e The air curtain must be protected by an appropriate circuit breaker in accordance with its electri cal parameters For safety reasons over designed protection is not recommended e The air curtain must be connected using the TN S system which means that the neutral conduc tor must always be connected e A main cut off switch must be placed in the electrical supply network disconnecting all poles of the network e The electrical enclosure of the air curtain is IP20 STANDESSE Comfort air curtains are equipped with a fuse with T characteristic slow blow This safety fuse protects the electronic panel and fans It is located under the service cover next to the main power supply connectors 6 3 CONTROL MODULES Air curtains STANDESSE Comfort are produced with unive
14. pack the curtain and immediately report the defect to the supplier e After unpacking check to see if the curtain and other parts are in order If you have any doubts contact the supplier e Never install a damaged air curtain If you do not unpack the curtain immediately after delivery it must be stored in a dry indoor environment with an ambient tem perature between 5 and 35 n go 9 reused or recycled 2 2 UNPACK THE AIR CURTAIN e If the curtain has been transported at temper atures below 0 C it will be necessary to let it sit for at least 2 hours under normal operating conditions after unpacking without turning it on This will allow the air curtain s interior tem perature to stabilise All used packaging materials are environmentally friendly and may be Take an active part in environmental protection and see that packaging materials are correctly disposed of or repurposed 3 MAIN PARTS AWN Suspension holders Water coil connection 34 Power supply cable plug Control cable plug SM control module or cable plug for water coil regulator DA DM control modules Pitfor capillary TV1 1 SM control module only Power supply connectors and fusse location Control modul socket Inlet face cover Outlet grid vtt 45 3 114 N 8lv ES lov
15. rsal connection interface Air curtains STANDESSE Comfort can be controlled by one of following control modules Control modules are required accessories and has to be ordered separatelly Air curtain is connected with control module by Quick connection sockets 6 3 1 Insert control module to the air curtain 17 6 INSTALLATION 6 3 2 SM control module suitable with all types of air curtains Types of SM control modules VCS R SM S Suitable withl types without heating VCS4x xxS DK1 DK2 X2 WHITE c1 NN VCS R SM V Suitable with types with water coil VCS4x xxV DK1 DK2 X2 WHITE VCS R SM E Suitable with types with electric heater VCS4x xxE DK1 6 INSTALLATION Ll For detailed information of SM control modules installation into STANDESSE Comfort air curtains read carefully QUICK START manual for SM control modules installation delivered with control module Ll For detailed information of SM control modules operation with STANDESSE Comfort air curtains read carefully Full manual OPERATION AND MAINTANANCE of STANDESSE Comfort with SM control module 6 3 2 1 Function overview of SM control modules VCS4 KONZ STR VCS4 KONZ STR VCS4 KONZ STR VCS4 KONZ STE VCS4 KONZ STE VCS4 KONZ STE VCS4 EXIT VCS4 EXIT VCS4 EXIT ae a a pe Thermos
16. taticvatve Power cable 230V Power cable 230V Power cable 230V ON OFF ON OFF ON OFF 6 INSTALLATION 6 3 3 DM control module suitable with all types of air curtains Types of DM control modules VCS R DM S Suitable with all types without heating VCS4x xxS E DK X2 WHITE DK VCS R DM V Suitable with all types with water coil VCS4x xxV ES P ES 22 BLUE 2 WHITE VCS R DM E Suitable with types with electric heater VCS4x xxE is X5 NONE 4 m 2 X3 BLUE X2 WHITE DK LI For detailed information of DM control modules installation into STANDESSE Comfort air curtains read carefully QUICK START manual for DM control modules installation delivered with control module LI For detailed information of DM control modules operation with STANDESSE Comfort air curtains read carefully Full manual OPERATION AND MAINTANANCE of STANDESSE Comfort with DM control module 6 INSTALLATION 6 3 3 1 Function overview of DM control modules DM DM DM VCS R DM S VCS R DM E VCS R DM V ZN 3 VCS R DM S VCS R DM E VCS R DM V LED LED LED LED BEEP sound LED BEEP sound LED BEEP sound In radio signal range In radio signal range In radio signal range 21 6 INSTALLATION 6 3 4 DA control module suitable with air curtains with water or electric heater Types of control mod
17. ules VCS R DA V Suitable with all types with water coil VCS4x xxV 23 n n 24 signalization H 53 External temp sensor e 27 e 28 e 29 7 e 30 EXT VCS R DA E Suitable with types with electric heater VCS4x xxE 23 eee 24 Run signalization 2 External temp sensor e 27 e 128 DK 29 e 30 ue Ee For detailed information of DA control modules installation into STANDESSE Comfort air curtains read carefully QUICK START manual for DA control modules installation delivered with control module LI For detailed information of DA control modules operation with STANDESSE Comfort air curtains read carefully Full manual OPERATION AND MAINTANANCE of STANDESSE Comfort with DA control module 6 INSTALLATION 6 3 4 1 Function overview of DA control modules DA DA VCS R DA E VCS R DA V Included with Included with control module control module X MV 3 Mixing valve DA DA VCS R DA E VCS R DA V xx p 2 internal sensors 2 internal sensors LCD LCD 23 QM EET vile 6 4 CONNECT THE EXTERNAL ACCESSORIES Accessories overview DM DA DM DA VCS R VCS R D VCS R DA E M V DA V Included Included with with control contr
Download Pdf Manuals
Related Search