Invacare® I
Contents
1. 1183377 A 25 l Transia Dimensions 580 22 8 in 350 13 8 s Ls C 156 mm 6 1 in D 184 mm 7 2 in E 83 mm 3 3 in C gt d 415 mm 16 3 in DP G 2500 mm 98 4 in 0 qe Eh Depth of hoist 194 mm 7 6 in B Safety Emergency stop Yes Emergency lowering device _ Yes electrical Control of lifting strap Yes Cut off angle Electronics 45 along the rail 10 across the rail On off Automatic when used Soft star stop Overload protection Automatic Low battery protection Automatic Power supply 36 V DC 0 83 A Supply voltage transformer 100 240 V AC 47 63 Hz Battery 24 V NiMH 2 8 Ah Continuous operation with short time loading with 3 hours without recharging 10 9076 2 min operation 18 min pause Max number of lifts in series 77 with 85 kg 187 Ib 33 1900 mm Max number of lifts in series with SWL 205 kg 450 Ib 28 1000 mm 250 kg 550 Ib M harging ti t 25 ax charging time a 3 hrs Operating temperature 10 C 35 C 50 F 95 F 26 1183377 A Warranty 10 Warranty 10 1 Limited Warranty Europe Terms and conditions of the warranty are part of the general terms and conditions particular to the individual countries in which this product is s2. Safety Transia Hand control Hanger Bar o Part no XXXXXX Edition Date XXXX XX XX IP44 Made in Portugal The hanger bar label is located near the end of the hanger bar to the inside of the hooks 1183377 A Setup 3 Setup 3 1 Included Items l Transia hoist l 2 Hand control 3 Transformer 4 Charging station 5 Side covers 6 Hanger bar The hoist includes the lifting strap carabiner and trolley 3 2 Installing the Hanger Bar Before Use WARNING A Risk of Injury Pinch points are present on the strap carabiner and fingers could be pinched The hanger bar can move suddenly and cause injury ALWAYS keep hands and fingers clear of moving parts to avoid injury When positioning the hoist be aware of the position of the hanger bar and the patient Injury could occur 1183377 A I l Transia The hanger bar can be installed to the lifting strap carabiner B without the use of tools Pull and hold the retainer up toward the pin Move the pin and retainer down to open the carabiner Install the hanger bar onto the carabiner Release the retainer and pin Before use ensure the hanger bar is installed completely onto the carabiner and the retainer is in place as shown in the figure Ud GC MN 3 3 Before Use 1 is delivered with the emergency stop activated in order to ensu
3. Fax 43 6232 5535 4 www invacare at info invacare austria com Invacare Corporation Worldwide Headquarters One Invacare Way Elyria Ohio 44036 Tel 800 333 6900 Fax 877 619 7996 ConsumerCare invacare com www invacare com Invacare Canada 570 Matheson Blvd East Unit 8 Mississauga Ontario L4Z 4G4 Tel 800 668 5324 Fax 800 668 5478 www invacare ca infocanada invacare com Invacare Corporation USA One Invacare Way Elyria Ohio USA 44036 2125 800 333 6900 www invacare com 1183377 A 2013 05 07 Manufacturer ad V Guldmann A S Graham Bells Vej 21 23A DK 8200 Aarhus N Denmark EU Representative pen Invacare Limited Pencoed Technology Park Pencoed Bridgend CF35 5AQ United Kingdom Making Life s xP ertences Possible Yes you can
4. 64 9 917 3957 www invacare co nz sales invacare co nz Invacare Poirier SAS Route de St Roch F 37230 Fondettes Tel 33 0 2 47 62 64 66 Fax 33 0 2 47 42 12 24 www invacare fr contactfr invacare com Invacare AG Benkenstrasse 260 CH 4108 Witterswil Tel 41 0 61 487 70 80 Fax 41 0 61 487 70 81 www invacare ch switzerland invacare com Invacare GmbH AlemannenstraBe 10 D 88316 Isny Tel 49 0 75 62 7 00 0 Fax 49 0 75 62 7 00 66 www invacare de kontakt invacare com Invacare Lda Rua Estrada Velha 949 P 4465 784 Leca do Balio e Tel 351 0 225 1059 46 47 Fax 351 0 225 1057 39 www invacare pt portugal invacare com Invacare SA c Areny s n Poligon Industrial de Celra E 17460 Celr Girona Tel 34 0 972 49 32 00 Fax 34 0 972 49 32 20 www invacare es contactsp invacare com Invacare nv Autobaan 22 B 8210 Loppem Tel 32 0 50 83 10 10 Fax 32 0 50 83 10 11 belgium invacare com www invacare be Invacare BV Celsiusstraat 46 NL 6716 BZ Ede Tel 31 0 318 695 757 Fax 31 0 318 695 758 nederland invacare com www invacare nl csede invacare com Invacare AS Grensesvingen 9 Postboks 6230 Etterstad N 0603 Oslo Tel 47 0 22 57 95 00 Fax 47 0 22 57 95 Ole www invacare no norway invacare com island invacare com Invacare Austria GmbH Herzog Odilostrasse 101 A 5310 Mondsee Tel 43 6232 5535 0
5. Check the emergency stop and emergency lowering function Check all parts for external damage or wear If damage is found DO NOT use Contact your Invacare dealer IMMEDIATELY Check that all hardware and attachment points for damage or wear Check all parts for external damage or wear If damage is found DO NOT use Contact your Invacare dealer IMMEDIATELY Verify that the hand control is functional Check the battery charger Charge the battery every day the lift is used Check the carabiner for wear at the bottom contact point 9 Do not use the hoist if the carabiner measures less than 6 mm 1 4 in at this point Safety Inspection Checklist The annual safety inspection checklist is available in the 1 service manual 8 3 Cleaning the Sling and Hoist Cleaning the Sling Refer to the washing instructions on the sling and to the sling manual for cleaning details Cleaning and Disinfecting the Hoist To prevent cross infection the parts of the hoist that come in contact with caregivers and patients must be cleaned and disinfected A soft cloth dampened with water and a small amount of dish liquid is all that is needed to clean the hoist lifting strap and carabiner The hoist can be cleaned with non abrasive cleaners Never use acids alkaline or solvents for cleaning the hoist Dry the hoist carefully after cleaning The hoist hand control and mounting parts can be da
6. a certified technician The transformer supplied must always be used Refer to for more information about the power supply 2 5 Radio Frequency Interference WARNING A Most electronic equipment is influenced by Radio Frequency Interference RFI CAUTION should be exercised with regard to the use of portable communication equipment in the area around such equipment If RFI causes erratic behavior stop the unit using the hand control or emergency stop DO NOT use the unit while transmission is in progress 8 1183377 A 2 6 Product Labeling Hoist Only one of the weight limit labels on the bottom of the hoist 33V AC 2 5 A IP44 AX Made in Denmark Barcode 128 Manufacturer V Guldmann A S Graham Bells Vej 21 23A DK 8200 Aarhus N Denmark WITH SHORT TIME LOADING INTERNALLY POWERED EQUIPMENT 24V DC Barcode GS1 13 l Transia 250110000 l Transia 205 110 000 amp Serial Number Power supply 1183377 A max 250 kg 550 Ibs max 205 kg 450 Ibs 5SINPRO SWITCHING POWER SUPPLY MODEL NO HPU31B 110 INPUT 100 240V o 47 63Hz 0 6 0 4A OUTPUT 36V 0 83A max CB E oC FEC Indoor use only LPS E 230351 C Efficiency Level gl 60601 1 7604 TPAY MRSA ACAUTION DO NOT OPEN RISK OF ELECTRIC SHOCK ATTENTI 0 DE CHOC ELECTRIQUE RoHS XX MADE IN
7. at the address on the back cover provide dealer s name address date of purchase indicate nature of the defect Invacare Corporation will issue a serialized return authorization The defective unit or parts MUST be returned for warranty inspection using the serial number when applicable as identification within 30 days of return authorization date Do not return products to our factory without our prior consent C O D shipments will be refused please prepay shipping charges LIMITATIONS AND EXCLUSIONS THE FOREGOING WARRANTY SHALL NOT APPLY TO SERIAL NUMBERED PRODUCTS IF THE SERIAL NUMBER HAS BEEN REMOVED OR DEFACED PRODUCTS SUBJECTED TO NEGLIGENCE ACCIDENT IMPROPER OPERATION MAINTENANCE OR STORAGE PRODUCTS MODIFIED WITHOUT INVACARE S EXPRESS WRITTEN CONSENT INCLUDING BUT NOT LIMITED TO MODIFICATION THROUGH THE USE OF UNAUTHORIZED PARTS OR ATTACHMENTS PRODUCTS DAMAGED BY REASON OF REPAIRS MADE TO ANY COMPONENT WITHOUT THE SPECIFIC CONSENT OF INVACARE OR TO A PRODUCT DAMAGED BY CIRCUMSTANCES BEYOND INVACARE S CONTROL AND SUCH EVALUATION WILL BE SOLELY DETERMINED BY INVACARE THE WARRANTY SHALL NOT APPLY TO PROBLEMS ARISING FROM NORMAL WEAR OR FAILURE TO ADHERE TO THE INSTRUCTIONS IN THIS MANUAL THE FOREGOING WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER EXPRESS WARRANTIES IMPLIED WARRANTIES IF ANY INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE SHALL NOT EXTEND BEYOND THE DURATION OF THE EX
8. or both IMPORTANT Indicates a hazardous situation that could result in damage to property if it is not avoided Gives useful tips recommendations and information for efficient trouble free use Emergency Stop Emergency Lowering Function Reset emergency stop Danger rotating parts This product complies with Directive 93 42 EEC concerning medical devices The launch date of this product is stated in the EC declaration of conformity Type B in accordance with IEC EN 60601 1 Read the manual before use 1 2 Intended Use 1 is a hoist which covers the need for lifting or moving a person with disabilities in the home care sector nursing homes rehabilitation centres and institutions 1183377 A General 1 3 Conditions for Use The use of the I Transia ceiling hoist is subject to the following Thel Transia should only be used by trained personnel e The safe working load SWL 205 kg 450 Ibs or 250 kg 550 Ibs must not be exceeded Refer to 2 3 Load Limits page 8 The instruction offered by Invacare to all customer groups in connection with the purchase of a ceiling mounted hoist has been received The caregiver pays attention to the well being of the user when using the hoist The hoist is used in rail systems which are installed tested and approved according to DS EN 10535 and Invacare s stipulations Only technicians who have been certified by Invacare may install and test the
9. rail systems The hoist is used with an Invacare hanger bar The hoist is used with an Invacare lifting sling or with other suitable slings Refer to 5 Sling Information page 18 1 4 Service Life The 1 has an expected lifetime of 15 years on the condition of correct use and correct service inspections Refer to the I Transia user manual for more information 1 5 Features Information panel on the I Transia bottom surface Green yellow battery indicator lamp Strap for activating emergency stop and emergency lowering device 1183377 A 5 Transia 2 Safety 2 1 General Guidelines WARNING A Read and understand these instructions DO NOT use this product without reading and understanding these instructions If you need help with these instructions contact a healthcare professional or an Invacare dealer Otherwise injury or damage may occur ACCESSORIES WARNING Invacare products can only be used with accessories made by Invacare Accessories not made by Invacare have not been tested by Invacare Accessories not made by Invacare should not be used Check all parts for shipping damage before using In case of damage DO NOT use the equipment Contact your Invacare dealer for further instructions The information contained in this document is subject to change without notice 2 2 Operating Information This section of the manual contains general safety information abo
10. Contact an Invacare dealer for service No indicator light on hoist System does not have power Check that the I Transia has or battery is discharged power supply and that the battery is recharged Check that the power supply is switched on and connected to the charging station Place the hand control in the charging station and recharge the 1 The emergency lowering cord Hoist requires service Contact an Invacare dealer does not turn hoist off for service The emergency lowering cord Hoist requires service Contact an Invacare dealer does not lower the hoist for service If problems are not remedied by the suggested means please contact your Invacare dealer 22 1183377 A Maintenance 8 Maintenance 8 1 Safe Maintenance WARNING A Regular maintenance of patient lifts and accessories is necessary to assure proper operation Maintenance MUST be performed only by a certified technician 8 2 Maintenance and Safety Inspection Service Interval At normal daily operation a service check up should take place every year according to the Safety Inspection Checklist in the Service Manual When performing annual or regular maintenance all parts designed to carry load must be as a minimum tested with load All safety features must be checked according to EN ISO 10535 2006 Annex B This inspection must be performed by a certified technician LOLER Statement The UK Health and Safety Executiv
11. Invacare 9 I Transia Transia 205 kg 450 Ib I Transia 250 kg 550 Ib EN Ceiling Hoist User Manual This manual MUST be given to the user of C the product BEFORE using this product read this Yes you can manual and save for future reference 9 2013 Invacare Corporation All rights reserved Republication duplication or modification in whole or in part is prohibited without prior written permission from Invacare Trademarks are identified by and 9 All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted Contents I General 1 1 Symbols 1 2 Intended Use 1 3 Conditions for Use 14 Service Life 1 5 Features 2 2 1 General Guidelines 22 Operating Information General Pinch Points and Positioning 2 3 Load Limits 2 4 Power Supply 2 5 Radio Frequency Interference 2 6 Product Labeling 3 3 1 Included Items 32 Installing the Hanger Bar Before Use 3 3 Before Use 4 Operation 4 1 Indicator lamps and audio signals 42 Operating the Hoists 43 Charging the 44 Emergency stop and lowering strap Emer
12. PRESSED WARRANTY PROVIDED HEREIN AND THE REMEDY FOR VIOLATIONS OF ANY IMPLIED WARRANTY SHALL BE LIMITED TO REPAIR OR REPLACEMENT OF THE DEFECTIVE PRODUCT PURSUANT TO THE TERMS CONTAINED HEREIN INVACARE SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES WHATSOEVER SOME STATES DO NOT ALLOW EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGE OR LIMITATION ON HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE EXCLUSIONS AND LIMITATIONS MAY NOT APPLY TO YOU THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH STATE OR PROVINCIAL LAWS AND REQUIREMENTS 1183377 A 27 Notes Notes Notes United Kingdom Ireland Australia New Zealand France Switzerland Deutschland Portugal Espaf a Belgium amp Luxemburg Nederland Norge Osterreich USA Canada Invacare Limited Pencoed Technology Park Pencoed Bridgend CF35 5AQ Tel 44 0 1656 776 222 Fax 44 0 1656 776 220 www invacare co uk UK invacare com Invacare Ireland Ltd Unit 5 Seatown Business Campus Seatown Road Swords County Dublin Ireland Tel 353 1 810 7084 Fax 353 810 7085 www invacare ie ireland invacare com Invacare Australia Pty Ltd Lenton Place North Rocks NSW 2151 Australia Tel 61 2 8839 5333 Fax 61 2 8839 5353 www invacare com au sales invacare com au Invacare New Zealand 4 Westfield Place Mt Wellington Auckland New Zealand Tel 64 9 917 3939 Fax
13. a 6 After Use 6 1 Transport and Storage Invacare recommends that the I Transia is always transported and stored in the original packaging For long term storage the emergency stop must be activated Refer to Emergency stop page 15 This will prevent the discharge of the battery The I Transia should be stored as indicated by the packaging symbols in the table Packaging Storage Condition Symbol Temperatures between 10 and 40 C 14 and 104 F Relative Air Humidity between 30 and 7076 Air Pressure between 700 and 1060 hPa wq 6 2 Disposal WARNING A Environmental Hazard This product has been supplied from an environmentally aware manufacturer that complies with the Waste Electrical and Electronic Equipment WEEE Directive 2002 96 CE This device contains NiMH batteries This product may contain substances that could be harmful to the environment if disposed of in places landfills that are not appropriate according to legislation DO NOT dispose of batteries in normal household waste They MUST be taken to a proper disposal site Contact your local waste management company for information Please be environmentally responsible and recycle this product through your recycling facility at its end of life 20 1183377 A After Use Environmental Policy Statement Invacare is continuously working towards ensuring that the company s impact on the environment locally and globally is reduced to a m
14. any tubes and wires that are attached to the user Check that the red emergency strap hand control and hand control cable are free of the hanger bar user and other objects before the hoist is activated and moved up or down When the hoist is used correctly the user should only be lifted to the extent that she he is clear of the surface and should be moved at this height 5 4 Lifting to and from a seated position Follow this procedure when lifting a person from a seated position wheelchair commode etc Move the 1 towards the person to be lifted 2 Position the hanger bar at the same height as the person s chest and no closer than mid thigh 3 Position the hanger bar so it is parallel to the person s shoulders 4 Position the person in the sling Refer to the sling user manual 5 Attach the sling to the hanger bar Refer to 5 2 Attaching the Sling page 18 5 5 Lifting to and from a lying position Follow this procedure when lifting a person from a lying position in bed Move the l Transia towards the person to be lifted Position the hanger bar over the center of the person Position the hanger bar so it is parallel to the person s shoulders Position the person in the sling Refer to the sling user manual Elevate the head of the bed so that the user is sitting up Attach the sling to the hanger bar Refer to 5 2 Attaching the Sling page 18 Ov UY dec pA 1183377 A 19 Transi
15. e s Lifting Operations and Lifting Equipment Regulations 1998 require any equipment that is used in the workplace to lift a load be subject to safety inspection on a six monthly basis Please refer to the HSE web site for guidance www hse gov uk The person responsible for the equipment must ensure adherence to LOLER regulations General Maintenance Follow the maintenance procedures described in this manual to keep your patient lift in continuous service The hoist is designed to provide a safe efficient and satisfactory service with minimum care and maintenance It is important to inspect slings hanger bar carabiner and lifting strap for signs of cracking fraying deformation or deterioration If damage is found DO NOT use Contact your Invacare dealer IMMEDIATELY If you question the safety of any part of the lift contact your Invacare dealer immediately and advise him her of your problem Replacement of parts must only be performed by a certified technician 1183377 A 23 Transia Daily Inspections The hoist should be checked each time it is used Perform the following checks in addition to those performed in the annual service inspection If you question the safety of any part of the lift DO NOT use Contact your Invacare dealer IMMEDIATELY Visually inspect the sling hanger bar and lifting strap Check all parts for damage or wear If damage is found DO NOT use Contact your Invacare dealer IMMEDIATELY
16. gency stop Emergency lowering Resetting the emergency stop 5 Lifting the Patient 5 1 Sling Information 5 2 Attaching the Sling 5 3 Lifting Information 5 4 Lifting to and from a seated position 5 5 Lifting to and from a lying position 6 After 10 6 1 Transport and 20 6 2 Disposal 20 Troubleshooting 22 7 1 Troubleshooting Table 22 Maintenance 23 8 1 Safe Maintenance 23 8 2 Maintenance and Safety Inspection 23 8 3 Cleaning the Sling and Hoist eae 24 Technical Data 25 9 1 Typical Product Parameters 25 Warranty 27 10 1 Limited Warranty Europe 27 10 2 Limited Warranty North America 27 I Transia General 1 1 Symbols Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage See the information below for definitions of the signal words A A Qv 7 RESET CE A WARNING Warning indicates a potentially hazardous situation which if not avoided could result in death or serious injury CAUTION Caution indicates a potentially hazardous situation which if not avoided may result in property damage or minor injury
17. he hand control in the charging station when the l Transia is not in use This guarantees l Transia functionality and maintains the battery to ensure a long lifetime The transformer must be connected and switched on before charging can take place A green indicator lamp on the transformer indicates it is connected and switched on 1 Tilt the hand control and place it on the two pins B on the charging station 2 Push the rubber handle into the opening on the charging station ii An audible click indicates that the hand control is placed correctly 4 4 Emergency stop and lowering strap WARNING A If the emergency stop or lowering strap must be used there is a problem with the system Contact your Invacare dealer for service before using the system again 14 1183377 Operation The red strap on the underside of the hoist B has the following functions e Emergency stop e Emergency lowering Emergency stop Pull and release the red strap 9 to activate the emergency stop function if the hoist B does not stop or react to the hand control during use Lifting lowering functions are deactivated Emergency lowering will not stop The hoist will not function until the emergency stop is reset The green lamp will turn off 1183377 A Transia Emergency lowering The emergency lowe
18. inimum It is Invacare s goal to e Comply with the current environmental legislation e g WEEE and REACH directives Ensure that we at the widest possible range use RoHS compliant materials and components Ensure that our products do not have an unnecessary negative impact on the environment regarding use recirculation or disposal Ensure that our products contribute to a positive working environment in the places they are utilised Inspections are made annually by the Department for Nature and Environment from the Municipality of Aarhus using the Danish Environmental Protection Act section 42 as a reference 1183377 A 21 1 7 Troubleshooting 7 1 Troubleshooting Table I Transia hoist does not Emergency stop is activated Check that the emergency respond to the hand control s stop is not activated keys System does not have power Check that the I Transia has or battery is discharged power supply and that the battery is recharged Check that the transformer is switched on and connected to the charging station Place the hand control in the charging station and recharge the l Transia Trolley does not traverse Rails require service or Contact an Invacare dealer cleaning for service Hoist will not charge System does not have power Place the hand control in the charging station and recharge the 1 Check that the power supply is switched on and connected to the charging station
19. ix lifting straps designed for mounting on hooks should be used when using a Invacare hanger bar Refer to the sling user manual for more details about the slings UK Customers Please see the Invacare bulletin concerning slings A copy can be obtained from Invacare UK 01656 776222 or uk invacare com 5 2 Attaching the Sling CAUTION A Be careful when attaching the lifting sling on the hooks Check that the straps have been positioned completely onto the hooks of the hanger bar When pressing the up button to lift the user check again that all the straps remain correctly placed in the hanger bar s hooks Place the uppermost set of straps from the back of the sling on the hooks on the hanger bar 2 Place the lowest set of straps from the legs of the sling on the hooks on the hanger bar Refer to the sling user manual for proper positioning of the person in the sling and proper positioning of the straps on the hanger bar 18 1183377 A Lifting the Patient 5 3 Lifting Information WARNING A Only personnel who have received training regarding the use of lifting equipment and fitting of slings should use the hoist Plan the move Avoid leaving the user in the sling unattended The l Transia lifts quickly Before lifting check that the user is completely free of his her surroundings The user s head arms hands and feet must not be in danger of becoming trapped Be careful with
20. maged if the hoist is cleaned any other way than stated above The hoist must be wiped with a moistened firmly wrung cloth with ordinary household disinfectants Only use disinfection detergents approved by the facility 24 1183377 A Technical Data 9 Technical Data 9 1 Typical Product Parameters Classification Non permanent installation with out protective ground Mobile equipment is class Il equipment marked with double encased symbol and can be connected to the mains Class Il equipment direct by the user Equipment is disconnected from the supply mains by detaching the mains plug from the wall outlet Flammability This equipment is not suitable for use in the presence of Flammabilit y flammable mixtures Liquid Ingress Lifting module IP 44 Hand control Charging station IP 20 Power supply IP 20 Functions Lifting capacity Safe Working 205 kg 450 Ib 250 kg 550 Ib Load SWL Operation Hand control Sound level 52 dB A Lifting Speed 85 kg 187 Ib load 40 mm sec 1 6 in sec 150 kg 330 Ib load 40 mm sec 1 6 in sec Safe Working Load SWL 40 mm sec 1 6 in sec Max 5 kg 11 Ib load 80 mm sec 3 2 in sec Weight and materials Safe Working Load SWL 205 kg 450 Ib 250 kg 550 Ib Hoist weight 8 0 kg 17 6 Ib Covers top and bottom Impact resistant UL 94 V 0 flame retardant recyclable plastic
21. old In order to comply with Health amp Safety regulations and to ensure that Invacare employees are not exposed to the risk of infection we must insist that all products returned for repair are thoroughly cleaned Any product sent to Invacare which appears to be contaminated will be rejected and disposed of immediately at the customer s expense 10 2 Limited Warranty North America o PLEASE NOTE THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4 1975 This warranty is extended only to the original purchaser user of our products This warranty gives you specific legal rights and you may also have other legal rights which vary from state to state Invacare warrants the products manufactured to be free from defects in materials and workmanship for a period of one year from the date of purchase If within such warranty period any such product shall be proven to be defective such product shall be repaired or replaced at Invacare s option This warranty does not include any labor or shipping charges incurred in replacement part installation or repair of any such product Invacare s sole obligation and your exclusive remedy under this warranty shall be limited to such repair and or replacement For warranty service please contact the dealer from whom you purchased your Invacare product In the event you do not receive satisfactory warranty service please write directly to Invacare
22. re that the battery is not being discharged during long term storage more than six months Reset the emergency stop by pressing the RESET button on the bottom of the hoist Refer to Resetting the emergency stop page 17 12 1183377 A Operation 4 Operation 4 1 Indicator lamps and audio signals Indicator Audio Possible I Transia Functions signals Emergency Lowering Fault on hoist Yellow Beeps at button activation Battery critical Yellow low Over load Green Beeps at button activation 4 2 Operating the Hoist The I Transia is switched on automatically when button on the hand control is pressed o The I Transia will switch off automatically after approximately 8 minutes of non operation Press the UP button 9 on the hand control to lift the patient 2 Press the DOWN button to lower the patient There must be a load on the lifting strap corresponding to the weight of the hanger I bar before I Transia s lowering function will operate 1183377 A 13 l Transia 4 3 Charging the Battery The 1 battery charges when the hand control is placed in the charging station 10 The indicator lamp on the bottom of the hoist turns yellow if the charge status becomes low Finish the current lift in progress and charge the batteries when finished The hoist is charged when the indicator lamp on the bottom of the hoist is green Always leave t
23. ring function is used to lower the patient if the hoist stops working Pull and hold the red strap to lower the patient 2 Release the red strap to stop lowering the patient The emergency stop feature is activated when the strap is released 3 If the hoist system needs service contact your Invacare dealer for service 4 Reset the emergency stop to resume using the hoist Refer to Resetting the emergency stop page 17 l6 1183377 A Operation Resetting the emergency stop The yellow reset button pops out when the red strap B has been pulled The hoist will not function until the emergency stop is reset Press the yellow button on the bottom of the hoist to reset the emergency stop or lowering feature 2 Activate the hand control twice to resume use of the hoist 1183377 A 17 l Transia 5 Lifting the Patient 5 1 Sling Information WARNING PN Invacare shall not be liable for damage or injury that may occur as a result of using slings made by other manufacturers Invacare shall not be liable for damage or injury due to incorrect use of the sling or inadequate attention by the caregiver or user Use the sling that is recommended by the individual s healthcare team for the comfort and safety of the individual that is being lifted If there is any doubt about the selection or use of a sling please contact your Invacare dealer A sling with four to s
24. tions 6 1183377 A Safety WARNING The electronics may only be serviced by certified service technicians For safety reasons the side cover may only be dismantled when the emergency stop is activated This product is mechanically protected against derailing and jamming The hand control is protected against water splashes IPX4 DO NOT immerse the hand control in liquids even for a short time Avoid any contact with water or other liquids Pinch Points and Positioning WARNING A Risk of Injury Pinch points are present on the strap carabiner and fingers could be pinched The hanger bar can move suddenly and cause injury ALWAYS keep hands and fingers clear of moving parts to avoid injury When positioning the hoist be aware of the position of the hanger bar and the patient Injury could occur 1183377 A 7 Transia 2 3 Load Limits Read the label which indicates the maximum load limits for each component The component e g hanger bar lifting sling etc labelled with the lowest load limit determines the maximum load limit for the entire system This maximum load limit must not be exceeded Please note that the max load may change when different components are used such as hanger bars lifting slings etc 2 4 Power Supply 1 is equipped with a battery that requires regular recharging The power supply for the transformer and the charging station must be connected by
25. ut your product For specific safety information refer to the appropriate section of the manual and procedures within that section General WARNING A Risk of Falling DO NOT attempt any transfer without the consent of the patient s healthcare providers Read this user manual and observe other personnel lifting patients Then practice lifting under supervision with a capable person acting as a patient Use common sense in all lifts Special care MUST BE taken with people with disabilities who cannot cooperate while being lifted Check that the sling attachments are secure on the hanger bar each time the sling is removed and replaced to ensure that the sling is properly attached before the patient is removed from a stationary object WARNING AN Read the instructions carefully before using the I Transia and in connection with cleaning and service of the hoist The I Transia s maximum load must never be exceeded The I Transia may only be used to lift or move a person The red strap for the emergency stop and the emergency lowering must be adjusted to the caregiver s reach and must not be removed If the I Transia fails while in use stop using the hoist transfer the patient using a different method and contact an Invacare dealer for repair by a certified technician The I Transia is controlled by a microprocessor PCB which can be damaged by static electricity if touched without the necessary precau
Download Pdf Manuals
Related Search