ST-3xxx Analog Input Module
Contents
1. abs s gt Field Power OVdc Contacts amp See Rui SS gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 0 3 Input Channel 1 4 Analog Ground 5 Analog Ground 6 Shield 7 Shield Type B temperature C OT 300 C 900 C 1800 C Data Hex H 0000 H OBB8 H 2328 H 4650 Thermocouple Input Range Tvpe Maximum Input Range Recommended Input Range Type K 270 1372 100 1200 J 210 1200 100 1100 C Type T 270 400 C 200 350 C Type B 30 1820 C 500 1700 Type R 50 1768 0 1600 C Type S 50 1768 0 1600 C Type E 270 1000 200 800 C Type N 270 1300 200 1250 C Type L 200 900 100 850 C U 200 600 100 550 C 0 2310 100 2100 D 0 2490 C 100 2200 F 1 8 C 32 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 29 FnIO S Series 3 1 20 ST 3804 L erm exe ses B p System Power 5V b System Power GND Fn Bus Contacts FnBus Signal Thermocouple TC Ch 0 Pin 1 Sensor TC Ch 0 Pin 2 1 I 1 5 PT100 Sensor 19 External PT100 PT100 Sensor 20 tou Field Power gt Bypass to next module Contacts mund gt Not used for this module g2. 1count PT50 0 00385 200 850 C 2000 8500 0 1 C or0 1 F count PT100 0 00385 200 850 C 2000 8500 0 1 C or 0 1 F count PT200 0 00385 200 850 C 2000 8500 01 or 0 1 F PT500 0 00385 200 850 C 2000 8300 0 1 C or0 1 F count PT 1000 0 00385 200 350 2000 3500 or0 1 F count JPT100 0 003916 200 640 C 2000 6400 0 1 or0 1 F count JPT200 0 003916 200 640 C 2000 6400 0 1 C or0 1 F count JPT500 0 003916 200 640 C 2000 6400 0 1 C or 0 1 F count JPT1000 0 003916 200 350 C 2000 3500 0 1 or 0 1 F count NI100 0 00618 60 250 C 600 2500 0 1 C or0 1 F count NI120 0 00672 80 250 C 800 2500 0 1C or0 1 F count NI200 0 00618 60 250 C 600 2500 0 1 C or 0 1 F count N1500 0 00616 60 250 C 2200 0 1 C or 0 1 F NI1000 0 00618 60 180 C 600 1800 dC or0 1 F count CU10 0 00427 200 260 C 2000 2600 0 1 C or0 1 F count Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 26 FnIO S Series 3 1 17 ST 3704 System Power 5V 5374 gt C gt je Svstem Power GND Fn Bus L 0 Contacts NES q FnBus Signal 3 wire RTD RTD Ch 0 Pin 1 Sensor RTD Ch 0 Pin 2 1 AGND Pin 9 or 10 Device Field Power Bypass to next module Contacts gt Not used for this module Pin No Description Pin No Description 1 RTD Ch 0 2 RTD Ch 0 3 RTD Ch 1 4 RTD Ch 1 5
3. 318 617 3708 REE EEE EEE 49 EE EEE REE EEE 50 EEE REE EEE EEE EE 51 Gr EEE REE EEE 52 4 DIMENSION 53 4 1 ST 3xx2 ST 3xx4 5 7 53 4 2 ST 3704 ST 3708 ST 3804 5 3808 54 4 3 571 3274 ST 3474 aded iiaii 55 5 Mapping Data into the image 56 5 1 TS 56 5 2 i EEE EE EN 56 5 3 ERE EEE EE EE NE 57 5 4 51 227 551 3414 sia bd Gd enim Daodd spen 58 6 Trouble Shooting T 59 6 1 Normal Module C 59 6 2 ST 3704 ST 3708 ST 3804 5 3808 60 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 6 FnIO S Series l Important Notes Solid state equipment has operational characteristics differing from those of electromechanical equipment Safety Guidelines for the Application Installation and Maintenance of Solid State Controls describes some important differences between solid state equipment and hard wired electromechanical devices Because of this difference and also because of the wide variety of uses for solid state equipment all persons responsible for applying this equipment must satisfy themselves that each intended
4. CREVIS 48 FnlO S Series 3 3 17 ST 3704 Items Specification Input Specification Number of Inputs 4 Channels Indicators 1 Green Red Status 4 Green States Sensor Types RTD Input PT 100 PT200 PT500 PT1000 PT50 JPT100 JPT200 JPT500 JPT1000 JPT50 NI100 NI200 NI500 1000 NI120 NI1000LG Resistance Input 100mQ bit 10mQ bit 20mQ bit 50mO bit Excitation Current About ImA Conversion Method 3 Wire or 2 Wire Conversion Time 30msec 1 Channel when Normal Conversion Data Format 16bits singed Integer 2 s compliment Resolution of Data 30 1 C F 10mQ Module Accuracy 0 1 Full Scale 925 0 3 Full Scale 0 C 60 C Calibration Not Required Diagnostic Sensor Open or Range Over then Conversion Data 0x8000 32768 Except Resistance Input Mode Common Type 4 Common Module General Specification Power Dissipation Max 100mA 5 0Vdc Isolation I O to Control Logic Photocoupler Isolation Field power Not used Field Power by pass to next expansion module Wiring Connector Type up to AWG22 Module Connector HIF3BA 20D 2 54DSA Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 49 FnlO S Series 3 3 18 ST 3708 Items Specification
5. Input Specification Number of Inputs 8 Channels Indicators Green Red LED Module Status 8Green LED Input State Sensor Types RTD Input PT 100 PT200 PT500 PT1000 PT50 JPT100 JPT200 JPT500 JPT1000 JPT50 NI100 NI200 NI500 1000 NI120 NI1000LG Resistance Input 100mQ bit 10mQ bit 20mQ bit 50mO bit Excitation Current About ImA Conversion Method 3 Wire or 2 Wire Conversion Time 30msec 1 Channel when Normal Conversion Data Format 16bits singed Integer 2 s compliment Resolution of Data 30 1 C F 10mQ Module Accuracy 0 1 Full Scale 925 0 3 Full Scale 0 C 60 C Calibration Not Required Diagnostic Sensor Open or Range Over then Conversion Data 0x8000 32768 Except Resistance Input Mode Common Type 4 Common Module General Specification Power Dissipation Max 110mA 5 0Vdc Isolation I O to Control Logic Photocoupler Isolation Field power Not used Field Power by pass to next expansion module Wiring Connector Type up to AWG22 Module Connector HIF3BA 20D 2 54DSA Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 50 FnlO S Series 3 3 19 ST 3802 Items Specification Input Specification Number of Inputs 2 Channels Sin
6. Not Connected Wiring I O Cable Max 2 0 m Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 47 FnlO S Series 3 3 16 ST 3702 Items Specification Input Specification Number of Inputs 2 Channels Single Ended Non isolated Between Channels Indicators 2 Green Red States 1 Green Red FnBus State Sensor Types PT50 PT100 PT200 PT500 PT1000 JPT100 JPT200 JPT500 JPT1000 NI100 NI200 NI500 NI1000 NI120 CU10 Resistance 100mQ Bit Resistance 10mQ Bit Resistance 20m0 Bit Conversion Time 200msec All Channel Data Format 16bits Integer 2 s compliment Dissolution ability 0 1C 10mQ Module Error 0 1 Full Scale 25 C X 0 396 Full Scale 0 C 60 C Calibration Not Required Diagnostic Channel Open if it is not Connected Data 0x8000 Common Type 2 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 70mA 9 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr
7. Pin No Description Pin No Description 1 TC Ch 0 2 TC Ch 0 3 TC 4 TC Ch 1 5 TC Ch 2 6 TC Ch 2 7 TC Ch 3 8 TC Chf3 9 AGND 10 AGND 11 2 13 4 15 6 17 8 19 External PT100 20 External PT100 Type B temperature C 0c 300 C 900 C 1800 C Data Hex H 0000 H 8 H 2328 H 4650 LED External PT100 Sensor status for Cold Junction Compensation E Status LED is To indicate Normal Operation Off External PT100 Sensor Not Found Normal Operation Green External PT100 Sensor Found Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 30 FnlO S Series 3 1 21 ST 3808 ST 3808 System Power 5V Ec ul P System Power GND Fn Bus Contacts NN FnBus Signal Thermocouple TC Ch 0 Pin 1 9387597 TC Ch 0 Pin 2 IP PT100 Sensor Pin 19 External PT100 P1100 Sensor Pin 20 Sensor Field Power me Bypass to next module Contacts sm gt Not used for this module Pin No Description Pin No Description 1 TC Ch 0 2 TC Ch 0 3 TC Ch 1 4 TC Ch 1 5 TC Ch 2 6 TC Ch 2 7 TC Ch 3 8 TC Ch 3 9 AGND 10 AGND 11 TC Ch 4 2 TC 4 13 TC Ch 5 4 TC 5 15 TC Ch 6 6 TC 6 17 TC Ch277 8 ChZ7 19 External PT100 20 External PT100 Type B temperature C OT 300 C 900 C 1800 C Data Hex H 0000 8 H 2328 H 4650 LED External PT100 Sensor status for Cold Junction Compe
8. 4 FnBus Signal Current 4 20mA Pin No Device Ti 1 1 1 1 I I I i Common i I hiel Shield Field Power 4144 Field Power OVdc gt Contacts mr G PR EP gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield 7 Chassis Ground Shield Current 3 0mA 4 0mA 5 0mA 10 0mA 20 0mA Data Hex H 8000 H 0000 H 00FF H 05FF H OFFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 13 FnIO S Series 3 1 5 ST 3218 Mos System Power 5V fas masqa cames System Power GND Fn Bus S Contacts 4 4 FnBus Signal Current 4 20mA Input Pin No Device Field P men ieldPowr er UC gd gh iz gt l Field Power OVdc Contacts G 5 gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel 4 5 Input Channel 5 6 Input Channel 6 7 Input Channel 7 Current 3 0mA 4 0mA 12 0mA 20 0mA Data Hex H 8000 H 0000 H 07FF H 0FFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 14 3 1 6 ST 3234 ST 3234 FnIO S Series dou ouem System Power 5V 1 System Power GND Fn Bu
9. Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 4 FnIO S Series 2115 REE EEE 23 3 116 STIL ayasa haqa saa diode dq RED un Sus hasan hua huu ps 24 1 17 _ ST 3Z04 26 CX NT E vig ccc ta 27 FSS BOL kai 28 cA MEI Dor aka 29 3 1 221 0 REE 30 3 2 Environment Specification esee 30 3 3 Specification EE 32 3 3 1 5 2116 n 32 3 3 2 C 33 3 3 3 ST 3134 EEE EEE 34 3 3 4 SEE a REE GR 35 3 3 5 SEE H 36 3 3 6 SEE EET T qasaqa 37 3 3 7 51 3274 q m 9 38 3 3 8 ko Cen PN 39 3 3 9 ST 3428 P 40 3 3 10 STA REE 41 33 11 ST 3474 c e 42 3 12 51 3524 T 43 8518 c 44 3 3 14 ST 3624 T 45 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 5 FnIO S Series 3 3 15 SEI c M 46 33 16 47 3 3 17 61 3704 T EEE 48
10. 1 10 ST 3444 u aum mis 344lC Eee System Power 5V W System Power GND um L status Fn Bus um Contacts 99 FnBus Signal Voltage 0 10V Device Common Shield Shield lt Field Power sele ondes ues ds x gt Field Power OVdc Contacts A PE gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield 7 Chassis Ground Shield Voltage ov 2V 5V 10V Data Hex H 0000 H 0CCC H IFFF H 3FFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 19 3 1 11 Fn Bus Contacts Field Power Contacts ST 3474 57 3474 B P1 Connector Upper Connector FnIO S Series i System Power 5V 1 System Power GND FnBus Signal Voltage 0 10V Input AGND is internally connected to Field Power OV AGND Common Field Power OV Field Power 24V P2 Connector Lower Connector Pin No Description Pin No Description 1 Input Channel 0 1 Input Channel 2 2 Field Power OV AGND Common 2 Field Power OV AGND Common 3 Input Channel 1 3 Input Channel 3 4 Field Power OV AGND Common 4 Field Power OV AGND Common Voltage ov 2 5V 5V 10V Data Hex H 0000 H 03FF H 07FF OFFF Co
11. Types Thermocouple Input Type KJ T B R S E N L U C D mV Input 10uV bit lu V bit 2uV bit Cold Junction Temperature 20 70 C Cold Junction Compensation Method External PT100 Sensor recommended or Internal Temperature Sensor Auto Detection if External PT100 high priority is Connected Conversion Time 30msec 1 Channel when Normal Conversion Data Format 16bits Integer 2 s compliment Resolution of Data 40 1 C F 10mQ Module Accuracv 0 1 Full Scale 025 K J mV 0 3 Full Scale 0 60 C K J mV 0 5 Full Scale 925 C The others X 1 096 Full Scale 0 C 60 The others Calibration Not Required Diagnostic Sensor Open or Range Over then Conversion Data 0x8000 32768 Common Type 1 Common 1 Input General Specification System Power Dissipation Max 140mA Q 5 0Vdc Isolation I O to Control Logic Photocoupler Isolation Field Power Not used Field Power by pass to next expansion module Wiring Connector Type up to AWG22 Module Connector HIF3BA 20D 2 54DSA Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 For more Accuracy strongly recommend to use Extern PT100 Sensor for Cold Junction Compensation If External PT100 Sensor is found ST 3804 3808 uses PT100 Temperature as Cold Junction Compensation Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www
12. www crevis co kr C R E V l S 16 FnIO S Series 3 1 8 ST 3424 dcin sz ome System Power 5V gt BOUE ds gu u b System Power GND IM status Fn Bus Contacts FnBus Signal Voltage 0 10V Device Common Shield Shield J esjool Field Power 7 i e Field Power OVdc Contacts N e poen m Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield 7 Chassis Ground Shield Voltage ov 2 5V 5V 10V Data Hex H 0000 03FF H 07FF H Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 17 FnIO S Series 3 1 9 ST 3428 mira 11 d System Power 5V m rn aa b System Power GND IM Fn Bus Contacts FnBus Signal Voltage 0 10V Input OV Common Field Power Field P OVdc 5 gt Field Power c Contacts Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel 4 5 Input Channel 5 6 Input Channel 6 7 Input Channel 7 Voltage ov 2 5V 5V 10V Data Hex H 0000 03FF H 07FF H Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 18 FnIO S Series 3
13. 3 1 ST 3114 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 12Bits 4 88uA Bit Input current Range 0 20mA Data Format 16bits Integer 2 s compliment Module Error X 0 196 Full Scale 925 C X 0 396 Full Scale 0 60 C Input Impedance 12002 Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 165mA 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 33 3 3 2 ST 3118 FnIO S Series Items Specification Input Specification Number of Inputs 8 Channels Single Ended Indicators 1 Green Red FnBus State Resolution in Ranges 12Bits 4 88uA Bit Input current Range 0 20mA Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedanc
14. 599 URL www crevis co kr CREVIS 44 3 3 13 ST 3544 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 14Bits 1 2mV Bit Input current Range 10 10Vdc Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 500KQ Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 200mA 6 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 m Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 45 3 3 14 ST 3624 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 12Bits 1 22mV Bit Input current Range 0 5Vdc Data Format 16bits Integer 2 s compliment Module Erro
15. 7 Chassis Ground Shield Voltage ov 2V 4V 5V Data Hex H 0000 H 1999 H 3332 H 3FFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr C R E V S 24 3 1 16 ST 3702 ST 3702 G Fn Bus Contacts ee 08 18 Analog GND Shield Pin No 16e6 2003 Ig AGROD Shield i Field Power S Contacts N B LN Pin No Description 0 Input Channel 0 A Input Channel 0 B Analog Ground Shield e AID Resistance 100mQ 00 5000 FnIO S Series System Power 5V annor System Power GND FnBus Signal Device Field Power OVdc gt Field Power 24Vdc Description Input Channel 1_A Input Channel 1_B Analog Ground Shield 10000 15000 20000 Data Hex H 0000 H 1388 Sensor PT100 200 C 100 C OT H 2710 3A98 H 4E20 200 C 400 C 600 C 850 C Data Hex H F830 H FC18 H 0000 Sensor JPT100 200 100 OT 0700 H H 1770 H 2134 200 C 400 C 640 C Data Hex H F830 HFC18 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr H 0000 0700 H OFAO H 1900 CREVIS 25 FnlO S Series Sensor Type Data Sensor Type Degree Counts Resolution Resistance 100mQ 1 20000 10 20000 100mQ Icount Resistance 10mQ 1 3270 10 3270 10mQ Icount Resistance 20mQ 1 6200 10 6200 20mQ
16. BitNo Bit7 Bit6 Bit5 Bit4 Bit3 Bi Bitl 0 8 byte Byte 0 Ch 0 Conversion Data Low byte Byte 1 Ch 0 Conversion Data High byte Byte 2 Ch 1 Conversion Data Low byte Byte 3 Ch 1 Conversion Data High byte Byte 4 Ch 2 Conversion Data Low byte Byte 5 Ch 2 Conversion Data High byte Byte 6 Ch 3 Conversion Data Low byte Byte 7 Ch 3 Conversion Data High byte Configuration Parameter Data 4byte Byte Bit7 Bit6 Bit5 Bit4 Bit3 Bit2 Bitl BitO Ch 3 Fault Action Ch 2 Fault Action Ch 1 Fault Action Ch 0 Fault Action Fault Action 00b Fault Value All Channels use the same fault value 0 015 Hold Last Value 10b Low Limit 11b High Limit 1 Reserved 2 Ch 0 3 Fault Value Low Ch 0 3 Fault Value High Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 59 6 Trouble Shooting ATTENTION 6 1 Normal Module LED Status EXPANSION MODULE STATUS LED Off Green Flashing Green Flashing Red Red CHANNEL STATUS LED Off Green FnIO S Series In this manual it couldn t be described all variety case with Network Adapter of several protocols So if you couldn t find any fault after investigating all below cases refer to NA user manual Cause Action Device has no expansion Module or may not be powered Not Power Noddaalized The Parameter is not initialized yet Fn Bus Connection FnBus normal Operation Fn Bus Ready FnBus ready Fn Bus Fault FnBu
17. RTD Ch 2 6 RTD Ch 2 7 RTD Ch 3 8 RTD Ch 3 9 AGND 10 AGND 11 12 13 14 15 16 17 18 19 AGND 20 AGND PT100 Sensor PT100 200 C 100 C OT 200 C 400 C 600 C 850 C Data Hex H F830 H FC18 H 0000 0700 H 1770 H 2134 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 27 FnIO S Series 3 1 18 ST 3708 System Power 5V 57 378 gt a Se gt System Power GND Fn Bus Contacts FnBus Signal 3 wire RTD RTD Ch 0 Pin 1 Sensor RTD Ch 0 Pin 2 1 AGND Pin 9 or 10 Device Field Power Bypass to next module Contacts gt Not used for this module Pin No Description Pin No Description 1 RTD Ch 0 2 RTD Ch 0 3 RTD Ch 1 4 RTD Ch 1 5 RTD Ch 2 6 RTD Ch 2 7 RTD Ch 3 8 RTD Ch 3 9 AGND 10 AGND 11 RTD Ch 4 2 RTD Ch 4 13 RTD Ch 5 4 RTD Ch 5 15 RTD Ch 6 6 RTD Chtt6 17 RTD Ch 7 8 RTD Ch 7 19 AGND 20 AGND PT100 Sensor PT100 200 C 100 C OT 200 C 400 C 600 C 850 C Data Hex H F830 H FC18 H 0000 H 0700 HOFAO H 1770 H 2134 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 28 FnlO S Series 3 1 19 ST 3802 caes System Power 5V cete e G ax System Power GND Fn Bus Contacts 4 2 FnBus Signal Pin No nkhiw e ee 20 a ee 4e AGROD 6 oe 67 g Shield 49 G Field Power a gt
18. ST 3544 ST 3644 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS FnIO S Series Table of Contents 1 Important NES u a 6 1 1 Safety Instruction 7 1 1 1 cuui Aj aysa 7 1 1 2 Safety c me kawa aya 7 1 1 3 Certification u n aisi ics pu qe quits Kip Deni eui ta or un CDU GN but Rn eli peg retta Dn inde 7 2 ANALOG INPUT MODULE 8 3 uu uu naq haah n 9 3 1 The Interface and data 2 2 2 2 22222 2 3001944 4082 00000000 9 3 1 1 v ia 9 3 1 2 SEE c S 10 3 1 3 O HER 11 3 1 4 prar c H E 12 3 1 5 51 3218 c He 13 3 1 6 SEPT PHH E 14 3 17 STI 9274 u r ES 15 3 1 8 SEE Toc P 16 3 1 9 51 3426 I A 17 SU OT n 18 3 111 E r0 pc I 19 3 112 ST 3524 Pc iatiluskada tikaqa ay 20 3 L13 ST 3 544 M 21 I i i i 22
19. Specification Input Specification Number of Inputs 8 Channels Single Ended Indicators 1 Green Red FnBus State Resolution in Ranges 12Bits 3 9uA Bit Input current Range 4 20mA Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 12002 Conversion Time Amsec All channel Calibration Not Required Diagnostic No Common Type Nothing in the module terminal Field Power is Common AGND General Specification Power Dissipation Max 80mA 5 0Vdc Isolation I O to Logic Photocoupler isolation I O to Logic Non Isolation Field Power Supply Voltage 24Vdc nominal Voltage Range 18 28 8Vdc Power Dissipation Max 40mA 24Vdc Wiring I O Cable Max 2 0 mm Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 37 3 3 6 ST 3234 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 14Bits 0 9uA Bit Input current Range 4 20mA Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 F
20. application of this equipment is acceptable In no event will CREVIS be responsible or liable for indirect or consequential damages resulting from the use or application of this equipment The examples and diagrams in this manual are included solely for illustrative purposes Because of the many variables and requirements associated with any particular installation CREVIS cannot assume responsibility or liability for actual use based on the examples and diagrams Warning Y Ifyou don t follow the directions it could cause a personal injury damage to the equipment or explosion Do not assemble the products and wire with power applied to the system Else it may cause an electric arc which can result into unexpected and potentially dangerous action by field devices Arching is explosion risk in hazardous locations Be sure that the area is non hazardous or remove system power appropriately before assembling or wiring the modules Do not touch any terminal blocks or IO modules when system is running Else it may cause the unit to an electric shock or malfunction Keepaway from the strange metallic materials not related to the unit and wiring works should be controlled by the electric expert engineer Else it may cause the unit to a fire electric shock or malfunction Y If you disobey the instructions there may be possibility of personal injury damage to equipment or explosion Please follow below Instructions C
21. compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 500KQ Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 170mA 9 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 42 FnlO S Series 3 3 11 ST 3474 Items Specification Input Specification Number of Inputs 4 Channels Single Ended Indicators Green Red FnBus State Resolution in Ranges 12Bits 2 44mV Bit Input current Range 0 10Vdc Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 500KQ Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type Nothing in the module terminal Field Power 0V is Common AGND General Specification Power Dissipation Max 80mA 0 5 0Vdc TBD Isolation I O to Logic Photocoupler isolation Field power Not Isolation Field P
22. crevis co kr CREVIS 53 FnIO S Series 4 Dimension 4 1 ST 3xx2 ST 3xx4 ST 3xx8 J I 1 60 i Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 54 FnIO S Series 4 2 ST 3704 ST 3708 ST 3804 ST 3808 70 I1 1 000 i A b L 5 L5 99 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 55 FnIO S Series 4 3 ST 3274 ST 3474 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 56 FnIO S Series 5 Mapping Data into the image Table 5 1 ST 3xx2 Input Module Date Analog Input Ch 0 Analog Input Ch 1 Input Image Value Bit No Bit7 Bit6 Bit5 Bit4 Bit3 Bit2 Bitl 0 Byte 0 Analog Input Ch 0 Low byte Byte 1 Analog Input Ch 0 High byte Byte 2 Analog Input Ch 1 Low byte Byte 3 Analog Input Ch 1 High byte 5 2 ST 3xx4 Input Module Date Analog Input Ch 0 Analog Input Ch I Analog Input Ch 2 Analog Input Ch 3 Input Image Value Bit No Bit7 Bit6 Bit5 Bit4 Bit3 Bit2 Bitl BitO Byte 0 Analog Input Ch 0 Low byte Byte 1 Analog Input Ch 0 High byte Byte 2 Analog In
23. ction if External PT100 high priority is Connected Conversion Time 30msec 1 Channel when Normal Conversion Data Format 16bits Integer 2 s compliment Resolution of Data 40 1 C F 10mQ Module Accuracv 0 1 Full Scale 025 K J mV 0 3 Full Scale 0 60 C K J mV 0 5 Full Scale 925 C The others X 1 096 Full Scale 0 C 60 The others Calibration Not Required Diagnostic Sensor Open or Range Over then Conversion Data 0x8000 32768 Common Type 1 Common 1 Input General Specification System Power Dissipation Max 120mA 5 0Vdc Isolation I O to Control Logic Photocoupler Isolation Field Power Not used Field Power by pass to next expansion module Wiring Connector Type up to AWG22 Module Connector HIF3BA 20D 2 54DSA Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 For more Accuracy strongly recommend to use Extern PT100 Sensor for Cold Junction Compensation If External PT100 Sensor is found ST 3804 3808 uses PT100 Temperature as Cold Junction Compensation Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 52 FnIO S Series 3 3 21 ST 3808 Items Specification Input Specification Number of Inputs 8 Channels Indicators 1 Green Red LED Module Status 8 Green LED Input State 1 Green LED E Cold Junction Sensor
24. e 12002 Conversion Time Amsec All channel Calibration Not Required Diagnostic No Common Type Nothing in the module terminal Field Power is Common AGND General Specification Power Dissipation Max 80mA 5 0Vdc Isolation I O to Logic Photocoupler isolation I O to Logic Non Isolation Field Power Supply Voltage 24Vdc nominal Voltage Range 18 28 8Vdc Power Dissipation Max 40mA 24Vdc Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 34 3 3 3 ST 3134 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 14Bits 1 22uA Bit Input current Range 0 20mA Data Format 16bits Integer 2 s compliment Module Error X 0 196 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 12002 Conversion Time Amsec All channel Calibration Not Required Diagnostic No Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 165mA 9 5 0Vdc Isolation I O to Logic Photoco
25. ex H E000 H F000 H 0000 H H IFFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 22 FnlO S Series 3 1 14 ST 3624 don nsu nun System Power 5V System Power Fn Bus Contacts FnBus Signal Voltage 0 5V Pin No Device 1 I LI I I I I i Common i Shield sg SE Field Power ome sveis mum am m gt Field Power OVdc Contacts D mandas diodes Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield 7 Chassis Ground Shield Voltage ov 2V 4V 5V Data Hex H 0000 H 0666 H 0CCC H OFFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 23 FnIO S Series 3 1 15 ST 3644 mi 57 3644 o E 3 h nrnm System Power 5V Lg EE RE OE P System Power GND Fn Bus F Contacts d _ FnBus Signal Voltage 0 5V Pin No 36 Device 0 1 2 3 4 5 Common Shield Field Power uius musca wow ama x gt Field Power OVdc Contacts Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield
26. ge 24Vdc nominal Voltage Range 20 26Vdc Power Dissipation Max 20mA 24Vdc TBD Wiring 3M Mini Clamp Socket 4pin 37204 62A3 004PL Matching Connector 3M Mini Clamp Plug 37104 Series AWG 20 22 available Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 39 3 3 8 ST 3424 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 12Bits 2 44mV Bit Input current Range 0 10Vdc Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 500KQ Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 165mA Q 5 0Vdc Isolation to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL w
27. gle Ended Non isolated Between Channels Indicators 2 Green Red States 1 Green Red FnBus State Sensor Types Type K J T B R S E N L U C D mV Input10uV Bit 1uV Bit 2uV Bit Conversion Time 200msec All Channel Data Format 16bits Integer 2 s compliment Dissolution ability 0 1C 10mQ Module Error 0 1 Full Scale 625 C X 0 396 Full Scale 0 60 C Calibration Not Required Diagnostic Channel Open if it is not Connected Data 0x8000 Common Type 2 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 70mA 9 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Connection 2 or 3 Wire Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 51 FnlO S Series 3 3 20 ST 3804 Items Specification Input Specification Number of Inputs 4 Channels Indicators 1 Green Red LED Module Status 4 Green LED Input State 1 Green LED E Cold Junction Sensor Types Thermocouple Input Type KJ T B R S E N L U C D mV Input 10uV bit 1uV bit 2uV bit Cold Junction Temperature 20 70 C Cold Junction Compensation Method External PT100 Sensor recommended or Internal Temperature Sensor Auto Dete
28. heck the rated voltage and terminal array before wiring Avoid the circumstances over 55 of temperature Avoid placing it directly in the sunlight Avoid the place under circumstances over 8590 of humidity Do not place Modules near by the inflammable material Else it may cause a fire Do not permit any vibration approaching it directly Go through module specification carefully ensure inputs output connections are made with the specifications Use standard cables for wiring Use Product under pollution degree 2 environment Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 7 FnIO S Series 1 1 Safetv Instruction 1 1 1 Symbols DANGER Identifies information about practices or circumstances that can cause an explosion in a hazardous environment which may lead to personal injury or death property damage or economic loss Identifies information that is critical for successful application and understanding of the product ATTENTION Identifies information about practices or circumstances that can lead to personal Injury property damage or economic loss Attentions help you to identity a hazard avoid a hazard and recognize the consequences 1 1 2 Safety Notes DANGER 1 1 3 Certification The modules are equipped with electronic components that may be destroyed by electrostatic discharge When handling the modules ensure that the environment persons workplace and packing is well g
29. i FnIO S Series Analog Input Module ST 3xxx User Manual n m lt stus lt stus H pu s pesi sess pes se ree ial i FE 6666 z 14 2003 2063 2001 2994 2003 1093 2004 2003 ES m e 66 66 14 1 ee 1005 1605 1005 1005 sees 4005 1005 40651 amp 8 2 NESSE ENE 166166 see sl EE EE EG EG i o a ee 5907 6087 6007 6007 6007 60077 JE I LL Ll 3 jetjetetiet Et ee 66666 oe ow AM Version 1 07 2013 CREVIS Co Ltd Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr C R V S DOCUMENT CHANGE SUMMARY FnIO S Series REV PAGE REMARKS DATE EDITOR 1 0 New Document 2011 10 07 JE KANG 101 6 Add your experience 2012 1 13 JE KANG Changed ST 3804 ST 3808 Module input wiring diagram 1 02 Add the Certificate RoHS 2012 3 21 JE KANG 1 03 Deleted ST 3704 ST 3804 Type B 2012 6 8 JE KANG Add ST 3704 ST 3804 PT100 104 55 Add the Dimension 2013 2 22 KANG 1 05 ST 3804 ST 3808 module 2013 5 2 JE KANG Add the External PT100 Sensor 1 06 Environment Spec 50 C 55 C UL Temp 2013 7 3 JE KANG 1 07 Changed Power Dissipation ST 3118 ST 3428 2013 7 17 JE KANG ST 3218 ST 3474
30. nels Voltage 0 5Vdc 14bit 41 43 25 Active ST 3702 2 Channels RTD Status 41 41 28 Active ST 3704 4 Channels RTD Status 41 43 64 Active ST 3708 8 Channels RTD Status 41 47 65 Active ST 3802 2 Channels TC 41 41 2A Active ST 3804 4 Channels TC 41 43 66 Active ST 3808 8 Channels TC 41 47 67 Active Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 9 FnIO S Series 3 Specification 3 1 The Interface and data 3 1 1 ST 3114 d ena tare mes d System Power 5V 1 System Power GND Fn Bus Contacts FnBus Signal Current 0 20mA 0 1 Device Common Shield A leoalloaH si sus Field Power agis mos ds wm 2 Field Power OVdc Contacts pi gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield 7 Chassis Ground Shield Current 0 0mA 5 0mA 10 0mA 20 0mA Data Hex H 0000 H 03FF H 07FF HOFFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 10 3 1 2 ST 3118 Fn Bus Contacts r aa STATUS lonis 57 3118 D n FnIO S Series d om System Power 5V 1 System Power GND FnBus Signal C
31. nsation E Status LED is To indicate Normal Operation Off External PT100 Sensor Not Found Normal Operation Green External PT100 Sensor Found Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 31 FnIO S Series 3 2 Environment Specification Environmental Specifications Operating Temperature Non Operating Temperature Relative Humiditv 20 to 55 C Discrete I O 0to 55 Analog I O 40 C to 85 C 590 9090 non condensing Operating Altitude 2000m Mounting DIN rail General Specifications Shock Operating 10g Shock Non Operating 30g Vibration Shock resistance Displacement 0 012Inch p p from 10 57Hz Acceleration 2G s from 57 500Hz Sweep Rate 1 octave Per Minute Axes to test X y Z Frequency Sweeps Per Axis 10 EMC resistance burst ESD Confirms to EN 61000 6 2 EMI Confirms to EN 61000 6 4 Installation Pos Protect Class Variable IP20 Product Certification UL cUL CE Network Conformance NA 9111 ODVA Conformance Test Completion NA 9122 PTO Conformance Test Completion NA 9131 CLPA Conformance Test Completion Isolation DC Module Included Analog Module Terminal Block to 500Vac 1min AC Module Terminal Block to 1500Vac 1 min Relay Module Terminal Block to F G 2500Vac 1min Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 32 3 3 Specification 3
32. ower Supply Voltage 24Vdc nominal Voltage Range 20 26Vdc Power Dissipation Max 20mA 24Vdc TBD Wiring 3M Mini Clamp Socket 4pin 37204 62A3 004PL Matching Connector 3M Mini Clamp Plug 37104 Series AWG 20 22 available Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 43 3 3 12 ST 3524 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 12Bits 4 8mV Bit Input current Range 10 10 Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 500KQ Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 170mA 9 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4
33. put Ch 1 Low byte Byte 3 Analog Input Ch 1 High byte Byte 4 Analog Input Ch 2 Low byte Byte 5 Analog Input Ch 2 High byte Byte 6 Analog Input Ch 3 Low byte Byte 7 Analog Input Ch 3 High byte Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 57 FnIO S Series 5 3 ST 3xx8 Input Module Data Analog Input Ch 0 16byte Input Data Analog Input Ch 1 Analog Input Ch 2 Analog Input Ch 3 Analog Input Ch 4 Analog Input Ch 5 Analog Input Ch 6 Analog Input Ch 7 Input Image Value Bit No Bit7 Bit6 Bit5 Bit4 Bit3 Bit2 Bitl 0 Byte 0 Analog Input Ch 0 Low byte Byte 1 Analog Input Ch 0 High byte Byte 2 Analog Input Ch 1 Low byte Byte 3 Analog Input Ch 1 High byte Byte 4 Analog Input Ch 2 Low byte Byte 5 Analog Input Ch 2 High byte Byte 6 Analog Input Ch 3 Low byte Byte 7 Analog Input Ch 3 High byte Byte 8 Analog Input Ch4 Low byte Byte 9 Analog Input Ch4 High byte Byte 10 Analog Input Ch5 Low byte Byte 11 Analog Input Ch5 High byte Byte 12 Analog Input Ch6 Low byte Byte 13 Analog Input Ch6 High byte Byte 14 Analog Input Ch7 Low byte Byte 15 Analog Input Ch7 High byte Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 58 5 4 ST 3274 ST 3474 FnIO S Series IO Input Image Data
34. pyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 20 3 1 12 ST 3524 187 3524 aq starus Fn Bus Contacts 0 1 2 3 FnIO S Series Susan System Power 5 1 System Power GND FnBus Signal Voltage 10V 10V Device eo Common Shield ieG icgH Field Power Field Power 0Vdc Contacts ml gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0 V 6 Chassis Ground Shield 7 Chassis Ground Shield Voltage 10V 5V ov 5V 10V Data Hex H F800 H FC00 H 0000 03FF 07FF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 21 3 1 13 ST 3544 Fn Bus Contacts Common FnIO S Series System Power 5V UNO Oc NONO P System Power GND FnBus Signal Voltage 10 10V Device Shield Shield jjoejiebg Field Power Field Power OVdc Contacts MEaNEMESB gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield 7 Chassis Ground Shield Voltage 10V 5V ov 5V 10V Data H
35. r 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 500KQ Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 170mA 9 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 46 3 3 15 ST 3644 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 14Bits 0 3mV Bit Input current Range 0 5Vdc Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 500KQ Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 200mA 6 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power
36. rounded Avoid touching conductive components e g FnBUS Pin c UL us UL Listed Industrial Control Equipment certified for U S and Canada See UL File E235505 DNV CERTIFICATE No A 10666 CE Certificate EN 61000 6 2 Industrial Immunity EN 61000 6 4 Industrial Emissions RoHS EU CHINA Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 2 ANALOG INPUT MODULE LIST FnIO S Series ST Number Description ID hex Production Status ST 3114 4 Channels Current 0 20mA 12bit 41 43 1C Active ST 3118 8 Channels Current 0 20mA 12bit 41 47 82 Active ST 3134 4 Channels Current 0 20mA 14bit 41 43 1E Active ST 3214 4 Channels Current 4 20mA 12bit 41 43 1 Active ST 3218 8 Channels Current 4 20mA 12bit 41 47 83 Active ST 3234 4 Channels Current 4 20mA 14bit 41 43 IF Active ST 3274 4 Channels Current 4 20mA 12bit Sensor Connector 41 43 A3 Active ST 3424 4 Channels Voltage 0 10Vdc 12bit 41 43 20 Active ST 3428 8 Channels Voltage 0 10Vdc 12bit 41 47 22 Active ST 3444 4 Channels Voltage 0 10Vdc 14bit 41 43 22 Active ST 3474 4 Channels Voltage 0 10Vdc 12bit Sensor Connector 41 43 AO Active ST 3524 4 Channels Voltage 10Vdc 10Vdc 12bit 41 43 21 Active ST 3544 4 Channels Voltage 10Vdc 10Vdc 14bit 41 43 23 Active ST 3624 4 Channels Voltage 0 5Vdc 12bit 41 43 24 Active ST 3644 4 Chan
37. s Contacts FnBus Signal Current 4 20mA Pin No Device 1 1 1 I 1 I 1 Common 1 Shield LETE jin Field Power nus wp Sint tuus tes gt Field Power OVdc Contacts i ur gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield 7 Chassis Ground Shield Current 3 0mA 4 0mA 5 0mA 10 0 20 0mA Data Hex H 8000 H 0000 H 03FF H 17FF H 3FFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 15 3 1 7 ST 3274 mi ST 3274 e sms Fn Bus Contacts Field Power Contacts PI Connector Upper Connector Pin No Description 1 Input Channel 0 2 Field Power OV AGND Common 3 Input Channel 1 4 Field Power OV AGND Common Current 3 0mA 4 0mA FnIO S Series A System Power 5V Moe a ee System Power GND FnBus Signal Current 4 20mA Input AGND is internally connected to Field Power OV AGND Common Field Power OV Field Power 24V P2 Connector Lower Connector Pin No Description 1 Input Channel 2 2 Field Power 0V AGND Common 3 Input Channel 3 4 Field Power 0V AGND Common 12 0mA 20 0mA 20 4mA lt Data Hex H 8000 H 0000 Copyright C CREVIS Co Ltd Support 82 31 899 4599 07FF H OFFF H 7FFF URL
38. s Time Out FnBus Failed Communication Device Fault Device fault Not Signal Normal Operation On Signal Normal Operation Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 60 FnIO S Series 6 2 ST 3704 ST 3708 ST 3804 ST 3808 LED Status Cause Action EXPANSION MODULE STATUS LED Not Power Not powered Off No Initialized Not Initialized yet Green Module Connection Normal Operation IO Exchange Flashing Green Module Ready Module ready Flashing Red Module Fault Module failed in Communication Red Module Fault Module fault CHANNEL STATUS LED Off Input Sensor Open or Input Range Normal Operation Over Green Normal Operation Sensor Connected and Input Range Valid Red Channel Fault Channel Open Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS
39. ull Scale 0 C 60 C Input Impedance 1200 Conversion Time 4msec All channel Calibration Not Required Diagnostic Channel Open if lt 3mA Data 0x8000 Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 165mA 9 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 38 3 3 7 ST 3274 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Indicators 1 Green Red FnBus State Resolution in Ranges 12Bits 3 9uA Bit Input current Range 4 20mA Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 60 C Input Impedance 12002 Conversion Time Amsec All channel Calibration Not Required Diagnostic No Common Type Nothing in the module terminal Field Power is Common AGND General Specification Power Dissipation Max 40mA 0 5 0Vdc TBD Isolation I O to Logic Photocoupler isolation Field power Not Isolation Field Power Supply Volta
40. upler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 35 3 3 4 ST 3214 FnIO S Series Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 12Bits 3 9uA Bit Input current Range 4 20mA Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 1200 Conversion Time 4msec All channel Calibration Not Required Diagnostic Channel Open if lt 3mA Data 0x8000 Common Type 4 Channels 2COM Single Common General Specification Power Supply From System Power DC DC Power Dissipation Max 165mA 9 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Not Connected Wiring I O Cable Max 2 0 Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 36 3 3 5 ST 3218 FnIO S Series Items
41. urrent 0 20mA Input Device Field Power a gi acs MES SG SS Field Power OVdc Contacts Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel 4 5 Input Channel 5 6 Input Channel 6 7 Input Channel 7 Current 0 0mA 5 0mA 10 0mA 20 0mA Data Hex H 0000 H 03FF H 07FF H Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 11 FnIO S Series 3 1 3 ST 3134 4 ses nue sen System Power 5V Hb oum oum System Power GND Fn Bus Contacts il FnBus Signal Current O 20mA Pin No Device T I I I I I 1 1 i 1 Shield 2 Field Power TE tala nre cies ee gt Field Power Contacts gt Field Power 24Vdc Pin No Description Pin No Description 0 Input Channel 0 1 Input Channel 1 2 Input Channel 2 3 Input Channel 3 4 Input Channel Common 0V 5 Input Channel Common 0V 6 Chassis Ground Shield 7 Chassis Ground Shield Current 0 0mA 5 0mA 10 0mA 20 0mA Data Hex H 0000 H H IFFF H 3FFF Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 12 3 1 4 ST 3214 FnIO S Series Mos System Power 5V fas masqa cames System Power GND Fn Bus 4 Contacts d q 7
42. ww crevis co kr CREVIS 40 3 3 9 ST 3428 FnIO S Series Items Specification Input Specification Number of Inputs 8 Channels Single Ended Indicators 1 Green Red FnBus State Resolution in Ranges 12Bits 2 44mV Bit Input current Range 0 10Vdc Data Format 16bits Integer 2 s compliment Module Error 0 1 Full Scale 925 C X 0 396 Full Scale 0 C 60 C Input Impedance 500KQ Conversion Time 4msec All channel Calibration Not Required Diagnostic No Common Type Nothing in the module terminal Field Power 0V is Common AGND General Specification Power Dissipation Max 80mA 5 0Vdc Isolation I O to Logic Photocoupler isolation Field power Non Isolation Field Power Supply Voltage 24Vdc nominal Voltage Range 18 28 8Vdc Power Dissipation Max 40mA 24Vdc Wiring I O Cable Max 2 0 mm Weight 70g Module Size 12mm x 99mm x 70mm Environment Condition Refer to Environment Specification page 35 Copyright C CREVIS Co Ltd Support 82 31 899 4599 URL www crevis co kr CREVIS 41 FnlO S Series 3 3 10 ST 3444 Items Specification Input Specification Number of Inputs 4 Channels Single Ended Non isolated Between Channels Indicators 4 Green Red States 1 Green Red FnBus State Resolution in Ranges 14Bits 0 6mV Bit Input current Range 0 10Vdc Data Format 16bits Integer 2 s
Download Pdf Manuals
Related Search