MOSCOW User Manual
Contents
1. BEBE PERE Od VAJ MOLVM 18 WECHILLIT COM Integral Multi Deck Cases MOSCOW S amp MOSCOW M amp MOSCOW L 1 4 5 The Seller will have no liability to the Buyer for damage in transit shortage of delivery of loss of Goods unless the Buyer gives written notice to the Seller of such damage shortage of loss with reasonable particulars thereof within three days of receipt of the Goods or in the case of total loss of receipt of the invoice or other notifications of despatch The Seller s liability if any will be limited to replacing or in its discretion repairing such Goods and it shall be a condition precedent to any such liability that the Buyer will if so requested provide authority for the Seller s employees or agents to inspect any damaged Goods within fourteen days of such request The Seller will not be liable for any damage to or loss of Goods occurring after risk in the Goods has passed to the Buyer Furthermore the Seller will have no liability for any consequential loss arising out of any damage in transit shortage of delivery or loss of the Goods Subject to clause 2 3 the Seller warrants that 2 1 the goods shall be free from defect in materials and workmanship for a period of 12 months from the date of delivery to the Buyer 2 2 it will perform the Services with reasonable care and skill and in accordance with the terms of the Contr2. Replaceheater earth on heater Replace heater If conditions cannot be Check heater element amp No fault found Check if ambient controlled then contact klixons for electrical fault conditions are above Capital Cooling for further Condensate 259C 60 RH guidance tray owerflows No continuity or short to earth Replace klixon s Note klixon opens at 60 C closes at 56 9 Check Condenser fans are earth on motor reversing when compressor n Condensate heater operate Check klixons are not Klixons still closed Replace klixons continuously closed above 60 Case not Case operates at correct OK operating at temperature correct temperature Adjust controller Case not operating at correct If air off temperature is too i e Air off set point temperature amp compressor high check refrigeration temperature runs continuously system and air flow iced cut out 2 1 C up evaporator cut in 0 1 C Compressor cycles but case Check probe amp or temperature too high change controller 16 WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Service and maintenance Lights Description As a standard MOSCOW amp MOSCOW amp MOSCOW L cases feature a single row T8 fluorescent tube located in the canopy of case A starter is located adjacent to the tube s To replace the tube Ensure that the case is switched off and if possible i disconnected from
3. WECHILLIT COM MODEL 2080 208C Moscow L iw warhe AHT MOSCOW 510 55 SERIAL NUMBER amp 100010010012030201 TOLTAGE AM PERS FUSE RATING FUSE LIGHTING ELECTRICITY POWER CLIHATIZATION RANGE CAPACITY COMPRESSOR CONTROLLER F Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Technical specifications 7 10 13S 13M amp L 15 20 1850 Depth 634 for 724 for 814 for L Display area Model s m2 094 ias 195 195 234 275 _ Display area Model M m BIAIS Temperature range C 2 C to 4 Refrigerant R404A Refrigerant charge S g 1200 1200 1200 1400 1800 Refrigerant charge M amp L g 1200 1800 1800 1500 1900 Defrost cycle 4 defrosts x 45 minutes each per 24 hours period Voltage V 230 Frequency Hz 2 22 ous w ss ss uo no 165 ozs 052 052 ose 165 nes so s xo uo 5 96 7 9 1 10 7 Evaporator Fans W A W A Compressors Condensate heater W A Maximum power W 1863 2166 2636 3020 A oss 115 1372 Data specified in the above table is based on the following parameters EN 441 Class 259 ambient temperature 60 relative humidity 0 2 m s
4. PARAMETERS Temperature Differential Probe Offset Set Point Maximum Set Point Minimum Compressor Rest Time I LL Time between Defrosts dit ALARM PARAMETERS High Temperature Alarm ZB X WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Setting parameters on the PJEZC easy The easy electronic controllers comprise a three digit LED display SET UP DOWN buttons which allow parameters to be set or reprogrammed To set or check temperature Ensure that the case is switched on and lights fans and compressor are running Press SET button to display SET on LED Press SET button again and set point value of 22 should be displayed on LED To change the set point use the DOWN buttons within 5 seconds New parameter has been set To set minimum temperature limit parameter Ensure that the case is switched on and lights fans and compressor are running Press SET button for a count of more than 5 seconds until P5 is displayed on LED Press SET button again O appears on the screen Use UP or DOWN buttons until 22 displayed on the LED Press SET button and see dO Change the value with UP or DOWN buttons Press SET again and see 0 on the LED Press set button once New parameter has been set To set maximum temperature limit parameter same applies for the maximum temperature But unlike
5. Press SET button and see di Change the value with UP or DOWN buttons Press SET again and see 1 the LED Press set button once New parameter has been set Display 22 16 BLA T 7 ED E is m SE DE 7 start up MEANS OF THE SYMBOLLS Co gits with ces ial point aod range 1t2 to Goo tee tors 4 UI Fic t a pere bxc cis p slay wales irt 10 WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Setting parameters on the PJEZC easy Keypad wi th 2 4 activae deactivates the continuous cycle 1 amp displays sets the set for 1 sRESET pressed point current EZY together 2 more than 3 5 accesses set and 3 activate the parameter setting menu parameter enter password 22 reset mutes the audible alarm procedure buzzer more than 3 5 activates pressed together for 1 s displays deactivates the defrost with activates firmware deactivates version Once the electrical connections have been completed simply power up the controller to make it operative CAREL then recommends to check that the display does rot show any alarm signals then set the time and date and finally set the parameter as desired The main parameters are as follows Control parameters st set poirt Set point diferential tonly easy split select type of probe Defrost par
6. Air flow 600 lux fluorescent lighting ZB _ WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Transport amp Delivery Transport Cases should always be transported in the upright position Cases should be handled with care Avoid dropping or jolting the case which may cause damage Unpacking Protective packaging should be removed carefully If using knives or sharp implements avoid damaging glass or paintwork Check case for damage and if neccessary report damage to the carrier and supplier Your case will be supplied assembled with shelves held in place by plastic transit clips Check for any deficiencies and advise shortages to your supplier Remove plastic clips ties with a sharp knife or scissors and avoid damaging pa ntwork while doing so Ce WECHILLIT COM Remove plastic shelf clips ties with a knife or scissors if any Remove metal shelf transit clips with pliersif any Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Location of your display case Siting Cases should be located on a flat and even surface Feet may be adjusted as required to ensure that the ed y ANN case is level If there is castors please lock the brake as F pM pr E Eb Ns in the picture Bre UO Do not expose the case to direct sunlight or other sources of heat Avoid incandescent lighting x MU o a MEN 6 Adjust
7. Integral Multi Deck Cases MOSCOW S amp MOSCOW amp MOSCOW L zs Installation Operation amp Maintenance Manual WECHILLIT COM AHT zz green freshness worldwide Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Introduction and index Page Contents 3 Cross Sectional Profile 4 Technical Specifications 5 Transport and delivery 6 Location of your display case 7 Installation 8 Operation 9 Control panel 10 Setting parameters on the PJEZ easy electronic controller 11 Setting parameters on the PJEZ easy electronic controller 12 Controller error and alarm messages 13 Cleaning 14 Cleaning 15 Housekeeping routines 16 Service and maintenance 17 Service and maintenance Electrical wiring diagramme for models MOSCOW S amp MOSCOW M 18 amp MOSCOWL 19 Troubleshooting 20 Warranties and liability 21 Warranties and liability 22 Declaration of Conformity N WECHILLIT COM 2 Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Cross sectional profile All dimensions in mm 2080 534 724 Moscow 5 Moscow VOLTAGE 220 240 V ELECTRICITY POWER Nominal absorbed power LIGHTING Absorbed power by the lights FUSE Fuse type amp size in the electrical board CLIMATIZATION RANGE Class III REFRIGERATING CAPACITY Refrigerant charge at Class III REFRIGERANT FLUID R404A AMPERS Power drawn from the case CONTROLLER Digital model used in
8. able feet Avoid locations where the case may be knocked by cleaning machines and pallets Access Ensure that the case is easily accessible for loading and unloading Place the case in a prominent position within the store to maximise visibility of merchandise promoting impulse purchases Ventilation Maintain a minimum air gap of 100 mm from the back of the case to the store wall to allow air circulation Do not locate the case close to sources of draught such as doors open windows or air conditioning vents Never place boxes in a position which may obstruct or restrict the circulation of air to the condenser Never place somethings in a position Make sure air return grille was open which may restrict air flow Ce WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Installation Assembly Assembly installation and connection of the case should always be undertaken by appropriately qualified personnel Adjustable shelves should be located and locked into position in the desired shelving configuration To adjust the shelves lift brackets straight up firmly and remove the shelf Relocate the shelf as required and push brackets firmly into place It is recommended that two people undertake this procedure one on each shelf bracket Firmly lift up shelf bracket Epos ticket strips should be located on the front edge of the shelves Power Supply As standard the case is suppl
9. act The above warranty is given by the Seller subject to the following conditions 3 1 the Seller will be under no liability in respect of any defect in the Goods arising from any drawing design or specification supplied by the Buyer 3 2 the Seller will be under no liability in respect of any defect in the Goods arising from fair wear and tear accidental or wilful damage negligence of the Buyer or it s employees or agents abnormal working conditions or use of Goods outside their design parameters failure to follow the Seller s instructions whether oral or in writing or misuse 3 3 the Seller will be under no liability in respect of any defect in the Goods arising from a improper installation service or repair carried out by any one other than the Seller b any alteration to the Goods carried out by anyone other than the Seller or a service agent approved by the Seller or c the use of any spare part or component which has not been manufactured or supplied by the Seller 3 4 the above warranty does not extend to parts materials or equipment not manufactured by the Seller in respect of which the Buyer will only be entitled to the benefit of any such warranty or guarantee as is given by the manufacturer of such parts materials or equipment to the Seller The Buyer will notify the Seller as soon as reasonably practicable after becoming aware of any defect in the Goods or any deficiency in the Services and will provide authority for t
10. ameters type of defrost cil interval between two defrosts atr end detfrost temperature maximum defrost duration Alarm parameters Ado _ temperature alarm delay m A low temperature alarm threshold deviation high temperature alarm threshohd deviation A0 alarm and temperature diferential 11 WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Controller error and alarm messages A variety of error and alarm messages may be displayed on the LED of the electronic controller A legen is detailed below 0 Faulty probe 1 Thermostat Probe 1 Faulty probe 2 Evaporator Probe e2 Faulty probe 3 Condenser Probe High temperature alarm for cabinet LO Low temperature alarm for cabinet AH High temperature alarm Condenser Probe AL Low temperature alarm Condenser Probe Ed Defrosting timed out 7 External alarm dOr Door open alarm Optional Df Defrost activated Press any button to silence the alarm The LED will start to blink If simultaneous they will be showed on the display alternately every 2 seconds 12 WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Cleaning General A regular and thorough cleaning regime is essential for the efficient and hygienic operation of your display case Before undertaking any c
11. erchandising Allow the case to operate for at least two hours before loading merchandise fe z When loading cases do not exceed loading limits or Power button to turn on amp off the case allow product to overhang shelf front edges or obstruct Warning This will not isolate the case air return grilles A tidy well merchandised case will function more efficiently than a badly loaded one Ensure free air flow around the merchandise and between the air discharge and return ducts Always load chilled product Your display case is designed to maintain not reduce temperature If warm product is loaded within the case there may be a delay the case reaching its normal operating temperature A well merchandised case will function more efficiently WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Control Panel As standard the case is supplied with an carel easy or full functional electronic controller incorporating an LED thermometer which displays average case operating temperature The controller is factory pre set but parameters may be programmed as detailed below Reprogrammed parameters take immediate effect and will be saved in the event of loss of power to the controller PJEZC easy Parameter Definition Display on LED MOSCOW amp MOSCOW amp MOSCOW L Models SET POINT mes Temperature Set Point SEt OPERATING
12. he Seller s employees or agrees to inspect the Goods and or Services and if necessary to remove any Goods for further testing and analysis Where any valid claim is made by the Buyer that the Goods are defective or that the Services have not been performed with reasonable care and skill and in accordance with the terms on the contract then the Seller will in the case of the Goods at its discretion either repair or replace the Goods or the part in question free of charge and in the case of the Services will at its cost re perform the Services necessary to remedy the deficiency ZB X WECHILLIT COM 6 Subjectto the clause 10 the Seller will have no other or further liability to the Buyer and whether for breach of Contract negligence breach of statutory duty or otherwise in respect of any claims proceedings damages losses costs and expenses whether direct or consequential and including without limitation refrigerant loss food loss loss of business loss of profit and loss of good will made against or incurred by the Buyer arising from or in connection with any defect in the Goods or any failure by the Seller to perform the Services with reasonable skill and care and in accordance with the Contract 7 The Sellers liability for any direct loss or damage sustained by the Buyer as a result of any error in any weight dimension capacity performance or any other description or information which has formed a representation o
13. ied at 230V 50 Hz Please ensure that the local power supply is appropriate Check the rating for your case model by consulting the Epos ticket strips on the front table on page 4 of this manual and ensure that the edge of the shelf plug is correctly fused If the case is hard wired to the mains supply a means of isolation must be provided If a plug and socket supply is used the power point Should be accessible after the case is positioned The case should be earthed An equipotential earth bonding terminal is also supplied allowing the case to be bonded to a building surge earth or adjacent equipment Ce WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Operation Switching On amp Off Ensure that the mains power supply is connected and switched on Once the power is connected case will start running Please turn on the lights from the switch located behind the lower front panel next to the thermostat The case fans will operate as soon as the power is switched on Case temperature will begin to fall to its pre set The light switch is located next to value For the pre set temperature for your the thermostat specific model please refer to the table on page 4 Should you need to turn the case off please press the button located on the thermostat This will stop the compressor but will not isolate the case For isolation please remove the supply cable from the mains plug M
14. leaning operation ALWAYS turn the case off and if possible disconnect from the mains power supply Avoid splashing water onto the case s electrical elements If water splashing should occur make sure that all electrical components are thoroughly dry before reconnecting to the power supply Never use abrasive or caustic cleaning agents Exterior Internal surfaces shelves and air grilles Painted or metal surfaces should be cleaned with a cloth soaked in warm soapy water Surfaces should be dried with soft cloth Shelves should be removed for cleaning as above Glass and Mirror Glass and mirrored endwalls should be cleaned with a suitable glass cleaner Glass and mirrored surfaces may be buffed with a soft dry cloth Case Well Lift out deck trays and sweep or vacuum any debris from the case well The well may be wiped with a cloth and mild disinfectant 13 WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Cleaning Fan Deck Lift the fan plate allow cleaning around the fans sure that fans are not running Air Cooled Condenser and Coolinf Fins Carefully vacuumm dust and air borne debris from the Clean around the fans condenser unit and cooling fins Exercise care not to damage fins Lhe ak Beware of the sharp finds and take care when cleaning this area Vacuum dust debris from
15. ll and condensate tray Remove and clean spillages and debris Service Request In the event of malfunction or failure you should request a service engineer visit as soon as possible If in doubt turn off the case and disconnect from the mains supply Servicing of your case should only be undertaken by an approved Service Engineer Failure to comply may invalidate your warranty In the event of case failure remove perishables from the display case and store in an alternative suitably chilled location to avoid deterioration of merchandise ZB X WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW L Service and maintenance Symptom Test fFault Action Is digital display if fitted Check plug fuse illuminated Are lights amp or evaporator Check power supply is on Compressor fans running not running Switch off power amp disconnect runs from outlet Remove lead marked 3 from terminal rail NENNEN compressor in base amp insert terminal 2 Compressor does not run compressor relay or Switch on power compressor electrics Adjust controller set point Compressor cycles Cabinet not achieving set Compressor temp check refrigeration runs Remove temperature Compressor stops system amp site conditions continiously probe connections Probe dislodged from plastic mounting clip amp touching metal work Remove temperature probe o arthonnester
16. ny indirect special or consequential loss or damage including without limitatition refrigerant loss food loss loss of business or loss of profit and loss of good will surffered by the Buyer which arises out or in connection with the supply of the Goods or their use or resale by the Buyer or the performance of the Services even if such loss was reasonably foreseeable or the Seller had been advised of the possibility of the Buyer incurring the same a WECHILLIT COM 12 seller shall not be liable to the Buyer or to deem to be in breach of the Contract by reason of any delay in performing or any failure to perform any of the Seller s obligations in relation to the goods or the Services if the delay or failure was due to any cause beyond the Seller s reasonable control Without prejudice to the generality of the foregoing the following shall be regarded as causes beyond the Seller s reasonable control 12 1 Act of God explosion flood tempest fire or accident 12 2 war or threat of war sabotage insurrection civil disturbance or requisition 12 3 acts restrictions regulations bye laws prohibitions or measures of any kind on the part of any governmental parliamentary or local authority 12 4 import or export regulations or embargoes 12 5 strike lock outs or other industrial actions or trade disputes whether involving employees of the Seller or the third party 12 6 difficulties in obtaining raw materials lab
17. our fuel parts or machinery 12 7 power failure or breakdown in machinery 21 Integral Multi Deck Cases MOSCOW 5 amp MOSCOW amp MOSCOW L Declaration of Conformity EC Declaration of Conformity HEREWITH CERTIFY UNDER OUR RESPONSIBILITY THAT THE FOLLOWING HOUSEHOLD REFRIGERATORS amp FREEZERS MANUFACTURER EFE MARKET EKIPMANLARI SAN VE TIC A S MANUFACTURER S ADDRESS GEBZE PLASTIKCILER OSB ATATURK CAD NO 45 41400 GEBZE KOCAFLI DEVICE S Integral Multi Deck Cases MOSCOW S amp MOSCOW M amp MOSCOW L DESCRIPTION SIZES 625 937 1250 1500 1875 MANUFACTURED EFE A S ARE ACCORDING WITH THE EUROPEAN COMMUNITY DIRECTIVES 96 57 EC DIRECTIVE OF ENERGY EFFICIENCY HOUSEHOLD REFRIGERATORS amp FREEZERS 89 336 EEC DIRECTIVE OF ELECTROMAGNETIC COMPATIBILITY EMC 73 23 EEC DIRECTIVE OF LOW OLTAGE ELECTRICAL EQUIPMENT 98 37 EC DIRECTIVE OF MACHINERY EFE MARKET EKIPMANLARI SAN VE TIC A S CONFIRMS THAT NO OTHER APPLICATION HAS BEEN LODGED WITH ANOTHER NOTIFIED BODY FOR ZB X WECHILLIT COM
18. r is part of the Contract will not exceed the price of the Goods and or the Services in respect of which description or information is incorrect 8 Except for the terms applied in Section 1 2 of the Sale of Goods Act 1979 or Section 2 of the Supply of Goods and Services Act 1982 all conditions warranties and other terms express or implied statuary or otherwise are expressly excluded except in so far as they are contained in these Conditions otherwise expressly agreed by the Seller in writing 9 Subject clause 10 the Seller will not be liable to the Buyer in respect of any direct or consequential loss or damage suffered by the Buyer arising from the negligence of the Seller or wilful default of the Seller s employees or agents in connection with the supply of the Goods or the design or manufacture thereof or in the performance of the Services 10 The terms of clause 6 and 9 will not exclude any liability of the Seller 10 1 for the death or personal injury resulting from the negligence of the Seller or the negligence or wilful default of theSeller s employees or agents or 10 2 under the Consumer Protection Act 1 987 20 11 Except in respect of liability for death or personal injury resulting from negligence the Seller will not be liable to the Buyer under any circumstances and whether arising from breach of Contract or the negligence or breach of statutory duty of the Seller or its employees or agents or otherwise for a
19. the Condensate Tray condenser unit and cooling fins The self evaporating water tray which collects defrost water should be cleaned regularly Spilled milk and other dairy products collecting in the condensate tray may lead to odour and should be cleaned immediately Condensate tray should be cleaned Water Outlets Outlets for waste water should be cleaned regularly to ensure a continious flow of waste water Lights Lights may be cleaned with a soft dry cloth Make sure that lights turned off vow 5 am 4 4 454 Drain outlet should be cleaned Ce WECHILLIT COM Integral Multi Deck Cases MOSCOW amp MOSCOW amp MOSCOW 1 House keeping routines Close of business Cases should not be switched off at close of business or overnight If appropriate night blinds may be used for energy conservation of up to 30 during non trading hours Defrost Cycles Your display case is pre programmed with an automatic defrost cycle of 4 x 45 minutes defrosts in each 24 hour period unless programmed otherwise The first defrost will take place 4 hours after switching on the case Case Inspection Operating temperature as indicated on the controller mounted on the front of the case should be checked on a daily basis Cases should be monitored on a daily basis for any undue noise smell or malfunction Regularly inspect the case for milk spillage or debris in the air grilles case we
20. the mains supply id y P Extreme caution should be exercised in changing the The lighting tube is located in the tube as it may shatter case canopy Carefully remove the spent tube from its mounting points Insert a new appropriately rated T8 fluorescent tube ensuring that it is securely in place Restore mains power and switch on the case Dispose of the spent tube in a safe and environmentally responsible way To replace the tube starter Ensure that the case is switched off and if possible disconnected from the mains power supply The starter is located adjacent to Remove the spent starter from its mounting the tube Insert a new appropriately rated starter in the mounting point ensuring that it is securely in place Restore mains power and switch on the case WECHILLIT COM M vy Integral Multi Deck Cases MOSCOW S amp MOSCOW M amp MOSCOW L 1 FAC M XO H were DOO H fITIIN FAY O ien 09 ON LEG AIR DON mE TED Mee EE PUDE AWE HSER E da TIJN VHH g u d11310N VH O Rue WAOS 0NIS IVA 02509 pau ETAT IS POA PD PY ININIM POE QUE 20 0 OU PO BO E 0E TON SSH F L3 14 505 5 5 85 9 8 252
Download Pdf Manuals
Related Search