Betriebsanleitung Pickup
Contents
1. Park the car safely let the engine in idle running Pull up the parking brake open the front hood cover to see if the cooling fan working or not 1 If the fan doesn t work stop the engine at once and send the maintenance service 2 If the fan working properly without warm gas please open the rear case cove for the engine checking up keep the engine working idle until the engine cooled up 3 If the fan woks well but the engine temp is hot stop the engine and as the engine is cool check the liquid level of cooling system normal or not the circulating pipeline leaking or not in time repair and add antifreeze of the same type Notice Not be close as it is hot or open the cover of the water tank care the high temp freezer or vapor would hurt you If that happens like above please go to 11 the maintenance service to check up 2 Speed gauge and odometer The odometer here is anti reset the mileage reads at above the mile calculator below To calculate a distance press the red button below the odometer to reset the meter so as to get the driving coverage 3 Fuel gauge After igniting the meter shows the fuel storage level in the oil box As the meter shows the fuel about to exhausted you d better refuel the tank in spite of some oil still in the tank The fuel gauge is ok as the following happens m The practical fueling quantity reads on the meter sometimes a little more or less E Turning braking or speeding up2. fuse case s domination Detail seeing the master wiring harness chart Rear fuse box 24 Replace the fuse piece with the same specs never use wires or metal piece instead which will cause burning fire Contact the FULU service for finding the reason and remove the fault if the fuse frequently burns Notice 1 Carbon tank please check the carbon tank once there is fuel smell or lower power or easy flameout Notice Fuel filling should not be so full or so fast in case that fuel comes into the carbon tank which cause flame out and failing to start up 2 Catalytic converter The car should use unleaded petrol otherwise the catalytic converter maybe failed to work Wash the converter every 10 thousand kilometers 3 Oxygen Sensor Normally the voltage of two sides of the Oxygen sensor should be in 0 1V the middle number should be around 500mV otherwise the Oxygen sensor maybe already broken Chapter eight Maintenance Please follow the stipulated miles to do the maintenance at the appointed service center Maintenance item First maintenance Mileage Km 2000 3000 9000 18000 cooling system check antifreeze liquid level replace it necessary engine oil replacement 23 oil itor replacement 2 tf tt engine check leakage engine oil antifreeze liquid and fuel Timing belt check wear and tear its tension and relax conditions adjust and replace spark plug check and replacement if necessa
3. it wait a moment as you hear noisy ss lt which means some pressure remains inside 1 Press the cover while continually turning the cover open 2 Open the jug see the fig 3 Add cooling fluid into the radiator till it levels at its outlet and the lowering fluid level sustained Then cover the cooler properly 4 Add antifreeze liquid into the jug till the liquid level sustained at the regular standard and then cover the jug CS Wash or wipe away the cooling fluid on the engine or other parts 6 Start the engine keep it running till the pipe on the radiator feel warm 7 Check the fluid level to see if the level be lowered otherwise add more till the fluid levels standard then cover the jug 8 The cooling fluid s requirement E Stand an anti freeze down to 37 C E Boiling temperature Up to 129 C E Antirust and anti erosion Chapter six Tire 1 Flat tire Tire burst in driving seldom happens if tire properly maintains Tire flat 16 often occurs bit by bit As for a tire burst you d follow these instructions lf the front tire bursts you should release the accelerate pedal then Slightly brake holding on the steering wheel to keep the direction then stop the car out of the traveling lane If a rear tire bursts for instance on a crooked road as if it skid you should deal with in a anti skid way Anyhow as the rear tire shrunken release the accelerate pedal and slightly press the brake holdin
4. makes the reads undefined 12 Heating system As it is cold before starting the heating system you d better drive the car several miles and wait for the water warmed up since the heating system is designed as a water disseminating The adjustable warm air outlet with its button lies on above the cassette player optional 13 Radio and cassette player EA 2 1 2 34 J 7 8 9 10 1 Mode 2 Volume 3 tune 4 screen 5 power 6 wave 7 search 12 8 clock 9 SD 10 USB 14 Radio AM Most AM station sends a larger range than FM station especially at night however the larger range would brings out the signals disturb between Stations AM signals will collect noises from storm wires etc If there is noise you can tune down the volume to reduce it 15 Stereo Radio FM stereo radio FM can bring you the best voice however its sending range limits from 16 to 65 kilos and the obstacles of voice echo by high building and hills disturb the FM signals 16 Driving and road Drunken drive Alcohol would affect a driver in four necessary ways E judgment E muscle corresponding ability E sight E attention To avoid drunken drive is to drive without drink however that how much you drink means too much is only depends The alcoholic consistence in the body rest on four aspects E alcoholic volume drunk mM the drunk s weight E The food quantity before and after drinking E The time length of drinking Be
5. the two front seats The gearshift sketch is shown on top of the handle The operation steps as follow 1 As the handle in the middle vertically it s neutral which no power will be transferred to the rear wheel so the vehicle can t go forward 2 For Gears 2 1 push the handle leftward and then forward or backward For Gears 4 3 the handle posts vertically in the middle then forward or backward Leftward then forward the rear shifting The following list shows the gearshifts are relatively suitable to the speed OUCE Gear and matching The gear shifting should be in time of the suitable speed speed a km The gear shifting should be a gear after another no skip the grade 1 The backward shift should be in the time of the car 3 halt 4 5 Parking brake Up lift the braking handle to carry out parking brake for releasing parking braking firstly up lift the eer braking handle a little with the thumb pressing a red RLA button on top of the handle then release the handle completely Notice Parking indicator is on the panel Driving as the parking brake is on will make the arrester over heated amp cause damage before its due time or even damage other parts Warninc Its dangerous to leave the car if the brake doesn t function well The car may have self motion by outside factors as the time the engine is working the car can even move suddenly that will Cause injury To insure a car still
6. warning light See the fig Brake oil level indicator Brake pot Braking liquid must be leveled between top low scales Below the scale add more liquid of the same type Two reasons cause the lower scale of the breaking liquid one is arrester disc wearing out severely another is the liquid is leaking As driving the breaking warning flashes you should speed down park the car safely and check the braking oil s level and its pipe line then go to the FULU maintenance service engine and damage the engine and all damages by it are excluded in the maintenance guarantee from the company Notice All the fault braking fluids would bring damage to the parts of braking system e g a few drops of mineral oil enter braking system will seriously damage the parts of the system and the damaged parts should be replaced Don t add the fault fluid If the fluid spilling on the body of the vehicle may ruin its surface so wipe out the fluid at once 10 Battery Here uses the lead acid liquid plus battery as you need new battery which should be the same with the original one Warninc Electrolyte is low consistence Acid liquid in the battery Clean it if there spattered on the skin 11 Bulb replacement Warninc Here uses halogen bulb with high air pressure inside if it drops on the ground or lacerated the bulb will exploded so as to injure people Replace it carefully 1 Front light replacement 22 Open the
7. Notice Either more or less oil harm the car better have the maintenance in FULU sound service Warnino Quality of the engine oil is very important Please go to FULU service station in time to get maintenance with qualified oil Engine faulty by low quality engine oil is out of the maintenance service guarantee 5 Gear box oil check up and replacement Check up the Gearbox oil the time you examine the engine oil normally replace the Gearbox oil every 3000 kilo as following 1 Gear box check up remove oil examine hole bolt on the left of the gear box with wrench M12 Oil overflow means oils level is normal Otherwise there is shortage of oil In time add oil of the same type till there is oil overflow Fuel inlet bolt 2 Replace the gear box oil release the in out oil bolts set empty the gear box oil and then screw down the oll out bolt loose oil examine hole bolt add standard oil into the gear box with a little filler till oil overflow out of the hole and then tighten the in oil bolt and oil examine hole amp bolt Fuel outlet bolt Notice Either more or less oil will harm the gear mid load oil winter box GL 4 75W 90 20 mid load oil summer GL 4 85W 90 Better have the maintenance in FULU sound service out of the professional technician Warninc Quality of the gear box oil is very important Please go to FULU service station in time to get maintenance with qualified oil Gear box damage by
8. USER MANUAL DEZHOU FULU VEHICLE CO LTD Welcome to use Fulu brand regular three wheel vehicles made by Dezhou Fulu Vehicle Co Ltd Taking on the advantages of similar models home and abroad Fulu Vehicles has newly developed the regular three wheel vehicles innovated with the hydraulic disc braking system independent Suspensions assembly cable control gearshift amp parking and postpositional engine 1 Initiatory saloon car structure ideal for your comfortable drive 2 The bran new control system newly designed vehicle frame and chassis for convenient maintenance 3 Initiatory postpositional engine compacted structures generate more power 4 Fine figure and framework lowering the center of gravity enhance vehicle s stability For better comprehending the innovated regular three wheel vehicles on their structure performances maintenance as to make them function well and extend vehicles available working span Please read the manual carefully All the specifications amp narrations in this manual are only for reference any alterations afterward would not be additionally informed The staffs of Fulu Vehicle Co Ltd look forward to better ideas advice from you on shortcomings of our products during the use of our Fulu regular three wheel vehicles We appreciate all that Remind that for your happy family please drive safely amp decently by traffic rules no drunken drive over speed or overload We wish you hav
9. before left please check the parking brake functioning well Chapter four Functions and Operations 1 Horn Press horn in center of the steering wheel for whistle Turning signal multi purpose operating lever The handle to the left of the steering post can control fig a Turning signal and lane change signal eso l i 7 A y Oe N b Head light high low beam switch ee y Fa c Overtake flash signal 2 Turning amp lane switch signal There are two positions upward right turning and downward left turning which will send out the turning or lane changing signals Push the lever to the up end or down end for the turning signal after that the lever will automatically return to its original position As signalizing the turning or lane changing the indicator light flashes on 8 the panel as shown in the fig If light flashes faster than normal or no flashing maybe one of the signal lamps is faulty while other drivers can t see your turning signal Notice If the turning light is faulty please check up and get it repaired in time in case any accident occurs 3 Main beam headlamp dipped head lamp For change from dimmed light to main beam headlamp or the dimmed to the main beam turn the switch on the lever to the illumination position and then up or down push the lever On the main beam headlamp __ position the indication lights are shown as in fig 4 Overtaking signal light While headligh
10. cause there are also sex differences the alcohol hydrated rate of women body is lower than that of man and the alcohol absorbed by the water in the body shows that the alcohol consistence in blood of female is a little higher than that of man at the same conditions The body needs an hour to decompose the alcohol coffee and cold shower cannot accelerate the course I ll be careful is not the right answer In case of urgent circumstances you are required to act swiftly What would happens if a group of traveling or cyclists rash into the road since a person with blood alcohol consistence leveled at medium will not react quick enough to avoid the collision Many people know little about disadvantages of drunken drive The 13 medicine research reveals the alcohol existence in body would do more harm especially to brain backbone and heart in a collision which means there is more severe injured or possibility to death for drunken than normal diver Warninc Drunken drive is very dangerous even a little alcohol would affect your reaction sense attention and judgment Drunken drive will bring dreadful result Therefore drunken driver or rider should take a taxi home 17 Drive at night Driving at night is much more dangerous than driving in day because some drivers are affected by alcohol medicine dark sight deficiency or exhausted Here are notices for night driving E cautiously driving E no drunk driving E adjust the rearvi
11. e pleasant drive Enforced Standard QC T688 Contents Chapter one Main Technical SpecificationS cccecceeeeeeeeeeeeeeeees 5 Chapter two Seal and Seal Dell crccviuietanieivessivendownsidewsnavsataceazen 6 Chapter three New Vehicle break in amp Engine Start up 5 7 Chapter four Brief Functions and Operations cccec eee eeeeeeee ee 10 Chapter five Cooling SyStOM cccecce cece ee eeteeeeeeeeeteeeeeeeaeeenanenes 21 CMa el SIE TO ea a E 22 Chapter seven Maintenance amp Parts Replacement scceeeeeeee 25 Chapter eight Engine Maintenance ccccceeseeeeeeeeeeeeeees 36 Chapter nine Accessories amp Tool List cccc eee eeeeeeeeeeeeeeeenees 37 Chapter ten Electrical Wiring Diagram ccceceeceeeeeeeneeenaeeeaeeees 39 Chapter one Main Technical Specifications Model NO Max Speed Fuel Consumption Eco Speed Grade Abilit Turning Diameter min Braking deceleration Wheel track Wheelbase Ground clearance min Net weight Front wheel spec tire pressure Rear spec tire pressure Front wheel turning L R angle max Dimensions L W H mm Engine model Engine type Cylinder bore stroke Max power and revolution Max torque and revolution Idle speed revolution Displacement Compression ratio Fuel spec Fuel consumption min Start Lubrication Ignition mode Spark pluo Machine oll FL600ZH A 65Km h
12. e pressure 250kpa and rear tire pressure 450kpa Tire excessive charged easily shear tear burst as on the bump road So the air pressure should be kept in a recommended level The worn out and old tire will cause accident and should be replaced Notice 23 Excessive or deficiency air pressure are estimated great Deficiency will lead to severe distortion excessive hot tire overloaded severe worn out difficult to control high fuel consume Excessive will lead to Abnormal worn out Running bumping Unnecessary wears by road obstacles 14 Vehicle Identification Number VIN locates on the longitudinal beam of right rear chassis Seen in fig 15 Engine Identification No EIN locates at the middle of the engine body right on the cylinder exhaust vent See the fig 16 Label Production label is located on the longitudinal beam of right rear chassis 17 Safety system If some electric functions e g the headlight or _ _ amp horn P or radio fail first you should check the safety system There are two fuse boxes front and rear cases which locate under seat beside the driver below the penal and leftward in front of tail light Only unscrew bolts on the fuse box cover and then check the fuse piece to find out its fault Replace it if necessary See the fig The rear fuse case dominate the following functions start up the engine ECU power supply and whole car power supply Other functions for the front
13. ew mirror to minimize the dazzling from behind E because of dimness view you need decelerating and keeping a more distance from the car in front m decelerating drive E notice animals in front at remote area E no fatigue driving 18 Close doors and skylight to prevent rain water drilling in as driving in the rain Notice The adhesive strength of the tire is not efficient on the wet road therefore you should care your braking speeding or turning especially as the tire veins worn out and the adhesive strength is much less so drive cautiously in a rainy day Warninc A wet arrester may cause accident as an urgent brake will bring improper result as to let the car side slide and lost control Slightly press the brake till it works oroperl ouddle 19 Sloping and mountainous road It is different to drive on a steep or mountainous road and plain or highland If you often or going to drive in mountainous here are some safety driving notices Keep the car in good condition check up all the fluids levels and arrester tire cooling system and transmission which will have more working loads on mountainous road Knowing how to drive on the slop or lengthy slop road most important to decelerate and use a lower shift Warninc 1 If shift not to a lower shift the arrester will get very hot so as to work improperly So while driving downward shift to a lower gear in order that the engine helps braking 2 Downward driving w
14. front hood Release the pressing clip to the bulb shield and take it off Loosen the fasten clip to the bulb Take out the bulb from the lampshade and replace it by a bulb of the same type e Clip the bulb and install the sealing ring 2 Taillight replacement a Open the rear hood carefully and take off the inner plaque respectively b Remove the tailing baffle with a cross head screwdriver c Unscrew the lamp holder counter clockwise to make replacement Notice the location of the filament touch as replacing the braking bulb since its luminosity is lighter than traveling light although they are the same bulb Replace other bulbs in order 12 Replacement of the wiper blade element Check the wiper blade element at least twice a year to see if it wear and tear Here the steps a Halt the wiper as it moves to the farthest reach and then remove or replace it more easily b Withdraw the wiper off the windshield c Push upward the release clip at the joints of the wiper blade element and the wiper arm and then draw downward the blade elements the way to the glass to take them off d Reset the blade elements by pushing them in to the wiper arm till hearing kada 13 Tire Over loaded tires become excessive hot and then may explode causing an accident OOo Oo MW Deficiency air risk the same danger and can causing accident So it is recommended to check the tire air pressure regularly to keep the number as suggested front tir
15. g on the steering wheel and keep the direction however there may have some bumps and noise control the direction then stop the car out of the traveling lane to a smooth place 2 Replace the flat tire Drive to a smooth place to avoid further tire damage Turn on the warning flash light BAY The spare wheel locates under the rear hood ANN behind the rear seat Open the rear hood and take it out and then replace it Here are notices E As use the jack support it at a spot crossbeam of rear suspend As the fig front and rear wheels supporting spots It is forbidden to support on the chassis oil pipe and wire harness in case of any damage such as no brake and cutting out of wire harness Problems caused by this are not in warranty E Draw back the parking brake to keep the p car halted still as carrying out the po p replacement m Remove rusts and dust on bolts of the wheel hub and spare tire in case the rusts and dusts fail the tightness of the parts joints after a period of usage or even cause the tire break off and result in an accident Also remove rusts and dust on the fixing places E Never use oil or grease on the bolts or nuts in case it affects its tightness and even fall off Causing an accident E As replace the spare wheel ensure to make the round end of the nuts 17 facing the wheel tighten each nut till the wheel against the wheel hub properly Follow the order in the fig to screw down the nuts to a
16. gear box Cleanout the air cleaner and filter element 3 New car s over speed and overload are forbidden 2 Ignition key has 3 options S Lock up at this location the whole vehicle is power off the key can only insert and pull out at this location At this location all the lights equipments and electro circuits of the car are turning on Y at this location the engine s ignition system is Switched on Q at this location the car is started Remark Headlight interior light is not controlled by the key without which you can directly operate their functions 3 Engine start Check up the fuel level and set a gear at neutral N firstly before starting the engine 1 Pedal the clutch but not step down the accelerate pedal turn the ignition key to the third start position after the engine being started let slip the key idle running for five minutes and then drive on Notice The sustain for the key to start a car keeps no more than five seconds in case the battery over discharged and overheated that will cause the electric engine damage The interval of two ignitions is at least five ten seconds in case the battery over discharges to damage electric engine 2 Ifthe engine can t be started after 2 3 times turn the key at off position and waiting for one minute then start again 4 Gearshift The gearbox has 5 gearshifts four forwards D and one Per Sea operated by a single control handle that locates between
17. ith vacant gear or ignition system off is dangerous since the arrester loads all deceleration Then the arrester becomes very hot and loses its efficiency till causing accident possibly So drive downward with the engine working anda Safety notice Downward drive at a lower gearshift and upward drive also better with lower gearshift which helps the engine cooling down and increase the torques As drive upward or on a two lane mountainous road keep on the right lane without swaying or over the center line Notice the traffic signs on mountainous road and measures your driving Chapter five Cooling System 1 Cooling System The cooler locates under front hood open the cover and support it with the rod as the fig Normally the antifreeze liquid level set between the upper and lower liquid scales Warning Never start the engine where there is no cooling 15 liquid in case making the engine faulty which is not guaranteed Warning While driving don t open the water outlet or the jug Hot fluid in cooling system may puff out and hurt you the fluid tank s pressure is high even you slightly turning its cover the hot fluid would burst out so never act on the tank cover when it hot Deal with it as it cools down 2 Add cooling fluid in the radiator You can open the radiator cover only after the cooling system cooled down as in fig Turn the cover counter clockwise till its first pause Don t press the cover while opening
18. loor mat 21
19. low quality gear box oil is out of the maintenance service guarantee 6 Deal with the used machine oil There exist some materials harmful to skin in the oil which may result in cancer Don t leave the machine oil rest on the skin long Clean your skin and nails with water and soap or cleanser Cloth stained with machine oil should be cleaned or properly put away The used machine oil is very dangerous to the environment As self replace the machine oil never leave the oil randomly in trash bin on ground in drainage or river and Lake etc In fact you should send it to the machine oil recycling station 7 Cleaning the engine air cleaner Air cleaner lies in the tailor connecting with the throttle its body fixed on the vehicle s bodywork See the fig Clean the filter and the carburetor times according to the local environment to keep the working engine sound condition Steps in fig 1 Undo the fasten nuts from the top of the crust of the air cleaner 2 Take out the filter core to clean or replace 4 Clean it inner to outside by high pressure air blowing but not with water Replace it with the same type 3 Cover the filter properly replace the cover and fasten with nuts Warning Driving without air cleaner is forbidden in case dusts enter the 8 Arrester fig 1 Braking fluid Braking fluid pot locates under the front hood cover in which is a oil level sensor and indicated on the panel by an oil level
20. lt 12 SQRB2G06 In line two cylinder four stroke water cooling DOHC electrically controlled fuel oil multi soot sorayina API SJ SAE 5W 30 5W 40 10W 40 4 Left position gear rack Clutch Associated spring Transmission Manual Horizontal Constant meshing gear four gearshitts 21 AL Storage battery capacit 12V 45Ah catalytic converter ET86 90 ECU 0 109 072 103 Oxygen Sensor Disc heating zirconia Chapter two Usage of seat Seat Driver seat manual adjustable the handle at front left on the seat if adjust it to and fro the seat goes forward or backward lift up leftward the handle to unlock the seat and slide it to a favorable position and then loose the handle the locker automatically locking the seat You should move yourself on the seat to make sure the seat well locked Warning Dont try to hand adjust the diver seat as the vehicle is moving for that easily causes the vehicle lose control The seat s sudden move will disturb you to press the accelerate pedal So adjust the seat as the vehicle stopped Chapter three New Car s Break in and Engine Starts up 1 New car s break in Notice Your car needn t have an annoyed fitting period if you keep the following which will let your car function well in your expecting time 1 Within the first 2000 km drive not always dive at same speed high or low 2 After 2000km drive replace the machine oils in the engine box and the
21. ock the locking handles of the sky light window by pulling them straight down force up the window till it parallels with its supporters as the tilting window ventilates Pull up the locking handles to the window Notice Before leaving the vehicle close the sky light window to prevent some aliens inside 11 Panel information system tee tt Ot 8 9 10 11 12 1314 15 16 17 1 panel 2 steering wheel 3 horn switch 10 4 instrument assy 5 Windshield wiper 6 blower speed adjust switch 7 decorative cover 8 WH glove case 9 warm air outlet 10 switch turning switch lighting 11 radio 12 gt decorative switch 13 radiator cooling air 14 loudhailer 15 warm air switch 16 decorative switch 17 decorative switch Instrument comb Panel components can help to Show the ors sux sees one pun oom oxnsee owas driving conditions such as speed oil consumption or some information about safety or economic driving See the indicator lights and panel illuminate 1 water temperature gauge revolution meter oleft turning symbol area oreset button oright turning speedometer PAH fuel gauge 1 water temperature gauge This meter shows the cooling fluid temperature of the engine Generally at fixed degree the cooling system will work automatically The engine is in over heated condition as the hand of the meter extends into the red area As the engine temp is over heated stop the car and check up
22. proper moment The wrong nuts or nuts moment would make wheel loose even fall off so as to cause an accident Ensure using the right nuts or nuts moment 50 55Newton m Notice 1 For a new car a comparatively smaller spare tire is i 7 oT charged up however after some time air may lose Please check air pressure in time right 250kpa beside k E 0 the spare tire can only be applied to as an urgency that ae can t be used for lasting Ke 2 Never use a tire worn out at a certain limit Sign a in the fig is a limit of wearing Chapter seven Maintenance and parts replacement 15 Self maintenance Warning As knows little on car would do harm in car maintenance Before doing maintenance you should have enough experience and knowledge of the right parts and tools etc Be sure to use the right bolts nuts and other tightening parts The wrong tightening parts may cause broken or loosen so as to Cause injury Zs Fuel filling Warninc Fuel vapor an endangering flammability Smoking spark light flame or other tinder are forbidden around the fuel or as the time of adding fuel 3 Fueling inlet location The fueling inlet locates at left back of the vehicle 18 see the fig Open the outlet cover put the key into the fuel tank lock pressing the cover as you contra rotates the lock and the cover Warning Stained with fuel and flaming you will be injured Too swiftly opening the fuel tank cover fuel may
23. ry air cleaner clean the cover and the filter replacement if necessary wedge belt check up its tension and relax conditions adjust and replace bolts of the engine bottom shell check if not tight tighten up if necessary Battery check the indicator and voltage if working ok Test run make sure all functions go well maintenance mileage notice Take the first maintenance till the car running 2000km since buying Except for the first maintenance take maintenance by 3000km according to the 3000km items listing as at 5000 8000 11000 14000 17000 20000 23000 26000 29000 32000 eta Except for the first maintenance take maintenance by 9000km according to the 9000km items listing as at 11000 20000 29000 38000 47000 56000 65000 74000 83000 92000 etd Special Note Air filter should be check every 500km cleanout replacement beside first maintenance replace it every 3000km Valve clearance adjust adjust it every 10000km 30000km and 90000km 26 Chapter nine Accessories tools list 1 Driver s tools Driver s tools supplied with each car for daily maintenance 1 tool bag 2 8x 10 spanner8 x10 3 13x16 spanner13x16 4 18x21 spanner18x21 5 twin bolt spanner 6 bolt spanner handle 7 fishtail pliers 8 jack 9 wheel nut spanner 10 jack rocker 11 spark plug wrench 2 accessories 1 12V45Ah battery battery plate No 1 battery plate No 2 2 145 70R12 spare wheel assy 3 F
24. spill out especially in hot days Lightly turning the cover waiting the sound ss tt disappearing then open it up without oil spilling out Oil spilled on the lacquer body should be wiped off soon enough Then put on the cover turn it slowly rightward clockwise press it and rightward clockwise turn the key to lock the fuel tank Take out the key cover the outlet ensure the cover tightly shut up otherwise the fuel would vapor out into air Notice E To avoid injury extra oil tank is not allowed in the car Only fueling the stated fuel tank m At the moment of fueling and after fueling let the oil pump touch the inner side of the outlet E No smoking as fueling 4 Check the engine lubrication There is a warning light for the engine oil pressure 3 See the fig ts As the key turn to Gear2 it s normal that the engine oil is lightened before the engine is started After start or in it in again See the fig 2 Take it out again and examine its scales See the fig 3 If the oil level reads between top and low scales the circuitry of indicator light maybe faulty If oil level under the scales add oil to the standard level then check up if the engine has leakage please go to the maintenance Station for repairing reference for tyoe of machine oil oil tyoe identit C temp scales API SF SAE 0W 30 25 below 30 API SF SAE 5W 30 25 30 API SF SAE 10W 30 15 30 API SF SAE 10W 40 15 40
25. t turns off as up pushing the lever the main beam headlamp shines shortly signalizing an overtaken as free the lever the overtaking light turns off 5 Windshield wiper The windshield wiper has two gears for wiping You can move the wiper handle bar forth and back to adjust the working speed The wiper pushed backward to LO position an G for a stable low working speed HI forahigh sg glen working speed OFF for stopping it a Notice The damaged windscreen wiper obstructs line of sight against driving safety To avoid this damage you should ensure clearing up icy snow in advance On local weather condition if there is snow iced on the windshield that should be melt moved if the wiper flake is damaged replace it Thick snow ice will make the wiper overload and cause motor or fuse burned Clear up the snow ice in time 6 Windshield cleaner optional As cleaning the windshield pull out the wiper s control simultaneously upward to start the cleaner and the wiper Pull back the control the cleaner stops If frost temperature locally use the cleaner as the windshield gets warm in case the cleaning liquids gets iced on the windshield ruining the line of sight 7 Inner lamp E Inner lamp locates over the windshield Turn rightly for the door light and left for the inner light 8 Sun shield we Turn down the sun shield to stop glaring Sune 9 Sky light window Manipulation Unl
Download Pdf Manuals
Related Search