(MYT SC-9) Manual - Janitorial Supplies & Equipment
Contents
1. Vacuum motor armature is worn out Replace vacuum motor Ball loat is shut of Empty the vacuum tank of all waste water Water is coming out of the vacuum motor Use a low foaming detergent 10 tE f f p E sora cus pcia y ds amics Cu PEN a gree a DESCRIPTION PARTNUMBER Ja UV 11002 Vol Ben 76 1 solenoid valve 8197 Bruch shaft ee Bras mw Brush pulley ums Brush bushing Hers 12 o DESCRIPTION PART NUMBER White nylon washer opacos nas Wave washer spacer nar 13 NOTES2. mind These precautions MUST BE FOLLOWED at all times to avoid serious injury harm and or death and damage to the unit Warning To reduce the risk of fire electrical shock or injury 1 READ ALL INSTRUCTIONS BEFORE USING EXTRACTORS 2 Use only as described in this manual Use only manufacturers recommended attachments 3 Always unplug power cord ftom electrical outlet before attempting any adjustments or repairs 4 Do not unplug by pulling on card To unplug grasp the plug not the cord 5 Do not pull or carry by card Do not close a doar on cord or pull cord around sharp edges or comen 6 Do not run appliance over cord Keep cord away from heated surfaces 7 Do not use with damaged cord or plug If cord is damaged repair immediately 8 Do not use outdoors or on wet surfaces and or standing water 9 Always unplug or disconnect the appliance from the power supply before servicing Unplug or disconnect the appliance om power supply when not in use 10 Do not allow to be used as a toy Close attention is necessary when sed by or near children 11 Do not use in areas where flammable or combustible material may be present 12 Do not eave the unit exposed to harsh weather element Temperatures below freezing may damage components and vid warranty 13 Use only the appropriate handles to move and lift unit Do not use any her parts ofthis machine for this purpose 14 Keep hair loose clothing fingers and all parts of bod
3. MP circuit Wire from power cord has become disconnected from terminal block Reattach wire to terminal block Pump is not running properly Quick disconnects are not completely locked together Snap quick disconnects firmly together Jets on manifold are clogged Clean jet with soft wire brush or remove jet and flush clean Filters are clogged Remove filters and rinse with clean water The solution tank is empty Fill the solution tank up with a premixed detergent Pump wire has become disconnected Reconnect wire Pump motor brushes are wom Replace pump Pump is pulsating Tighten all hoses Check for leaks Pressure switch on pump head is bad Replace with new pressure switch SYMPTOM PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION Vacuum motor not working properly Switch on switch plate is bad Replace switch Drain valve is not shut completely Close drain valve completely Power switch on body is bad Replace switch Hose not connected tightly to accessory tool or machine Connect hose tightly Vacuum tank lid is not on tightly Secure the vacuum tank lid on tightly Vacuum tank lid or the vacuum tank is cracked Replace the vacuum tank lid or the vacuum tank Vacuum hose is cracked or split Replace vacuum hose
4. Tracker User s Guide Self Contained Carpet Cleaner Dear Customer Congratulations on the purchase of your new carpet cleaner As you are already aware the scene of the detailing world is becoming more high tech and we at Mytee Products Inc strive to keep you on the cutting edge with superior quality and technology Keep in mind that your carpet cleaner is a machine and neglect and abuse will cause unnecessary damage und void warranty With simple maintenance however your vacuum will give you quality performance for many years to come he labels on your unit are scratch resistant They are made with a clear film To achieve a high gloss finish simply peel off he thin clear layer IS warranty questions arise please consult your user s guide or get in touch with your distributor If you have questions about maintenance replacing parts or ordering parts please call an authorized Mytee Products Inc service center To see an updated list visit our website at www Mytee com Before you begin cleaning please read you user s guide thoroughly Sincerely Customer Care Dept IMPORTANT INFORMATION Model Serial Distributor name and phone Date of purchase Table of Contents General Safety Warranty RMA Model Description Advantages Set Up Maintenance Operation Troubleshooting Parts List Notes General Safety Warnings These precautions have been written for your safety and the safety of others in
5. en Tie waranty eaves he cs of replacement only and does So over shipping or labor costs PUMP VACUUM MOTOR AND HEATER 1 YEAR LIMITED WARRANTY Myce warts hat puma van tt nd beter wil be fee fen manufcheig det defects fa red und dels teria or ene 1 yen onthe date af cial purchase Ths ray does ot apply and is voi if the up vta motor crear as worn rsh motors ater damage chemical buku chemical damage or evidence of abuse neglect or tapeo This warranty covens the cos of placental and des nl sovet pig ot abo HOUSING 3 YEAR LIMITED WARRANTY Fer re 3 years cn the dae of purchase My wer a percentage the cs of replacement ut role bowing ped as follows Mc wil pay 100 of replacement cs in the st year fom We dat ol purchase 79 of replacement cst athe seeond yer Irom the date pace and 25 in id yes om the date of purchase Replacement at det not clade te coo shipping or abr LIMITATION OF DAMAGES THE REMEDY OF REPLACEMENT OR REPAIR OF ANY DEFECTIVE GOODS SHALL BE THE EXCLUSIVE REMEDY UNDER ANY WARRANTY MADE BY MYTEE WHETHER EXPRESS OR IMPLIED IN NO EVENT SHALL MYTEE BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES PROPERTY All ied ware are void for and Mytee dos not warrant any way any product that seen mapa improperios ae ck of tenance neg w we or Sr hama us alteran al ei se of ncmpalhe Coon cee ein a rel Service madot servicing italien of pr or repairs by anyone ran Myts o a Mee authorized iur ar serie cnt Mts
6. may make changes in products i minutes and 4 ht kn ane he changes ae mado without obligation to changa onu rd tay odie proto seld or malt Myts has mo obligation to bonor te limiled warns st forth berein alts be ral cs pump upon discovering te waranty am nd prior w comi o use the prot ntact Mts ra My ua dar ar ence center o describo the cl nd Reeve a fallow stc fr documenting and rich un he ai In an te purchase mat provide he roc fo wich he cin applies to M ts or a Mytee hard distributor or en ner for ung pen any provision or portion of his ml warranty policy is found o be unenforceable ten he win provisions an portions al rin val nd eneceable If amy poison ce portion ts amined waranty polacy i ound abe ie by fa thn al peso ot portem hal be nod male fee win the bods of lan Fr expe leo are egal mins the dran of ware wre mae he sal be tons 1o Bave De mama en rogue by lave ithe u legal nitions of exclusion of remedier he exclusion nado bral be used w apply othe ult exten pose without lag the Daw The validity conc and prfrmanc af hia warranty pole al be governed by the awe RETURNED MATERIAL AUTHORIZATION PROCEDURE nie responsibilty of any Authorized Service Center ASC or Distr with writen uhr 1 ensure the Customers equip i repaired ae son at posible Only Myte Proc In cis tral deers wi writes abetos sevice er and agents uy make man reps a hse products Al ors do wo Ir on ik and expense Te Distribut
7. mp To do this fill your solution tank with enough water to cover the filter with at least inches of water Turn the pump switch to the ON position Press the GREEN 4 button between the handles You will notice air coming out first This is normal Keep the line open until there is no more air and solution is flowing steadily and evenly It may take up to 2 minutes 2 Tum you vacuum switch to the ON position 3 Lift the powerhead by pushing down on the handles Turn the brush switch on You will hear and fee the brush rotating in the machine 4 To clean an area press the GREEN spray button and pul the machine backwards ata slow steady pace You can go over the area again without pressing the GREEN spray button to vacuum up additional solution from the carpet You will notice that the area you have cleaned will be damp This is normal To speed up the drying precess use the model 2500 WindStar or 2200 WindStorm air SYMPTOM PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION SYMPTOM PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION PROBLEM SOLUTION TROUBLESHOOTING Unit will not turn on Not plugged in Plug machine in proper outlet Circuit breaker has popped Reset circuit breaker Make sure no other items are running on the same circuit as machine Outlet must be a 15 A
8. or murt follow Myte Product Ic standard RMA proce 1 When a repair fla within the Warranty tine pei for a plc of oquipment the Diaributor il a RMA Warranty cai rm Ths forms wili act 2t a epider replace any een paro 2 All detective pst be str a Myter Produet Ic wil the RMA clai form for alsin at e customer s expense This shipping e nn refundaie A waranty claims are bj am evalton by Myles Products nto tere warranty wil be approved Any re for eae nor par wi aly be sae upon el and approval om Mee 3 When Wary i approved be Dis sec wil creed for the replacement Par Myles Prodan wl tip the warte element par 1 he Date Prem IWant dei the Dto aca wl ao be ceded fo aay pr an for cia MODEL DESCRIPTION ADVANTAGES SCH Tracker The SC 9 Tracker self contained carpet cleaning unit is a 9 gallon unit hat is equipped with a 100 PSI pump and a single HP 3 stage vacuum motor This machine has a single S0 foot power cord It has a 17 inch cleaning path and a 13 HP motor powers the rotating brush The amperage draw on this unit is 18 amps To run this unit effectively please use a dedicated 20 amp outlet The SC 9 Tracker delivers these additional Mytee advantages PERFORMANCE Operating at up to 100 PSI with 137 inches of water lift the SC 9 Tracker is a powerhouse extractor Heavy duty brush and motor combination cuts jobs down to size Clean fast clean deep VERSATILITY Use the Tracker with the hose as
9. sembly and upholstery tool to clean furniture and other upholstered items quickly ad efficiently CONVENIENCE Self contained and quiet the SC 9 Tracker is perfect for institutional cleaning EASY TO USE Easy to remove 9 gallon tanks ensure faster leading and unloading and make maintenance a snap Set up Maintenance SET UP You will find a black plastic 45 degree elbow inside the machine Place this elbow on the drain valve on the rear of the unit The elbow will direct the flow of recovered water downward Locate a dedicated 20 amp electrical outlet and plug in your machine Mix hot water and approved extractor detergent in a clean bucket Avoid mixing the chemical and water in the solution tank as the chemical does not dissolve completely and will clog your solution tank filter Clogging the filter will starve the pump of fuid and can shorten the life of the pump considerably MAINTENANCE As with any quality machine you will want to maintain your Tracker to obtain years of use This can be accomplished by running clean water with some form of System Maintainer available through your chemical distributor or through Mytee Products through your system on a bi weekly basis If your location is within a geographical area with hard water you may want to clean your machine more often OPERATION sc Tracker wem puue aus 1 i o Green Sich 1 Itis very important to prime the pu
10. y away from all openings and moving parts 15 Use extra care when cleaning on stairs 16 To reduce the risk of fire or electric shock do no use this machine with a solid state speed control device MYTEE LIMITED WARRANTY POLICY My Products Ine endeavors to provide high quality routs and product support o is Cates nd therefore backs op al fi pew products purchased ram Myts Product Inc Ce or any surged Mitr rs center wih this eed waranty This od warranty bagina on th dao of he em pacho and ia valid and val othe original pra ely te products we fr commercial we only ad ae mot ended fr personal aly or hota wen HOWEVER OTHER THAN SET FORTH HEREIN MYTEE GIVES NO WARRANTY EXPRESS OR IMPLIED AS TO DESCRIPTION QUALITY MERCHANTABILITY FITNESS FOR ANY PARTICULAR PURPOSE PRODUCTIVENESS INFRINGEMENT OR OTHER MATTER OF ANY GOODS WHICH MYTEE SHALL SUPPLY THERE ARE NO MYTEE SHALL INNO WAY BE RESPONSIBLE FOR THE PROPER USE AND APPLICATION TOASSUME FOR MYTEE ANY OTHER LIABILITY IN CONNECTION WITH THE SALE OF MYTEE S GOODS THUS LIMITED WARRANTY POLICY MAY BE CHANGED OR WEAR PARTS 0 DAY LIMITED WARRANTY Myc vil eplco all ear parts for 90 days om the date of original purchase War parti aot which wer out av osu of usage or he page of ine and are consumed despues to maa tn chat gasket whe tra con wie lc trials hass ach bemas plat pate Ses beangs she ale wins bulls beating clement castro te paris decd we em in Myc ne der
Download Pdf Manuals
Related Search