Home

Minnie Winnie - Winnebago Industries

1. 6 1 POWER 6 2 CONVOI 6 3 6 3 110 Volt Circuit 6 3 Ground Fault Circuit Interrupter 6 4 Auxiliary 110 Volt 6 4 Starting and Stopping the Generatot 6 5 Generator Hourmeter 6 6 122 Ol DC Sy Stemi asec 6 6 12 Volt Fuses and Circuit Breakers 6 7 Battery 0 2 2 6 7 Battery Storage and Maintenance 6 8 Trailer Wiring 6 9 SECTION 7 PLUMBING SYSTEMS Fresh Water 7 1 Waller PUM a 7 1 External Water 7 2 Exterior Shower Wash 7 3 Waste Water 5 7 3 Dumping Holding Tanks 7 4 Holding Tank Level 7 5 Water Drain 7 5 Water System Winterization Valve 7 5 SECTION 8 APPLIANCES AND INTERIOR FEATURES Refrigerator oc ease 8 1 Range and Oyen 5255 4 ian 8 4 Monitor Panel 8 6 Direct ignition Gas W
2. 6 3 6 4 2 6 6 12 Volt House Fuses Circuit Breakers 6 7 A About This 0 1 Air in the LP Gas 5 3 Armrest 222 2 6 Automatic Retraction Feature 2 5 Automotive Starting Battery 6 6 Automotive 12 Volt Fuses and Circuit Break sit 9 9 Auxiliary House Battery Access 6 7 Auxiliary 110 Volt 6 4 Auxiliary Battery Switch 2 12 Awning 9 9 9 7 Battery Boost Switch 2 12 Battery Condition 6 9 Battery Condition 8 7 Battery 0000 21 6 7 Battery Storage and Maintenance 6 8 Before Driving Your Vehicle 2 1 Before 0 2 Before Entering Your Vehicle 2 1 PRO CHING sod 4 7 CAD NCU 9 5 Campsie 4 7 Trailer TOW iM 4 3
3. 3 4 SECTION 4 TRAVELING WITH YOUR MOTOR HOME Loading the 4 1 Front Axle Tire Alignment 4 1 Weighing Your Loaded Vehicle 4 1 Maximum 4 3 Roof Loading eines eats 4 3 Car or Trailer Towing 4 3 Pres Travel Check 6 4 4 Travel EPS sese 4 5 Severe Weather Information 4 6 Nighttime 1 4 7 Mountain Driving 2 2200000411 4 7 UD onean 4 7 4 7 Effects of Prolonged Occupancy 4 8 Humidity and Condensation 4 8 SECTION 5 LP GAS SYSTEM EP Gas SUD DIY 5 1 Safe use of the LP Gas 5 1 How LP WOTKS 5 1 selecting LP Fuel 5 2 Tank see eae 5 2 Renin LE Tank 5 3 Air in the LP Gas 5 3 travel Witt LP 5 3 RESU O 5 3 TABLE OF CONTENTS LEAKS mereinen 5 4 Winter Use of LE Gas 5 5 SECTION 6 ELECTRICAL SYSTEMS 110 Volt 8 6 1
4. 2 1 2 2 PUGH SClCCHOM 2 2 Gasoline Fuel 2 2 Tank Capacity 2 2 Starting and Stopping Engine 2 3 Fuel Pump Shut Off 2 3 Brake 2 3 Hazard Warning 2 3 Entrance Door Lock and 2 3 2 4 2 5 CAE BENS 2 7 Child 2 8 OFS 2 9 Instrument 1 2 2424 22000 2 9 Comfort 8 2 0 2 0200221 2 11 RV RIO 2 11 Auxiliary Battery Switch 2 12 Slideout Room 2 13 SECTION 3 IN CASE OF DRIVING EMERGENCY Hazard Warning 3 Spare Tire 3 1 Motor Home Jacking and Tire Changing 3 1 NVC SL 3 2 Recover 3 2 3 3 Connecting Jumper Cables 3 3 Connecting A Battery Charger 3 4
5. INTRODUCTION About This 0 1 Chassis Operating Guide 0 1 Owner s INOC ASE 0 1 Options and Equipment 0 2 0 2 Service 0 2 EY nie 0 2 Drinking 2 2222 0 0 2 Reporting Safety 0 2 Vehicle Certification 0 4 Exterior Feature 0 5 SECTION 1 SAFETY PRECAUTIONS General 1 1 B 1 2 LP 1 2 eas 1 3 1 3 1 4 1 5 1 5 Formaldehyde Information 1 5 Carbon Monoxide Warning 1 5 Carbon Monoxide Alarm 1 6 Fimerocncy EXIS ananasni l 7 Using Slider Windows as Emergency Exits 1 7 Pirg Extinguisher aa 1 8 1 8 SECTION 2 DRIVING YOUR MOTOR HOME Before Entering Your Vehicle 2 1 1 Before Driving Your Vehicle
6. 7 2 Doors 9 7 Doors Locks 1 2 3 Draperies Curtains Bedspreads 9 3 Drinking and 0 0 000 0 2 Driver Compartment Door 2 4 aione Rye Erne 1 2 Ducted Roof Air Conditioning System 8 12 Dumping Holding Tanks 7 4 E Effects of Prolonged Occupancy 4 8 2 4 Emergency Crank In 2 15 Emergency Exis r l 7 Engine Cooling System 9 7 Pagine 3 4 Entrance Door Lock Handle 2 3 Extend Slideout 2 14 Exterior Entertainment 8 16 Exterior Feature 0 5 Exterior Shower Wash 7 3 ESITO 9 1 External Power 6 1 External Water 7 2 F Filling the Fresh Water 7 1 Fire 1 8 Formaldehyde Information 1 5 Fresh Water 7 1 Fresh
7. 3 2 Window Roll Up Shade Adjustment 8 23 Windshield Washers and 1 9 8 Winter 5 5 Motor Home Coach Year Chassis Make Roof Air Conditioner Furnace Water Heater Power Converter 110 Volt Generator Range Microwave Oven Refrigerator Television Video Cassette Player Dealer Name Address Phone INSURANCE POLICY Company Policy Number Phone Brand Brand Brand Brand Brand Brand Brand Brand Brand Brand IMPORTANT SERIAL NUMBERS Model Serial VIN Model Model Model Model Model Model Model Model Model Model EMERGENCY INFORMATION Serial Serial Serial Serial Serial Serial Serial Serial Serial Serial Serial MAINTENANCE RECORD FUEL amp RECORD Odometer Fuel Oil Odometer Fuel Oil Date Mileage Gal Qts MPG Cost Date Mileage Gals Qts MPG Cost FUEL amp RECORD Odometer Fuel Oil Odometer Fuel Oil Date Mileage Gal Qts MPG Cost Date Mileage Gals Cost
8. e Use caution when handling or working near electrical storage batteries Always remove jewelry and wear protective clothing and eye covering Avoid creating sparks LOADING e Store or secure all loose items inside the motor home before traveling Possible over looked items such as canned goods or small appliances on the countertop cooking pans on the range or free standing furniture items can become dangerous projectiles during a sudden stop or evasive maneuver Minnie e Be aware of GVWR GAWR and individual load limit on each tire or set of duals See Loading the Vehicle in Section 4 e Never load the motor home in excess of the gross vehicle weight rating or the gross axle weight rating for either axle NOTE Your motor home s load capacity ts designated by weight not by volume so you cannot necessarily use all available space when loading your motor home MAINTENANCE e Do not remove the radiator cap while engine and radiator are still hot Always check cool ant level visually at the see through coolant reservoir e Never get beneath a vehicle that is held up by a jack only e Do not mix different construction types of tires on the vehicle such as radial bias or belt ed tires as vehicle handling may be affected Replace tires with exact size type and load range SECTION 1 SAFETY PRECAUTIONS A e Do not attempt to start the vehicle by hot wir ing FORMALDEHYDE
9. SECTION 7 PLUMBING SYSTEMS TANK CAPACITIES Black Water Holding Tank Modela 7P TT 42 gal Model 450 Y Toler Lavatory E EEEO ETEO NEOR 35 gal Model 431C Toilet amp 35 gal HT2 Gray Water Holding Tank Model 427P Shower Lavatory amp 2 iaaea 35 gal Model40V Galley Ren NE EEEE 38 gal Model 431C 38 gal Water Tank Drain Valve Water Line Drain Valves _ Model 431C RH Rear Compartment _ Water Drain Valves in Water Center Model 430V SECTION 7 PLUMBING SYSTEMS Minne Winne WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS 427P 430V 7 8 Water Lines City Water Line Water Tank Water Heater Water Heater By Pass Valve Winterization Antifreeze Valve Water Lines Water Tank Exterior Shower Water Heater Water Heater By Pass Valve Winterization Antifreeze Valve One 1 valve in passenger side rear cargo compartment Also open exterior shower faucet in water center and place shower head below floorline The city water hose connection 15 located on the ceiling of the Utility System compartment Stick your finger up inside the conn
10. E E 9 7 Trailer Wiring 6 9 Travel 2 13 Travel T 4 5 5 3 TV 8 13 Signal Amplifier 8 14 Underbody 9 1 NT OTS CCI sie cored 9 2 Upholstery Carpeting and 9 2 Using On Site Sewer 0 7 4 Vehicle Certification 0 4 Vehicle Maintenance 9 7 Video Selector 8 15 Vinyl Wallboard 9 5 9 3 W eng 0 2 Waste Water System Holding Tanks 7 3 Water Drain Valves 7 5 INDEX Water Heater Pressure Temperature A bce ee Pee se 8 9 Water Heater SwitChs 8 6 Water Pump Switch 22202001 7 1 Water 8 7 W ater PUMP 7 1 Water 9 4 Water SAIS d 9 4 Water System Drain Valve Locations 7 8 Water System Winterization Valve 7 5 Weighing Your Loaded Vehicle 4 1 WANE CIN
11. Wimmie TO THE OWNER Congratulations We welcome you to the exciting world of motor home travel and camping You will find it convenient and enjoyable to have all the comforts of home and still enjoy the great outdoors wher ever you choose to go Your motor home has been carefully designed engineered and manufactured to provide dependability as well as safety Before sliding into the driver s seat take a few minutes to become familiar with opera tions and features This manual was prepared to aid you 1 the proper and operation of the vehicle and equipment We urge you to read it completely In addition spend some time with the dealer when you take delivery you will want to learn all you can about your new motor home Your new motor home 15 covered by a factory warranty against defects in material and workmanship This warranty should be validated at once and returned to the factory by your dealer About Safety Messages Used in This Manual Throughout this manual certain items are labeled Note Caution Warning or Danger These terms alert you to precautions that may involved damage to your vehicle or a risk to your personal safety Read and follow them carefully This SAFETY ALERT SYMBOL 15 used to draw your attention to issues which could involved potential personal injury This symbol is used throughout this manual and or on labels affixed on or near various equipment in this motor home DANGER DANGER indicates
12. e We recommend using a mild soap and water applied gently to the soild areas Buff dry immediately with a soft cloth to avoid water spotting Avoid harsh and excessive rubbing while cleaning Soft leather needs delicate care e Never use harmful substances e g stain removers solvents saddle soap shoe polish or other unsuitable fluids on soft leather Cleaning and touch up kits specifically formulated for leather upholstery are avail able from most fine furniture dealers CABINETRY Wooden items may be cleaned with a soft cloth and a good quality wood finish cleaning product such as Guardsman equivalent Vinyl simulated wood Plus Wood panels may be cleaned with a mild water based cleaner and a soft cloth Do not use solvents on vinyl wood panels NOTE Many cabinetry and furniture items throughout this motor home are con structed either partially or completely of real hardwoods Because of natural vari ations in woodgrain density slight dif ferences in stain hue may exist between one item and another This is the distinc tive character and beauty of real wood SECTION 9 amp MAINTENANCE An VINYL WALLBOARD Decorative vinyl covered wallboards may be cleaned with a mild solution of water and isopro pyl rubbing alcohol or a mild soap solution Do not use solvents or abrasive cleaning products TABLES AND COUNTERTOPS Tables and countertops except galley are covered with a plastic l
13. An LP tank must have at least 20 of tank volume free to allow for expansion and proper vaporization of the liquid fuel The tank 15 also equipped with mandatory safety shut off equipment that prevents filling above this level 2004 NEW VEHICLE LIMITED WARRANTY WINNEBAGO INDUSTRIES INC WARRANTY COVERAGE TO OWNER Winnebago Industries Inc of Forest City lowa warrants each new Winnebago Industries motor home to the owner for use in the U S A and Canada as follows WARRANTY PERIOD The Warranty Period for all coverages begins on the date the vehicle is delivered to the first retail purchaser or first placed in service as a demonstrator or company vehicle BASIC COVERAGE The basic Warranty Period is 12 months or 15 000 miles 24 135 kilometers on the odometer whichever occurs first Winnebago Industries does not authorize any person to create for it any other obligations or liability in connection with this vehicle ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE APPLICABLE TO THIS VEHICLE 15 LIMITED IN DURATION TO THE DURATION OF THIS WRITTEN WARRANTY AS HEREINBEFORE OR HEREINAFTER PROVIDED THE PERFORMANCE OF REPAIRS 15 THE EXCLUSIVE REMEDY UNDER THIS WRITTEN WARRANTY OR ANY IMPLIED WARRANTY WINNEBAGO INDUSTRIES SHALL NOT BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR LOSS OF TIME INCONVENIENCE OR OTHER CONSEQUENTIAL DAMAGE INCLUDING EXPENSE FOR GASOLINE TELEPHONE TRAVEL LODGING LOSS
14. s information InfoCase for any additional warranty coverage after the basic warranty has expired PART NO 701677 K2 004 5 03 NOTICE OF SECOND OWNER ORIGINAL NAME OWNER ADDRESS NAME ADDRESS WINNEBAGO INDUSTRIES IDENTIFICATION NUMBER VEHICLE MILEAGE CHASSIS IDENTIFICATION NEW OWNER SIGNATURE DEALER S REPRESENTATIONS EXCLUDED Winnebago Industries Inc does not undertake the responsibility to any purchaser of its products for any undertaking representation or warranty made by dealers selling its product beyond those herein expressed INSTALLATION NOT COVERED Winnebago Industries Inc cannot however and does not accept any responsibility in connection with any of its motor homes for additional equipment or accessories installed at any dealership or other place of business or by any other party other than Winnebago Industries Inc Such installation of equipment or accessories by any other party will not be covered by the terms of this warranty CARE AND MAINTENANCE It is the owner s responsibility to perform the care maintenance and proper load distribution described in the owner s manual which accompanies your motor home Any damage which results to your vehicle as a result of your failure to perform such duties is not covered Damage to appearance items such as fiberglass metal paint fabrics and trim may occur during manufacturing or transporting Normally any factory defect or damage is c
15. 12 13 14 15 tions Also make sure all hangers and sup ports are securely place Sanitize the water system as outlined under Disinfecting the Fresh Water System in Section 7 Check operation of all faucets to be sure fau cet washers have not hardened during stor age Check sealing valve in the toilet for proper operation and lubricate with silicone spray Add water to the holding tank using the toilet flush pedal Check to be sure dump valve seals tightly Check around all appliances for obstructions and ensure that all vent openings are clear Start refrigerator and check for proper cool ing Clean paneling and counter surfaces and apply a thin coat of wax Replace batteries if necessary and check out electrical system to make sure all lights and electrical components operate Check tires for proper cold inflation pres sure After washing accumulated winter grime from the vehicle it 15 important to carefully inspect the seams and sealants for separation or cracks that may have appeared around the window frames vents and any other joints Re sealing is quite simple and the material 15 quickly and easily applied Appropriate com pounds are available from your dealer Also inspect weather seals around doors etc and if necessary have a dealer replace immedi ately inne Minnie Minnie Wimmie AC 6 110 Volt Circuit
16. 58 066 1 1 inne Satellite Television 8 15 9 1 Seat Belt Care and Cleaning 2 8 ENS eae teas 2 7 E A 2 5 Selecting LP Fuel 5 2 Service and 518 0 2 Severe Weather 4 6 Shower Valve Pressure Bleed Off 7 3 Side Mirror Head 2 9 Sleeping 2 222 2 8 17 Slideout Room Extension 2 15 2 13 Slider Windows as Emergency 1 7 Slider VV aun 8 23 Spare Tre Storage eunian 3 1 Spo AN 9 2 Starting and Stopping Engine 2 3 Starting and Stopping the Generator 6 5 Steering Column Controls 2 11 Suspension Alignment and Tire 1 9 8 Swivel Glider Lounge 8 17 T Tables and Countertops 9 5 Tank Capacities s a E 7 7 29 6 3 Whe R E
17. Driving to a disposal site will normally loosen and rinse any waste material from the sides of the tank B Completely drain the sewage and waste water holding tanks at an approved waste disposal site Drain the sewage tank first so the following waste water can rinse any waste solids from the dump outlet and sewer hose C Close dump valves and refit the dust cap onto the drain outlet SECTION 10 STORING YOUR MOTOR HOME 2 Level the motor home and drain the entire plumbing system as described in the follow ing steps 3 Open all drain valves See the water system drain valve chart in Section 7 for locations on your model DRAIN DRAIN LINE END VALVE IN LINE VALVE NOTE If your coach is equipped with a water purifier system you will need to remove the filter cartridge and install the divert er plug supplied The cartridge is located beneath the galley sink counter The di verter plug must be removed and a filter cartridge installed before resuming nor mal use of the water system The plug is intended for winterization only 4 Turn the Water Pump switch ON to allow it to operate until you are done draining all fau cets and toilet 5 Open all faucets and shower head valves including exterior shower 6 Operate the toilet flush pedal and hold until water stops flowing in the toilet Then turn water pump switch OFF 7 Turn off the water heater power switch before draining the water heater tank to avoi
18. Know the height and width of your unit Always fill the fresh water tank at an ap proved potable water filling facility or a 10 12 13 14 SECTION 4 TRAVELING WITH YOUR MOTOR HOME known purified drinking water source Taste the water before filling the water tank in an unfamiliar location The water in some areas may contain an undesirable taste Do not use a new hose to fill the water tank It can leave a distinct rubber or vinyl taste Showers can take a lot of water Conserve water by taking a Sea Shower This is done by wetting down turning off the water soap ing thoroughly and then rinsing Dump sewage only at approved dumping sta tions Store liquids in plastic containers with tight fitting caps to prevent spills Keep an eye on the water and holding tank levels It is a good idea to dump the holding tank at least every two days When traveling with children it is helpful to plan their wardrobe for a week Place each days clothing in a plastic bag and label the bag with the child s name and day of the week for use Use sleeping bags whenever possible They save laundry and take up less storage space than bedding Make sure all compartment doors have been closed and the door step has been stowed in the correct position before moving the vehi cle Before traveling make sure the refrigerator door has been secured Use care when open ing the refrigerator door after the ve
19. Never use an open flame to test for LP gas leaks Replace all protective covers and caps on LP system before filling Never fill the LP tank with engine or generator running REGULATOR The pressure regulator is protected from the elements by a plastic cover which should be left in place at all times Only your dealer or a quali fied LP gas service should remove the regulator cover for adjustments 5 3 5 LP GAS SYSTEM WARNING Inspect the pressure regulator vent hole periodically for blockage If any obstruction 1s apparent have the regu lator serviced by your dealer or a qual ified LP gas service center LP gas regulators are installed with the diaphragm vent facing downward Make sure that the regulator vent always faces downward to minimize vent obstruction which could result in excessive pressure causing a fire or explosion Regulator freeze ups are caused by the pres ence of moisture in fuel This moisture will pass through the cylinder valve and into the regulator where it can freeze Fuel producers tank and bot tle manufacturers and LP gas dealers take every precaution to reduce moisture but sometimes only a fraction of an ounce entering the tank can cause problems To help avoid the possibility of freeze up always keep tank control valve closed when not in use even when tank is empty to pre vent moisture from collecting on the inside If regulator freeze up should occur you
20. and is commonly called the black water tank The second holding tank contains the waste water from the galley sink bathroom lava tory and shower and is commonly called the gray water tank The holding tanks are dumped through a com mon outlet located on the left side of the vehicle near the rear wheels 7 3 SECTION 7 PLUMBING SYSTEMS DUMPING HOLDING TANKS 1 Remove drain hose from rear bumper or exterior storage compartment 2 Remove dust cap from drain and connect drain hose Be sure it is firmly attached 3 Place the other end of sewer hose into dis posal opening 4 Open the large sewage valve with a quick pull OPEN ONE VALVE AT A TIME Move hose gently about to dislodge any waste and to ensure complete drainage Pull second to drain lt Black Tank 17 lt a mi 5 Close sewage valve and open small waste water valve with a quick pull Make sure there are no sags the hose during drainage Close valve handle as soon as tank is empty 6 After both tanks have been drained run sev eral gallons of water into the sewage tank through the toilet Then open sewage dump valve and drain the tank again Close valve and replace dust cap securely 7 Itis advisable to add an odor control chemi cal to the sewage holding tank These chemi cals are available at most R V stores 8 Rinse sewer hose thoroughly with water and Stow NOTE We recommend that you dump all hold ing tanks
21. cle Do not operate the cruise control on icy or ex tremely wet roads winding roads in heavy traffic or in any other traffic situation where a constant speed cannot be maintained Use care when accelerating or decelerating on a slippery surface Abrupt speed changes can cause skidding and loss of control Driving through water deep enough to wet the brakes may affect stopping distance or cause the vehicle to pull to one side Check brake operation in a safe area to be sure they have not been affected Never operate any vehicle if a difference braking efficiency is noticeable Adverse weather conditions and extremes in terrain may affect handling and or perfor mance of your vehicle Refer to your chassis manual for related information FUEL amp LP GAS 1 2 All pilot lights must be extinguished and pliances turned off while refilling the fuel tank or LP tank Minne Wine Never smoke while refilling vehicle fuel tank or LP gas tank Avoid inhaling exhaust gases produced by burned gasoline diesel fuel or LP gas in items such as the range chassis engine gen erator engine refrigerator furnace and water heater They contain carbon monoxide which is an odorless colorless and poisonous gas Do not bring or store LP gas containers gas oline or other flammable liquids inside the vehicle because a fire or explosion may re sult LP gas containers are equipped with safety valves which relieve
22. which could cause a crash or could cause injury or death you should immediately inform the National Highway Traffic Safety Administration NHTSA addition to notifying Winnebago Mime Wimme Industries Inc If NHTSA receives similar complaints it may open an investigation and if it finds that a safety defect exists in a group of vehicles it may order a recall and remedy campaign However NHTSA cannot become involved individual problems between you your dealer or Winneba go Industries To contact NHTSA you may either call the Auto Safety Hotline toll free at 1 800 424 9393 or 366 0123 in Washington D C area or write to NHTSA U S Department of Transportation Washington D C 20590 You can also obtain other information about motor vehicle safety from the Hotline INTRODUCTION 0 3 INTRODUCTION Minne VEHICLE CERTIFICATION LABEL This label contains vehicle identification and other important reference information The vehicle cer tification label is located on the sidewall to the left of the steering wheel or on the driver s door Never remove or destroy this label MANUFACTURED BY INCOMPLETE VEHICLE MANUFACTURED INNEBAGG BY MOTOR CORP MONTH AND YEAR OF MANUFACTURE GVWR_ SUITABLE TIRE AND RIM CHOICE COLD INFLATION PRESSURE KPA SINGLE THIS VEHICLE CONFORMS TO ALL APPLICABLE FEDERAL MOTOR VEHICLE SAFETY ST
23. 12 volt equipment in the motor home Certain circuits however remain unchanged for use by items which require 1 10 volt current such as the air conditioner s the refrigerator in AC mode the microwave oven etc Current drawn from the coach batteries passes through the power center unchanged although it is routed through a series of protective fuses lo cated on the power panel The power panel is located a lower cabinet face the galley living area The power panel contains the coach electrical system 110 volt cir cuit breakers and 12 volt fuses 110 Volt 12 Volt Circuit Breakers House Fuses Wit A Power Center Minne WARNING Do not store anything around or on top of the converter or in front of the cover The converter generates heat while operating and needs unre stricted air flow for proper cooling CONVERTER Converter DC The converter charges coach batteries while 110 volt external power is connected The con verter will automatically sense the condition of the RV battery If it is below full charge the Charging Section will start charging the battery If the coach batteries have been extremely dis charged they will accept charge at a relatively high amperage rate If they are only slightly dis charged they will charge at a lower amperage rate The rate of charge will decrease as the bat teries reach full charge Active charging
24. 1s slightly dished If You Already Know Your Sleep Number If you know what your Sleep Number is enter it on the remote by pressing the firmer or softer buttons until your sleep number 15 dis played The display screen will blink as the mat tress adjusts Lie still until 1t stops blinking There may be some minor clicking as the final Sleep Number setting is perfected Once reached the remote will display your Sleep Number then shut itself off Finding Your Sleep Number The Simple Step by Step Process If you do not already know your Sleep Num ber or would like to experiment with finding a different one use the instructions below It sometimes takes several nights of sleeping at different settings to discover your ideal Sleep Number Wine Step 1 Lie on your normal side of the bed in your normal sleep position holding the remote for your side of the bed Press the firmer or softer button on the remote to wake it up It will display the current Sleep Number setting Step 2 d 2 hoo 4 4 _ 4 al 4 Step 3 Start by setting the Sleep Number to 50 on the remote Step 4 Take time to evaluate your comfort see diagrams below Step 5 If you like the feel of the mattress at 50 go to Step 5 If you find that this setting is too firm or too soft change your Sleep Number in increments of 5 Reevaluate your comfort level after each chang
25. 2 Turn off water heater power switches Turn LP gas supply off 4 Wait five minutes for any gas to clear the area If you smell gas then stop and follow item B of the Safety Information above If you don t smell gas go to the next step Turn on LP gas main tank valve 6 Turn on the water heater switch on the moni tor panel You may hear a clicking noise as the ignition element begins working If the burner does not light on first try the system will stop trying to light burner and go to lockout mode 7 Iflockout happens before main burner lights turn switch OFF wait five seconds and turn switch back on This will restart the ignition cycle The first start up of the water heater after it has not been used for a long time may require several ignition cycles before all the air 1s purged from the gas lines and gas begins to flow If the burner will not come on check the fol lowing items before calling for service 99 1 Is the switch turned Dos the LP tank have gas in it or is main tank valve turned on 3 Is the ECO Reset button tripped See Atwood Water Heater Operation ual in your Owners InfoCase To Turn Water Heater Off 1 Turn switch on monitor panel to Off posi tion SECTION 8 APPLIANCES amp INTERIOR FEATURES 2 Turn electric water heater switch off 3 Turn off LP gas supply if not to be used for extended period 4 Drain water heater tank if the coach 1s to be
26. Carbon Monoxide 1 1 6 Carbon Monoxide 1 5 Care of Ceiling 9 3 Care of Ceiling 9 3 Care of Stripes 9 2 Carpet Care amp 1 9 2 Chassis Battery 6 7 Chassis Operating Guide 0 1 Chassis Service amp Maintenance 9 7 Child RES Wal nts 2 8 4 7 Cold Weather Storage Procedure ZS 2232 0 10 1 INDEX COmiort C ONIONS aese 2 11 Connecting a Battery 3 4 Connecting Jumper Cables 3 3 CONVEO T aE 6 3 Couch Bed 10155 8 18 D Day Nighter Pleated Window Shades 8 23 DC AC Electrical Voltage Inverter 8 16 Deluxe Sound 2 11 D scendinge a Hill 4 7 Dinette Bed 1 8 18 Direct Ignition Gas Water Heater 8 7 Disinfecting Fresh
27. INFORMATION WARNING Some components in this vehicle con tain formaldehyde based adhesives which may release formaldehyde fumes into the air for an unknown period of time until total dissipation occurs Individuals who are allergic to formaldehyde gas fumes may experience irritation to eyes ears nose and throat Reaction in infants may be more severe Although long range effects are not well understood testing to date has not revealed any serious health effects in humans at the level of emission from these prod ucts NOTE To aid in dissipation ventilate the vehi cle by opening all windows and circulat ing the air with a fan CARBON CARBON MONOXIDE ON WARNING Avoid inhaling exhaust gases as they contain carbon monoxide which is a colorless odorless and poisonous gas If you suspect that exhaust fumes are entering the passenger compartment have the cause deter mined and corrected as soon as possible If you must drive under these conditions drive only with ALL WINDOWS FULLY OPENED 1 5 A SECTION 1 SAFETY PRECAUTIONS The best protection against carbon monoxide entry into the vehicle body is a properly main tained engine exhaust and ventilation system It is recommended that the exhaust system and body be inspected by a qualified motor home service center e Each time the vehicle is raised for an oil change e Whenever a change in the sound of the ex haust system is noticed
28. This switch is located on the lower left dash panel Two Way Radios Optional If your coach is equipped with the available two way radios the built in charger station 1s located in the electrical load center cabinet on the end of the galley for easy grabbing as you head out the door 2 12 Please read the manufacturer s operating 1 formation AUXILIARY BATTERY Aux Batt SWITCH This switch is intended to disconnect the aux iliary house batteries from the 12 volt system of your RV to avoid long term battery drain by elec trical items that are hooked directly to the coach batteries such as clock displays and radio mem ories etc The Aux Batt switch is lcoated on the cabinet right inside the entrance door Always leave this switch ON except during storage periods Some electronic displays and memory functions may need to be reset after power has been reconnected See also Battery Storage and Maintenance on page 6 8 Aux Battery Switch Sr SLIDEOUT ROOM Optional The slideout room provides expanded living area at the push of a button The slideout room is extended and retracted using a hydraulic powered mechanism with an electronic control system The slideout control switch is located on the end of an overhead cabinet just inside the entrance door Slideout Switch on end of Galley Overhead Cabinet WARNING Keep all persons clear of the slideout room and moving parts while
29. Water Heater switches the gas one on the monitor panel and the electric one This will help reheat the water heater tank more quickly than a single source would alone Use this mode when you are using a larger than nor mal volume of hot water for example when someone 15 taking a shower and the dishwasher or clothes washer is also being used Gas Safety Information A This appliance does not have a pilot light It is equipped with an ignition device that auto matically lights the burner Do Not try to light the burner by hand B Before lighting smell around the appliance area for gas Be sure to smell near floor because LP gas 1s heavier than air and will settle on the floor WHAT TO DO IF YOU SMELL GAS e Do not try to light any appliance e Do not touch any electrical switch e Get out of the coach immediately and turn off the LP gas tank at the main tank valve See photo on page 5 2 e Use neighbor s phone to call your Win nebago Industries dealer or a local gas sup plier for instructions Do not use a phone in your coach Follow the dealer s or gas sup plier s instructions e Ifyou cannot reach a Winnebago Industries dealer or a local gas supplier call the fire department e Have the source of the leak corrected before using the LP gas system again Operating Instructions 1 STOP Read the safety information provided in the Atwood Water Heater Operation Man ual in your Owners InfoCase
30. a directly hazard ous situation which if not avoided will result in death or serious personal injury 4 WARNING WARNING indicates a potentially hazardous situation which if not avoided could result in death or ous personal injury November 2003 132000 04 004 CAUTION indicates a potentially hazardous situation which if not avoided could result damage mainly to equipment or property but in Some cases may also result in minor or moderate personal injury NOTE A Note is not necessarily safety related but indicates a recommendation or special point of information that could assist in understanding the use or care of a feature item VEHICLE CHASSIS IDENTIFICATION NO VIN DATE OF DELIVERY TO FIRST RETAIL PURCHASER VEHICLE MILEAGE AT TIME OF DELIVERY SELLING DEALER NAME AND ADDRESS TANK CAPACITIES Chassis Fuel Tank Ford Chassis w 6 8L EFI Gas Engine LP Gas Tank All Models Fresh Water Tank Model 427P Models 430V amp 431C Water Heater All Models HT1 Black Water Holding Tank Model 427P Toilet Model 430V Toilet amp Lavatory Model 431C Toilet amp Lavatory HT2 Gray Water Holding Tank Model 427P Shower Lavatory amp Galley Model 430V Galley amp Shower Model 431C Galley amp Shower LP Gas tank capacity shown is the usable full LP gas capacity which is 80 of the tank manu facturer s listed water capacity w c shown in parenthesis
31. amp INTERIOR FEATURES NOTE If heat does not come out of the heat ducts after a minute or so the burner is not lit Turn thermostat off for 3 5 minutes check to be sure tank valve is open and tank is not out of fuel then try steps 2 4 again If it still will not light after three attempts go to Shut Down steps and contact your dealer or a local RV service center For Further Information Please see the Suburban furnace operating instructions provided in your Owner InfoCase for further information including operating pre cautions and periodic maintenance HEAT PUMP Optional Your coach may be optionally equipped with an air source heat pump built into the central air conditioning system Because the heat pump operates on electricity it provides economical heat inside your coach and helps reduce the use of LP gas for heating in cooler weather A heat pump can be thought of as an air con ditioner running in reverse An air conditioner absorbs heat from the air inside of the coach and moves it to the outside The heat pump does exactly the opposite Even cold air contains some heat so a heat pump will extract heat from the outside air on a cold day and carry it to the inside of the coach to maintain a comfortable tempera ture The efficiency of a heat pump decreases as the outdoor air temperature drops so supplementary heat is often needed when the outside tempera ture nears freezing This system 15 set to automat ically
32. as possible and fit snugly across the hip area Always sit erect and well back into the seat To gain full pro tection of the safety belt never let more than one person use the same safety belt at any one time and do not let the safety belts become damaged by pinching them 1n the doors or in the seat mech anism After any serious accident any seat belts which were in use at the time should be replaced SECTION 2 DRIVING YOUR MOTOR HOME ae lt gt 1 PULL TIGHTEN 2 TONGUE 3 PUSH TO RELEASE Adjustment To lengthen belt turn tongue at a right angle to belt and pull to desired length To shorten pull loose end of belt To Fasten Be sure belt is not twisted Grasp each part of the belt assembly and push tongue into buckle Adjust to a snug fit by pulling the loose end away from the tongue To Release Press button in center of buckle and slide tongue out of buckle WARNING To reduce the risk of an injury in an accident position the lap belt tightly and as low as possible across the pel vic area Pregnant woman should be especially certain to wear the lap belt as low as possible across the pelvic area so there 15 no pressure on the abdomen Only seats equipped with seat belts are to be occupied while vehicle is in motion Lap Shoulder Belts Fastening Hold the belt just behind the tongue using the hand nearest to the door Next bring the belt across the body and slide the tongue into t
33. cautions in this manual before operating your new motor home About Safety Messages Used in This Manual Throughout this manual certain items are la beled Note Caution Warning or Danger These terms alert you to precautions that may involved damage to your vehicle or a risk to your personal safety Read and follow them carefully This SAFETY ALERT SYMBOL is used to draw your attention to issues which could involved potential personal injury This symbol is used throughout this manual and or on labels affixed on or near various equipment in this motor home DANGER DANGER indicates a directly hazard ous situation which if not avoided will result in death or serious personal injury 4 WARNING WARNING indicates a potentially hazardous situation which if not avoided could result in death or seri ous personal injury CAUTION CAUTION indicates a potentially hazardous situation which if not avoided could result damage mainly to equipment or property but in Some cases may also result in minor or moderate personal injury SECTION 1 NOTE A Note is not necessarily safety related but indicates a recommendation or special point of information that could assist in understanding the use or care of a feature item The following pages provide safety precau tions that must be adhered to These precautions as well as others that involve possible injury or damage to equipment are also disp
34. cleaning agent from the list below before your begin the cleaning process NOTE In many cases listed in the chart below repeated steps may be required to fully extract contam inant from material Items listed with may also be removed through steam extraction method by a pro fessional cleaner or service Always check to see that the cleaner used will not cause damage to the material or fabric by testing an area out of sight Mustard Ketchup Coffee Chocolate Tea Chewing Gum Oil Nail Polish Shoe Polish Crayon Marker indelible Ink Ballpoint Pen Pencil Lead Graphite Vomit Urine Blood Excrement Water Stains Dry Clean Solvent High Strength Detergent High Strength Detergent Detergent High Strength Detergent Dry Clean Solvent High Strength Detergent High Strength Detergent Degreaser Kerosene Thinner Detergent Rust Remover Detergent Dry Clean Solvent Dry Clean Solvent Dry Clean Solvent High Strength Detergent Detergent Dry Clean Solvent Detergent High Strength Detergent High Strength Detergent High Strength Detergent High Strength Detergent Water stains should be cleaned with a mixture of 1 4 cup of white laundry detergent in a bucket of warm water Working with a clean sponge or white cloth start from the outside of the stain and work your way to the center This method will keep the stain from spreading Do not over satu rate as this may cause de lamination No ne
35. differ slightly between models Some equipment described in this manual may not apply to your coach BEFORE DRIVING Before sitting in the driver s seat always check around your vehicle to be sure you have proper clearance for maneuvering If necessary have a passenger help guide you out of a difficult parking space Although your coach features automotive conveniences like power steering and power brakes driving a motor home is different from driving a A motor home is larger and heavier than an automobile so it requires more stopping and passing distance and more parking and ma neuvering space than does a car Always be aware of the size of your motor home The added height of roof air conditioners TV antennas or luggage boxes may cause clear ance problems around some tunnels canopies and hanging signs Know the height of your unit so you can observe posted clearance limits Also remember that some bridges old ones particu lar may not support the weight of your motor home Know the weight of your unit and observe any posted weight limits Remember Always use your seat belt and be sure your passengers do so as well We also ad vise making frequent rest stops while traveling to relieve stress on yourself your passengers and your vehicle Gl SERVICE AND 7 ASSISTANCE Your dealer will be glad to provide any addi tional information you need as well as answer any questions you might have abou
36. e Whenever the exhaust system underbody or rear of the vehicle is damaged To allow proper operation of the vehicle s ventilation system keep front ventilation inlet grill clear of snow leaves or other obstructions at all times DO NOT OCCUPY A PARKED VE HICLE WITH ENGINE RUNNING FOR AN EXTENDED PERIOD Do not run engine in confined areas such as a garage except to move vehicle in or out of area When vehicle is stopped in an UNCONFINED area with the engine running for any more than a short period adjust heating or cooling system to force outside air into the vehicle as follows 1 Set fan to medium or high speed and vent control to air 2 On vehicles equipped with air conditioning set fan to medium or high speed and set con trol to obtain maximum vent air Rear windows should be closed while driving to avoid drawing dangerous exhaust gases into the vehicle CARBON K CARBON MONOXIDE ALARM Your coach is equipped with a carbon monoxide CO alarm located on the ceiling in the bedroom area 1 6 gt ANAC Sed Yellow Light Warning Red Light Press to Test Alarm The CO alarm is powered by a 9 volt battery and contains a sensor that 15 designed to detect toxic carbon monoxide gas fumes resulting from incomplete combustion of fuel It will detect CO gas from any combustion source such as the fur nace gas range oven water heater refrigerator chassis engine and e
37. equipped with an auto matic 80 stop fill device AIR IN THE LP GAS TANK If your LP gas appliances do not stay lit or re quire frequent adjustment even though you know the LP tank contains sufficient fuel the problem may be air in the LP gas tank Air in the tank mixes with the LP gas vapors causing them to burn poorly This condition could linger for weeks if the air is not purged from the tank Most LP gas dealers have equipment for purging air from LP gas tanks and will purge before refilling the tank TRAVEL WITH LP GAS It is illegal for vehicles equipped with LP tanks to travel on certain roadways or through certain tunnels in the U S To avoid inconve nience check state regulations concerning flam mable gas transportation SECTION 5 LP GAS SYSTEM LE DO NOT FILL CONTAINER TO MORE THAN 80 PERCENT OF CA PACITY Make sure the motor home is level when filling It is possible to accidentally overfill the tank if the ve hicle is unlevel with the fill valve on the uphill side Overfilling the LP gas tank can result in uncontrolled gas flow which can cause fire or explo sion A properly filled container will contain approximately 80 percent of its volume as liquid LP gas All pilot lights must be extinguished and supply valve closed before refill ing LP gas tanks or vehicle fuel tanks Do not smoke or expose an open flame while near an LP refueling area LP gas is heavier than air and ex tremely flammable
38. es Unhook the strap for the side that is touching the sidewall then continue cranking until the gapped side is snug Reattach the other strap and snug up the crank to hold the room in 2 16 4 Prep For Travel Before driving off close T handle bypass valve on hydraulic pump pull bypass tube out of hydraulic fluid reservoir and replace cap to avoid contamination by road dust or debris while driving You may notice that some hydraulic fluid has overflowed onto the ground while cranking This is normal if the reservoir was full See your dealer for service of the slideout system before using again NOTE When the system has been corrected check fluid level and refill as necessary Press the Retract switch for 15 to 20 seconds before attempting to extend the room Then run the room out and in several times to purge any air from the hydraulic system Finally recheck fluid level and fill as necessary Further Information See the HWH Room Extension operating guide included in your Owner InfoCase for fur ther instructions and troubleshooting informa tion SECTION 3 IN CASE OF DRIVING EMERGENCY HAZARD WARNING FLASHER The hazard warning flasher provides addi tional safety when the vehicle must be stopped on the side of the roadway and presents a possible hazard to other motorists When the flasher 15 on it serves as a warning to the other drivers to ap proach and overtake your vehicl
39. from the shower faucet assembly The dripping results when vacuum in the shower hose after closing the shower faucet slowly releases and allows water remaining in the hose to drain down This is a normal function of the shower valve assembly and is not a leak or defect The International Association of Plumbing and Mechanical Officials Standard TSC 21 85 PAR 4 3 states Shower heads which incorporate shutoff valves shall have a minimum drip rate of one 1 quart in thirty 30 minutes If items are placed into the shower tub before shower valve vacuum release is complete they may become wet SECTION 7 PLUMBING SYSTEMS 9 EXTERIOR SHOWER WASH STATION The exterior shower wash station feature allows you to do things such as rinse off sand or salt after a swim rinse off muddy boots or bath your pet outside the coach The shower is located in the service center compartment on the left side of the coach just ahead of the rear wheels A A 27 V WASTE WATER SYSTEM HOLDING TANKS The drainage system 1s self contained and uses two separate holding tanks to contain the waste water until 1t can be dumped at an appro priate waste water disposal site This means you can use the toilet sinks and shower even in areas where utility hookups are not available The main holding tank contains the sewage from the toilet
40. heating system Capacity 10 gal The optional 10 gallon gas electric water heater has a dual power feature It can operate from LP gas or 110 volt house current or it can use both at the same time for quicker recovery at times when you are using a lot of hot water Read the Atwood Gas Water Heater Installa tion and Operation Manual for complete Safety Warnings Operating Instructions and Mainte 8 8 nance Information before operating the water heater Be sure the water heater is filled with water before starting either electric or LP operation To fill the water heater turn the Water Pump switch on and open a hot water fau cet anywhere in the coach When water begins to flow steadily from the faucet the water heater 15 full For Electric Operation Turn on the Water Heater electric element switch The shoreline must be connected for electric operation For LP Gas Operation Press the Water Heater switch on the Monitor Panel The Pilot Out light will glow for about 10 15 seconds then it will go out The Heater On indicator will remain lit If the Pilot Out light comes on during LP operation it means that the burner has gone into lockout mode and must be restarted If this happens turn the Water Heater switch off for about 5 minutes then turn it back on See the Atwood user s guide in your Owners InfoCase for further information For Quick Recovery Operation Dual Turn On both
41. home is equipped with one of these types of emergency exit windows in the rear of the vehicle that functions as an escape exit in an emergency situation Side Escape Window The side mounted escape window is secured by two red safety latches and can be opened by first releasing these two latches and then pushing outward on the lower part of the window Identi fy which type of emergency exit window 15 in your vehicle Instructions for removal are also located near the latches for quick reference and for passengers who may not be familiar with the exit Never re move or destroy this label il 11142 nal Went Lift Both Handles Up Push Out on Bottom of Window Rear Escape Window To open pull on the red plastic loop at the bot tom of the window until the rubber cord 1s com pletely removed This allows the window to be pushed out SECTION 1 SAFETY PRECAUTIONS A Instructions for removal are also located on a label on the glass for quick reference and for pas sengers who may not be familiar with the exit Be sure this label is never removed or destroyed 4 WARNING Use emergency window for emer gency exit only Do not test for proper operation If the cord is released by accident but the glass remains in place the cord can be replaced using a blunt instrument preferably one made of plastic We suggest you contact your dealer for assistance WARNING Us
42. in a cool place on a wooden or rubber pad to inhibit conductive transfer Check the state of charge periodically to avoid discharge or sulfating To ensure that the battery will always accept and hold a charge follow these simple mainte nance practices Make sure the batteries always remain se curely clamped the battery tray Make sure battery cable clamps are tight on the terminal posts and are free of corrosion Neutralize corrosion buildup or acid film on top of battery by washing with a baking soda water solution Rinse with clear water NOTE Make sure vent caps are on securely to prevent baking soda solution from enter ing the battery and contaminating the electrolyte fluid Before removing any battery cables battery make sure all 12 volt equip ment in the motor home is off and the power cord has been disconnected Replace any damaged cables at once Always remove jewelry and wear pro tective clothing and eye covering when checking or handling batteries Refasten the retainer strap when returning the battery to the compart ment Clean and tighten battery terminals and have the specific gravity checked at least once a year Every two months or more often in hot weather check the battery fluid level to approximately 3 8 inch above the plates DO NOT OVERFILL If fluid is added during freezing weather the motor home should be driven several miles to mix water and electro lyt
43. is loose or too tight after closing the buckle release the buckle and pull the loose end of the strap in or out to adjust tension as needed Then reclose the buckle To Extend Slideout Room e Level the coach e Set the Parking Brake An interlock relay sys tem will then provide power to the slide out control switch e Press the Slideout switch and hold until the room is fully extended then release the switch To Retract Slideout Room e Set the Parking Brake to provide power to the slideout control switch e Press Slideout switch and hold until room is fully retracted then release the switch Although there is an awning over the roof of the slideout room there is a possibility of debris getting onto the roof Because the slideout roof is drawn into the interior of the coach when retracted be sure there is no debris such as excessive dirt tree seeds twigs leaves etc on the roof before retracting General Slideout Care e Wipe the outer seals occasionally with talc or 303 brand protectant for smooth quiet opera tion e Clean the floors inside before retracting the room to avoid vinyl flooring scratches car pet pile snags e Besure there are no obstructions items at end or behind the driver seat or in compartments Some items could be crushed or cause dam age to floor covering or cabinets when the room is retracted 2 14 e See your authorized dealer for regular main tenance and service
44. is removed from the battery it should be replaced by WARNING Refasten the retainer strap when returning the battery to the compart ment BATTERY STORAGE AND MAINTENANCE the engine alternator or the RV converter sys tem If a battery sits unused for 30 days or more es pecially during warm weather it can develop a deposit of sulfate crystals on the metal plates in side the battery This conditions is called sulfac tion or sulfating and prevents the battery from either releasing or accepting a charge If this con dition occurs the battery must be replaced If a battery does not contain at least 80 charge during freezing temperatures the electro lyte can freeze and crack the battery case The two best defenses against sulfating and insufficient charge are to 1 6 amp turn off the Auxiliary Battery switch to avoid parasitic discharge the trickle discharge caused by directly connected components like LP gas detectors or digital clock dis plays etc and check the battery and recharge as necessary at least once a month during long storage periods Minnie W California Proposition 65 Warn ing Battery posts terminals and related accessories contain lead and lead compounds chemicals known to the state of California to cause cancer and reproductive harm Wash hands after handling Further precautions are Remove the battery from the coach Store it
45. lockout mode Turn the switch off for about 5 minutes then turn back on DIRECT IGNITION GAS WATER HEATER 6 Gallon 1 Place Water Heater switch in the posi tion The switch and WH Pilot light are located on the lower face area of the galley cabinet 8 7 SECTION 8 APPLIANCES amp INTERIOR FEATURES 2 Pilot light stays on longer than 15 seconds place switch position and wait 5 minutes Repeat step one 4 If heater fails to operate due to high water temperature the heater will go into a lockout condition W H Pilot light on When water cools reset by placing switch position for at least 30 seconds then return to position 5 Ifa lockout condition persists contact your dealer an Atwood Service Station or Atwood Service Department Phone 815 877 5700 6 For complete shut down before servicing a Place Water Heater switch in posi tion b Remove red wire from left hand terminal of ECO switch ECO to valve 99 temperature knob or lever 15 fac tory adjusted to its lowest setting We recommend the mid point position between warm and hot as noted above This will provide for energy efficient operation and sufficiently hot water Setting at a higher position will produce a higher temperature and increase the risk of being scalded GAS ELECTRIC WATER HEATER Optional with Motor Aid water
46. many vents are closed however it can cause the air conditioner unit to shut down particularly in high humidity conditions All cooling functions controlling to setpoint have a short cycle protection time delay of 3 min utes There will be no delay if the cycle OFF time exceeds 3 minutes Wr Wa SECTION 8 APPLIANCES amp INTERIOR FEATURES Operation The following chart shows the system functions with the Heat Cool thermostat Disregard refer ences to heat functions when using the thermostat the rear bedroom snows POSITION OF SWITCH SYSTEM HEAT COOL OFF FAN FAN OPERATION No functions occur Air conditioner fan runs at high specd continuously regardless of fan switch setting or sctpoint No other 2 m functlons occur Air conditioner compressor high speed fan and furnace high speed if so equipped and wired cycle to satisfy setpoint Air conditioner compressor low speed fan and furnace low speed If so equipped and wired cycle to satisfy setpolnt Air conditioner compressor cycles to satisfy setpoint Air conditioner low speed fan and furnace low speed fan If so equipped and wired run continuously Air conditioner compressor cycles to satisfy setpoint Air conditioner high speed fan and furnacc high speed fan If so equipped and wired run continuously Furnace and furnace high speed blower cycle to satisfy setpoint Fur
47. may contain fire retardant and lightfastness additives which can be damaged by use of improper clean ing products Some water based household cleaning products are not formulated for use on fabrics and may cause excessive shrinkage or fading Always test any cleaning product hidden area of fabric before using on visible ar eas For best results fabric cleaning should be re ferred to a professional carpet and upholstery cleaner NOTE To minimize fading of upholstery car pets and other interior fabrics caused by excessive sunlight the drapes blinds or shades should be closed when the motor home is parked for an extended period of time WARNING When cleaning upholstery and fab ric do not use lacquer thinner nail polish remover laundry soaps or bleach Never use carbon tetrachlo ride gasoline or naptha for any cleaning purpose These materials may cause damage to the material being cleaned and most are highly flammable Spots and Stains Spots or stains should be treated as soon as possible before they set in to avoid permanent damage Always start from the outside of a spot or stain and work inward to avoid spreading it Use a clean cloth or sponge and turn frequently to an unused area of the cloth or sponge as you clean Some stains or soils such as lipstick ink grease or mustard are extremely difficult or impossible to remove completely and should re ceive immediate attention Consult a
48. position WARNING Do not use steps unless it 15 fully extended Do Not Stand on step when vehicles ignition switch is turned to either the On or Start position The step will automatically retract which may cause personal injury Always remember to retract the step before moving the vehicle For additional information on the step see the step manufacturer s operators manual included in your Owners nfoCase The driver and co pilot seats may be indepen dently adjusted to suit individual preference To recline the seats Lift the reclining lever lean back to desired incline and release the lever To return to the upright position lift the lever and lean body forward Allow the seat to return to the desired position and release the lever 2 5 SECTION 2 DRIVING YOUR MOTOR HOME Seat Recline Lever Seat Position Adjustment Bar Lift to slide foward back To slide seat front back Lift the seat adjustment bar and use body pressure to adjust the forward rearward position of the driver seat Release the bar to lock seat in desired position A WARNING Do not adjust driver s seat while vehi cle is in motion After adjusting seat always use body pressure to make sure slide and swivel locking mechanism have engaged 2 6 If your model has a dinette seat located di rectly behind the driver or passenger front seat the dinette seat back is hinged and can be folded
49. product and void the warranty ES RANGE AND REFRIGERATOR For care and appearance maintenance of the range and refrigerator refer to the operation and maintenance manual for each of the individual appliances included in your Owner InfoCase 1 BATHROOM The tub and shower walls in the bathroom should be cleaned with a mild soap and water so lution or to obtain maximum luster use a good quality wax cleaner Do not use an abrasive cleaner on the shower walls and tub If the show er has a glass door it is extremely important that abrasives not be used Use only a good quality glass cleaner or mild detergent and water solution with a soft cloth to clean glass surfaces The bathroom lavatory cabinet sink is made of the same composite material as the galley sink Do not use abrasive cleaners harsh detergents or solvents Refer to the Galley Sink Care and Cleaning Instructions For instructions on the care of your fresh wa ter toilet refer to the information in your Owner InfoCase DOORS AND WINDOWS Windows may be periodically cleaned with a good quality glass cleaner or mild soap solution using a soft cloth Use care when removing ice or frost from the windows Always use a plastic ice scraper never one made of metal Use care when removing ice from the mirrors to protect the re flective surfaces Door locks and hinges should be lubricated periodically with powdered graphite to ensure trouble fr
50. professional carpet and upholstery cleaner for assistance Nine Wimme Vinyl should be cleaned with a soft damp cloth and a mild detergent only Do not use sol vents Solvents may damage the surface of the vinyl Draperies Curtains and Bedspreads These items may be woven from a variety of fabrics We recommend that these be profession ally dry cleaned only A five percent shrinkage may occur when you have these items dry cleaned Care of Ceiling Fabric While using your coach your ceiling fabric may become soiled and require spot cleaning from time to time The following information 1s provided as a guideline for care and cleaning of ceiling fabrics used your coach See cleaning chart on following page These materials are made from polypropylene or polyester synthetic fibers so they clean very well with virtually no damage to the color or fabric itself Most commercially available carpet and up holstery cleaners will do an excellent job remov ing stains From time to time additional cleaning methods may need to be used to remove stubborn or difficult stains General Stains As with any stain or contamination the quick response 15 the best especially when done 1 con junction with the proper cleaner for the type of stain SECTION 9 CARE amp MAINTENANCE 9 3 9 CARE amp MAINTENANCE mE Minne W IMPORTANT Make sure you have selected the right
51. registered by a sending unit on the tank The gauge mounted on the side of the tank will give a more accurate indication of actu al tank level if needed Water Pump Switch When use of the self contained water system is desired turn the Water Pump switch on The Pump On light will illuminate when the pump switch is on and the system is operable Water will be available as soon as a faucet is opened Refer to Fresh Water System for additional in formation on the water pump and initial start up SECTION 8 APPLIANCES amp INTERIOR FEATURES ER LEVELS WATER TEST PUMP PUMPON Battery Condition Meter Push the Levels Test button to check the level of charge voltage in the 12 volt coach battery The colored segments red yellow and green will light from the bottom up to the amount of charge the battery contains Green good or adequate charge Yellow marginal charge Red battery needs charging before use Water Heater Switch and W H Pilot Indi cator Be sure the water heater is filled with water before pressing this switch To fill the water heater turn the water pump switch on and open a hot water faucet until water begins to flow The W H Pilot light will glow for about 10 15 seconds after the water heater switch is turned on then it will go off If the W H Pilot light comes on during normal operation it means that the burner has gone into
52. start the LP gas furnace to assist the heat pump if room temperature cools to 5 degrees or more below the thermostat set temperature You may wish to manually switch to furnace heat to maintain a higher temperature when outside tem peratures begin to reduce the efficiency of the heat pump The heat pump will not operate when the outside temperature falls below 36 degrees F To operate the heat pump Slide the Thermostat switch to Electric heat mode SECTION 8 APPLIANCES amp INTERIOR FEATURES e Ifthe inside temperature is 5 degrees more below the thermostat set point both the heat pump and the furnace will run initially to bring the interior temperature up to the set point as quickly as possible If the inside temperature is 4 degrees or less below the set point then only the heat pump will run ini tially When the thermostat is satisfied the heat pump and furnace will both shut off When the thermostat calls for heat again only the heat pump will run The heat pump will remain the sole heat source unless it cannot maintain the inside temperature If the inside temperature falls five degrees below the set point the furnace will assist the heat pump until the set point 15 reached If the furnace must assist the heat pump three times in a row the thermostat will shut down the heat pump for two hours and the furnace will take over as the heat source After two hours the heat pump will become active a
53. stored or water heater will be Off during freezing temperatures See Draining and Storage Instructions in Atwood Water Heater Operation Manual in your Owners InfoCase Water Heater Pressure Temperature Relief Valve On occasion water may be seen seeping from the water heater pressure temperature relief valve This is no cause for repair or replacement of the valve P T Relief Service Access Exterior Valve Water Heater Normally there is an air gap at the top of the water heater tank which acts as a pressure buffer In time however heated water may expand and fill this air gap causing a slight increase in water pressure This may cause the P T valve to weep until the air gap 15 manually replaced To Replace the Air Gap 1 Turn off the water heater switch and incom ing water supply city water and or demand pump 2 Open a faucet in the motor home to relieve water pressure 3 Pull the handle of the P T valve straight out and allow water to flow until it stops 8 9 SECTION 8 APPLIANCES amp INTERIOR FEATURES Lift straight out to open P T valve 4 Let the handle of the P T valve snap shut 5 Close the faucet and turn on the water supply before switching the water heater on Manually operate the pressure temperature re lief valve at least once a year OPERATE THIS VALVE ONLY WHEN THE WATER HEAT ER AND COOLING SYSTEM ARE COLD Leave by pass valve handle in NOR MAL FLOW position if d
54. the city water connection in the utility compartment on the left side of your vehicle 3 Turn on the external water source Ar City Water Connection When connected to an outside source of water the water bypasses the demand pump and storage tank and supplies pressure directly to individual faucets and toilet A check valve built into the pump prevents water from entering the pump and filling the storage tank NOTE Because the city water pressure varies from location to location we recommend using an in line water pressure regulator to prevent damage to any components connections and seals your fresh wa ter system A water pressure regulator may be ob tained from any well stocked RV dealer ship retail center and some retail discount centers These devices simply connect in line between the supply hose and the city water input on the coach We recommend a regulator that controls water pressure to 40 psi maximum To disconnect from the external source 1 Turn the external source off 2 Open a faucet inside the vehicle to relieve line pressure 3 Disconnect the hose from the coach 4 Stick your finger up inside the connection and gently press the backflow valve upward to drain any water left in the line 5 Replace the protective plug back into the threaded collar on the connection SHOWER VALVE PRESSURE BLEED OFF After using the shower you may notice water dripping
55. the coach straight ahead until only the rear wheel dual set is on the scale pad as shown Weighing Left Rear Corner After the rear wheel set has been weighed turn the coach around and repeat this process for the other side The load on each wheel or dual wheel set should not exceed one half of the corresponding GAWR For example if the GAWR for the rear axle is 12 000 Ibs then the load on each rear dual set left rear duals or right rear duals should not exceed 6 000 Ibs Tires should be filled to the recommended air pressure for the highest loaded tire set on that axle For example on the rear axle if the left side weighs more than the right fill the left tires to the pressure required for that weight then fill the right tires to the same pressure as the left ones NOTE The Hitch Load from a Towed Vehicle or carrier box must also be counted on the Rear GAWR and subtracted from the rear axle cargo capacity SECTION 4 TRAVELING WITH YOUR MOTOR HOME BELTED SEATING POSITIONS MAY EXCEED SLEEPING CAPACITY OF THIS VEHICLE SEE OWNERS MAN UAL FOR OCCUPANCY AND WEIGHT RESTRICTIONS The number of belted seating positions in your motor home may exceed the number of people used to determine maximum coach occu pancy called Cargo Carrying Capacity CCC To calculate the CCC Winnebago uses vehi cle sleeping capacity however your coach may be equipped with more belted seating positions than sleeping posi
56. the contact assembly out of the barrel 6 9 SECTION 6 ELECTRICAL SYSTEMS TM Tail lights GD Ground LT Left Turn Brake RT Right Turn Brake A Backup lights EA FRESH WATER SYSTEM The fresh water system provides water to the galley sink shower bathroom lavatory toilet and water heater Water may be supplied by either of two sources awater tank located within the motor home or any external water source to which the motor home may be connected known as city wa 29 FILLING THE FRESH WATER TANK Always fill the fresh water tank at an approved potable water filling facility or a known purified drinking water source The tank may be filled by inserting a hose into the tank fill opening A built in vent prevents the tank from becoming air locked while filling When neither city water nor a hydrant are available a bucket and funnel may be used to fill the tank but this can take a considerable amount of time Model 427P Models 430V amp 431C SECTION 7 W PLUMBING SYSTEMS Pressure for the water system is supplied by a water system demand pump which is fully auto matic after initial priming When a faucet 1s opened the pump begins operation to provide a constant flow from the tank When the faucet 15 closed the pump automatically shuts off WATER PUMP SWITCH The water pump switch is located on the wa ter holding tank monitor panel
57. v VALA Hoop Chair Mount The hoop base of lounge swivel glider 15 mounted to the floor with a clamp as shown Ay CAUTION The chair must be clamped back into place and the glide mechanism locked before driving the coach SLEEPING FACILITIES The clamp knob can be unscrewed and re moved to allow you to position the chair as you A desire in the living area of the coach Do not use sleeping facilities while vehicle 15 moving OVERHEAD FRONT BUNK if equipped The overhead front bunk is located above the driver s compartment The rear mattress section is stored on top of the front section when not in use A bunk ladder supplied can be hooked into 8 17 SECTION 8 APPLIANCES amp INTERIOR FEATURES the brackets on the rear edge of the mattress for To Revert to Couch easier access and exit 1 Fold mattress forward from the wall to return the seat cushions upright 2 Pull the front of the couch upward and push in toward the wall at the same time until fully seated against the wall 3 Place the backrest cushions in their original locations Presto Bed Shock Bed To Convert Couch to Bed Pull the front edge of the couch seat upward and outward from the wall while gently pushing S _ downward on the backrest until the cushions Se flat The bed is now ready for use Front Overhead Bunk Shown with mattress sections in use position To Revert to
58. will not resume until batteries again fall below full charge The converter will not overcharge the batteries If your storage battery does not charge as described above it is possible the battery is de fective Thermal Breaker A protective thermal breaker will break the 110 volt AC power to the converter section of Power Center if the power converter becomes overheated This can result from operating above its maximum limit for an extended period of time or by obstruction of ventilation to unit NOTE Power converter section will automati cally route 12 volt lights and motors to battery power in this event The thermal breaker will reset itself after a pe riod of time and the lights and motors will again resume operation from power converter section If the breaker trips again shortly after reset take SECTION 6 ELECTRICAL SYSTEMS immediate steps to correct cause of overheating A portion of RV 12 volt load lights or motors or both should be turned off to reduce total load Also inspect power converter section to make sure ventilation 1s not obstructed NOTE The converter will not change 12 volt DC current to 110 volt AC 110 VOLT CIRCUIT BREAKERS The breaker panel protects all 110 volt com ponents the motor home from either an over load on the circuit or a short in the wiring or component itself When an overload or short de velops the breaker will open preventing any fur ther flow of electri
59. 1s not recom mended the GCWR will equal the GVWR NOTE See the Ford Recreation Vehicle and Towing Guide for maximum towing ca pacities GCWRs These guides are available from your local Ford dealer Your cargo capacity will vary according to the options equipped on your vehicle and your additional equipment and components not sup plied with the vehicle Do not exceed any of the recommended weight ratings NOTE We recommend that you dump all hold ing tanks before traveling to avoid car rying unnecessary weight The weight of the loaded vehicle including options attachments pas sengers water fuel luggage and all other cargo must not exceed the GVWR or GAWR of either axle FRONT AXLE TIRE ALIGNMENT We recommend that you have the front sus pension and steering alignment checked and adjusted after you have fully loaded the vehi cle according to your needs Thereafter have alignment inspected periodically to maintain vehicle steering performance and prevent un even tire wear WEIGHING YOUR fa LOADED VEHICLE To check the weight of your fully loaded coach locate a commercial weighing scale that is capable of weighing large trucks Drive the entire coach onto the scale This weight should not exceed the Gross Vehicle Weight Rating GVWR specified on the Vehi cle Certification Label near the driver seat See sample in the Introduction Section 4 1 SECTION 4 TRAVELING WIT
60. 1s that of the weather Whether you travel the high mountain terrain the lower deserts and flatland or the plains of the midwest the weather is always with you and subject to change sometimes with little or no warning However adequate warnings are normally broadcast over local radio and sta tions Motor home travelers and campers often seek secluded areas for weekend recreation or extend ed summer vacations Many recreational areas are vulnerable to severe weather situations espe cially flash flooding conditions A few simple precautions may help lessen the hazards of flash flooding or reduce your immediate involvement NOTE We recommend that all motor home oc cupants become familiar with these safe ty precautions and be alert to change in weather e Be alert because thunderstorms can form at any time in any month of the year Thunder storms can produce large amounts of rain over a small area in a short time which may result in a flash flood Listen frequently to weather reports on the radio for weather and flood conditions e When camping near a stream leave plenty of sloping bank between you and the stream 4 6 e Avoid deep canyons and dry washes during stormy or threatening weather Be aware of alternate exits Mme e Ifheavy rain occurs move to high ground im mediately at least 30 40 feet above the can yon floor or bottom of dry wash e During a flash flood if you cannot move you
61. ANDARDS IN EFFECT ON THE DATE OF MANUFACTURE _ SHOWN ABOVE SERIAL NO _ EXPLANATION OF DATA 10 Serial Number This is the serial number 1 Chassis manufacturer assigned to the completed vehicle by Win 2 Chassis manufacture date nebago Industries 3 Month and year of manufacture at Win 11 Vehicle Identification Number VIN This nebago Industries number identifies the chassis on which the 4 Gross Vehicle Weight Rating Total permis motor home is built The 10th digit of the sible weight of the vehicle including driver VIN designtes the chassis model year passengers total cargo carried including all 2 2002 3 2003 4 2004 This informa liquids and equipped with all options tion is useful when ordering chassis repair 5 Gross Axle Weight Rating Total permissi parts ble weight allowed for the front and rear 12 Type States the NHTSA designated usage axles listed in pounds and kilograms classification for your motor home MPV 6 Suitable Tire Choice Tires recommended to signifies a Multi purpose Passenger Vehicle meet handling and safety requirements 13 Model Lists the Winnebago product model When replacing any of the tires on your number of your vehicle vehicle always replace with a tire that meets 14 Color Signifies the color code number of the these specifications decor used throughout the vehicle This 7 Suitable Rim Choice Wheel rims recom number is necessary for ordering replace mended to meet handling
62. Couch Push the front edge of the seat toward the wall while lifting upward on the backrest until the couch 1s fully seated against the wall DINETTE BED CONVERSION To Convert Dinette to Bed 1 Lift the seats and remove the seat support bumpers to allow the seats to lie flush for Front Bunnie use as a bed Do not lose bumpers because you must refit them when reverting back to dinette seat configuration Shown hooked into mattress bracket COUCH BED CONVERSIONS Continental Bed To Convert Couch to Bed 1 Remove the backrest cushions from the couch 2 Grasp the front edge of the couch and pull upward and outward from the wall at the same time 3 Lift the front edge of the seat cushion and unfold it toward the wall until it lies flat forming a sleeping surface 2 Release the catch on the table leg brace and fold the leg up against the bottom of the table Remove the table from the wall support bracket by lifting the end of the table Then lower the table to rest on the cleats attached to each dinette bench To Revert to Dinette 1 Replace the table onto the wall support lower the table leg SECTION 8 APPLIANCES amp INTERIOR FEATURES 2 Make sure that the table leg is secured into the floor support bracket and the leg brace is locked SLEEP NUMBER BED Optional by Select Comfort NOTE Before Traveling If you pl
63. DRIVING EMERGENCY CONNECTING A BATTERY CHARGER To connect a battery charger first make sure the engine is switched off Disconnect the posi tive lead from the battery Never disconnect the battery while the engine 15 running or alterna tor damage could result Connect the positive red lead of the charger to the positive terminal on the bat tery Next connect the negative black lead of the charger to a suitable ground Finally plug in or switch on the charger To disconnect the charger after charging un plug the charger from the electrical outlets re move the charger leads from the vehicle and reconnect the vehicle leads to the battery ENGINE OVERHEAT If you see or hear steam escaping from the ra diator or the engine compartment or have any other reason to suspect an extreme engine over heating condition pull the vehicle over to the roadside as soon as it is safe to do so stop the en gine and get out of the vehicle WARNING Operating a vehicle under a severe overheating condition can result in damage to the vehicle and may result in personal injury An engine will overheat if the coolant 15 low or there is a loss of coolant because of one or more of the following aleak in the cooling system ahose failure adrive belt breaking water pump failure Also be aware of the following situations which can cause temporary engine overheating c
64. ERING YOUR VEHICLE Before entering your vehicle there are a few recommended procedures that will aid your driving safety and equipment 1 Be sure that the windows mirrors and light lenses are clean and unobstructed 2 Make sure all exterior lights operate prop erly 3 Check tires for proper cold inflation pres sures and inspect for any unusual wear 4 Check wheel lug nuts for tightness 5 Look beneath the vehicle for noticeable fluid leakage 6 Check fluid levels and fill if necessary This includes engine oil transmission fluid cool ant brake fluid power steering fluid and windshield washer solvent WARNING The transmission must be P Park and park brake engaged while per forming any checks or adjustments The engine should be shut off unless specifically required for a certain pro cedure 7 Unhook and store sewer and water supply hoses 8 Retract step 9 Be sure that all of your cargo is secured before traveling Be aware of loose items on tables or countertops or free standing furni ture items that could become dangerous pro jectiles during a sudden stop or evasive maneuver 10 Check around your vehicle in all directions to assure that you have proper clearance 11 Lower TV antenna and or satellite dish 12 Disconnect and store shoreline Before driving your vehicle be sure you have read the entire operator s manual and that you understand your vehicle s eq
65. H YOUR MOTOR HOME Loading Load your vehicle completely as if you were going on a long trip with everything you would carry including food clothing bed ding lawn chairs etc a full fuel tank full LP tank and maybe a partial tank of fresh water but empty holding tanks Finding a Scale In urban areas the most common places to find a public access scale are commercial truck stops In rural areas most grain storage elevators have scales available If you don t know of a truck scale in your area look the Yellow Pages for entries such as Grain Elevators Scales Public Truck Stops Weigh Stations etc If you cannot locate a scale in your area call your state DOT and ask for rec ommendations Most scales charge a nominal fee for weighing a vehicle Weighing There is typically a scale opera tor to direct you but the basic routine is to take three separate weights front axle whole vehi cle and rear axle You will first drive only your front wheels on to the scale pad then drive ahead so that the whole vehicle is on the scale then finally pull off until just the rear wheels are on the pad GVWR Both Front and Rear Axles 4 2 Rear GAWR Rear Axle Only You will receive a weight ticket that states your current Front Gross Axle Weight Rear Gross Axle Weight and Gross Vehicle Weight You can compare these weights to the weight ratings listed on your Vehicle Certification Label to use as a g
66. ITE arrows to provide ignition spark 2 While rotating the gnitor knob turn the desired Burner Knob to the LITE position 3 When the burner lights release the Ignitor knob and turn the Burner knob to the desired flame height SECTION 8 APPLIANCES amp INTERIOR FEATURES Rotate Ignitor Knob while Burner Knob is in LITE position WARNING Do not turn burner control knob to On and allow gas to escape before lighting match Lighting Oven Pilot NOTE Ifrange has not been operated for a long period of time a longer waiting period for ignition of the pilot may be necessary due to air in the gas line 1 sure all valves are in the OFF Position The oven control knob should be in OFF position 2 Turn on main gas sup ply to range 3 Press and turn control knob to the PILOT position This will allow gas to oven pilot 4 Open oven door and light oven pilot with a match Small flame will be noted at the top of the pilot burner OFF Oven Control Knob in OFF position Oven Control Knob in PILOT ON position 8 5 SECTION 8 APPLIANCES amp INTERIOR FEATURES Lighting oven pilot when pilot is located on left side of burner Operating Oven Control Push in and turn the oven control knob coun terclockwise to the desired temperature setting There is a delay of about 45 seconds before the main burner ignites This is normal a
67. If the GFCI keeps tripping have the electrical system checked and repaired if necessary before using again The GFCI outlet is located in the bath bed room or dinette area depending on the floor plan of the vehicle C The GFCI will not completely elimi nate electrical shock Small children and persons with heart conditions or other disabilities which make them especially sensitive to electrical shock may still be injured by a 110 volt receptacles even though pro tected by a Ground Fault interrupter 6 4 HB The GFCI will not completely elimi nate electrical shock Small children and persons with heart conditions or other disabilities which make them especially sensitive to electrical shock may still be injured by a 110 volt receptacles even though pro tected by a Ground Fault interrupter NOTE In compliance with CSA electrical codes the appliance outlet in Canadian equipped coaches is not connected to a protected circuit AUXILIARY 110 VOLT GENERATOR Optional Consult the information provided in your Owner InfoCase for instructions on operation troubleshooting and maintenance WARNING Careless handling of the generator and electrical components can be fa tal Never touch electrical leads or appli ances when your hands are wet or when standing in water or on wet ground Do not attempt to repair the generator yourself Service should be perfor
68. LP gas however there are other combustible fumes or vapors which may be detected by the sensor These include alcohol liquor deodor ants colognes perfumes wine adhesives lac quer kerosene gasoline glues most all cleaning agents and the propellants of aerosol cans Most are lighter than air in their vapor state will only be detected when the area 15 closed up Glues and adhesives may exhaust hydrocarbon vapors for months after they are applied They are easily activated by high temperatures If you close up an RV coach on a hot day the chemicals used its construction may be detected for months after the coach was manufactured Further Information See the manufacturer s information supplied in your Owner InfoCase for further descriptions and directions including monthly testing and troubleshooting WARNING Never use an open flame to test for gas leaks When testing for gas line leaks with a soapy water solution DO NOT use a detergent containing ammonia or chlorine These sub stances may generate a chemical reaction causing corrosion to gas lines resulting in dangerous leak con ditions 1 4 Power Connection The gas alarm is powered by the coach batter ies If the battery cable is disconnected from the batteries auxiliary battery switch 15 shut off or the circuit breaker 15 tripped the alarm will not work The LP gas alarm breaker 1s located on the power converter breaker pan
69. ME See also SAFETY PRECAUTIONS Section 1 of this manual LOADING THE VEHICLE NOTE Your motor home s load capacity is des ignated by weight not by volume so you cannot necessarily use all available space when loading your motor home When loading the vehicle distribute the cargo load equally so that you do not exceed either the Front or Rear Gross Axle Weight Rating GAWR or the Gross Vehicle Weight Rating GVWR The Gross Axle Weight Rating GAWR means the weight value specified by the chassis manufacturer as the load carrying ca pacity of a single axle system as measured at the tire to ground interfaces This 15 the total weight a given axle is capable of carrying Each axle has its own rating Also distribute cargo side to side so the weight on each tire or dual set does not exceed one half of the GAWR for either axle For example if the Front GA WR is 6 000 lbs there should be more than 3 000 165 on each tire If the left side weighs 3 100 165 and the right side weighs 2 700 165 at least 100 Ibs of the load should be shifted from the left side to the right side Have your vehicle weighed to determine the proper load distribution for your vehicle The GVWR 1s listed on the Vehicle Certification La bel See the Introduction Section The GCWR Gross Combination Weight Rat ing means the maximum allowable loaded weight of this motorhome and any towed trailer or towed vehicle If trailer towing
70. NCE DOOR LOCK AND HANDLE The entrance door may be opened from out side the vehicle by pulling the door handle out ward To open the door from inside pull outward on the door handle When the door is locked nei ther the inside nor the outside door handle can be operated It can be locked and unlocked from the outside of the vehicle by inserting the key into the lock and turning 2 3 DRIVING YOUR MOTOR HOME MULE S Deadbolt Lock Bai Door Lock To lock the door from inside rotate the lock levers as indicated The deadbolt lock 15 for add ed security and should be used as a security night lock Deadbolt Door Lock Entrance Door Handle Inside Press lever to separate screen door from main entrance door Screen Door Latch Lubricate the locks periodically with graphite to maintain good working condition Ay CAUTION When releasing security night lock be sure to retract bolt before opening door latch to prevent drag on bolt pin Instruct all passengers in operation of this door catch system as well as emergency exit window DRIVER COMPARTMENT DOOR LOCK Consult your chassis operating guide 7 ELECTRIC ENTRANCE STEP The power switch for the electric entrance step is located to the left of the main entry door as you enter the coach 2 4 Automatic Mode Operates with Door With the Power Switch in the On position the step is in Auto
71. OR DAMAGE TO PERSONAL PROPERTY OR LOSS OF REVENUE RESULTING FROM BREACH OF THIS WRITTEN WARRANTY OR ANY IMPLIED WARRANTY Some states do not allow limitations on how long an implied warranty will last or the exclusion or limitation of incidental or consequential damages so the above limitations or exclusions may not apply to you ITEMS NOT SUBJECT TO WARRANTY COVERAGE Chassis Drivetrain and related components Wheels Tires Service Items such as Windshield Wiper Blades Lubricants Fluids amp Filters Adjustments These items are covered under the manufacturer s individual warranty This warranty gives you specific legal rights and you may also have other rights which vary from state to state Also this warranty shall not apply to failures damage or malfunctions resulting from normal wear misuse abuse negligence alteration accident fire improper repair of the vehicle or failure to follow recommended maintenance requirements 36 MONTHS 36 000 MILE STRUCTURAL WARRANTY At the expiration of the Basic Coverage and for the remainder of the period of 36 months or 36 000 miles 57 924 kilometers on the odometer whichever occurs first Winnebago Industries warrants the following 1 Thermo Panel Lamination of the sidewalls and backwall against delamination Body Thermo Panel Lamination is the bonding of the exterior skin and the interior paneling to an insulating core material Delamination separation
72. OUCH ELECTRICAL SWITCHES SHUT OFF THE GAS SUPPLY AT THE TANK VALVE S OR GAS SUPPLY CONNECTIONS OPEN DOORS AND OTHER VENTILATING OPENINGS LEAVE THE AREA UNTIL ODOR CLEARS HAVE THE GAS SYSTEM CHECKED AND LEAKAGE SOURCE CORRECTED BEFORE USING AGAIN FAILURE TO COMPLY COULD RESULT IN EXPLOSION RESULTING IN DEATH OR SERIOUS INJURY WARNING Never use an open flame to test for gas leaks When testing for gas lines leaks with a soapy water solution DO NOT use a detergent containing ammonia or chlorine These sub stances may generate a chemical reaction causing corrosion to gas lines resulting in dangerous leak con ditions LP GAS ALARM See page 1 2 WINTER USE OF LP GAS Due to vaporization characteristics of LP gas it is important that the winter camper knows how to most efficiently use the LP system The vapor ization rate of LP gas decreases in a direct rela tionship to a decrease in temperature Propane will convert to a usable gas at temperatures down to 44 F For this reason propane is a popular heating fuel in cold climates However even pro pane vaporizes at a slower rate as it becomes colder The greater the amount of liquid gas in the tank up to 80 level the greater the amount of LP gas vapor generated The following 15 an ex ample of the number of BTU s available from an 84 pound tank at 0 F at three levels As you can see the number of BTU s decreases as the tank
73. Observe the engine temperature gauge more frequently than normal If overheating occurs pull off to the side of the road and allow the engine to thoroughly cool before refilling the radiator and restarting the engine Descending A Hill When going down a long grade you may need to manually shift to a lower gear rather than keeping your foot on the brake pedal A lower gear will allow the engine to provide a degree of braking action Holding your foot on the brake pedal for an extended period may cause brakes to overheat causing you to lose control of the vehi cle See your chassis operating guide for more in formation CAMPSITE SET UP Try to pick as level a spot as possible on which to park your motor home Leveling the motor home is very important not only for your comfort but for plumbing and appliances as well Some refrigerators are ex tremely sensitive to being off level The ammonia vapor cooling system used in most RV refriger ators can lock up and damage the refrigerator 1f it is not level This is both inconvenient and cost ly Also water and holding tank level indicators may give false readings because water level 15 greater at one side of the tank than the other Blocking A motor home can be leveled using several methods including sophisticated electronic hy draulic systems The most common and inexpen sive method however 1s blocking This is done by stacking various lengths of plankin
74. Off Pilot posi tion If this step is not performed LP gas could accumulate inside the motor home creating a fire or explosion hazard Overflow Main Tank Supply Valve Valve ets 4 Rin tA ey Mi ey Tank Valve Gauge Pressure Regulator LP Gas Tank Capacity 14 4 gal 18 gal w c All Models LP Gas tank capacity shown is the usable full LP gas capacity which is 80 of the tank manu facturer s listed water capacity w c shown parenthesis An LP tank must have at least 20 of tank volume free to allow for expansion and proper ventilation of the liquid fuel The tank is also equipped with mandatory safety shut off equipment that prevents filling above this level REFILLING LP TANK There are many LP gas refueling stations lo cated throughout the country These stations are listed in the telephone directory Yellow Pages under Gas Liquefied Petroleum Bottled and Bulk Since the LP tank is permanently mounted to the frame the motor home must be taken to an LP dealership for filling Do not attempt to remove the LP tank from the vehicle The tank 15 equipped with a fill adapter with both internal and external threads which allows easy filling with any LP filling equipment The tank is full when liquid LP gas appears at the overflow valve NOTE The LP tank is
75. SATION Moisture condensing on the inside of win dows 1s a visible indication that there 1s too much humidity inside the coach Excessive moisture can cause water stains or mildew which can dam age interior items such as upholstery and cabi nets When your recognize the signs of excessive moisture and condensation in your coach you should take immediate action to minimize their affects You can help reduce excessive moisture in side the motor home by taking the following Steps Ventilate with outside air Partially open one or more windows and a roof vent to circulate out side air through the coach In cold weather this ventilation may increase use of the furnace but it will greatly reduce the condensation inside the coach Minimize moisture released inside the coach Run the range hood fan while cooking and open a bath vent while bathing or showering to carry water vapor out of the coach Avoid making steam from boiling water excessively or letting hot water run Avoid bringing extra moisture into the coach by way of soaked clothing or snow on shoes Do not hang dry wet overcoats or clothing inside the coach NOTE Your coach is not designed or intended to be used as permanent housing Using this product for long term occupancy or permanent housing may lead to prema ture deterioration of structure interior finishes fabrics carpeting and drapes Damage or deterioration due to long term occupancy may not be consid
76. See Section 8 While the switch is in the ON position the pump will automatically supply water pressure as it is needed It 1s recommended that the pump switch be turned off whenever you are away from the vehicle or not using the water system A slow leak in a faucet could drain the water system and discharge the house battery RS ER LEVELS WATER TEST PUMP PUMPON INITIAL START UP 1 Make sure that all water drain valves are closed including water heater valve Refer to Section 10 Turn water pump switch to OFF position Fill water tank Open all faucets hot and cold Turn on pump switch Close each faucet as it begins to deliver a steady stream of water close cold water first Leave hot water faucets on until they ee 7 1 SECTION 7 PLUMBING SYSTEMS also deliver a steady stream of water This will ensure that the water heater 1s filled with water 7 Check to be sure pump stops soon after all faucets have been closed 8 Pump is now ready for automatic operation Pump will start when a faucet is opened and stop when the faucet 15 closed DISINFECTING FRESH WATER SYSTEMS ON RECREATION VEHICLES As approved by the U S Public Health Service To assure complete disinfection of your fresh water system it is recommended that the follow ing procedure be followed on a new system one that has not been used for a period of time or one that may have become contaminate
77. WER Rear Helper Spring Air Valves located inside water center NOTE Your motor home s load capacity is designated by weight not by volume so you cannot necessarily use all available space when loading your motor home See page 4 1 for more information WINDSHIELD WASHERS AND WIPERS See your chassis operating guide for recom mendations and precautions regarding washers and wipers All exterior lights should be checked for prop er operation each time the vehicle is prepared for a trip Any bulbs which fail to light should be checked and replaced when necessary with a new bulb of the same size A failure of more than one light such as both taillights not operating may indicate a burned out fuse Check fuse and replace with one of the same rating when neces sary If a fuse is not the cause of the problem the mme wiring system should be checked immediately by an authorized service center The headlight circuit is protected by a circuit breaker An overload on the breaker will cause the lights to flicker on and off Headlight wiring should be checked immediately anytime this con dition is apparent Refer to your chassis operating guide for further information AUTOMOTIVE 12 VOLT FUSES AND CIRCUIT BREAKERS The automotive fuses and breaker are protect ed from short circuit and overload conditions by a fuse block On most models this 15 located be neath the dash to the left side of the steering col
78. Water 8 22 Front Axle Tire 4 1 Puech Sc IS 1 2 Fuel Pump Shut Off 2 3 INDEX FUG Selecion 2 2 Fuel Tank Capacity 2 2 Fuse or Circuit Breaker 6 7 G Galley 9 6 Gas Electric Water Heater 8 8 Gasoline 2 2 General SCANS 9 3 General 9 3 1 1 Generator Hourmetet 6 6 Ground Fault Circuit Interrupter 6 4 H Harzard Warning 1 3 Hazard Warning 16 2 3 FAG AG PUMP iciessestdonaseseusvestendevedebeastedeseasessaa bees 8 11 Holding Tank Level 7 5 Hoop 8 17 Bale eS n EA AT 6 6 How LP 5 1 Humidity and Condensation 4 8 Humidity Storage 1 8 3 I Pane 2 9 3 3 K casted sth 2 2 L 2 7 Lap Sh
79. able at most RV supply centers e Don t dispose of sanitary napkins or other non dissolving items in the toilet e Don t put automotive antifreeze or caustic chemicals such as laundry bleach or heavy detergents into the toilet or holding tank These products may damage plastic or rubber parts in the system Cleaning the Toilet The toilet should be cleaned regularly for maximum sanitation and operating efficiency If an odor is apparent from the toilet 1 Clean the toilet bowl with a mild bathroom cleaner Do not allow cleaners to set in the bowl for long periods of time to avoid dam aging the seals Do not use caustic or abra sive cleaners because 1 may damage the plastic surfaces 2 Dump and rinse holding tank 3 Add odor control chemical in amount speci fied after cleaning and every few days during use 4 Remove the water line from the base of the toilet and clean the screen 5 Ifthe flush valve becomes stiff after extended use it may be lubricated with a sil icone spray Turn the water pump off and operate flush pedal to drain water from the toilet bowl Spray silicone lubricant onto flush valve inside bowl and operate flush pedal a few times to ensure free operation See instructions in Section 10 to prepare the toilet for storage in freezing conditions POWER ROOF VENT Bath Area A push button switch for the vent fan 15 locat ed up on the vent The vent dome can be raised and lowered using the crank ha
80. alled tank gas bottle gas or simply LP LP is used by appliances vapor form only but is stored the tank as a liquid under very high pressure As the liquid gas is released it re verts back to a vapor and expands to many times its compressed volume 5 1 5 LP GAS SYSTEM SELECTING LP FUEL TYPES We recommend using straight propane in your LP tank Propane gas is commonly available at all LP gas outlets in the U S According to the National LP Gas Association LP gas outlets in the United States do not offer any other type of liquefied petroleum gas than propane to the gen eral public Check local phone directory yellow pages for locations of local LP gas refilling sta tions or bulk dealerships NOTE If you travel outside the U S with your motor home you may find butane or pro pane butane mixtures available in addi tion to propane Because gas burning RV appliances are designed to run on propane only we recommend that you request straight propane only Butane burns about 30 percent hotter than pro pane and can overheat some appliances particularly refrigerators and cause permanent damage Other appliances designed to operate on propane can be come sooted and lose efficiency by using butane fuel Propane is commonly available in most loca tions LP gas used as a motor vehicle fuel for tractors generators forklifts etc must be pure propane so even in areas where butane mixtur
81. aminate that resists sol vents stains and abrasions A coat of furniture wax applied to these surfaces on the counters and table will help preserve their beauty and make cleaning easier Always clean the surface before applying wax CARE AND MAINTENANCE OF YOUR SOLID SURFACE COUNTERTOPS You can easily maintain the beauty of your countertop with little effort under most circum stances using a window spray cleaner warm soapy water or other general purpose spray clean er You can also use liquid or gel type cleaners containing bleach Because the material is non porous stains cannot penetrate below the surface and will nearly always disappear using these cleaning methods If a stain has dried on allow the cleaner or soapy water time to soften the area after which the stain will wipe off If the stain is not water base or oil base material you may need to gently remove it using a plastic scraper disposable plastic knife for example followed by normal cleaning methods described above You may want to scrub the entire surface odically Do this lightly and evenly with a mild abrasive cleaner such as Soft Scrub Bon Ami Barkeeper s Friend Always use a cutting board rather than slicing foods directly on your countertop The underside of one of your sink covers will provide an easily accessible cutting surface This will keep your 9 5 SECTION 9 NJ CARE 6 MAINTENANCE countertop looking its b
82. an to travel with your Sleep Number mattress into mountainous regions either 1 tempo rarily disconnect the mattress from the pump hose to allow air to escape or 2 partially deflate the mattress chamber Change Sleep Number settings to 20 or lower on both sides before traveling Rapid changes in altitude will affect the air pressure inside the mattress The chamber may be damaged if the pressure becomes too great Unlike innerspring mattresses your Sleep Number bed can be personalized specifically to your ideal comfort level The dual chamber mat tress gives you the ability to enter a different Sleep Number for each side of the bed Since no two body types are the same each sleep partner should personalize their side of the bed with their own Sleep Number SECTION 8 APPLIANCES amp INTERIOR FEATURES What is Your Sleep Number Your Sleep Number is a setting between zero and 100 that represents the ideal combination of mattress comfort firmness and support for your body giving you the best night s sleep possible If you do not have your Sleep Number this sec tion will take you through the process of finding your Sleep Number and will provide you with additional information about your Sleep Number bed Using Your Sleep Number Remote The buttons of the remote are contoured to be easily distinquished even the dark if neces sary The firmer button has a slight dome shape and the softer button
83. and controls in this coach Some equipment such as the vehicle chassis and certain electronic systems or appliances have their own comprehensive manufacturer supplied manuals or information sheets which describe operation of these products in great detail This manual will refer you to the manufacturer s in formation included in your Owner JNFOCASE whenever necessary SUBJECT ICONS To make it easier for you to find information you re looking for we have placed convenient pictorial symbols called icons beside many of the subject headings in this manual The icons correspond to the subject matter of the section These icons were designed similar to the familiar international symbols which identify public facilities such as restrooms and handicap access There are several examples of icons on this page PAGE ICONS The icons at the upper cor ners of each page correspond to the primary con tent of each main section of the manual such as LP Gas Electrical Plumbing etc This means you can flip through the manual either forward or backward and know exactly which main section you are looking for just by watching the icons at the top of the page This means less paging back and forth We also urge you to read the complete Chassis Operating Guide provided by the chassis maker and all other operating infor mation provided by our equipment suppliers and manufacturers This is contained in your Owner INFOCASE M Q T
84. and safety require ment cushions curtains carpet etc ments When replacing any of the rims on your vehicle always replace with a rim that meets these specifications 8 Cold Inflation Pressure Inflation pressures recommended while Cold for the tires orig inally equipped on your vehicle These pres sure levels must be maintained to assure proper handling safety and fuel economy 9 Rear Axle Wheel Configuration Single or 0 4 Dual Minne Mii me INTRODUCTION EXTERIOR FEATURE IDENTIFICATION Class C Motor Homes Typical model shown for illustration purposes only Actual locations of features may vary depending on your model and option combinations 1 Roof Access Ladder 7 LP Gas Tank Access 2 Assist Handle 8 Storage Compartment 3 TV Antenna 9 110 Volt Outlet 4 Refrigerator Vent 10 Ext Entertainment Center 5 Roof Air Conditioner 11 Storage Compartment 6 Porch Light 12 Storage Compartment 13 Water Heater Access 19 Fuel Tank Fill 14 Range Hood Vent 20 Storage Compartment 15 Refrigerator Service Access 21 Furnace Intake Exhaust 16 Auxiliary Generator Compartment 22 Storage Compartment 17 Water Tank Fill 23 Storage Compartment 18 Utility Systems Compartment NOTE Some equipment shown may be optional CAUTION Be careful These features may become HOT while water heater or furnace are in use 0 5 Minnie Winnie SAFETY PRECAUTIONS Read and understand all instructions and pre
85. ater Heater 8 7 Gas Electric Water Heater 8 8 MOOT AIC 8 10 Water Heater By Pass Valve 8 10 LP pa SPUPN ACC ane 8 11 Heat PUMP 8 11 Ducted Roof Air Conditioning System 8 12 TV ADON 8 13 TV Signal A Mpera 8 14 Phone and Cable TV Hook Up 8 15 Video Selector 8 15 Satellite Television 8 8 15 DC AC Electrical Voltage Inverter 8 16 Exterior Entertainment Center 8 16 Swivel Glider Lounge 8 17 Sleeping 8 17 Dinette Bed 1 8 18 Couch Bed Conversion 8 19 Fresh Water 8 22 Power ROOF 8 23 Slider 8 23 Day Nighter Pleated Window 5 8 23 Window Roll Up Shade Adjustment 8 23 Quartz Wall 1 8 23 SECTION 9 CARE AND MAINTENANCE 9 1 9 1 ess 9 1 1 9 1 Care of Stripes 15 9 2 Upholstery Carpe
86. bed if needed e achieve a fuller bed appearance Evaluate Your Comfort Level Right e Neck and back are aligned in the same posi tion as when you are upright e No discomfort at shoulder and hip pressure points e You feel the mattress support the small of your back back sleepers or the curve of your side side sleepers Wrong e Body alignment is not straight e Your pillow makes your head tilt at an angle to the rest of your body e You feel discomfort from pressure in your neck shoulders back hips or legs Your pillow should help keep your body aligned properly otherwise it may interfere with your ability to sleep comfortably SECTION 8 APPLIANCES amp INTERIOR FEATURES What if I am not comfortable on the Sleep Number I was given when I purchased by Sleep Number Bed by Select Comfort Since you probably only spent a few minutes getting your SLEEP NUMBER in the store or through other means you may find that you need to explore other settings in order to pinpoint your ideal comfort level Please use the easy step by step process on this page to set your Sleep Number If you still do not feel comfort able after going through this process contact a Select Comfort Customer Service Representa tive at 1 800 318 2231 Please have your Sleep Journal with you when you call so you can tell your representative what settings you have used Why do my numbers fluctuate RV users may find that the n
87. before traveling to avoid carry ing unnecessary weight USING ON SITE SEWER HOOK UPS The drain hose may remain attached to the dump outlet and be routed out the bottom of the 7 4 Mime compartment while the motor home is parked connected to an on site sewage hook up When using a sewer hook up keep the dump valves closed until a tank becomes full or when preparing to leave the site This keeps the solids in suspension allowing them to be carried out with the liquids when the dump valve is opened If the valve is left open the liquids will drain off leaving solids in the tank Should this accidental ly happen disconnect the hose fill the tank about half full with water and drive a few miles to dis lodge the solids A few starts and stops will aid in the process Then reconnect the hose and drain in the normal manner Holding Tank Heaters Optional Your coach may be optionally equipped with black water and grey water holding tank heaters to allow use of waste utilities in freezing temper atures The holding tank heater power switch 1s located near the monitor panel The illuminated switch will glow when the power 15 on DO NOT operate the holding tank heaters un less you are providing a supplemental 12 volt power source to recharge the house batteries This means either the shoreline cord must be plugged into a 110 volt source or the auxiliary generator must be operating or the chassis engine must be r
88. city and therefore damage to the system Shut off the equipment example roof air con ditioner and allow a brief cooling period Then reset the breaker by moving the switch to Off and back to If the breaker is continually tripped and no overload 15 evident have the sys tem checked for a short in the wiring or the appli ances 110 Volt 12 Volt Circuit Breakers Circuit Fuses ni t 111 Power Center Further Information Refer to the converter manufacturer s infor mation provided your Owner InfoCase for additional information about your power con verter system 6 3 6 ELECTRICAL SYSTEMS 110 VOLT RECEPTACLES Outlets A number of standard AC electrical outlets are provided throughout the coach for connecting small appliances such as televisions radios toasters etc Outlets are also located on the out side of the coach near the entrance door GROUND FAULT CIRCUIT INTERRUPTER Exterior bath and galley outlets are connected to a GFCI Ground Fault Circuit Interrupter which is an extremely sensitive circuit breaker that will help to protect against severe electrical shock if a ground fault develops If such a condi tion occurs the GFCI will break the circuit by turning off the power to the protected outlets Should this occur unplug all the appliances on that circuit and press the reset button on the GFCI equipped outlet
89. d This procedure is also recommended before long periods of storage such as over winter 1 Prepare a chlorine solution using 1 gallon of water and 1 4 cup of household bleach sodium hypochlorite solution With tank empty pour chlorine solution into the tank Use 1 gallon solution for each 15 gallons of tank capacity This procedure will result in a residual chlorine concentration of 50 ppm in the water system If a 100 ppm concentration is required as discussed in item 3 use 1 2 cup of household bleach with 1 gallon of water to prepare the chlorine solution One gallon of the solution should be used for each 15 gallons of tank capacity 2 Complete filling of tank with fresh water Open each faucet and run the water until a distinct odor of chlorine can be detected in the water discharged Do not forget the hot water taps 3 Allow the system to stand at least 4 hours when disinfecting with 50 ppm residual chlorine If a shorter time period is desired then a 100 ppm chlorine concentration should be permitted to stand the system for at least 1 hour 4 Drain and flush with fresh water 7 2 Chlorine 1s poisonous recap bottle and clean utensils after use Never use automotive type antifreeze in your potable water system as it is poisonous EXTERNAL WATER SUPPLY City Water To connect to an external source 1 Turn the demand pump switch to off 2 Attach a hose from the external water source to
90. d damage to the heating element 8 Drain the water heater by removing the plug from the base of the water heater tank acces sible from the outside of the coach Requires socket and ratchet Also open the Pressure Temperature relief valve at the top right portion of the tank to prevent air lock ing in the tank while draining 10 1 SECTION 10 STORING YOUR MOTOR HOME Drain Plug P T Relief Valve WATER HEATER SERVICE ACCESS EXTERIOR 9 After water has stopped draining at all fau cets and drain valves connect a blow out plug to the city water connection on the coach Then use a hand pump or air com pressor regulated to 30 psi or less to force air through the system A blow out plug be purchased at any Winnebago or Itasca dealer P N 701705 01 000 City Water Connection Ay CAUTION Limit air pressure to 30 psi to avoid damage to pump or water lines NOTE NOT burst air into the system This can damage the water pump It is better to let air in slowly 10 Let air flow for five minutes until water 15 completely drained out of faucets and drain valves Then close faucets one at a time 11 Operate and hold toilet flush pedal until water is completely drained from toilet 10 2 2 aI a 12 13 14 Now turn air pressure off and disconnect water purge adapters Recap the city water connection to avoid contamination by dirt or insects Close al
91. down to allow full use of the front seat reclining feature Simply remove the seat back cushion and unlatch the bolt latches on both sides of the di nette seat as shown then fold downard Dinette Seatback Latch Remove cushion and unbolt to fold down Dinette seat fold down to allow front seat reclining ARM REST ADJUSTMENT The driver and co pilot seat armrests may be adjusted to rest at two different positions as shown Position I Normal This is the normal de fault position of the armrest which 1s generally used when the seat is in the upright position If the armrest has been lowered to position 2 and you want it in normal position 1 raise the armrest until it pops outward slightly then lower into normal position Position 2 Lowered Raise the armrest straight up then push the spring loaded base of the arm rest firmly inward against the seat When you feel the armrest move inward lower it into position while still pushing the base inward against the seat This position would generally be used when the seat is reclined To Slide the seat Pull up on the slide lever lo cated on the side of the seat Slide to desired po sition and release lever SEAT BELTS Seats intended for occupancy while the vehi cle is in motion are equipped with seat belts for the protection of the driver and passengers Lap Belts The lap belts must be worn as low
92. e Once you have found a Sleep Number setting where you feel comfort able log this number into your Sleep Journal Step 6 Try to sleep at this Sleep Number for a minimum of five nights It will take your body that long to become accus tomed to a new sleep surface After five nights reevaluate your comfort level and log this into your Sleep Journal If you need to make adjustments repeat Steps 4 and 5 If you would like to experiment further with your Sleep Number setting just press the Firmer Softer button in the opposite direction you are adjusting and the Firmness Control Sys tem will stop Then go to the Sleep Number you want Minnie Winnie If after trying four different Sleep Number settings you have not found your ideal Sleep Number please call 1 800 318 2231 to reach trained Select Comfort Customer Service Repre sentative They may be able to recommend adjustments make suggestions or pinpoint con cerns that might be contributing to less than ideal comfort Altering Your Sleep Number Unlike an innerspring mattress a Sleep Num ber bed can be personalized at any time to the changing condition of your body Some reasons to alter your Sleep Number include e strained muscles back pain e weight change e bad sunburn In addition to personalizing your bed for a great night s sleep you can also alter the mat tress firmness when you wake the morning in order to e assist getting out of
93. e care when exiting emergency window as broken glass may be present in the exit area USING SLIDER WINDOWS AS EMERGENCY EXITS Most slider windows along the side of the mo tor home can also be used as emergency exits should the need arise To use the windows as ex its first slide the window open then slide the screen open 1 7 AN SECTION 1 SAFETY PRECAUTIONS FIRE EXTINGUISHER dry chemical fire extinguisher 15 located near the floor by the side entrance door We recommend that you become thoroughly familiar with the operating instructions displayed on the side of the fire extinguisher or in the infor mation supplied your Owner InfoCase We also recommend that you inspect the fire extinguisher for proper charge at least once a month accordance with National Fire Protec tion Association NFPA recommendations as stated on the label If the charge is insufficient the fire extinguisher must be replaced WARNING Do not test the fire extinguisher by discharging it Partial discharge can cause leakage of pressure or contents which would render the unit inopera tive when needed When using the fire extinguisher aim the spray at the base of the fire 50 SMOKE ALARM Your motor home is equipped with a smoke alarm located on the ceiling in the galley area This alarm meets U L Standard 217 and NFPA Standard 74 for operation of smoke detection devices 1 8 Wi
94. e equipped with automatically activated brakes See the Ford Recreation Vehicle and Trailer Towing Guide for maximum towing ca pacities and GCWRs These guidelines are available from your local Ford deal ers Before descending a steep or long grade when towing a trailer reduce speed and shift into a lower gear to control vehicle speed Avoid pro longed or frequent application of brakes which could cause overheating and brake failure 4 4 Minnie WARNING For safety towing and vehicle han dling maintain proper trailer weight distribution The total weight of the motor home and the vehicle towed must not exceed the Gross Combined Vehicle Weight rating Contact the chassis manufacturer to obtain the Gross Combined Vehicle Weight rating for your chassis Exceeding any of the recommended gross vehicle weight ratings may re sult in vehicle damage Do not install a frame equalizing type hitch on your vehicle See also Trailer wiring connector in Section PRE TRAVEL CHECK LIST Before starting the engine to leave on a trip be sure your motor home has been properly pre pared and maintained This will ensure an enjoy able trip and help avoid delays Use this checklist as a guide Fluid Levels Check and fill if necessary e engine oil transmission power steering radiator brake battery e windshield washer Wheel Lug Nuts Check for tightness Tires Check for proper cold inf
95. e equipped with a water heater by pass valve for easier winterization of water lines using RV antifreeze The valve is lo cated inside the coach near the water heater See pg 7 5 for the exact location in your coach Line up the arrow on the handle with the ap propriate arrow on the valve plate to either by pass or flow through the water heater Normal By Pass Flow Mode LP GAS FURNACE SUBURBAN Start Up 1 Open the LP gas tank valve by turning fully counterclockwise Temperature Selector 2 Move THERMOSTAT switch from Off to Heat and press the Temp Selector button Up Down arrows until the desired tempera ture is shown in the display 3 Furnace fan will start to blow immediately after setting thermostat 4 After about 30 seconds the furnace burner will light 5 The furnace will now cycle off and on auto matically as the thermostat demands just like a household furnace NOTE Metal coatings used during manufacture of the furnace burner parts may smoke when the furnace is used for the first time which may also set off your smoke alarm If this happens provide adequate ventilation of the smoke to avoid a nui sance smoke alarm at this time We do not recommend removing the smoke alarm battery If it were inadvertently left disconnected the smoke alarm would be inoperative To Shut Down 1 Slide thermostat switch to OFF position 2 Close LP tank valve SECTION 8 APPLIANCES
96. e it up immediately to avoid damage Technical Assistance If you need assistance or advice on care and maintenance of your solid surface countertops contact the countertop man ufacturer Vendura Industries Phone 608 223 9555 Galley Sink Care and Cleaning Instructions The galley sink is made from a remarkably tough material and has been designed and engi 9 6 neered to resist scratches and should not stain under normal household use if used properly To keep this product looking brand new and shiny we recommend that you take a few easy precau tions e Do Not use abrasive cleaners or scouring powders Use of an abrasive cleanser will dull or damage the surface of this product and could leave scratches We recommend you use a spray window cleaner or house hold cleaner made from fiberglass acrylic or solid surface products e Do Not use scouring pads steel wool Scotch Brite type scratch pads or any other abrasive scrubbers Wipe only with a soft cloth or sponge e Always use a cutting board or a sink pro tector when using knives or sharp objects We recommend that you use protective mats racks or dishpans to help protect your sink e Always allow pans to cool before setting them in your sink Do Not stand in your sink Even though this sink has been tested to withstand weights up to 200 lbs excessive weight in the center of the sink may cause cracking NOTE Improper use may damage this
97. e to prevent freezing Fluid level check may be omitted if equipped with maintenance free batteries SECTION 6 ELECTRICAL SYSTEMS WARNING To prevent damage to batteries or wiring always observe battery polar ity Always attach positive cable to positive terminal and negative cable to negative terminal The bat tery terminals are marked and negative Disconnect both battery cables before connecting a booster battery charge to a battery inside the battery com partment Never try to charge or boost a frozen battery A battery explosion could result BATTERY CONDITION METER This meter allows you to check the level of charge the house battery in your motor home It is located on the monitor panel in the galley ar ea See Section 8 To obtain an accurate reading 1 Both the automotive engine and the auxiliary generator engine must be stopped 2 An interior light should be turned on to pro vide a small load which draws off battery surface charge AUX START SWITCH See Section 2 TRAILER WIRING CONNECTOR Your coach 1s pre wired for trailer or car tow ing lights with a 6 pin socket on the rear bumper The connector plug is supplied in the coach parts package provided to you by your dealer when you took delivery of the vehicle The diagram shows proper connection of trail er or tow vehicle wiring to the coach light system Remove the small screw near the end of the plug and slide
98. e to the fuel evapo rative emission system Chassis Fuel Tank Capacity Ford Chassis w 6 8L EFI Gas Engine 55 gal REPLACEMENT FUEL CAPS To protect gasoline system from excessive pressure or vacuum or from sudden pressure re place lost caps with caps of the same design available from your dealer Winnie STARTING AND STOPPING ENGINE Refer to your chassis operating guide for the manufacturer s recommendations on starting and stopping the engine Brake Shift Interlock Ford chassis are equipped with a brake shift interlock safety feature The shift lever cannot be moved from the Park position unless the ignition is ON and the service brake pedal is pressed NOTE On Ford chassis if the brake light fuse is blown the interlock feature will not work properly and an alternate method must be used See your Ford Owners Guide for detailed instructions on what to do in this situation FUEL PUMP SHUT OFF SWITCH Vehicles built on Ford chassis are equipped with an inertial type switch that shuts off the fuel pump in the event of collision This switch must be manually reset to resume the fuel supply to the engine See your Ford Owners Guide for location and reset procedures for this switch NOTE It is possible to accidentally trigger the fuel pump shut off switch by abruptly striking an object such as curb or park ing block If your vehicle exhibits symp toms of running out of fu
99. e with caution WARNING Operating the hazard warning flasher system while moving on the highway is illegal The front directional signals and the taillights will flash intermittently when the flashers are in operation The hazard warning flashers will not operate when the service brake pedal 1s de pressed The turn signal will not operate when the flashers on When it is necessary to leave the vehicle the flasher system will continue to oper ate with the ignition key removed IF YOU GET A FLAT TIRE In case of sudden tire failure avoid heavy brake application Tire manufacturers recom mend accelerating briefly to regain steering sta bility then gradually decreasing speed Avoid quick steering movements Hold steering wheel firmly and move slowly to a safe off road place Park on level spot turn off the ignition and turn on the hazard warning flasher system SPARE TIRE STORAGE The spare tire is fastened to a swing down carrier beneath the rear of the coach WARNING Do not lie beneath tire carrier while removing tire The tire and carrier assembly are heavy e Support tire carrier with a jack or block while removing wire pin and wing nut from bolt at front of carrier e Carefully lower tire carrier to ground e Remove 2 bolts and retainer plate that hold wheel to carrier bracket e Luft or slide tire from carrier Do not over tighten wing nut when returning carrier to storage posi
100. eD en 6 2 Power Connec HoN 1 4 Power Door eee 2 3 Power ROOT 8 23 Preparing Vehicle for 10 1 Presto Bed Shock Bed 8 18 Pre Travel 5 2 222222222 4 4 Q Quartz Wall CLOCK 8 23 R Radio Power 5 2 2 11 Range and OVEN 8 4 Range and 9 6 Rear Escape 1 1 7 Rearview Monitor System 2 9 Recovery 1 3 2 Ee PW oink hatte dale 5 3 Refrigerator 9 4 RGM CE ALON 8 1 5 3 Removal from 10 3 Replacement Fuel Caps 2 2 Reporting Safety 0 2 Retract Slideout 2 14 Roo 4 3 ROO 9 1 RV Rid 2 11 RV BRAGG 2 11 S Safe Use of the LP Gas 5 1 Safety
101. ection and gently press the backflow valve upward to drain any water left in the line One 1 valve in passenger side rear cargo compartment Drain plug on outside of coach behind service door Use socket to remove drain plug Behind access panel beneath galley cabinet In passenger side rear cargo compartment Two 2 valves cargo compartment just behind rear dual wheels on driver side of coach One 1 valve in cargo compartment just behind rear dual wheels on driver side of coach Open exterior shower faucet knobs and place shower head below floorline of coach to drain hose and water line Drain plug on outside of coach behind service door Use socket to remove drain plug Behind access panel beneath galley cabinet See photo on pg 7 8 In cargo compartment just behind rear dual wheels on driver side of coach Water Lines City Water Line Water Tank Water Heater Water Heater By Pass Valve Winterization Antifreeze Valve SECTION 7 PLUMBING SYSTEMS One 1 valve in passenger side rear cargo compartment Two 2 valves 1 hot 1 cold on floor beneath lavatory cabi net Also open exterior shower faucet and place shower head below floorline The city water hose connection is located on the ceiling of the Utility System compartment Stick your finger up inside the connection and gently press the backflow valve upward to drain any water left in the line O
102. ed shades when they are not needed to prevent them from losing their shape WINDOW ROLL UP SHADE ADJUSTMENT If a roll up type window shade your motor home does not roll up or down fully the spring tension may need adjustment Spring Too Weak Roll shade about half way down on window Remove shade from bracket Roll shade snugly by hand and replace onto bracket Spring Too Strong Roll shade all the way up Remove shade from bracket Unroll shade one or two turns as necessary by hand and replace onto bracket QUARTZ WALL CLOCK To Replace Battery The clock is mounted in a socket on the face of the cabinet SECTION 8 APPLIANCES amp INTERIOR FEATURES Carefully remove the clock from the socket by rotating to the left counterclockwise as shown After replacing the battery simply place the clock back into the socket with 12 at the 9 o clock position and rotate upright 8 24 CARE amp MAINTENANCE SEALANTS Ay CAUTION Sealants must be inspected every 6 months and resealed if necessary ROOF The roof is made of Thermo Panel materials like the walls and floor It will support the weight of an average adult should it become necessary to repair the roof or roof mounted components It is not recommended however that very large or heavy objects be carried on the roof while the ve hicle is in motion See page 4 1 for roof loading specif
103. ed fresh air for safe operation Before operation 1 Open overhead vent or turn on exhaust fan 2 Open window FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY Unlike large homes the oxygen supply inside a recreational vehicle is limited due to its size To avoid danger of axphyxiation pro vide proper ventilation when using the gas rangetop or gas oven It 1s especially impor tant that the gas oven and range top not be used for comfort heating Danger of asphyx1 ation is greater when these appliances are used for long periods of time LP GAS LEAKS The following label is located in the vehicle near the range area If you smell gas within the vehicle quickly and carefully perform the proce dures listed A DANGER IF YOU SMELL GAS 1 EXTINGUISH ANY OPEN FLAME PILOT LIGHTS AND ALL SMOKING MATERIALS 2 DO NOT TOUCH ELECTRICAL SWITCHES 3 SHUT OFF THE GAS SUPPLY AT THE TANK VALVE S OR GAS SUPPLY CONNECTIONS 4 OPEN DOORS AND OTHER VENTILATING OPENINGS 5 LEAVE THE AREA UNTIL ODOR CLEARS 6 HAVE THE GAS SYSTEM CHECKED AND LEAKAGE SOURCE CORRECTED BEFORE USING AGAIN FAILURE TO COMPLY COULD RESULT IN EXPLOSION RESULTING IN DEATH OR SERIOUS INJURY SECTION 1 AN SAFETY PRECAUTIONS LP GAS ALARM Your coach is equipped with an LP gas detec tor which sounds an alarm if an unsafe amount of LP gas is present inside the coach Because LP gas 1s heavier than air the detector 1s loca
104. ed to scrub simply rub lightly or dab the stain 9 4 Scrub Soak Blot Dry Scrub Soak Blot Dry Scrub Soak Blot Dry Scrub Soak Blot Dry Scrub Soak Blot Dry Scrub Soak Blot Dry Scrub Soak Blot Dry Scrub Soak Blot Dry Scrub Soak Blot Dry Hot Iron on Detergent Soaked Towel or cloth Scrub Soak Blot Dry Scrub Soak Blot Dry Soak Blot Dry Soak Blot Dry Soak Blot Dry Scrub Soak Blot Dry Scrub Soak Blot Dry Soak Blot Dry Scrub Rinse Blot Dry Scrub Rinse Blot Dry Deodorize w Vinegar Scrub Rinse Blot Dry Deodorize w Vinegar Scrub Rinse Blot Dry Scrub Rinse Blot Dry Deodorize w Vinegar You may have to repeat this procedure more than once to achieve desired results Finish up with clean water using the same method and blot dry REMEMBER this is polypropylene basic plastic so do not be afraid to clean it Steam cleaning 15 also an option Again take care not to over saturate the material Nine Wimmie IMPORTANT The fabric manufacturer s recommendeds made above are done in good faith and are based history of actual experiences and laboratory evaluations Foss Manufacturing Company Inc and or its designed distributor does not warrant either expressed or implied the effectiveness of the cleaning agents listed and the process for cleaning described above Leather Upholstery Driver Co Pilot Seats amp Sofa Optional The optional leather seats are made of top quality cattle hide soft leather
105. ee operation and to protect against freeze up o VEHICLE MAINTENANCE See also Safety Precautions Section 1 of this manual SECTION 9 Ea CARE amp MAINTENANCE HN lt CHASSIS SERVICE amp g MAINTENANCE Consult the appropriate sections in your chas sis operating guide for specific information re garding operating safety service recommendations and maintenance schedules for the chassis section of your motor home ENGINE ACCESS Refer to your chassis operating guide B ENGINE COOLING SYSTEM Refer to your chassis operating guide for in formation and precautions on filling servicing and checking the fluid level When refilling the coolant system of a vehicle equipped with a rear auxil iary automotive heater and motoraid water heater be sure to allow for additional coolant capacity of the heater and its supply and return Low air pressure results in tire overloading and abnormal wear and also affects handling and fuel economy Obtain proper inflation pressures from your chassis operating guide or tire manu facturer 9 7 WE SECTION 9 CARE amp MAINTENANCE WARNING Make sure all replacement tires are of the same size and ply rating as those installed as original equipment am SUSPENSION ALIGNMENT AND TIRE BALANCE The front suspension and steering system of this vehicle was factory aligned using highly ac curate equipment prior to delivery to the dealer ship How
106. el See Section 6 Electrical Systems Because the LP gas alarm is connected direct ly to the auxiliary battery it is always drawing a small amount of current Even though this current draw is slight it could drain the coach battery during storage periods when the house battery will not be charged regularly by the engine or shoreline To avoid battery discharge we recom mend turning the Aux Batt switch off during stor age periods and after periodic or weekend usage Further Information See the manufacturer s information entitled Your LP Gas Detector in the Owner InfoCase for further instructions on nuisance alarms and care and testing of the LP gas detector ELECTRICAL e Careless handling of electrical components can be fatal Never touch or use electrical components or appliances while feet are bare while hands are wet or while standing in water or on wet ground e Improper grounding of the vehicle can cause personal injury Do not plug the utility power cord into an outlet which 16 not grounded and do not adapt the plug to connect to a recepta cle for which it is not designed e Do not attach an extension cord to the utility power cord e sure that all electrical appliances to be used contain 3 prong plugs for proper grounding e Avoid overloading electrical circuits Re place fuses or circuit breakers with those of the same size and amperage rating only Nev er use a higher rated fuse or breaker
107. el immediately after such an occurrence the fuel pump shut off switch may need to be reset Consult your Ford chassis operating guide for additional information PARKING BRAKE Never drive your vehicle with the parking brake set This will reduce parking brake effec tiveness and cause excessive wear Consult your chassis operating guide in your Owner InfoCase for operating instructions SECTION 2 DRIVING YOUR MOTOR HOME HAZARD WARNING LIGHTS See your chassis operating guide for operation of the hazard flasher switch See also Section 3 for supporting information DOOR LOCKS AND HANDLES NOTE Keys should always be removed when leaving the vehicle Since doors can be locked without keys make sure they have been removed from the ignition before locking the driver s compartment The entrance door may be opened from out side the vehicle by pulling the door handle out ward To open the door from inside pull outward on the door handle When the door is locked nei ther the inside nor the outside door handle can be operated Power Door Locks Ford chassis models are equipped with power door lock switches on the cab doors The cab door power lock switches also control the entrance door power lock This means that any time you press the switch to lock the front doors you will also lock the side entrance door Also when you unlock either one of the front doors it will unlock the side entrance door as well ENTRA
108. ered normal and under the terms of the war ranty may constitute misuse abuse or neglect and may therefore reduce your warranty protection Wimmie See also Safety Precautions Section 1 of this manual LP GAS SUPPLY The LP gas system supplies fuel for the range water heater furnace and refrigerator while in gas mode When used and handled properly this system 15 safe and economical and provides mod ern living conveniences wherever you travel iL SAFE USE OF THE LP GAS E SYSTEM The LP system is designed and built with strict adherence to both federal and recreational vehi cle industry requirements for mobile LP gas equipment For your safety there are many safety devices and backup systems installed such as tank fill overflow valves an interior LP gas detector alarm and an interior carbon monoxide CO de tector alarm LP gas also contains an odor additive that you can smell if LP is present in the air Listed below are a few precautions to observe that will help you to use the LP gas system safely e Exercise caution at all times Be familiar with the distinctive odor of LP gas Ifa leak is sus pected turn off the supply valve immediate ly Have the LP gas system checked by your dealer or a qualified LP gas service center e Do nottamper with the LP gas piping system pressure regulator or gas appliances Service and maintenance of LP gas system compo nents should be performed
109. erior storage compartment below dinette 2 15 SECTION 2 DRIVING YOUR MOTOR HOME Lift front edge of sofa and pull out strap lying on floor beneath sofa Hook looped end of this strap into hook on winch strap Step 3 Crank Room Inward Be sure the winch ratchet pawl is in the lock ing position against the gear teeth before cranking Crank the winch handle clockwise slowly Begin cranking until the strap becomes taut then crank slowly a few clicks at a time then wait a few seconds so that both sides of the room pull in evenly Allow about 10 minutes to crank room in fully Attempt ing to crank the room in too quickly will raise fluid pressure in the hydraulic lines and make cranking more difficult When the room is fully retracted fasten travel straps then unhook the winch straps and return the winch to its storage area Release the straps by putting slight pressure clockwise on the crank handle then moving the ratchet pawl lever to the unlocked straight outward position WARNING Do not attempt to continue cranking the room inward if binding occurs Excessive tension could cause a strap to break or pull free which could result in personal injury Damage to the winch equipment cabinets or coach sidewall could also occur NOTE When you are done cranking the room in you may notice on the outside that either the top or bottom of the room may still be gapping out from the sidewall a few inch
110. es may be sold you can assure that you are getting pure propane by filling at an LP refilling station that sells motor fuel LP Check local phone directory yellow pages for these LP gas refilling stations Butane 15 typically sold only in warmer cli mates and is not normally sold northern states See also Winter Use of LP Gas on page 5 5 LP GAS OUTPUT Each gallon of liquid LP gas contains approx imately 92 000 BTU s of heat energy or about 36 2 cubic feet of dry gas for cooking heating water heating and refrigeration 5 2 WIE To find out how long a gallon of LP gas will last you should determine the total BTU input on all your LP gas appliances in use Let s say you have a furnace that has a 10 000 BTU input per hour of operation A gallon of LP gas would last 9 2 hours of continuous operation 92 000 BTU s by 10 000 BTU s 9 2 To estimate how long a gallon of LP gas lasts try to deter mine what your total daily BTU input is then di vide into 92 000 to arrive at an approximate daily LP gas consumption LP TANK SYSTEM The storage reservoir for the LP gas system is a horizontally mounted tank which is permanent ly attached to the vehicle frame The tank is ac cessible only from the outside of the vehicle The tank supply valve is located near the top center of the tank next to the regulator Before opening the supply valve check to be sure all controls for gas appliances in
111. est and minimize care efforts An occasional sanding with a medium grade 120 grit sandpaper will remove any cut marks accumulated on the sink cover botton To remove cuts and scratches use a more aggressive cleansing powder such as Comet a moistened SOS pad or green Scotch Brite pad We recommend that you finish the entire surface using the same cleansing material and scrubbing method to maintain a uniform appear ance If you prefer a glossier look follow up with a good quality furniture polish such as Pledge or a liquid automotive wax non cleaner type Use trivets and hot pads under hot cooking pans Do Not set hot pads or pans directly from the stove or oven onto the counter The solid sur face material is extremely heat resistant but sud den contact by a very hot material with a cold countertop surface could cause a crack that would need to be repaired Likewise concen trated high heat sources in a small area such as a crock pot or an electric griddle may cause a crack We strongly recommend using a trivet under these Also do not allow candles to burn directly on the counter surface Avoid paint remover or oven cleaner The solid surface material is also resistant to most chemical substances but exposure to some harsh chemicals and solvents such as these can cause damage that would need professional repair or replacement If one of these materials does spill or drip onto the counter surface wip
112. et of keys has an identification number either a small metal tag or stamped into the key head Record these numbers and keep them in a safe place In case keys are lost or stolen your dealer or a locksmith can provide you with dupli cate keys or modify the locks NOTE Keys should always be removed when leaving the vehicle Since doors can be locked without keys make sure they have been removed from the ignition before locking the driver s compartment FUEL SELECTION Refer to your chassis operating guide for the manufacturer s recommendations on proper fuel selection mme Minne Modern fuel systems may build up pressure within the tank as the gaso line warms during use or 1n hot weath Under certain conditions sudden release of this pressure when remov ing the gasoline cap can spray gaso line from the fuel fill opening causing a possible hazard E GASOLINE FUEL FILL REMOVING THE FUEL CAP When removing the gasoline cap slowly ro tate it only far enough to allow pressure to re lease After any hissing sounds stop continue removing the cap FILLING THE TANK Do not overfill the fuel tank Allow gasoline to pump into the tank until the auto shutoff valve in the fuel pump nozzle stops the flow of fuel in dicating a full tank This provides a pre deter mined vapor space at the top of the tank to allow for expansion of the gasoline Continuing to fill above this level may cause damag
113. ever we recommend that alignment be checked and adjusted if necessary after you have fully loaded the motor home according to your personal needs Thereafter the alignment should be periodically inspected to help prevent uneven tire wear Any excessive or abnormal tire wear may 1 dicate worn or misaligned suspension or steering unbalanced tire or other tire suspension problem Alignment can be affected by worn steering suspension parts or by incidents which happen during driving such as hitting a curb pothole or railroad track etc Improper alignment can cause tires to roll at an angle and wear unevenly It may also cause the vehicle to pull to the right or left Have your dealer inspect your vehicle s suspen sion and steering components periodically for misalignment or wear Out of balance tires will not roll smoothly and can lead to annoying vibrations and uneven tread wear such as cupping and flat spots Tires may need to be balanced if uneven wear 15 detected or if ride comfort decreases noticeably See your chassis operating guide for further information 22 Rear Air Springs Optional 27 30 amp 31 models Check and adjust the air bag pressure periodi cally to maintain optimal ride and handling char acteristics according to cargo weight 9 8 IE Mime Min press 20 1 Max press 100 p s 1 Air Spring Valves LT AIR BAGS RT SHO
114. excessive pres sure by discharging gas to the atmosphere Do not fill LP gas container s above 80 per cent of capacity Overfilling the LP gas con tainer can result in uncontrolled gas flow which can cause fire or explosion A properly filled container will contain approximately 80 percent of its volume as liquid LP gas Never use an open flame to test for LP gas leaks Replace all protective covers and caps on LP system after filling Make sure valve is closed and door latched securely Never connect natural gas to the LP gas sys tem When lighting range burners do not turn burner controls to and allow gas to es cape before lighting match Portable fuel burning equipment including wood and charcoal grills and stoves shall not be used inside the recreational vehicle The use of this equipment inside the recreational vehicle may cause fires or asphyxiation LP gas regulators must always be installed with the diaphragm vent facing downward Regulators are equipped with a protective cover Make sure that the regulator vent faces downward and that the cover is kept in place to minimize vent blockage which could result in excessive gas pressure causing fire or ex plosion e The following warning label is located in the cooking area to remind you to provide an ad equate supply of fresh air for combustion A WARNING IT IS NOT SAFE TO USE COOKING APPLIANCES FOR COMFORT HEATING Cooking appliances ne
115. extend ing or retracting Do not occupy the slideout room while it is being extended or retracted CAUTION Be sure to allow adequate clearance at least 2 feet beside the vehicle to prevent damage when extending the slideout room Be aware of items like cars tree branches etc beside the vehicle Travel Straps Slideout Room The Travel Straps must be released before attempting to extend the room or damage to the coach will result SECTION 2 DRIVING YOUR MOTOR HOME The travel straps are designed only to help keep the room extension secured against the coach sidewall to maintain an effective weather seal while the vehicle 15 in motion They are not designed to withstand the force exerted by the hydraulic extension mechanism and will not pre vent extension of the room Travel straps are located on the floor near the ends of the slideout room To Release e Pull the strap buckle outward and up to re lease tension on strap e Pull a short length of the excess strap back through the buckle to provide sufficient slack e Unhook the strap end pegs from the mooring brackets on the floor and wall edge Store straps in location of your choice Under the couch is one choice 2 13 SECTION 2 DRIVING YOUR MOTOR HOME To Fasten Straps e Hook the strap end pegs into the mooring brackets e Flip buckle downward and press toward strap until it snaps snugly into place against the Strap e Ifastrap
116. fluid reservoir The pump 1s located under the coach just ahead of the driver side rear wheels 7 j Open Slideout 4 Y Solenoid Valves WARNING Stop engine place transmission in park position and apply parking brake before lying beneath vehicle for this procedure NOTE The slideout room solenoid has a small 1 4 nut at the end of the valve shaft that requires to use 1 4 nut driver tool that is built into the end of the hydraulic pump oil cap SECTION 2 DRIVING YOUR MOTOR HOME See the HWH Operator s manual includ ed in your InfoCase for specific instruc tions on which valves to open for front or rear slideout rooms and what additional precautions to follow e Open all of the slideout solenoid valves with 1 4 nuts on the ends to relieve hydraulic line pressure See Step 1 under slideout Room Emergency Crank In on previous page DO NOT LOOSEN NUTS MORE THAN 4 FULL TURNS e pletely open counterclockwise Step 2 Install Winch Crank Assembly and Straps The winch assembly is generally stored in the left rear cargo compartment Fasten tail strap of winch to bolt on floor beneath dinette table as shown Push up on bolt from compartment to find exact loca tion then cut small X in carpet to push bolt through Approximate location of winch anchor bolt beneath carpet under dinette table Bolt is visible ceiling of ext
117. for the child s height weight and development The instructions and or the regulation label attached to the restraint typically provides this information 4 Review the instructions for installation and use of the restraint Be sure that you under stand them fully and can install the restraint properly and safely in your vehicle MIRRORS Always adjust mirrors for maximum rear 151 bility before driving off Make sure the seat 15 ad justed for proper vehicle control and that you are sitting back squarely into the seat Mirror Heat Control Switch Mirror Adjustment Side Mirror Head Adjustment While sitting properly the driver seat and the mirror arms extended normally have a helper grip the mirror head by opposite upper and lower corners and move it horizontally and vertically for proper rearward vision NOTE For power mirrors be sure the power adjustment is in the middle of it s adjust able range both up down and right left before adjusting the head position Rearview Monitor System Optional If your model is equipped with this optional system please refer to the Owner InfoCase for specific instructions provided by the manufactur er SECTION 2 DRIVING YOUR MOTOR HOME INSTRUMENT PANEL GAUGES AND CONTROLS The illustrations on the following page show ing switches and features provided by Winneba go See your chassis owner s manual for detailed information on the instru
118. g blocks into a ramp like formation in a low spot to drive the tire onto thus leveling the coach as shown Wedge a pair of wheel chocks or similar de vices in front and back of a tire that is on the ground as shown to keep the coach from rolling forward or backward off the leveling blocks 4 7 SECTION 4 TRAVELING WITH YOUR MOTOR HOME Blocks Wheel Chocks Leveling Your Motor Home When placing blocks beneath a set of rear dual wheels be sure the blocks support both tires so that the load weight 1s not resting on one tire which could damage that tire THIS 5 Blocking Rear Duals To provide extra firmness you can place inexpensive mechanical jacks jack stands or hydraulic bottle jacks under the frame to keep the coach from moving on the suspension springs while walking around inside the coach These devices are not intended to lift the coach only to hold it rigid and steady NOTE We do not recommend lifting any of the wheels off the ground for leveling This could allow the coach to roll off the Jacks possibly resulting in damage to the vehicle weg EFFECTS PROLONGED OCCUPANCY Your motor home was designed primarily for recreational use and short term occupancy If you expect to occupy your coach for an extended period be prepared to deal with condensation and humid conditions that may be encountered 4 8 Minnie Winnie HUMIDITY AND 2522 CONDEN
119. gain and try to be the primary heat source Off Gas Heat Heat 0 FAN MODE THERMOSTAT SPEED Gas Heat Gas Furnace Electric Heat Heat Pump Cool Roof Air Conditioner Have you checked your air filter lately Closed or blocked vents and a dirty air filter can hinder the efficiency of a heat pump See Air Conditioner Filter for location and instructions Vme e Be sure ceiling vents are open to distribute heat pump output air Also make sure furni ture clothing items packages or other obstructions do not block the air return air grilles beneath the rear bed e filter should be checked monthly for dirt build up and replaced as needed The air fil ter is a disposable woven fiberglass type which cannot be cleaned and should be replaced when coated with dust DUCTED ROOF AIR CONDITIONING SYSTEM The furnace thermostat also controls ducted roof air conditioner operation when the thermo stat switch is placed in position NOTE The thermostat is equipped with a re placeable 2 Amp fuse located on the back of the thermostat body Refer to the manufacturer s information in your InfoCase for complete operating instruc tions NOTE The ducted roof air conditioning system has ceiling registers that can be closed if necessary to force more cool air toward a specific area of the coach or to route cool air away from a specific area If too
120. he buckle until the latch engages Unfastening Press the release button in the buckle Hold onto the tongue when you release it from the buckle to keep it from retracting too rap idly When the lap shoulder belt is in use the lap portion must ride across the strong hip area and the shoulder portion must ride diagonally over the shoulder blade toward the buckle 2 7 SECTION 2 DRIVING YOUR MOTOR HOME The shoulder belt 1s designed to lock only dur ing a sudden stop sudden body movement or a collision At all other times it will move freely with the occupant Never wear the shoulder belt in any position other than as stated above Failure to do so could increase the chance or extent of injury in a colli sion NOTE On some models the shoulder belt height can be adjusted to provide the most com fortable position for each individual per son s size To adjust shoulder belt height press the lever down select the desired position and release the lever A ratchet ing mechanism will allow the belt to be pushed upward but not pulled down ward Seat Belt Care and Cleaning e Be careful not to damage the belt webbing and hardware Take care not to pinch them in the seat or doors Inspect the belts and hardware periodically Check for cuts frays and loose parts Dam aged parts should be replaced Do not remove or modify the belt system mE e Keep belts clean and dry If the belts need cleaning use only a m
121. he shoreline 15 connected 6 1 6 ELECTRICAL SYSTEMS 30 Amp Receptacle The three prong power cord is designed to ground the electrical system through the recepta cle It is also designed to carry the amperage out put of most campground outlets If the electrical receptacle to be used 15 designed to mate with the three prongs on the power cord plug the electri cal connection can be expected to carry rated load See approximate power consumption table on page 6 5 WARNING Do not plug the power cord into an outlet which is not grounded or adapt the plug to connect to a receptacle for which it 15 not designed Be sure that all three prongs of the supply cord are properly plugged into the receptacle Do not connect the power cord to an extension cord Do not plug the power cord into the generator receptacle while the gener ator 15 already running 6 2 Most campgrounds are equipped with a fuse or circuit breaker at the receptacle This protects the park s wiring as well as the power cord on your vehicle from electrical damage If electrical power fails contact the park attendants and have them check the fuse or breaker for your supply receptacle After disconnecting the power cord neatly re place it in the storage compartment POWER CENTER The power converter changes 110 volt AC current from the auxiliary generator or the shore line into 12 volt DC current for use by
122. hicle has been stopped Any articles that have shifted may fall out when the door is opened During peak tourist season and holidays it is best to phone ahead and make reservations at the park where you plan to stop Some states or cities will not permit vehicles with LP gas containers to pass through high way tunnels If your route includes a tunnel check with the highway patrol or department of highways to avoid inconvenience Do not leave food or odor causing material in your vehicle for extensive periods of time Always allow damp clothing swimwear hunting gear etc to dry before stowing Become familiar with the fire extinguisher and make sure it is always fully charged Re move and replace it and read instructions so you know the correct operating procedure be fore an emergency happens 4 5 SECTION 4 TRAVELING WITH YOUR MOTOR HOME 15 Make a list of all groceries fresh meats veg etables newspapers etc that you may need and try to pick them up during your last fuel stop of the day This will prevent leaving a good parking spot once you have arrived at your destination 16 When you sit over the front wheels while driving as in a motor home you have a ten dency to crowd the middle of the road Check the side view mirror frequently to observe how close you are driving to the center line SEVERE WEATHER INFORMATION One of the more serious conditions affecting the motor home traveler and camper
123. his manual should be kept in the vehicle at all times for personal reference The operator s manual INFOCASE and chassis operating guide are to be considered permanent components of this vehicle They should remain in the vehicle when sold to provide the next owner with impor tant safety operating and maintenance informa tion INTRODUCTION NOTE The descriptions illustrations and spec ifications in this manual were correct at the time of printing We reserve the right to change specifications or design with out notice and without incurring obliga tion to install the same on products previously manufactured CHASSIS OPERATING GUIDE Throughout this manual frequent reference is made to the vehicle chassis operating guide The chassis guide is the operator s manual pro vided by the manufacturer of the chassis on which this motor home is built 1 or Ford Consult the chassis guide for operating safety and maintenance instructions pertaining to the chas sis section of the motor home OWNER S INFOCASE Your Owner s InfoCase contains information supplied by manufacturers of individual appli ances and equipment installed your motor home Consult this information regarding the opera tion and care of appliances accessories and special equipment 0 1 INTRODUCTION OPTIONS AND EQUIPMENT This model 15 available in several sizes and floorplans so accessories and components may
124. ications Always have damage to the roof area repaired immediately Damaged or detached sealant around the vents air conditioner body to roof seams etc should also receive immedi ate attention Delaying these repairs may allow water leakage and result damage to interior ceiling and body panels upholstery etc UNDERBODY Buildup of mud and dirt under the body can cause damaging rust on steel parts and can add needless weight to the vehicle This in effect re duces the amount of cargo you can carry and re main with GVWR and GAWR limits Corrosive materials such as those used for ice and snow removal and dust control also accumu late on the underside of a vehicle These materi als should be removed by flushing the underbody regularly with water especially areas where mud and other foreign materials collect EXTERIOR The exterior surface of your motor home has an automotive finish Frequent washing and thor ough cleaning is recommended to prevent dam SECTION 9 age to the vehicle finish after exposure to damaging salts calcium chloride road tar tree sap insects and other foreign material Never wash the vehicle direct sunlight while the ve hicle surface is hot or using hot water Do not use strong soaps or detergents for washing the motor home Always use a mild soap in warm water a commercially prepared product for cleaning automotive finishes or your local car wash Be careful when using pressu
125. ience in winterizing fresh water lines The system features a diverter valve and sup ply tube in line between the tank and water pump to draw non toxic RV water system anti freeze into the water lines This feature is located near the water pump and drain valves See the end of this section for location in your coach To Fill Lines with RV Water Line Antifreeze Turn water heater by pass valve to BY PASS position e Remove and save the protective from the end of the supply tube e Insert the end of the tube into a container of RV antifreeze solution e Turn the diverter valve handle so that it points toward the supply tube e Turn a water pump switch on e Open each cold water faucet handle the coach one at a time until antifreeze solution just begins to flow from the faucet then close When Done Adding RV Antifreeze e Turn water pump switch off e Turn the diverter valve handle so it points to ward the water line to the pump as shown in the photo This will stop the flow from the supply tube and revert the tank line flow to the pump e Replace the protective cap onto the end of the supply tube to keep out insects and debris when not in use 7 5 7 6 SECTION 7 PLUMBING SYSTEMS A CAUTION Leave by pass valve handle in NOR MAL FLOW position if draining water and blowing out water lines Place in BYPASS position ONLY when using antifreeze solution in water lines Minne mme
126. ild soap and water so lution Do not use hot water Do not use abra sive cleaners or bleach These products may weaken or damage the belts e Replace any belt assembly that was used dur ing a severe impact Replace the complete as sembly even if damage is not apparent CHILD RESTRAINTS All 50 of the United States and the District of Columbia now require the use of the child infant restraint systems for children in vehicles A properly installed and secured child re straint system can help reduce the chance or se verity of personal injury to a child in an accident or during a sudden maneuver Children may be injured in an accident if they are not seated in a child restraint which is not properly secured A child restraint system is designed to be se cured in a vehicle seat by a lap belt or the lap belt portion of a lap shoulder belt According to acci dent statistics children are also safer when prop erly restrained in rear seating positions than in front seating positions When purchasing a child restraint system 1 Look for the label certifying that it meets all applicable U S Federal Motor Vehicle Safety Standards FMVSS Canada requirements of the Children s Car Seats and Harnesses Regulations CCSHR 2 Make sure that it will attach to your vehicle and restrain your child securely and conve niently so that you are able to install it cor rectly each time it is used 3 Be certain that it is appropriate
127. ill the water heat er turn the water pump switch on and open a hot water faucet until water begins to flow On electronic ignition models the W H Out light will glow for about 10 15 seconds af ter the water heater switch 15 turned on then it will go off If the light comes on during normal operation it means that the burner has gone into lockout mode Turn the switch off for about 5 minutes then turn back on See Water Heater elsewhere in this section for further information Wimme Water And Holding Tank Levels Press and hold the Levels Test switch to show approximate level on the monitor lights These approximate water levels are measured by electronic probes in the sides of the tanks so the water must be touching a probe to register at that level There is generally more water in a tank than indicated on the monitor panel For example if the water level of 1 2 below the FULL probe the monitor will show the level to be only 2 3 even though the tank is nearly full If the water level 15 below the 1 3 probe the mon itor will register an empty tank because the water is no longer touching the 1 3 probe There may actually be some water left in the tank However when the indicator reads FULL the tank is actu ally full WATER LEVELS WATER HEATER TEST PUMP PUMP ON LP Gas Level Press and hold the Levels Test switch to show approximate LP tank level The LP level is
128. ing appliances or electri cal equipment on e Refer to the output specifications of your generator in the generator manufacturer s manual e Do not overload generator by turning too many items on See load chart for estimation of typical RV loads Stopping e Before shutting generator down turn off electrical loads and let engine run at no load for a few minutes to cool down e Press the generator switch Off and hold until the generator engine comes to a complete Stop Continuous generator overloading can cause high operating tempera tures that can damage the generator windings Keep the electrical loads within the generator wattage rating 6 5 6 ELECTRICAL SYSTEMS Approximate Power Requirements of Common Appliances Approximate Power Consumption Watts Amps 200 S500W 1 7 4 3A 550 700W 4 8 6 1A 800 1500W 7 0 13 0A 500 1200W 4 3 10 4A 50 200W 0 4 1 7A 80 100W 0 7A 250 750W 2 2 6 5A 1400 2000W 13 19A 300 500W 2 6 4 3A 700 1500W 6 0 13 0A Appliance or Tool Vacuum cleaner Coffee Maker Hair dryer Electric clothes iron Electric blanket Television Electric drill Air conditioner Converter Microwave Oven GENERATOR HOURMETER If Equipped This meter is located on the monitor panel It registers the total number of hours that the gen erator has been operated Refer to the hourmeter to determine when periodic maintenance is due and to record services which have been per f
129. ins pressure sensitive touch switches and LED display The AC LP GAS Battery and AUTO indicators illuminate to indi cate the refrigerator s operating mode The ON OFF button turns the refrigerator On or If the button 1s pressed 1t will turn the refrigerator On and set the mode to AUTO When the refrigerator is On pressing this button for 2 seconds will turn the refrigerator Off 8 2 rin Ane Pressing and holding the MODE button allows the user to cycle through the three mode choices one AUTO and two manual modes AC LP GAS The refrigerator will not switch to the new operating mode until the mode button is released The TEMP SET thermostat button controls the refrigerator and freezer temperature during both gas and electric operation Press and hold the TEMP SET button to select the desired tem perature setting The temperature settings are shown in the form of numbers 1 9 Quickly press and release any button to display the temperature setting Start Up Instructions Auto Mode When the AUTO mode 1s selected the oper ating control automatically selects the power source using the following priority scheme When 120 volts AC is available to the refrig erator the AUTO LED and the AC LED will illuminate indicating the refrigerator 15 ating on AC electric After 10 seconds the AC LED will turn off and only the AUTO LED will remain illuminated Press and quickly release any butt
130. is emptied Nearly twice as many BTU s are avail able from a full tank than one that is one fourth full BTU s Available at 0 F Tank Level BTU s 80 64 000 50 50 400 20 33 000 The following LP Gas Vaporization and Tem perature Relationship chart typifies the LP gas loss with a decrease in temperature The percent age figures are the increase or decrease of vapor SECTION 5 ye LP GAS SYSTEM LE that would be available at 0 F These figures ap ply to any size LP gas tanks Percentage of BTU s Temperature Available at 0 F 20 F 200 10 F 150 0 100 5 F 75 10 F 50 15 F 25 20 F 12 1 2 44 Propane will not vaporize 5 5 Mimmie Wy See also Safety Precautions Section of this manual Your motor home 15 equipped with an electri cal system consisting of two separate voltages a 12 volt DC system and a 110 volt AC system The 12 volt system consists of two internal pow er sources while the 110 volt system 1s operated from an outside power source or the optional 110 volt generator All systems operate through a single power converter control center to provide electrical power to the motor home The 110 volt system operates from an outside 110 volt utility service such as those at camp grounds or from the optional 110 volt generator When the power cord is connected to an outside power source or when the generator is 1n opera tion the power conver
131. ive TV signal volt DC from the TV signals and provides a place Never allow the antenna to touch for attaching the TV set and the 12 volt power electrical power lines or any other source electrical wires 8 13 SECTION 8 APPLIANCES amp INTERIOR FEATURES Rotating Antenna Make sure antenna is in the UP position Pull down on rotating knob until it disengages ceiling plate and rotate for best picture and sound on TV set Lowering Antenna to Travel Position Rotate antenna until pointer on rotating knob aligns with pointer on ceiling plate 4 27 Never leave the antenna partially raised or partially lowered This can damage the crank mechanism gears Always raise the antenna straight up or lower it completely into the travel position Turn elevating crank counterclockwise in DOWN direction until resistance 1s noted An tenna 1s now locked in travel position Turn am plifier power switch OFF Count the number of turns needed to crank the antenna down to the roof of the unit normally about 13 Mark the final position of the crank handle on the ceiling or the directional knob for reference Also mark the number of turns needed Use the mark and number as a reference whenev er you lower the antenna Always align directional handle to DOWN position before lowering Wimme TV SIGNAL AMPLIFIER NOTE For coaches without the video control center optio
132. l drain valves and faucets to avoid contamination by dirt or insects Reinstall water heater drain plug and close P T relief valve Pour about one cup of non toxic RV anti freeze into the kitchen sink drain bathroom sink drain and shower drain This prevents any holding tank odors from entering the coach during storage WARNING NEVER use automotive antifreeze coolant in your RV water system Auto antifreeze contains Thelon gly col which if ingested can cause blindness and can be fatal It is not necessary to add antifreeze to the toi let since the flush valve will be closed Do not add automotive antifreeze or caustic chemicals such as bleach or laundry deter gents into the toilet bowl or holding tanks Although these products may have a deodor izing effect they may damage plastic and rubber parts in the system NOTE As alternative to totally draining the plumbing system you may winter ize tanks and lines by pumping non toxic RV antifreeze through the sys tem This product is available from your dealer and from most RV supply stores Follow directions on the con tainer to determine the correct amount to use for your coach See Water System Winterization Valve on page 7 5 for instructions on inject ing RV antifreeze into water lines Minne 15 Place a bucket beneath the sewage drain valve outlet and re drain the sewage and waste holding tanks of any clean water that en
133. lation pres sures as specified on the Vehicle Certifica tion Label Drive Belts Check for proper condition and tension not cracked frayed or loose etc 110 Volt Generator Optional Check oil level generator engine WARNING Never check oil level in generator while engine is operating Fire Extinguisher Make sure it 1s fully charged and secured in mounting bracket Lights Make sure all exterior lights operate Sewer and Water Supply Hose Unhook and store TV Antenna Make certain the TV antenna is lowered and seated in its support cradle Loose Items Inside the Motor Home Store or secure items Pilot Lights Make sure all pilots are off Fuel Tanks Check level Water Tank Fill with fresh water Exterior Door and Step Make sure doors are closed locked and step retracted Seats Adjusted for comfortable position and locked place Mirrors Adjust for maximum visibility from driver s seat TRAVEL TIPS As you travel around the country in your motor home you will pick up useful advice from other motor home owners A number of suggestions can also be obtained by reading articles and regular columns in outdoor and camping magazines Some maga zines and publishing companies print an annual park and campground directory These can be found at your local news stand or RV supply dealer Here are a few travel tips to begin with 2 Always check for sufficient clearance
134. layed in the appropriate areas in this manual GENERAL WARNINGS e Only seats equipped with seat belts are to be occupied while the vehicle is moving e Make sure all passengers have seat belts fas tened in a low and snug position so the force exerted by the belt in a collision will be spread across the strong hip area Pregnant women should wear a lap shoulder belt whenever possible with the lap belt portion worn low and snug throughout the pregnan cy e All seats which can be positioned such as swiveling sliding reclining or footrest out must be placed in a fully upright and swivel locked position with footrests retracted while the vehicle is moving Some swivel lounge chairs are designed to lock in a forward facing position while others lock in an aisle facing position Be certain these seats are secure from swiveling before traveling e Never let passengers stand or kneel on seats while the vehicle 15 moving e Sleeping facilities are not to be utilized while vehicle is moving e Examine the escape window and be familiar with its operation but do not use except in emergency 1 1 ZN SECTION 1 SAFETY PRECAUTIONS Inspect the fire extinguisher monthly for proper charge and operating condition This should also be done before beginning a vaca tion or any extended trip Do not attempt to adjust the driver s seat while the vehicle 15 moving Do not adjust tilt steering in a moving vehi
135. lectric generator engine e Patented biomimetic sensor mimics the human response to Carbon Monoxide e Test Reset alarm circuitry microprocessor battery and horn e Red light flashes once every thirty seconds in normal operation e Continuous yellow light with a beep every three seconds indicates an unhealthy CO level e Continuous red light and pulsating alarm signal a dangerous CO condition e Battery operation provides protection 100 of the time Low battery signal alerts consum er of need to replace battery e 55 decibel alarm assures waking during sleeping hours Monthly Testing Press the TEST button on the face of the alarm periodically at least monthly to check the func tion of the alarm and condition of the battery If the alarm begins to beep every few seconds the battery may be weak and need replacement Press the TEST button to be sure before replac ing the battery If the alarm sounds the battery may still be okay If the alarm still beeps every few seconds check the smoke detector also The low battery warning beep is similar on many alarm devices so the origin of this electronic sound can be deceiving Further Information Please read the manufacturer s guide included in your Owner InfoCase It includes information on precautions operational testing and battery sensor replacement EMERGENCY EXITS Emergency Exit Windows Your motor
136. limbing a long hill on a hot day idling while stopped traffic for long peri ods of time 3 4 Wit towing trailer or automobile stopping after a period of high speed driving If the TEMP indicator on the instrument pan el shows rise engine coolant temperature while driving take the following steps to attempt to lower the overheating condition Ifyou are using the automotive air condition er turn it off Ifyou are stopped traffic shift the trans mission into P Park and engage parking brake If the temperature does not drop within a minute or two Pull the vehicle over to the roadside as soon as it is safe to do so Place the transmission in P Park and press the accelerator to increase engine speed r p m s to twice that of normal idle speed and hold it there for approximately two or three minutes If engine temperature does not go down turn the engine off and wait until the engine has cooled before attempting to open the hood When no trace of escaping steam 15 heard or seen open the hood to check for the cause of the overheat Check hose connections and tighten if necessary Make sure there are no broken belts pulleys or hoses before adding any coolant to the radiator For further information in case of overheat ing consult your chassis operating guide it 1 SECTION 4 TRAVELING WITH YOUR MOTORHO
137. ll chassis and auxiliary battery cables 26 Fully charge the batteries Batteries must have at 80 charge to survive freezing temperatures and long period of non use We recommend that you connect a battery charger or plug in the shoreline once a month during a long term storage periods to main tain battery charge and to avoid sulfating If connecting a charger directly to batteries turn the Aux Battery switch off to avoid electrical arcing when attaching and detach ing charger clamps 27 After charging batteries turn the Aux Bat tery Switch off to disconnect the batteries and avoid parasitic drain NOTE We do not recommend leaving the shore line plugged in continuously during stor age period because the batteries can lose electrolytic fluids and become damaged from continuous charging without peri odic use We recommend following regular bat tery inspection and maintenance espe cially in cold weather REMOVAL FROM STORAGE Completely air out the motor home 2 Have the entire LP gas system checked for leaks Check window operation 4 Check cabinet and door hinges Lubricate with penetrating oil if necessary 5 Close all faucets and drain valves that are open If necessary reconnect toilet water line and close flush valve 6 Add a few gallons of water to the fresh water tank and check for leaks especially at junc 99 10 3 SECTION 10 STORING YOUR MOTOR HOME 10
138. making the repairs request that he contact Winnebago Industries Inc 4 If after the above steps are completed the repair is not made the customer should contact Winnebago Industries Inc P O Box 152 Forest City lowa 50436 Attention Owner Relations Department 800 537 1885 and furnish the following information complete serial number of the vehicle Date of retail purchase Selling dealers name Nature of the service problem and a brief explanation of the steps or service the dealer has performed and the results obtained The customer may be directed to another dealer or service center for repairs to be completed if such a dealer or service center is better able to complete the repair Winnebago Industries may at its option request the vehicle be returned to Forest City lowa for repair If the customer refuses to allow repairs to be performed at the Forest City lowa facility the warranty on that repair will be voided 5 If after the above steps are completed and the repairs are not satisfactory the customer contact the Service Administration Manager of Winnebago Industries and request a customer relations board meeting to resolve the problem This action however is not mandatory 6 Certain components are covered beyond the 12 months 15 000 miles basic warranty coverage by the individual manufacturer s warranty Please refer to the component s information supplied in the owner
139. matic Mode This means it will extend and retract automatically whenever the door is opened or closed This 15 done by means of a magnetic door switch attached to the lower hinged edge of the screen door section of the entrance doors The steps will extend when the screen door 15 opened and retract when the screen door 15 closed With the power switch in the Off position the step can be kept in the ex tended or retracted position as described below Stationary Extended Mode To keep the step in the extended position turn the Power Switch to e open the screen door to extend the step e then turn the Power Switch to Off The step will now stay extended whether the door is opened or closed This position 15 normal ly used when parked at a campsite or whenever people are going to be entering and exiting the vehicle frequently Automatic Retraction Feature The coach is equipped with a step retraction feature that retracts the step automatically when the Ignition Switch key is turned to either the On or Start position regardless of whether the Step SECTION 2 DRIVING YOUR MOTOR HOME Power Switch is On or Off This feature 1s stan dard and 1s installed to prevent injury or damage which may be caused by an extended step when the vehicle is moving An associated feature is the Last Out Feature This feature extends the step when the screen door is opened after the ignition switch has been turned to either the On or Start
140. may attempt to thaw the regulator using a light bulb DO NOT USE AN OPEN FLAME OR HEAT LAMP Be sure vent hole is not blocked LP Gas Pressure Regulator View upward into open end of regulator cover 5 4 If moisture begins to cause problems your LP gas dealer inject a small amount of dry methyl alcohol in your tank approximately one once to 20 pounds or one pint to 100 gallons to help guard against regulator freeze ups In very cold weather when a large volume of gas 1s being used for heating it is possible to ex perience a loss of gas pressure At first this prob lem may appear to be caused by a regulator freeze up but is actually caused by failure of the liquid gas to vaporize as fast as it is needed As the temperature becomes colder it is increasingly harder for the liquid LP gas to vaporize At the same time the demand for LP to produce heat in creases to the point where the system cannot maintain production The only solution to this problem 15 to reduce the consumption of gas where possible Adjust ing the temperature on the gas electric refrigera tor may be a first step Using less hot water will help as well The following label has been placed the ve hicle near the range area If you smell gas within the vehicle quickly and carefully perform the procedures listed A DANGER IF YOU SMELL GAS EXTINGUISH ANY OPEN FLAME PILOT LIGHTS AND ALL SMOKING MATERIALS DO NOT T
141. med by an authorized service center Do not plug the power cord into the generator receptacle while the genera tor 1s running To use the 110 volt generator plug the power cord into the generator receptacle within the shoreline compartment before starting the gener ator Generator Receptacle Power Cord STARTING AND STOPPING THE GENERATOR The generator switch 1s located on the range hood The generator starter circuit does not rely on the automotive battery so the switch will operate whether the ignition switch 15 on or off This coach may be equipped with one of sev eral models of generators Consult the generator owner s manual in your Owner InfoCase for specific instructions on starting and stopping your generator Generator Switch and Hourmeter GENERATOR TOP START S DISPLAY ON WHEN HOLD START UNTIL GENERATOR RUNS GENERATOR STARTS WATER LEVELS WATER JEATE ST PUMP Basic Generator Operation Starting e See generator manufacturer s operating 1 formation for specific instructions e Reduce all electrical loads Shut off lights fans appliances etc SECTION 6 ELECTRICAL SYSTEMS e Ifthe generator has not been run for two weeks or more you may need to prime the fuel system before attempting to start e Press the generator starter switch on and hold until generator engine is running then re lease e Let the generator engine stabilize and run smoothly before turn
142. ment gauges steering column controls brakes and other chassis origi nal equipment 2 9 SECTION 2 DRIVING YOUR MOTOR HOME INSTRUMENT PANEL Ford Chassis Power Mirror 12V Power Fan Speed Auto A C Heater Controls Gauges Socket Control Controls Rear Auto Heater i Power Door Lock Battery Boost Cruise Control Cigarette RV Radio amp Window Buttons Switch Power Switch Buttons Lighter See Ford chassis operator s manual 2 10 STEERING COLUMN CONTROLS See your chassis operator guide for all con trols located on the steering column or steering wheel WARNING Do not operate the cruise control on icy or extremely wet roads winding roads in heavy traffic or in any other traffic situation where a constant speed cannot be maintained 32 2 COMFORT CONTROLS AUTO AIR CONDITIONER HEATER See your chassis operating guide for operating instructions for dash mounted automotive heater air conditioner controls NOTE The automotive air conditioner is not de signed to cool the entire interior of the motor home but is intended to cool the driver s compartment only RVeRADIO RV Radio avail on Ford chassis only The RV Radio in your coach can receive AM FM stereo and Weather band stations It also has both cassette and compact disc CD players for your listening enjoyment through quality high output speaker
143. mmie 1 The smoke alarm should be tested for correct operation each time the vehicle is brought out of storage before each trip and at least once a week during motor home use To test the electronics firmly depress the button To test that smoke reaches the sensor blow smoke in a careful fire safe manner into your smoke alarm Press Button to Test 2 Your smoke alarm will not work without power Never remove the battery to quiet the alarm When your smoke alarm beeps about once a minute the battery is weak Install a new battery immediately Be sure to use only batteries specified in manual or on unit Test unit after installing a new battery 3 Clean and vacuum the openings on your smoke alarm once a month 4 Do not open the smoke alarm or try to repair it For replacement information see warranty in Owner s Manual 5 Smoke alarms have technical limitations and may not respond in all situations FIRE PRE VENTION is your best safeguard See your Owner InfoCase for further informa tion ioe Winnie SECTION 2 DRIVING YOUR MOTORHOME See also Safety Precautions Section 1 of this manual NOTE See your Ford Owner s Guide for infor mation on starting the engine operating the transmission Steering column con trols descriptions of instrument gauges and other chassis related information Some items described in this section may be optional or unavailable on your coach BEFORE ENT
144. n be sure the TV antenna amplifier switch is turned OFF while connected to cable The antenna amplifi er will make the cable TV signal snowy or block it out completely To operate amplifier turn on power switch Indicator On Off Light Other TV jack plates are mounted in various locations throughout the coach Some of these wall plates are not readily visible and may be in one of the following locations Beneath passenger side overhead cabinet In front overhead TV cabinet if equipped In the flip down entertainment tray on the outside of the coach Checking Reception The TV signals available to an RV are entirely dependent on its location in relation to the trans mitter Signals may vary from strong to no usable signal at all We recommend that the TV system be checked out in an area known to have good TV reception To check the antenna amplifier raise the an tenna select a TV channel and rotate the antenna for best picture Then turn off the amplifier pow er switch If the antenna amplifier is working properly the TV picture will now be degraded snowy When you turn the switch back on the picture should again be sharp PHONE AND CABLE HOOK UP Some models are equipped with external con nections for cable television The connector is lo cated in the sewage or water center compartment Cable TV Input Jack in Water Center Compartment NOTE For coache
145. n the MANUAL mode the AUTO indicator disappears and the desired operating mode is illuminated Unlike AUTO mode the operating mode indicator remains illuminated until an alternate mode 15 selected If the energy source is interrupted while in the MANUAL mode the corresponding indicator flashes and the refrigerator ceases operation until an alternative energy source 1s selected or the problem 15 corrected Refer to the Diagnos tics section on page 7 of the Norcold Operator s Guide in your blue binder for corrective actions AUTO and MANUAL Modes Gas Operation Only If the gas does not ignite within 30 seconds which may occur on initial start up the refriger ator s gas valve will automatically close and the operating controls will select an alternate power source AUTO Mode or revert to a stand by SECTION 8 APPLIANCES amp INTERIOR FEATURES mode in which the LP GAS indicator flashes The indicator continues to flash until the refrig erator is turned OFF and then ON If the gas does not ignite after several attempts check the input gas supply or consult with your dealer a Norcold authorized service center A different mode of operation may be selected by pressing and holding the MODE button The refrigerator will not switch to the new operating mode until the MODE button is released Backup Operating System BOS Your refrigerator features a Backup Operat ing System which keeps the refrigera
146. nace blower operates from sequencer or time delay in furnace During furnace opcration furnace overides and forces fan to high speed Air conditioning fan does not run Furnace blowcr runs continuously at low speed if so equipped and wired until furnace cycles satisfy setpoint Furnace overides and forces fan to high specd during furnace operation Air conditioning fan does not run Furnace blower runs continuously at high speed if so equipped and wired Furnace cycles to satisfy setpoint of o ojm fojoj g ih ojojw jo o o Operation F TV ANTENNA Raising Antenna Turn elevating crank clockwise in UP direction about 13 turns or un til some resistance to turning is noted Antenna is The TV antenna on your motor home can be y now in operating position Turn amplifier power easily raised rotated a full 360 and lowered from inside the vehicle by simply turning a crank or rotating knob A built in signal amplifier de signed to strengthen signals is controlled by a power switch built into the TV jack assembly The signal amplifier is housed inside the an tenna with the circuit board connected directly to the antenna elements Power to operate the am plifier 12 volt DC is supplied through the downlead cable which also carries the TV signals WARNING to the TV set The power supply separates the 12 switch ON to rece
147. nd there 15 no gas escaping during this delay It is also nor mal for the oven burner flame to cycle off and on at all temperatures except broil BR Shut Down Instructions When oven cooking 1s finished turn the oven control knob to the PILOT ON position the oven standby pilot will remain lit When the recreational vehicle is not in use or while traveling turn the oven control knob to OFF position and turn off main gas supply this will turn off the oven pilot MICROWAVE OVEN RANGE HOOD For complete operating instructions refer to the manufacturer s information provided with the oven ee MONITOR PANEL The monitor panel provides central location of switches for the hood fan hood light water pump and tank level indicator lights At the push of a single button this monitor panel simultaneously displays the coach battery 8 6 Wimme condition and levels of the water tank holding tanks and LP tank It also contains the water pump power switch and an indicator light to show when the pump switch is on XY GENERATOR START STOP HOLD START UNTIL DISPLAY ON WHEN GENERATOR STARTS GENERATOR RUNS LEVELS WATER TEST PUMP GENERATOR START STOP DISPLAY ON WHEN UNTIL GENERATOR RUNS GENERATOR STARTS WATER LEVELS WATER HEATER TEST x Water Heater Switch Be sure the water heater is filled with water before pressing this switch To f
148. ndle SLIDER WINDOWS Lift the latch handle straight out from the win dow Grasp the sliding window edge frame and slide the window to the side Be sure the latch 1s raised before trying to slide the window closed DAY NIGHTER PLEATED WINDOW SHADES Your coach may feature two stage pleated window shades that can be used for daytime or nighttime privacy Sun Filter The first lower section 15 a trans lucent white shade that can be lowered for priva cy without darkening the inside of the coach It can also filter out harsh direct sunlight to help keep the inside of the coach cool in summer or to disperse light for houseplants Room Darkening Privacy Shade The sec ond upper section is an opaque darkening shade for nighttime privacy and daytime room darken ing purposes Pull both the first and second sec tions down together or separately Tension Adjustment The tension of the pleated shades can be ad justed if they become loose and will not stay up when raised or they are too tight and are difficult to raise and lower SECTION 8 APPLIANCES amp INTERIOR FEATURES Guide Cord Spool To tighten the tension simply wrap the lower end of the guide cords on each side of the shade a few turns around the spools at the lower corners of the shades To loosen the tension unwrap the guide cords from the spools one turn at a time until desired tension is achieved We recommend that you fully raise pleat
149. ne 1 valve in passenger side rear cargo compartment Drain plug on outside of coach behind service door Use socket to remove drain plug Behind access panel on lower face refrigerator cabinet In passenger side rear cargo compartment 7 9 See also Safety Precautions Section 1 of this manual NOTE Because this model is available in sever al sizes and floor plans some items de scribed may be optional or unavailable on your coach The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent lab oratories to meet all applicable standards and codes set for RV appliances These appliances are covered by your New Vehicle Limited War ranty Certain items may be covered by individ ual manufacturer s warranty See your New Vehicle Limited Warranty for details REFRIGERATOR The refrigerator in your coach can be operated from either of two power sources available to the motor home 110 Volt AC electric LP gas The refrigerator 1s an absorption type which uses an ammonia water solution for cooling Ba sically ammonia vapor is distilled from the solu tion by heat produced from either LP gas or electricity and then carried to the finned condens er where it liquefies The liquid then flows to an evaporator where it creates cold temperatures through evaporation LEVELING Always park the vehicle on a level location when operati
150. ne Hookup jacks are located in the left or right front overhead com partment depending on model See your autho rizied Winnebago Industries dealer for proper installation and sealing of roof mounted compo nents TOSATELLITE i om DISH INPUT OUTPUT rin Ane DC AC ELECTRICAL VOLTAGE l INVERTER Optional DC AC The voltage inverter changes 12 volt DC cur rent into 110 volt AC current to operate your TV and VCR while traveling or when shoreline hookup 16 not available The voltage inverter 1s located in the video center in the right front overhead cabinet above the drivers compartment DC AC Voltage Inverter in Video Center The inverter must be switched on to operate Turn the inverter off when not in use to avoid draining the coach or automotive batteries EXTERIOR ENTERTAINMENT CENTER The exterior entertainment center contains a stereo radio CD player and convenient TV hook ups for your outside listening or viewing plea sure i Exterior Entertainment Center SECTION 8 APPLIANCES amp INTERIOR FEATURES SWIVEL GLIDER LOUNGE CHAIR This chair is not equipped with a seat belt and is not intended for seating while the coach is in motion The chair has a glide lock mechanism to prevent chair movement while the coach 1s mov ing The glide lock is located behind the seat skirt on the rear side of the seat base mechanism
151. ng or polishing the finish Care of Stripes and Decals The pressure sensitive decals on your coach require very little maintenance They should be treated like any painted surface on your vehicle Here are a few helpful hints on caring for decals Wash decals with plain soap and water or any retail car wash soap Always rinse thorough ly Keep high pressure wash nozzles at least 1 1 2 feet from edge of decals High pressure wa ter spray may cause edge lifting of decals Test any cleaning solution on a small section of decal before using Do Not use any aromatic solvents such as ac etone MEK toluene xylene etc on decals Any solvent including alcohol may soften or smear colors Do Not use lacquer thinner on paint or decals Do Not overcoat decals with clear paint Do Not let gasoline or other fuels drip and stay on decals for any length of time Rinse immediately UPHOLSTERY CARPETING AND DRAPERIES We recommend a weekly routine of vacuum ing all fabrics and carpet throughout the motor home to prevent an accumulation of dirt which can detract from the appearance and shorten the lift of carpet and fabrics Carpet Care amp Cleaning See the carpet manufacturer s Carpet Care Guide in your Owner InfoCase It includes detailed information on cleaning soils and 9 2 removing stains from the fine carpet in your coach Upholstery Some fabrics used in this motor home
152. ng the refrigerator while parked Operating the refrigerator off level for longer than hour can result in a form of vapor lock that could permanently damage the refrigerator Normal vehicle leveling to provide comfort for the occupants is generally satisfactory for refrig erator operation YAY ODO APPLIANCES amp INTERIOR FEATURES SECTION 8 A small round bubble level 15 provided with your refrigerator Place the bubble level on the bottom surface of the refrigerator and watch the position of the bubble in relation to the circle in top of the level gt If over 1 2 of the bubble is inside the circle in any direction the coach is level enough for con tinuous operation of the refrigerator while parked To prevent permanent damage to the refrigerator cooling unit turn the refrigerator off if the vehicle will be parked on an incline of over 3 side to side or 6 front to rear such as steep driveways or parking lots etc for more than one hour 8 1 SECTION 8 APPLIANCES amp INTERIOR FEATURES OPERATING INSTRUCTIONS Norcold Models with Electronic Auto Mode Control WU 1 7 ATI Push door handle downward and pull to open refrigerator Lift freezer handle to open Start Up Instructions Gas Mode The control panel is located between the freezer compartment and fresh food compart ment It conta
153. of layers caused by other factors such as physical damage or failure to properly maintain sealants is not covered by this warranty 2 slide out room assembly for defects in material or workmanship 3 Structural defects of the subfloor and floor Floor lamination failure and lamination failure of the subfloor panels and risers are covered by the structural warranty Winnebago Industries Inc P O Box 152 Forest City lowa 50436 ATTENTION WARRANTY DEPT WINNEBAGO INDUSTRIES RESPONSIBILITY Any part of the vehicle subject to warranty which is found to be defective in material or workmanship will be repaired or replaced at Winnebago Industries option upon notice of the defect without charge to the customer for parts or labor While any Winnebago Industries motor home dealer can perform warranty service we recommend you return to the dealership that sold you your vehicle If you are touring or have moved contact any Winnebago Industries motor home dealer in the United States or Canada for warranty service CUSTOMER RESPONSIBILITY WHEN REPAIRS ARE NEEDED If a part of the system covered by this warranty fails to function or requires service during the warranty period 1 Promptly take the vehicle to the selling dealer for repair or inspection 2 Written notice of defects must be given to the selling dealer or manufacturer no later than 10 days after the expiration of the warranty 3 the dealer is incapable of
154. of the mechanism and hydraulic system e See the HWH guide in your InfoCase for maintenance information If Slideout Room Will Not Operate Trouble shooting e The chassis battery may be low on charge Press the Aux Start switch on the dash to the momentary MOM position while pressing the slideout control switch This momentarily connects the coach batteries to assist in re tracting the room e The circuit breaker may be tripped The cir cuit breaker is located on an interior wall of a passenger side storage compartment just be hind or ahead of the main entrance door Slideout Breaker e If the batteries and breakers are okay there may be a failure the mechanism or electri cal system See Manual Retracting Instruc tions for help Slideout Room Extension Emergency Crank In Procedure Use Only when room will not retract using Control Switch If a failure occurs in the slideout electrical or mechanical systems and the room will not retract using the control switch you can manually re tract the room using the emergency crank assem bly described below The pump 15 located a bracket attached to the chassis frame beneath the coach about mid way on the left side of the vehicle just ahead of the rear wheels Step 1 Relieve Hydraulic Line Pressure e Open the hydraulic pump slideout solenoid valves to release hydraulic line pressure and let fluid bypass into the
155. on to display the operating mode e If 120 volts AC is not available the refriger ator will switch to the gas operation The AUTO indicator and the LP GAS indicator will illuminate After 10 seconds the LP GAS indicator will turn off and only the AUTO indicator will remain illuminated Press and quickly release any button to dis play the operating mode During operation in the AUTO mode when a higher priority power source becomes avail able the operating controls will cease using the current power source and will switch to the higher priority power source For example if AC electric becomes available while the refrig erator 1s operating in the AUTO LP GAS mode the refrigerator will switch to AUTO AC opera tion If an operating mode 1s not functional its corresponding indicator will flash and the refrig erator will attempt to operate in a lower power uimme priority source If a lower power priority source is not available the indicator will continue to flash and the refrigerator will cease operation until the energy source is corrected Refer to the Diagnostic section on page 7 of the Norcold 9100 Series Refrigerators Operator s Guide your blue binder Start Up Instructions Manual Mode To operate the MANUAL mode press and hold the MODE button until the AUTO indicator disappears the desired operating mode 15 displayed If the power source 15 interrupted while operating i
156. only by your deal er or a qualified LP gas service center e Never attempt to connect natural gas to the LP gas system SECTION 5 LP GAS SYSTEM e Have the entire LP gas system inspected for possible leaks and missing or damaged parts at each tank filling Also inspect before and after each trip and any time trouble is sus pected e Turn the LP supply valve off when not using the LP gas system e Never use a wrench to tighten the tank supply valve It is designed to close leak tight by hand If a wrench 15 required to completely close the valve it is defective and must be re placed e Never allow the tank to be filled above the 80 percent level indicated by the flow of liquid gas out of the overflow valve or by the auto matic stop fill device e Be sure appliance and outside vents are open and free from obstruction when using the LP gas system e Never attach a lock or any device requiring a key to the LP tank compartment door Ac cording to standards set for recreation vehi cles the LP supply valve must be readily accessible in an emergency e Exercise caution when drilling holes or at taching objects to the walls Gas lines and electrical wiring could be seriously damaged and present an extreme safety hazard HOW LP GAS WORKS LP Liquefied Petroleum gas is a true gas compressed into liquid form for easy transporta and storage LP gas is available two types propane and butane It is also c
157. or 4 on the TV Refer to your TV operating guide for detailed in structions on selecting video aux input SATELLITE TELEVISION SYSTEM Optional The Satellite Television System allows you to receive TV programs directly from satellite to your coach The programs are transmitted in dig ital format so the quality is equal to laser disc or CD SECTION 8 APPLIANCES amp INTERIOR FEATURES See your Winegard RV Digital Satellite Antenna System Owner s Manual for instruc tions about aiming the satellite antenna dish There is a supplemental Quick Reference Guide for the system with Receiver The coach must be level before attempting to aim the antenna dish See your Satellite Receiver User s Manual for instructions about setting up the receiver and remote unit We recommend that you read both of these manuals thoroughly to understand the system completely before attempting any setups or adjustments Satellite System with Optional Video Control Center Press the SAT switch to connect the TV to the Satellite system The satellite system is hooked through the SAT input of the video control center Satellite System without Optional Video Con trol Center Turn off the power switch for the TV Antenna Signal Amplifier to route the sys tem signal to the TV input jacks Satellite System Wiring This coach is pre wired for installation of a digi tal satellite system DSS if your coach was not factory equipped with o
158. or the towed vehicle s weight and hitch ball weight The combined weight of the coach and the towed vehicle should not exceed the coach s Gross Combined Weight Rating GCWR Also the combined weight of the coach and the towed vehicle s hitch ball weight should not exceed the coach s Gross Vehicle Weight Rating GVWR or its rear Gross Axle Weight Rating GAWR listed on the Vehicle Certification Label Because of individual vehicle use and loading habits we recommend weighing the vehicle while fully loaded to avoid exceeding any of the listed Gross Weight Ratings See Vehicle Certi fication Label the Introduction Section for in formation on gross weight ratings Towing will affect vehicle handling durabili ty and fuel economy Exceeding any of the listed Gross Weight Ratings will result unacceptable overall vehicle performance Maximum safety and satisfaction when towing depends on proper use of correct equipment Select a drawbar that mates properly with the towing hitch receiver and provides proper align ment to the vehicle tow bar The tongue of the tow bar must be as close as possible to parallel with the ground when attached to the hitch ball Installation of a proper trailer brake system 15 recommended Check state regulations on trailer weight and trailer brake requirements to be sure you Select the right equipment before towing NOTE If you tow a car or trailer that weighs over 1 000 Ibs it must b
159. ormed GENERATOR OPERATION WARNINGS AND CAUTIONS WARNING The exhaust of all internal combus tion engines contains carbon monox ide CO This poisonous gas 1s colorless odorless tasteless and lighter than air The exhaust systems of both your motor home engine and your generator engine have been installed with your safety in mind However certain precautions must be taken when using them to protect yourself from conditions beyond the control of the manufacturer 1 Do not simultaneously operate the generator engine and a ventilator which could draw exhaust gases into the vehicle 2 Do not open windows or ventilators on the end or side of the vehicle where exhaust pipe of the generator 15 located 6 6 Minnie Y 3 Park the vehicle so that the wind will carry the exhaust away from the vehicle Also note the position of other vehicles to be sure their exhaust will not enter your vehicle 4 Do not operate the generator engine when parked if vegetation snow buildings vehi cles or any other object can deflect the exhaust under or into the vehicle Check auxiliary generator oil level frequently during periods of use Refer to the generator manufacturer s information in your Owner Info Case for specific recommendations WARNING Never check generator oil level while generator engine 15 running 12 VOLT DC SYSTEM The DC voltage system consists of the auto motive battery and
160. orrected at the factory In addition dealers are obligated to inspect each vehicle upon delivery to them and prior to delivery to you You should also immediately inspect appearance items and advise your selling dealer of any discrepancies Damage and normal deterioration due to use and exposure is not covered by this warranty CHANGES IN DESIGN Winnebago Industries Inc reserves the right to make changes in design and changes or improvements upon its products without imposing any obligation upon itself to install the same upon its products theretofore manufactured NEW YORK If your motor home has been repaired three or more times for the same nonconformity defect or condition or if your motor home has been out of service by reason of repair for twenty one days Section 198 a of the General Business Law of the State of New York requires you to provide written notice by certified mail return receipt requested to Winnebago Industries or its authorized dealer before making any claim under that section of the law If you do have problems with your motor home you should provide written notice to Winnebago Industries at the following address Winnebago Industries Inc P O Box 152 Forest City lowa 50436 Atten Owner Relations ZIP CODE IMPORTANT THIS NOTICE IS TO BE USED ONLY FOR RECORD KEEPING BY WINNEBAGO INDUSTRIES The completed form does not constitute an actual change of ownership Mimmie
161. oulder 6 2220000 2 7 Leather Upholstery tusviwtisie 9 5 Lighting Oven 2 222 8 5 9 8 Loading he Vehicle cerros issie 4 1 1 5 LPE CISA 1 3 LP Gas Umma aoa io cote casas stad 8 11 ER AS LEIK can 1 3 5 4 LEVE l aeieea 8 7 LP GaS OUMU 5 2 EP GaSe SUPPLY 4 1 Wank 5 2 IVI ALE ATNG 6 gt 1 5 Maximum 4 3 MIOS 2 9 Monitor 8 6 Motor Aid Water Heater and Rear Auxiliary Heater Maintenance 8 10 8 10 Motor Home Jacking and Tire Changing PEOCE GUIS 3 1 Mountain Driving 4040022 2 1 4 7 N Nighttime 0 0222 4 7 O Operating Oven 22 8 6 Options and Equipment 0 2 Overhead Front 8 17 Owner s InfoCase sisi soci 0 1 Parkie Brake cennar 2 3 Phone and Cable TV Hook 8 15 PONET
162. produce caustic acid explosive gases and electrical current which may cause burns It 15 important that the instructions below are followed exactly or personal injury particularly to eyes or prop erty damage may result due to battery explosion battery acid or electrical short circuit burns e NEVER smoke near the battery or expose it to open flame or electrical sparks e Wear eye protection or shield your eyes while working near battery in case an explosion does occur NEVER lean over a battery e Do not allow battery fluid to con tact eyes skin clothing or painted surfaces Immediately flush any contacted area with water If eyes are affected seek medical help after flushing e Remove all metal jewelry to lessen the risk of a short circuit occurring CONNECTING JUMPER 1 Make sure that the other vehicle has a 12 volt battery and negative ground compatible with your vehicle s electrical system Position the vehicle with the good battery so that the jumper cables will reach but do not allow the vehicles to touch Turn off all electrical accessories motors and lights except those needed for safety or to light up the work area Place automatic transmission in P Park Be sure parking brakes are engaged both vehicles SECTION 3 IN CASE OF DRIVING EMERGENCY 4 Ifthe weak battery has filler caps make sure the electrolyte 15 at proper level Add dis tilled water if fluid is low If elect
163. r vehicle abandon it Do not attempt to return to your vehicle before the water has receded e Do not attempt to wade to your vehicle if the water is above your knees fast moving water exerts an enormous amount of pressure mak ing it impossible to remain standing or walk ing Do not try to drive through flooded areas e Follow instructions of local authorities Leave immediately when advised to do so Many lives have been lost because people did not heed warnings e Have on hand survival supplies for several days including food water first aid equip ment and necessary medications In desert ar eas during hot weather allow 3 4 gallons of drinking water per person per day e Before you leave home inform someone of your destination and when you expect to re turn Authorities at your destination should be notified immediately if you do not arrive on time REMEMBER THESE TERMS WATCH Severe weather may develop in the specified area Be alert and prepare for possibility of an emergency WARNING Severe weather is occurring or 1s imminent in certain areas Move to a safe loca tion immediately We highly recommend that you obtain a weather radio These radios offer up to date weather reports The latest information and fore casts are broadcast by local National Weather Service offices in recorded messages that last Mime Wimme from three to five minutes These messages are replayed continually 24 hours a da
164. raining water and blowing out water lines Place in BYPASS position ONLY when using antifreeze solution in water lines MOTOR AID Optional The motor aid acts as a heat exchanger be tween the water heater and the vehicle engine Two hoses from the water heater connect to the hoses which deliver hot water between the engine and the driver s compartment heater A heat ex changer in the water heater then circulates the water from the engine radiator around the water heater tank Under normal conditions the entire contents of the water heater tank will be heated to approximately 140F in about two hours or 100 miles of driving 8 10 Wimmie In addition the motor aid heat exchanger helps the vehicle engine to operate at cooler tem peratures by dissipating heat from the engine This reduces the possibility of overheating par ticularly when operating in hot climates Any leak the heat exchanger or its supply or return lines could cause loss of coolant and subsequent engine fail ure We recommend that you periodi cally inspect these connecting lines and the heater to insure that no leaks have developed Motor Aid Water Heater and Rear Auxiliary Heater Maintenance Have your authorized dealer check all hose clamp connections on the rear automotive heater and the motor aid water heater at least every six months and tighten them if necessary WATER HEATER BY PASS VALVE Your coach may b
165. re type wash ers to avoid loosening exterior decals or sealants etc NOTE Avoid aiming water flow from a hose or spray from high pressure washing equip ment into any appliance intake or ex haust vents which could cause damage or difficulty in operating appliances After washing the motor home carefully 1 spect caulking around window frames and vents and any other joints that may have separated Re caulking if necessary is quite simple Appropri ate compounds are sold at Winnebago and Itasca dealers and the materials are quickly and easily applied Also inspect weather seals around door etc and if necessary have a dealer replace them immediately Never use a strong solvent such as lacquer thinner or harsh abrasives on painted surfaces Waxing and Polishing When water will not bead up and roll off the finish of your freshly washed vehicle it s time to apply a new coat of wax to the finish Wax not only improves the appearance of the vehicle but protects the finish against oxidation and corro sive substances We recommend using a wax that is compatible with painted and gel coated fiberglass finishes If the finish begins to look dull or discolored it may need to be cleaned with a polishing or cleaning compound 9 1 WE SECTION 9 CARE amp MAINTENANCE NOTE If you use a polish or a cleaning com pound that does not contain a wax pre servative we recommend reapplying a coat of wax after cleani
166. rolyte is not visible or appears to be frozen do not attempt jump starting A battery may rup ture or explode if the electrolyte is frozen or not filled to the proper level Connect end of the positive red jumper cable to the positive terminal of the weak battery Connect the other end to the positive terminal of the charged bat tery Connect one end of the negative black jumper cable to the negative terminal of the charged battery Finally connect the remaining end of the negative black cable to a solid metal grounded location on the engine of the vehi cle with the weak battery at a point at least 18 inches from the battery Do not connect to any moving parts THE MAIN SAFETY PRECAUTION IS TO MAKE THE FINAL GROUND CONNECTION ON THE ENGINE AT A SAFE DISTANCE FROM THE BATTERY THIS HELPS TO REDUCE THE CHANCE OF EXPLO SION DUE TO SPARKS Start the engine of the vehicle with the charged battery and allow it to run for a few minutes at moderate r p m Then start the engine of the vehicle with the discharged battery Reverse the above sequence EXACTLY when removing the jumper cables Start by removing the cable from the ground location on the engine first then continue in reverse sequence WARNING Do not attempt to push start this vehi cle Damage to the transmission or other parts of the vehicle could occur 3 IN CASE OF
167. s located in several areas of the coach SECTION 2 DRIVING YOUR MOTOR HOME Please refer to the RV Radio manufactur er s operating guide your InfoCase for detailed instructions on programming preset station but tons and using this full featured radio audio sys tem Deluxe Sound System Optional Your coach may be optionally equipped with a deluxe sound system featuring special high output cube speakers and subwoofers to enhance your listening enjoyment Place the Ignition Switch in ACC accessory position to listen to the radio when parked A speaker selector switch in the front over head cabinet video center lets you switch the deluxe speakers to your desired sound source whether the dash radio or the TV and VCR for theater surround sound listening SPEAKER SOURCE SELECT SWITCH P Radio Power Switch The radio power switch lets you connect the dash radio to the house batteries with the ignition switch turned off for listening while parked This prevents accidental draining of the chassis start 2 11 SECTION 2 DRIVING YOUR MOTOR HOME ing battery during prolonged operation of the ra dio BATTERY BOOST SWITCH This switch can be used to provide emergency starting power from the motor home auxiliary battery if the automotive battery is dead Aux Start Switch If engine battery is dead press and hold the switch while turning key for emergency starting power
168. s without the video control center option be sure the TV antenna amplifier switch is turned OFF while connected to cable The antenna amplifi er will make the cable TV signal snowy or block it out completely VIDEO SELECTOR SYSTEM The optional video selector system allows you to switch the antenna cable TV or VCR signal to any set location in the coach This means one person can watch a ball game coming in on the roof antenna on the bedroom TV while another person watches a cable TV pro gram or a video tape on the VCR on the front TV Also two people can watch different programs SECTION 8 APPLIANCES amp INTERIOR FEATURES on the two TV s while taping a third program on the VCR Components MAIN Front or Lounge TV VCR VCR DVD Combo Player TV2 Bedroom or Rear TV TV ANT Power TV Signal Amplifier Signal Inputs AUX Press to connect VCR or selected TV to an electronic accessory component which you may have installed later such as a Digital Video Disc DVD player SAT Press to connect VCR or selected TV to the Digital Satellite System dish antenna ANT Press to connect VCR or selected TV to the roof antenna VCR Press to connect selected TV to the VCR CABLE Press to connect VCR or selected TV to a cable TV system hookup Video Input Selection To watch the VCR or DVD you must go to the TV menu and select Aux Input It will not work to simply select channel 3
169. se or breaker will shut down that circuit If this happens turn off all affected lights or appliances and reset the breaker or replace the fuse with a new one of equal amperage rating A label on the panel states the amperage rating and circuit protected for each fuse or breaker FUSE OR CIRCUIT BREAKER PANEL The fuse or breaker panel is mounted on the right hand side of the power converter 12 Volt 110 Volt House Fuses Circuit Breaker Power Center SECTION 6 ELECTRICAL SYSTEMS The fuse panel accepts only blade type plug in fuses Always replace fuses with those of the same amperage rating Bad Fuse Good Fuse BATTERY INFORMATION CHASSIS BATTERY ACCESS The automotive starting battery 1s located in the engine compartment AUXILIARY HOUSE BATTERY ACCESS The house battery is located in the battery storage compartment beneath the inside entrance steps for convenient access for periodic inspec tion or maintenance r m lt FT 4 5 26 House Battery Entrance Step To service or remove the batteries unfasten the retainer strap and disconnect battery cables 6 7 6 ELECTRICAL SYSTEMS Lead acid type batteries are electro chemical devices for storing and releasing electrical charge As such they are simply an electrical res ervoir not an electrical source As soon as energy
170. t operating the equipment in your motor home When it comes to service remember that your dealer knows your vehicle best and 15 interested your satisfaction 0 2 mE Your dealer will provide quality maintenance and any other assistance that you may require during your ownership of this vehicle If you need warranty repairs while traveling you may take your motor home to any Winneba go or Itasca dealership and they will assist you Your new vehicle is covered by a factory watranty against defects in material and work manship This warranty should be validated 1m mediately and returned to the factory by your dealer For additional information see your New Vehicle Limited Warranty included with this vehicle DRINKING AND DRIVING Winnebago Industries supports the recom mendations of the Presidential Commission on Drunk Driving e Exercise your good judgment and encourage others to do the same e Know the legal limits and do not exceed them e Also know your personal limits which may be lower than the legal limits e Should you ever exceed your limits find al ternative transportation call a cab ask a friend to drive you home or call a family member to come and get you The presence of alcohol in significant levels in the blood increases the probability that the driver will be involved in an accident REPORTING SAFETY DEFECTS If you believe that your vehicle has a defect
171. ted on a cabinet face near the floor of the coach A green light on the face of the alarm shows when the unit is active If the detector senses LP gas the alarm will make a loud pulsating sound and the red light will come on Pressing the MUTE button will stop the alarm for 60 sec onds If there is no more detectable LP gas the alarm will stay off If the detector still senses LP gas by the end of the 60 second mute mode the alarm will sound again Press to stop alarm Be LP GAS LEAK DETECTOR OPERATING 10 VOLTAGE Green Red Amber Active Alarm Low Batt If The Alarm Sounds Ifthe alarm sounds do not touch any electrical switches Immediately turn off the main LP tank valve and all LP appliances open all windows 1 3 AN SECTION 1 SAFETY PRECAUTIONS and roof vents and leave the coach until the alarm stops sounding If the alarm keeps sounding at regular inter vals a leak may be present Contact your dealer or an LP gas service center to have the problem corrected before using the LP system again If the coach batteries become extremely drained 8 5 volts or less the amber Low Volt age FAULT light on the face of the alarm will come on and in some rare cases the LP alarm may begin to sound on its own If this happens connect the shoreline to 110 volt supply to re charge the house batteries Other Combustible Fumes or Vapors This alarm is designed to detect the presence of
172. ter automatically changes a portion of the 110 volt current to 12 volt DC current All equipment in the motor home that 15 normally powered by the auxiliary battery is then powered through the converter In addition the following equipment 15 entire ly dependent on 110 volt current roof air condi tioner refrigerator when placed 110 volt mode microwave oven any 110 volt elec trical equipment used at convenience outlets na EXTERNAL POWER CORD J Shoreline The external utility power cord commonly re ferred to as a shoreline is stored in the utility compartment on the left driver s side of the coach ELECTRICAL SYSTEMS SECTION 6 Shoreline Cord Shown connected to generator outlet WARNING Do not connect the external power cord to any receptacle until you have contacted the owner and or attendant of the premises to verify proper polar ity and grounding It is the responsibility of the owner of the electrical receptacle to ensure that the receptacle is properly wired and grounded Reverse polarity and improper grounding of the vehicle can cause personal injury or death To connect to an external power source re move the cord from the storage compartment and plug it into a suitable power receptacle An access hatch the compartment floor lets you route the shoreline cord out the bottom of the compartment so you can close the compartment door while t
173. tered during blow out procedure Close dump valves to prevent valve shafts from rusting and to prevent entry by rodents and insects Refit the dust cap onto the drain outlet Your drainage and fresh water systems are now totally winterized 16 Have the vehicle chassis completely serviced and lubricated Be sure radiator antifreeze protection level 15 sufficient for the lowest anticipated temperatures 17 Wash and wax the coach 18 Inspect all seams and seals around doors windows vents and any other joints Replace or repair any that are damaged Sealing materials and compounds can be purchased from your dealer Badly damaged weather seals may need to be replaced by your dealer 19 Close all windows and roof vents Protect all appliance vent openings from contamination by animals or insects e g bird nests wasp nests etc 20 Lubricate all door hinges and locks 21 Clean the interior of the coach Dirt and stains are more easily removed when fresh 22 Remove all foods and items that may cause odors 23 Clean and defrost the refrigerator Leave the door slightly ajar to allow any odors to dissi pate Place an open box of baking soda SECTION 10 STORING YOUR MOTOR HOME he inside the refrigerator to help absorb odors 24 Turn the furnace thermostat switch on the bottom of the thermostat to OFF 25 Turn auxiliary battery Aux Batt switch off If your coach does not have an Aux Batt switch disconnect a
174. the 12 volt motor home aux iliary batteries Automotive Starting Battery The chassis battery is used solely to operate the engine starter and all automotive accessories and controls found on the instrument panel This includes the horn speed control all exterior lights radio windshield wipers rear auto heater fan etc House Batteries The house batteries supply current to all 12 volt equipment located the living area of the motor home This includes interior lights range exhaust fan furnace fan water pump water level and holding tank gauges 110 volt generator starting refrigerator bath roof vent fan and the rear automotive heater The house battery may also be used to start the engine if the chassis battery is dead Refer to Aux Start Switch The house batteries are type bat teries specially designed for recreational vehicle use They will provide longer lasting power than standard automotive batteries and will withstand the frequent drain and recharge cycles that occur under the demanding conditions of a camping outing The house batteries are automatically charged by the engine alternator while the engine 1s run ning 12 VOLT HOUSE FUSES AND CIR CUIT BREAKERS All 12 volt circuits and equipment in the coach area of the motor home are protected by ei ther a fuse panel or breaker panel When a circuit is overloaded or a short develops in any part of the system a fu
175. the range in your home does One benefit of gas burners 15 that heat is available as soon as a burner 1s lit as opposed to an electric element slowly heating up The range has a Pilot Off position on the oven control which allows the oven pilot to be turned off when traveling or refilling the LP tank The following warning label has been located in the cooking area to remind you to provide an adequate supply of fresh air for combustion Minne A WARNING IS NOT SAFE TO USE COOKING APPLIANCES FOR COMFORT HEATING Cooking appliances need fresh air for safe operation Before operation 1 Open overhead vent or turn on exhaust fan 2 Open window FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY Unlike large homes the oxygen supply inside a recreational vehicle 15 limited due to its size To avoid danger of asphyxiation provide proper ventilation when using the gas rangetop or gas oven It is especially important not to use the gas oven and range top for comfort heating Danger of asphyxiation 1s greater when these appliances are used for long periods of time WARNING Portable fuel burning equipment including wood and charcoal grills and stoves should not be used inside the recreational vehicle The use of this equipment inside the recreational vehicle may cause fires or asphyxia tion Using Range Top Burners 1 Rotate the Top Burner Ignitor knob clock wise in the direction of the L
176. ting and 9 2 9 4 Ultraleather 9 5 Ca DNEV eee tiara 9 5 Vinyl Wallboard 9 5 Tables and Countertops 9 5 SUING 9 6 Galley Sink 9 6 Range 9 6 aye het 9 7 Doors 9 7 Vehicle Maintenant 9 7 A 9 7 Suspension Alignment Tire Balance 9 8 Windshield Washers and Wiperts 9 8 9 8 Awning 2 0000 222 9 9 SECTION 10 STORING YOUR MOTOR HOME Preparing Vehicle for 10 1 Cold Weather Storage 10 1 Removal from 10 3 Mimmie Congratulations the purchase of your new Minnie Winnie motor home which has been carefully designed engineered and quality built by Winnebago Industries Inc ABOUT THIS MANUAL Please read this operator s manual complete ly to understand how everything in your coach works before taking it on its maiden voyage This manual is a guide to safe operation of the features equipment
177. tion MOTOR HOME JACKING AND TIRE CHANGING PROCEDURE Follow the chassis manufacturer s recom mendations for jacking and tire changing These instructions are found in the chassis operating guide in your Owner Infocase A jack is designed for use as a tool for changing tires only not for use as a leveling device or as a support for service purposes TIRE CHANGING SAFETY PRECAUTIONS Before attempting to change either the front or rear tires the following precautions should be headed 1 Park vehicle on level surface only 2 Turn off engine and set parking brake 3 Activate hazard warning flasher 4 Block both front and back of wheel opposite wheel to be removed 5 On soft ground use a board or other material under jack as a firm base to ensure that the jack will not shift 3 1 3 IN CASE OF DRIVING EMERGENCY 4 WARNING DO NOT crawl under the vehicle when it 1s supported by a jack NOTE When installing the outboard rear dual wheel and tire assembly rotate the outer dual wheel so valve stems are accessible but not touching one another In some cases this means that the inner and outer valve stems should be in separate wheel cutout locations When installing or tightening dual wheels both wheels on the same side must be off the ground not resting on the inner dual This minimizes the possibili ty of loose wheels after correct mounting torque is applied WHEEL NUTS To properl
178. tions to give passengers a choice of seating arrangements You may use all of the belted seated positions providing you stay within your vehicle s GVWR listed on the Vehi cle Certification Label see the Introduction Sec tion However you use or load your vehicle it is your responsibility to keep the weight within its stated gross vehicle weight rating ROOF LOADING The roof on most models is capable of carry ing some lightweight articles while the vehicle is in motion A roof mounted luggage carrier de signed for this purpose is available from your dealer However roof load while the vehicle 15 in motion 1s not to exceed 10 pounds per square foot or a maximum of 100 pounds When the vehicle is stationary a cargo load of 100 pounds plus the weight of a 225 pound per son to load the cargo or to conduct inspection and maintenance is permissible Weight added to both the roof and the trailer hitch contribute to the gross vehicle weight which must not exceed the vehicle s GVWR MAXIMUM OCCUPANCY The following label is placed in a visible location in the driver compartment CAR OR TRAILER lt 8 TOWING The factory installed towing hitch on this coach is capable of pulling 5 000 Ibs max and 4 3 SECTION 4 TRAVELING WITH YOUR MOTOR HOME carrying 350 16 max the hitch ball How ever your coach s towing and hitch ball capacity may be less due to the coach s loaded weight and
179. tor cool in the event of a failure of the refrigerator s operat ing controls If a failure occurs the TEMP SET indicator flashes and refrigerator switches to the BOS mode This mode provides refrigeration until the refrigerator is serviced The fresh food and freezer compartment temperatures should be monitored to prevent over freezing or thawing of refrigerator contents when operating in the BOS mode If the refrigerator temperature 1s too cold adjust the thermostat to a lower number in single increments If the refrigerator temperature is too warm adjust the thermostat to a higher number in single increments Let the refrigerator operate at the new setting for one hour before rechecking the freezer and fresh food compart ment temperatures Frequent door opening pre vents the temperatures from stabilizing Although the refrigerator can operate in this mode Norcold recommends that you seek ser vice to restore manual operation as soon as prac tical HUMIDITY STORAGE SWITCH Turning this switch to HIGH HUMIDITY will keep the surface between the door openings dry during high humidity conditions The switch should be left in the NORMAL OPERATION position unless moisture collects around the door When storing your RV for the winter place this switch in the STORAGE LIGHT OFF po sition This shuts off all DC power to the light and humidity heater and allows the refrigerator door to be left open for airing without draining the ba
180. ts and Blankets If you feel too warm try using a premium 100 cotton mattress pad 100 cotton sheets and an open weave cotton blanket FRESH WATER TOILET The fresh water toilet in your motor home is very similar to the household type except that it is designed to use only a small amount of water per flush It uses a high velocity jet of water pro ducing a swirl effect to efficiently cleanse the bowl And since each flush uses fresh water no special chemicals are required other than a de odorizing agent if necessary Flushing The Toilet 1 To add water to the bowl before using step on the small pedal to the right Hold pedal until desired level of water is reached Release pedal slowly do not allow it to snap back Generally more water is required only when flushing solids 2 flush the toilet step on the large pedal to the left The large pedal also depresses the small pedal Hold pedal until bowl is clean 8 22 3 Release pedal slowly small amount of water should remain the bowl Please refer to the manufacturer s information supplied with the toilet for further operating and maintenance instructions Important Don ts e Don t use facial tissue or regular toilet tissue in the RV toilet These will not disintegrate sufficiently and will often cling to the sides of the holding tank Toilet tissue made specifi cally for use in RV toilets and holding tanks is avail
181. ttery 8 3 SECTION 8 APPLIANCES amp INTERIOR FEATURES Operating Tips e The refrigerator should already be cold be fore placing items in it e Food and beverages should also be cold be fore placing in RV refrigerator Never put warm or hot items in a cold refrigerator e Do not pack the refrigerator too full The re frigerator needs room for cold air to circulate e Use smaller containers for each item e g a half gallon container of milk instead of a half full gallon jug e Always put foods especially liquids tight ly sealed containers e Use crumpled paper between loose items to reduce rattling or clinking noises Further Information For further information and operating cau tions see the Norcold refrigerator operating 1 structions included either inside the refrigerator or in your Owner InfoCase REFRIGERATOR COMPARTMENT Exterior The exterior refrigerator compartment allows access to the rear of the refrigerator for inspec tion maintenance and service 8 4 Wine To Open 1 Use coin to turn the latch knobs to the ver tical position as shown 2 Remove the door from the opening To Close 1 Replace the door into the opening 2 Push the latch knobs in while turning to the horizontal position as shown RANGE AND OVEN The range and oven in your motor home are operated on LP gas and will provide nearly all of the functions that
182. uideline for future loading limits and weight distribution The gross weight of the vehicle should not exceed the Gross Vehicle Weight Rating GVWR specified on the Vehicle Certification Label on the rear inner jamb of the drivers door see page 0 4 The front and rear axle weight also should not exceed the corresponding Axle Weight Rating specified on the Vehicle Certifi cation Label To determine the weight on either the front or rear axle drive that axle only onto the scale Neither axle weight should exceed the corre sponding maximum axle weight rating specified on the certification label Corner Weighing Side to Side Weighing each corner of the coach sepa rately single LF RF front wheels or LR RR rear dual sets is an accurate method to determine how to distribute your cargo to avoid overload ing especially on tires To determine the weight distribution on each tire or dual set you will need to find a scale capable weighing side to side or all four cor ners of the vehicle separately A truck scale may be used if the ground 15 level with the scale surface and the scale has clearance to drive one side of the coach onto the scale as shown below Drive the coach on the level area next to the scale and straddle the scale so that only one side of the coach will be on the scale pad Pull only the front wheel onto the pad as shown Weighing Left Front Corner When the front wheel has been weighed pull
183. uipment completely and how to use the equipment safely BEFORE DRIVING YOUR VEHICLE Before preparing to drive your vehicle here are a few recommended procedures that will add to your driving safety and enjoyment 1 Be sure that you adjust the interior and exte rior rear view mirrors to your driving prefer ence Adjust the driver s seat for proper distance from foot pedals and steering wheel to allow for safety and ease in controlling your vehi cle 3 Place front seats in the forward facing posi tion 4 Be sure to fasten all safety belts to fit you comfortably but tight enough to obtain the full safety of the belts Make sure all doors are completely shut and locked When the doors are shut and locked 2 1 SECTION 2 DRIVING YOUR MOTOR HOME there is less chance of the doors flying open in event of an accident It also prevents unin tentional opening of doors and keeps intrud ers out of your vehicle 6 Check to see that all gauges are operating properly 7 Check the fuel level the vehicle 8 certain that the fire extinguisher is fully charged and secure in its mounting bracket Be sure hood and all compartment doors are latched securely before driving vehicle KEYS Your motor home is supplied with several sets of keys In addition to the chassis manufacturer s ignition key you receive keys for front doors en trance door and exterior compartment doors Each s
184. umbers fluctuate fairly frequently due to changes in temperature within the vehicle and changes in elevations when you travel Be sure to check your settings when you first lay down on the bed and adjust it as necessary It 15 normal for the numbers on your remote to fluctuate slightly and it is not necessary to make any adjustments Some reasons for the numbers to fluctuate include weight differences on the bed change in sleeping position heat from an electric blanket change 1 room temper ature or weather However if you notice that your bed 15 get ting softer night after night and your Sleep Num ber consistently gets smaller check to make sure that you have a tight connection between the hose and the air chamber You should hear it click when it connects Mattress Care Cleaning the Mattress Cover We recommend spot cleaning your mattress cover with sparkling water soda or mild deter gent DO NOT dry clean the mattress cover or put it in a washing machine Also please do not apply stain guard as it may cause yellowing of the fabric For allergy sufferers an added benefit of owning a Sleep Number mattress is the ability to 8 21 SECTION 8 APPLIANCES amp INTERIOR FEATURES air it out by unzipping it or cleaning the surface of the air chamber with a vacuum attachment or by applying a bleach solution use 1 tablespoon bleach to 1 cup water and apply with a rag to surface of air chamber only Shee
185. umn See your chassis operating guide for additional fuse replacement information AWNING INSTALLATION NOTE See your Winnebago or Itasca dealer for installation of awnings Your dealer s service department has information showing locations of awning bracket supports in the sidewall of the coach Ay CAUTION Improper awning installation may result in damage to the coach SECTION 9 CARE amp MAINTENANCE a 9 9 PREPARING VEHICLE FOR STORAGE Properly preparing your vehicle for storage will lessen the possibility of damage to your vehicle Prepare the motor home for vacancy just as you would if you were leaving your house for an extended period e Remove all perishables from cabinets and re frigerator Prop refrigerator door open Turn off LP gas tank Drain water heater water tank and holding tank e Close shades to protect upholstery from sun light When storing your vehicle through the winter or 1 cold climates extra preparations need to be made to protect systems that can be damaged by freezing temperatures Cold Weather Storage Procedure Winterizing 1 Clean and dump holding tanks by following steps A B and C A Add water to the sewage holding tank by holding the toilet flush lever open with the water pump running Add wa ter to the waste water holding tanks by opening the kitchen shower and lavato ry faucets Tanks should be about 1 4 to 1 3 full to rinse properly
186. unning such as when driving down the road These three sources can prevent excessive discharge of the house battery NOTE The holding tank heater pads are electri cal resistance type heating elements This type of heating element typically uses large amount of current while operating If the tank heaters are used without a recharging source they will drain the house batteries in a relatively short period Typically the batteries would not support overnight heating without a supplemental charging source HOLDING TANK HEATER TURN OFF when not in use SEE OPERATOR S MANUAL HOLDING TANK LEVEL INDICATORS The holding tanks may be monitored on the wall mounted monitor center Press the Levels Test switch to check the level in each tank See Section 8 Appliances for further infor mation on the monitor panel WATER DRAIN VALVES The water drain valves are used to drain water from the water tank and the water supply lines when preparing the motor home for storage or when sanitizing the water system To open or close the drain valves turn the handles in the directions indicated by the follow ing illustration Drain valve locations are listed on the follow ing pages DRAIN LINE END VALVE IN LINE VALVE Water Drain Valves typica SECTION 7 PLUMBING SYSTEMS Water System Winterization Valve Your coach is equipped with a manually operated water line winterization system for your conven
187. y The record ed messages are revised every three to four hours or more frequently when appropriate When severe weather threatens forecasters at the local National Weather Service office inter rupt the broadcasts with storm warnings either recorded live as the situation demands The frequencies used for NOAA Weather Ra dio National Oceanic and Atmospheric Admin istration nationwide are 162 40 162 475 or 162 55 megahertz NIGHTTIME DRIVING e Make sure all running lights and signal lights are clean and working order Have your headlights periodically checked and adjusted e Use care when passing other vehicles Your motor home 15 a longer vehicle than a car and you may have a more difficult time knowing when to pull back into your lane If possible have another person in the coach help you watch while maneuvering your motor home in traffic Neen MOUNTAIN DRIVING Special techniques must be used when driving in mountainous or hilly country Climbing A Hill The transmission will automatically down shift as needed to climb most hills If the hill 1s long or very steep however you may need to manually shift to a lower gear to keep the trans mission from repeatedly upshifting and down shifting Select the lowest adequate gear range for the duration of the incline See your chassis operating guide for more information SECTION 4 TRAVELING WITH YOUR MOTOR HOME
188. y seat the wheel nuts and to elimi nate the possibility of the wheel nuts becoming loosened while driving they should be tightened at frequent intervals to the torque specified in your Ford chassis manual This is especially im portant during the first 100 1 000 and 6 000 miles of operation after replacement of a wheel or wheel nuts 3 2 WARNING The operator is advised to obtain road service whenever possible and attempt tire changing under emer gency conditions only and with close adherence to instructions If it becomes necessary to change a wheel that wheel should be checked after being properly torqued and inspected by qualified service person nel at 100 miles and every oil change thereafter Upon satisfactory completion of emergency tire change it is highly recommended that the wheel nuts be properly torqued and inspected by qualified service personnel as soon as possible RECOVERY TOWING See your Ford Owner s Guide for proper recovery towing procedures Winnebago Industries does not assume re sponsibility for damage incurred while towing this vehicle WARNING Stay out from beneath the motor home while it is suspended by the towing assembly unless the vehicle is adequately supported by safety stands Do not allow passengers to occupy a towed vehicle NOTE Know and obey all state and local towing regulations Tow at reduced speed JUMP STARTING Automotive batteries

Minnie Winnie - Winnebago Industries

Contents

Download Pdf Manuals

Related Search

Related Contents