Manuals - Drs. Foster and Smith
Contents
1. PUMP SYST M 7502 Owner s Manual INNOVATIVE MARINE 9 9 D 9 UO o H 2 H O O TABLE OF CONTENTS Important Safety Instructions 3 4 Parts Exploded View amp Identification HydroFill ATO Pump System 5 Introduction HydroFill ATO Pump System 6 Specifications 7 Getting Started Unpacking amp Inspection 8 Choosing a Location for ATO Pump 9 Acrylic Bracket Return Pipe Assembly 10 Mounting Return Pipe on Framed Tanks 11 Plumbing ATO Pump System 12 13 Powering up ATO Pump 14 Notes 15 Warranty Information 16 Owner s Product Information 17 WARNING To guard against injury basic safety precautions should be observed including the following READ ALL SAFETY INSTRUCTIONS BEFORE USE WARNING To avoid electric shock special care should be taken since water is employed in the use of aquarium equipment For each of the follow ing situations do not attempt to repair yourself Return the appliance to an authorized service facility for service or discard the appliance e If the appliance falls into water DO NOT reach for it First unplug it and then retrieve it If the electrical components of the appli ance gets wet unplug the appliance immediately e Carefully examine the appliance after installation It should not be plugged in if there is water on parts not intended to be wet e Do not operate any appliance if it has a damaged cord or pl2. H 2 lt o x e Place the Return Pipe Bracket Assembly your rimless aquarium sump NOTE It is recommended to tighten screw on bracket after you have attached the tubing See Plumbing ATO Pump pg 12 13 10 GETTING STARTED Inside Aquarium OT 2255 SSS SISSIES SIS 22 11 Remove return pipe from Acrylic Bracket and hang direct For Framed Aquariums ly over aquarium frame PLUMBING ATO PUMP SYSTEM The ATO Pump System comes with 10ft of Silicone Tubing Pre measure the following OQ H c lt I o x RETURN 4 RESERVIOR PIPE PUMP 1 Plumbing Hose onto Return Pipe Male End of Return Pipe Hose Clamp Silicone Tubing ELI e Slip the included Silicone Tubing on the Male end of the Black Return Pipe e Secure Tubing to Pipe by tightening hose clamp over the silicone tubing NOTE Measure the Silicone Tubing from Return Pipe to the ATO Pump and cut to size 12 PLUMBING ATO PUMP SYSTEM 2 Plumbing Hose onto ATO Pump Silicone Tubing Male End Mark OUT 0 m 2 0 o gt A m Silicone Tubing Male End Mark IN e Slip the hose coming from return pipe to Male end of pump pipe mark OUT e Secure Tubing to Pipe by locking the hose clamp over the silicone t
3. this warranty Damages brought on by abuse misapplication or mishandling also voids this war ranty This warranty is limited to the repair or replacement of the prod uct at the discretion of the manufacturer This warranty does not cover personal injury property loss including livestock or damage direct incidental or consequential arising out of use of this product This warranty gives you specific rights and you may also have other rights which may vary from state to state The Product Registration Card must be filled out completely and returned within 14 days from the date of purchase Fail ure to do so will void this warranty A proof of purchase from an authorized dealer must be provided when making a war ranty claim For Warranty Claim please contact our Customer Care De partment A RMA must be issued before sending any product back to Innovative Marine Products sent back to Innovative Marine without a RMA will be not be accepted Service on products will not extend the original warranty period Email warranty innovative marine com 16 PRODUCT INFORMATION MODEL HYDROFILL PUMP TI gt Oz 2 m 22 gt 07 0 On ZO O SERIAL DATE OF PURCHASE Please keep your receipt in a safe place to ensure you have this in formation 17 INNOVATIVE MARINE WWW INNOVATIVE MARINE COM Division of 127
4. 12V 10W Up to 15 GPH 1 4 HydroFill ATO PUMP System Unpacking and Inspection Please inspect your new HydroFill ATO Pump System and con firm all parts are included before assembly Q e aa H Immediately report if there is any damage or missing parts to info innovative marine com Your HydroFill ATO Pump System purchase should include HAADROL Acrylic Bracket Return Pipe amp 1 Mounting Screw 10ft of Silicone Tubing Pump io 8 3 Hose Clamps El Inlet Spacer and Inlet Spacer Coupling ag Mounting Bracket 2 Non Tapered Screws aaa 2 Tapered Wood Screws CHOOSING A LOCATION FOR ATO PUMP e There are many options for the pump location e It is recommended to keep the total distance from Reservoir to Pump to Return Pipe no more than 10 ft MOUNTING OPTIONS FOR ATO PUMP Hang on Aquarium or Sump e Use the 2 non tapered screws to attach Mounting Bracket to ATO Pump e Hang the pump on the Aquarium Sump Cabinet Mount e Use the 2 tapered wood screws to attach Mounting Bracket amp ATO Pump to Cabinet Stand Alone e Place on noise dampening rubber feet 0 m 2 0 o A m ACRYLIC RETURN BRACKET amp RETURN PIPE ASSEMBLY For Rimless Aquariums Sumps Insert the Return Pipe through the Acrylic Bracket Secure into place so the return pipe does not move OQ
5. e The use of attachments not recommended or sold by the appliance manufacturer may case an unsafe condition Do not install or store the appliance where it will be exposed to the weather or to temperatures below freezing Make sure an appliance mounted on a tank is securely installed before operating it Read and observe all the important notices on the appliance This appliance has a polarized plug one blade is wider than the other As a safety feature this plug will fit in a polarized outlet only one way If the plug does not fit fully in the outlet reverse the plug If it still does not fit contact a qualified electri cian Never use with an extension cord unless plug can be fully inserted Do not attempt to defeat this safety feature This appliance is intended FOR HOUSEHOLD USE ONLY If an extension cord is necessary a cord with a proper rating should be used HYDROFILL ATO PUMP SYSTEM HydroFill Pump Return Pipe Bracket Mounting Screw 1 HydroFill Pump Acrylic Bracket HydroFill Pump Return Pipe Code 750210 750211 750212 SLYVd AUQA Gadgets a new line of fresh amp clever tools that aid in your daily chores for your aquarium Innovative design and sim plicity are the core ingredients to save you time and frustration AUQA Gadgets series include SMART products that encompass maintenance filtration feeding and organization to streamline your husbandry needs wit
6. hout the hassle H Q aa H HUdroFill ATO Pump System Pair your auto top off with the industry s first low voltage air lift pump specifically designed for ATO controllers The HydroFill ATO Pump System eliminates the guess work and comes complete with a lift pump acrylic bracket with return pipe 10 feet of silicone tubing 3 hose clamps and an optional hanging mount 4 i 0 t T Model 7502 Engineered for high performance this exter nal positive displacement diaphragm pump outputs up to 15 gallons per hour and max 5 feet of head This self priming pump is equipped with a built in check valve to safeguard against back siphoning The HydroFill diaphragm pump is the smart alternative when compared to submersible pumps diaphragm pumps offer the benefit of safely running dry and are thermally protected against heat build up Versatile design offers 3 options for pump placement hang on cabinet mount or simply place on noise dampening rubber feet HUdroFill ATO Pump System Z A O C Features Pump e Positive Displacement Diaphragm Pump e Self Priming e Built in Check valve e Dry Run Protection e Thermally Protected Return Kit e Low Voltage e 10 feet of silicone tubing e 1 4 barb fitting e 3 Hose clamps e Upto 15 Gallons Per Hour e Acrylic mounting bracket e Pump mounting bracket e Return pipe SPECS 7502 3 38 2 52 x 5 59
7. ubing e Slip the remaining tubing on the Male end of pump pipe marked IN e Secure Tubing to Male end of pump by locking the hose clamp over the silicone tubing 3 Plumbing Hose onto Inlet Spacer Creates space for unimpeded suction from reservoir Silicone Tubing Inlet Spacer Coupling Ex Inlet Spacer Slip the hose coming from return pipe to the inlet spac er coupling Attach the inlet spacer cou pling to the inlet spacer Measure hose and cut so inlet spacer reaches the bot tom of your reservoir 13 Powering up ATO Pump NOTE Before powering up ATO pump make sure all plumb ing connections are secure Make sure the return pipe is securely attached to the Aquarium Sump OQ 2 o x 1 Plug male prong from 12V Driver to ATO Pump 2 Plug the ATO Pump Driver into the ATO Controller or approved household power outlet 14 15 gt H 2 aa c 4 gt WARRANTY INFORMATION LIMITED 2 YEAR WARRANTY HydroFill ATO Pump System This HydroFill ATO PUMP System has a 2 YEAR limited war ranty The HydroFill ATO PUMP System is warranted to the original purchaser against defective material and workmanship for 2 YEAR from the date of original purchase This warranty is valid only under the following conditions additions modifica tions or changes made to the product by the purchaser and not by the manufacturer shall void
8. ug or if itis malfunctioning or if it is dropped or damaged in any man ner e To avoid the possibility of the appliance plug or receptacle getting wet position aquarium to one side of a wall mounted receptacle to prevent water from dripping onto the receptacle plug A Drip Loop should be arranged by the user for EACH cord connecting an aquari um appliance to a receptacle The Drip Loop is that part of the cord below the level of the receptacle or ae the connector if an extension cord Drip Loop is used This Drip Loop prevents water travelling along the cord and coming in contact with the receptacle If the plug or the recepta cle do get wet DO NOT unplug the cord Disconnect the fuse to the circuit breaker that supplies power to the appliance Then unplug and examine for the presence of water in the receptacle e Close supervision is necessary when any appliance is used by or near children e To avoid injury do not contact moving parts or hot parts such as heaters reflectors lamps bulbs and etc e Always unplug an appliance from the outlet when not in use be fore putting on or taking off parts and before cleaning Never yank the cord to pull plug from outlet Grasp the plug and pull to disconnect 3 do AX 25 az O Zo m 4 gt H LLI LL lt o 2 INSTRUCTIONS Do not use an appliance for other than intended us
Download Pdf Manuals
Related Search