OWNER`S GUIDE
Contents
1. 1 2 8 13 25 33 66 cm A WARNING Turn the electrical power off at the electrical panel board circuit breaker or fuse box and lock or tag the panel board door to prevent someone from turning on power while you are working on the heater When using electrical appliances basic precautions should always be followed to reduce the risk of fire electric shock and injury to persons including the following Read all instructions before using this heater Do not place heater against paperboard or low density fiberboard surfaces Do not use outdoors This heater is not intended for use in bathrooms laundry areas and similar indoor locations Never locate heater where it may fall into a bathtub or other water container Do not place heater below an electrical convenience receptacle WARNING Overheating or fire may occur Do not place the heater behind doors WARNING Fire or explosion may occur Heater has hot and arcing or sparking parts inside Do not use it in areas where gasoline paint or flammable liquids are used or stored A WARNING Burn Hazard This heater is hot when in use To avoid burns do not let bare skin touch hot surfaces If provided use handles when moving this heater Keep combustible materials such as furniture pillows bedding papers clothes and curtains at least 3 feet 0 9 m from the front of the heater and keep them away from the sides and rear Use extreme caution when any hea2. To prevent a possible fire do not block air intakes or exhaust in any manner Do not use on soft surfaces like a bed where openings may become blocked Heater must be kept clear of all obstructions maintain a 3 foot minimum clearance from front and 12 inches from sides and rear Heaters must be kept clean of lint dirt and debris See Maintenance Instructions WARNING Risk of Fire DO NOT use heater with an extension cord Plug the heater directly into a 240 208 volt receptacle Use this heater only as described in this manual Any other use not recommended by the manufacturer may cause fire electrical shock or injury to persons WARNING Risk of Fire Do not use as a residential or household heater SAVE THESE INSTRUCTIONS www cadetco com Teli 360 693 2505 P O Box 1675 Vancouver WA 98668 1675 Grounding Instructions This heater is for use on 240 or 208 volts The cord has a plug as shown to the right No adapter is available for this blade configuration and none should be used The outlet type is a 240 or 208 volt grounding outlet When properly installed it provides a ground connection through the cord to the heater to protect the operator from electrical shock CGH402 20 AMP eq Ci GROUND Receptacle Configuration Plug Configuration Installation Instructions CAUTION Heater will operate on either 240 or 208 volts Check heater voltage and phase on label on back of heater to make sure they
3. maintenance Allow heater to cool IMPORTANT Heater must be unplugged before performing any maintenance For dusting use a soft cloth For cleaning use only a damp rag and nonabrasive dish detergent Do not use abrasive or chemical cleaners as these may damage the finish If heater is used ina dusty location use a vacuum cleaner dust brush to remove dust and other foreign particles from the grill Always unplug cord and wind it around heater handles when not using Keep heater in a safe location for storage Any other servicing should be performed by an authorized service representative Temperature Limiting Device All heaters are equipped with a thermally actuated manual reset limit control which automatically disconnects heating element and motor in the event normal operating temperatures are exceeded If heater should fail to operate with thermostat turned clockwise to its limit disconnect heater and wait a few minutes allowing heater to cool Using a small straight object such as a pencil push in button located inside small hole marked RESET The thermal cutout almost invariably indicates a partial or complete blockage of the air intake or exit Be sure to keep these areas clear in order to allow proper circulation of air Maintenance For more effective and safer operation and to prolong the life of the heater read the Owner s Guide and follow the maintenance instructions included with each heater Failure to properly maintain th
4. also have other rights which vary from state to state Cadet neither assumes nor authorizes anyone to assume for it any other obligation or liability in connection with its products other than as set out herein If you believe your Cadet product is defective please contact Cadet Manufacturing Co at 360 693 2505 during the warranty period for instructions on how to have the repair or replacement processed Warranty claims made after the warranty period has expired will be denied Products returned without authorization will be refused Parts and Service Visit http support cadetco com for information on where to obtain parts and service 2009 Cadet Manufacturing Co Printed in U S A Rev 5 10 720100
5. are the same as the electrical service supplied See plug configurations below Altering the cord in any way will void the warranty Be sure that the electrical receptacle is of the configuration and capacity appropriate for the heater The heater may be used as a heavy duty portable It may also be hung on the wall or ceiling using the bracket provided The wall ceiling mounting structure and anchoring provisions must be of sufficient strength to support the combined weight of the heater and mounting bracket Specifications MODEL WATTS VOLTS 60 Hz BTUs AMPS PLUG TYPE CGH402 4000 3000 240 208 13 648 10 236 16 7 14 4 20 Amp Operation and Maintenance How To Operate Your Heater 1 Turn the thermostat knob fully clockwise 2 When the room reaches your comfort level turn the thermostat knob counter clockwise until the heater shuts off One or two minor adjustments may be necessary as the heat becomes better distributed throughout the area 3 To reduce the room temperature turn the knob counter clockwise D To increase the room temperature turn the knob clockwise Maintenance Heaters are equipped with a permanently lubricated motor and therefore no maintenance other than occasional cleaning is required Ad WARNING WHEN CLEANING OR DISSASEMBLING HEATER BE SURE TO DISCONNECT HEATER CIRCUIT To disconnect heater turn thermostat to OFF then remove plug from electrical outlet before cleaning or performing any
6. e heater will void any warranty and may cause the heater to function improperly Warranties are non transferable and apply to original consumer only Warranty terms are set out below LIMITED ONE YEAR WARRANTY Cadet will repair or replace any Cadet Garage Utility Unit Heater CGH element or motor found to be defective within one year after the date of purchase THESE WARRANTIES DO NOT APPLY 1 Damage occurs to the product through improper installation or incorrect supply voltage Damage occurs to the product through improper maintenance misuse abuse accident or alteration The product is serviced by anyone other than Cadet If the date of manufacture of the product cannot be determined If the product is damaged during shipping through no fault of Cadet CADET S WARRANTY IS LIMITED TO REPAIR OR REPLACEMENT AS SET OUT HEREIN CADET SHALL NOT BE LIABLE FOR DAMAGES SUCH AS PROPERTY DAMAGE OR FOR CONSEQUENTIAL DAMAGES AND OR INCIDENTAL EXPENSES RESULTING FROM BREACH OF THESE WRITTEN WARRANTIES OR ANY EXPRESS OR IMPLIED WARRANTY N ooa ew 7 IN THE EVENT CADET ELECTS TO REPLACE ANY PART OF YOUR CADET PRODUCT THE REPLACEMENT PARTS ARE SUBJECT TO THE SAME WARRANTIES AS THE PRODUCT THE INSTALLATION OF REPLACEMENT PARTS DOES NOT MODIFY OR EXTEND THE UNDERLYING WARRANTIES REPLACEMENT OR REPAIR OF ANY CADET PRODUCT OR PART DOES NOT CREATE ANY NEW WARRANTIES 8 These warranties give you specific legal rights and you may
7. ter is used by or near children or invalids and whenever the heater is left operating unattended SAFETY amp QUALITY Cadet Garage Utility Unit Heater OWNER S GUIDE Features amp Benefits e Operates on 240 or 208 volts e Internal manual reset thermal cutout e Finned steel tubular heating element e 6 foot cord with molded plug Built in single pole thermostat with mechanical OFF position Bracket for Wall or Ceiling Hung and floor stand use 1 year extended warranty Models CGH402 LISTED IMPORTANT INSTRUCTIONS 9 10 11 12 13 14 A WARNING Risk of electrical shock Connect to properly grounded outlets only Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an electric shock or fire or damage the heater Unplug heater before performing any maintenance or when not in use To disconnect heater turn control to low then remove plug from outlet WARNING Risk of electrical shock or injury Do not run cord under carpeting Do not cover cord with throw rugs runners or the like Do not route cord under furniture or appliance Arrange cord away from traffic area where it will not cause a tripping hazard Do not operate heater with a damaged cord or plug or after heater malfunctions or has been dropped or damaged in any manner Discard heater or return to authorized service facility for examination and or repair WARNING Risk of Fire
Download Pdf Manuals
Related Search