Sonoma 16 Pergola Installation Manual
Contents
1. Inside Dimension te 144 5 8 1 lt 4507 84 Inside Diagonal 145 5 8 1 205 1 4 1 Center to Center 5 Dimension i 150 1 8 1 14 Overhang all sides Suggested for installa tion on lawns For other surfaces appropriate mounting methods should be used A Depth of Masonry Footing Varies by Local Code amp Conditions ened amp Sonoma Pergola Warranty Information OutdoorGreatRoom company Your new Sonoma 16 pergola is warranted against structural defects for a period of three 3 years from the date of purchase This does not apply to damage caused by excessive loads such as snow or use of roof as storage Your Sonoma pergola is warranted against defects in finish and other defects not related to structure for a period of one 1 year from the date of purchase All metal hardware must be sprayed with a clear lacquer sealer once your pergola is assembled to prevent rust and corrosion l l The Outdoor GreatRoom Company extends the following warranty for Outdoor GreatRoom outdoor products used in the United States of America or Canada Dealers and employees of The Outdoor GreatRoom Company have no authority to make any warranty or authorize any remedies in addition to or inconsistent with the terms of this warranty This warranty gives you specific legal rights You may also have other rights that vary from state2. il a pa X together as shown using bolts P with a nut and washers Bolt heads should be on the side comprised of beams E Do not use bolts in holes marked with an X above Repeat for opposite side ledger beam Insert 2 wood screws S into pre drilled holes near ends of beams D once bolts are in place and tightened Step 4 Attach rectangular mending plates 1 fo canopy beams as shown Attach beams G to beams H x2 and beams I to I x3 With arch beams laying flat on ground bolt Together X5 using supplied hardware bolts N and mending plates L NOTE In the remaining steps a rubber mallet may be useful in fitting beams together properly step 5 Lay columns on level surface Bolt ledger beams assem bled in step 2 to columns A with beams E facing uoword Step After end arched beams are Once header beams ore installed Toll Corbel Post Braces installed and bolts are tight B can be attached as shown ened end arched beam below with hardware screws sections can be installed R Upper 3 screws ore in stalled from both sides of cor between them and secured 1 bel Once corbels are in place in place with hardware install remaining arched beams 7 screws R Position compo with screws R Aa YA nents with bolt heads visible a IEA from the outside of perg
3. obtain service under this warranty you must Send written notice of the claimed condition to The Outdoor GreatRoom Company 2015 Silver Bell Road 195 Eagan MN 55122 Affirm that you are the original owner of the Product Provide The Outdoor GreatRoom Company reasonable opportunity to investigate the claim including reasonable opportunity to inspect the Product prior to any repair or replacement work and before the Product or any component of the Product has been removed Obtain The Outdoor GreatRoom Company s consent to any warranty work before the work is done The Outdoor GreatRoom Company Q a
4. Amt OutdoorGreatRoom compan y Sonoma 16 Pergola Manual and Installation Instructions Please read these instructions before removing parts from crate Introduction Thank you for your purchase from The Outdoor GreatRoom Company This pergola has been engineered and manufactured in the USA This user manual will help make the installation and setup of your new pergola fast and easy Outdoor GreatRoom company recommends visiting with your local authority for building codes restrictions or requirements for this product Please read the manual through before starting the project This pergola is made of premium grade kiln dried Douglas Fir Douglas Fir if maintained properly will last a very long time similar to life of both Cedar and Redwood All finished pieces have been stained via submersion to ensure even penetration It is recommended that the pergola receive a clear oil based stain yearly to maintain the color minimize warping and prevent rot ting Every few years a colored oil based stain should be used to keep the original color Important e Anchoring Required Contact your local authority for details Read instructions prior to assembly Assistance is required and we recommend at least 2 people for installation Do not let wood pergolas sit on bare ground Over time this can cause moisture damage and rotting of wood If you have questions contact the place of purchase Douglas Fir Lumber may have surface splits Th
5. Room Company has been af forded a reasonable opportunity to inspect the Product This warranty is limited to the replacement or repair of defective components or workmanship and The Outdoor GreatRoom Company may fully discharge its obliga tions under this warranty by repairing or replacing at its discretion the defective components The Outdoor GreatRoom Company will provide replacement parts at no charge and will pay reasonable and necessary labor and freight costs related to replacing or repairing defective components under this warranty The maximum amount recoverable under this warranty is limited to the purchase price of the Product and if The Outdoor GreatRoom Company is unable to provide replacement or repair in an expedient and cost effective manner The Outdoor GreatRoom Company may discharge all obligations under this warranty by refunding the pur chase price of the Product EXCEPT TO THE EXTENT PROVIDED BY LAW THE OUTDOOR GREATROOM COMPANY MAKES NO EXPRESS WARRANTIES OTHER THAN THE WAR RANTY EXPRESSED HEREIN THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO THE DURATION OF THE WARRANTY SPECIFIED ABOVE IN NO EVENT SHALL THE OUTDOOR GREATROOM COMPANY BE LIABLE FOR ANY INCIDENTAL OR CONSE QUENTIAL DAMAGES CAUSED BY DEFECTS IN THE PRODUCT Some states do not allow limitations on how long an implied warranty lasts or do not allow exclusion or limitation of incidental or consequential dam ages so these limitations may not apply to you To
6. is occurs while the lumber dries and seasons This characteristic is also Known as checking in the lumber industry These can be upwards of 1 8 running inches to feet in length These characteristics do not affect the structural strength and integrity of the product nor does it affect or void the warranty Before Beginning make sure that all components listed on the next page were included with your hardware kit Contact your dealer if any parts are missing Tools Required Corded or Cordless Drill Measuring Tape Level Metric Socket Set Rubber Mallet Step Ladder 7 f ity affect all wood products Taking proper care of your pergola is Hammer Drill T E essential to ensure long lasting performance and beauty Concrete Anchors e Construction grade adhesive such as PL 400 Only Required for anchoring to concrete surfaces Disclaimer The Outdoor GreatRoom Company is not liable for damage caused by weather or misuse 90222 Sonoma 16 Pergola REV B 4 17 2012 2 Extreme weather including heat cold rain snow and high humid Included Ports B C Tall Corbel Post Short Corbel Post Brace ama ALL bolts require washers Le as ma apes Ps Oo MIOx 55 Hex Bolt with nut ana washers i x80 N H Canopy Beam Right L Canopy Beam Left L Rectangular Mending Plote XO Step 1 Bolt steel footplate to each of four sup plied posts A as shown Use hardware M and O
7. ola me a hea te Hardware O is used Repeat step 5 for remaining posts Insert 2 screws R into each Side of column Ensure columns are squared with ledger beam before fas tening Repeot for all columns Step 6 Attach short corbels C with hardware screws R upper screws should be installed from both sides of ledger beam step 8 Carefully position posts in final location Check for square Install canopy beam assemblies with screw R of intersections with arch beams The use of a level or similar tool is highly suggested Dimensional and Post Location Information NOTE 1 NOTE2 Recommended 12 18 DIA footing 12 minimum Check local codes for depth minimums Footing typically 24 mini mum depth 42 for extreme cold cli mates Max Width 185 x p j j i ait a F f a i P i J A j P y g g pi ji P 4 5 j fz 7 i iA A P 4 a A i E F A Fe ie M p k jd Z P 4 f 4 E A g F A ay r A 7 A il f P A F 4 _ j rf r a ay ae ie x A amp W Ny T 12 oside Dimension 145 5 8 Do not do final tightening of all bolts until unit is fully assembled level and square After Pergola is IN POSITION SQUARED UP amp LEVELED anchor posts with masonry bolts through steel footplates Masonry Post Bolts f Cement Footing 7
8. to state The Outdoor GreatRoom Company warrants that this Outdoor GreatRoom Outdoor Product the Product will be free from defects in material and workman ship for a period of one 1 year for finish and other non structural defects and three 3 years from its date of purchase structurally This warranty is subject to the conditions exclusions and limitations described below This warranty applies only to the original owner of the Product and is non transferable The Outdoor GreatRoom Company obligation under this warranty does not ex tend to damages resulting from 1 assembly operation or maintenance of the Product not in accordance with the Installation Assembly Instructions Operating Instruc tions and the Listing Agency Identification Label furnished with the Product 2 installation or use which does not comply with local building codes and ordi nances 3 shipping improper handling improper operation abuse misuse accident or unworkmanlike repairs 4 Installation or use of components not supplied with the Product or any other components not expressly authorized and approved in writing by The Outdoor GreatRoom Company and or 5 modification of the Product not expressly authorized and approved in writing by The Outdoor GreatRoom Company Any of the circumstances described in the previous sentence voids this warranty This warranty is void if the Product or any component has been removed repaired or replaced before The Outdoor Great
Download Pdf Manuals
Related Search