AES-HM76Z1FL
Contents
1. E e II Suggestion Application Circuit PCB Internal Circuit External Circuit Circuit l High 2 5 3 3V Low 0 0 8V 1 www acrosser com 31 EC ROSSER AES HM76Z1FL User Manual 4 2 4 3 4 4 4 5 32 Digital Outputs There are 8 digital outputs for general purpose output The eight digital outputs are TTL level Schmitt trigger pin with 12mA source sink capability for each channel and the maximum output voltage is 3 3V You can control the output status of these digital outputs through the software API Please refer to the Software Installation and Programming Guide chapter for the detailed information on how to use the API The following diagrams state how to connect the digital inputs to the devices on the system Suggestion Application Circuit PCB Internal Circuit External Circuit Maximum Sink Current 12mA Circuit Watchdog Timer If you set a watchdog timer you can use it to reset the system when system hangs up due to hardware issue After you set the watchdog timer the software shall re set the timer to re start a new cycle before it time out Please refer to Chapter 6 Software Installation and Programming Guide for how to set the watchdog timer Serial ATA SATA There is one SATA III port on the main board There is also one SATA power connectors 5V only power for the SATA hard disk Please be careful abo2. e SB USB configuration SB USB Configuration settings e Graphics Configuration Graphics parameters www acrosser com 25 ECROSSER AES HM76Z1FL User Manual 3 4 1 26 PCH IO Configuration Aptio Setup Utility Copyright 2012 American Megatrends Inc EU decide Ze Chipset Boot Security Save amp Exit SB USB Configuration EHCI1 Enabled EHCI2 Enabled Legacy USB Support Enabled lt Select Screen TL Select Item Enter Select Change Opt F1 General Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit SCHEXxI Version 2 15 1226 Copyright 2012 American Megatrends Inc XHCI Mode Disabled Auto Smart Auto Mode of operation of xHCI controller EHCI1 EHCI2 Enable Disable Control the USB EHCI USB 2 0 functions One EHCI controller must always be enabled Legacy USB Support Enabled Enables Legacy USB support Disabled Keep USB devices available only for EFI applications Auto Disables legacy support if no USB devices are connected Acrosser Technology Co Ltd E CROSSER AES HM76Z1FL User Manual 3 4 1 1 Graphics Configuration Aptio Setup Utility Copyright 2012 American Megatrends Inc EU VEA Chipset Boot Security Save amp Exit System Agent Bradge Name lvyBridge System Agent RC Verison 1 5 0 0 VT d Capability Supported DVMT Total Gfx Mem 256MB Promary IGFX Boot Display VBIOS Default
3. Lea L Je V11 E RYO Ok 2 www acrosser com AES HM76Z1FL Driver Utility Application Document Acrobat Reader XI INTEL_MEI Acrosser Driver Drivers for Optional Modules isc www acrosser com 43 ECROSSER 7 AES HM76Z1FL User Manual Step 4 Note 44 If the Windows Security warning message appears select Install this driver software anyway to go on next step ig Windows Security amp Windows can t verify the publisher of this driver software Don t install this driver software You should check your manufacturer s website for updated driver software for your device Install this driver software anyway Only install driver software obtained from your manufacturer s website or disc Unsigned software from other sources may harm your computer or steal information w See details Install Drivers for Optional Modules CAL kb ERP www acrosser com aaa Wi IIIT AES HM76Z1FL Driver Utility Application Document Acrobat Reader XI INTEL MEI Acrosser Driver Drivers for Optional Modules Browse 4 Disc This driver installation is necessary for operating the optional 3 5G or WiFi module Acrosser Technology Co Ltd Pen AESHNTSEIEL User Manual According to your application run the EXE file in the 3 5G or WiFi folder to install its driver Organize v Share with New folder LT a Name Date modi
4. lt Select Screen TL Select Item Enter Select Change Opt F1 General Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit ESCHEXIT Version 2 15 1226 Copyright 2012 American Megatrends Inc e DVMT Pre Allocated 32M 64M 96M 128M 160M _ Select DVMT 5 0 Pre Allocated Fixed Graphics Memory size 1 192M 224M 256M 288M used by the Internal Graphics Device 320M 352M 384M 416M 448M 480M 512M 1024M e DVMT Total Gfx Mem 128M 258M MAX Select DVMT 5 0 Total Graphics Memory size used by the Internal Graphics Device e Primary IGFX Boot Display VBIOS Default D_SUB Select the Video Device which will be activated during POST This HDMI 1 HDMI 2 has no effect if external graphics present Secondary boot display selection will appear based on your selection VGA modes will be supported only on primary display Wwww acrosser com 27 Een AES HM76Z1FL User Manual 3 5 Boot Setup Choose boot priority Aptio Setup Utility Copyright 2012 American Megatrends Inc Main Advanced Chipset Security Save amp Exit Boot Configuration Bootup NumLock State On Boot Logo Enabled Fast Boot Disabled CSM16 Module Version 7 69 Driver Option Priorities Boot Option Priorities Boot Option 1 PO ADATA SX900 Hard Drive BBS Priorities lt Select Screen T1 Select Item Enter Select Change Opt F1 Genera
5. Network Connections gt v Organize Disable this network device Diagnose this connection Rename this connection gt e A by Local Area Connection AD _ acrosser com GT Intel R 82574L Gigabit Network C Acrosser Technology Co Ltd AES HM76Z1FL User Manual e Ifthe problem still exist please shut down the firewall and anti virus software 4 gt Control Panel Control Panel Home Allow a program or feature through Windows Firewall Change notification settings Se Turn Windows Firewall on or off Se Restore defaults Advanced settings Troubleshoot my network See also Action Center Network and Sharing Center K System and Security Windows Firewall Help protect your computer with Windows Firewall Windows Firewall can help prevent hackers or malicious software from gaining access to your computer through the Internet or a network How does a firewall help protect my computer What are network locations Home or work private networks Not Connected E Connected A Networks in public places such as airports or coffee shops Windows Firewall state On Incoming connections Block all connections to programs that are not on the list of allowed programs Active public networks None Notification state Notify me when Windows Firewall blocks a new program e If the Network Connections Local Area Connection show no connect
6. Q 3 Q 4 Q 5 Q 6 FAQ Why the Linux operating system can not re install by the same storage device e Make sure to clean up the original data on the storage device before installation e It is recommended to format the storage device before installation Why the monitor display abnormally on screen during Linux installation e Change another monitor and try to install again e Install the OS in basic graphics mode Why the display resolution only for 800x600 and 1024x768 at X Window under Basic Graphics Mode e Make sure the Vender and Project of monitor detected correctly on the Display configuration e Contact your monitor vender to get the driver for Linux e Adjust the settings in XORG CONF e Determine the interval between the two frequencies Max and Min for both horizontal scanning and vertical scanning your monitor supported For example HorizSync 30 0 80 VertRefresh 50 75 e Add the frequencies in XORG CONF for that vesa device and monitor e Reboot system Does my system support Windows 8 e The system is designed and verified with Windows 7 Fedora 17 and Ubuntu 12 10 Acrosser did not verify this system with Windows 8 Please contact Acrosser local sales representative or authorized channels to help you confirm whether a new Windows 8 driver is provided Why do we get error message when we execute utility program e Make sure all the drivers have been installed correctly e Ifthe p
7. i j d See full ma Change adapter settings A se D e fu p Change advanced sharing settings TEST PC Network Internet This computer View your active networks Connect or disconnect E Network Access type No Internet access Public network Connections Local Area Connection Change your networking settings Ka Set up a new connection or network kad Set up a wireless broadband dial up ad hoc or VPN connection or set up a router or access point Connect to a network Connect or reconnect to a wireless wired dial up or VPN network connection Choose homegroup and sharing options See also Access files and printers located on other network computers or change sharing settings HomeGroup Troubleshoot problems ae a Diagnose and repair network problems or get troubleshooting information Windows Firewall e Ifthe problem still exist please contact your MIS whether there are any DHCP or IP configuration or ISP WAN setting limitation 56 Acrosser Technology Co Ltd ECROSSER AES HM76Z1FL User Manual Technical Support Form We deeply appreciate your purchase of Acrosser products Please find the tech_form doc file in our utility CD If you have any questions or problems about Acrosser products please fill in the following information We will answer your questions in the shortest time possible Describe Your Info and Acrosser System Info e Your Company Name Your Contact Info Phone Number You
8. AES HM76Z1FL Driver Utility Application Document T Chipset T Audio M LAN IT VGA l USB3 Select Clear 4 Browse Disc If not enter the root folder of the CD Title run the excution file Setup exe H AS CL el A USB_ AES HM76 gt 4 Search AE Organize Open New folder E3 Documents z Name Date modified B Music Pictures E Videos dou HM76Z1 1 16 2014 4 50 PM image 1 16 2014 4 50 PM autorun 5 19 2011 4 12 PM Z board 1 16 2014 5 51 PM M Computer amp Local Disk C e Removable Disk E Setup 10 2 2013 8 09 PM a USB_BOOT E d Trash 1000 du AES HM76Z1_ du AES HM76Z1FI J embedded wh r D 423 Ta Setup Date modified 10 2 2013 8 09 PM v Application Size 5 86 MB HT 36 Acrosser Technology Co Ltd FECROSSER AES HM76Z1FL User Manual 5 2 Step 1 Note Driver Installation Page Select the Driver tab Click the Select All button to select all the driver checkboxes and then click Install button to start installing all the selected drivers fE wu ECR OMS ER www acrosser com AES HM76Z1FL Driver Utility Application Document M Chipset Audio M LAN M VGA M USB3 Select the Clear All button will clear all the selections and then you can select the driver you want to install one by one but the Chipset driver has to be installed before inst
9. not for general audiences 2 Acrosser Technology Co Ltd EC ROSSER AES HM76Z1FL User Manual Table of Contents As System Ty ee TT T lt sssrinin 5 Ee Ee een EE 6 1433 lt Te 4151 EE 8 1 3 1 CODE tee eee er eee ees ee A ate eee rere ene eee ATA ee 8 1 4 System Dssechon ENEE EEN 9 LAN UNMET Ke E 9 B Te An EE 10 1 4 3 System Configuration ss 11 2 Assembly Disassembly Procedures ccs sss sees ess esse eee eee 12 2 1 2 5 HDD CF Card SIM Card and Mini PCle Card installation 12 2 2 Memory Module Installation ss 17 3 ee date CN 19 3 1 Enter the AMI Aptio Setup Utility 19 K G eT E lt e EE 19 3 3 Advanced T 21 3 3 1 SATA COMUTA NIO ME 22 3 3 2 F81216 Second Super IO Configuration 23 3 3 3 W83627DHG Super IO Configuration 24 3 3 4 W83627DHG HW Monitor ss 24 x GADS OL OD ser a des do IA Anta D ae le 25 3 4 1 PCH IO Configuration sise 26 3 4 1 1 Graphics Configuration 27 2o BOUrG T 28 3 6 SECUN Ee EE 29 3 7 Save e D 30 4 Function E le e BEEN 31 AT NINA Neie 31 42 DO OO 32 v e Watchdog B NIMO EE 32 4 4 Serial ATA SAA EE 32 Ao T e E A E E E ES nee ee E 32 4 6 GPI GPO connector definition ss 33 4 6 1 GPIO2 COMA pin definition ss 33 4 6 2 GPIO1 COMS pin definition 33 4 6 3 GPI GPO cable color dennon sse sese eee 34 www acrosser com 3 FECROSSER AES HM76Z1FL User Manual 5 Driver and Utility Installation 35 5 1 CD
10. 1 x Quick Manual 1 x CD Title with driver and utility 1 x Power Cord for USA or Europe or Japan or UK 1 x DC12V Universal Power Adapter 1 x Combo Cable 2 x GPIO Cable 2 x 2 4 2 5GHz Antenna DU DUDU DD DD a 1 x Pull tab Opener Options List 3 5G Module Mini PCle WiFi Module Mini PCle Memory DDR3 2G 2G NN Memory DDR3 4G 4G a Memory DDR3 8G 8G Sy There are 4 output connectors in one Combo cable but only USB VGA and AUDIO features are available Please connect them correctly The remaining connector is reserved for other products Acrosser Technology Co Ltd E CROSSER AES HM76Z1FL User Manual 1 4 System Dissection 1 4 1 Dimensions Unit mm S 274 Se CLNY LIN L d mu AN DUTT TTT TTT il L O o S L 7 TT DC12V HDMI1 HDMI2 USB1 USB2 USB3 LAN1 LAN2 COMBO iO 00 re www acrosser com 9 ECROSSER AESHNZEEIEL User Manual 1 4 2 I O Panel Power DC COMBO Switch Input HDMI USB 3 0 LAN connector Antenna RS 232 GPI amp RS 422 485 GPO a
11. Graphic Controller e Integrated within HM76 Video Interface e 2 x HDMI HDMI Type A connector e 1 x VGA Combo Connector Storage CF e 1 x Compact Flash Type Il Socket SATA e 1 x SATA III Port with SATA Power Connector Communication and lO Expansion e 1x Mini PCle Socket For 3 5G WiFi SIM e 1 x SIM Card Slot Ethernet e 2x GbE RJ45 with LED USB e 3 x USB 3 0 USB 3 0 Type A Connector e 2 x USB 2 0 1 for Mini PCle 1 for Combo Connector Serial Ports e 2 x RS 232 DB9 Connector e 2 x RS 422 485 DB15 Connector Shared with GPIO GPIO e 8 x GPI DB15 Connector Shared with RS 422 485 e 8 x GPO DB15 Connector Shared with RS 422 485 Audio e 1 x Line Out Combo Connector Power Requirement Power Supply e 12V 60W Power Adaptor DC Jack Acrosser Technology Co Ltd F CROSSER AES HM76Z1FL User Manual Software OS Support e Windows 7 x86 x64 e Windows 7 Embedded x86 e Fedora 17 x86 x64 e Ubuntu 12 10 x86 x64 Mechanical amp Environment Thermal e Fanless Heatsink Dimension e 274 0 mm x 182 6 mm x 20 mm Operating Temp e 0 45 C 32 113 F Storage Temp e 20 80 C 4 176 F Relative Humidity e O 90 Non condensing Safety e CE FCC Class A www acrosser com T E CROSSER AES HM76Z1FL User Manual 1 3 1 3 1 Note Packing List Check if the following items are included in the package 1 x AES HM76Z1FL System
12. Save amp Exit F81216 Second Super IO Configuration Set Parameters of COM 1 F81216 SecondlO F81216 Second Super IO Chip gt COM 2 Configuration gt COM 3 Configuration K COM 4 Configuration COM3 422 485 function RS 422 COM4 422 485 function RS 422 lt Select Screen TL Select Item Enter Select Change Opt F1 General Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit ESCHEXIT Version 2 15 1226 Copyright 2012 American Megatrends Inc COM 1 COM 4 Configuration This option sets parameters of COM1 COM4 COM3 422 485 function This option enables COM_3 422 function or only 485 function COM4 422 485 function This option enables COM 4 422 function or only 485 function www acrosser com 23 EF ECROSSER AES HM76Z1FL User Manual 3 3 3 W83627DHG Super IO Configuration Aptio Setup Utility Copyright O 2012 American Megatrends Inc Advanced Ref Boot Security Save amp Exit W83627DHG Super IO Configuration W83627DHG Super IO Chip W83627DHG lt Select Screen T1 Select Item Enter Select Change Opt F1 General Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit ESCHEXT Version 2 15 1226 Copyright 2012 American Megatrends Inc e Parallel Port Configuration The Parallel Port is used as the GPO 3 3 4 W83627DHG HW Monitor Aptio Setup Utility Copyright 2012 American Megatre
13. Second Super IO Configuration gt W83627DHG Super IO Configuration gt W83627DHG HW Monitor lt Select Screen F2 Previous Values F3 Optimized Defaults F4 Save amp Exit ESCHEXIT Version 2 15 1226 Copyright 2012 American Megatrends Inc www acrosser com 21 ECROSSER AESHNZEEIEL User Manual 3 3 1 22 SATA Configuration This option allows you to view and configure the SATA settings Aptio Setup Utility Copyright O 2012 American Megatrends Inc Advanced RAMA Boot Security Save amp Exit Enable or Disable SATA Device SATA Mode Selection AHCI Serial ATA Port 1 Empty Software Preserve Unknown Port 1 Enabled CF CARD Empty Software preserve Unknown CF CARD Enabled lt Select Screen T1 Select Item Enter Select Change Opt F1 General Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit ESCHEXII Version 2 15 1226 Copyright 2012 American Megatrends Inc SATA Controller s Set this opton to enable or disable the SATA devices SATA Mode Selection Determines the SATA controller s will operate in IDE or AHCI mode Serial ATA Port 1 Enable or disable SATA Port 1 CF CARD Enable or disable CF card socket Acrosser Technology Co Ltd Pen AES HM76Z1FL User Manual 3 3 2 F81216 Second Super IO Configuration Aptio Setup Utility Copyright 2012 American Megatrends Inc Advanced Rent Boot Security
14. Title OCU OM 22 Seege ege ege 35 5 2 Driver Installation Page E 37 5 3 Utility Installation Page oes aa eee 39 5 4 Application Installation Page Vs Ai 99 Document Le EE 46 6 Software Installation and Programming Guide 47 CT IA OCTO A 47 6 1 1 Overview O 47 6 2 API List and Descriptions iii 47 2 OR da MATA ANA ATA ATA 47 OR E E 48 6 2 3 Watchdog WE 48 6 2 4 Hardware Monitor ss 49 6 2 5 oeral e E 50 A a eo a 51 Q 1 Why the Linux operating system can not re install by the same storage device 51 Q 2 Why the monitor display abnormally on screen during Linux installation 51 Q 3 Why the display resolution only for 800x600 and 1024x768 at X Window under Basic Graphics e E 51 Q 4 Does my system support Windows i 51 Q 5 Why do we get error message when we execute utility program 0cceeeees 51 Q 6 What can do if my system does not power on 51 Q 7 No display when power ON iii 52 Q 8 Where is the serial number located on my system 52 Q 9 My system has audio problem 53 Q 10 My system can not connect to Internet 54 A Acrosser Technology Co Ltd FECROSSER AES HM76Z1FL User Manual 1 System Introduction The AES HM76Z1FL embedded system uses the latest technology in scalable Intel Celeron and 3rd generation Core i7 i3 processors with a HM76 chipset It features graphics via VGA and HDMI DDR3 SO DIMM support complete I O such as 4 x C
15. Voltage and 3 3V Voltage Serial Mode can get and set COM3 and COM4 current status is RS422 RS485 Mode API List and Descriptions General General Syntax Description Syntax lib_init void Description Library initialization using this library must call this function first Parameters None Return Value 0 Successful 1 Fail Syntax lib_close void Description Library close when you not used this library must call this function Parameters None Return Value 0 Successful 1 Fail www acrosser com 47 FECROSSER AES HM76Z1FL User Manual 6 2 2 Table 2 6 2 3 Table 3 48 GPIO GPIO Syntax Description Description Get the status of GPIO input pins status Parameters This function takes an integral variable as the parameter The pin0 7 is pins Return Value 1 HIGH 0 LOW Description Get the status of GPIO output pins status Parameters This function takes an integral variable as the parameter The pin0 7 is pins Return Value 1 HIGH 0 LOW Description Set the status of GPIO Output value Parameters Set value O is Low 1 is High Linux Return Value None Watchdog Watchdog Syntax Description Description This function of the watchdog time to start counter Parameters The parameter value is the value to set to watchdog timer register The range is 1 255 Return Value None Descri
16. 5 A 3 AES HM76Z1FL User Manual ECRO AES HM762Z1FL Fanless and Ultra Slim Intel HM76 Embedded System 0101 1010 a C3 USB 3 0 va Fanless User Manual Acrosser Technology Co Ltd www acrosser com Industrial amp Embedded Solutions Digital I O FECROSSER AES HM76Z1FL User Manual Disclaimer For the purpose of improving reliability design and function the information in this document is subject to change without prior notice and does not represent a commitment on the part of Acrosser Technology Co Ltd In no event will Acrosser Technology Co Ltd be liable for direct indirect special incidental or consequential damages arising out of the use or inability to use the product or documentation even if advised of the possibility of such damages Copyright This document contains proprietary information protected by copyright All rights are reserved No part of this manual may be reproduced by any mechanical electronic or other means in any form without prior written permission of Acrosser Technology Co Ltd Trademarks The product names appear in this manual are for identification purpose only The trademarks and product names or brand names appear in this manual are the property of their respective owners Purpose This document is intended to provide the information about the features and use of the product Audience The intended audiences are technical personnel
17. NAR T ILRER OINSERXIE12E HP 200085 12E Aile Building No 631 Ling ling Road Xu Hui Dist Shanghai China Postal 200085 TEL 86 21 64288853 FAX 86 21 64288854 Acrosser Beijing Office RER FARAA LENAR IRMSLERET E RIS H m 2 703 HZ 100085 Room 2 703 Yipinshangceng No 9 Xisantiao Anning Zhuang Haidian Dist Beijing China Postal 100085 TEL 86 10 82359009 FAX 86 10 82359003 Acrosser USA Inc 11235 Knott Ave Suite A Cypress CA 90630 USA Toll Free 1 866 401 9463 TEL 1 714 903 1760 FAX 1 714 903 5629
18. OM ports 3 x USB3 0 ports 8 x GPI and 8 x GPO and storage via SATA III and Compact Flash The AES HM76Z1FL also supports communication by 2 x RJ 45 gigabit Ethernet ports 1 x SIM slot and 1 x Mini PCle expansion socket for a 3 5G or WiFi module The heat sink from the fanless design provides AES HM76Z1FL with great thermal performance as well as increases the efficiency of usable space The fanless design provides dustproof protection and saving the product itself from fan malfunction AES HM76Z1FL has thin client dimensions with a height of only 20 millimeters half the size thinner than most of the embedded appliances Different from most industrial products that focus on application in one specific industry the AES HM76Z1FL provides solutions for various applications through the complete 1 0 interfaces Applications of the AES HM76Z1FL include embedded system solutions control systems digital signage POS Kiosk ATM banking home automation and so on It can support industrial automation and commercial bases under multiple circumstances Wwww acrosser com 5 E CROSSER 1 1 AES HM76Z1FL User Manual Specifications System CPU e Intel Core i7 3517UE 1 7GHz e Intel Core i3 3217UE 1 6GHz e Intel Celeron Processor 1047UE 1 4GHz e Intel Celeron Processor 927UE 1 5GHz Chipset e Intel HM76 Memory e 2 x 204 pin SO DIMM Sockets e Support 1333 1600MHz DDR3 up to 16GB BIOS e AMI UEFI BIOS Display
19. SSER AES HM76Z1FL User Manual Step 5 Insert your SIM card according to your application Step 6 Install your Mini PCle card according to your application For 3 5G or WiFi installation you will have to connect both ends of the antenna cables to the feed point on the Mini PCle card first and then connect the two antennas found in the package to the ANT1 amp ANT2 port at the rear I O panel www acrosser com 15 Pen AESHNTSEIEL User Manual Step 7 After finished installation close the compartment cover and fasten the screw 16 Acrosser Technology Co Ltd Een AES HM76Z1FL User Manual 2 2 Memory Module Installation Step 1 Loosen the screw located at the chassis bottom and lift the memory compartment cover Step 2 Install the DDR3 memory into the socket Align the notch key on the module with the one on the socket when installing the memory module Wwww acrosser com 17 ECROSSER AESHNZEEIEL User Manual Step 3 After finished installation close the compartment cover and fasten the screw 18 Acrosser Technology Co Ltd CROSSER 7 AES HM76Z1FL User Manual 3 Note 3 1 3 2 BIOS Settings This chapter describes the BIOS setup program The BIOS settings can be viewed and changed for the module Only technical personnel should change the default BIOS settings Enter the AMI Aptio Setup Utility Aptio is AMI s BIOS firmware based on the UEFI Speci
20. alling all the others www acrosser com 37 ECROSSER Step 2 Step 3 38 AES HM76Z1FL User Manual The driver installation started ECR CONS E www acrosser com AES HM76Z1FL Driver Utility Application Document M Chipset M Audio LAN V VGA M USB 3 Installing Now GA Select Clear All OH All A Install K Browse Close Disc The driver installation finished The configuration will be valid after reboot ALL Drivers Install Finished Will Reboot Computer Cancel Acrosser Technology Co Ltd E C EN j IS SS Re 9 3 Utility Installation Page AES HM76Z1FL User Manual Step 1 Select the Utility tab Click the Test Utility box Driver Utility Application Document www acrossercom AES HM76Z1FL Step 2 The Test Utility screen appears WatchDog Hardware Monitor COM Mode www acrosser com 4 Browse Disc C Close E T EMES HM76Z1 CD Title VI Crot y 39 F CROSSER AES HM76Z1FL User Manual Select 1 GPIO Utility E AES HM76Z1_CD_Title_V1 2 HM76Z1 Utility TestUtility exe Lo eem WatchDog Hardware Monitor COM Mode Show GPI status Show GPO status Set GPO all HIGH Set GPO all LOW Set GPO Select 2 WatchDog Utility E AES HM76Z1_CD_Title_V1 2 HM76Z1 Utility TestUtility exe 4 Set GPO all LOW 5 Set GPO Wat
21. are SKU 1 5 MB ESC Exit System Date Mon 05 06 2013 System Time 12 03 42 Access Level Administrator Version 2 15 1226 Copyright 2012 American Megatrends Inc www acrosser com 19 E CROSSER AES HM76Z1FL User Manual 20 Listed at the bottom of the menu are the control keys If you need any help with the item fields you can press lt F1 gt key and it will display the relevant information BIOS Information Options Description BIOS Vendor This item displays the BIOS vendor Core Version This item displays the Core Version Compliancy This item displays the BIOS Compliancy Project Version This item displays the Project name and BIOG e version Build Date and Time This item displays the date and time of the project build PCH Information Options Description Intel PCH SKU Name This item displays the PCH Information Processor Information Options Description Brand String This item displays the CPU processor Name This item displays the CPU type Frequency This item displays the CPU speed Processor ID This item displays the CPU processor ID Number of Processors This item displays CPU of cores and Threads Microcode Revision This item displays the microcode version GT Info GT2 1200 MHZ IGFX VBIOS Version This item displays the VBIOS s version Memory RC Version This item displays the memory RC version Total Memory This item di
22. ation files Adobe Systems Incorporated Install Intel MEI components driver L ep St ed P e C RLC PZ j e Le www acrosser com AES HM76Z1FL Driver Utility Application Document Acrobat Reader XI INTEL_MEI Acrosser Driver Drivers for Optional Modules Browse Disc Acrosser Technology Co Ltd CROSSER AES HM76Z1FL User Manual Intel Installation Framework Intel Management Engine Components intel Setup Progress Please wait while the following setup operations are performed Creating Process regsvr32 exe Copying File C Windows system32 drivers IntelMEFW Ver dl Creating Process C Program Files Intel Intel R Management Engine Components FW Service Deleting File C Program Files Intel Intel R Management Engine Components FW Service Inte Copying File C Program Files Intel Intel R Management Engine Components FW Service Inte Creating Process C Program Files Intel Intel R Management Engine Components PWService Creating Process C Program Files Intel Intel R Management Engine Components FW Service Removing Intel ME FW Recovery Agent Installing Intel ME FW Recovery Agent Copying File C Program Files Intel Intel R Management Engine Components Firmware geg Click Next to continue aj UE Intel Installation Framework Step 3 Install Acrosser Driver into the system Windows OS will create AcroDev device
23. chDog Hardware Monitor COM Mode lt i gt Show Watchdog status 2 gt Set Watchdog timer 3 Stop Watchdog timer Select 3 Hardware Monitor Utility E AES HM76Z1_CD_Title_V1 2 HM76Z1 Utility TestUtility exe WatchDog Hardware Monitor COM Mode GITT EE d Enter to exit PU temperature is 33 System temperature is 32 ore voltage is 6 768 2U voltage is 12 113 SU voltage is 5 268 3 3U voltage is 3 381 40 Acrosser Technology Co Ltd FECROSSER AES HM76Z1FL User Manual Select 4 COM Mode Utility C ENAES HM76Z1_CD_Title_V1 2 HM76Z1 Utility TestUtility exe 5U voltage is 5 268 3 3U voltage is 3 381 press q Enter to exit WatchDog Hardware Monitor COM Mode 1 gt Get Com Mode 2 gt Set Com Mode 5 4 Application Installation Page Step 1 Select the Application tab Click the Acrobat Reader XI box Eva www acrossercom AES HM76Z1FL Driver Utility Application Document Acrobat Reader XI INTEL_MEI Acrosser Driver Drivers for Optional Modules 4 Browse Close Disc Li Note The Acrobat Reader is necessary for reading the user manual in PDF file format www acrosser com 41 E CROSSER AES HM76Z1FL User Manual Step 2 42 BB Adobe Reader XI Setup Preparing installation This may take a few minutes depending on your processor speed and hardware configuration Extracting install
24. erent because of different operating systems and S W version e You can search from Google as reference setting e Ifthe problem still exist please contact Acrosser FAE or authorized sales channels My system has audio problem e Make sure to enable the on board audio function in BIOS menu Aptio Setup Utility Copyright 2012 American Megatrends Inc EU decide Ze Chipset Boot Security Save amp Exit Enabled LAN2 Enabled Audio Auto gt SB USB Configuration gt Graphics Configuration e Make sure the audio driver and device was installed successfully File Action View Help e gt 2510180 e As Computer Management Local an test PC a System Tools M Computer Task Scheduler x Disk drives L i Event Viewer KS Display adapters Shared Folders gt 22 DVD CD ROM drives Local Users and Groups 5 Human Interface Devices EI Performance Ca IDE ATA ATAPI controllers Device Manager Keyboards 4 3 Storage D Mice and other pointing devices t Disk Management B Monitors Services and Applications KR Network adapters Ports COM amp LPT D Processors a Sound video and game controllers mu Intel R Display Audio amp Realtek High Definition Audio Ji System devices Universal Serial Bus controllers More Actions e Make sure the speaker is connected to the correct connector e Check if the audio function is set to MUTE e Please adjust the audio volu
25. faults Boot Override PO ADATA SX900 lt Select Screen TL Select Item Enter Select Change Opt F1 General Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit ES CHE Version 2 15 1226 Copyright 2012 American Megatrends Inc Save Changes and Exit Exit system setup after saving the changes Discard Changes and Exit Exit system setup without saving any changes Save Changes Save changes done so far to any of the setup options Discard Changes Discard changes done so far to any of the setup options Restore Defaults Restore Load default values for all the setup options Save as User Defaults Save the changes done so far as User Defaults Restore User Defaults Restore the User Defaults to all the setup options Acrosser Technology Co Ltd F CROSSER AES HM76Z1FL User Manual 4 Function Description 4 1 Digital Inputs There are 8 digital inputs for general purpose input You can read the status of any input through the software API You can define their purpose for any digital input function Please refer to the Software Installation and Programming Guide chapter for the detailed information on how to use the API The following diagrams state how to connect the digital inputs to the devices on the system Suggestion Application Circuit PCB Internal Circuit II LI Li l gt SIO t Circuit f
26. fications and the Intel Platform Innovation Framework for EFI The Aptio Setup Utility can be accessed by pressing the lt Delete gt or lt Esc gt key during POST After powering up the BIOS message appears on the screen If the message disappears before you respond restart it by pressing lt Ctrl gt lt Alt gt lt Delete gt keys Main Setup Once you enter the AMI Aptio Setup Utility the Main Menu appears on the screen Press the arrow keys to highlight the item and then press the lt Page Up gt lt Page Down keys to select the parameters you want in each item Aptio Setup Utility Copyright 2012 American Megatrends Inc Advanced Chipset Boot Security Save amp Exit BIOS Information Choose the system default BIOS Vendor American Megatrends language Core Version 4 6 5 3 Compliancy UEFI 2 3 PI 1 2 Project Version SKU_0 B1 0 Build Date and Time 07 25 2013 11 22 29 PCH Information Intel PCH SKU Name HM76 Processor Information Intel Core i7 3517UE CPU 1 70GHz Name lvyBridge Frequency 1600 MHz Processor ID 306a9 Number of Processors 2Core S 4Thread s Microcode Revision 16 GT Info GT2 1000 MHz Select Screen Select Item IGFX VBIOS Version 2143 ie Select Memory RC Version 1 5 0 0 Change Opt Total Memory 8192 MB DDR3 F1 General Help Memory Frequency 1333 MHz F2 Previous Values F3 Optimized Defaults ME FW Version 8 0 10 1464 F4 Save amp Exit ME Firmw
27. fied 1 Computer J 356 amp Local Disk C e Removable Disk e USB_BOOT E d Trash 1000 1 AES HM76Z1_ do HM76Z1 A Applicatior A Acrosser de intel mei do Modules Au 3 56 CHE 3 2 items 1 16 2014 4 59 PM File de WiFi 1 16 2014 4 59 PM File www acrosser com 45 S CROSSER AES HM76Z1FL User Manual 5 5 Document Page The user manual is stored in the Document folder S ROSS SAR www acrosser com AES HM76Z1FL Driver Utility Application Document System User Manual zeg 9 Close isc Note To read the PDF file you will have to install Acrobat Reader first Please refer to the Application Installation Page 46 Acrosser Technology Co Ltd E CROSSER AES HM76Z1FL User Manual 6 6 1 6 1 1 6 2 6 2 1 Table 1 Software Installation and Programming Guide Introduction Overview This model provides four type APls which are GPI GPO interface Watchdog timer interface Hardware Monitor interface and Serial Mode interface Users can use the GPI GPO API configure and access the GPI GPO interface and the Watchdog timer The GPI GPO has eight input pins and eight output pins The Watchdog timer can be set to 1 255 seconds Setting the timer to zero disables the timer The remaining seconds of the timer to reboot can be read from the timer The Hardware Monitor API can get CPU Temperature System Temperature CPU Core Voltage 5V Voltage 12V
28. ion please check your network cable connection an deal ut Network and Internet Network and Sharing Center E Search Control Panel Control Panel Home Change adapter settings Change advanced sharing settings See also HomeGroup Internet Options Windows Firewall www acrosser com View your basic network information and set up connections d a D See full map TEST PC Internet This computer View your active networks Connect to a network You are currently not connected to any networks Change your networking settings Ki Set up a new connection or network Set up a wireless broadband dial up ad hoc or VPN connection or set up a router or access point Connect or reconnect to a wireless wired dial up or VPN network connection L Connect to a network ke Choose homegroup and sharing options Access files and printers located on other network computers or change sharing settings Troubleshoot problems Diagnose and repair network problems or get troubleshooting information 55 e If the Network Connections Local Area Connection show limited connection please disable and enable your connection to fix this problem Or you can unplug and plug the LAN cable to fix the problem 2 x e gt Network and Internet Network and Sharing Center X Search Contro Panel D A o Control Panel Home e e e e e View your basic network information and set up connections
29. l Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit SC ca Version 2 15 1226 Copyright 2012 American Megatrends Inc e Setup Prompt timeout Number of seconds to wait for setup activation key 65535 OxFFFF stands for indefinite waiting e Bootup NumLock State Select the keyboard NumLock State s Boot Logo Enables or disables Quiet Boot option s Fast Boot Enables or disables boot with initialization of a minimal set of devices required to launch active boot option Has no effect for BBS boot options s Boot Option 1 Sets the system boot order e Hard Driver BBS Priorities Set the order of the legacy devices in this group 28 Acrosser Technology Co Ltd AES HM76Z1FL User Manual Aptio Setup Utility Copyright 2012 American Megatrends Inc Main Advanced Chipset EC Se urity RES amp Exit Administrator Password Version 2 15 1226 Copyright 2012 American Megatrends Inc e Administrator Password Set administrator password e Secure Boot Secure Boot flow control Secure Boot is possible only if System runs in User Mode www acrosser com 29 E AES HM76Z1FL User Manual 3 7 30 Save amp Exit Setup Aptio Setup Utility Copyright 2012 American Megatrends Inc Main Advanced Chipset Boot SEA Save amp Exit Discard Changes and Exit Discard Changes Save Changes Discard Changes Restore Defaults Save as User Defaults Restore User De
30. me louder www acrosser com 53 ECROSSER AESHNZEEIEL User Manual 54 If the problem still exist please contact Acrosser FAE or authorized sales channels Q 10 My system can not connect to Internet Leg Make sure the network adapter can be recognized in Device Manager If there is question mark or exclamation mark in the network adapter please re install the network driver If the problem still exist please contact Acrosser FAE or sales representative for testing wn T SE Computer Manageme File Action View Help e 25 OI HIS else A Computer Management Local 4 test PC Actions a System Tools M Computer bras e Task Scheduler x Disk drives 12 Event Viewer R Display adapters More Actions gt Shared Folders DVD CD ROM drives Local Users and Groups Os Human Interface Devices Performance C IDE ATA ATAPI controllers Device Manager 2 Keyboards a EZ Storage D Mice and other pointing devices t Disk Management K Monitors Z Services and Applications KR Network adapters Er Intel R 82574L Gigabit Network Connection gt XF Ports COM amp LPT DI Processors Sound video and game controllers See gt E System devices Universal Serial Bus controllers II b Make sure the Network Connections Local Area Connection is enabled right click and choose Enable Lg gt Control Panel Network and Internet
31. mp RS 422 485 10 Acrosser Technology Co Ltd AES HM76Z1FL User Manual c O 2 o Bn 5 D K C O e S 3 E O Q 0 E gt O ei 2 Bottom Base 3 HDD Cover 4 Heatsink Module Set 5 Mainboard 5 2 O O gt O O 2 Y Q 5 A D O Z z ECROSSER AES HM76Z1FL User Manual 2 2 1 Step 1 12 Assembly Disassembly Procedures The following instructions will guide you to install your HDD or SSD CF Card Mini PCle Card SIM Card and Memory Card 2 5 HDD CF Card SIM Card and Mini PCle Card Installation Loosen the screw located at the chassis bottom and lift the HDD cover Ae There is the room reserved for 2 5 HDD CF Card SIM Card and Mini PCle Card installation Acrosser Technology Co Ltd Ec CROSSER AES HM76Z1FL User Manual Step 2 We have a customized pull tab opener which can easily pull out the disk After having inserted the disk to the SATA connector peel off the protective sheet on the pull tab EES and then stick it on your disk Step 3 Insert and push the disk into the SATA connector For SSD installation we recommend using SSD of H9 5mm www acrosser com 13 Een AES HM76z1FL User Manual The pull tab opener will be helpful to detach the disk from the SATA connector Step 4 Insert your CF card Y reg tie TIR SCC 14 Acrosser Technology Co Ltd ECRO
32. nds Inc Advanced WAME Boot Security Save amp Exit PC Health Status System temperature 32 C CPU temperature 42 C VCORE 0 832 V 5V 5 175 V 12V 12 000 V 3 3V 3 328 V lt Select Screen T1 Select Item Enter Select Change Opt F1 General Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit EC za Version 2 15 1226 Copyright 2012 American Megatrends Inc 24 Acrosser Technology Co Ltd Een AES HM76z1FL User Manual 3 4 Chipset Setup Select the Chipset menu item from the Aptio Setup Utility to enter the Chipset Configuration Setup screen You can select any item in the left frame of the screen and press lt Enter gt key to enter its sub menu and access its parameters Aptio Setup Utility Copyright O 2012 American Megatrends Inc Ef decide Ze Chipset Boot Security Save amp Exit Enabled LAN2 Enabled Audio Auto gt SB USB Configuration gt Graphics Configuration lt Select Screen T1 Select Item Enter Select Change Opt F1 General Help F2 Previous Values F3 Optimized Defaults F4 Save amp Exit ES Ca exit Version 2 15 1226 Copyright 2012 American Megatrends Inc e LAN1 LANZ Control the LAN port Enabled Disabled e Audio Control Detection of the Azalia device Disabled Azalia will be unconditionally disabled Auto Azalia will be enabled if present disabled otherwise
33. plug back the other components one by one to find out which one may cause this problem e If the system still could not power on please listen if there is any warning beeps e Memory issue e Clean the Golden Finger of memory e Clean the memory slots e Leave only one memory stick to test e If convenient please change different memory modules to test again e CPU issue e Check whether the CPU is in our supported CPU e Check whether there are any damagers of your CPU or CPU socket e Check whether the CPU fan is correctly connected e If the problem still exist please contact Acrosser FAE or authorized sales channels Q 8 Where is the serial number located on my system e The serial number S N is an alpha numeric character located on the bottom or side chassis ACE S6301 010140132 5184677 HI IHN for reference only Ivy Bridge Core i5 3320M 2 6GHz DDR3 4GB 52 Acrosser Technology Co Ltd ECR Q 9 e AES HM76Z1FL User Manual s How do I connect the second monitors to my system e Basically there are duplicate and extend mode for the second monitor e duplicate mode you will see the same contents on both monitors e extend mode your monitors display different contents and you can drag your contents between the first and second monitor e Ensure the display device setting is correct and monitor cables are connected well e For device setting it could be diff
34. ption Any time call this function will stop Watchdog Timer Parameters None Return Value None Acrosser Technology Co Ltd ECROSS SE AES HM76Z1FL User Manual Description This function read the value of the watchdog time counter Parameters None Return Value This function returns the value of the time counter 6 2 4 Hardware Monitor Table 4 Hardware Monitor Syntax Description Description Get the CPU Temperature Parameters None Return Value An Integral number Description Get the System Temperature Parameters None Return Value An Integral number Description Get the CPU Core Voltage Parameters None Return Value A floating number Description Get the 5V Voltage Parameters None Return Value A floating number Description Get the 12V Voltage Parameters None Return Value A floating number Description Get the 3 3V Voltage Parameters None Return Value A floating number www acrosser com 49 Ee AES HM76Z1FL User Manual 6 2 5 Serial Mode Table 5 Serial Mode Syntax Description Description Get the COM port mode Parameters 0 COM3 1 COM4 Return Value 0 RS485 1 RS422 Syntax ___set_comport mode int com int mode Description Set the COM port mode Parameters 0 COM 1 COM4 0 RS485 1 RS422 Return Value None 50 Acrosser Technology Co Ltd EC ROSSER AES HM76Z1FL User Manual T Q 1 Q 2
35. r E Mail Address Your Company Address Acrosser Model Name e Acrosser Serial Number Describe System Configuration e CPU Type e Memory Size Storage Device e g HDD CF or SSD Additional Peripherals e g Graphic Card Operating System amp Version e g Windows 7 Embedded Special API or Driver If yes please provide it for debug Running Applications Others Describe Your Problems or Questions Send the above information to one of the following Acrosser contacts e Acrosser Local Sales Representative e Acrosser Authorized Sales Channels e Acrosser Inquiry http www acrosser com inquiry html e Acrosser FAX Number 886 2 29992887 Wwww acrosser com 57 To Make Your Embedded Idea a Reality Acrosser Headquarters 2414k Z E E ST R609 125R101 10F No 12 Ln 609 Sec 5 Chongxin Rd Sanchong Dist New Taipei City 241 Taiwan R O C TEL 886 2 29999000 FAX 886 2 29992887 Acrosser Taichung Office 4086 HTS E EA RS 00 EG 10255 1242 7 0 12F 6 No 162 Sec 4 Henan Rd Nantun Dist Taichung City 408 Taiwan R O C TEL 886 4 22510659 FAX 886 4 22546079 Acrosser China Subsidiary AN Th RFA R FARAR ANDREA EK 2S Be PA TL EB 21 5 Ee FR 2 HBS 518040 2F 3rd Building Crown Science Park No 21 Tai Ran 9th Rd Che Gong Miao Futian Dist Shenzhen China Postal 518040 TEL 86 755 83542210 FAX 86 755 83700087 Acrosser Shanghai Office IW 1515 R T A BRA A E
36. roblem still exist please contact Acrosser FAE or authorized sales channels What can I do if my system does not power on e If your system can not power on via adapter below are a few steps you can follow to attempt to correct the issue e Ensure that the power cord and AC adapter are plugged solid and not loose fitting e Ensure the adapter output is DC 12V min 60W www acrosser com 51 E CROSSER AES HM76Z1FL User Manual e Ensure the DC 12V output correctly connect to the system e Attempt to use a different electrical outlet or a different adapter e If your system can not power on via ATX PSU below are some steps you can fellow to attempt to correct this problem e ATX PSU has some protections Ensure that PSU PS_ON signal connect to GND and the PSU output DC 12V to the system e Because the system only use DC 12V it will not consume 3 3V and 5V output Some PSUs could mis judge the situations and stop any voltage output e Ensure the DC 12V output correctly connect to the system e Attempt to use a different electrical outlet or a different PSU Q 7 No display when power on e Make sure all cables are connected correctly and the power has been turned on e Restore CMOS default setting via CMOS headers then reboot the system e Ifthe problem still exist please keep the necessary components e g CPU memory keyboard and HDD for testing e If the system could power on well with the above configuration please
37. splays the amount of memory installed Memory Frequency This item displays the speed of memory installed ME FW Version This item displays the ME FW version ME Firmware SKU This item displays the ME Firmware System Language Choose the system default language System Date This option allows user to set the date on the system real time clock RTC Use your keyboard to navigate to the month day or year and type in the correct numeric value Acrosser Technology Co Ltd LI ECROSSER AES HM76Z1FL User Manual Note Note 3 3 The Day option automatically changes when you set the Date option System Time This option allows user to set the time on the RTC Use your keyboard to navigate to the hour minute or second and type in the correct numeric value The time is in 24 hour format For example 5 30 A M appears as 05 30 00 and 5 30 P M as 17 30 00 Access Level This feature enables user to provide access to the user based on the administration rights whether the user can be an Administrator or Guest User Advanced Setup Select the Advanced menu item from the Aptio Setup Utility to enter the Advanced BIOS Setup screen You can select any item in the left frame of the screen and press lt Enter gt key to enter its sub menu and access its parameters Aptio Setup Utility Copyright 2012 American Megatrends Inc Advanced Ref Boot Security Save amp Exit STAT Device Options Settings K F81216
38. ut it when you install SATA hard disk driver USB There are three USB 3 0 connectors provided on the mainboard These USB 3 0 connectors are backward compatible with the USB 2 0 There are also two USB 2 0 ports provided 1 for Mini PCle 1 for Combo Connector Acrosser Technology Co Ltd FECROSSER AES HM76Z1FL User Manual 4 6 4 6 1 GPI GPO connector definition GPIO2 COM4 pin definition al pa io pa al pe io me www acrosser com 33 E CROSSER AES HM76Z1FL User Manual 4 6 2 GPIO1 COM3 pin definition al Re 0 re 5 1 GN Sla Laa TRT me 4 6 3 GPI GPO cable color definition GPI GPO DB15 Cable 34 Acrosser Technology Co Ltd Ee AES HM76z1FL User Manual 5 Driver and Utility Installation 5 1 CD Title Introduction Acrosser s CD Title is a compact driver and utility CD that enables a fast and easy installation for all the drivers utilities applications and documents this product may need Put the CD Title into your CD ROM drive The CD Title will automatically detect the mainboard information to see if they are matched The following error messages appear if you use an incorrect CD Title version with your mainboard Please find the correct CD Title to proceed www acrosser com 35 E CROSSER AES HM76Z1FL User Manual Put the correct CD Title of your mainboard into your CD ROM drive The following installation screen should appear www acrosser com
Download Pdf Manuals
Related Search
AES HM76Z1FL