User Manual
Contents
1. SIX PAK GENERAL SPECIFICATIONS Load Limit 400 Ibs 181 kg Size 12 30 48 cm 18 45 7 cm 34 to 2 Va thicknesses Pin and Non Pin Boards Weight 14 05 Ibs 6 37 kg Length 10 x 22 25 4 cm x 55 9 cm Height 10 25 4 cm Width 10 25 4 cm Installation EE Log roll patient onto the long back board Position the patient approximately 12 304 8mm from the bottom allowing for easy installation of the Six Pak PF Pass the upright safety straps P24 Adjust both upright safety straps at the same time to remove any SLACK that may exist in the straps through the hand hold opening on each side of the spine board Please note The Six Pak mainframe can be installed on MANAG most Pin and Non pin boards K J Slide the Six Pak mainframe on to the bottom of any spine board FIJ Once the upright safety straps have been fed through the back board hand holds secure the speed clips to the sewn in D Rings on the upright straps EJ Hold excess strap end away from center of the center board mounting strap buckle and lock in place WAI Connect upright safety straps WC 206 to the top of the mainframe upright loop opening PLEASE NOTE The speed clip end is only at the bottom The D Ring end is at the top of the board and should be installed near the hand holes WATERCREST COTE 2 OLLEN way installation Continue2. e EMS Fire Rescue e Offers the rescuer stability and control e Can be used in single rescue situations e Ideal for long distance rescue e Reduces drop risk and harm to patient and or rescuers e SWAT Extractions Assembies audy e Adaptable to most square and tapered spine boards 12 30 48 cm 18 wide 45 7 cm e MCI Incidents e Load limit 400 Ibs 181 kg e Can be installed on Pin amp Non Pin Boards e Quick three strap anchoring system e User friendly installation of tri wheel pin assembly e Oil Platform Rescue e Unique tri wheel design which stays in contact with stair riser e Promotes smooth stair tread transitions when carrying up and down stairs e Especially good in tight quarters where the need to pivot around e High Rise Rescue corners doors or any other obstacles may impede your exit e Enters and exits easily from elevators e Compact design makes for easy storage Rapid Intervention Teams P E E eile bag with reinforced bottom e Easy to clean and decontaminate e Special protective finish to ensure low maintenance product life e Wilderness Rescue e Made from 5052 Aircraft Grade Aluminum e Specially formulated axle bushings that never need replacement e Sealed bearings on tri wheel assembly designed for easy replacement if necessary e Stadium Rescue e Replacement parts available WATERCREST COLNE a OLLEN way WC 201 MAINFRAME W CENTER BOARD STRAP Capacity
3. 1 500 Ibs 681 6kg Material 5052 Aircraft Grade Aluminum WC 202 CENTER BUCKLE amp LOCK STRAP ASSEMBLY 1 Capacity 1 000 Ibs 454 kg Material Heavy weight polypropylene PLEASE NOTE If replacement of WC 205 center buckle strap should become necessary please refer to page 6 WC 205 Center Strap Reinstallation Guide Fig s 1 9 WC 203 UPRIGHT SAFETY STRAPS 2 Capacity 900 Ibs 408 kg very low stretch ratio when wet Material Heavy weight polypropylene D RING Capacity 2 812 Ibs 1 267 kg Material Cast nickel SPEED CLIP Capacity 268 Ibs 122 kg Material Cast nickel WC 204 TRI WHEEL AXLE ASSEMBLY 2 Capacity 1 500 Ibs 681 6kg Material Stainless steel Q we 205 sareTy Pins 2 Capacity 500 Ibs 227 kg Material Stainless steel Q WC 206 WHEELS 6 Capacity 200 Ibs 91 kg per wheel Operating Temperatures Negative 20 F 28 9 C to 180 F 82 C Material High temp neoprene WC 207 WHEEL AXLE SHAFT SUPPORT amp FASTENERS Capacity 690 Ibs 313 kg Material Zinc plated steel Q WC 208 BEARING ASSEMBLIES 2 Capacity 600 Ibs 272 kg Material Hardened steel WC 209 LOCATION PIN TRI WHEEL ASSEMBLIES 2 Capacity 800 Ibs 363 kg Material Stainless steel we 210 storace BAG Capacity 200 Ibs 91 kg Material Tri laminated reinforced vinyl with pliable plastic wall reinforcements Q WC 211 USERS MANUAL WC 212 INSTRUCTIONAL DVD
4. a OLLEN way Maintenance of the Six Pak Cleaning and Disinfecting Inspecting the Six Pak Warnings the Six Pak Are all the components present For professional use only Permit only trained personnel to 1 Rinse off with warm water apply Six Pak to spine board Check straps for any 2 To disinfect apply a solution excessive wear e Untrained operator s can cause of 2 to 5 chlorine bleach Injury or be Injured and water a Improper installation can lead to Check strap stitching patient injury 3 Rinse all pieces with warm water l Six Pak must be removed when 4 Allow all pieces to dry _ Check wheels for any used in a MRI completely before returning excessive wear or gouges Never leave patient unattended them to storage case on their surface area Stay with patient at all times Disclaimer This manual contains general instruction for use operation and care of this product The instructions are not all inclusive Safe and common sense use of this product is the sole discretion of the user Safety information is included as a service to the end user All other safety measures taken by the user should be within and under consideration of applicable regulations It is recommended that training on the proper use of this product be provide before using this product in an actual situation Propriety Notice The information disclosed in this manual is the property of WaterCrest Industries
5. Audubon MN 56511 USA Reserves all patent rights propriety design rights manufacturing rights reproduction use rights and sales rights thereto and to any article disclosed therein except to the extent those rights are expressly granted in writing to others or where not applicable to vendor propriety rights VATERCREST C1COLING a QLLEL way 2009 WaterCrest Industries LLC
6. d Secure Center Board strap EJ Once the Six Pak mainframe E J Install safety pins through holes WC 205 by pushing the is properly installed to the so that safety pin bottoms out handle from right to left This long back board then proceed on the mainframe assembly will insure the strap is locked with a rescuer on each side of A wsadi eked in place the patient to slide the patient ahaa SED oneree ener Checkihe Enema mainframe down until the patients feet rest APEN oe against the foot plate of the IMPORTANT Make sure the WC 201 to ensure that it is Spal manane Then f Ae h firmly attached to the board pares PUD 1S pushed throug proceed to secure the patient to the main frame and closed and the long back board with locked in place the back board straps l WARNING Be sure to place chest strap below arms and NOT OVER THE ARMS THIS WILL LIMIT THE PATIENT S ABILITY TO SLIDE DOWN ON THE BOARD If arms need to be secured use the Hand E EES A properly installed Six Pak mainframe to a long back board Make sure that the Six Pak mainframe is firmly in place and NO side or upper movement from the Six Pak mainframe board exists EE You are now ready to use the Six Pak with the confidence we have engineered into making your job safe and easy Install tri wheel assemblies l WC 204 by aligning tri wheel gr shaft to mainframe WC 201 opening To ensure correct installation of the tri whee
7. l assemblies WC 204 hold the horizontal shaft of the tri wheel f assemblies and allow the offset E7 to hang down and then insert the tri wheel assemblies into the mainframe WC 201 Make sure that the safety pin holes match up correctly and safety pin WC 209 will slide into place smoothly PLEASE NOTE Either wheel assembly can be inserted on either side of the Six Pak mainframe to at F PA raa i d F o Z 2 ee 7 a r D p e j aie i w j F i ii an a j a gt z 5 i i AR F 4 w i hes i i t n 4 t aT aa J EE Feed strap through the slot on RE Again feed the strap on the Slide the strap to allow enough the right upright outside of the left upright and slack to follow the strap back through the slot on the front of through the slot adjacent to the the left upright left upright vey iH To feed the strap into the over center buckle hold the buckle E Now the over center buckle is open to the right properly fed and will allow for ff Next feed the strap on the use To lock fold the buckle to outside of the upright and the left follow it back through on the back of the right upright ff Now feed the strap through the second slot of the over center buckle fig 9 Correctly installed center over buckle in locked position fH Pull strap through and slide the strap in the back left upright WATERCREST TCO
Download Pdf Manuals
Related Search