Interlock User Manual 3.0.book
Contents
1. in an area with ex treme temperatures Do not disconnect the handset while driving or while the Interlock is requesting a re test If you disconnect the handset during these condi tions a violation will be recorded If you are instructed to disconnect the Interlock e When the vehicle is off unplug the modular cable located at the bottom of the handset by pressing down on the lever and gently pulling the cord out of the handset e In extreme temperatures hot or cold the Interlock start up procedure will take longer To avoid this disconnect the In terlock and store it in a room temperature location e Again do not remove the Interlock unless the Service Pro vider has instructed you that this is allowed Unauthorized disconnection of the Interlock will be recorded as a viola tion 9 Vehicle Repairs 9 1 Battery Recharging or Replacement If your battery dies or is disconnected the Interlock will detect the power loss It is your responsibility to document what hap pened for the monitoring agency If the battery is recharged or jump started record the date and time that the battery lost power and the date and time of recon nection If you need to replace the battery and choose to do it yourself then make a copy of the receipt to show the replacement If you have a repair facility replace the battery bring a copy of the receipt for the charges parts and labor to your next appoint ment 9 2 Vehicle Maintenance It2. prepare to test again e Take the test again and perform a sharp suck back when the tone stops Suck until a beep sounds Drager Interlock XT User Manual V3 0 2013 Random Retest 6 Random Retest 6 1 Whatis a Random Retest To make sure the user stays sober while driving the Interlock requires you to take additional tests while you drive You must give additional breath tests at random intervals perhaps several times before you turn off your vehicle e When the Interlock prompts for Retest you will hear a beep and the yellow light will flash e The Interlock display will read Retest required PLEASE BLOW You will have several minutes to give the test Do not turn off the vehicle to avoid the retest This will be recorded as a violation The breath sample is given in the same way as the original test 6 2 Questions about Random Retests What happens if do not hear the retest prompt The Interlock XT will start beeping an audible tone continuously to alert you Stop the tone by pushing the OK button and taking the test What happens if do not take the retest in time The message Retest Violation appears on the display the tone will beep continuously and the vehicle s horn may honk and or the parking lights may flash You must turn off the vehicle to deactivate the horn and lights The vehicle will not shut down while you are driving What happens if fail the retest Make sure your mouth
3. technician and only Dr ger spare parts may be used Otherwise the proper functioning of the device may be impaired 1 1 2 Note In this document the Dr ger Interlock XT is also referred to as the Interlock or Interlock XT 1 2 Definition of alert icons The following alert icons are used in this document to provide and highlight areas of the associated text that require a greater awareness by the user A definition of the meaning of each icon is as follows CAUTION Indicates a potentially hazardous situation which if not avoided could result in physical injury or damage to the product or environment It may also be used to de scribe unsafe practices to be avoided NOTICE Indicates additional information regarding the device 2 Copyright and legal disclaimer Copyright Draeger Safety Diagnostics Inc 2013 All rights reserved Reproduction of this document in part or whole by any means electronic or otherwise is prohibited except by express written permission of Draeger Safety Diagnostics Inc Draeger Safety Diagnostics Inc 4040 W Royal Lane Suite 136 Irving TX 75063 Phone 972 929 1100 Fax 972 929 1260 www draeger com Drager Interlock XT User Manual V3 0 2013 For your safety 2 1 Disclaimer Draeger Safety Diagnostics Inc accepts no responsibility for technical inaccuracies and reserves the right to make periodic changes enhancements revisions and alterations to the program
4. Drager Instructions for Use B2 Dr ger INTERLOCK XT User Manual Version 3 0 Cli Drager Technology for Life Table of Contents 1 For your safety xoc dudes ikke bald cere d XEM Led Rd RER REEL MERECE cis Copyright and legal disclaimer nn n nn nn nn nn nn nn VETVICW E E E E E Do s and Don ts of Interlock Use eee Ann RAA RR RR RR 2 3 4 5 Breath Test at Vehicle Start sssssssssssssssssssnnrsssnnnnnnnnnnnn nan n nn nn nn ann nn nn nan 5 Random heteslui iei cien cx Rd ai Cx D Dn s a saco Di a KR SE CREEK 7 Service Requirements s sssssssssssssssssssssssnnnssnnn nn n rr nn nn nn nn RR ARR R RNE RR RR RR RR nennen Xni 6 dns aa aaa Aaa das ss aaa a araea EN a SicclLreeem T 10 Program Information ioci osieie ecco eec prb rd ard a rd a ardua ARR ARR RR RR RR di E Eck nn nn 11 Contact Information s ss ssssssssssssrsrsnrsn nns nn rn nen RAR RENAR RAR ARR RR RAR RER ARR RAR ARR nr unas 1 For your safety 1 1 General safety statements e Forcorrect and effective use of the described instrument it is essential to read and strictly follow the instructions contained in this document e The instrument is only to be used for the purposes specified herein 1 1 1 Maintenance Repairs of the described instrument may only be performed by Draeger Safety Diagnostics Inc or an authorized service
5. and vehicle are free of alcohol vapors and smoke If the alcohol level was above the set point the device may go into the Temporary Lockout mode If this happens pull over and turn off the engine Wait for the time to count down and when prompted to do so provide a breath sample Notice You have several minutes to take the Retest Drager recommends that you pull over to the side of the road when it is safe to do so to take the retest Do not turn off the engine while the Interlock is asking you to take a retest 7 Service Requirements 7 1 Overview The Interlock XT must be serviced periodically When the Inter lock is serviced the data in the Interlock is downloaded and the device is checked to ensure that it continues to work properly You must take your vehicle to the service location when service is required 7 2 Early Service Reasons The Interlock is programmed to require servicing earlier than scheduled if some conditions occur Not all of these conditions are violations This could be caused by Vehicle maintenance Interlock Memory is full A failed Breath Alcohol Test A skipped retest A failed retest Tampering with the Interlock Attempts to circumvent the Interlock 7 3 Device Lockout If the vehicle is not taken to a service location within the allotted time then the Interlock will lock out the vehicle The Interlock will show Service Lockout on the Interlock s display The Interlock will not allow the v
6. eft side of the device will light up Turn the key to start your vehicle Test Failed If the breath sample is above the set point the message Test Failed will appear Figure 4 and the red light on the right side of the device will light up The vehicle will not start Drager j Figure 4 Test Failed X Cox Figure 3 MC Test Passed A 5 4 Failing the Breath Test If you fail the breath test e The vehicle will not start e The device may go into temporary lockout e Ifthe alcohol content of your breath is very high the tempo rary lockout may be longer e The display will show you how much time remains in the Temporary Lockout period Temporary Lockout 00 4 45 Dr ger Prieto 1 Figure 5 Temporary Lockout 5 5 Breath Test Messages If you hear beeping or see a red light flash during a test stop and look at the display The displayed message will tell you what went wrong and you can retake the test Blow Longer e Means you did not blow long enough e Press the OK button and the Interlock will prepare to test again e Take the test again and blow until the buzzer sounds Blow Stronger e Means you did not blow hard enough e Press the OK button and the Interlock will prepare to test again e Take the test again and blow a little harder Suck after Blow e Means that you did not do the suck back correctly e Press the OK button and the Interlock will
7. ehicle to start Call your local service location for assistance 7 4 Service Specifics An authorized service technician will Download the information stored in the device Log the odometer reading Inspect the Interlock for evidence of tampering Check the wiring and connections Calibrate the Interlock Work with you to schedule your next appointment Drager Interlock XT User Manual V3 0 2013 Service Requirements 8 Interlock Care 8 1 Interlock Precautions When the Interlock is in your possession e Keep the Interlock dry e Make sure your windows are always closed and that your doors are locked when you are away from your vehicle e Do not spill anything onto or into the Interlock If this hap pen do not turn the system on and contact your provider e Treat the Interlock as you would a cellular phone or other portable electronic device e You will be liable for any damage the Service Provider or Manufacturer believes was caused by misuse abuse and or neglect of the Interlock 8 2 Handset Cleaning If the Interlock gets dirty e Use a lightly dampened cloth to wipe off dirt e Never use a cleaner or soap on the Handset e You can ask the service technician to clean it for you at your next service appointment 8 3 A Disconnecting the Handset CAUTION Do not disconnect the handset without authorization In some states this is a violation You may be instruct ed to remove the handset if you live
8. is your responsibility to keep the Interlock clean Cover the handset with a clean sock or towel while the vehicle is in the repair shop If your repair shop has any questions have them contact your service technician If your vehicle will be in the shop for an extended period of time the repair facility may advise you to seek authorization for a temporary disconnect of the Interlock Ask the repair shop to contact the Service Technician for instructions 9 3 Other Maintenance Information For minor service observe the vehicle while it is being serviced Ensure that alcohol free solvents are used in your vehicle If al cohol solvents are used air out your vehicle before taking the initial test for at least 15 minutes For major repairs ask the automotive technician to contact the Service Technician for instructions If vehicle repairs take more then a few days you may be re quired to make up time on your Interlock program Drager Interlock XT User Manual V3 0 2013 Vehicle Repairs 10 Program Information The device must be serviced every days The vehicle will continue to operate for day s after the above service period expires If the vehicle is locked because you did not bring it in for service it will be your responsibility to tow the vehicle into the service center at your expense There may be fees for missed appointments The device will display Failed and temporarily disable the ve hicle when there is alcohol prese
9. nt in the breath sample If you fail test s in a row the device will enter the lockout period The first lockout period is minutes long After this time has expired you may try the test again If you fail another test s in a row the device will enter the second lockout period for minutes After this time has ex pired you may try the test again The lockout period for a failed breath testis minutes long If you perform the test incorrectly times in a row the device will enter the first lockout period If you continue to perform the test incorrectly it will enter the second lockout period After the time has expired you may try the test again You have ____ minute s to start the vehicle after you pass the breath test The device will ask you for the first retest to minutes after you start the engine After that the device will ask you for other retests every to minutes You have minutes to pass the retest Failure to pass a re test within this time will result in a violation and if the engine is running honk the horn and or flash the parking lights as well The vehicle will not shut down If your vehicle stalls or you turn it off you may restart it within minutes without having to pass another breath test The device will enter the Violation Reset mode after viola tion s If not serviced within day s your vehicle will be dis abled You will see only Service Lockout displayed on
10. r within 15 minutes of using the device 5 2 Turning on the System To turn the system on 1 Insert a clean dry mouthpiece into the Interlock device as shown in Figure 1 below 2 Insert the key into the ignition switch 3 Turn key to the on position usually two clicks 4 The Interlock will show Warming up PLEASE WAIT on the display screen as shown in Figure 2 and the yellow light on the left side of the device will remain constantly on 5 When the Interlock is ready for the breath sample it will dis play Ready for Test PLEASE BLOW on the screen as shown in Figure 2 and the yellow light on the left side of the device will flash repeatedly 6 Take a few normal even breaths 7 Take a deep breath and put your lips around the mouth piece 8 Provide a steady blow into the mouthpiece by exhaling nor mally As you blow into the Interlock a tone will sound This means you are blowing correctly Do not stop 9 When the tone stops immediately give a sharp suck back until you hear a beep f macty f r Tent Please blow Drager Figure How to Insert Mouthpiece Drager Interlock XT User Manual V3 0 2013 Breath Test at Vehicle Start 5 3 Test Results The Interlock will display Test Passed or Test Failed if the breath sample was given correctly Test Passed If the breath sample is below the set point the message Test Passed will appear Figure 3 and the green light on the l
11. s and or its manuals without obligation to notify any person institution or organization of such changes enhancements revisions and alterations 2 2 License Agreement The Firmware Software within the instrument is the property of Draeger Safety Diagnostics Inc and is protected by US Copyright Law Trademark Law and International Treaty Provisions No ownership or title to the Firmware Software is transferred to the User Draeger Safety Diagnostics Inc does not grant any express or implied right to the User under Draeger Safety Diagnostics Inc s patents copyrights trademarks or trade secret information except as set forth immediately below Draeger Safety Diagnostics Inc grants the User a non exclusive license to use the Firmware Software as part of User s use of the Hardware and under the following terms and conditions 1 User shall not remove or obscure Draeger Safety Diagnostics Inc s copyright trademark or proprietary notice from the Hardware and any documentation associated with the Hardware 2 User shall not copy sell transfer loan rent lease modify extend improve or create derivative works or alter the Firmware Software in any way nor shall User allow any other entity to do so without the express written consent of Draeger Safety Diagnostics Inc 3 User shall take appropriate steps to prevent any unauthorized copying of the Firmware Software 4 User shall not take any actions inconsisten
12. t with Draeger Safety Diagnostics Inc s ownership of the Firmware Software 5 User shall not reverse engineer decompile or disassemble the Firmware Software or otherwise attempt to derive source code from the Firmware Software nor shall User allow any other entity to do so The foregoing license is nontransferable except in conjunction with a permanent transfer of the Hardware to another entity and providing such other entity expressly acknowledges and agrees to the terms and conditions of this license 3 Overview 3 4 Purpose The Dr ger Interlock XT allows you to start your vehicle once you provide a breath sample below the set limit for your instrument If the alcohol content of your breath exceeds the allowed limits your car will not start 3 2 Service The Interlock will warn you in advance when your next service deadline is approaching If you do not have your device serviced as scheduled the unit will lock out and you will be unable to start your vehicle 3 3 Violations A violation is an event recorded in the Interlock device when it is not used correctly a test is ignored the device is disconnect ed or an attempt is made to circumvent a test or tamper with the device Violations are recorded and reported to your mon itoring agency Drager Interlock XT User Manual V3 0 2013 Overview 4 Do s and Don ts of Interlock Use 4 14 Do s DO keep the unit clean and dry at all times DO use a clean dry mo
13. the Interlock Contact your Service Provider immediately if device lockout is displayed Drager Interlock XT User Manual V3 0 2013 Program Information For appointment information please call Your Program Number is Please have this number available whenever you call your Service Provider For emergencies only please call to contact your Service Technician Please allow up to 45 minutes for the call to be returned Do not block unknown telephone numbers on your telephone line Make sure you know exactly what message is being displayed on the Interlock If necessary write the message down and take it inside with you so it will be handy when the call is returned If your telephone will not accept calls from phones whose num ber is blocked you must temporarily disable this feature in or der for your call to be returned Draeger Safety Diagnostics Inc 4040 W Royal Lane Suite 136 Irving TX 75063 USA Tel 972 929 1100 Fax 972 929 1260 Www draeger com Draeger Safety Diagnostics Inc Version 3 0 2013 Subject to alteration
14. uthpiece when providing breath tests DO contact your Service Provider with any questions or concerns A 4 2 CAUTION Leave the tamper evident label in place Any attempt to remove the label is a violation Don ts DO NOT use or consume any product other than water within 15 minutes of using the device DO NOT place the handset on the vehicle s floor while driving If the device is not secured it may interfere with the pedals and the safe operation of the vehicle DO NOT use the handset while driving if you are at all unsure about your safety If you are asked for a breath test while driv ing Drager recommends that you pull over before taking the breath test DO NOT attempt to disable the handset or fail to provide a ran dom retest This will shorten the service interval and these ac tions are recorded in memory DO NOT tamper with abuse misuse and or neglect the Inter lock device Tampering with the device may be a violation of the law and result in fines and or incarceration A CAUTION To ensure a valid breath test you must abstain from eating drinking any fluids except water or smoking for at least 15 minutes prior to providing an initial breath test As the Interlock may require a random re test while you are driving you should not eat drink ex cept water or smoke while driving your vehicle 5 Breath Test at Vehicle Start 5 1 Preparation Do not use or consume any product other than wate
Download Pdf Manuals
Related Search