ELECTRIC SAUNA HEATER
Contents
1. emit some odour If you detect any odour while the sauna heater warms up disconnect the sauna heater briefly and air the room Then you can turn the sauna heater on again The sauna heater is turned on from the control panel that has controls for the heating temperature and time The heating of a sauna should be started roughly an hour before you plan to take a sauna bath so that the stones have time to heat up properly and the air warms up evenly in the sauna room Do not put any objects on the sauna heater Do not dry clothes on the sauna heater or anywhere in its vicinity Installation and User Manual Helo Ring 9 2 4 Sauna heater stones Quality stones meet the following requirements 1 Sauna stones should withstand heat and heat variation caused by vaporisation of the water thrown on the stones 2 Stones should be rinsed before use in order to avoid odour and dust 3 Sauna stones should have an uneven surface to supply a larger surface for the water to evaporate from 4 Sauna stones should be large enough measuring about 50 80 mm to allow good ventilation between the stones This extends the useful life of the heating elements 5 Sauna stones should be piled sparsely in order to enhance ventilation between the stones Do not bend the heating elements together or against the frame Rearrange the stones regularly at least once a year and replace small and broken stones with new larger stones Stones are piled so that they cov2. sauna room s volume 4 Check page 8 Table 2 for a suitable fuse size A and the correct diameter of the power supply cable mm for the sauna heater in question 5 Conform to the specified safe clearance around the sauna heater Please refer to Table 1 on page 7 6 There should be enough room around the sauna heater for maintenance purposes Also a doorway can be considered as a maintenance area 3 2 Installation Follow the safety clearance specifications on page 7 when installing the sauna heater The sauna heater is a floor standing model The base must be solid because the sauna heater weighs about 75 kg The sauna heater is levelled by the adjustable legs The sauna heater is fixed on the floor from its legs by the provided metal fasteners 2 pcs This will keep the safety clearances intact during use The minimum clearances specified on page 7 must be followed even if the sauna room wall materials are incombustible Walls or ceilings must not be clad with fibre reinforced plaster board or other light weight cladding because they may cause a fire hazard Install the sauna heater so that the sign and the warnings can be read even after the installation The control panels are installed outside the sauna room with the exception of the Midi controller which is installed on the wall beside the sauna heater Refer to more detailed installation instructions in the installation and operation guide of the control panel Only a
3. 1 Check before taking a sauna bath The sauna room is suitable for taking a sauna bath The door and the window are closed The sauna heater is topped with stones that comply with the manufacturer s recommendations the heating elements are covered with stones and the stones are piled sparsely po be NOTE Ceramic rocks are not allowed A pleasant smooth sauna bath temperature is about 70 C degrees Rearrange the sauna stones at least once a year and replace any weathered stones This enhances air circulation between the stones which extends the useful life of the heating elements If you encounter any problems please contact the manufacturer s warranty service shop For additional information about enjoying a sauna bath please visit our website at www helo fi 1 2 Operation of the sauna heater controls The main switch is located on the side of the sign at the bottom of the sauna heater The sign shows the position of the switch 0 Refer to the specific control panel operating instructions 2 Information for users Persons with reduced physical and mental capacity sensory handicap or little experience and knowledge about how the device is operated e g children should only operate the device while supervised or according to instructions given by the persons in charge of their safety Make sure that children aren t playing with the sauna heater 2 1 Sauna room The walls and ceiling of a sauna room should be th
4. 2 4 Helo Ring spare part list Part 1 5 7 5 ROHS Helo Ring 900 eu Sean SSS regen Vereen 7 een Date 2 Cens Peien In C7306611 Rubber cover forrockerswich 1 mon 1 erna Io 4316221 0207518 Heating element SEPC 202 2000W 230V Heating element SEPC 203 2670W 230V 6216410 Circuit board OLEA 83 Heater with Midi control panel Ymp rist n suojeluun liittyvi ohjeita T m n tuotteen k ytt i n p tytty sit ei saa h vitt normaalin talousj tteen mukana vaan se on toimitettava s hk ja elektroniikkalaitteiden kierr tykseen tarkoitettuun ker yspisteeseen Symboli tuotteessa k ytt ohjeessa tai pakkauksessa tarkoittaa sit Valmistusaineet ovat kierr tett viss merkint ns mukaan K ytettyjen laitteiden uudelleenk yt ll materiaalien hyd ynt misell tai muulla uudelleenk yt ll teet arvokkaan teon ymp rist mme hyv ksi Tuote palautetaan ilman kiuaskivi ja verhouskivi kierr tyskeskukseen Tietoa kierr tyspaikoista saat kuntasi palvelupisteest Instructions for environmental protection This product must not be disposed with normal household waste at the end of its life cycle Instead it should be delivered to a collecting place for the recycling of electrical and electronic devices The symbol on the product the instruction manual or the package refers to this The materials can be recycled according to the markings on them B
5. en Puissance Vermogen Resistencias 230 V Potencia SEPC 202 SEPC 203 3 2 D 1 RE 1 tt SE L2 L3 E i 400V 415V 3N E E E EEE t ft tt QD n L1 L2 L3 J11 A12345 B12345 J10 LL H 4 1 2 3 4 Sin Val Pun Kelt Bla Vit Rod Gul eee ae LC Blau Web Rot Gelb a i i Blue White Red Yellow i i i Bleu Blanc Rouge Jaune H Blauw Wit Rood Geel 5 i 1 i Azul Blanco Rojo Amarillo 6 Katso ohjauskeskuksen kayttoohje Se styrpanelens bruksanvisning Sehe die Bedienungsanleitung des Steuergerates See the control panel manual Voir le manuel du panneau de commande Zie handleiding bedieningspaneel Consulte el manual del panel de control 1 Syotto Natet Stromnetz Power input Puissance absorb e Vermogensingang Entrada de alimentacion 2 Saunavalo Bastu belysning Saunabeleuchtung Sauna light Eclairage du sauna Saunaverlichting Luz de sauna 3 Tuuletin Fl kt Ventilator Fan Ventilation Ventilator Ventilaci n 4 Sahkolammityksen vuorottelu Alternering med elvarme Signal kontakt Signal contact Contact du signal Signaalcontact Contacto senal 5 Ohjauskeskus Styrpanel Steuergerat Control panel Panneau de commande Bedieningspaneel Panel de control 6 Tuntoelin Sensor F hler Sensor Capteur Sensor 354 SKLT 5B Image 4 wiring diagram for the sauna heater Installation and User Manual Helo Ring 1
6. er the heating elements Do not however pile a large heap of stones on the heating elements For a sufficient amount of stones refer to Table 1 on page 7 Any small stones in the package of stones must not be piled on the sauna heater The warranty does not cover defects resulting from poor ventilation caused by small and tightly packed stones Ceramic rocks are not allowed They may cause damage to the sauna heater that will not be covered by the warranty 2 5 If the sauna heater will not heat up If the sauna heater will not heat up please check that the power is on the main fuses of the sauna heater are intact is there any error messages on the control panel In case of an error message on the control panel please refer to the control panel instructions Installation and User Manual Helo Ring 6 3 Instructions for the installer THE PERSON INSTALLING THE SAUNA HEATER SHOULD LEAVE THESE INSTRUCTIONS AT THE PREMISES FOR THE FUTURE USER 3 1 Preparing for sauna heater installation Check the following before installing the sauna heater 1 The ratio of the heater s input kW and the sauna room s volume m Volume recommendations are presented in Table 1 on page 7 The minimum and maximum volumes must not be exceeded 2 The sauna room height must be a min of 1900 mm 3 Uninsulated and masonry stone walls extend the preheating time Each square metre of plastered ceiling or wall surface adds 1 5 2 m to the
7. ermally well insulated All surfaces that store heat such as tiled and plastered surfaces must be insulated It is recommended to use wooden panel cladding inside the sauna room If there are heat storage elements in the sauna room such as decorative stone glass etc note that these elements may extend the pre heating period even though the sauna room is otherwise well insulated see page 6 section 3 1 Preparing for sauna heater installation Installation and User Manual Helo Ring 4 2 2 Recommended sauna room ventilation RR NEES E E Image 1 Recommended sauna room ventilation 1 Sauna room 3 Electric sauna heater 5 Exhaust flue or channel 2 Washroom 4 Exhaust valve 6 Door to the sauna room 7 Aventilation valve can be installed here to be kept closed while the sauna is heated and during bathing Inlet vent can be positioned in the A zone Make sure the incoming fresh air will not interfere with i e cool down the sauna heater s thermostat near the ceiling The B zone serves as the incoming air zone if the sauna room isn t fitted with forced ventilation In this case the exhaust valve is installed min 1m higher than the inlet valve DO NOT ISTALL INLET VALVE WITHIN ZONE C IF THE SAUNA HEATER S CONTROL THERMOSTAT IS LOCATED IN THE SAME ZONE 2 3 Heating the sauna Before turning the sauna heater on make sure the sauna room is suitable for taking a sauna bath When heated for the first time the sauna heater may
8. helo GENUINE SAUNA amp STEAM Installation and User Manual Helo Ring DE ELECTRIC SAUNA HEATER 1118 600 0405 1118 900 0405 CONTROL PANELS 1601 12 RA 12 Digi I 1601 13 RA 13 Digi I 1601 16 RA 16 Easy 1601 18 RA 18 Midi 314 SKLT 34 A Installation and User Manual Helo Ring Contents 1 Quick instructions for use of the sauna heater dd 1 2 Check before taking a sauna bath Operation of the sauna heater controls 2 Information for users 2 1 2 2 2 3 2 4 2 9 Sauna room Recommended sauna room ventilation Heating the sauna Sauna heater stones If the sauna heater will not heat up 3 Instructions for the installer 3 1 3 2 KSC 3 4 3 5 3 6 3 7 3 8 Preparing for sauna heater installation Installation Sauna heater safety clearances Connection of the sauna heater to the mains Electric heating toggle Locating the connecting box for the connection cable in the sauna room Principle image when Digi Il is used as control panel Wiring diagram 4 Helo Ring spare part list 5 ROHS Images and tables Image 1 Recommended sauna room ventilation Image 2 Location for the connection box Image 3 Principle image Image 4 Wiring diagram for the sauna heater Table 1 Safety clearances Table 2 Connection cable and fuses 10 11 12 12 Installation and User Manual Helo Ring 3 1 Quick instructions for use of the sauna heater 1
9. on and User Manual Helo Ring 3 6 Locating the connecting box for the connection cable in the sauna room Image 2 Location for the connection box 100 mm Specified minimum safety clearance 1 Recommended location for the connecting box 2 Silumin box recommended in this area 3 This area should be avoided Always use a silumin box In other areas use a heat resisting box T 125 C and heat resisting cables T 170 C The connection box must be clear of obstacles When installing the connection box to zones 2 or 3 refer to the instructions and regulations of the local energy supplier Installation and User Manual Helo Ring 3 Principle image when Digi Il is used as control panel Connector strip Limiter 4 Yellow A1 Valk Vit White Weiss A2 Ruskea Brun Brown Braun A3 Vihre Gr n Green Gr n A4 Kelt Gul Yellow Gelb A5 Harm Gra Grey Grau Sensor S a Silicone 4 x 0 25 Sauna heater Image 3 Principle image 4 Yellow ee B1 Rosa Ljusrod Pink Rose B2 Sin Bla Blue Blau B3 Pun Rod Red Rot B4 Musta Svart Black Schwarz B5 Violetti Violett Violet Violett Control panel 1601 12 LiYY 10 x 0 25 230 240V 1N 2 Input 230V 3 400 415V 3N 10 Installation and User Manual Helo Ring 3 8 Wiring diagram Teho Effekt Lampovastukset Varmeelement l ments chauffants Power Leistung Heating elements Heizeelement Verwarmingselement
10. parate control current fuse the diameter of all cables must be the same i e in accordance with the front fuse The connecting box on the sauna wall should be located within the minimum safety clearance specified for the sauna heater The maximum height for the connection box is 500 mm from the floor See page 9 Image 2 Location for the connection box If the connection box is located at over 500mm distance from the heater the maximum height is 1000mm from the floor Sauna heater insulation resistance The sauna heater heating elements may absorb moisture from air e g during storage This may cause leakage currents The moisture will be gone after a few heating sessions Do not connect the heater power supply through a ground fault interrupter However adhere to the effective electrical safety regulation when installing the sauna heater Sauna heater s Sauna heater s Sauna heater s connection cable connection cable connection cable HO7RN F HO7RN F HO7RN F 60245 IEC 66 60245 IEC 66 60245 IEC 66 mm mm mm 400 415V 3N 230V 3 230 240V 1N 2 6 0 ox1 5 3 x 10 4 x 2 5 3x16 3x6 35 8 0 9X 2 9 3 x 16 4x6 3x25 3x6 35 Table 2 Connection cable and fuses 3 5 Electric heating toggle The electric heating toggle applies to homes with an electric heating system Sauna heater has a connection marked 55 for controlling the electric heating toggle Connector 55 and the heating elements are simultaneously live 230V Installati
11. single sauna heater is allowed per sauna room Installation and User Manual Helo Ring 3 3 Sauna heater safety clearances Saunaroom Safety clearances min Adequate amount of stones Table 1 Safety clearances Corner and wall installation The sensor is placed on the centreline of the heater Com Sensor 1100 100 Fixing the sauna heater on the floor NOTE fixing of two 2 legs 28 gU CT Ra Si j N i mm eae a Heater s leg iue Floor PS be Metal fastener i Adjustable leg b S Mid floor installation Sensor NOTE 2 Ke mm If the heater is placed more than 100 mm from the wall the Sahsdr installation type is always a mid 100 100 floor installation The sensor must be fitted to the ceiling according to instructions 1100 1900 800 Installation and User Manual Helo Ring 8 3 4 Connection of the sauna heater to the mains The sauna heater must be connected to the mains by a qualified electrician and in compliance with current regulations The sauna heater is connected with a semi permanent connection Use HO7RN F 60245 IEC 66 cables or a corresponding type Other output cables signal lamp electric heating toggle must also adhere to these recommendations Do not use PVC insulated cable as a connection cable for the sauna heater A multipolar e g 7 pole cable is allowed if the voltage is the same In the absence of a se
12. ung wiederverwertbar Mit der Wiederverwendung der stofflichen Verwertung oder anderen Formen der Verwertung von Altgeraten leisten Sie einen wichtigen Beitrag zum Schutze unserer Umwelt Dieses Produkt soll ohne Steine und S pecksteinmantel an dem Sammelpunkt f r Recycling zur ckgebracht werden Bitte erfragen Sie bei der Gemeindeverwaltung die zustandige Ents orgungsstelle
13. y reusing utilising the materials or by otherwise reusing old equipment you make an important contribution for the protection of our environment Please note that the productis returned to the recycling centre without any sauna rocks and soapstone cover Please contact the municipal administration with enquiries concerning the recycling place Anvisningar f r milj skydd Denna produkt f r inte kastas med vanliga hush llssopor n r den inte l ngre anv nds Ist llet ska den levereras till en tervinningsplats f r elektriska och elektroniska apparater Symbolen p produkten handboken eller f rpackningen refererar till detta De olika materialen kan tervinnas enligt m rkningen p dem Genom att teranv nda nyttja materialen eller p annat s tt teranv nda utsliten utrustning bidrar du till att skydda v r milj Produkten returneras till tervinningscentralen utan bastusten och eventuell t ljstensmantel V nligen kontakta de kommunala myndighetema f r att ta reda p var du hittar n rmaste atervinnin gs plats Hinweise zum Umweltschu tz Dieses Produkt darf am Ende seiner Lebens Dauer nicht ber den normalen Haushaltsabfall Entsorgt werden sondem muss an einem Sammelpunkt f r das Recycling von elektrischen und elektronischen Geraten abgegeben werden Das Symbol auf dem produkt der Gebrauchsanleitung oder der Verpackung weist darauf hin Die Werkstoffe sind gem ihrer Kennzeichn
Download Pdf Manuals
Related Search