gebruiksaanwijzing betriebsanleitung user manual mode d`emploi
Contents
1. 2012 08 Rev 0 0 75 EN Animo Coffee Convenience OptiFresh Bean 4 7 Stop dispensing cups or jugs 1 Press the stop button Caution A Do not pull away a cup or jug A running cycle will still have to be finished first 4 8 Filling the bean canister 1 If required unlock the cover of the bean canister 2 Remove the cover A 3 Fillthe bean canister 4 First put the beans in the small section and then in the large section of the bean canister 5 Replace the cover 6 If required lock the cover of the bean canister 4 9 Filling the instant canisters 1 Open the machine door 2 Turn the canister s outlet upwards 3 Liftthe canister from the socket and pull it out from the rotor B EN 76 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience 4 Remove the cover C 5 Fill the instant canister Make sure that you do not overfill the instant canister 6 Replace the cover 7 Replace the canister into the socket 8 Make sure the canister locks into place with the pin in the hole 9 Turn the canister s outlet downwards 10 Close the machine door 4 10 Using the coin mechanism optional Place a cup on the tray Press a recipe or press the hot water button Insert the correct amount of money The d2. 125 Safety QEV C S 51 1 6 Safety precationis eiit RERUMS ERR NER 53 1 7 Users ET 1 8 9 55 1 9 Guarantee MM P 55 1 10 Disposal 1 11 Further help and information th ehh thou bann 55 2 M M 2 1 OVOIVIGW Lacan centre E 2 2 Working principle E A Mezier reieu 2 4 DISPLAY MEUS 2 5 Configuration menu 2 6 Energy safe mode 3 Transport amp Installation 3 1 TRANS 322 Installation 4 g 73 4 1 Overview control panel 73 4 2 Overview control panel inside 74 4 3 Opening the door 74 4 4 Switching on and off in 75 4 5 Start dispensing cups D 4 6 Start dispensing jugs 75 4 7 Stop dispensing cups or jugs 76 4 8 Filling the bean canister 76 4 9 Filling the instant canisters 76 4 10 Using the coin mechanism optional se LL 4 11 Using the coin changer 77 5
3. If necessary connect the machine A with the hose B to the stand alone pump set C 5 Make sure that the minimal water pressure is not below 2 bar at 5 l min flow pressure 3 2 4 Electrical connection The machine is provided with an electrically suitable plug as advised and provided by the installer 1 Connect the green yellow coloured wire A either to the terminal which is either marked with PE the earth symbol or coloured green yellow Connect the blue coloured wire B to the terminal which is either marked with N or coloured black Connect the brown coloured wire C to the terminal which is marked with L 3 2 5 Drip tray discharge 1 Open the drip tray discharge A with a drill 6 mm 2 Connect a waste hose to the drip tray EN 70 2012 08 Rev 0 0 OptiFresh Bean www rp ru Animo Coffee Convenience 3 2 6 Applying the recipe strips 1 Open the machine door 2 Remove the screws and remove the cover A 3 Insert the recipe strip B 3 2 7 Applying the ingredient stickers 1 Open the machine door 2 Place the stickers as shown A amp 3 2 8 Setting the software for first use 1 Open the machine door 2 Press the configuration menu button A 2012 08 Rev 0 0 71 Animo Coffee Convenience Were Opt
4. du 78 5 1 Cleaning and disinfecting detergents 78 Ber PEE 78 6 Troubleshooting 6 1 Error messages 6 2 Display messages 6 3 Malfunctions EN 48 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience 1 Safety 1 1 Important information This user manual is intended to help you operate this machine safely and effectively This manual gives information about installation operation and maintenance of the equipment Make sure to read and understand the manual before use It is your responsibility to operate this machine in accordance with all the safety instructions and procedures in this manual and with all other safety procedures in your workplace It is the user s responsibility to make sure that the machine is correctly installed configured commissioned operated serviced and maintained and that such actions are only carried out by people who have been fully and properly trained for those tasks It is also the user s responsibility to make sure that the machine is only used in full accordance with laws and regulations which have the force of law in the jurisdiction in which the machine is installed WARNING AN Before attempting to use the machine read understand and know all the safety information
5. EN Animo Coffee Convenience www rp ru OptiFresh Bean Item Specification Operating mode with dispensing ECPL 105 Wh Litre Standby ESM 0 Wh Heat up from standby HU ESM 150 Wh 2 3 4 Capacities Coffee Item Specification Hour capacity per cup of 120 ml 125 cups Preparation time per cup of 120 ml 29 sec Preparation time per jug of 12 x 120 ml cups 6 min 2 3 5 Capacities Cocoa Item Specification Hour capacity per cup of 120 ml 300 cups Preparation time per cup of 120 ml 12 sec 2 3 6 Capacities Hot water Item Specification Hour capacity per cup of 120 ml 360 cups Preparation time per cup of 120 ml 8 sec 2 3 7 Ambient conditions Item Specification Temperature 0 lt lt 40 C Relative humidity 80 2 3 8 Type plate A Animo cottes and tesmakingsystems A Model number B Article number C Supply voltage V EN 62 2012 08 Rev 0 0 www rp ru OptiFresh Bean Animo Coffee Convenience D Machine number E Power W F Frequency Hz 2 4 Display 2 4 1 Main Screen A Product name area B Instruction Message area C Strength icon 2 4 2 Display icons Icon Name Description Rinsing The machine is rinsing The ma
6. WARNING AN Warning identifies a hazard that could lead to personal injury including death Caution Caution identifies a hazard that could lead to damage to the machine damage to other equipment and or environmental pollution Note Note is used to highlight additional information 1 3 Intended use The machine is an assembly to make coffee with coffee beans and hot drinks Any other or additional use will be considered to be not in conformity with the purpose The manufacturer cannot be held liable for any damages caused by use for any other purposes than what is described above or by incorrect operation WARNING Do not use products that do not comply with the applicable foodstuffs regulations Note This machine may only be used for commercial settings This is not a household appliance m A Modifications WARNING Do not attempt to make any modifications or alterations to the machine without the prior express agreement of Animo Unauthorised modifications or alterations to the machine could lead to serious personal injury including death WARNING Do not attempt to change remove or defeat the safety features WARNING Do not attempt to apply changes that violate local regional or national regulations WARNING Make sure the main switch and operating button are freely accessible PPP Animo is always willing to discuss improving the value of its machines to users by means of modifications or alter
7. Refer to 5 2 5 Change brewer filter The brewer filter needs to be replaced by a clean brewer filter Refer to 5 2 6 Service boiler The boiler needs service Contact the dealer or service engineer Service brewer The brewer needs service Contact the dealer or service engineer 6 3 Malfunctions Problem Possible cause Correction The machine does not work Broken fuse Check fuses The machine is switched off Switch on the machine Broken cable Check the power cable The machine does not reponse The machine is in standby Switch off the standy mode Bad product taste The canister is empty Fill the canister The canister is incorrectly posi tioned Position the canister correctly The outlet of the canister is blocked Clean the outlet of the canister 2012 08 Rev 0 0 89 EN Animo Coffee Convenience www rp ru OptiFresh Bean Problem Possible cause Correction The distributor of the canister Check the distributor of the can does not work ister or clean the canister Wrong ingredient Use the correct ingredient The ingredient is solidified Replace the ingredient caked The mixer is not cleaned Clean the mixer The ingredient has expired Replace the ingredient The boiler temperature is too low Contact the
8. Replace the outlet front 2012 08 Rev 0 0 85 EN Animo Coffee Convenience OptiFresh Bean 7 Take out the drink outlets C from the front piece of the outlet arm D 8 Remove the front piece from the outlet arm F 9 Clean the parts 10 Replace the outlet hoses EN 86 2012 08 Rev 0 0 OptiFresh Bean www rp ru Animo Coffee Convenience 6 Troubleshooting 6 1 Error messages Problem Possible cause Correction E1 Level error Sensor level problem Contact the dealer or service engineer E2 Level error Boiler is filling up too slowly There is no water pressure or the water tank is empty Check the water pressure Turn the water supply tap completely open Check the connection tube for any kinks Switch the machine off and on again E3 Level error Boiler is not filling up Check the water pressure Turn the water supply tap completely open Check the connection tube for any kinks Switch the machine off and on again E4 Brewer error Brewer has not started from its ini tial position Check whether the brewer is cor rectly placed into its bracket Switch the machine off and on E5 Brewer error Brewer has not returned to its initial position Check the brewer Switch the machine off and on E6 Boiler temp Temperature sensor pr
9. Convenience www rp ru 2 5 4 Switching times Screen Item Description 1 2 0 Mo Fri To set the on and off time from Mondays until Fridays hour min 00 00 not active There are switching times available 1 2 1 Sa To set the on and off time on Saturdays hour min 00 00 not active There are 3 switching times available 1 2 2 Su To set the on and off time on Sundays hour min 00 00 not active There are 3 switching times available 1 2 3 Energy safe mode To activate and set the energy safe mode active not active backlight on off OptiLight on off and boiler temperature in energy safe mode See 2 6 2 5 5 Recipe counters Screen Item Description 1 3 0 Recipe 1 12 To show the amount of free paid jug and total cups 0 99999 cups 1 3 1 Recipe total To show the total amount of free paid jug and total cups 0 99999 cups 1 3 2 Service counters To show the amount of rinsing of the brewer and mixer 0 99999 1 3 3 Reset counters If available to reset all counters 1 3 4 Save counters To save counters 2 5 6 Quick recipe Screen Item Description 1 4 0 11 Recipe recipe To set the volume strength of coffee cocoa topping and sugar per name gt recipe 2 5 7 Software Screen Description 1 6 Software To show the software version 2 5 8 PIN code Screen Description 1 7 PIN code To enter the service men
10. Make sure the brewer chamber is connected to its place Replace the coffee outlet E Close the machine door Press the confirm button The brewer chamber moves down 5 2 6 Replacing the filter Open the machine door 2 Press the Brewer open close button C from the control panel on the inside of the machine The brewer chamber moves up 3 Remove the brewer chamber D 4 Clean the surface of the brewer with the cleaning brush 5 Remove the coffee outlet E 6 Use the filter disassembly tool B to loosen the filter A 7 Remove the filter EN 80 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience 8 Replace a clean filter A 9 sure the filter is locked to its place B S WS 10 Make sure the wiper F is centered The wiper should be in between the two arms G 11 Replace the brewer chamber Make sure the brewer chamber is connected to its place 12 Replace the coffee outlet E 13 Press the Brewer open close button C from the control panel on the inside of the machine 14 Close the machine door 15 Press the confirm button The brewer chamber moves down 5 2 7 Cleaning Emptying the waste bin 1 2 NOOR W Open the machine door Lift the outlet See cleaning instructions sticker on the waste bin A Take out the waste bin
11. below 0 C Only use the supplied hose set 3 2 1 Package contents The machine is supplied with the following accessories e 1x coffee residue litter bin e 1x drip tray grid 2x door key e 2x bean canister key e 1x door pin e 2x jug lock key Recipe strips Ingredient stickers Strength strips e 1x user manual e 1x service manual e 1x connection hose 1x product registration card e x filter disassembly tool 1x coffee cleaner sachet e 1x extra permanent filter e 1x cleaning brush EN 68 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience 3 2 2 Positioning 1 Place the machine at work top on a firm flat surface 2 If available place the machine on base cabinet 3 Make sure that the area on the left of the machine is at least 11 cm to open the door 4 sure that the area above the machine is at least 22 cm to remove and or refill the canisters 5 Turn the feet A at the back of the machine to level the machine 3 2 3 Water connection 1 Connect the machine A to a tap B with air valve 2 Open the tap and check for leakage 3 If necessary connect the machine with the hose B to the filter system C and connect the filter system with the hose D to a tap 2012 08 Rev 0 0 69 EN Animo Coffee Convenience OptiFresh Bean
12. Animo Coffee Convenience OptiFresh Bean gebruiksaanwijzing betriebsanleitung user manual mode d emploi www rp ru Copyright 2012 Animo No part of this document may be reproduced and or made public in print microfilm electronic media or any other form without the manufacturer s prior consent This also applies to the corresponding diagrams and or charts Animo retains the right to alter parts at any given time without prior or immediate announcement to the consumer The content of this manual can also be changed without any prior warning This manual is valid for the standard model of the device Animo can therefore not be held liable for possible damage resulting from specifications deviating from the standard model for the device supplied to you This manual was created with the utmost care but the manufacturer cannot be held responsible for any mistakes in this document or their consequences This manual was originally written in English All other languages in this document are a translation of the English source text EN 47 2012 08 Rev 0 0 Animo Coffee Convenience OptiFresh Bean TABLE OF CONTENTS Copyright 47 1 Safety eniin 49 1 1 Important information 49 1 2 Warning signs 49 1 3 Intended use 50 1 4 Modifications
13. Clean Empty the waste bin Replace the waste bin Lower the outlet Close the machine door 5 2 8 Cleaning the exterior and interior 1 Clean the exterior and interior with a damp cloth 2012 08 Rev 0 0 81 EN Animo Coffee Convenience OptiFresh Bean 5 2 9 Cleaning Emptying the drip trays Remove the drip trays A under the machine If required remove the drip tray hose Clean the drip trays Replace the drip tray hose Replace the drip trays 5 2 10 Cleaning the mixer Turn the canister s outlet upwards Remove the outlet hose from the mixer Turn the green mounting ring C counterclockwise Take off the mixer housing B Pull off the mixer fan A Remove the mounting ring Clean the parts 9 Remove the dust tray 10 Clean and dry the dust tray 11 Replace the dust tray Turn the green mounting ring C further counterclockwise EN 82 2012 08 Rev 0 0 OptiFresh Bean www rp ru Animo Coffee Convenience 12 13 14 15 16 Replace the mounting ring and turn it clockwise to lock the ring into place Replace the mixer fan Make sure that the mixer fan locks into place The mixer fan must not touch the green mounting ring Replace the mixer housing Turn the green mounting ring clockwise to
14. ations Refer to Further help and information EN 50 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience 1 5 Safety devices 1 5 1 Door switch The door switch A automatically switches off the machine when the door is opened 1 5 2 Temperature safety device The temperature safety device turns off the heating element if the temperature is too high It prevents the machine from boiling dry The temperature safety device can be operated manually 1 Remove the cap B 2 Press the reset button A 2012 08 Rev 0 0 51 EN Animo Coffee Convenience WENT OptiFresh Bean 1 5 3 On Off switch The on off switch A puts the machine in the on off position The machine can still be charged after the machine is switched off Unplug the machine to make sure that the machine is entirely uncharged WARNING The main power switch does not switch off all internal parts Always disconnect the machine from the electricity before opening it 1 5 4 Cancel button A The cancel button A cancels the selected recipe EN 52 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience 1 5 5 Display A The display shows technical malfunction with error codes The display also provides addit
15. chine must be rinsed Waste Bin Missing The waste bin is missing Waste Bin Full The waste bin is full Boiler Heating i The boiler is heating up Boiler Filling The boiler is filling up Door Open The door of the machine is open 2012 08 Rev 0 0 63 EN Animo Coffee Convenience TENET OptiFresh Bean Icon Name Description Drip Tray Full The drip tray is full Error The machine generated an error Standby The machine is on standby Cleaning The machine must be cleaned Replace brewer filter The brewer filter must be replaced 2 5 Configuration menu 2 5 1 Main menu Screen Title Level See 0 Main Operator 2 4 1 1 0 Free dispensing Operator 2 5 2 1 1 Clock Operator 2 5 3 1 2 Switching times Operator 2 5 4 1 3 Recipe counters Operator 2 5 5 1 4 Quick recipe Operator 2 5 6 1 6 Software Operator 2 5 7 1 7 PIN code Service 2 5 8 1 8 OptiLight Operator 2 5 9 1 9 Contrast Operator 2 5 10 2 5 2 Free dispensing Screen Item Description 1 0 Free dispensing To activate free dispensing on machines with a payment system yes no 2 5 3 Time Screen Description 1 1 0 Time To set the time hour min 1 1 1 Date To set the date dd mm yyyy EN 64 2012 08 Rev 0 0 OptiFresh Bean Animo Coffee
16. d operators of its products Contact the dealer for information regarding settings maintenance and repair work which is not included in this document 2012 08 Rev 0 0 55 EN Animo POET Coffee Convenience OptiFresh Bean 2 Description 2 1 Overview 2 1 1 Front Bean canister Control panel Outlet Tray Drip tray Water outlet Door lock OptiLight rommoomm 2 56 2012 08 Rev 0 0 OptiFresh Bean www rp ru Animo Coffee Convenience 2 1 2 Back Fan Water connection Power cord Temperature safety device 2012 08 Rev 0 0 57 EN OptiFresh Bean www rp ru An Coffee Convenience Inside 2 1 3 A Grinder B Canisters C Mixer D On off switch E Brewer F Waste bin G Outlet H Control panel Cleaning instructions stickers 2012 08 Rev 0 0 58 EN Animo OptiFresh Bean Coffee Convenience 2 2 Working principle 2 2 1 Canisters The canisters contain the coffee beans A and instant products B 2 2 2 Grinder 4 The grinder A grinds the coffee beans and transfers the product to
17. dealer or service engineer The ingredient is damp Check the ventilation system and replace the ingredient EN 90 2012 08 Rev 0 0 POET Animo OptiFresh Bean Coffee Convenience 2012 08 Rev 0 0 92 EN Animo POET Coffee Convenience OptiFresh Bean EN 92 2012 08 Rev 0 0 Animo Coffee Convenience 125424 88 8 74955404600
18. e are to be maintained within the process area Caution As an operator you should have received training in personal and food hygiene from your employer s If you have not do not use the machine or enter the process area Arrange training with your supervisor or training manager Working in the process area without a good understanding of hygiene can lead to contamination of drinks Wash your hands thoroughly before entering the process area Remove your watch and any loose jewellery before entering the process area Make sure that the machine is cleaned regularly EN 54 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience 1 8 Directives This machine meets the following EC directives directive 2004 108 EC Low voltage directive 2006 95 EC Machinery directive 2006 42 EC RoHS directive 2002 95 EC X WEEE directive 2002 96 EC Food contact directive 1935 2004 EC 1 9 Guarantee The guarantee provisions that apply to this machine are part of the general terms of delivery 1 10 Disposal The use and maintenance of the machine includes no environmental dangers Most parts can be disposed in the regular way ET Note Ensure compliance with local legislation regulations instructions and precautions concerning health safety and environment 1 11 Further help and information Animo is committed to provide the highest level of support to users an
19. ection buttons Cancel button Navigation buttons Confirm button Jug lock Recipe dispensing button Water dispensing button Dispensing LED Stop button rTommoomuusr 2012 08 Rev 0 0 73 EN Animo Coffee Convenience OptiFresh Bean 4 2 Overview control panel inside A Standby button B Configuration menu button C Cleaning button D Rinsing button E Brewer open close button 4 3 Opening the door 1 Place the key in the door lock A 2 Turn the key and open the machine door EN 74 2012 08 Rev 0 0 OptiFresh Bean www rp ru Animo Coffee Convenience 4 4 Switching on and off 1 Open the machine door 2 Press the on off switch A to switch the machine on or off 4 5 Start dispensing cups Place a cup on the tray 2 Press a recipe or press the hot water button The dispensing LED starts to flash 3 If required press the strength button to set the strength of the coffee milk and chocolate 4 Press the start dispensing button 4 6 Start dispensing jugs Place the key into the jug lock Turn the key to activate the jug mode Turn away the tray Place a jug on the drip tray Press a recipe or press the hot water button If required press the strength button to set the amount of cups for 1 jug 7 Press the start dispensing button 0
20. iFresh Bean www rp ru Animo Coffee Convenience 6 2 Display messages Problem Possible cause Correction Out of order boiler filling When used for the first time boiler is still empty boiler is being filled No action required Out of order boiler filling Boiler is not filling up or is filling up too slowly After 60 seconds the dis play will show E3 Level error Check the water pressure Turn the water supply tap completely open Check the connection tube for any kinks Switch the machine off and on again Out of order boiler heating The boiler temperature is too low because too much water is used Wait until the boiler temperature has reached the correct level Out of order drip tray full Drip tray is full Empty the drip trays Out of order waste bin full Waste bin full Empty the waste bin Out of order waste bin is missing Waste bin is missing Check the waste bin Out of order door open The door is open Close the door or use the door pin Out of order stand by The machine is on standby Remove the standby mode in the configuration menu Close door The door is not closed correctly Close the door Rinse The rinsing program has not been Carry out the rinsing program carried out Refer to 5 2 4 Clean The cleaning program has not been Carry out the cleaning program carried out
21. iFresh Bean 3 Use the recipe buttons B to navigate through the menu 4 Select clock to set the time and date C gt x 5 Select switching time energy save mode to set the mode 6 Select OptiLight to set the colour setting 3 3 2 9 Using the machine for the first time Plug the machine into earthed socket Switch on the machine and follow the instructions on the display Place a bowl min 1 5 I under the outlet Select a recipe and press the start dispensing button Check whether the taste and quantity is as desired Repeat the previous steps for every recipe to ensure all recipes are as desired If the taste or quantity is not as desired inform your dealer EN 72 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience 4 Operation WARNING AN Inspect the machine for damage before use Do not submerge or hose down the machine not use sharp objects to operate the buttons Keep the operating controls free of dirt Unplug the machine and unplug the water supply when the machine is not used for a longer period of time Note The energy safe mode is activated by default Only use the following products Coffee beans Instant products e Sugar suitable for vending machines 4 1 Overview control panel Display Strength buttons Recipe sel
22. in this chapter Pay particular attention to all warnings and cautions throughout this manual If you do not follow all the warnings and procedures in this manual this could lead to serious injury to yourself or others including death WARNING If there is any safety instruction or procedure that you do not understand do not use the machine Contact your supervisor and arrange proper training on the use of the machine Use of the machine without understanding and following all the safety instructions and procedures in this manual could lead to serious injury to yourself or others including death WARNING AN Do not use the machine until you have received adequate and proper training in its safe and effective use If you are unsure of your ability to use the machine safely and effectively do not do so Never attempt to remove modify over ride or frustrate any safety device on the machine Interfering with safety devices could lead to fatal or other serious personal injury 1 2 Warning signs Safety signs are attached to the machine to give safety information safety signs are repeated and usually further explained in this manual 1 2 1 Classification of safety signs Safety signs are of the internationally accepted types and described below WARNING AN Warning sign that identifies a hazard 2012 08 Rev 0 0 49 EN Animo Coffee Convenience WEN OptiFresh Bean 1 2 2 Warning caution and note
23. ine will be in energy safe mode after 30 min The temperature of the boiler drops every 30 min with 5 C If there is dispensing after 2 hours the machine is reactivated The machine uses less energy if there is no dispensing or is left switched on EN 66 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience Energy safe mode with three set switching times Energy safe mode without switching times If the machine is switched on and there is no dispensing the machine will be in energy safe mode after 30 min The temperature of the boiler drops every 30 min with 5 If there is dispensing after 2 hours the machine is reactivated The machine uses less energy if there is no dispensing or is left switched 2012 08 Rev 0 0 67 EN Animo Coffee Convenience WENT OptiFresh Bean 3 Transport amp Installation 3 1 Transport 3 1 1 General When the machine and its additional equipment is delivered e Check the machine for possible transport damage Make sure the delivery is complete Refer to the sales and delivery conditions 3 2 Installation Caution Use a filter system with a water softener if the tap water has been chlorinated or is too hard This increases the quality of the drink and will ensure that you do not have to descale the machine too often Do not place the machine in an area with temperatures
24. ional user information or warnings 1 6 Safety precautions 1 6 1 General safety precautions Make sure that the environment around the machine is dry clean and lit sufficiently well Keep away from moving parts Use Animo replacement parts only Use Animo recommended products only 1 6 2 During installation Place the machine at work top height on a firm and flat surface Plug the machine into a safety grounded power outlet Make sure the machine does not leak Do not place the machine in an area with temperatures below 0 e Observe local regulations and use approved materials and parts e Check if the details on the type plate correspond to the country 1 6 3 During normal operation Inspect the machine for damage before use Do not tilt the machine Do not submerge or hose down the machine Do not use sharp objects to operate the machine Keep the operating controls free of dirt and grease Switch off the machine and unplug the water supply when the machine is not used for a longer period of time 1 6 4 During maintenance and repair Perform regular maintenance on the machine Wear protective gloves when performing maintenance Do not leave the machine during maintenance 2012 08 Rev 0 0 53 EN Animo Coffee Convenience OptiFresh Bean sure that the repairs are performed by trained and authorised personnel only Unplug
25. ispensing LED starts to flash if sufficient money is inserted Press the strength button to set the strength Press the start dispensing button 4 11 Using the coin changer optional Place a cup on the tray 2 Press recipe or press the hot water button 3 Insert the correct amount of money The dispensing LED A starts to flash if sufficient money is inserted 4 Press the strength button to set the strength 5 Press the start dispensing button 6 If required remove the change from the machine B a 2012 08 Rev 0 0 77 EN Animo Coffee Convenience OptiFresh Bean 5 Maintenance 5 1 Cleaning and disinfecting detergents WARNING AN Do not use other chemicals unless it is approved by Animo not put the machine parts in a dishwasher except for the instant canister Dry the canister thoroughly before replacing it Purpose Product Remarks Mixer cleaning Coffee cleaner sachets Brewer cleaning art no 49009 5 2 Cleaning 5 2 1 Daily cleaning Machine part Dishwasher proof See Brewer No 5 2 4 Mixer No 5 2 4 Waste bin No 5 2 7 Drip tray No 5 2 9 5 2 2 Weekly cleaning Machine part Dishwasher proof See Brewer No 5 2 5 Mixer No 5 2 10 Outlet No 5 2 13 Exterior amp Interior No 5 2 8 5 2 3 Monthly c
26. leaning Machine part Dishwasher proof See Bean canister No 5 2 11 Instant canister Yes 5 2 12 Brewer filter No 5 2 6 EN 78 2012 08 Rev 0 0 OptiFresh Bean www rp ru Animo Coffee Convenience 5 2 4 Using the rinsing program 1 2 Open the machine door Press the rinsing button A from the control panel on the inside of the machine Close the machine door Place a bowl min 1 5 1 under the outlet Follow the instructions on the display 5 2 5 Using the cleaning program 1 2 3 Open the machine door Put the cleaning product A in the brewer chamber Press the cleaning button B from the control panel on the inside of the machine Close the machine door Place bowl min 1 5 1 under the outlets Follow the instructions on the display Note The cleaning program is in progress and will rinse the brewer in three cycles At the end of the cycle the brewer chamber moves up 7 Open the machine door 8 Remove and clean the brewer chamber D 9 Clean the surface of the brewer with the cleaning brush 2012 08 Rev 0 0 79 EN Animo Coffee Convenience www rp ru OptiFresh Bean 10 11 12 18 14 15 Remove and clean the coffee outlet E Make sure the wiper F is centered The wiper should be in between the two arms G Replace the brewer chamber
27. lock the mixer into place Replace the outlet hose 5 2 11 Cleaning the bean canister 1 2 3 4 5 Close the supply A to the grinder Take out the bean canister B Remove the cover C Clean and dry the canister Clean the grinder A with the brush 2012 08 Rev 0 0 83 EN Animo Coffee Convenience OptiFresh Bean 6 Replace the bean canister B 7 Replace the cover C 8 Open the supply A to the grinder 5 2 12 Cleaning the instant canisters 1 Open the machine door 2 Turn the canister s outlet upwards 3 Liftthe canister from the socket and pull it out B 4 Remove the cover EN 84 2012 08 Rev 0 0 Animo OptiFresh Bean Coffee Convenience Clean the instant canister and its parts Dry the parts thoroughly Replace the cover Replace the canister into the socket Make sure the canister locks into place with the pin D in the hole 10 Turn the canister s outlet A downwards 11 Close the machine door 5 2 13 Cleaning the outlets 1 Open the machine door 2 Remove the outlet front A while holding the tab at the back of the front Take out the outlet housing B Clean the outlet housing Replace the outlet housing
28. oblem Contact the dealer or service engineer E7 BM error Brewer motor overload stuck The brewer is stuck or fitted incor rectly Remove the brewer from the machine clean and install the brewer correctly Switch the machine off and on again E8 Mixer 2 error Mixer 2 overload stuck Mixer 2 is unclean or incorrectly fit ted The control switched off the outlets Remove the mixer from the machine clean and install the mixer correctly Check whether the rotor can run freely Switch the machine off and on again E9 Mixer 3 error Mixer 3 overload stuck Mixer 3 is unclean or incorrectly fit ted The control switched off the outlets Remove the mixer from the machine clean and install the mixer correctly Check whether the rotor can run freely Switch the machine off and on again E10 Valve error Valve or ventilator overload stuck Valve or ventilator outlet overload The control switched off the outlet Contact the dealer or service engineer 2012 08 Rev 0 0 87 EN Animo Coffee Convenience www rp ru OptiFresh Bean Problem Possible cause Correction E11 Ingr m error Ingredient motor overload stuck Clean the canisters Refer to Ingredient motor outlet overload 5 2 12 The prime mover of one of the out Switch the machine off and on lets is not running smoothly again E12 Fan error Fan overload
29. stuck Contact the dealer or service The control switched off the outlets engineer E13 Mixer group error Brewer and mixer group overload The control switched off the outlets Clean the mixer rotor Check whether the rotor can run The prime mover of one of the out lets is not running smoothly The control switched off the outlets freely Switch the machine off and on again E14 Exit error Ingredient motor group over Clean the canisters Refer to load stuck 5 2 12 Switch the machine off and on again Valve outlet group or fan overload Contact the dealer or service The control switched off the outlets engineer E16 Level error Boiler level suddenly much too low Contact the dealer or service engineer E17 MDB error There is no communication Switch the machine off and on between the machine and MDB again payment system Contact the dealer or service engineer E18 Mixer FET error Brewer or mixer motor output still Contact the dealer or service active engineer E19 Output FET error Ingredient motor valve or ventila Switch the machine off and on tion motor still active again Contact the dealer or service engineer E20 Software error Software error Switch the machine off and on again Contact the dealer or serv ice engineer E21 Boiler timeout Boiler is not heating Contact the dealer or service engineer EN 88 2012 08 Rev 0 0 Opt
30. the brewer 2012 08 Rev 0 0 59 EN Animo Coffee Convenience WENT OptiFresh Bean 2 2 3 Brewer The brewer A receives the product from the grinder The product is made by vacuuming hot water through the filter The brewer piston transfers the product to the outlet A wiper transfers the residue to the waste bin 2 2 4 Mixer The mixer A mixes the instant products with hot water and transfers the product to the outlet EN 60 2012 08 Rev 0 0 OptiFresh Bean www rp ru Animo Coffee Convenience 2 2 5 Outlet The outlet A transfers the product into the cup or jug 2 3 Specifications 2 3 1 Standard machine Item Specification Machine dimensions 402 x 570 x 860 mm Weight empty full 35 45 kg Pressure 2 10 bar Water inlet temperature 5 60 C Water hardness gt 5 dH Boiler volume 3l Boiler heating time 7 5 min Boiler temperature 95 Acoustic pressure 70 dB A 2 3 2 Electrical system Item Specification Voltage 220 240 V Frequency 50 60 Hz Power 2500 W Heating element power 2200 W Fuse 10A 2 3 3 Power consumption according to EVA EPM standard Item Specification Reaching operating temperature HU 244 Wh Operating mode without dispensing IM 70 Wh Litre 2012 08 Rev 0 0 61
31. the machine to perform maintenance regarding error messages WARNING AN To entirely uncharge the machine unplug the machine 1 6 5 Replacement instructions If the supply cord is damaged it must be replaced by the manufacturer its service agent or similarly qualified persons in order to avoid a hazard Always use the new hose set supplied with the machine Old hose sets or other hose sets should not be used WARNING AN To entirely uncharge the machine unplug the machine 1 7 Users 1 7 1 Personnel qualifications e The machine is designed only for personnel being 14 years or older Consider the respective national regulations for occupational safety and health machine must not be used by children or persons with reduced physical sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision Only personnel who have been given permission are allowed to work with the machine All personnel must only carry out the work they have been trained to perform This applies to both maintenance work and the normal machine operation All personnel working with the machine must have free access to the applicable manuals The operators must be familiar with all situations that may occur so that they can act rapidly and effectively in the event of emergencies 1 7 2 Personal and food hygiene The machine processes drinks for human consumption So the highest standards of hygien
32. us 2 5 9 OptiLight Screen Item Description 1 8 0 Red To set the amount of red in the colour 0 100 1 8 1 Green To set the amount of green in the colour 0 100 1 8 2 Blue To set the amount of blue in the colour 0 100 1 The quick recipe menu is only available if it has been activated by the service engineer 2 Forservice personnel only 2012 08 Rev 0 0 65 EN Animo Coffee Convenience WEEDS OptiFresh Bean Screen Description 1 8 3 Random To show all colours of the complete colour spectrum 0 60 min 0 not active 2 5 10 Contrast Screen Item Description 1 9 Contrast To set the contrast of the display 0 100 2 6 Energy safe mode The machine in energy safe mode uses less energy The recipe buttons are still active and the boiler cools down in steps of 5 After choosing a recipe the machine needs some time to heat up the boiler Example Three set switching times 1 2 3 9 00 11 00 12 00 13 00 14 00 15 00 The machine switches on at 9 00 12 00 14 00 automatically The machine is on standby at 11 00 13 00 15 00 During standby mode the control panel is switched off and the boiler temperature drops to the set boiler temperature 1 2 3 9 00 11 00 12 00 13 00 14 00 15 00 If the machine is switched on after being on standby and there is no dispensing the mach
Download Pdf Manuals
Related Search