USER MANUAL - LifeTec Inc.
Contents
1. Huntleigh A K R O N AKRON M6M Model 8462 USER MANUAL AKRON 8462 Contents 1 10 Introduction Warnings Cautions General Warnings Installation Operation Accessories Operating Instructions Cyriax Horns Hole amp Horn Lean Back Frame Fixation Rails Cleaning and Decontamination Troubleshooting Maintenance Warranty and Service Revision Status Technical Specification C The C mark on this product demonstrates conformity with the EC Directive 93 42 EEC NO ON UN da III aq 10 11 11 12 AKRON 8462 1 Introduction Always keep this Operating Manual available for reference Warnings amp Cautions WARNINGS Warnings identify possible hazards in procedures or conditions which if not correctly followed could result in death injury or other serious adverse reactions CAUTIONS Cautions identify conditions or procedures which if not correctly followed could result in equipment failure or damage General Warnings WARNINGS Use only accessories that have been designed or approved for use with this couch Do not use electric couches in the presence of flammable gasses such as an anaesthetic agent Maximum Load 180 396 Ibs distributed evenly Do not concentrate weight on either side of the couch Plug acts as a disconnect device Do not allow children to play with the couch at any time Adequately supervise children in the proximity of the2. Press out from underneath AKRON 8462 4 Accessories Operating Instructions Cyriax Horns Fixation Rails Adjust Cyriax Horns to suit patient by A Unlocking the locking knobs B Adjust position of horns C Tighten locking knobs To fit Horn into Hole A simply locate horn into hole B Ensure horn is fully inserted prior to use To adjust Lean Back Frame A Remove locating pins from frame B Slide frame to required position C Replace pins into holes at the end of the frame Ensure straps are correctly located through fixation rails before use AKRON 8462 5 Cleaning and Decontamination WARNING Do not use Alkalis or other organic solvents for routine cleaning Replace torn or damaged vinyl immediately Always cover vinyl with fresh paper or sheet between patients If contamination is known or suspected always decontaminate couch before use Frequency of routine couch cleaning will depend on exact application CLEANING DECONTAMINATION Wear suitable protective clothing Disconnect mains supply Locate couch in a suitable cleaning area with castors disengaged or wheels locked A Using a clean damp cloth warm water and soap carefully wipe couch from top to bottom taking care around electrical components B Wipe couch carefully from top to bottom using a damp cloth and clean water C Wipe couch carefully dry with clean paper towels from top to bottom If DECONTAMINATING
3. couch AKRON 8462 2 Installation Adjustable Foot WARNING Lock castors before adjusting A Lock castors first B Adjust foot C Lock foot by tightening half nut WARNING Do not insert the 2 pin mains connector directly into a 3 pin 13A mains outlet Always use the adapter provided Plug acts as a disconnect device Electric Models Use adapter if 3 pin 13A plug is required Order reference 5504097 Ensure mains supply cable is not stretched when connected Ensure during couch use no obstacles are in its path Ensure hand foot switch tubes or leads are not trapped by moving parts of the couch CAUTION When not in use switch couch off AKRON 8462 3 Operation Elevation Controls WARNING Safely position patient before elevating couch Position all electrical cables away from the moving parts Position Hand Foot switch where accidental operation is not possible Electric Models Press to raise couch Press Y to lower couch Handswitch AUF Press to raise couch AB Press to lower couch Footswitch Foot Bar Switch Press tube done to raise couch Lift tube up to lower couch AKRON 8462 3 Operation Wheel Locking WARNING Lock couch wheels castors prior to patient transfer or treatment The retractable castors are not designed for transportation of patients Disconnect and coil electrical cord away from moving parts prior to repositio
4. then repeat steps a to c using a dilute Hypochlorite warm water mixture 10 000ppm instead of warm water and soap Safely discard cleaning decontaminating materials Wash hands thoroughly Put couch back into service 6 Troubleshooting Electric Actuator Symptom Actuator will not work Power disconnected Ensure mains supply is connected Fuse blown Replace fuse in socket Hand footswitch Check that the hand foot switch is fully disconnected inserted into the actuator Actuator runs when Bar Out of balance system Vent air tube by disconnecting from is not pressed actuator then reconnect Foot Bar Switch If the problem persists consult your local Akron Supplier AKRON 8462 7 Maintenance Check couch visually before use Carry out routine servicing every six months or more frequently if in heavy use Routine servicing or repair must only be performed by suitably qualified person WARNING Before commencing any maintenance activity disconnect the couch from the electrical supply Plug acts as disconnect device Examine the couch for any signs of damage Make sure that all nuts bolts and other fasteners are tight Do not over tighten as this may cause binding Upholstery fasteners should be checked tightened or replaced if necessary Check section hinge pins to ensure that no pin protrudes Check gas strut controls throughout the full range of movement for locking and assistance Check hydraulic c
5. he decontamination certificate or other written statement declaring that the product has been cleaned to the outside of the package 4 Mark the package Service Department Manufactured in the UK by Huntleigh Akron As part of the ongoing development programme this company reserves the right to modify specifications and materials of this couch without notice 10 AKRON 8462 8 Warranty and Service UK only Huntleigh Akron s standard terms and conditions apply to this couch A copy is available upon request These contain full details of warranty terms and do not limit the statutory rights of the consumer For service maintenance and any questions regarding this or any other Huntleigh Akron Product please contact Huntleigh Akron I Farthing Road Ipswich Sutfolk IP SAP England Telephone 44 0 1473 461042 Fax 44 0 1473 462924 Huntleigh Akron T A a Division of Huntleigh Nesbit Evans Limited A Member of the Huntleigh Technology PLC Group of Companies O Huntleigh Technology PLC 2001 If for any reason your couch is being returned please inform Huntleigh Akron prior to sending and l 3 4 Clean the product as described in the cleaning section Pack it 1n suitable packing Attach the decontamination certificate or other written statement declaring that the product has been cleaned to the outside of the package Mark the package Service Department Manufactured in the UK by Huntleigh Ak
6. ning couch Castors Castors Unlocked Castors Locked Head amp Foot Sections CAUTION Support upholstery section while manually altering the angle Head Section Operating Lever A Press lever UP to alter section angle B Support section when altering angle C Release lever to lock section in position A Tilt armrest towards head section B Move armrest into position C Release armrest to lock into position AKRON 8462 3 Operation Foot Section CAUTION The foot section 1s able to move in two independent modes It is recommended that Operators familiarise themselves with the functions of each mode prior to using the couch with a patient Flexion amp Extension To adjust the foot section for flexion amp extension A Rotate the lever positioned under the foot section clockwise or anti clockwise B Raise or lower section to desired angle C To secure foot section at correct angle continue to rotate the lever Foot Section Angles 4 26 25 Foot Section Operating Lever Side Bending To release the foot section to enable side bending A Rotate the lever under the mid section upholstery anti clockwise B Rotate the foot section to desired position C Rotate the lever clockwise to secure foot section in desired position Angles 30 35 along the horizontal axis Side Bending Release Lever Breathing Hole and Plug Remove plug for patient prone position
7. ouches for smooth operation and signs of leakage WARNING All electrical checks should be performed by a suitably qualified and licensed electrician Neither BLUE or BROWN wires are to be connected to the earth terminal of a three pin plug Examine the flexible cables for cuts abrasions kinking or other deterioration and replace if necessary Ensure that the power supply connector plug 1s securely attached Check mains plug connections are tight and fuse is correctly rated SA AKRON 8462 8 Warranty and Service UK only Huntleigh Akron s standard terms and conditions apply to this couch A copy 1s available upon request These contain full details of warranty terms and do not limit the statutory rights of the consumer For service or maintenance please contact Service Department Huntleigh Healthcare 310 312 Dallow Road Luton Beds Telephone 01582 745700 LUI 1TD Fax 01582 745869 For information on this product or any other Huntleigh Akron product please contact Huntleigh Akron Farthing Road Ipswich Telephone 01473 461042 IP SAP Fax 01473 462924 Huntleigh Akron T A a Division of Huntleigh Nesbit Evans Limited A Member of the Huntleigh Technology PLC Group of Companies O Huntleigh Technology PLC 2001 If for any reason your couch is being returned please inform Huntleigh Akron prior to sending and l Clean the product as described in the cleaning section Pack it in suitable packing 3 Attach t
8. ron As part of the ongoing development programme this company reserves the right to modify specifications and materials of this couch without notice 9 Revision Status 8462 PAGES ISSUE WRITTEN DATE ALL PAGES UM 01 08 06 98 ALL PAGES UM 02 02 12 98 PAGES 10 amp 11 UM 03 18 11 99 PAGE 2 UM 04 DCN958 30 10 00 11 AKRON 8462 10 Technical Specification Akron M6M Le Head length cm Mid Length cm Foot Length cm Width cm Overall Length cm Height Range cm 62 1 5 109 1 5 Max Load Weight Elevation Control AA Electrical Data 230v Actuator Internal Fuse Rt Current Power Mains Plug Fuse Rt UK ee WW Actuator Internal Fuse Rt F4 0A x 1 Current Power 380W IEC 601 1 Classification Check serial number label for classification 230v 115y 115y E Double Insulated E Double Insulated Class 1 Type B equipment Type B equipment 2 Type B equipment 2 Attention consult this Attention consult this Attention consult this manual manual manual 12 pum w Huntleigh A K RON Huntleigh Akron 1 Farthing Road Ipswich Suffolk IP1 SAP England Tel 44 0 1473 461042 Fax 44 0 1473 462924 792 187 04
Download Pdf Manuals
Related Search