Flame Grill Manual
Contents
1. LAG 010 CKG OPTIONAL FLAME GRILL WARNING If the information in this manual is not followed exactly a fire or explosion may result causing property damage personal injury or death Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance Do not touch any electrical switch Do not use any phone in your building Immediately call your gas supplier from a neighbor s phone Follow the gas supplier s instructions If you cannot reach your gas supplier call the fire department Installation and service must be performed by a qualified installer service agency or the gas supplier WARNING THIS RANGE CAN TIP INJURY TO PERSONS COULD RESULT INSTALL ANTI TIP DEVICE PACKED WITH RANGE SEE INSTALLATION INSTRUCTIONS Page 1 of 20 LAG0I0CKG US Page 2 of 20 LAGOLOCKG US GENERAL MANUAL LAG 010 CKG SPECIFICATIONS Lavout Built in cooktop option flame grill left or right of central hob depending on model Description A 12 500 BTU hr gas burner a gas valve with thermocouple safety is located under the fire tray An optional bed of lava rock rests on a rack which rests on the bottom of the fire tray A 275 x 460 mm grill resting on pillars is located above the fire tray Electronic spark ignition Pressures and hourly consumption ie re 0 Accessories C2. age 16 of 20 LAGO1OCKG US USER S MANUAL LAG 010 CKG SAFETY INSTRUCTIONS gt If the range is to be installed on an area covered with linoleum or any other floor covering make sure that the floor covering can withstand 90 F 65 C above room temperature without warping shrinking or discoloring Do not install the range over carpeting gt Never store anything in the oven or the cooktop Flammable materials can catch fire plastic items may melt or ignite and other types of items could be ruined This appliance is for cooking Based on safety considerations never use the oven or cooktop to warm or heat a room Doing so may result in carbon monoxide poisoning and overheating of the oven Also such use can damage the cooktop or oven parts gt Never cover any slots holes or passages in the oven bottom or cover an entire rack with materials such as aluminium foil Doing so blocks air flow through the oven and may cause carbon monoxide poisoning Aluminium foil linings may also trap heat causing a fire hazard gt Do not obstruct the flow of combustion or ventilation air to the appliance Be sure a fresh air supply is available gt When using the cooktop do not touch the burner grates or the immediate surrounding area Areas adjacent to the burners may become hot enough to cause burns gt Do not hang articles from any part of the appliance or place anything against the oven Some fabrics are quite flammable and m
3. ay catch on fire gt However children should not be left alone in the kitchen while the range is in use Do not store items of interest to children over the unit Children climbing to reach items could be seriously injured gt Do not use aluminum foil to line any part of the oven or cooktop gt When using the oven do not touch the interior surfaces of the oven the exterior area immediately surrounding the door or the backtrim gt Disconnect from power supply before servicing Page 17 of 20 LAG010CKG US USER S MANUAL LAG 010 CKG USE OF OPTIONAL LAVA ROCK GRILL Before use it is mandatory to remove all the internal and external plastic packing pieces failure to do so will cause irreversible damage to the steel walls Remove the cooking grill and cover only the stone rack in the tray with the 3 kg of lava rock supplied Initial usage will cause some smoke and is no cause for alarm Caution potential users that temperatures may exceed 300 C After any use close the valve to stop gas flow Using the burner Push and turn the burner control knob anticlockwise as far as the IGN symbol Depression of the control knob will activate the spark ignition You should hear the burner flame ignite After the flame ignites keep the control knob pushed in for roughly 20 seconds in order to activate the thermocouple safety device A reduced flow rate position identified by the LOW mark produces the prese
4. de 50 mm relative to the adjacent units cabinets Must be installed under an exhaust hood Do not install this unit near combustible walls partitions pieces of furniture or decorative material unless these are covered with adequate thermal insulation of the noncombustible type Making sure the resulting installation meets local fire regulations A shut off valve must be installed and accessible close to the appliance in order to isolate it from the supply or to facilitate cutting the gas supply Page 8 of 20 LAGO10CKG US INSTALLER S MANUAL LAG 010 CKG Changing Injector Nozzle Replace the injector C Lacanche ranges are supplied with the gas fittings requested when the order is placed The settings must be fine tuned when the range 1s installed IMPORTANT Close the main gas valve before carrying out any work GAS Pressure IMPORTANT In case of use with a gas other than that for which the appliance was initially set up it is crucial to replace the injectors and modify the adjustments as defined below Adjusting the primary air of hob burners Loosen the screw D that secures the air ring Adjust the air ring Opening in mm inches GAS Pressure Oven L P propane 10 WC Air Adjustment Page 9 of 20 LAGO10CKG US INSTALLER S MANUAL LAG 010 CKG a gt Adjusting reduced flow of hob burners After connection or change of gas it 1s crucial to modify th
5. gt ALL WORK ON OR REPAIR OF AN APPLIANCE MUST BE CARRIED OUT BY A QUALIFIED INSTALLER OR REPAIR TECHNICIAN THE APPLIANCE WHEN INSTALLED MUST BE ELECTRICALLY GROUNDED IN ACCORDANCE WITH THE LOCAL CODES OR The National Electrical Code ANSIYNFPA 70 1996 or latest edition REPAIRS All work on or repair of an appliance must be carried out by a qualified installer or repair technician Refer to data sheet of basic appliance Page 12 of 20 LAGO10CKG US INSTALLER S MANUAL LAG 010 CKG GAS CIRCUIT DIAGRAM 65 062070 65 080012 65 51764 4 screws 65 129101 4 washers 65 30932 GAS CIRCUIT DIAGRAM Oven Burner Diffuser 65 062070 Injector Holder 65 51764 2 5mm Set Screw 65 51085 Oven Burner Body 65 062011 Page 13 of 20 LAG010CKG US INSTALLER S MANUAL LAG 010 CKG Page 14 of 20 LAGO10CKG US 4 LA CAN CHE LAG 010 CKG USER S MANUAL IMPORTANT Provide adequate air supply during use of the appliance Provide adequate clearances for servicing and proper operation by not obstructing front or side of appliances WARRANTY The warranty is stated on the sales contract Please contact your approved Dealer if any work has to be carried out under warranty This warranty excludes damage resulting from incorrect installation improper use or inadequate servicing A ACANCHN ANN HE fran ce Page 15 of 20 LAGO1OCKG US P
6. is adjustment gt Remove the knob gt Light the appropriate burner gt Adjust to minimum setting Use a small screwdriver to set the adjusting screw E Note Flame is reduced to 4 of its size in the minimum setting the burner must remain lit when changing from maximum setting to minimum setting Adjusting the safety devices for each thermocouple of the hob If the burner goes out having kept the control knob pushed in for roughly twenty seconds check that The magnetic head grips the valve moderately The flame touches the point of thermocouple F The thermocouples and magnetic head connections are absolutely clean Page 10 of 20 LAGO10CKG US IMPORTANT IMPORTANT IMPORTANT Page 11 of 20 LAGO1OCKG US INSTALLER S MANUAL LAG 010 CKG Must be installed under an exhaust hood Do not install this unit near combustible walls partitions pieces of furniture or decorative material unless these are covered with adequate thermal insulation of the noncombustible type Making sure the resulting installation meets fire regulations THE APPLIANCE MUST BE INSTALLED IN ACCORDANCE WITH THE LOCAL CODES OR National Fuel Gas Code ANSI 223 or latest edition Manual shut off valve should be installed in an accessible location in the gas piping external to the appliance for the purpose of turning on or shutting off gas to the appliance INSTALLER S MANUAL LAG 010 CKG ELECTRICITY
7. ooking grill Railing of recovery Juice Tub Ash drawer Fire Tray Optional Accessory 36 LCKG Bag of lava rock 3 kg Stone rack Rack Support Lava Rock Option shown here Page 3 of 20 LAGO10CKG US GENERAL MANUAL LAG 010 CKG Page 4 of 20 LAGO10CKG US Page 5 of 20 US OPTIONAL FLAME GRILL INSTALLER S MANUAL Appliances must be installed in a workmanlike manner in accordance with the instructions in this manual and locally applicable regulations This manual will be handed over to the user after installation Page 6 of 20 LAGO1O0CKG US Page 7 of 20 LAGO10CKG US INSTALLER S MANUAL LAG 010 CKG LEVELING Cautions The purchaser undertakes to install or arrange for his her equipment to be installed in a workmanlike manner and in accordance with the applicable regulations and standards Any servicing or repair work on appliance must be performed by a qualified technician Recommendations Adjust this appliance by using the leveling feet Allow a minimum clearance of 50 mm between the appliance and any other surfaces above counter height walls affected by heat If the appliance is to be built in between two surfaces it is CRUCIAL to allow free circulation of air behind the appliance provide shielding at rear Cooktops should NEVER be installed lower than adjacent work surfaces It is also recommended to allow the unit front panel to protru
8. otection so required by manipulation of the tub while full of juice fig B during the service Warn users of the potential hazards After use remove food residue with a metal brush from grill while still hot The optional lava rock rests on a rack which itself rests on the bottom of the fire tray The rack may be removed to clean the tray Ashes fall into the ash drawer C which may be pulled out completely for emptying Replace optional lava rock as a function of use at least once a year Railings of recovery fig A Juice Tub fig B Ash Drawer fig C a 3 rrr rer Aaa ee Burner The deflector D detachable removable protecting the burner can clean easily in the dishwasher Use a metal brush to clean the burner after heavy use Body panels You can use special purpose products for stainless steel e g SUMAINOX JOHNSON STAINLESS STEEL PPZ STAINLESS STEEL Never use abrasive products CAUTION Use NO chlorinated cleansers to clean this unit Carefully read the precautions and recommendations for applying the products you use to clean and maintain the range Follow the instructions for use as listed on the product Page 20 of 20 LAGO10CKG US
9. t minimum burner power low flame To turn off turn the control knob clockwise to the OFF position Useful tips CAUTION Use no oils or fats when cooking over lava rock as these may burn and smoke Untrimmed fat may burn and smoke simply move the cut away from the flame The grill can be fixed in a higher or lower position for fast or slow cooking High level Low level Page 18 of 20 LAGO10CKG US USER S MANUAL LAG 010 CKG Broiled meat tips Do not score or spear the cut or it will lose its juices Use tongs not a fork to turn Recommended temperatures Very hot Use for thin cuts or for rare and red cuts Hot For thin or medium thick cuts cooked medium Medium Thick cuts e g ribs of beef should not be seared too quickly to avoid a well browned outside and a raw inside Broiling lengthwise and crosswise Cuts can be broiled length and crosswise once or twice twice will more evenly distribute the juices and produce a tender piece dripping less when served Page 19 of 20 LAG010CKG US USER S MANUAL LAG 010 CKG CLEANING Do not use a steam cleaner to clean the appliance Before any cleaning work isolate from the main supply Wait until the fire tray has at least partially cooled Cooking grill DANGER Wait for the cooling of the device before any manipulation of the drawer with residues rep C and to use an adequate hand pr
Download Pdf Manuals
Related Search