User Guide - Vaxcommercial.co.uk
Contents
1. 31 Specifications The manual uses specifications shown below to draw your attention to specific functions of the machine It contains additional information and useful advice on how to make best use of the machine CAUTION For safety reasons be cautious with hot steam WARNING this manual is for the appropriate use of the appliance only Use of the machine outside the specifications shown is at the owner amp risk 4 USES With the use of water this appliance lets you clean and sanitise surfaces professionally and thoroughly through the use of steam and suction A With its high pressure stainless steel boiler with an unlimited life span and easy to use accessories it is possible to reliably clean and disinfect all surfaces with high pressure steam thereby eliminating mites germs and bacteria as well as limiting allergies A With its high efficiency suction and electronic control it is possible to adjust the suction power directly from the gun and pick up the dirt that has been deeply ground in This is achieved by injecting steam into the surface to lift the dirt and then suck up the dust and liquids with its 4 filtering passage system The water filter can be used to get extra filtration efficiency STEAM CLEANING SYSTEM WET amp DRY VACUUM WATER FILTER f g h i 5 GENERAL WARNING Carefully read the User Guide before starting using performing work with the machine The manufactur2. Turn the handle N over and pull the filter assembly O up forward CAUTION Before removing the tank switch off the appliance and unplug it picture 51 Check the solids filter R and remove any deposits If steam or A no a the two buttons U located besides the hand liquids have been vacuumed or of filtration water has been used picture rinse the internal part of the tank as well as the filter assembly A Lift up the handgrip T components with running water Lift up the handle N and remove the machine tank M pictures 49 50 R Check and eventually clean the microfibre filter P sponge filter Q ilii oes with running water from the inside out let it dry before reassembling the filter assembly To make for easier cleaning of the internal part of the tank regularly remove the internal baffle Z picture 52 carefully unlock both ends of the internal baffle Z see picture To put it back wedge the baffle onto the edge of the tank by hooking the ends picture 51 or picture 52 The boiler water tank L supplies the boiler through an electronic level To top up proceed as follows control since this is an external tank it can be topped up any time Switch off the boiler switch E When water runs out in the boiler water tank Turn off the main switch D 1 the appliance beeps intermittently Remove the cable from the socket 2 the no water level pilot light G flashes Remov
3. which is already assembled WARNING For safety reasons the handgrip T can be released only if the quick connector 24 is not inserted A Lift the safety cover V picture 2 Attach the quick connector 24 of the hose by pressing the front button 25 into the steam socket W picture 3 Make sure it is properly fastened button 25 should return to its initial position once in position it should click Plug the power cable B into an appropriate 240V socket provided with an earthing system Press the main switch D the pilot light H will come on picture 4 picture 5 picture de a picture 1 picture 2 6 2 Starting up the boiler CAUTION When preparing the appliance for use switch it off and unplug it WARNING The appliance must be placed on a horizontal flat surface We recommend using demineralized or distilled water to prevent lime scale deposit in the boiler Do not add any type of detergent or chemical substance to the boiler tank water Remove the boiler water tank cap C picture 4 Fill the boiler tank max 1 2 litres with water using the recharging 6 3 Replacing the filter Press the two buttons U located besides the handgrip T down completely picture 7 Lift up the handgrip T Lift up the handle N and remove the machine tank M picture 8 Turn the machine tank handle N over and pull
4. for maintenance cleaning and textile surfaces ee maximum steam for thorough cleaning disinfecting and greasy surfaces USAGE TABLE The following table describes depending on the surface to be cleaned the amount of steam the attachment and the method to be used Surface to be cleaned Amount of steam Attachment to be used Cleaning method LARGE SURFACES Tough grime use fitting with bristle before ae ae nee steam cleaning and vacuuming Parquet foor wood linoleum le Big ami 3 oh sis Normal surfaces use fitting for liquids before Marble stone ceramic 2e Big Brush 3 fitting for liquids 6 docti ond suis eae comers ee Spray 7 crevice 9 Use bristles for tough grime Floor grouting 3 a spray 7 crevice F Steam clean and then vacuum Taps sa fixtures Jeee Spray 7 crevice 9 RE DOOR FRAMES Le crevice fos anal bat dapareling on base De Skirting boo ue fin le Fi all brush hf the surface is Shutters cae ind 2 a 4 z niir et 4 Tough grime use bristles Smooth surfaces use es tae bites UPHOLSTERY MADE OF FABRIC Turbo brush 1 1 or Carpet es Big brush 3 carpet fiting 4 First vacuum fo remove the dust from the fabric Rugs 5 ou sr 13 marae fitting 4 Deliver the steam suction Direct the first steam jet Furniture padding oe lei na i mer wiper aftachment be aside fo avoid wetting the fabric Sofos Natty Shs wiper atiachment i Use nozzle with squeegee of windows wiper Large surfaces le
5. in carbon dust which blocks the motor Check it monthly by removing contact with the water and therefore does not need to be rinsed out the containment screen and if necessary replace it when dirty immediately after use To remove it wash from the inside out under CAUTION Handle with care Do not inhale Keep out of reach of children running water then leave it to dry before reassembling the filter group picture 33 IMPORTANT The microfibre filter P should not be used during the vacuuming with water filter D Water filter employs the natural purifying strength of tap water to catch the dirt avoiding irritating contact with dust and harmful dispersion of dust into the environment picture 33 9 SUGGESTIONS 9 1 Steam cleaning suggestions Adjust the amount of When initiating cleaning or after having a long break you steam with the knob J should direct the first steam jet to one side in order to turn anticlockwise to eliminate possible water residues from the steam hose increase the amount of especially when cleaning the textile surfaces carpets rugs and steam turn clockwise to sofas reduce it Always test a hidden spot of the surface to be cleaned Let it dry lt minimum steam for and then check to see if the surface can withstand the heat delicate surfaces upholstery furniture glass Clean extremely dirty surfaces slowly in order to vacuum the dirt intermediate steam off with the steam
6. the filter assembly with float O up forward picture 9 Replace the filter P or Q A Fit the lower filter cover S completely picture 10 A Fit the solids filter R completely along with the curved ends picture 11 Make sure the unit is properly assembled check if the filter lower filter cover and solids filter are completely and properly fitted Put back the filter assembly with float O in the tank M Keep the handgrip T lifted and reposition the machine tank M on to the appliance Lower the handgrip T Close the handgrip T by pressing downwards and making sure that the buttons U return to their initial position properly Once in position it should click WARNING Make sure that the microfiber filter P or the sponge filter Q are properly fitted between upper filter holder and lower filter cover and that the solid filter R is placed correctly If not the handgrip T cannot be hooked safely picture 8 picture 7 picture 11 picture 9 picture 10 7 OPERATION 7 1 Using the appliance as a vacuum cleaner To select the suction power from level 1 to level 4 press the remote suction button 27 on the handgrip 23 at short intervals the selected suction power level LED indicator 28 will light up Pictures 12 13 It is possible to change the power level both when the suction is on and off To switch
7. WELD COMMERCIAL VCST O1 Steam cleaner and Vacuum lyear warranty 19 User Guide 0121 347 6047 sales vaxcommercial co uk 9 vaxcommercial co uk INSTRUCTIONS FOR USE DETAILS LIST OF ACCESSORIES BEFORE USE 3 1 Specifications USES GENERAL WARNINGS STARTING UP 6 1 Preparing the vacuum cleaner 6 2 Starting the boiler 63 Replacing the filter OPERATION 7 1 Preparing the vacuum cleaner 7 2 Starting the boiler 73 Replacing the filter 7 4 Using steam and suction simultaneously USING THE ACCESSORIES BIG BRUSH 3 WINDOW WIPER 13 SMALL BRUSH 14 EXTENSION SPRAY 7 SMALL NOZZLE BRUSH 8 SUCTION ATTACHEMENTS 9 10 12 UPHOLSTERY nozzle 11 FILTERS SUGGESTIONS page 3 page 4 page 5 page 5 page 5 page 6 page 7 page 7 page 7 page 7 page 8 page 8 page 8 page 8 page 9 page 10 page 10 page 10 page 11 page 11 page 11 page 11 page 11 page 12 page 13 10 11 12 13 14 15 16 17 9 1 Steam cleaning suggestions page 13 9 2 Vacuum suggestions page 14 EMPTYING THE MACHINE TANK page 15 TOPPING UP THE BOILER WATER TANK WITH WATER page 15 AFTER USE page 16 MAINTENANCE page 16 TROUBLESHOOTING page 17 DISPOSAL page 18 APPLIANCE FEATURES page 18 16 1 Technical features nameplate page 18 16 2 Technical specifications page 18 WARRANTY page 19 Colours of product may differ from final product received Cable winder Power ca
8. Window wiper 13 Purl sut le Small brush 14 small wiper 15 es me a al FURNITURE Small brush 14 small wiper 15 oat Delicate lurniture e g vami i le ar brisiled aiiochmant 16 Delicate surfaces a a cotton cloth in between Plutsonolal furnthire 7 e Small brush 1 4 small wiper 15 Smooth surfaces bristlad attachment 18 le g kitchen furniture or bristled attachment 14 22 Vacuum suggestions When vacuuming liquids on the surfaces do not exceed the double A ON Max level inside the machine tank M When using the water filtration replace water when it starts to look Do not vacuum explosive toxic or inflammable substances e g cloudy chimney ashes and soot or substances that may be dangerous to The appliance is supplied with a safety float O1 which will come your health a into operation if the maximum allowed level of liquid is exceeded Do not use the appliance to suck liquids from containers sinks inside the tank picture 39 In this case the appliance will not suck baths etc in and at the same time you will hear the motor revolutions Do not vacuum foam _ increase If this occurs switch off the appliance and empty the If foam builds up inside the machine tank switch off the machine tank M appliance immediately and empty the machine tank M picture 39 10 EMPTYING THE MACHINE TANK WARNING Empty the machine tank M every time you finish using it
9. ble Boiler water tank cap Main switch Boiler switch Steam ready pilot light No Water pilot light Main switch pilot light Boiler switch pilot light Steam adjustment knob Pressure gauge Boiler water tank Machine tank Machine tank handle Filter assembly with float 01 Microfibre filter Sponge filter Solids filter Lower filter cover Handgrip Handgrip button Safety cover Steam socket Air filter Carbon filter Internal tank baffle 2 LIST OF ACCESSORIES AND COMPONENTS Colours of accessories and components may differ from final product received 1 Hose tube 27 Suction power level 2 Extension tubes LED indicator 3 Big brush 28 steam delivery 4 Carpet fitting safety lock 5 Floor fitting 29 lower hooking lever 6 Liquid fitting 7 Extension spray 7a Steam nozzle extension 8 Small nozzle brush 9 Crevice 10 Swivel brush 11 Upholstery nozzle 12 Radiator brush 13 Window wiper 14 Small brush 15 Small wiper attachment 16 Bristled attachment 17 Iron Optional 18 19 Cotton cloth 19a Recharging automatic valve bottle Optional 20 Cleaning tool Optional 21 Kit of spare seals 22 Handgrip 23 Quick connector 24 Front button 25 Steam lever 26 Remote suction motor button 3 BEFORE USE CAUTION This user manual is an integral part of the appliance Read the user6 manual carefully before using the appliance Keep the manual for future reference
10. e All our machines are subjected to strict tests and are covered against manufacturing with a 12 months warranty The warranty runs from the date of purchase The purchasing date shall be that indicated on the receipt issued when the dealer distributor delivers the machine The manufacturer undertakes to repair free of charge those parts showing manufacturing defects within the warranty period or to replace these free of charge Defects not clearly attributable to materials or manufacture may be examined by Vax and shall be charged according to the outcome of the examination The warranty will not cover Cleaning and repair of machine and accessories caused by development of lime scale deposits Accidental damage caused by transport neglect or inadequate care Incorrect or improper use and installation Failing to comply with the indications in the instruction manual user guide Causes that do not depend on normal operation or use of the machine The warranty becomes void when the machine has been repaired or handled by unauthorizsed third parties The warranty shall not cover replacement of the machine or extension of the guarantee resulting from a breakdown Repairs shall be carried out by Vax The machine shall reach us carriage free i e With transport expenses at the user amp charge The warranty shall not cover any cleaning operations to which the operative components may be subjected The manufacturer declines all responsibility fo
11. e the boiler water tank cap C 3 the steam stops coming out SAA Fill the boiler water tank L picture 53 us Put on the boiler water tank cap C 12 AFTER USE Every time you finish working with the appliance switch it off unplug it and wind the electric cable into its cable rewinder A Empty the machine water tank M every time you finish using it see section M1 EMPTYING THE MACHINE TANK Let the appliance and the utensils cool down before putting them away 13 MAINTENANCE Clean the outside of the appliance with a damp cloth Do not use solvents or detergents Do not use solvents as could damage the plastic parts of the appliance Do not steam clean the appliance Empty the machine tank every time you finish using it see section 1 EMPTYING THE MACHINE TANKO Only use water to clean the attachments When using the appliance with combined functions i e steam and vacuum Cleaning wet dirt can jam and get stuck inside the pipes or hose extension tubes and accessories This dirt may generate bad odours can make the fitting of the accessories very difficult and could reduce the performance of the appliance To eliminate dirty residues from the inside of the attachments extension tubes or brushes wash the vacuum ducts with warm running water and remove any residues with the cleaning tool CAUTION Do not wash or immerge the hose 1 in water or any other liquid A For a thorough clea
12. ed on the appliance The gauge K indicates the pressure inside the boiler the grey silver area indicates the ideal pressure for use picture 17 When the pilot light F comes on the appliance will be ready to function with steam Now press the lever 26 on the handgrip 23 The first amount of steam will come out with water condensation direct the jet to one side or onto a cloth The handgrip 23 has a safety lock 23 which prevents steam from accidentally escaping left lock the lever is free right lock the lever is locked Note To obtain the correct volume of steam wait 3 4 minutes for the water to heat up FC HEC pure 16 74 Using steam and suction simultaneously Please refer to the chapter f6 2 Starting up the boilerdbefore use To steam and vacuum simultaneously it is possible to use the above mentioned steam cleaning functions together When work is finished release the steam lever 26 a few moments prior to switching off the suction motor button 27 This will allow the suction ducts to recover the humidity Note Whilst you are working it is normal to occasionally hear the pump as it pumps in the water Be careful not to confuse this noise with audible warning signal beep made when the boiler water tank is empty picture 18 8 USING THE ACCESSORIES The attachments can be directly connected to the handgrip 23 or depending on your needs to the extension tubes 2 A Fi
13. er will not be held responsible for injuries to persons or damage to property due to non compliance with the aforementioned User Guide It is recommended to keep all the pieces of the packing since they might be useful in the future to protect the machine and the accessories during transport to another location or sent for evaluation repair If not the packing can be disposed in accordance with current disposal laws For commercial use only Use the appliance for its specific purposes only The appropriate Personal Protective Equipment should be worn to operate the machinery and protect the user This should be in accordance with an appropriate risk assessment prior to its first use Connect machine to a suitable 240V power supply It is recommended that a RCD circuit breaker is used to provide earthed protection Do not pull the plug by its cable Do not drag the appliance by its power cable Unwind the power cable completely before use Avoid using electrical extension cables if necessary use an extension cable with a safety approval mark with a protective earthing system Minimum size of extension cable is 3x1 5mm Unplug the appliance after use before filling cleaning of the tank or attachment of the hose Do not fill the tank by placing the appliance directly under a aa tap Before using the appliance make sure that the cable plug and hose are not damaged Do not use the appliance for steam cleaning electrical appliances o
14. ing out The steam adjustment knob J is in the closed Turn the steam adjustment knob J position to open position When working an attachment falls off The attachment has not been connected Connect the attachment safely properly When working the suction power drops The attachment is clogged Check and clean the attachment The suction power is too low One of the filters is clogged Check and clean solids filter R microfibre filter P or sponge filter Q air filter X and carbon filter Y Wrong filter assembly Make sure that the filter assembly O is completely assembled with lower filter cover S and solids filter R Air bypass Make sure that the machine tank M the filter assembly O the flex tube 1 and the quick connector 24 are positioned correctly The suction motor is working but there IS The float has come in operation Empty the machine tank no suction The handgrip buttons do not hold Wrong assembly or position of filter Check the assembly make sure that the handle safely assembly O les or sponge filter are properly inserte Malodorous smell from hose tube Wet dirt remnants in hose tube Clean the parts according to or attachment Maintenance in use instructions 16 DISPOSAL Disposal should take place without detriment to the environment The appliance and attachments are mostly made of plastic When the appliance or attachments no longer work they mus
15. ning of the hose empty the machine tank fit the extension spray attachment 7 and suck one liter of fresh water through the hose into the machine tank To prevent the brushes from becoming misshapen leave the clean brushes to dry with the bristles facing upwards The appliance is supplied with a kit of spare seals Periodically check if the seals worn out and if necessary replace them REPLACEMENT OF FILTERS Micro fiber filter best to replace every 6 months Sponge filter best to replace every 6 months Air filter best to replace every year Motor carbon filter best to replace every year 14 TROUBLESHOOTING CAUTION Repairs should only be carried out only by the Vax Service Centre Breakdowns may occur when the appliance is not used properly The following table describes a few problems and explains how to solve them If our solutions do not help call the Vax Service Centre TROUBLE CAUSE SOLUTION After switching on the no water pilot Low water level in the boiler tank Fill the boiler tank with water using the light flashes and the appliance is beeping recharging automatic valve bottle The appliance is ready for use but there The quick connector of the flex tube is not fitted Make sure that the quick connector 24 is no suction or no steam properly is hooked properly into the socket The steam ready pilot light is on but no The steam safety lock 29 is on Release the safety lock Steam is com
16. nst window to remove dirt ATo dry vacuum the surface by putting the window wiper rubber squeegee against it Aor slightly dirty surfaces use both steam and vacuum at the same time WARNING To avoid dripping complete the steam delivery and continue to vacuum for a few moments in order to allow the vacuumed liquid to go up the suction ducts After each cleaning operation clean the window wiper rubber strip with a clean cloth Proper window cleaning with no lines will be guaranteed only if a clean and outstretched strip is used SMALL BRUSH 14 The small brush has a steam diffuser and a suction nozzle Two different fittings can be installed on it Small wiper attachment 15 A Bristled attachment 16 The attachments can be fixed onto the small brush 14 To disconnect the attachment from the brush press the front part of the brush push were indicated using your thumb to release the hooking teeth of the attachment pictures 23 24 picture 23 picture 24 picture 25 EXTENSION SPRAY 7 SMALL NOZZLE BRUSH 8 SUCTION ATTACHMENTS 9 10 12 The spray has a concentrated steam diffuser picture 26 The following attachments can be used pressure connection Small nozzle brush 8 to be pressure fastened onto the extension spray 7 for cleaning incrustations cracks etc picture 27 A Crevice 9 for vacuuming hard to reach spots such as corners sofa c
17. r damage to persons or property caused by bad installation or incorrect use of the machine Vax Commercial Kingswood Road Hampton Lovett Droitwich Worcestershire WR9 0QH UK info vaxcommercial co uk vaxcommercial co uk
18. r electric sockets Once the appliance is plugged in do not work with wet hands or feet Do not immerse the appliance in any liquid The appliance is not to be used by children or persons with reduced physical sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision or Instruction Do not use or store the appliance in a vertical position Do not steam clean the appliance itself Do not leave the appliance unattended when it is connected to the mains or when the appliance is on Repairs must be carried out only by Vax technicians and by return of the product to Vax Service Centre The electric cable must be replaced only by the Vax service centre Do not vacuum explosive toxic and inflammable substances e g chimney ashes and soot or substances that may be dangerous to your health Do not use the appliance to suck water from containers sinks baths etc Do not place the suction orifice near delicate parts of the body such as eyes mouth and ears Do not put your hands close to the steam jet Do not point the steam jet towards people or animals During use the appliance could overheat if covered 6 STARTING UP automatic valve bottle 19a picture 5 which stops the water supply when the boiler water tank is completely filled picture 6 Put on the boiler water tank cap C a 6 1 Preparing the vacuum cleaner The appliance is supplied and equipped with a microfibre filter P
19. reases etC picture 28 Swivel brush 10 with natural bristles to be pressure fastened onto the extension spray 7 for vacuuming and cleaning more effectively picture 29 A Radiator attachment 12 used specifically for vacuuming dust inside radiators is to be used with the crevice 9 picture 30 UPHOLSTERY NOZZLE 11 The small brush has a steam diffuser and a suction nozzle FILTERS The appliance is supplied with the following filters A Solids filter R this filter performs an initial filtration of A Sponge filter Q The Sponge filter Q is to be used for deposits and material of considerable size The curved pieces vacuuming dust vapour and liquids with the water filter for more located at the ends can be removed for easy cleaning Check and thorough cleaning Wash with running water from the inside out and wash with running water Reinstall the curves by applying pressure sn eee aon to fastened them to the special rib and housing picture 32 picture 32 lt Air filter X this filter has a high filtering capacity and can filter fine dust thereby ensuring clean air coming out of the appliance A Microfibre filter P This filter has a high filtering capacity and EE PRO y E oan e allows you to vacuum up dust effectively It is convenient function for Carbon filter Y this filter has a high filtering capacity for quick job as the dust remaining in the machine tank M is not
20. t be disposed of WARNING As owner of an electrical or electronic product you are not allowed by law according to EU Directive 2002 96 EC of 27 January 2003 on waste electrical and electronic equipment and the particular national laws of the EU Member States transforming this Directive to dispose of this product or its electrical electronic accessories as unsorted domestic waste You shall use the designated gratis possibilities for return instead 17 APPLIANCE FEATURES 17 1 Rating plate CAUTION Make sure that the technical data shown on the rating plate correspond to the electric mains to which you want to connect the appliance 17 2 Technical specifications Boiler Power 1700 W Suction Motor power 1200 1400 W Vapour Pressure 4 5 bar Vapour Flow 50 g min A Air Flow 51 l sec motor Vacuum Pressure 2400 mm H20 motor Time of Heating 1 min 50 A Boiler Volume 0 81 Boiler capacity 1 2 Recovery tank volume 8 Power cable length 4 5 m Flexible tube length 1 2 2 m 17 3 Safety features Process pressure switch Process thermostat Safety thermostat Boiler overpressure valve Low voltage electric Controls on flex A Safety Float 18 WARRANTY CONDITIONS The manufacturer shall not be held liable for damage to persons or things caused by any installation which does not comply with the instructions in the user guide or misuse of the applianc
21. the vacuum on and off hold down the remote suction but ton 27 for about two seconds If the quick connector 24 is pulled out the suction power level will restart from level 1 the next time the appliance is used CAUTION Never vacuum if the microfibre filter P is not installed picture 12 7 2 Vacuuming with water filter For best filtration results add water to the machine tank M The water filtration allows you to feapturedthe dirt so that the outbound air always remains clean and therefore you clean more effectively Proceed as in chapter f6 1 Preparing the vacuum cleanero then replace the microfibre filter P with the sponge filter Q chapter 16 3 Replacing the filter picture 14 Add one litre of normal tap water to the tank until you reach the MAX level shown on the tank picture 15 CAUTION Do not put detergents or inflammable substances in the tank Never vacuum if the sponge filter Q is not installed You can add Aroma to the machine tank This prevents bad odours or smell from the tank Use the product according to the instructions for use shown on the label 7 3 Using the appliance as a steam cleaner Please refer to the chapter f6 2 Starting up the boilerdbefore use Press the main switch D and the boiler switch E the respective pilot lights H and I will come on Water will start heating up and steam will then be produced picture 16 Pre select the amount of steam using the knob J locat
22. tting the attachments fit completely until the lower hooking lever 30 is hooked Disconnecting the attachments press and release the lower hooking lever 30 and pull out the attachment CAUTION Make sure it is properly fastened by pulling it slightly CAUTION Never separate the attachments when steam is coming out you could burn yourself BIG BRUSH 3 The big brush is provided with an articulated connection wheels steam diffuser and a suction unit Three different fittings can be attached to it A carpet fitting 4 A floor fitting 5 A liquid fitting 6 To assemble the fitting Move the top slides outwards picture 19 Turn the big brush 3 upside down Fit the required fitting and make sure it is properly oriented the wide part must face forward picture 20 Fasten the fitting by moving the two top slides inwards picture 21 picture 19 picture 20 picture 21 WINDOW WIPER 13 CAUTION Excessive temperature differences between the glass window and the steam can break the window With extreme outside temperatures preheat the window with steam at a distance of about 30 50 cm Then spray the steam all over the surface of the glass to compensate the temperature differences and to avoid stressing the glass surface picture 22 USE Ause the window wiper to wipe the surface Starting from the top downwards ASlightly press the window wiper sponge agai
Download Pdf Manuals
Related Search