Home

IO-Power USMC-12V3556

1. 15 25W H estimated as in 22W H Special reminder 1 some devices will have the fan heat sink design calculate the power consumption of power plus the fan operation Special reminder 2 some devices will have heat heater design computing power plus heat heater operation power consumption Estimated internal and external devices using the power system operation time required for power supply Automobile Model DC UPS suggest designing for 10 hours Long term Automobile DC UPS suggest designing for 24 hours C LiFePO4 Lithium Batteries Capacity V S C Value of charging and discharging C Value definition hours of battery capacity and discharge current rate such as 1Ah battery Capacity amps to 1 A 1C discharges 1 hour Recommended charging current should be less than 0 5C the discharge current should be less than 0 2C to improve battery life and power stability EX With 4 units of infrared surveillance camera 6W H and 1 unit of NVR 10VW H for 10 hour Total power consumption 10WH 6WH 4 10Hr 110 374W gt 374W 12 8V 29 2Ah Recommended model OP USMC 1235 10B 445 WH 34 8Ah 12 8V Discharging current and discharging C value C 1OWH 6WH 4 12 8V 2 6A gt 2 6A 34 8Ah 0 07C lt 0 2C Charging current and charging C value 374W 12hr full charge 12 8V 2 43A gt 2 43A 34 8Ah 0 07C lt 0 5C 2 43A lt Convertor 3 5A 80 2 8A Form No IOP DOC 011 001 13 23 Retention Period 6Y Gp O Power Technology
2. 3 the built in micro controller will automatically stop discharging and executes low voltage discharge termination the final low voltage discharge termination is 9V 3 and the high voltage discharge termination is 14 4V 3 B Recovery after protection of low voltage power output description IOP USMC 12V3556 OA series uses built in charging and discharging micro controller When battery discharging voltage is down to 11V 3 it will execute low voltage discharge termination It Form No IOP DOC 011 001 20 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan Gp PERRERA GS MI HIALeS 100314 Tel 886 3 5429395 Fax 886 3 5357297 otoit Tocina Ca LA http www io power com tw www io power com cn e mail io power io power com tw will not discharge for the load devices until the outer power source is back in service The micro controller will discharge again when the battery voltage raise to 12V 3 voltage Usually it needs 1 10 minutes depending on the charging current C LiFePO4 Lithium Batteries Charging IOP USMC 12V3556 OA series adopts the latest technologies of high and low temperature resistance of C LiFePO4 Lithium Batteries It is very different from the other types of battery like lead acid batteries deep cycle lead acid batteries and lithium ion battery characteristics Besides the different C LiFePO4 Lithium Batteries products characteristics made
3. Lil http www io power com tw www io power com cn e mail io power io power com tw Product application IOP UMC 1212 07A 1 OP USMC 1224 09B LOP USMC 1247 10B 3 DVR NVR 16Ch 4TB HD Monitoring recording playback video host DVR NVR 16Ch 4TB HD Monitoring recording playback video host Input DC power Input DC power Input DC power DC 12 28V DC 12 28V ig 0 Hi mobile Wireless Surveillance with Outdoor Street Lamps UPS System a ni ea n seeeeeeeunna x ant A A ia T KJ tTOP USMC 1212 07A Mobije DC UPS System OP USHC 1212 07A MIMO Multiple Hops Support Hi mobile Wireless Surveillance Transmit System ESE g e a Bae o a p s Tog AT gsuuk su8 anaes s a jwt ee 200Kmi h Car Speed eg Z pu 100Mbps pa s Aa gt a Form No IOP DOC 011 001 23 23 Retention Period 6Y
4. Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan MHENKARAA GM MHL STH 10031 Tel 886 3 5429395 Fax 886 3 5357297 Kotoi Tocina Ca LA http www io power com tw www io power com cn e mail io power io power com tw EX With 2 units of infrared surveillance camera 6W H and 1 unit of NVR 10W H for 24 hour Total consumption 6WH 2 10W 1 24Hr 110 580 8W gt 580 8W 12 8V 45 4Ah Recommended model OP USMC 1247 10B 594 WH 46 4Ah 12 8V Discharging current and discharging C value 22W 12 8V 1 7A gt 1 7A 46 4Ah 0 036C lt 0 2C Charging current and charging C value 580 8W 16hr full charge 12 8V 2 8A gt 2 8A 46 4Ah 0 06C lt 0 5C 2 8A lt Convertor 3 5A 80 2 8A Note 1 Using C LiFePO4 Lithium Batteries for supplying enough electricity for 3 years use may drop the capacity to 90 95 To operate 3 years please plus the battery aging compensation coefficient of 10 Note 2 The C LiFePO4 Lithium Batteries voltage is 12 8V different from lead acid battery 12V Therefore C LiFePO4 Lithium Batteries is 580 8W 12 8V 45 4Ah Form No IOP DOC 011 001 14 23 Retention Period 6Y 10 Power lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA GS AT hiE 100581 Tel 886 3 5429395 Fax 886 3 5357297 Co Ltd ad http www io power com tw www i0 power com cn e mail io pOwer io power com tw Consideration for environmental characteristics for C LiFePO4
5. Gp IO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan KT QHSARARAA Ge AT HILES TR 1003814 Tel 886 3 5429395 Fax 886 3 5357297 niii http www io power com tw www io power com cn e mail io power io power com tw IO Power USMC 12V3556 OA Series Automobile Heavy Current amp Large Capacity Model Online Type Uninterruptible Operation Boosted amp Stabilized Power System 10P USMC 1247 10B Oi Output DC power DC 12V 6A Input DC power DC 18V 3 5A DC Power Convertor DVR NVR 16Ch 4TB HD Monitoring recording and playback video host Mobile ar Lighter Input DC power DC 12 28V LOP USMC 12V3556 OA Series User Manual LOP USMC 1235 L0B LOP USMC 1240 L0B LOP USMC 1247 L0B LOP USMC 1256 L0B V 13 003_1105 Form No lOP DOC 011 001 1 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA GS AT hiE 100581 Tel 886 3 5429395 Fax 886 3 5357297 l0 Power Technology Co Ltd http www io power com tw www io power com cn e mail io pOwer io power com tw Directory Trademark and Copyright INOW CC serseri 4 PRONE N INON ene E E E E E AEE R ines 4 EET AEE A AAE E E A E A EA N E ee EA E ee A 5 POUSO N A e E T E E E eee eee 5 Fully electronic micro processing control boards WALTANLY cccccscsccccccccceceesssssesssessseeeeeeeeeeeeeeeeeseseeeeeeaaaaes 5 DC step up and stable tr
6. Rd North Dist Hsinchu City 30053 Taiwan ENKARA AH My mALesS 100314 Tel 886 3 5429395 Fax 886 3 5357297 Oomer Temy ntit_http www io power com tw _www io power com cn _ e mail io power io power com tw Mounting instructions Firstly put the waterproof rubber gaskets on the screws Ba E Then set the screw through another set of waterproof rubber gaskets on the stainless steel bracket Finally screw the bracket tight into the screw holes in the bottom side of the housing Pole fixation Suggest using stainless steel cable belt to pass through the stainless steel fixing brackets on either side of the hole and then fix the belt tightly to poles or garden lamp posts or street light lay etc Wall fixation Drill two holes on the wall and put plastic plugs into the holes And then screw the self tapping stainless screws in Finally go through the stainless steel fixing brackets on either side of the holes pressing down and keep the product fixed Form No IOP DOC 011 001 19 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA Ge AT HALB STH 100581 Tel 886 3 5429395 Fax 886 3 5357297 Co Ltd ial ad http www io power com tw www i0 power com cn e mail io pOwer io power com tw Product use instructions External power input description IOP USMC 12V3556 OA series output 12 28VDC through car cigarette lighter power supply
7. by different manufacturers are also different both in voltage and current IOP USMC 12V3556 OA series charging mode and charging voltage is as below Battery Charge Mode CCP CVP MCU Control Battery Charge Voltage 14 4V 3 Battery Charge Float Voltage 13 6V 3 Battery Cut off Discharge Voltage 11V 3 Battery Final Cut off Discharge Voltage 9V 3 IOP USMC 12V3556 OA series uses C LiFePO4 Lithium Batteries different voltage values the remaining power capacity is as below no load voltage 5 1400 osa 1319 ow 1240 saen Form No IOP DOC 011 001 21 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA GS AT hiE 100581 Tel 886 3 5429395 Fax 886 3 5357297 Co Ltd ial ad http www io power com tw www i0 power com cn e mail io pOwer io power com tw LED Display Instruction 1 Input AC power LED red full light Battery capacity more than 95 2 Input AC power LED red flash light Battery is charging 3 Battery is charging Insert the 12V device load LED green flash light 4 Battery none charging Insert the 12V device load LED green full light if the LED green flash of low voltage discharge please charging it 1 When inputting abnormal DC voltage and LED red light flashing fast please immediately remove the power supply to avoid danger 2 When outputting DC power to the load device and LED green light flashing fast p
8. io power io power com tw Product Installation Instruction Automobile DC UPS power transferring Via the car cigarette lighter the automobile power transformer transfers the power from 12 28VDC to 18 20VDC 3A stably and efficient And then it charges the C LiFePO4 batteries and supply DC11V 14 4V to the devices via C LiFePO4 batteries a ak 0 y a i aa My mna ra rT A J ane REF r DC M12 Male to DC M12 Female for input Take aim at M12 Male and plug in M12 Female and spin to tighten the connectors please do an extra waterproof protection Form No IOP DOC 011 001 17 23 Retention Period 6Y l O Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEARARAA GS AHA S TH 10051 Tel 886 3 5429395 Fax 886 3 5357297 iO Power Tochnalogy Co Lil http www io power com tw www io power com cn e mail io power io power com tw DC M12 Female to DC M12 Male for output Take aim at M12 Female and plug in M12 Male and spin to tighten the connectors please do an extra waterproof protection DC Extend Connector DC Extend Cable 1 1 DC Female to 2 DC Female 15cm Female to Female 1 to 2 extended distribution connector 2 1 DC Male to 1 DC Male 18 8cm Male to Male extended short cable 3 1 DC Male to 1 DC Male 150cm Male to Male extended long cable Form No IOP DOC 011 001 18 23 Retention Period 6Y l O Power Technology Co Ltd 1F No 100 Jinzhu
9. mount installation 12 months 490 400 155mm 490 400 155mm 490 400 155mm 490 400 155mm Note 1 battery capacity 5 Note 2 Product specifications change without notice consultation with agent or dealer before buying the latest specifications Form No IOP DOC 011 001 11 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA GS AT hiE 100581 Tel 886 3 5429395 Fax 886 3 5357297 Co Ltd ial ad http www io power com tw www i0 power com cn e mail io pOwer io power com tw Product specification selection assessment Firstly to confirm the power consumption of the devices Power consumption evaluation Description Usually the current claimed on the device EX cameras adapter is not the actual power consumption for normal working We suggest asking the technical support from the Original Design company for the actual power consumption for a precise evaluation The current claimed on the device EX cameras adapter is usually for the transient current when starting the device Therefore it is usually much higher than its normal working power consumption IOP USMC 12V3556 OA series can support 12V 7A above of the starting large current discharging so please calculate and evaluate with the normal working power consumption Load device power consumption Description 1 IOP USMC 12V3556 OA series product the power consumption of the main con
10. 5 13 8VDC 95 Battery is fully charged when PCBA still awake It cannot working when voltage under 5VDC It cannot charge when voltage under 5VDC It should open covers to charge by instrument when voltage under 5VDC Please charge battery up to 11 5 VDC and put it into covers as to charge equalization management by PCBA l O Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QHSRKRARAA AE My PAbesS TH 10051 Tel 886 3 5429395 Fax 886 3 5357297 http www io power com tw www i0 power com cn e mail io pOwer io power com tw fully charged for a long term It extends life of battery unplugged Fully charged is defined by 13 21VDC 80 95 quantity Unplugged 13 0VDC 36 Unplugged 12 8VDC 21 Unplugged 11 0 11 5VDC 3 Stopping discharge 12 0VDC 5 2 Unplugged 9 0VDC 0 5 Stopping discharge lastly PCBA is sleeping The voltage is between 9VDC 5VDC When plugging power energy the battery could 5VDC 0 1 Battery system enters the last stage to protect voltage charge regularly Retention date 6Years Form No IOP DOC 011 001 16 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan HEARARAA AS i mibmee i TH 100314 Tel 886 3 5429395 Fax 886 3 5357297 vena talk _http www io power com tw _ www io power com cn_ e mail
11. Jinzhu Rd North Dist Hsinchu City 30053 Taiwan 2A 3A 2A 6A 25 C 2000 Times 25 C Charging Discharge 800 Times Capacity Over 93 1100 Times Capacity Over 90 45 C 1600 Times 50 C 1200 Times 60 C 550 Times 60 C 720 Times 70 Capacity Aluminium Radiating Airtight Housing IP67 M12 Connector 1 Input DC 12V 28V Cigar Lighter Male Plug to 18 20V DC Jack Female 2 Output 12V M12 Female to DC Jack Female 20 C 60 C In car temperature 30 C 70 C 20 40 C Battery Capacity 100 10 C Battery Capacity 60 20 C Battery Capacity 48 30 C 60 C In car temperature 30 C 70 C 20 C 40 C 10 95 RH Do not wake the system can store 12 months after you wake the system each 2 months charging 1 times Please fully charging battery in first times to use 209 L x200 W x210mm H 209 L x200 W x210mm H 209 L x200 W x210mm H 209 L x200 W x210mm H 4 7Kg Box 5 3Kg 2Pcs Carton 5 4Kg Box 6Kg 2Pcs Carton 7 0Kg Box 7 5Kg 2Pcs Carton 8 2Kg Box 8 8Kg 2Pcs Carton 1 Input AC power LED red full light Battery capacity more than 95 2 Input AC power LED red flash light Battery is charging 3 Battery is charging Insert the 12V device load LED green flash light 4 Battery none charging Insert the 12V device load LED green full light if the LED green flash of low voltage discharge please charging it IP67 CE amp FCC 1 Upright pole mount 2 Plane
12. Lithium Batteries Battery service life and service efficiency is influenced obviously by the factors below Please take the factors in consideration 1 Operating temperature Lowest temperature shall be higher than 20 C and highest temperature shall be lower than 60 C Discharge depth Usually the definition of full charged battery state is at 95 capacity 13 3V When its voltage is 11V the power capacity is about 2 13 left Long Term discharging deeply will speed up aging the batteries Therefore we suggest discharging 70 and keeping 30 left about 13V It will obviously extend the battery service life The charging and discharging current The recommended charging current should be less than 0 5C And the recommended discharging current should be less than 0 2C It will fully show the battery charging discharging characteristics and performance It can also extend the battery service life and slow down the battery aging Regularly re charge the power the self discharging rate of C LiFePO4 Lithium Batteries is much less than other batteries Remaining in high voltage can extend battery service life and slow down battery aging Form No IOP DOC 011 001 15 23 Retention Period 6Y O 10 Power Technology Co Ltd Graph of C LiFePO4 Battery Voltage and Capaci 14 4VDC 100 13 8VDC 99 Battery is fully charged wheg Trickle charge when plugged plugged Battery is under high voltage and 13 3
13. SMC 12V3556 OA series is Automobile Heavy Current amp Large Capacity Mode online power voltage regulator and power systems protection grade iron material metal casing complemented by professional antirust paint suitable for indoor and outdoor harsh environments Users in accordance with the operations manual to operation and use of this product in non human is a misuse case will have 1 year warranty guarantee Fully electronic micro processing control boards warranty IOP USMC 12V3556 OA series using uses chip microprocessor design micro controller design for online charging and discharging Control Board Control Board at 20 C 70 C under normal operation Charge Discharge current of current control board were 7A 20 C 70 C temperature protection when product temperatures is above 70 C all micro controller will automatically stop charging and discharging operations it must be cool or under the limited high temperature the system will be activated again In accordance with the user manual to operate and use this product in non human misuse case buyer will have 1 year warranty guarantee DC step up and stable transfer electric appliance warranty IOP USMC 12V3556 OA series is especially designed for large consumption vehicle load devices Input vehicle cigarette lighter DC power 12 28V and output 18 20V 3A Max by DC DC step up and stabilizing converter to charge the Automobile DC UPS power system DC step up and Stabilizing
14. Standby Consume Protection Balance Voltage Function Overload Protection Overcharge Protection Over discharge Protection Over current Protection Short circuit Protection Over current Protection Short circuit Protection Automobile Cigarette Lighter DC voltage Output Protection Power Converter DC voltage Output Protection DC Power Converter Boosted amp Stabilized Power voltage Support Battery Type C LiFePO4 Lithium Batteries Battery Capacity 34 8Ah 12 8V 445WH 40 2Ah 12 8V 515 WH 46 4Ah 12 8V 594WH 56Ah 12 8V 717WH Battery Charge Mode CCP CVP MCU Control Battery Charge Voltage 14 4y 3 Battery Charge Float 13 6V 3 Voltage Battery Cut off Discharge 11V 3 Voltage Battery recovery 12V 3 Form No IOP DOC 011 001 10 23 Retention Period 6Y discharge voltage Standard Charge Current Max Charge Current Standard Discharge Current Max Discharge Current Battery Cycle Life 80 Capacity 0 2C Charging 0 5C Discharge Industrial Housing amp Connector Connector Type Operating Temperature Discharge Charging Temperature Storage Temperature Rel Humidity Storage Time Dimension Weight LED Indicator Housing Approvals Installation Warranty Carton Size lO Power Technology Co Ltd GHEGRARAA GS AMT HALBS TH 10051 Tel 886 3 5429395 Fax 886 3 5357297 http www io power com tw www i0 power com cn e mail io pOwer io power com tw 1F No 100
15. ansfer electric appliance WAITANKY ccesssecccceceesesssseeeeececeeessssseeeeeeeeessssseeeeeeeeeens 5 C LIFePO4 Lithium Batteries warranty cccccccssssssececsssssseecesssssesececssssesseesesssaseeecssseaseeesesssaseeesssssesseeessssaes 6 ToT ACIE OSV 4 ai E E E E E E AE OEE A E E eee ey ea ZO Special attention of the Product used sssseesessseseseesssssserrrrersssssereeeessssserrrrenssssserereenssssserrreenssssererreenesssee FOGG 250 CCIIC ALON eae E A E E E 10 Product specification selection assessment ccccccccccessssssseeececcessssssnseeeeceeeesssssaeeececeeesssesaeeeeeeeeeseeeeaeeeeeesensns 12 Firstly to confirm the power consumption of the devices ssssessseessssssesrreesrrssserrreensrssserrreeresssserrreeesssssene 12 Estimated internal and external devices using the power system operation time required for power T a E E E E E E E 13 C LiFePO4 Lithium Batteries Capacity V S C Value of charging and diSCharQing cccsscccccesssseeeeess 13 Consideration for environmental characteristics for C LiFePO4 Lithium Batteries eeeeeeeees 15 Produc Ti Stale lON AS MC UO eese Guns teens ceaaneaaeigeaanecsaceGesecennseuisaeueesiaeanees 17 Automobile DC UPS power transferring cccccssssscccsssssseceessssseceeesssseseeecsssssaeeeeesssaseeesesusaeeeessesseaeeesesssaes 17 DC M12 Male to DC M12 Female for input ccccsssssseeeecceeesssssseeeeeeeeeesssssseeeeeeeeesssesa
16. by boosting stability go out 18 20VDC 3A DC electrical power then enter the charging and discharging to the built in DC UPS products of micro controller to charge and discharge the battery management and at the same time providing DC power 11V DC 14 4V to load devices such as surveillance cameras DVR NVR host infrared projector and so on Charging the device while output 12VDC 6A power supply for loading equipment on board the vehicle use Ki First time to activate When an external power input power power from the car cigarette light transferred by the automobile transformer the microprocessor will be 3 10 seconds to wake up wake up the controller to charge and discharge the battery immediately after management jobs and at the same time on the device side discharge management After the first time to activate the system unless the DC UPS System executes the low voltage discharge termination it will keep working When the microprocessor detects the battery low voltage at 11V 3 it will automatically execute the termination to avoid battery damage of low voltage DC power output description IOP USMC 12V3556 O A series uses built in charging and discharging micro controller with the online power circuit design online in real time to discharge by C LiFePO4 Lithium Batteries providing DC power 11V DC 14 4V to load devices such as surveillance cameras DVR NVR host infrared projector etc When the battery discharges 11V
17. ches 36 C and the temperature in the vehicles will reach 60 65 C If it is directly shined temperature of the housing surface is about 65 C while it is about 55 58 C inside the box and battery temperature is about 50 55 C USMC 12V1224 OA was tested under the sun during 10AM 4P M and it worked normally to supply stable DC 11 5V 14 4V 3 for the cameras both inside and outside the vehicle Form No IOP DOC 011 001 9 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan GHEPRARAA GS Hitit 10051 Tel 886 3 5429395 Fax 886 3 5357297 l0 Power Technology Co Ltd http www io power com tw www i0 power com cn e mail io pOwer io power com tw Product Specification lIOP USMC 12V3556 OA Series Specification Patent Pending Model lIOP USMC 1235 10B lIOP USMC 1240 10B lOP USMC 1247 10B lOP USMC 1256 10B Automobile Model M12 Connector Aluminium Radiating O cos Airtight Housing IP 67 input DC power pt DC power por Input DC power DC 12 28V DC 12 28V DC 12 28V Power Capacity 445 WH 34 8Ah 12 8V 515 WH 40 2Ah 12 8V 594 WH 46 4Ah 12 8V 717 WH 56Ah 12 8V Car boost steady DC12V 28V 3A electrical appliances 18V 3A Max Output DC Voltage DC to DC for Device DC 11 5V 14 4V 3 6A Max DC to DC for Battery 14 4V 3 2 3A Max Transform Efficiency 90 Protection On Line Working System Non Stop Standby Consume Protection
18. converter is rated IP65 When installing please place it at the proper position in car and do an extra waterproof and dustproof protection In accordance with the user manual to operate and use this product in non human misuse case buyer will have 1 year warranty guarantee for DC step up and stabilizing converter Form No IOP DOC 011 001 5 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA Ge AT HALB STH 100581 Tel 886 3 5429395 Fax 886 3 5357297 Co Ltd ial ad http www io power com tw www i0 power com cn e mail io pOwer io power com tw C LiFePO4 Lithium Batteries warranty IOP USMC 12V3556 OA series adopts the latest technologies of high and low temperature resistance of C LiFePO4 Lithium Batteries supported by Automatic detection of abnormal voltage or battery status and fault exception of battery charging protection Battery low voltage protection with zero power consumption Balancing charge discharge protection Patent design and unique microprocessor system for charging and discharging control management C LiFePO4 Lithium Batteries characteristics into full play In accordance with the user manual to operate and use this product in non human misuse case buyer will have 1 year warranty guarantee or 500 times battery charge and discharge cycle Extension of the warranty period and the number of cycle life 500 times product warra
19. eeeeeeeeeeseeageeeeees 17 Take aim at M12 Male and plug in M12 Female and spin to tighten the connectors please do an extra WATCH FOOT DIOL SCHON e EAEE A E 17 DC M12 Female to DC M12 Male for output cc cccssssceeeceeeessssseeeeeceeeessssaeeeeeeeeeeessaseeeeeeeeeseesaaaeeeees 18 Form No IOP DOC 011 001 2 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QESRARA A Gi ATT HA wee 10058142 Tel 886 3 5429395 Fax 886 3 5357297 otoit tocino Ca Ll http www io power com tw www io power com cn e mail io power io power com tw Take aim at M12 Female and plug in M12 Male and spin to tighten the connectors please do an extra Waor CION a ee ee 18 DC Extend Connectors DG Extend Cable sirrane n aiene eres ise EE EEE 18 MOUNTO SUCOS nE E A AE A REA EE E A ee ee eee eee 19 Firstly put the waterproof rubber gaskets on the SCreWsS nsssosnensssesrenssseerenssserenssserrenssserrenesserrenssserees 19 Then set the screw through another set of waterproof rubber gaskets on the stainless steel bracket 19 Finally screw the bracket tight into the screw holes in the bottom side of the NOUSING ceeeeeees 19 POETAN a E 19 WNT OT e a E E E S avcadeor a tauestesnadeneadeed oeneaseeeneeeeanece 19 PrOdUCTUS GINS TUCO ea S E T E saadonoeons 20 External power input description eeccsssssssssssncccceeeeeeeeeeeeeessssessessaaaaeeeeeeeeeeeeeeeesssesns
20. eeesaaaaaaeeeeeeeeeeeeeeesseseas 20 B First time to activate oo seececcscesecececsesececsesesecscsescsucsesesesecersvscecessvsucecarsvsucesavavsusasavavsesasavesecasavstsecavavetsesasersetees 20 DC power output GSS Gil HOM essc E AE NEEE EEE 20 L BA Recover after protection of low voltage power output description ssessseeesssssssreerssssserrrreesssssrrrrees 20 C LIFePO4 Lithium Batteries Charging ccccccccsssssscceeessssseceessssseceeesssaseceessssaseeeesssseseeesessseaseesessssaseeesesssaes 21 CEDO M TUCU a E T E E O E E O 22 VA display CO MSIC Ch AU OINS seseina EAE 22 FOCUSED ONC AOU acess aa recep ate soccer E E A EN 23 Form No IOP DOC 011 001 3 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA GS AT hiE 100581 Tel 886 3 5429395 Fax 886 3 5357297 Co Ltd ial ad http www io power com tw www io power com cn e mail io pOwer io power com tw Trademark and Copyright Notice lIOP USMC 12V3556 OA series is Automobile Heavy Current amp Large Capacity Model online power voltage regulator power systems O Power technology limited a registered trademark All parts of the product including software and accessories their copyrights are owned by l O Power Technology Limited without O Power Technology license transcript may not be any imitation copying or translation Product specifications and information referred to in this manual a
21. en the C LiFePO4 Lithium Batteries is discharging and being discharged please keep it away from other conductive objects 9 When recycling the batteries please be sure that the battery short circuit is isolation to avoid danger 10 The C LiFePO4 Lithium Batteries has a life cycle when the battery life cycle ends please contact your seller to replace the same battery Form No IOP DOC 011 001 8 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan Gp PERRERA GB Watie 100314 Tel 886 3 5429395 Fax 886 3 5357297 otoit Tocina Ca Ll http www io power com tw www io power com cn e mail io power io power com tw 11 Be aware of the abnormal heat flame shape smell color and other abnormal conditions please immediately discontinue your use of the product and contact the seller as soon as possible or contact O Power Technology company 12 When erecting IOP USMC 12V3556 OA series if there is more space in the distribution box or patch space license case we recommend this product fixed inside the box it will help to reduce this product at the risk of excessive high temperature operating temperature 13 When erecting IOP USMC 12V3556 OA series if possible we recommends that this product fixed to the Lee side or not to be in the rain it will help to reduce the risk of this product working in environments that is too much little humidity Humidit
22. ium Batteries are very different from the lead acid batteries and other types of batteries C LiIFePO4 Lithium Batteries made by different manufacturers design different characteristics in product including the operating voltage and operation current This product uses C LiFePO4 Lithium Batteries Users shall pay more attention on list below 1 Please use the product in accordance with the product specification data Please do not remove or change this equipment without authorization of any of the main parts so as to avoid the safe use of the extension of the problem 2 Donot proceed heating over 80 C or put it close to fire or keep it less than 40 C to directly cooling down It might cause damages for electronic components and the batteries 3 When the product housing over 70 C do not carry out charging and discharging operation to avoid danger 4 Do not place this product in high humidity and put it into water or close to the highly volatile chemical solvents to avoid danger 5 Installation and assembly connectors in accordance with product instructions not adjacent to the wrong wire connection to avoid danger 6 Donot use hammer or other items to strike this product trample on the battery cause strong impact or throw drop this product to avoid danger 7 Before using this product any action to charge and discharge the battery of this product please be sure to read the manual in detail and with care 8 Wh
23. lease immediately remove the load device to avoid danger 3 When other abnormal situation occurs resulting in high temperature please immediately remove the power supply and the load devices in order to avoid danger 4 lIOP USMC 12V3556 OA series uses built in micro controller to detect the battery charging and discharging voltage every 3 minutes and executes charging and discharging management even if battery is fully charged micro controller will still float charge the battery in order to remain the best status and performance of C LiFePO4 Lithium Batteries 5 If the LED green light is flashing slowly without connecting to any load device it is that micro controller detects the output noise When inputting the power the flashing will disappear and it does not affect the charging and discharging functioning 6 When you plug in a load device but the LED green light is not on it is that the lowest discharging current that micro controller may detect is 300mA 10 load device power consumption less than 3 5 W If the power consumption of the load device is less than 300mA the LED green light may not flash or constantly display but it does not affect the charging and discharging functioning Form No IOP DOC 011 001 22 23 Retention Period 6Y l O Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan HSARARA a AS MT PALeS TH 1003814 Tel 886 3 5429395 Fax 886 3 5357297 so Foner Technology Co
24. nty guarantee may be extended 1year 500 times will cost another 10 Attention of the Product storage IOP USMC 12V3556 OA series adopts the latest technologies of high and low temperature resistance of C LiFePO4 Lithium Batteries and ability to import static zero power But after the charge and discharge test before shipping the system is on low consumption detecting status Storage temperature must be between 20 C 35 C to remain the normal operation of stockpile security and subsequent use of products IOP USMC 12V3556 OA series uses static zero power function But after the charge and discharge test before shipping system stays in low voltage low power reconnaissance operation status When C LiFePO4 Lithium Batteries discharge to 11V 3 the built in charging and discharging micro processing controller will automatically execute low voltage discharge termination protection so user should regularly detect for low voltage status to keep stockpile sage and subsequent use of product Form No IOP DOC 011 001 6 23 Retention Period 6Y 2 lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA GS AT HALB STH 100581 Tel 886 3 5429395 Fax 886 3 5357297 10 Power Co Ltd id http www io power com tw www io power com cn e mail io pOwer io power com tw IOP USMC 12V3556 OA series adopts the storage under low voltage and low power consumption status we strongly recommend that afte
25. r obtaining the products charge the battery for 8 hours for the first time and then charge the battery once every 3 months Fully charged C LiFePO4 Lithium Batteries stored 25 C storage for 1 year its power capacity will remain 90 After charging its power capacity will lift to 95 97 IOP USMC 12V3556 OA series adopts low voltage detection operation for low power consumption storage when the battery voltage is below 11V 3 microprocessor will execute the termination After the outer power is put in it will activate the system in 10 seconds And then the PCBA will start to charge the C LiFePO4 Lithium Batteries and supply for the supported equipment at the same time After the first time to activate the system before Automobile Heavy Current Model executes the low voltage discharge termination DC UPS power system can detect the discharging status Once the supported equipment is plugged in the system will automatically supply power for the equipment Form No IOP DOC 011 001 7 23 Retention Period 6Y 2 lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA GS AT hiE 100581 Tel 886 3 5429395 Fax 886 3 5357297 Co Ltd tonr ny http www io power com tw www io power com cn e mail io pOwer io power com tw lIOP USMC 12V3556 OA series adopts the latest technologies of high and low temperature resistance for C LiFePO4 Lithium Batteries The characteristics of C LiFePO4 Lith
26. re for reference only specification changes without prior notice please consult with agent or dealer before purchase latest product specification data About this manual This manual discusses O Power technology Automobile Heavy Current Model online power voltage regulator power systems through the operation of the content of this article to address the problems of outdoor power seizing This manual uses the following criteria to communicate instructions and information C LiFePO4 Lithium Batteries Readers attention These attentions to include the special conditions referred to in this manual or use the recommendation and note references Reader beware In this case readers can result in equipment damage or risks Hazard Means that there is a potential risk of this can result in physical damage Before using any equipment please pay attention to the risks associated with the circuit as well as familiar with standard practices required to prevent accidents from happening Bold It means an important function and set of steps require your attention Form No IOP DOC 011 001 4 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QEAKARAA GS AT hiE 100581 Tel 886 3 5429395 Fax 886 3 5357297 Co Ltd ial ad http www io power com tw www i0 power com cn e mail io pOwer io power com tw Product Warranty Housing Warranty IOP U
27. trol board estimated as in 1W H 2 General surveillance cameras 2 5 5W H estimated as in 3 6W H 3 Professional surveillance cameras of road surveillance 3 5 6W H estimated as in 4 5W H 4 Infrared surveillance cameras IR on 4 8W H estimated as in 6W H 5 Professional infrared shield 4 10V H estimated as in 6W H 6 Professional long distanced IR projector 8 12W H estimated as in 10W H 7 Video Server analog into digital processor 6 10W H estimated as in 8W H 8 Speed Dome Cameras 8 12W H estimated as in 10W H estimates with IR on please add 6W H estimated as in 16W H 9 DVR with built in 1 unit of 2TB Hard Disk drive 8 14W H estimated as in 10W H plus 5W H for 1 extra unit of hard drive 10 NVR with built in 1 unit of 2TB Hard Disk drive 8 14W H estimated as in 10W H plus 5W H Form No IOP DOC 011 001 12 23 Retention Period 6Y lO Power Technology Co Ltd 1F No 100 Jinzhu Rd North Dist Hsinchu City 30053 Taiwan QHESRARA A Gi ATT HAs TH 1005142 Tel 886 3 5429395 Fax 886 3 5357297 Kotoi FORNEY Ca Ll http www io power com tw www io power com cn e mail io power io power com tw for 1 extra unit of hard drive 11 The network switches hubs 2 4W H estimated as in 3 W H 12 Outdoor wireless equipment normal RF output power 5 10W H power consumption estimated as in 8W H increased RF output power and MIMO power consumption 8 15W H estimated as in 12W H 1W high RF output power
28. y too high low and water environments is such an operational risks 14 When erecting IOP USMC 12V3556 OA series if possible we recommend this product fixed on the back of sunshine or not to be shined it will help to reduce the heat caused by excessive heat and sunshine to protect the product body and wiring from speeding up aging from the environmental risks 15 When erecting IOP USMC 12V3556 OA series even this product is rated IP66 IP67 of waterproof and dustproof grade but for a sound safety for indoor and outdoor use we suggest proceeding professional waterproof protection Using general PVC tape for waterproof with 2 levels can reach the effect for waterproof and dustprootf 16 When erecting IOP USSP 12V0712 Il series in response to different frequencies of vibration wave made by vehicles moving electronic component vibration might be damaged Please do shockproof to improve the service life and stability of the product Note1 The sunshine goes in the inside of the vehicles through the glasses The temperature will rise especially when the windows are close If the environment temperature is 36 C temperature in the car will reach up to 60 65 C and the positions that sunshine directly shines will reach up to 65 70 C But temperature for other positions that are not shined directly is about 55 63 C Note 2 USMC 12V1224 OA series adopts high temp resistant coating wrapping on the metal housing When the temperature rea

IO-Power USMC-12V3556

Contents

Download Pdf Manuals

Related Search

Related Contents