User Guide
Contents
1. FRAUD FIGHTER CT 550 Currency Detectc x a FRAU ICHTE D ee d i Sapa Hy in Fhar J en a Operation Manual lt a gt Supplier of Fraud Fighter Products 1743 South Grand Ave Glendora CA 91740 www fraudfighter com 800 883 8822 CT 550 USER MANUAL Catalogue Safety Instructions 2 00 ccc eee teen eee eens 2 MMOOUGUON aos euteea mn oars a huna Gana a db Gee bees 3 SPCCHICHNON ecards nenna eA NESANA NESRETAN EENAA 4 OPON eee Ena EA E E E A E EARNS 5 Troubleshooting 0 cece cece cee eee ee ne eunneneeunenunnae 7 Maintenance 6 once osc nested sow eee ntin see wwaw eek neaee Vowew eek ass 8 Safety Instructions 1 10 11 12 13 14 Before using the machine read the instructions and safety guidelines carefully Store these instructions within reach so that you can consult them later Take special note of the warnings on the machine and in these instructions lf the machine is passed on to third parties these instructions must also be passed on Only plug the adaptor into an A C voltage of 100 240V 50 60Hz The power outlet into which the machine is connected must be easily accessible at all times so that the plug can be pulled out in case of emergencies In order to completely switch off the machine pull the plug out of the socket Do not open the casing under any circumstances Always contact customer service for maintenance Do not use this machine in the direct vici2. PO1 The PPE left IR sensor is failure Detection Emor Code Display The following error codes shown in the display window during banknote detection indicate the type of detection error and the reason the note was rejected E01 mak AA Error E Spectrum Error SS Important Notices e lf the machine works abnormally check the following Confirm that the power outlet is within specified range AC 100V 240V 50 60H7 Confirm the power cord is firmly connected to the power input on the rear of the machine If on battery power Confirm the built in battery is sufficiently charged by testing the machine on AC DC power Keep away from strong magnetic fields which can affect electronic function Clean any dust or other contaminant from the sensors e fa banknote is blocked while it is being detected please open the top cover and remove the banknote to detect it again e Please ensure that banknotes have been smoothed e g folds and wrinkles repaired before inserting Also remember that the banknote must be put in straight crooked notes will usually be rejected by the CT 550 Maintenance This CT 550 is a precise financial detecting equipment which requires periodic maintenance e Keep the banknote detector in a ventilated place and away from magnetic fields e Periodically clean the sensors use a piece of cotton with a small amount of alco hol to clean all sensors rubber wheels and rubber synchronous
3. Display Window will display Lo at an interval to remind the user of that the battery needs to be charged or the user should turn off the banknote detector Download Software 1 Turn off the banknote detector first and then use the provided download cable to connect the USB port on your PC to the USB port of the detector 2 First plug in the power adaptor Next press and hold CLR key and ON OFF key together then turn on the banknote detector If twelve dashes are displayed on the display window this means the machine has entered download mode See Figure 6 If the display window doesn t display twelve pieces of please retry steps 1 and 2 again 3 Run the AS410 exe program provided to you on your PC and click the Load File button to select the updated currency software UPL See Figure 7 then click Upload Unit button to download the software See Figure 8 Figure 6 Sener Es Figure 8 Figure 9 4 If the download is successful See Figure 9 please restart the machine Troubleshooting Self test error code display The detector automatically performs a self test when powered on If one of the following error messages is displayed on the display window usually it is because the sensor is blocked by banknotes or dust Please use a brush or a piece of soft cloth to clean the dust on the sensor or remove the banknotes and then restart the machine
4. belts Be sure not to expose the sensors to sharp or hard articles in order to avoid damage to them e Do not disassemble the detector Doing so will invalidate any warranties provided on the machine
5. ECB authentication Distinguishes currency types and denominations automatically Displays number of banknotes and total value of each currency type Rechargeable lithium battery inside for portable usage Provided with sound light alarm function Software can be updated through USB port List of Accessories Detector User Manual AC DC Power Adapter USB Download Cable Rechargeable Battery Operation Turn on off the machine Press the ON OFF key and hold on for about 2 seconds The ON OFF indicator lights up and a self test will start after turning on the detector If the test is success ful the Quantity Display Window will display the software version See Figure 1 Next two 0 will respectively display on the Quantity Display Window and Value Display Window See Figure 2 In this mode the detector is ready for use The user can turn the machine off by pressing the ON OFF key and holding for about 2 seconds The software version Illustration Description 1 Feed port 2 REP DIR key 3 CLR key 4 Power ON OFF key 5 Backward Direction Indicator 6 Forward Direction Indicator 7 Currency Type Display Window 8 Quantity Display Window 9 Value Display Window 10 Exit 11 USB download port 12 DC input socket Figure 1 Figure 2 Select Genuine Banknote Exit Direction Press REP DIR key and hold on for 2 second to select the exit direction of the genuin
6. e banknote The denotation of direction will be shown on the left part of the top cover AW means the genuine banknote will exit from the front while a 4 means genuine banknotes will exit from the rear The CT 550 will remember the last setting for exit direction Detecting You need not select currency type when testing banknotes because the machine can distinguish the type automatically The type of currency being tested will be displayed on the Currency Type Display Window When the machine detects a banknote in the feed port it will automatically start the motor and the bill will be pulled into the sensing area The CT 550 requires the user to insert banknotes on the correct side of the Test feature magnetism infrared image paper quality thickness feeding port and with the banknote facing the correct direction The user should Dimension 155x137x82 mm consult the printed label on the machine to see which side and direction is to be Power Supply AC100V 240V 50 60Hz or DC12V 1 0A used When inserting a banknote please make sure to align the bill so it is not Operating temperature 0 40 C crooked otherwise the test may fail Storage temperature 20 65 C lf the banknote is genuine the tally of the total number of notes will be in Battery rechargeable lithium battery 10 8V 600mAH creased by one and the value of the tested note will be added to the cumulative Power Consumption lt 10W value The banknote will exit from the selected exi
7. nity of water such as near a bath a wash basin a sink a wash bucket in a damp cellar or close to a swimming pool Avoid foreign substances and fluids coming into the casing of the machine Do not place the machine close to a radiator a heater flap an oven or other devices which emit heat Under no circumstances try to repair the machine yourself Contact the dealer who you bought it from or a customer service office in your area lf the power cable of this machine is damaged it must be replaced by the manufacturer its customer service department or a similarly qualified person in order to avoid hazards Do not use any accessories which were not supplied on purchase or with the packaging The guarantee is no longer valid if this is not observed The machine must not be connected with the mains and not switched on if the case of the machine is open It must be noted that the machine can still be active even if it is not connected to the mains Moving parts in the interior may Cause injuries This machine is exclusively intended for indoor use Introduction This device is a reliable and easy to operate banknote detector It can detect coun terfeit banknotes and identify genuine currency With the included rechargeable bat tery it can be used portably The currency detection techniques include magnetism infrared image paper quality and a variety of other physical characteristic tests Features Passed CE REACH ROHS EUP and
8. t direction See Figure 3 When the speed lt 0 5s sheet number of bills is greater than 999 or the total value is greater than 999999 the data will be automatically reset to zero Specification Currency Type Exit Direction gt Total Number Error Code Total Value Figure 3 Figure 4 lf the banknote is a suspicious one it will be rejected and exit from the feed port with 3 beeps At the same time the ON OFF key will flash and an error code will be displayed on Quantity Display Window See Figure 4 The error codes are listed in the Troubleshooting section on pages 7 and 8 Detecting Report and Clearing After finishing detection press REP DIR key to enter report mode When checking the detection record it is possible for you to press REP DIR key repeat edly to display records for different denomination and its pieces by turns See Figure 5 Press CLR key and hold it for 2 seconds to clear records Number Of Sheets Denomination Figure 5 Power Saving Mode When operating on battery power the CT 550 will power off automatically when the detector is idle for more than 15 minutes Battery Status Message When the machine is charging the battery the Currency Type Display Window will display Ch every 5 seconds to indicate the charging status Usually the bat tery needs about 15 hours to achieve a full charge If the voltage is low the Currency type
Download Pdf Manuals
Related Search