Home

2015 210 Popular Brochure

1. Hidden latch along edge of cabinet door 2014 by Roadtrek Inc Interior Living Space 13 Galley cabinets Immediately beneath the galley countertop there is a drawer with a pull knob to the right of the food preparation surface to hold silverware and small cooking utensils The left panel is fixed and is not a drawer The two cabinets below this panel on the left provide storage space for food and larger cooking utensils The water heater is at the bottom of the left cabinet but there are shelves above this and more shelves in the right cabinet for the entire height of the cabinet There are three more drawers on the right below the top drawer and the pull out table with hidden latches on the right side by the driver s seat Galley cabinets 2014 by Roadtrek Inc Interior Living Space 14 Lights Fluorescent light LED tap light All cabin lights use 12 volts and are powered by the coach batteries so the battery disconnect switch must be on for any of these lights to work The fluorescent lights turn on and off with the integrated switch at one end of the light fixture There are three fluorescent lights down the center aisle and one more over the galley The four oval and round LED ceiling lights in the back and the two more oval lights over the driver and passenger seats up front are all individually controlled and are tap lights to turn them off or on press on the lens area Th
2. 2014 by Roadtrek Inc HOWTO Waste Water Dumping 112 A Do not toss the packet into the toilet even if it claims to be dissolvable It may not be dissolvable enough for the macerator Tear open the packet and pour the contents into the black tank and dispose of the packet in the trash The contents of the powder packets can be irritating to your eyes and nose so hold the packet low to the bowl and try to pour directly into the tank A The waste water discharge pump can be damaged if allowed to operate dry for any length of time Turn off the pump as soon as the tanks are empty Turn off the pump as soon as the solid stream of liquid begins to sputter and the pump s sound changes Jammed Waste Water Discharge Pump If the wastewater discharge pump stops while you are pushing the button it s jammed Something has gotten caught up in the blades Release the button to stop the pump e Locate the manual macerator crank knob underneath the vehicle You can see it behind the black and gray handles e Push in on the knob and turn clockwise you will feel the knob engage the waste water discharge pump shaft e Turn the knob first in one direction and then the other to loosen the obstruction e Once loose continue dumping ErrA F ai ao oe ae is Ta i Macera tor manual crank knob 2014 by Roadtrek Inc HOWTO Cable and TV Reception 113 HOWTO Cable and TV Reception Your Roadtrek comes with a home th
3. HOWTO Monitor Panel 92 Optional Gasoline Generator Switch and Hour Meter To start the generator first push the bottom of the rocker switch for 5 seconds to PRIME then push the top of the switch to START Allow the generator to run for a couple of minutes before turning on heavy loads such as the air conditioner To stop the generator first shut down all heavy loads let the generator run for a few minutes to cool down then press the STOP bottom side of the rocker switch The hour meter keeps track of how many hours your generator has been running This is important for servicing intervals such as oil changes etc See your Cummings Onan generator service manual for details There is a break in oil change after the first 20 to 50 hours of use You alSo need to exercise your generator every month by running it for an hour under moderate load 2014 by Roadtrek Inc HOWTO Setting Up Your Campsite 93 HOWTO Setting Up Your Campsite What Do You Need To Hook Up In a Roadtrek the answer to this question Is a lot less than you think Rather than slog through the setup ordeal that Class As and fifth wheels and other trailers go through Class Bs are much more nimble We travel light and can set up and pack up in minutes Let s look at the differences in these different types of units and see why Most big rigs and trailers don t really have a self contained philosophy they re basically like sticks and bricks homes
4. The standard configuration includes a 750 watt inverter This inverter provides 120 volt AC household current for a few of the outlets in your Roadtrek primarily the ones running the TV and the DVD player It is not powerful enough to operate the air conditioner or the microwave The inverter is configured at the factory for the batteries and power sources in your Roadtrek Please do not change any settings without consulting the factory Optional 2500 Watt Inverter If your vehicle has the engine generator option you also have a 2500 watt inverter This is sufficient to run all your appliances However running large high energy appliances such as Inverter switch with standard 750 watt inverter microwave ovens air conditioning toasters etc drains your batteries very quickly If you operate these appliances do so for a limited time unless you also have additional sources of power 2014 by Roadtrek Inc Electrical System 58 Instead of the regular inverter switch on the monitor panel your inverter switch will be on its own smaller panel to the left of the main monitor panel The switch has three positions off in the middle position power save auto in the top position and power save off in the bottom position e In the power save auto setting when you re not using anything T Laas with 120 volt power the inverter will put itself to sleep In this owe Saver mode it still uses a small amount of po
5. e Plan your trip Then use this quick checklist e The day before your trip e charge your batteries by plugging in overnight e cool your refrigerator by turning it on e chill any beverages in your home refrigerator e fill your fresh water tank with clean tap water e The day of the trip e Load the refrigerator with cold food from your home refrigerator 2014 by Roadtrek Inc Coming Home Coming Home When you come home there are a few maintenance tasks you should do to get your Roadtrek ready to go for next time Refer to other sections in this manual for the procedures listed here On your way home dump the gray and black tanks at a convenient facility See the HOWTO Waste Water Dumping section for a concise description of the procedure to do this Some RV parks and gas stations will let you dump for a fee some city wastewater plants will let you dump for free but there is no real pattern so local knowledge is vital in locating dump stations The website http www sanidumps com is a good resource The maps for each state and province are especially helpful http www sanidumps com maps help php At home flush the water tanks and fill them with fresh chlorinated water if you will be using it in the next few days Otherwise drain the tank Don t let water you are planning to use sit in your tanks for more than a week or so and don t let ANY water sit in your tanks for more than two weeks whether you plan on using
6. The 210 has an exhaust fan in the bathroom Turn the white handle to open and close the vent and turn on the fan by pushing the power button Outside Shower The outside shower is located on the driver s side towards the rear wheel See Outside your Roadtrek for more details on location 2014 by Roadtrek Inc Appliances 32 Appliances TV and DVD player TV Bracket release DVD player The TV and DVD player are located in the rear on the passenger side Both the television and the DVD player use 120 volt current so the inverter generator or shore power must be used They are supplied with remote controls See the HOWTO Cable and TV Reception for antenna connections and configuration details 2014 by Roadtrek Inc Appliances 33 Antenna and Cable Connections There are two antenna connections in the cabinet above the DVD player One is labeled for the antenna the other for cable TV Connect the cable to the appropriate jack Rear speaker control switch Controlling the Rear Speakers The surround sound system offered in your Roadtrek allows you to control the rear speaker sound in your vehicle Locate the Speaker switch which can be found in the cabinet above the home theater system e Surround Setting Allows back speakers to function as part of the TV home theater system e Off Setting Turns the rear speakers off e Automotive Setting Connects the rear speakers to the front dash radio
7. BBQ quick disconnect is regulated to 10 P S I Please ensure that all devices connected to this are either rated for high pressure or have their own regulator Many grills sold in the United States are low pressure 1 2 P S I and will require an additional regulator to step the pressure down to a useable level If hooked directly to the BBQ quick disconnect they will be a severe fire hazard PROPANE LEAK DETECTOR Do not block the air circulation in the area where the Propane Leak Detector is located PROPANE LEAK DETECTOR Battery disconnect switch must be in the ON position for the propane detector to function 2014 by Roadtrek Inc Do s and Don ts FLAMMABLE Do not store gasoline or other flammable liquids inside your vehicle X LIQUIDS AND GASSES HEATING Never use cooking appliances or unvented propane heaters for space heating purposes They need fresh air for safe operation HEATING The heating furnace provides its own outside combustion air and exhausts to the outside HEATING Portable fuel burning equipment including wood charcoal and liquid fuel grills and stoves should not be used inside your vehicle Use of this type of equipment inside your vehicle may cause a fire or asphyxiation CARBON MONOXIDE LEAK DETECTOR Do not block the air circulation in the area where the Carbon Monoxide Leak Detector is located x i i I CARBON MONO
8. Check tire pressure including your spare Check coolant level in the coolant recovery reservoir Check windshield washer fluid brake fluid and power steering fluid levels Check operation of all exterior lamps including brake lamps turn signals and hazard warning flashers At Least Every Three Months Flush black water holding tank Use a hose or bucket to fill the tank through the toilet and dump Flush grey water holding tank Use a hose or bucket to fill the tank through the galley sink and dump Flush and sanitize fresh water tanks To flush the tanks fill them completely using the gravity fills open the tank isolator valve and drain using the freshwater tank drain underneath the right side of the driver s doorsill It will sometimes take an hour or more for the internal tank to drain through the external tank You can speed the process up by selecting the internal tank with the tank selector lever and running the water pump and the outside shower faucet Remember to put it back to the exterior tank after you re done Sanitize by adding 1 2 cup chlorine bleach to each tank fill with water let sit for at least two hours and drain 1 2 cup vinegar added to the next tankfulls which will also be drained before filling with fresh water for use will help dissipate the chlorine smell Information on the location of these valves is in the HOWTO Potable Water Use section 2014 by Roadtrek Inc Maintenance 72 Exterior ta
9. Vehicle is free from defects in material and workmanship on the portion manufactured by Roadtrek Motorhomes under normal use and service for five 5 years from date of purchase by the first Purchaser or the date the Vehicle was first put into service for example as a demo or rental whichever is earlier This warranty shall be fulfilled at a Roadtrek Motorhomes Dealer or authorized Roadtrek repair facility For in transit emergency repairs you may choose to deal with a non authorized RV service facility However all warranty repairs at non authorized RV service facilities must be preauthorized by Roadtrek Motorhomes Roadtrek Motorhomes will at its option replace or repair free of charge including related labor any defective part about which the Purchaser shall notify their Roadtrek Dealer within the warranty period The obligation of Roadtrek Motorhomes under this warranty is expressly limited to such replacement or repair The provisions of this limited warranty shall not apply to the following 1 Accident 2 Unauthorized repairs or alterations 3 Normal maintenance 4 Changes made to other units manufactured after this Vehicle was manufactured This is not an engineer upgrade warranty 2014 by Roadtrek Inc Warranty 80 5 Incidental damages connected with the failure of the Vehicle such as lost time inconvenience loss of use of the Vehicle cost of rental cars gasoline telephone travel or lodging 6
10. Winterizing Switching from Summer to Winter Mode To change from summer to winter mode you perform the following steps e Open the enclosure under the driver s side bench just to the left of the refrigerator and close the tank isolator valve connecting the two fresh water tanks by turning the black plastic handle so that the handle is across perpendicular to the water line pointing toward the rear of the vehicle e Drain the exterior tank by opening the valve under the driver s door step The valve is open when the black plastic handle is aligned with the water line It may take several minutes for the water to drain out Tank isolator valve in closed position Exterior tank drain located under the black plastic handle pointed toward the driver s door step To open the valve and back of the vehicle This valve is located drain the tank turn the handle so that it inside the enclosure under the driver s points along the water line side bench 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 127 e Run the water pump briefly to drain water from the water line to the exterior tank then switch the tank selector valve from the exterior to the interior tank ie saj ae Tank selector valve in exterior tank Tank selector valve in interior tank position colored plastic handle pointed position with the colored plastic handle toward driver s side of Roadtrek This pointed up valve is located inside the
11. an hour meter to the right of the switch which displays hours of generator use Maintenance on the generator is scheduled according to hours of use There is a break in oil change scheduled fairly early in your generator s use so check your Onan manual for particulars A Please be sure to operate the generator at half load or more at least 1200 watts either the heat pump or an electric heater for one hour every month Failure to do this can lead to internal corrosion gumming up of the float bowl and eventual failure Shore Power GENERATOR START HOURS jmo incompatibile with E 85 fuels Run generator with regular unloaded gasoline only 31 OP PRIME Generator switch and hour meter The shore power connection is through the shore power cord stored in the driver s side large compartment See Outside your Roadtrek for location The switchover from shore power to inverter is automatic To connect to external Shore power open the side compartment and remove the power cord Plug the power cord into the campsite 30 amp power source See HOWTO Shore Power for a concise guide on how to connect and disconnect to shore power 2014 by Roadtrek Inc Electrical System 60 Outlets The outlets are operated from the inverter generator or shore power Further the outlets are protected by GFCI Only some of the outlets are powered by the standard 750 watt inverter The electrical outlets above the galley
12. discharge hose and black and gray tank valves in the front of this compartment 2014 by Roadtrek Inc HOWTO Waste Water Dumping 108 r g A e EA aN Waste water discharge pump switch on Extending the hose base of driver s seat e Open the driver s door and locate the waste water pump switch It is a red pushbutton located on the driver s seat base e Remove the waste water discharge hose from storage There is a strap holding the lid on pull the hook and loop strap to open the lid 2014 by Roadtrek Inc HOWTO Waste Water Dumping 109 Open the dump hose valve Weigh the hose down to prevent accidents 2014 by Roadtrek Inc HOWTO Waste Water Dumping 110 e Open the valve on the end of the sewage discharge hose e Insert the waste water discharge hose outlet into the dump Station waste receptacle e There are two ways to secure the hose in the dump station waste receptacle four inch pipe In the white box that came with your Roadtrek there is a rubber doughnut which goes over the discharge nozzle and can be wedged into the waste receptacle to hold the waste water discharge hose in place Some RV parks require you to use a doughnut If you trust gravity more than friction or don t want to store the doughnut between uses use a rock to weight the hose down Either way make sure the hose doesn t get loose when you turn the pump on Q The discharge stream is forceful and will knock the
13. ey If you are experiencing problems with your TV reception while using the over the air antenna check to ensure the connection to the antenna signal booster located in the cabinet above the home theater system is plugged in ey To ensure power is getting to the antenna check to see if the blue indicator light on the antenna is illuminated and that the indicator light on the power injector in the cabinet above the TV is illuminated 2014 by Roadtrek Inc Appliances 34 Hot Water The 210 Popular is equipped with a 6 gallon water heater The heater requires both 12VDC and propane for proper operation See Monitor Panel for location and operation of the switch for the heater Refer to the Owner s Manual for maintenance Refrigerator The refrigerator is a 3 way electric and propane model which that runs on DC battery power AC shore generator power or propane Propane operation allows you to operate your refrigerator for weeks on one tank of propane while boondocking but cannot be used while the vehicle is in motion While driving operate the refrigerator on DC 12 volt power the vehicle alternator generates more than enough power to run the refrigerator and keep your batteries charged while driving You can use AC when plugged into shore power when you don t want to use propane unnecessarily X Never run your refrigerator on propane while at a gas station Shut the refrigerator off while at a gas station and turn it back
14. hose out of the drain if you do not weight it down or secure it in the drain with the doughnut It is much easier and more Rubber doughnut installed on nozzle sanitary to secure it before turning the pump on than it is to chase it around afterwards 2014 by Roadtrek Inc HOWTO Waste Water Dumping 111 Open the black valve Open the gray valve e Open the black water tank gate valve by pulling the black handle out It will come out approximately 3 inches 8 cm and stop e Press and hold the waste water discharge pump button until the tank is empty e Close the black water tank valve by pushing in on the handle e Open the grey water tank gate valve by pulling the grey handle out It will come out approximately 1 1 2 inches 4 cm and stop e Press and hold the waste water discharge pump red button until the grey waste tank is empty e Close the gray tank valve by pushing it back in to the original position A Always dump the black tank first and the gray tank second The graywater will help flush any remaining solids from the dump hose e Close the valve on the end of the waste water discharge hose e Rinse off the dump area and the waste water discharge hose e Return the waste water discharge hose to its storage compartment Close its lid with the hook and loop fastener strap e Add about gallon of fresh water to the black tank While you re doing this add a packet of black holding tank chemicals to the tank
15. monitor panel switch Go outside and take the cover off the water heater Pop open the pressure relief valve at the top of the water heater A small amount of water might flow out x If water is gushing out continuously STOP Go back to the beginning of this guide DO NOT remove the anode rod until you figure out what s going on You either left the water pump on or you are hooked up to city water 2014 by Roadtrek Inc HOWTO Water System Winterizing 139 Water Heater Anode Water heater anode with some corrosion but probably cleanable and usable for another year e Drain the water heater by removing the anode rod You will need a 1 1 16 socket and a ratchet or breaker bar A This is a good time to rinse out the water heater and inspect the anode rod If the anode rod looks spongy or all that is left is a rusty iron rod throw it away and buy and install a new anode rod Use teflon tape on the threads to reinstall the anode rod Do not overtighten 2014 by Roadtrek Inc HOWTO Water System Winterizing 140 F I T aa 7S a ae ae wy a Ji Y loos l a Water heater bypass valves in the Water heater bypass valves in the bypass unwinterized normal position position e The water heater bypass valves are in the cabinet under the sink on the left wall Set the valves to the by pass position see photo The middle valve the one on the horizontal water line connecting the two vertical lin
16. on wheels which require what campgrounds call full hookups electricity water and sewer connections at each campsite to function Roadtreks have big fresh water and holding tanks that the other types of RVs lack so it s usually easier just to plug into the electricity and not bother with the water and sewer hookups This makes your hookup procedure a five minute process park in a level spot and plug in Maybe hook up the cable TV too if they have it at the campsite but that s about it It s a different philosophy because most large RVs plunk down and don t move once they get to a campsite They have a towed vehicle or the truck they haul their trailer with to take short trips around the area Since you don t have a tow vehicle like z the big rigs you need to be able to head out to the store orgo n _ sightseeing in your Roadtrek so the less elaborate the set up EEEE RE TE EE Full hookups electric water and sewer plus lots of and pack up procedures the better company 2014 by Roadtrek Inc HOWTO Setting Up Your Campsite 94 Connected Fresh Water vs Using your Tanks There s no real advantage to leaving the water hooked up all the time it s easier just to get your hose out and fill your tanks and then put the hose away No leaks no hose to trip over no need to disassemble and store all that stuff when it s time to hit the road again In a campground with shower faciliti
17. on 12 volt DC after pulling away from the pumps To ensure that neither your hot water heater nor your refrigerator generate dangerous open flames while handling fuel always turn the battery disconnect switch OFF when refueling Refer to the Owner s Manual for details of operation 2014 by Roadtrek Inc Appliances 35 Oven The oven is a standard microwave convection oven It operates much the same as the microwave at your house It is probably lower powered so cooking may take a bit longer You must 120V AC power available to use the microwave See Electrical System for details Stove The propane stove needs fresh air for its safe operation Make Sure to open a window and open turn on the overhead fan for proper ventilation Refer to the Owner s Manual for details of operation Galley stove 2014 by Roadtrek Inc Outside your Roadtrek 36 Outside your Roadtrek Awning T i N A Wd Awning power switch Awning attachment Stoved awning Your Roadtrek has an electric roll up awning The control for the awning is located above the passenger door on the inside To open the awning push the rocker switch and the awning will extend Lower the supports on each side and secure them to the two attachment points on the side of the Roadtrek Refer to the awning manual for the proper way of securing the awning Supports to the attachments To stow the awning detach the supports stow them in
18. propane tank is mounted outside the vehicle and will vent propane where it can dissipate any tank inside the vehicle will vent into the passenger compartment creating an explosive propane air mixture inside the enclosed space which also contains many potential sources of ignition 2014 by Roadtrek Inc HOWTO Propane System 124 gt 4 To reduce the danger of fire or explosion do not store gasoline or other flammable liquids inside your vehicle In a moving vehicle containers get tipped over or jostled and leak and flammable vapors will create an explosive air vapor mixture inside your passenger compartment which also contains many potential sources of ignition A Purchase propane from a reputable propane facility Contaminated propane is a common cause of system failure Q The auxiliary BBQ outlet is regulated to 15 P S I If you are using an external grill with this hookup ensure that the appliance is rated for that pressure or has its own regulator for lower pressure 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 125 HOWTO Summer and Winter Mode Summer and Winter Mode The 190 and 210 Popular models have the capability to operate in mildly sub freezing conditions provided the water system is properly configured To better understand this it is best to know how the plumbing is configured The diagrams below show how water is supplied in each mode Solid triangles are closed valves hollow triangles are
19. rearview mirror area folding mattress To set up a front bed with the optional folding mattress turn the front passenger side captain s seat so that it is facing outward toward the front door remove the second row seat back by lifting it up and place the folding mattress on the front and second row seat bottom cushions When the front seat is in position facing the door slide it as far back toward the center aisle as possible to accommodate the folding mattress This configuration is only possible with the standard bathroom enclosed bathroom models do not have the second row seat 2014 by Roadtrek Inc Bathroom Facilities 27 Bathroom Facilities Enclosed Bath Toilet Shower curtain 2014 by Roadtrek Inc Bathroom Facilities 28 Toilet pedal Bathroom door pin Door The bathroom doors are secured by a pin in each door To secure the doors for driving close the left door first then the right door and then push the pins down so that they engage behind the lip at the front of the bathroom floor This will prevent the doors from swinging open when the vehicle is in motion Toilet The enclosed bathroom in your Roadtrek contains a marine toilet To flush the toilet press the foot pedal located at the bottom of the front of the toilet bowl 2014 by Roadtrek Inc Bathroom Facilities 29 Shower Shower connection and knob Shower curtain track To take a shower uns
20. substitute for formal training or instruction x Do not attempt to fill the tank unless you have had appropriate training Reading this manual does not constitute sufficient training to safely fill propane If you overfill the tank propane will vent uncontrollably out of the relief valve Attach the fill hose to the fill valve open the bleeder valve slightly and fill the tank to 80 capacity The stop fill valve should automatically stop the filling process You may also see liquid propane spit out of the bleeder valve Stop filling immediately and close the bleeder valve We recommend that you use only propane from certified LPG retailers 2014 by Roadtrek Inc HOWTO Propane System 122 Propane relief valve RELIEF a ae SP et Pl ME DISA EA h A Painan ied we i g E Propane relief valve Propane gauge and sender Under no circumstances should anyone fill the tank to more than 80 capacity doing so can cause liquid propane to flow into the regulators If this happens the regulators will have to be replaced The relief valve with the blue plastic cover will automatically vent propane if the tank is overfilled or overheats This is not a user serviceable item never attempt to remove the cover test or otherwise interfere with the operation of this valve Sometimes an overfilled tank will not start venting until the temperature rises If this valve should open it is best to remove all sources of ignition and
21. t have solar panels it would be prudent to check your coach battery state of charge every month or so and charge them if necessary If you don t turn everything off even with solar panels you will probably come back to dead batteries That s it You re ready for the next trip 2014 by Roadtrek Inc Interior Living Space 12 Interior Living Space Cabinets Cabinet latches in your Roadtrek are different from the ones in your home and more like those on boats they have to stay closed when the vehicle is in motion The cabinet doors are secured with latches located along the edge of the cabinet door Run your fingers along the edge and you will find the latch Press the latch in and open the door To close a cabinet door shut it gently until you hear the latch click shut You may need to press on the latch to get it to latch closed A Do not slam the cabinet door in order to latch it this will damage the latch Do not keep large round and or heavy objects in a cabinet unsecured they will roll around and apply excessive pressure to the inside of the cabinet doors as you drive Even if the force of such objects doesn t break the latch they can shift position with vehicle motion and be leaning against the inside of the cabinet door waiting to fall when you open the cabinet For this reason Roadtrek recommends that you not store anything in the overhead cabinets that you wouldn t want to get hit over the head with
22. to sleep In this mode it still uses a small amount of power If you turn on a 120 volt appliance it senses a load and will come back on in about 20 seconds If you select power save auto you ll reduce the electricity it takes to keep the inverter powered and your batteries will require less recharging 2500 watt inverter switch ey The inverter checks for a load by turning on the power briefly and checking if appliances are connected This can cause some appliances such as the microwave to turn on and off If this happens either unplug the appliance or turn the inverter off or on 2014 by Roadtrek Inc HOWTO Monitor Panel 89 Pressing the bottom of the switch selects power save off When this setting is selected the inverter will be on continuously There is a shore power indicator light to the right of the switch to tell you the system is receiving shore power There Is also a battery charging indicator light to tell you when the batteries are being charged by shore power Patio Light On the monitor panel the top left switch is the patio light switch Press the top of the button to turn the lights on and the bottom to turn them off These are LED lights and use very little power fill p Hig TEE I a a Patio light switch Water pump switch on blue indicator light lit 2014 by Roadtrek Inc HOWTO Monitor Panel 90 Water Pump Switch The centered switch to the right of the leftmost
23. tunnels on ferries and on bridges Please follow all local restrictions in all the jurisdictions along your trip Some bridges tunnels ferries require you to have your main tank valve closed This valve must be closed whenever the vehicle is in motion in any case not just in certain areas Other bridge tunnels ferries ban vehicles with propane tanks entirely Plan ahead and take an alternate route if passing through areas where vehicles with propane are prohibited 2014 by Roadtrek Inc HOWTO Propane System 119 Propane Tank Location The propane tank is located across the rear of the vehicle To access the tank for filling and to turn the manual tank shutoff valve off and on turn the two retaining tabs on either side of the access cover located in the center of the rear bumper and remove the access cover Main Shutoff valve 5 PROPGHE PIPIRG STSTER LF NESIGHRED POR USE Wl PROUPANF Ta Oo HET Tl i Sys COMHEST HATURGL GAS TEM Im ome T es P a r r ae Ot Pi ly S A Par aa a a a Laat p O ae on ra Pe oy cay Pee is ae aly hi t t eee at Maree L ane a a ae a ee See ee vie ore E pon i Tag n Propane tank cover Propane tank main shutof X You must close the tank shutoff valve when the vehicle is not in daily use Further you must close the shutoff valve when the vehicle is traveling Never operate any propane appliance while the vehicle is in motion The propane tank valve operates reverse from the conve
24. Damages caused by environmental factors including but not limited to hailstorms tornadoes sandstorms stone chips lightning floods earthquakes airborne fallout chemicals tree sap ocean spray road hazards 7 Vehicle that has been declared a total loss by an insurance company demolished or a Vehicle whose title indicates that It is designated as Salvage Junk or rebuilt or words of similar impact 8 Exterior side storage compartments may not be moisture free It is advised that you store items accordingly Roadtrek Motorhomes is not responsible for goods damaged while stored in exterior storage compartments 9 There will be no allowance for emergency road repair towing labor meals accommodations etc Such will not be accepted if claimed under warranty 10 Aluminum wheels are not warranted against corrosion that is a result of road salt sea salt cleaning chemicals or harsh driving conditions The provisions of this limited warranty shall not apply to deterioration due to wear and exposure beyond the following limitations 1 For ninety 90 days after the QualityCare Pre Delivery Report is completed by the dealer for appliance adjustments door latch adjustments light bulbs fuses battery in the smoke detector and window screens After 90 days these items are considered part of normal maintenance 2 For one 1 year from the date of original purchase sewage hose curtain fabric seating fabric carpet cup holders ext
25. ERATOR The generator cannot run all the appliances at the same time 2014 by Roadtrek Inc Do s and Don ts WASTE WATER STORAGE AND DUMPING SYSTEM Close both the black and gray water gate valves before using the waste water system FREEZING Under moderate subfreezing conditions antifreeze is required in the exterior fresh water tank black and gray waste water tanks Use RV antifreeze in accordance with the manufacturer s instructions ELECTRICAL This unit has 12 volt 110 volt and potentially 36 volt solar system These systems need to be SERVICING disconnected before working on them GENERATOR The generator is not compatible with E 85 fuel If the vehicle is equipped with a generator avoid the use of E 85 fuel TLA ENGINE BATTERY The Chevrolet engine battery will be drawn down by the GM electronics to a no start condition if left unattended for extended periods Plug the vehicle in drive the vehicle for at least three hours every two weeks to keep the engine and auxiliary batteries charged or disconnect the engine battery to keep it in good condition Battery maintenance is the vehicle owner s responsibility 2014 by Roadtrek Inc Before you head out Before you head out Your new Roadtrek is ready to go with just a little bit of preparation To prepare for your first trip you should e Read this manual e Contact your dealer with any questions
26. It controls the heating and cooling in the vehicle This single thermostat controls both the electric heat pump and the propane furnace Heat Pump The heat pump can provide both heating and cooling for your Roadtrek using electric shore power or generator power The heat pump gives you the advantage of heating your unit with electricity if you would prefer to use electricity rather than the propane the furnace uses The heat pump can be operated normally when you are plugged in to shore power If you are running the heat pump using the generator please follow the following steps e Set the battery disconnect switch on the monitor panel to the ON position e Start the generator and run for several minutes until warm e Set thermostat setting above ambient temperature e Turn thermostat control to the low cool position e Turn fan to the ON position 1 a lt e Adjust the thermostat on the unit for the desired temperature Heat pump The compressor should start automatically e Your vehicle should be parked as close to level as possible to maximize the air conditioner s efficiency If you are parked very much off level it is possible for condensate to leak into the living space If this happens park in a more level location 2014 by Roadtrek Inc Heating and Cooling 53 You can use the heat pump to warm the motorhome on cool nights For colder temperatures below 40 F 4 C you should use the propane
27. Owner s Manual 210 Popular Roadtrek Inc PDF generated at Thu 04 Sep 2014 14 12 27 EDT Contents Articles Introduction Copyright Do s and Don ts Before you head out Coming Home Interior Living Space Sleeping Facilities Bathroom Facilities Appliances Outside your Roadtrek Utilities Propane System Heating and Cooling Electrical System Monitor Panel Distribution Panel Alarms and Warnings iO CO W N e 12 23 27 32 36 44 49 52 54 61 66 67 Maintenance Spare Tire Storage Obtaining Service Specifications Warranty Registration Regulatory Notices HOWTO HOWTO HOWTO HOWTO HOWTO HOWTO HOWTO HOWTO HOWTO HOWTO Monitor Panel Setting Up Your Campsite Shore Power Potable Water Use Waste Water Dumping Cable and TV Reception Propane System Summer and Winter Mode Water System Winterizing De Winterizing 70 74 76 71 79 83 85 86 93 97 101 106 113 118 125 134 143 Introduction Introduction Congratulations on the purchase of your Roadtrek and welcome to the Roadtreking family The information included in this manual is meant to help and guide you through the use of your vehicle so that you know how to properly use the many functions your Roadtrek has to offer Please keep this manual in your vehicle as a reference for when you are travelling If you have any questions or comments on information found in this document please contact us at manualS roa
28. XIDE LEAK DETECTOR Battery disconnect switch must be in the ON position for the Carbon Monoxide Leak Detector to function i 110 VOLT ELECTRICAL SERVICING Prior to servicing the 110 volt Galley GFCI amp Audio Video cabinet interior receptacles unplug the output lead from the power inverter EXTERIOR ACCESS DOORS Ensure the shore power cord and city water supply lines are disconnected and in their stored positions before the vehicle is put in motion 2014 by Roadtrek Inc Do s and Don ts 7 AWNINGS Close the sliding side door prior to opening or closing the awning CLOVERLEAF The cloverleaf dining table is heavy Use proper lifting techniques DINING TABLE EXTRA COUNTER SPACE Make sure the stove is off and has cooled prior to lowering the stove cover BATTERY Battery acid can burn your skin and damage clothing Protective eye wear and gloves should be worn while handling batteries Effective June 2010 all Roadtrek installed batteries are sealed AGM batteries that do no require the addition of water BATTERY Disconnect the inverter charger prior to disconnecting the auxiliary battery GENERATOR Never submerge the generator Use a spotter when launching a boat or crossing streams GENERATOR When using the generator as the main power source to run the appliances refer to the generator owner s manual for proper use and maintenance GEN
29. adtrek Inc HOWTO Cable and TV Reception 115 Over the air TV To watch TV using the Roadtrek rooftop antenna e Have 120 volt AC power available inverter on OR shore power plugged in OR generator running e Turn on TV and home theatre system e Make sure the power injector is on the barrel connector is plugged into the top of the injector e Set the speaker selector to SURROUND e Set the antenna cable TV switch to Antenna LY 0 m r w T sj ai z r z 5 mMm Fa i F z Ja p Dg m 5 ii 2 i DVD To watch a DVD e Have 120 volt AC power available inverter on OR shore power plugged in OR generator running e Turn on TV and home theatre system a a e Set the speaker selector to SURROUND Antenna cable AB switch set for antenna top button Cable TV To connect your Roadtrek to cable TV at a campsite or even in your driveway first locate the Roadtrek s cable TV connection inside the rearmost driver s side compartment behind the rear wheel It has a square gray plastic cover about 3 cm on each side which is hinged at the top and opens to expose the barrel connector the cable hooks to You need a length of coaxial TV cable to reach from the cable TV outlet to your Roadtrek s connection point These are sold in electronic supply and camping supply stores and come in lengths of 25 50 and 100 feet The cable is typically sold as RG 59U or RG 6 with F type connectors The RG 6 is preferabl
30. and under the passenger side rear captain s seat have ground fault circuitry GFCI the button in the middle of the outlet pops out when they sense an anomaly or sometimes when the circuit undergoes transitional conditions If you are not getting power from an outlet check and reset this button if needed The outlet under the passenger side chair powers the TV and DVD player so check it if your TV is not receiving power GFCI outlet under rear passenger side seat 2014 by Roadtrek Inc Monitor Panel 61 Monitor Panel The monitor panel is located inside the side door above the doorframe to the left of the bathroom Power Sources The monitor panel controls 2 separate power sources the 12 ite a volt DC power and the 120 volt AC power via the inverter shore i power or optional generator aye ee Mel eE ash s is ra E ran PA ge S or kisi a t c a he ts EAN HEN PEEP BA a I GENERATOR START Fa F 7 ri TAREE OF VaI F f 12 Volt DC Power The power to the 12 volt DC outlets and appliances is controlled by the battery disconnect switch to the lower left On the bottom left is the battery disconnect switch which supplies 12 volt battery power to the 12 volt light and other cabin appliances This switch must be on for any of the 12 volt electrical devices to work Remember to turn off two switches the inverter switch and the battery disconnect switch when your Roadtrek is not being used to avoid
31. ase of the cylinder Fire extinguisher 2014 by Roadtrek Inc Maintenance 70 Maintenance Tires See the automotive chassis manufacturer s owner s manual and documents for tire warranty information Inflation pressure information is on the sticker inside the galley cabinet door The current Chevrolet Express manual recommends checking tire pressures regularly at least every month and definitely before a long trip Tire rotation intervals depend on wear and other factors but the current Chevrolet Express manual recommends tires should be rotated at least every maintenance interval every 12 000 km 7500 miles Follow the tire rotation pattern in your owner s manual Cargo Carrying Capacity See the information labels attached to the driver door post and the inside of the lower galley cabinet door Owner Maintenance Checks Listed below are vehicle maintenance checks and inspections that should be performed by the owner or qualified service technician at the indicated intervals Any adverse conditions should be brought to the attention of your dealer or qualified service technician for expert service advice as soon as possible The owner maintenance checks are generally not covered by warranties and you may be charged for labor parts and supplies used 2014 by Roadtrek Inc Maintenance 71 When You Stop for Fuel or Weekly Check engine oil level Look for low or underinflated tires At Least Monthly
32. asive material Rinsing the panel a couple times a year to remove excess dirt is all you need to do to keep the panel operating at full output At Least Once a Year Lubricate all door hinges locks and latches especially the exposed hinges on exterior doors These will freeze up and cause damage to the doors if neglected Have appliances tested and cleaned Wax polish and protect exterior surfaces The wheels are coated aluminum not bare aluminum therefore do not use aluminum polish on any surface of your Roadtrek The wheel center caps are chrome To prevent water from entering your vehicle avoid spraying water directly into exterior vents or grills Do not use a power washer to clean your Roadtrek damage to the paint removal of decals and water leaks will result Hand washing or commercial car washes accommodating large vehicles are the best way to keep your Roadtrek clean 2014 by Roadtrek Inc Spare Tire Storage 74 Spare Tire Storage Rear Door Spare Tire Spare tire retaining pin ey Supplied with your new Roadtrek are two types of small keys One is for the storage compartments and the other is to unlock the chrome surround on your spare tire Find both keys put one of each on your key ring and carry them with you whenever you drive your Roadtrek If you ever need to change a tire you will need this key T If your new Roadtrek still has the blue coating on the chrome spare tire cover remove it as so
33. at the top of the leg fits into the socket underneath the table Store the table top under the cushion with the socket seated in the hole in the side bench base and return the table leg to the proper location and clip into place for proper storage 2014 by Roadtrek Inc Interior Living Space 18 Front Captain s Seats The two captain s seats in the front of your 210P are adjustable fore and aft by pulling up on the bar under the front of the seat and will swivel when the swivel tab the black metal bar on the side of the chair base is pulled up Always return the seats to the forward facing position when driving They will lock into this position and stay locked until the swivel tab Is raised again To create a front lounge area loosen the recline adjustment and move the backs of the seats to a vertical position Do not attempt to pivot a reclined seat Use the fore and aft adjustment while swiveling the seats to allow the sides of the chairs to clear the armrests on the vehicle doors the engine cover and other obstructions Do not force the seats around Swiveling the driver s seat may require you to loosen the tilt steering wheel adjustment and move the steering wheel as far forward and up as possible Opening the front doors slightly will facilitate clearance of the door armrests Front seat swivel tab just below lumbar support control Second Row Seat If you have the standard bathroom you have a third seat
34. carrier and reattach the chrome surround X Do not attempt to raise an empty tire carrier if you change the tire put the flat on the carrier before attempting to raise it NEVER release the latch on a tire carrier without a tire on it The spring will move the arm of the carrier upward with great force and speed 2014 by Roadtrek Inc Obtaining Service 76 Obtaining Service When your Roadtrek needs service determine if the issue is with the Roadtrek upfits or the GM Chassis For Roadtrek upfits contact your Roadtrek dealer For chassis related issues contact GM service Advise the service writer that you have a G 30 1 ton van rather than a motorhome Some GM dealerships do not want to work on _ motorhomes but most can service a 1 ton van 2014 by Roadtrek Inc Specifications 77 Specifications For general chassis specifications please refer to the GM manual For specifications relating to your vehicle including occupancy weight rating tire size inflation and so on refer to the sticker on the driver s side B pillar right side of the door frame near the latch This specification refers to the Roadtrek upfits Roadtrek upfits only 4 AA R Sticker on driver side B pillar with passenger capacity chassis weight and tire specs your sticker will be different 2014 by Roadtrek Inc Specifications 78 Total fresh water capacity includes water heater 36 gal
35. crew the drain stopper in the center of the bathroom floor Release the hook and loop fastener straps retaining the shower curtain and slide the shower curtain along its track to enclose the shower space Attach the shower hose to the water outlet just behind the bathroom sink faucet handles and pull up on the knob on the faucet spout Adjust the water to the correct temperature There is a water cutoff on the shower head to help you conserve water while showering You can shower in the enclosed bathroom by pulling the shower curtain across the shower curtain track near the bathroom doors or you can shower in the aisle by extending the shower curtain around the longer loop of shower curtain track which goes around the ventilation fan in the roof and opening the drain in the aisle by removing the flat cover plate and unscrewing the drain stopper 2014 by Roadtrek Inc Bathroom Facilities 30 Shower curtain Shower curtain deployed for aisle Aisle shower drain deployed for enclosed shower bathroom shower When finished either air or towel dry the curtain before storing it refasten the drain stopper to prevent the contents of the gray water tanks from sloshing up into the shower area while driving and remove the shower hose from the sink connection Push the knob back down to change the sink back into normal mode 2014 by Roadtrek Inc Bathroom Facilities 31 Exhaust fan Outside shower connection Exhaust fan
36. d perpendicular to the water line when your water system Is in self contained mode 2014 by Roadtrek Inc HOWTO Potable Water Use 104 Two Tank System in Self Contained Mode There are two fresh water tanks in your Roadtrek the internal tank under the passenger side bench and the external tank under the driver s seat Each has its own gravity fill on the rear door passenger side door frame and driver s door frame respectively a Front exterior tank gravity fill Rear internal tank gravity fill There is a manual valve to select which tank your water pump draws water from There is also a water line connecting the two tanks with a manual valve on it so when this line is open water drains from the higher internal tank to the lower external tank In non freezing weather the easiest way to use the system is to leave the valve on the line connecting the tanks open and set the tank selector valve to draw water from the lower external tank As you use water from this tank water from the internal tank replenishes it by gravity so you can use all of the water from both tanks simply by filling them up and turning on the water pump To access the tank selector valve and the tank isolator valve open the door on the side of the driver s side bench facing the aisle just to the left of the refrigerator The tank selector valve has a long plastic covered handle usually either yellow or red When this handle is vertical the tank selec
37. discharging the batteries The battery disconnect switch has a blue indicator light to the right of it to show you when the battery power is on Monitor Panel with standard 750 watt inverter and optional gasoline generator 2014 by Roadtrek Inc Monitor Panel 62 Battery Disconnect Inverter switch for standard 750 watt Inverter switch for optional 2500 watt inverter inverter Inverter The inverter provides 120 volt AC household current to the 120 volt appliances and wall outlets If you have the optional engine generator and 2500 watt inverter your inverter switch is back by the thermostat on the passenger side of the rear lounge area See the Optional Engine Generator and 2500 Watt Inverter portion of the Electrical System section for further information 2014 by Roadtrek Inc Monitor Panel 63 Shore Power Shore power is the name for power supplied by a utility company that you plug into to provide power to your Roadtrek See HOWTO Shore Power for a concise guide to plugging in and unplugging from shore power Other Switches Patio Light On the monitor panel the top left switch is the patio lights switch Press the top of the button to turn the lights on and the bottom to turn them off These are LED lights and use very little power qian rere wees TL et em a Patio light switch Water pump switch 2014 by Roadtrek Inc Monitor Panel 64 Water Pump S
38. dtrek com M or 1 888 ROADTREK References 1 mailto manuals roadtrek com 2014 by Roadtrek Inc Copyright Copyright This manual is released under a Creative Commons Attribution NonCommercial NoDerivatives 4 0 International License lH In Summary you may e Copy any portion of this manual in any form for personal use e Distribute this manual complete with all of its original unmodified content e Modify this manual for your own personal non commercial use You may not e Use this manual for any commercial use whatsoever e Modify this manual except as provided for in the full license and then distribute the resulting work e Charge for this manual other than reasonable media and shipping costs All images used in this manual remain the property of Roadtrek Inc They are for illustrative purposes only and may or may not be representative of the upfits in your Roadtrek Contact Roadtrek Inc for alternate licensing arrangements if you want to use or distribute this manual commercially References 1 http creativecommons org licenses by nc nd 4 0 2014 by Roadtrek Inc Do s and Don ts Do s and Don ts Symbol Legend ey For your information May be useful information to know A Warning Not following this can lead to bad results Caution You really should follow this to avoid bad results X Don t do it Doing this can result in injury severe damage or death Information cautions a
39. e 2014 by Roadtrek Inc Alarms and Warnings 67 Alarms and Warnings iW te m afer to ure Re ai for CO mple uxiliary gt ia details attery an ma VARNING aeoe ma EAR OPERATION ste ace E AFTER PER W Falne Sus NG DBE a aT Lens ONCE Propane and CO alarm Smoke alarm Propane and CO alarm Your vehicle has been equipped with a combination propane leak and carbon monoxide detection device for your protection It is located slightly above floor level directly behind the rear bathroom door on the passenger side of the vehicle Be sure the detector is operating while using your vehicle especially when you are asleep inside it When storing things on the floor do not block air circulation to the propane leak detector You should be able to see it at all times from the front of the vehicle The detector runs on 12 volt power and is operational whenever the battery disconnect switch is on There is no separate switch for the detector There is an indicator light on the detector so that you can tell whether it s working or not For this reason whenever the vehicle is occupied the battery disconnect switch should be on the on position Q Coach power on the Monitor Panel must be on for detector operation Make sure your battery disconnect switch is on 2014 by Roadtrek Inc Alarms and Warnings 68 Do not disable unplug or otherwise hinder the operation of this detector A The detector has a
40. e and wait 10 minutes Slowly turn on the propane turning the main valve 1 4 turn a minute until the valve is open Check for propane smell as you turn on the valve Once the valve is open turn on the stove and try to light it If air entered the line it may take a short time to purge the air out of the line If you still have no propane at the stove and you detect no propane smell have a qualified technician check the system About Propane Propane fuel is colourless heavier than air and smells like garlic or rotten eggs The odor is added by the distributor so propane may smell differently as you travel and purchase propane from various distributors Being heavier than air it will collect in low spots and along the floor of your vehicle lf you smell propane or your propane detector sounds immediately get all occupants out of the vehicle and turn the manual shutoff valve off Wait for the propane to dissipate Once the smell is gone take the vehicle to a qualified repair facility to find and fix the problem before using the propane system again If closing the manual shutoff valve does not stop the propane leak and you still smell propane do not attempt to start drive occupy or otherwise use the vehicle in the presence of a propane smell x Propane tanks must not be placed or stored inside your vehicle Propane tanks are equipped with safety devices which relieve excessive pressure by discharging gas to the atmosphere The Roadtrek s
41. e but either will work 2014 by Roadtrek Inc HOWTO Cable and TV Reception 116 TV cable connected AB switch selected for cable bottom button Screw the cable onto the barrel connectors at each end If you route it through the mousehole in the bottom right side of the compartment floor you can close the compartment door without crimping the wire Push the bottom button on the A B switch in the cabinet above the TV The bottom button connects your TV to the cable connection and the top button connects it to the over the air signals from your rooftop antenna 2014 by Roadtrek Inc HOWTO Cable and TV Reception 117 Speaker Switch The speaker switch is located in the same cabinet as the i PET Cable Antenna switch You can select Surround Off or a 99 5 ai Sane T rahe ee Automotive In the Surround position the rear speakers the speakers above the bed will work with the TV home theatre system In the Off position the speakers are off In the Automotive position the Speakers are connected to the dash radio Rear speaker switch 2014 by Roadtrek Inc HOWTO Propane System 118 HOWTO Propane System Your vehicle is equipped with a propane system which when properly handled and maintained will provide trouble and worry free operation of your propane fueled appliances Regulatory Concerns Many jurisdictions place restrictions on propane on highways in
42. e skepticism especially it there s a wastewater dump nearby Large RVs use hoses to flush their wastewater system Always flush faucet and hose thoroughly before use 2014 by Roadtrek Inc Utilities 47 City Water Your Roadtrek can operate in either fully self contained mode or can be connected to a water supply such as a campsite s faucet The city water connection is in the driver s side rearmost compartment Unscrew the white plastic protective cap and connect your clean hose to the water faucet and a water pressure regulator attached to this connection point Turn the faucet on and check for leaks tightening the connections as necessary For more details please refer to the HOWTO Potable Water Use section Summer and Winter modes The water system in your Roadtrek has an exterior and interior water tank In summer mode above freezing both tanks can be used In mildly sub freezing conditions the exterior tank must be drained and the system set to winter mode See the HOWTO Summer and Winter Mode for a concise description of how to operate your system in either mode In temperatures lower than mildly sub freezing or any freezing temperatures when the Roadtrek is not constantly heated you must winterize Summer Use In summer mode both the interior and exterior tank are used to store fresh water The tank isolator valve in the water line connecting the two tanks is open and water is drawn from the exterior tank by
43. eatre system This consists of a TV a DVD player the speaker system and the radio in the dash along with a rooftop TV antenna and a cable TV connection The TV and home theatre system are located in the rear on the passenger side The Cable TV Antenna switch and power injector for the built in antenna are in the cabinet just above the DVD player The TV and the home theatre system must be on to use the system Both the television and the DVD player use 120 volt current so the inverter generator or shore power must be used Refer to the Electrical System for instructions on 120 volt AC power The TV and DVD are supplied with remote controls The home theatre system has inputs for media devices Read the Owner s manual for full details gt a zx i DVD player The TV is stowed against the wall on a hinged bracket The bracket is secured with a large thumbscrew Turn the thumbscrew horizontally to release the bracket and vertically to secure the bracket to the wall Once released you can swing the TV to a comfortable viewing position A Always stow the TV with the bracket secured to the wall for travel 2014 by Roadtrek Inc HOWTO Cable and TV Reception 114 r i a E a s ETY z 1 F 1 at tat ai xy a i ar F a Se Eu miu i 4 r h inig C ee eunian J g Aa A i l h Eal are a A 7 a i her 2 ae i TV antenna switch and power injector Rear speaker switch 2014 by Ro
44. een in place and the door open They may take themselves for a walk 2014 by Roadtrek Inc Utilities 44 Utilities Just like your house your 210 Popular has fresh water electricity waste water disposal heating and cooling systems In the 210 Popular these systems are self contained and travel with you Your vehicle should be reasonably level to allow normal operation of the system Fresh Water Standard Edition Fresh water is contained in two tanks called the exterior and interior tanks The exterior tank is underneath the driver s seat outside the passenger compartment and thus exposed to the elements so it is susceptible to freezing The interior tank is inside the Roadtrek underneath the passenger side bench and will allow you to carry and use water in mildly sub freezing conditions Tank isolator valve shown in open City water connection position black plastic handle pointed along the water line 2014 by Roadtrek Inc Utilities 45 The two tanks are connected by the tank isolator valve located in the compartment under the driver side bench to the left of the refrigerator There are two fill locations a Pe y Exterior tank fill location driver door Interior tank fill location rear door right pillar side e The fill for the exterior tank is in the door post of the front driver door near the door handle Look for the orange plug in the fill port With the tank isolator va
45. enclosure under the side bench just in front of the tank isolator valve e Open the lid on the side bench enclosure by removing the side bench s cushion and table to expose the hinged lid Undo the Robertson head screw to raise the lid Once you know where these valves are you can just open the access door on the front but it s best to unscrew the top to give you a full view if you re not familiar with these controls 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 128 JF m E 5 3 i fa ON apie dm gat ee 4 k niri a n E k Lid raised to expose valves and water pump Screw to open water valve enclosure e Close the two shutoff valves going to the outside shower faucet These valves are visible through an access hole in the enclosure floor just to the rear of the other valves To shut these valves turn them so that the black plastic handles are across the water line 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 129 ee gt a i a gt p Outside shower valves shown closed Outside shower valves shown open e Open the outside shower faucets to drain the water from the lines There will be no water pressure just let the small amount of water remaining in the lines dribble out Leave these faucets open In winter mode remember that you need to keep the interior temperature at least 60 degrees F 15 C by running the propane furnace or heat pump and keep the wa
46. erior stripping and decals running board trim propane regulators and black and grey water tank valves After one year these items are considered part of normal wear and tear and maintenance Roadtrek Motorhomes Limited Motorhome Warranty is void unless the following conditions are adhered to 1 Warranty Card on Vehicle must be completed by the Dealer and faxed to Roadtrek Motorhomes within 48 hours of date of retail delivery When warranty applications are made and Warranty Card is not on file at Roadtrek Motorhomes reimbursement of claim will be delayed until proof of original purchase is submitted to Roadtrek Motorhomes 2 Warranty claims and authorization requests should be submitted using the Electronic Warranty Management system found on the Dealer Website Including the last 8 digits of the Vehicle Identification Number V I N and odometer reading All claims must be submitted within 30 days of the date of repair 3 Warranty work that will exceed 200 must first be authorized by Roadtrek Motorhomes before proceeding with such work The authorization number issued by Roadtrek Motorhomes must be noted on the warranty claim See item 2 above 4 Roadtrek Motorhomes reserves the right to inspect defective parts that have been replaced under warranty Dealer is expected to hold selected parts for a period of not to exceed 60 days See below 2014 by Roadtrek Inc Warranty 81 5 Only parts and accessories and other materia
47. es should be turned in line with the tubing All handles should have been pointing vertically in the normal summer use position Turn each handle 90 degrees to a horizontal position to achieve the bypass position e Check to be sure that the fresh water drain on the exterior tank and the black and and gray tank valves are all closed Move the single lever galley faucet all the way to the cold side and leave it open e Add 1 1 2 gallons of non toxic RV approved antifreeze to the interior tank and 1 2 gallon to the exterior tank through the gravity fill Use a funnel and wash any spillage off the paint Put the tank selector switch in the exterior tank position handle horizontal pointed toward driver s side of vehicle e Turn the water pump on and allow to prime Close cold galley sink faucet once you see pink antifreeze coming out Switch the plastic covered tank selector handle to the interior tank position e Move the single lever galley faucet to the hot side and run until you see pink antifreeze come out Open both hot and cold faucets in the bathroom sink Open the toilet valve Open the hot and cold faucets on the outside shower Leave the outside shower valves open or open them if you were in winter mode Observe the antifreeze flow through all fixtures then close each fixture Ensure antifreeze flows into all P traps galley sink washroom sink and shower You may also consider adding antifreeze from the extra gallon in the container jug t
48. es your water supply will last for days and when it runs out you just get the hose back out fill it up again and you re ready for another few days Sewer Hookup vs Dumping The advantage of using your tanks for fresh water over a more permanent water hookup is that you re automatically reminded of when your waste water tanks are full When you re close to running out of fresh water that means it s time to dump your wastewater tanks With a more permanent hookup the reminder may be waste water backing up in your sink or toilet which is not nearly as pleasant The tank level indicators only tell you to the nearest third what your tank levels are Since you have a waste water discharge pump the big rig s semi permanent giant sewer hose on an inclined pathway to the dump won t work for you you have to run the pump anyway so why not just dispense with all that unsightly and potentially hazardous plumbing Full hookup sites have a handy sewer dump right at your campsite When your fresh water runs low refill your fresh water tanks dump your waste water holding tanks and you re good to go plus you can drive off anytime merely by stowing your electrical cord 2014 by Roadtrek Inc HOWTO Setting Up Your Campsite 95 Simplify Simplify Campgrounds capitalize on the helplessness of non self contained RVs by charging a premium for full hookup sites You aren t helpless With an electric only hookup you drive a short dis
49. ese LED lights use very little energy and a good way to conserve battery power is to use them rather than the fluorescent lights whenever possible 2014 by Roadtrek Inc Interior Living Space 15 Tables Rear dining area There are front and rear tables to use either the front or rear lounge Front lounge area areas for dining playing cards or computer use 2014 by Roadtrek Inc Interior Living Space 16 Front Table Front table in cabinet The front table top slides out from the galley cabinet It does To stow the front table slide it back into the cabinet not have a table leg i Front table in place 2014 by Roadtrek Inc Interior Living Space 17 Rear Table Table leg stowed Rear table T Nut Rear table set up for use The rear tabletop is stored under the driver s side rear bench seat and its leg is stored within the wardrobe The dining table for the rear seating area is located under the driver s side rear bench cushion directly across from the TV Lift the cushion and remove the table top The table leg is stored in the narrow ledge above the passenger side door Unscrew the T nut on the end of the leg fully Insert the T nut into the slot in the table leg base Rotate the leg clockwise until you feel it tighten Pull on it to check that is is secured If not extend the T nut fully by unscrewing it and try again Place table top on the table leg so th
50. expeditiously leave the area until propane odor is no longer detectable Venting unburned propane is a slightly more advantageous situation than a tank explosion which is what this valve is designed to prevent Propane Sender The propane tank has a level indicator with a remote sender to the Monitor Panel Both the three light system on the monitor panel and the gauge on the tank will give you a rough idea of your propane level you will get a more accurate indication when you fill up Note the amount it takes to fill your tank The ten gallon tank in your Roadtrek will hold eight gallons 30 4 liters when completely empty and filled to the correct 80 full level Subtract the amount you buy from this number and you ll know how much was in the tank when you filled it You may find that the gauge will read one light when you still have a 2014 by Roadtrek Inc HOWTO Propane System 123 considerable reserve or you may find that empty means empty and you d be wise to refill as soon as it goes down to one light It depends on the characteristics of your individual propane system Slam shut valve The propane system is equipped with a slam shut valve If this valve detects a sudden increase in flow as if from a ruptured line or a shock as if from an accident the valve will shut down the propane system If you detect no propane flow and you have checked that you have propane in the tank shut off all appliances shut off the main valv
51. for those places where finding a level spot is difficult These are available in most camping supply stores or can be ordered online They go under your tires and can be stacked in various combinations to lift the low corner or end of your vehicle enough to get comfortable Many Roadtrek owners install a small bubble level in an inconspicuous place visible from the driver s seat to assist with the leveling process How level is level Refrigerators that run on propane require a fairly level setting to operate properly since the refrigerant relies on gravity to circulate Your unit has such a refrigerator Check the manual for the specific leveling requirements for your unit but in general if it s level enough to be comfortable for you it s probably good enough for your 3 refrigerator Front to back leveling is more important than side to side Leveling blocks leveling If you have a choice it s better to have the front of the Roadtrek very slightly higher than the back both for shower drainage and heat pump condensate drainage 2014 by Roadtrek Inc HOWTO Shore Power 97 HOWTO Shore Power Connecting To Shore Power Your Roadtrek has a shore power cord which is permanently attached inside the rear driver s side compartment behind the rear wheel Open this compartment and pull the cord out to attach to the campsite or house electrical outlet There is a notch in the lower right edge of the compartment floor to allow you
52. four switches is the water pump switch It should be on only when you have water in the fresh water tanks and wish to use the sinks showers or toilet The pump should not be run without water As with the patio light switch pressing the top of the button turns the pump on and pressing the bottom turns it off Water Heater Switch The water heater switch is to the right of the water pump switch As with all the other switches on the monitor panel the battery disconnect switch must be on for the water heater to work Even though the water heater uses propane to heat the water all the igniters and controls are electrical Be sure that the water heater is full of water before turning it on if water comes out of the hot water faucets when they are opened the water heater has water in it After turning it on the red light to the right of the switch will come on for a few seconds than go off as the burner ignites If the light keeps going off and on your burner is not lighting Make sure that you have propane in your propane tank and that the main valve is open If the stove burners light your propane supply is good Piney HELA TAM EE DAT PESH MIIE BLA G E a Water heater switch and red indicator Tank level indicators light 2014 by Roadtrek Inc HOWTO Monitor Panel 91 Tank Levels and Battery Charge Indicator To the right of the monitor panel switches are the indicator lights for the battery charge level the propa
53. furnace Heating Standard Propane Furnace The furnace is controlled by the combination thermostat located above the rear bed The furnace requires propane and 12V power The furnace uses minimal electricity compared to the heat pump and can be used without shore power or generator use Keep the aisle in front of the furnace clear of any obstructions when using the furnace to allow air circulation The furnace can operate when outside temperatures are below freezing 2014 by Roadtrek Inc Electrical System 54 Electrical System Coach Batteries The coach batteries in your Roadtrek are sealed AGM absorbed glass mat batteries Do not attempt to open them There is no user maintenance possible on these batteries except keeping them charged Battery Disconnect Switch The battery disconnect switch provides power to all 12 volt appliances such as the water pump the refrigerator and so forth Even the propane cooktop uses 12 volt power to run the burner igniters This switch should be off when you are not using your Roadtrek and on whenever you are driving or camping The Battery On light next to it will indicate the position of the Switch a Roadtr Charging your batteries Inverter Charger Your Roadtrek is equipped with a inverter charger which converts 120 volt AC household current to 12 volts DC when you are connected to shore power or running the optional Battery disconnect switch gasoline generato
54. g relay connecting the coach batteries to the electrical loads If you hear a clunk clunk or nothing at all it s possible that your batteries are depleted to the point where they cannot drive the relay The best way to charge your batteries in this situation is to start your vehicle engine and try again after it has charged for a while Once the relay is working you can continue to charge with the generator or shore power Inverter Switch Just as the battery disconnect switch powers the lights fan and other 12 volt electrical loads the standard inverter takes 12 volt power from your coach batteries and changes it into 120 volt electricity It powers some of the smaller 120 volt alternating current loads such as the TV and DVD player This is the regular electricity you have in your house With this inverter you can watch television or play a DVD while you are camping without the need to plug into shore power or run your generator The inverter is rated for 750 watts maximum output Larger loads such as the air conditioner or microwave are too big to run on the power produced by the inverter and will not operate unless you plug in to shore power or start your generator The inverter will shut off if you try to draw too much power through it 2014 by Roadtrek Inc HOWTO Monitor Panel 88 The inverter switch is on the left side of the monitor panel above and to the right of the battery disconnect switch It has an indicator
55. generator is charging the batteries to avoid exhaust entering the vehicle s interior The engine generator is charging the coach batteries whenever the vehicle s engine is in operation which means you are also charging them as you drive You will arrive at your camping destination with fully charged coach batteries There is no required maintenance for the engine generator Engine generator Note however that your vehicle s serpentine belt the belt which drives the vehicle s alternator water pump power steering etc will be different than the one for similar vehicles without the engine generator so carrying a spare belt may be prudent in case you have a serpentine belt failure while traveling 2014 by Roadtrek Inc Electrical System 56 Optional Solar Panels The optional solar panels will charge your batteries when Sufficient sunlight is available The solar charge controller is installed at the factory for the type of panels and batteries installed on your vehicle and Roadtrek strongly recommends that you make no adjustments or changes to the charge controller or its programming The charge controller usually displays either system voltage or amperes generated by the panels ge hts Sat Sree SE 4 nee see gd ee z eg A ate Aei 2 C iss Solar charge controller 2014 by Roadtrek Inc Electrical System 57 On board 120 Volt AC power Standard 750 Watt Inverter
56. ger side in the rear The seatbelts for the power sofa are attached to the floor behind the power sofa In order to use the power sofa as a seating position while driving these seat belts must be threaded up through the gap between the seat back and bottom and used together with the shoulder belts to secure passengers in these seating positions 2014 by Roadtrek Inc Sleeping Facilities 24 Twin beds King bed A Make sure that there are no obstructions in the travel path both above and below the sofa Q Do not ride the sofa while it is moving 2014 by Roadtrek Inc Sleeping Facilities 25 Twin Beds You create two twin beds by lowering the sofa The sofa makes a continuous sleeping surface with the two bench seats leaving the center aisle to make it easy to get in and out of bed King Bed Making the king bed Bed board in place To make a full size bed slide the panel under the passenger side bench seat out into the open space between the two bench seats and secure it into the notches on the two inner surfaces of the bench seat bases Move the bottom cushion for the bench seats together over this panel and place the vertical cushions for the bench seats between these and the outer walls of your Roadtrek 2014 by Roadtrek Inc Sleeping Facilities 26 Optional Folding Mattress for Front Bed Front captain s seat in position for Folding mattress in position View from
57. gerator e stove e toilet e water pump e macerator e water heater While still within the terms of the appliance warranty Purchaser and or Dealer are required to deal directly with the nearest service center for such manufactured components and abide by the warranty policy as allowed by such component manufacturers 2014 by Roadtrek Inc Warranty 82 Propane or Gasoline Generator The generator is covered by the manufacturer s warranty 1 The generator warranty may be voided if the manufacturer s maintenance and run requirements are not met AGM Battery Warranty Batteries are warranted by the battery manufacturer for one year from the In Service Date of the Roadtrek 1 Warranty is voided if AGM batteries are tampered with topped off with distilled water or allowed to sulfate or freeze due to lack of charge Warranty Intent The intent of this extended warranty is to assure the new owner of a Roadtrek that it is worry free from manufacturer caused defects for the first five 5 years of use The first owners of this unit can feel comfortable that Roadtrek is behind them for five 5 years 2014 by Roadtrek Inc Registration Registration Please send this form in or email the information to sales roadtrek com 1 when you purchase your Roadtrek CHANGE OF OWNER NAME OR ADDRESS FORM PLEASE TYPE OR PRINT LEGIBLY 5 VEHICLE IDENTIFICATION NUMBER 17 character number found on top left of instrument
58. icle is in motion in any case not just in certain areas Other bridge tunnels ferries ban vehicles with propane tanks entirely Plan ahead and take an alternate route if passing through areas where vehicles with propane are prohibited There is a BBQ quick connect pigtail secured behind the access cover This will allow you to connect a high pressure grill or burner to the propane supply of your Roadtrek If you close the main tank valve it is possible for the distribution lines to fill with air It may take a while for propane to fill the lines again The fridge and water heater handle this automatically for the stove you can hear the difference between propane and air We recommend that you use only propane from certified LPG retailers Please note that the tank can only be filled to 80 Capacity If you smell propane or your propane detector sounds immediately get all occupants out of the vehicle and turn the manual shutoff valve off Wait for the propane to dissipate Once the smell is gone take the vehicle to a qualified repair facility to ip i LIA find and fix the problem before using the propane system again High pressure BBQ pigtail If closing the manual shutoff valve does not stop the propane leak and you still smell propane do not attempt to start drive occupy or otherwise use the vehicle in the presence of a propane smell The relief valve is underneath the tank with a circular blue plastic cover and will automatically
59. it from the bottom will not allow you to remove it from the doorframe surround Optional Side Door Screen In addition to the rear door screen there is alSo an optional side door screen which will allow you to keep the side door open for ventilation without admitting insects There is a zipper in the screen so you can enter and exit without removing the screen a Aree You can access the underbed storage area without removing the screen 2014 by Roadtrek Inc Outside your Roadtrek 42 Hook and loop fastener for the side door screen Installed sc pa i reen 2014 by Roadtrek Inc Outside your Roadtrek 43 Locate the screen in the white box that comes with your new Roadtrek and shake it out To orient the screen correctly look for the zipper in the screen hold the screen so that the zipper goes across near the top and then down the right side Start the hook and loop fastener at a convenient corner and work your way around the perimeter until the screen is secured To enter or exit the vehicle through the side door while the screen is installed unzip the opening and step through There is a zipper tab on either side so you can fasten it behind you once through While sturdy enough to keep insects out neither this screen nor the rear screen are designed to resist repeated and persistent attempts by pets to get out of the vehicle Do not leave your pets unattended with the scr
60. it or not Over time the chlorine goes away and the microbes come out to play To flush the tanks fill both of them using the gravity fills in the driver s doorframe and rear passenger side doorframe make sure the tank isolator valve is open and open the fresh water tank drain under the rear of the driver s doorstep It may take an hour or so for all the water from the rear internal tank to drain out through the front tank you can speed the process by putting the tank selector valve on the internal tank turning on the water pump and opening the outside shower faucet 2014 by Roadtrek Inc Coming Home 10 Tank selector valve in interior tank Tank isolator valve in open position position e Plug in overnight to fully charge batteries e Turn off and clean out the refrigerator and prop the door open to let it air out 2014 by Roadtrek Inc Coming Home 11 e Turn off two important switches to keep from draining your batteries e the battery disconnect switch on your monitor panel e the inverter switch either on your monitor panel with the standard inverter or just to the left of it on the separate inverter switch if you have a big inverter HakmihHi a Battery disconnect switch Standard inverter switch Inverter switch for 2500 watt Inverter If you turn everything off and you have solar panels the panels will keep your coach batteries topped up while your Roadtrek is parked outside If you don
61. just inside the side door Enclosed bathroom models do not have this seat The second row seat has an adjustment to the seat back and bottom cushion to change the seat back angle for more comfortable seating The back lifts up and is held by a pin in a slot see photo below The seat bottom cushion can be lifted and moved forward approximately three inches 8 cm to its alternate position because of the way it is mounted to the seat base Moving the bottom cushion forward and flipping the small panel at the base of the seat back out will configure the second row seat in a more reclined position 2014 by Roadtrek Inc Interior Living Space 19 Second row seat back pin and slot Back seat configured in reclined position 2014 by Roadtrek Inc Interior Living Space Ventilation Your Roadtrek is equipped with a ceiling mounted ventilation fan Mer 1 The fan has a cover that must be raised by turning the large knurled knob before the fan will operate Raise the cover then turn the switch to the desired speed x a The fan also has a thermostat which will allow you to set the A temperature at which the fan comes on If you want the fan to operate at all temperatures turn the thermostat all the way toward the blue section of the dial m J a r ri a p Knurled Knob to raise lid_ There is also a fuse in the body of the fan in addition to the fuse in the distribution panel Chec
62. k both this fuse and the one on the 12 volt fuse panel if your fan stops working For more details please refer to the Fantastic Fan manual A When using the aisle shower leave the fan off or the Shower curtain will be sucked in and stick to you Exhaust fan 2014 by Roadtrek Inc Interior Living Space 21 Window Treatments Skylight covers Curtains Curtain rails and clips 2014 by Roadtrek Inc Interior Living Space 22 The skylight windows in your Roadtrek can be covered using the covers stored above the side door Place the cover against the glass and use the locking tabs to hold it in place The smooth side faces the interior of the cabin the side with the smaller panel attached goes toward the glass The window curtains for the regular windows slide on tracks It s best to use two hands one at each track to pull curtains closed and open The curtains have snaps and clips at the end of the track to hold them in place The front curtain meets in the middle and is secured with hook and loop fasteners along this edge 2014 by Roadtrek Inc Sleeping Facilities 23 Sleeping Facilities Your Roadtrek has beds that can be configured as a king bed or twin bed Experiment with different configurations to find what works best for you Power Sofa Power sofa switch Power sofa The switch to lower the sofa into the bed position is located next to the thermostat on the passen
63. l available through Roadtrek Motorhomes are to be used in the performance of warranty service Express shipping costs are not covered by this warranty policy 6 Warranty repairs performed a second time by a Dealer due to incorrect or inadequate diagnosis improper assembly or repair or lack of proper testing when the original warranty repair was performed are considered as shop comebacks and are not reimbursable Costs of such repairs must be adsorbed by the Dealer 7 Purchasers are responsible for presenting their vehicle to a Roadtrek Dealer as soon as problem exists The warranty repairs should be completed in a reasonable amount of time from date of authorization This limited warranty is expressly in lieu of any other expressed or implied warranty including any implied warranty of merchantability or fitness for a particular purpose and of any other obligations or liabilities on Roadtrek Motorhomes which neither assumes nor authorizes any other person to assume for it any other liability in connection with Vehicle manufactured by it Appliance Warranty The following are not warranted by Roadtrek Motorhomes but are covered by individual warranties offered by their respective manufacturers to which terms both Purchaser and Dealer must comply e air conditioner e electrical inverter charger e electronic equipment TV DVD player in dash radio etc e furnace or other heating system e hydronic heating system e microwave oven e refri
64. light inside it that comes on to let you it s on If you are not using any 120 volt electricity turn the inverter off to conserve battery power since it uses a small amount of electricity even when it s not powering any appliances The inverter will also shut off if the battery voltage falls below a certain level This is to protect your batteries wiring and the inverter itself from damage Your battery voltage drops under load so it is possible to have the inverter cut off under high load when the battery voltage is normal with no load If this happens try turning off any power hungry appliances and trying again Things like electric toasters electric curlers and hair dryers or anything else that produces heat are usually energy hogs Most appliances have the wattage indicated on a label somewhere on the appliance With practice you will learn what you can and can t run within the 750 watt limit Inverter Switch With Optional Engine Generator and 2500 Watt Inverter Instead of the regular inverter switch on the monitor panel your inverter switch will be back in the rear lounge area on the passenger side just to the right of the thermostat The switch has three positions off in the middle position power save auto im ee 8 i ae M i chine ay in the top position and power save off in the bottom position a b nr a In the power save auto setting when you re not using anything with 120 volt power the inverter will put itself
65. lons 136 liters Fresh water tank capacity Gray water tank capacity Black water tank capacity Battery type Battery Capacity Propane tank size Propane tank capacity at 80 Water heater capacity Furnace Refrigerator Air Conditioner 30 gallons 114 liters 23 gallons 85 liters 10 gallons 38 liters AGM maintenance free 190 amp hours standard 440 amp hours optional 10 gallons 38 liters 8 gallons 30 liters 6 gallons 28 5 liters 16 000 BTUs hour 3 way propane 12VDC 120VAC 10 200 BTUs hour 2014 by Roadtrek Inc Warranty 79 Warranty Chassis Manufacturer s Warranty The automotive Chassis is warranteed by General Motors Please refer to the Chevrolet Warranty Information booklet for details All automotive service maintenance and repairs are to be performed by any Chevrolet dealer See the Chevrolet Warranty Information booklet for details Such items are not warranted by Roadtrek Roadtrek will pay for the removal and reinstallation of motorhome components necessary to perform automotive recalls and warranty for the duration of the original manufacturer s warranty After this period such costs are considered to be inherent in the ownership of such a vehicle and Roadtrek will not pay for the removal and reinstallation of motorhome components necessary to perform automotive service or maintenance Roadtrek Motorhomes 5 Year Upfit Warranty Roadtrek Motorhomes warrants to the Purchaser that the
66. lve CLOSED handle across the line running water into the fill port will fill the exterior tank only approximately 20 gallons e The tank selector valve determines which tank the water pump draws water from It is a long handle with a plastic cover usually red or yellow in color located in the compartment under the driver s side bench to the left of the refrigerator See photos below for how to position the valve to draw from the exterior or interior tank In summer mode this handle is in the exterior tank position and the tank isolator valve is open 2014 by Roadtrek Inc Utilities 46 ae u g K Tank selector valve in exterior tank Tank selector valve in interior tank position position e To fill the interior tank only close the tank isolator valve and set the tank selector valve to the interior position The interior fill is located in the rear door on the right side With the tank isolator valve closed running water into this fill port will fill the interior tank only approximately 10 gallons e To fill both interior and exterior tanks open the tank connection valve and set the tank selector valve to the exterior position Fill exterior tank first then interior tank T Roadtrek recommends that you use a dedicated single purpose potable water hose These are usually white in color Buy a new one and use it only for filling your tanks and connecting to city water View any hose lying around a campground with extrem
67. m which when properly handled and maintained will provide trouble and worry free operation of your propane fueled appliances Propane fuel is colourless heavier than air and smells like garlic or rotten eggs The odor is added by the distributor so propane may smell differently as you travel and purchase propane from various distributors Being heavier than air it will collect in low spots and along the floor of your vehicle The propane main tank valve must be open to operate gas fueled appliances The propane tank valve has arrows on the handle to indicate which direction is open and which is closed The propane tank is located across the rear of the vehicle To access the tank for filling and to turn the main tank shutoff valve off and on turn the two retaining tabs on either side of the access cover located in the center of the rear bumper and remove the access cover x You must close the tank shutoff valve when the vehicle is not tn daily use Further you must close the shutoff valve when the vehicle is traveling Never operate the refrigerator on propane while the vehicle is in motion 2014 by Roadtrek Inc Propane System 50 Many jurisdictions place restrictions on propane on highways in tunnels on ferries and on bridges Please follow all local restrictions in all the jurisdictions along your trip Some bridges tunnels ferries require you to have your main tank valve closed This valve must be closed whenever the veh
68. nd warnings Level Item Comment SEAT BELTS Use only forward facing seats equipped with factory installed seat belts while the vehicle is in motion All passengers must be seated in these seats only with the seat belts fastened while the vehicle is in motion 7 TV Turn the TV off and stow it while the vehicle is in motion TV The flat screen TV should not be stored inside the Roadtrek in cold temperatures Remove it to A reduce the chance of damage from the cold Check the Owner s Manual for the TV for storage and operating temperatures 2014 by Roadtrek Inc Do s and Don ts TV To remove the TV remove the four mounting bolts on the back of the TV mounting bracket A and remove the RCA cables power supply cable and antenna cable PROPANE Do not store propane tanks inside your vehicle Propane tanks are equipped with safety devices which relieve excessive pressure by discharging gas to the atmosphere PROPANE Do not refuel the propane tank to more than 80 of its capacity PROPANE The propane tank valve must be closed and ALL PILOT LIGHTS APPLIANCES AND THEIR IGNITERS MUST BE TURNED OFF during refueling of the motor fuel tank and or the propane fuel tank Only qualified personnel should refuel your propane tank PROPANE Purchase propane from a reputable propane facility Contaminated propane is a common cause of system failure and is not covered under any warranty PROPANE The
69. ne tank level the fresh water tank level for each of the two tanks and the black and gray water tank levels Press the button for each to see the display These will give you an approximate reading to the nearest third of how much is in each tank Roadtrek recommends that you keep a small amount of water in your gray and black tanks at all times This will reduce the likelihood of material sticking to the inside of the tank The four indicator lights for the battery are low fair good and charging Battery voltage dips under load the greater the load the greater the voltage dip A battery under heavy load will show much lower state than one at rest The propane indicators will show full when the tank is at it maximum capacity Because of the safety related need for a vapor Space at the top of the propane tank the maximum fill capacity is 80 of the volume of the tank Your 38 liter 10 gallon propane tank is full when it holds 30 4 liters 8 gallons of propane There is another gauge directly on the tank that you can see behind the propane fill door on the back bumper This gauge has finer gradations and will give you more information about your propane level than the indicator light display will TH y tt apt pi i iIe h 4p a ee ties el tet ay T Saal al dip alle gt gt sie ee ee aah r a 5 t n a Sey zl et E i Generator switch prime off position Generator hour meter 2014 by Roadtrek Inc
70. ng up into the shower pan from the gray water tank while driving Black Tank The black water tanks contains toilet waste Please refer to the HOWTO Waste Water Dumping section for materials you can flush down the toilet Indicators The gray and black water tank level indicators on the control panel will give you an approximate indicator of your tank levels When the gray water tanks ts full to capacity water will no longer drain down the shower and sink drains and you need to dump the tanks before running any more water If you see fluid below the toilet valve in the bowl of the toilet your black water tank is full and also needs to be emptied before further use See Monitor Panel for more information A Close both the black and grey water gate valves before using the waste water system It is possible for the valves to open slightly especially after extensive driving Black and grey water dump valves are accessed through the driver side storage door 2014 by Roadtrek Inc Propane System 49 Propane System THES PROPGHE PPRS SYSTEM H DESIGHKED FOA USEN H PSOPAHF DHG CO HOT CONNECT Bont reg GAS TO THIS ITEM E F E Te en ee er cc fod a e P ee ee a eee ee Ate A ae eit ee n Boir ai J zE ay lth ae ee ial 4 am tr Pal a a T Fot hi roe f at Pak ee mt lg ret a A Pet ak Propane tank cover Propane tank main shutoff fill valve capped with yellow cap ji a J Your vehicle is equipped with a propane syste
71. nk fill location driver door Interior tank fill location rear door right pillar side a Peery Exterior tank drain under driver s Tank isolator valve shown in open Tank selector valve in int doorstep position position as vy erior tank 2014 by Roadtrek Inc Maintenance 73 At Least Twice A Year Check windshield wiper operation Clean wiper blades with clean cloth dampened with washer fluid Wiper blades should be replaced at least once a year Check radiator heater and air conditioning hose for leaks or damage Check for worn tires and loose wheel lug nuts Check parking brake system put the brake on and see if it will hold on a moderate hill If not get it repaired Check head lamp alignment shine your low beam headlights on a wall The light patterns should be the same height Check lap and shoulder belts for wear and function Replace any belts with frayed spots or that do not smoothly retract into their holders Inspect appliance vents to ensure they are free from dirt insects spider webs and or nests Inspect black water tank vent and remove any debris or other obstructions The black water tank vent is on the roof passenger side in the bathroom area Clean air conditioner filter See air conditioner manual for details Thoroughly clean and wax the roof of the van To wash the solar panel use a garden hose to rinse dirt off the panel Do not scrub it with a brush or apply any abr
72. nly recommends the winterizing method outlined above using RV antifreeze 2014 by Roadtrek Inc HOWTO De Winterizing 143 HOWTO De Winterizing If you winterized only for a short time less than a week you can skip to the second step First step You will need 4 gallons of water and 2 cups of fresh bleach Bleach loses its potency over time always start with bleach that is less than 6 months old 1 Close the connecting valve between interior and exterior tanks This valve is located under the drivers side bench seat inside the water valve enclosure Valve connecting the interior and exterior Exterior tank drain under driver s door tank shown closed step 1 Mix up two gallons of water and one cup of chlorine bleach Add to the interior tank fresh water fill on the right rear door doorpost 2 Mix up two gallons of water and one cup of chlorine bleach Add to the exterior fresh water fill the one on the driver s doorpost You now have a chlorine mixture in both water tanks 2014 by Roadtrek Inc HOWTO De Winterizing 144 3 This is a good time to get some stuff for spring cleaning of your Roadtrek so drive around for an hour Let it sit for a couple more hours 4 Open the connecting valve to the exterior tank and let mixture drain into that tank 5 Open the exterior tank drain valve and drain both tanks This can take an hour or so You can speed up the process by putting the tank select
73. ns or so of water for use and will travel lighter with a better weight distribution since your rear axle will be about 85 pounds lighter Every little bit helps Of course once you get to the area where you re going to camp fill up both tanks before you head out boondocking so you can stay out for a longer time without running out of water 2014 by Roadtrek Inc HOWTO Waste Water Dumping 106 HOWTO Waste Water Dumping Wastewater storage and dumping Your house is permanently connected to your septic system or a municipal sewer you don t have to worry about the wastewater you generate because gravity takes it away Your Roadtrek doesn t have that connection and has to hold any wastewater until you have the opportunity to dump it at an approved dump station A Most municipalities have severe penalties for improper disposal of human waste especially into a watershed fines can be several thousand dollars and it s often a felony Even if it s Just gray water it will still flunk a coliform bacteria test because of the common discharge hose which is difficult to explain to a judge Never dispose of wastewater unless you re sure you are at an approved dump station Tanks Your vehicle is equipped with a gray holding tank and a black holding tank The gray tank holds the sink and shower water The black tank holds the toilet waste As a result the black tank is a lot nastier than the gray tank Waste Water Discharge Pump You
74. ntion right clockwise is open and left counterclockwise is closed If you close the main valve for an extended period of time it is possible for the distribution lines to fill with air It may take a while for propane to fill the lines again The fridge and water heater handle this automatically for the stove you can hear the difference between propane and air 2014 by Roadtrek Inc HOWTO Propane System 120 BBQ pigtail Propane pigtail with dustcap removed and valve in open position High pressure BBQ pigtail shown with yellow dustcap and valve in closed position The propane system has a high pressure auxiliary BBQ takeoff Locate the hose behind the access panel The hose has a yellow dustcap and an integral cutoff valve This provides 15PSI regulated propane to appliances that have their own regulators or are built to use high pressure propane The auxiliary BBQ male connector is Cast Products part 829000 The hose assembly in varying lengths is available as MB Sturgis part no 100476 The hose ts available from your Roadtrek dealer 2014 by Roadtrek Inc HOWTO Propane System 121 Propane Tank Filling Propane fill valve To fill the tank first turn off all propane appliances then turn off the tank shutoff valve We recommend that you find a qualified LPG technician to fill the tank The following is an outline of the process to help you understand and not intended to be complete nor to
75. o the shower floor pan trap 2014 by Roadtrek Inc HOWTO Water System Winterizing 141 vice ge Valves for outside shower lines shown Valves for outside shower lines shown open closed e If the water pump loses its prime in this process add more antifreeze to the interior fresh water tank e Open the grey and black waste tank valves and operate the waste water discharge pump for about 10 seconds You should see pink antifreeze coming out of the waste water discharge hose 2014 by Roadtrek Inc HOWTO Water System Winterizing 142 City water connection valve shown Water pump filter inside water heater closed enclosure e Turn the city water connection valve on The water pump will operate Allow it to run about 20 seconds Turn city water connection valve off e Turn the water pump off and open a galley sink faucet to release back pressure e Open the valve on the water line connecting the two fresh water tanks in the water heater compartment on the floor left side at the base of the large speaker to allow the remaining antifreeze in the interior tank to drain into the exterior tank e Open the fresh tank drain line briefly until antifreeze flows out e Remove water pump filter if so equipped Replace water pump filter lid Winterizing using compressed air Roadtrek recommends against using compressed air for winterizing Other methods of winterizing Roadtrek o
76. of Transportation Washington DC 20590 You can also obtain other information about motor vehicle safety from the Hotline 2014 by Roadtrek Inc HOWTO Monitor Panel 86 HOWTO Monitor Panel The monitor panel is located inside the side door above the doorframe Depending on the options you have there may be a gasoline generator starter switch and hour run meter to the right Battery Disconnect Switch ne amp oe The battery disconnect switch turns the coach battery power off E AAN and on When off it prevents your coach batteries from being sr 2 drained while the Roadtrek is not in use The lights the water pump the fan the refrigerator control board even the igniters for the propane cooktop need 12 volt power from the batteries If something electrical in your Roadtrek doesn t work the first thing to check is to make sure the battery disconnect switch is yay is ra E ran PA ge S or kisi a t c a he ts EAN HEN PEEP BA a I r f n iP on The battery disconnect switch is on the bottom left corner of the Monitor Panel with standard inverter and optional monitor panel To its immediate right is a blue indicator light gasoline generator which illuminates to show you when the switch is on 2014 by Roadtrek Inc HOWTO Monitor Panel 87 mR Battery disconnect switch Standard inverter switch You will hear a clunk as the battery disconnect switch is pressed this is a bi
77. on as you can If left on for an extended period of time particularly in the hot sun it will become very difficult to remove In order to open the driver s side rear door you must lower the spare tire To lower the continental kit spare tire and gain access to the driver s side rear door of the Roadtrek unlatch the retaining Spring and pull the pin out while supporting the top of the tire with your other hand It helps to wiggle the tire back and forth to allow the pin to slide out Place the pin where you won t lose it and grasp the top of the tire with both hands Lower it into a horizontal position to allow the driver s side rear door to open freely The tire will latch when horizontal 2014 by Roadtrek Inc Spare Tire Storage 75 Q While the tire is spring loaded it is still fairly heavy Use proper lifting technique or get help To raise the spare tire back into position lift the guard over the cable mechanism enough for the catch to clear and allow the tire to be raised Raise the tire back up into position and insert the pin Flip the retaining spring over the end of the pin to secure it To use the spare tire lower the tire unlock the chrome surround with the key supplied with your Roadtrek unbolt the tire from the carrier with your lug wrench and lift the tire off the carrier Follow the Chevrolet manual for instructions on the use of the jack and other tire change procedures Install the flat tire on the spare tire
78. open valves Fresh water system in summer Fresh water system in winter mode mode In summer mode both fresh water tanks are in use The interior tank is inside the vehicle and is filled via the gravity fill in the back door frame and the exterior tank is below the vehicle and filled via the gravity fill in the driver s door post The water line between the two Is open so water flows from the higher interior tank to the lower exterior tank as the water pump draws water from the exterior tank In winter mode the line between the two tanks is closed and the exterior tank is drained to prevent it from freezing The outside shower water lines are closed and drained to prevent them from freezing and the water pump draws water from the interior tank which is protected from freezing by cabin heat The hot water heater will also not freeze if left running In this way hot and cold running water continues to be supplied to the galley sink toilet and shower 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 126 A Winter mode and winterized are two different things Winter mode protects the water in the system from mildly sub freezing conditions as long as the Roadtrek is adequately heated and in use If you plan extended stays in sub freezing conditions or if you store your vehicle in freezing conditions you must winterize to avoid damage to the water system To prepare your vehicle for really cold weather see HOWTO Water System
79. or has the shower and cable TV connection 2014 by Roadtrek Inc Outside your Roadtrek 38 Directly above the center access door and below the galley window you will see two vent hatches The rectangular one is for the refrigerator and the square one is for the water heater The water heater will vent hot gasses when the water heater is running Q Do not block either of these two vents Dangerous fumes can enter the vehicle if you do X Since all these sources of open flame are near the fuel fill door on the driver s side please ensure that all propane appliances are off when refueling your Roadtrek In addition to making sure your main propane tank valve is shut whenever the vehicle is stored or in motion turn the battery disconnect switch off when refueling this will disable the water heater igniter the refrigerator igniter and the furnace Propane Access Panel The propane access cover is located in the rear at the center of the bumper Flip the side latches to expose the tank valve and filler 12 PROPGHE PIMRG SYSTEM I NESIGHKED FOR WSF Will PSOPAHF DHAN OO HOT COMMECT Bae cas T 4 Syke Propane access cover Outside shower faucet 2014 by Roadtrek Inc Outside your Roadtrek 39 Exterior Shower The outside shower hose attaches to the faucet inside the rearmost driver s side storage compartment behind the rear wheel This faucet provides hot and cold running water from the same sources as your in
80. or valve on the interior tank turning the water pump on and opening the outside shower faucet until no more water comes out Close the faucet and turn the water pump off This kills any bacteria in the tanks before you distribute them through the entire water system Second step You will need a good supply of fresh water and a cup of chlorine bleach e Close the connecting valve e Fill the exterior fresh water tank approximately 1 2 full adding a cup of chlorine bleach halfway through the filling process x ST f ji 2A D ee i Filling the exterior tank Tank selection valve in exterior tank position City water valve in closed position e Put the plastic covered tank selector handle in the exterior tank position pointed toward the driver s side of the vehicle Turn on the water pump and circulate the dilute bleach solution through the entire system The water heater is still winterized Run water out of all three faucets galley washroom and outside shower hot and cold until you smell 2014 by Roadtrek Inc HOWTO De Winterizing 145 chlorine With the water pump on open the city water valve and let the pump push water through the fill line for a minute or so Close the city water valve e Pull the anode rod out of the water heater and flush out the water heater tank with a hose Install the new anode rod using Teflon tape on the threads and close the pressure relief valve Take the system out of water heater b
81. our use You can purchase a 15A to 30A adapter and connect to an ordinary 15A household outlet Be aware that in those situations you will have limited power compared to a 30A circuit You will be able to run a single large appliance at a time you may need to turn off your air conditioner if you want to use the microwave for example If you exceed the current capacity of the receptacle you may pop the breakers in the pedestal If this happens turn off some appliances and reset the breaker It is also possible that you will find a 50A receptacle Again you can purchase a 50A to 30A adapter In this case your power Should not be limited as you will have the full 30 amps available Although you are connected to a 50A service you can only draw 30A there is no advantage to connecting to a 50A service if a 30A service is available 2014 by Roadtrek Inc HOWTO Potable Water Use 101 HOWTO Potable Water Use Your Roadtrek can operate in either fully self contained mode or can be connected to a water supply such as a campsite s faucet Connecting to a Water Supply The city water connection is in the driver s side rearmost compartment Unscrew the white plastic protective cap and connect your clean hose to the water faucet and this connection point Turn the faucet on and check for leaks tightening the connections as necessary A Campgrounds and municipalities vary greatly in supplied water pressure Before connecting to external wa
82. own in the open i e tanks connected position e Drain the fresh water tanks by opening the black tank isolator valve on the water line connecting the two fresh water tanks in the water valve enclosure under the diver s side bench on the floor and opening the drain for the exterior tank under the driver s door Let this drain for at least 30 minutes Close the valve between the tanks and the drain for the exterior tank 2014 by Roadtrek Inc HOWTO Water System Winterizing 137 Tank selector lever in the exterior position Tank selector lever in the interior position e Switch the plastic covered tank selector lever to the interior tank position handle pointed straight up and turn the water pump back on Put the galley faucet in the cold position and open it If the interior tank is empty the open galley sink faucet should sputter If it emits a steady stream of water the tank is not empty You will need to run the water until it is empty either catching it in a container and throwing it outside or running it down the sink and re dumping the gray water tank Do so if necessary and then turn the water pump off Return the galley sink lever to its open position halfway between hot and cold 2014 by Roadtrek Inc HOWTO Water System Winterizing 138 Water heater cover removal turn tab Water heater pressure relief valve vertically to remove cover e Make sure the water heater is turned off on the
83. panel 2 PRINT Last Name including Jh Sr etc 3 PRINT First Name or Initial and Middle Name or Initial 4 PRINT NEW mailing Address House Building Number and Street Name including St Ave Rd Ct etc Apt Suite Na gt P O BoxNo of ORR QHOR check one O RR O HCR Box No ZIP Code ZIP 4 Area Code Postal Code A Phone No i oi T 8 Month Day Year Email Address Current Date G H fa Roadtrek Form 2 February 1999 M190204 2014 by Roadtrek Inc Registration 84 References 1 mailto sales roadtrek com AFFIX STAMP Fe Roadtrek 100 SHIRLEY AVENUE KITCHENER ONTARIO N2B 2E1 2014 by Roadtrek Inc Regulatory Notices 85 Regulatory Notices If you believe that your vehicle has a defect which could cause a crash or could cause injury or death you should immediately inform the National Highway Traffic Safety Administration NHTSA in addition to notifying Roadtrek Motorhomes If NHTSA receives similar complaints it may open an investigation and if it finds that a safety defect exists in a group of vehicles it may order a recall and remedy campaign However NHTSA cannot become involved in individual problems between you your dealer and or Roadtrek Motor Homes To contact NHTSA you may call the Auto Safety Hotline toll free at 1 888 327 4236 or 366 0123 in Washington DC area or write to NHTSA U S Department
84. r This 120 volt power is used to power your 12VDC appliances as well as charge your batteries Whenever you are receiving either source of 120 volt power you are charging your batteries iiy Bi iy 2014 by Roadtrek Inc Electrical System 55 Standard Alternator Charger and Battery Isolator While driving your Roadtrek will also charge the coach batteries from the vehicle alternator through a separator The separator allows extra vehicle alternator produced electricity to charge your coach batteries in addition to keeping your engine chassis battery charged When the vehicle engine is not running it breaks the electrical connection between your coach batteries and your engine battery so your engine battery remains charged to start your engine even though you are using coach battery power while camped This is all automatic there are no user adjustments possible to the separator Optional Engine Generator Your vehicle may be equipped with an engine generator The engine generator is mounted on the vehicle engine and is operated by idling the vehicle engine If your coach batteries are low start the vehicle engine and let it idle until the batteries are sufficiently charged Usually 30 minutes of idling are enough to restore moderately depleted coach batteries to a useful level of charge As with a conventional generator always close the rear windows of the vehicle and turn off the roof ventilation fan when the engine
85. r Roadtrek is equipped with a waste water discharge pump to make dumping your tanks easier and cleaner The macerator in this pump grinds up any solids in the system and pumps the resulting wastewater out to the dump station A Do not throw any paper towels personal wipes rags baby wipes tampons hairballs etc into the toilet The macerator is not capable of handling these types of solids and may jam or be damaged Use toilet paper intended for RVs or septic systems A If in doubt take a tissue and leave it in a glass of water Stir with a spoon a couple of times If it falls apart into a gooey slurry after a few minutes it s safe for your tank If it stays together swells up or clumps into a solid mass it s not safe and should be disposed of in the trash and not down the toilet 2014 by Roadtrek Inc HOWTO Waste Water Dumping 107 A If possible you want to dump the tanks after driving as the movement of the vehicle will have sloshed the water in the tanks loosening any solids ey You should dump the black tank first then the gray tank The water in the gray tank is considerably cleaner and will rinse any remaining solids from the hose and the macerator You should dump both tanks in sequence if possible Dumping the tanks le D gil ui Compartment with hose and valves Compartment with dump hose e Open the big access door of the storage drawer the driver s side This will expose the waste water
86. setting the tank selector valve to the exterior tank position As water is used from this exterior tank the interior tank which is positioned higher in the vehicle drains into the exterior tank by gravity thus providing you with full use of the combined capacity of the two tanks The valves to the outside shower are open allowing use of that facility as well Winter Use In winter mode only the interior tank is used to store fresh water The tank isolator valve in the water line connecting the two tanks is closed and the exterior tank is drained The interior water tank has a capacity of approximately ten gallons and this water is protected in moderate sub freezing conditions by the tank s position inside the heated vehicle The valves in the water lines to the outside shower are closed so it cannot be used and neither can the city water connection 2014 by Roadtrek Inc Utilities 48 Again please refer to the HOWTO Summer and Winter Mode section for instructions on how to configure your water system in these modes Water Pump To use the water in the tank you need to turn on the water pump See Monitor Panel for switch location Waste Water Gray Tank Galley sink bathroom sink and shower drain water drains into the gray water tank The shower and sink have traps to prevent tank odors from entering the living space Be sure to replace the screw in plug in the shower floor after use to prevent gray water from sloshi
87. side faucets When finished disconnect and store the shower hose and nozzle Optional Rear Door Screen Roadtreks have an optional rear screen which allows you to open the rear doors and get fresh air and a better view without bugs coming in or attended pets going out If you ordered this option look for this screen in the white box that comes with your new Roadtrek The screen attaches to the rear door frame and cargo area floor with a zipper and hook and loop fasteners a Surround with zipper Hook and loop fastener for bottom edge of screen Open the screen and locate the edge with hook and loop material along it This edge is the bottom so use the hook and loop Strips on the screen to attach it across the bottom of the door opening 2014 by Roadtrek Inc Outside your Roadtrek 40 Start the zipper on the left side Tre Ea Installed screen 2014 by Roadtrek Inc Outside your Roadtrek 41 Start the zipper at each bottom corner by pushing the bottom stop the metal end of the zipper into the two back to back Zipper sliders and zipping the top slider upward At the top close the flap with the hook and loop fastener strip where the zippers meet Use the double slider to unzip the bottom of the screen to allow access to the underbed storage area in the back of the Roadtrek without disturbing the top section To remove and stow the screen unzip it from the top down Unzipping
88. t with calm winds then you don t need to winterize The heat in your Roadtrek is enough to keep the lines from freezing A If the forecast is for extended cold periods with daytime temperatures at or below freezing if you re not heating your Roadtrek or if you expect sustained winds and the roads and ground is already frozen you need to winterize X As always you are final judge and you need to do what is comfortable and makes you feel good If you are not comfortable with leaving water in your lines when it gets cold and you will sleep better go ahead and winterize 2014 by Roadtrek Inc HOWTO Water System Winterizing 135 How to winterize using anti freeze C So 2 i me pe pal ee a j Se ak k ET a8 Water valves enclosure Typical non toxic RV antifreeze This procedure can be done in less an hour with only one specialized tool a 1 1 16 inch 27 mm socket and a ratchet or breaker bar e Get 2 3 gallons of RV antifreeze gt 4 DO NOT use automotive antifreeze It is toxic RV antifreeze is non toxic and safe for potable water lines e Dump and rinse the gray and black tanks if they are not already empty e Turn off the water pump and open your single lever galley faucet putting it in the middle halfway between the hot and cold settings 2014 by Roadtrek Inc HOWTO Water System Winterizing 136 i Freshwater tank drain valve shown closed Location of the tank isolator valve sh
89. tance to the campground s fresh water source and waste water dump every few days Do it on the way to the store or other trip that you re going to take anyway and it s no bother In addition to saving money you ll also have a choice of more campsites since not all of them have full hookups or the even better choice of no campsite at all if you have extra batteries and solar or generator capability or are just careful about your electricity use Freedom from hookups also opens up a whole range of Mion national and provincial forest campgrounds with limited or no hookups to you There is also dispersed camping in national forests and crown lands and other boondocking options where you find your own campsite There are rules for where you can and can t boondock so check the forest websites or drop in the ranger station for information Once you re out there don t look around for those big rigs who are dependent on hookups they re all back in town It s just you and nature with the occasional backpacker Why drive all the way back to town just to smell someone else s woodsmoke Camp where you are 2014 by Roadtrek Inc HOWTO Setting Up Your Campsite 96 Leveling your Roadtrek Roadtreks don t have or need the built in leveling jacks and stands large RVs have it s usually easy enough to move back and forth in your campsite until you re reasonably level However many Roadtrek owners buy and carry leveling blocks
90. ter Supplies purchase and install a pressure regulator inline with the water connection In a typical campground you may see the faucet with a backflow preventer attached These look similar to a pressure regulator but do not affect the pressure The backflow preventor is there to protect the campground You need the pressure regulator to protect yourself from excess pressure te F i Hi T 5 f 1 Vi af A 1 aa Backflow preventer Typical water pressure regulator 2014 by Roadtrek Inc HOWTO Potable Water Use 102 ey If you have any doubts about a water supply pressure situation you can always fill your tanks from the water source using the gravity fill and use the water pump to supply water from the tanks You can connect to a city water connection when your Roadtrek is configured in the summer operation mode The city water inlet connection is located in the small compartment just behind the driver s side rear tire A Roadtrek recommends that you use a potable water hose These are usually white in color City water fill location City water valve in closed handle Attaching pressure regulator to city vertical position water fill location To connect the Roadtrek s water system to an outside source e Turn the water pump off e Close the city water valve by turning the handle to the vertical position e Close all interior faucets e Flush old water and any contaminants out of the wa
91. ter heater running Also remember that the waste water tanks are not protected from freezing If you use them mix pink RV antifreeze with whatever you put down the drain 50 50 If you do not use them drain and winterize the waste water system Switching from Winter to Summer Mode e Check to be sure the exterior tank drain valve under the driver s door step is closed and fill the exterior tank using the gravity fill on the driver s door post e Open the lid on the side bench enclosure by removing the side bench s cushion and table to expose the hinged lid Undo the Robertson head screw to raise the lid Once you know where these valves are you can just open the access door on the front but it s best to unscrew the top to give you a full view if you re not familiar with these controls 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 130 Bo ero i Water controls enclosure under side Screw to remove in order to lift lid bench e Open the tank isolator valve to connect the two tanks In winter mode the handle is across the line turn it so that the handle points along the line 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 131 Tank isolator valve in open position Exterior tank drain located under the black plastic handle pointed along line driver s door step To open the valve and This valve is located inside the water drain the tank turn the handle so that it control enclosure under
92. ter supply faucet e Connect your fresh water hose to the faucet e Attach your pressure regulator to the Roadtrek s city water connection e Attach a fresh water hose to the the pressure regulator e Slowly open the faucet of the city water source 2014 by Roadtrek Inc HOWTO Potable Water Use 103 The city water connection by passes the water pump and fresh water tank Therefore the use of these items is not necessary when connected directly to an external water source To disconnect the city water connection Turn off the external water source Open a faucet to relieve the pressure in the system Failure to do so will not damage your vehicle but may result in an unexpected shower when you disconnect the hose The outside shower faucet next to the city water connection is a convenient place to do this Make sure the the city water valve is closed handle vertical Remove the hose from the city water connection and replace the cap on the fill connection Disconnect the hose from the supply faucet and stow it in your storage compartment Connecting the ends Is a handy way to prevent dirt or other contaminants from entering the hose while stored Outside shower ey If you hear your pump running and water pressure is low inside the vehicle after disconnecting from an external water source it is because you have not properly positioned the city water valve Make sure the black plastic handle is vertical an
93. the awning housing and retract the awning Electrical awnings have the switch inside the passenger door above the side window Awnings are susceptible to damage from wind and for this reason should never be left extended when you are away from the vehicle If a thunderstorm or other windy weather is imminent stow your awning until the wind calms down ey The awning is only powered when the ignition switch ts off To use the awning turn off the ignition 2014 by Roadtrek Inc Outside your Roadtrek 37 Exterior Access Doors Battery Access Door The door just in front of the rear tire on the passenger side is for the batteries These are maintenance free AGM batteries There is no user maintenance possible on these batteries except keeping them charged you never have to add water to them Driver s Side Doors z me is AE E d am iri Peaks ams fei a ala yy al or Be Pts bette Sa ani Try eae a ar Driver s side access doors Driver s side front access door showing Driver s side center access door houses tank dump valves power cord and waste hose fly n On the driver s side there are 3 doors that house items that you will use The small access door directly behind the driver s door has the dump valves for the gray and black tanks The center door has a storage area for the macerator hose and power cord The smaller door just in front of the rear tire has the outside shower The rear access do
94. the driver s side points along the water line bench to the left of the refrigerator e Switch the tank selector valve from the interior to the exterior tank by moving it from the vertical position to a horizontal one pointing toward the driver s side of the vehicle 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 132 Tank selector valve in interior tank position with the colored plastic handle pointed up This valve is located inside the water control enclosure just in front of the tank isolator valve Tank selector valve in exterior tank position colored plastic handle pointed to the driver s side of the Roadtrek e Open the two shutoff valves going to the outside shower by placing the handles parallel to the water lines and close the outside shower faucet after running water through them briefly to flush air and any contaminants 2014 by Roadtrek Inc HOWTO Summer and Winter Mode 133 R Outside shower valves shown closed Outside shower valves shown open 2014 by Roadtrek Inc HOWTO Water System Winterizing 134 HOWTO Water System Winterizing Do you really need to winterize A lf your Roadtrek is going to remain heated to comfortable temperatures and the temperatures during the day are well above freezing above 40 deg F or above 4 deg C and the forecast is for temperatures just below freezing for a few hours at nigh
95. to feed the cord through and close the storage compartment door Driver s side rear compartment Cord fed through mousehole 2014 by Roadtrek Inc HOWTO Shore Power 98 Campsite Connections Most RV parks and campgrounds have AC power of various voltages and amperages available at each site The power will typically be in a pedestal with a cover that flips up If you cannot find your power pedestal or you re not sure how to open it ask the campground personnel 50A outlet 30A outlet 2014 by Roadtrek Inc HOWTO Shore Power 99 15A outlet Breakers A typical campsite s power pedestal will have three types of plug in receptacles 15 amp 30 amp and 50 amp The 15A receptacle is typically the same as you would find in your home The 30A and 50A receptacles are specific to the RV industry Other receptacles look similar but may not be wired the same If in doubt check with campground personnel The pedestal will also typically have individual breakers for the 15A 30A and 50A services Many campgrounds turn off unused breakers so check that the breaker for the plug you will be using is turned on Your Roadtrek is equipped with a 30 Amp cord Most power pedestals have a 30 amp receptacle 2014 by Roadtrek Inc HOWTO Shore Power 100 15A to 30A adapter 50A to 30A adapter It is possible that a campground or perhaps a friend s driveway will not have a 30A receptable available for y
96. tor valve is drawing water from the internal tank You want it to be horizontal and pointing toward the driver s side of the vehicle that s the position where it s drawing water from the external tank 2014 by Roadtrek Inc HOWTO Potable Water Use 105 Tank selector valve in exterior tank Tank isolator valve in open position position The tank isolator valve is just a couple of inches to the rear of the vehicle from the tank selector valve to your left as you look into this cabinet and is a smaller black plastic handle on a white water line You want this handle to be pointed along the water line open not across it closed Leave the other two black handled valves on the left side of this enclosure alone those are the outside shower cutoff valves Set the tank selector and isolator valves in these positions for warm weather operation and simply fill up your tanks when they run out You don t have to change a thing until you need to operate in winter mode or winterize the system To see how to do that check out the HOWTO Summer and Winter Mode and the HOWTO Water System Winterizing sections If you are driving for extended distances and don t want to carry extra water you don t need 36 gallons of water weighs 300 pounds and it takes fuel to lug that much weight cross country just put water in the front exterior tank at the driver s door gravity fill and leave the back interior tank empty You will still have 20 gallo
97. useful service life beyond which it needs to be replaced See Manufacturers Owner s Manual for other operating instructions or look for the sticker which is sometimes placed on the detector to see the replacement date A The detector may chirp if the coach batteries are running low The Carbon Monoxide and Propane Leak detector is located on the passenger side near the floor under the TV These detectors have a service life beyond which point they need to be replaced The detector requires no maintenance other than periodic replacement See User Manual supplied with the unit for replacement intervals 2014 by Roadtrek Inc Alarms and Warnings 69 Smoke Alarm The smoke alarm is located to the right of the Monitor Panel It requires a 9V battery and periodic replacement Please refer to the Owner s Manual for the unit in your vehicle Fire Extinguisher The fire extinguisher is located just rear of the front passenger seat It is a dry chemical fire extinguisher suitable for all fires Before every trip check to see that the needle on the dial is in the green range If not replace the fire extinguisher DO NOT test your fire extinguisher by discharging it total discharge time is 8 to 12 seconds so it will become rapidly depleted if you test it this way Service life on fire extinguishers currently supplied is 12 years replace the fire extinguisher if it is more than 12 years past the year of manufacture stamped on the b
98. vent propane if the tank is overfilled or overheats This is not a user serviceable item never attempt to remove the cover test or otherwise interfere with the operation of this valve If this valve should open it is best to remove all sources of ignition and expeditiously leave the area Venting unburned propane is a slightly more advantageous situation than a tank explosion which is what this valve is designed to prevent 4 Propane tanks shall not be placed or stored inside your vehicle Propane tanks are equipped with safety devices which relieve excessive pressure by discharging gas to the atmosphere 2014 by Roadtrek Inc Propane System 51 X To reduce the danger of fire or explosion do not store gasoline or other flammable liquids inside your vehicle Q Ensure you purchase propane from a reputable propane facility Contaminated propane is a common cause of system failure Q The auxiliary BBQ outlet is regulated to 15 P S I If you are using an external grill with this hookup ensure that the appliance is rated for that pressure or has its own regulator for lower pressure by The auxiliary BBQ male connector is Cast Products part 829000 or 829120 The hose assembly in varying lengths is available as MB Sturgis part no 100476 These parts are available through your Roadtrek dealer 2014 by Roadtrek Inc Heating and Cooling 52 Heating and Cooling Thermostat The thermostat is located above the rear bed
99. wer If you turn on a 120 z ee os volt appliance it senses a load and will come back on in about O Inverter 20 seconds If you select power save auto you ll reduce the 3 Maa electricity it takes to keep the inverter powered and your batteries will require less recharging WWW AIMSCORP NET ey Many appliances use a small amount of power even when off It is possible for some of these appliances to use just enough power to get the inverter to turn on and off continuosly when in power save mode If this happens either unplug the appliance or turn the inverter off or on 2500 watt inverter switch Pressing the bottom of the switch selects power save off When this setting is selected the inverter will be on continuously There is a shore power indicator light to the right of the switch to tell you the system is receiving shore power There Is also a battery charging indicator light to tell you when the batteries are being charged by shore power Your refrigerator will run on either 12 volt battery power or 120 volt inverter power 2014 by Roadtrek Inc Electrical System 59 Optional Gasoline Generator The gasoline powered generator provides up to 2800 watts of power enough to run all your appliances Please refer to the Onan Generator manual for operation and maintenance Always close the rear windows of the vehicle and turn off the roof ventilation fan to avoid exhaust entering the vehicle s Interior There is
100. witch The centered switch to the right of the leftmost four switches is the water pump switch It should be on only when you have water in the fresh water tanks and wish to use the sinks showers or toilet The pump should not be run without water As with the patio light switch pressing the top of the button turns the pump on and pressing the bottom turns it off Water Heater Switch The water heater switch is to the right of the water pump switch As with all the other switches on the monitor panel the battery disconnect switch must be on for the water heater to work Even though the water heater uses propane to heat the water all the igniters and controls are electrical Water heater switch Tank status lights 2014 by Roadtrek Inc Monitor Panel 65 Tank and charge indicators To the right of the monitor panel are the indicator lights for the the battery charge level the fresh water tank levels for each tank and the black and gray water tank levels The battery disconnect switch has to be on for this display to work Press the button for each to see the display These will give you an approximate reading to the nearest third of how much is in each tank The four indicator lights for the battery are low fair good and charging Optional Generator Switch and Hour Meter If you have the optional 2800 watt gasoline generator the Switch is to the right of the tank and charge indicators Press the bottom of the s
101. witch for about five seconds to prime the generator then the top to start Press the bottom again to turn it off GENERATOR START HOURS jmo Incompatible with 85 fuels Run generator with regular unloaded gasoline only 31 OP PRIME garth the b the me ON p toar soul Owners on BATTE The b the n 1 Aim The hour meter to the right of the switch keeps track of how many hours your generator has been running There is a break in oil change after 20 to 50 hours of operation and other required maintenance at other intervals later on see the generator manual for details 2014 by Roadtrek Inc Distribution Panel 66 Distribution Panel The distribution panel is located above the side door just below the monitor panel The 120 volt AC breakers and the 12 volt DC fuses are behind a black plastic panel aol ee jT au ened agria Distribution panel Oo 120 volt AC breakers and 12 volt DC fuses AC Breaker Panel The 120 volt breakers are located below the monitor panel behind a black plastic cover Flip the cover to the right and note the labels under the cover with the identifying information on each breaker When storing the Roadtrek for the winter turn off the battery disconnect switch and all circuit breakers in this panel 12 Volt Fuse Panel The 12 volt fuses are located to the right of the 120 volt AC breakers The label on the cover has identifying information for each fus
102. ypass mode by turning the three valves on the lines in front of the water heater so that the handles all point vertically _ oe Anode rod location Water heater bypass valves in normal position all handles vertical e Open the galley sink move the handle in the hot water direction and run the water pump until water flows from hot water tap at sink and you smell chlorine The water heater holds six gallons so it will take a while for it to fill up e Allow the system to sit overnight e Drain both tanks completely fill both fresh water tanks with clean water and run all faucets for 2 3 minutes each To help get rid of the residual chlorine smell pour a half cup of vinegar into each tank fill let sit for a few hours drain and refill with fresh water 2014 by Roadtrek Inc

2015 210 Popular Brochure

Contents

Download Pdf Manuals

Related Search

Related Contents