XGX-3 Power Truck User Manual
Contents
1. 48220 P 586 757 1336 E Service extremercbyrsi com CHARGING BATTERY PACK The battery cover is located on the bottom of the chassis 1 Pinch the battery cover blocks as shown to open the battery cover 2 Remove the battery pack Connect battery pack to balancer Balancer Connect balancer to charger Battery Pack Connect charger to the wall outlet 3 Connect your battery to the charger using the balancer as shown in the picture above 4 During charging both red and green indicator on the balancer are on The red indicator light goes out and green indicator remains on when battery is fully charged The charging time is up to 2 5 hours 5 Do not charge your battery unattended 6 Charge battery on flat non flammable surface DRIVING PRACTICE Once you are comfortable with the basic operation of your vehicle forward reverse and turning practice driving the vehicle in circles and figure eights as shown in the image above Keep practicing until you are comfortable with steering acceleration and braking at low speeds Once you have mastered the basics you will be able to control the vehicle at increasingly faster speeds on more challenging tracks and terrain Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com 7 Mi MAINTAINING YOUR CAR After operating your Extreme RC vehicle perform the following maintenance checks to preserve your car s perfo2. Batterv Door Motor Gear 45 Front Body Post Rear Body 16 Bumpers Assembly Assembly Cover Posts Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com 9 a 47 Flange Lock Nut M4 48 Shock Tower Braces 19 Rear Axles Diff Outdrives 20 Front Axles 21 Diff Pinion Gears 22 Front Upper Suspension 23 Front Lower Suspension 24 Rear Upper Suspension Hinge Pins 3 3737mm 4 pcs Hinge Pins 3 3 30mm 4 pcs Hinge Pins 2 5 38mm 4 pcs QUO GULL QUD MU 25 Rear Lower Suspension 26 Batterv Door Hinge Pins 27 Front ji Hub Carrier 28 Battery Door Springs 4 pcs j Hinge Pins 2 5 37 6mm 4 pcs 2 5 56mm 2 pcs Pins 4 pcs 30 Gear Posts 4 pcs 31 Honey 12 5 5 5 0 5mm 39 Oiled Brass Bearings 2 pcs 5 8 2 5mm 12 33 Oiled Brass Bearings 34 Wheel Hex Pins 2 10mm 35 Zip Ties Small 8 pcs 36 5 Wire Steering Servo 8 12 3 5mm 12 pcs 8 pcs 38 Battery Pack 7 4V 850mAH 39 R C 390 Motor 40 Wheels Complete Dune Truck 4 pcs 41 Truck Shell 42 Flange Lock Nut M3 6 pcs 43 Motor Pinion Gears 12T Set 44 Countersunk Self Tapping Screws 3 3mm 2 pcs Screws 2 15mm 12 pcs 0 Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com 45 Set Screws 3 3mm 12 pcs 49 Countersunk Self Tapping Screws 2 9mm 12 pcs NM TIM 53 Round Head Self Tappin Screws 2 6 6mm 12 sa TIM NM 57 Step Sc
3. same tvpe brand Ji STIVA of Remove batteries from R C if notin use Always check the battery power E 2 Slide back the battery cover after batteries are installed hl Dispose of used batteries properly Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com 3 DRIVING YOUR CAR Q TURN ON THE RECEIVER ON YOUR UNIT e TURN ON THE RADIO CONTROLLER The ON OFF switch is located in the rear underneath Switch on the power switch on the the truck shell radio controller Vour unit is connected with vour radio controller automaticallv 3 CHECK STEERING PERFORMANCE CENTER TURN LEFT TURN RIGHT 1 To keep the car running straight 2 To turn left turn the control wheel 3 To turn right turn the control in line do not move the control towards you wheel away from you wheel Keep it centered 4 CHECK TRIGGER RESPONSE PUSHIT FORWARD iA PULL IT BUCK FENTER A Pull the trigger back to accelerate release it to decelerate and push it forward to brake B To stop your running car release the trigger to neutral position C Pushing the trigger forward a second time activates the reverse feature i A Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com DRIVING YOUR CAR Q TO TUNE THE STEERING TRIM STEERING TRIM Gently pull the trigger to allow your car to run slowl
4. KEIT ro me eXmenc INSTRUCTION MANUAL EXTREME XGX 3 AT POWER TRUCK Manual Contents Packing List General information 1 Power truck e 2 4GHz radio system R C 1 2 4GHz R C e Driving instructions 1 A C adapter Angle adjustment instruction 1 Balancer PARTS SERVICE REPAIRS Charging instructions 1 aa card OPEN Mon Fri 9am 6 pm Sat 10 am 3 pm EST Troubleshooting i ss PME Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 Safety instructions 7 a Phone 586 757 1336 Email Service extremercbyrsi com Website www extremercbvrsi com e Parts list by number PACKING LIST Outer Shell E XGX 3 Power Truck Motor Metal Outer Spring Front Shock Set Metal Outer Spring Rear Shock Set Power Switch Rear Wheels E Controller Control Interface A C charger x1 ji 7 AV 850mAh Battery x1 aL Battery case Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com 1 Mi GENERAL INFORMATION This user s manual is designed for use with vour XGX 3 Power Truck and contains the instructions you will need to operate assemble disassemble after 60 day warranty maintain and troubleshoot your R C unit We want users to enjoy our R C products and to operate them with care Failure to operate your vehicle in a safe and responsible manner may result in property damage or injury to yourself or o
5. djustments and easily maintained settings will assure optimum operation and performance When making adjustments do so only in small increments and always check for other parts of the vehicle that are affected Many aftermarket options are available to make your R C vehicle faster and stronger Please read this section carefully and always make sure to write down base settings in case you need to refer to them at a later date FRONT STEERING TOE ANGLE ADJUSTMENT The front steering toe angle has a dramatic effect on how your car performs and how your tires wear You can have toe in zero toe or toe out This can be adjusted by tuning the length of the steering linkage screwbolts as shown in the figure below Before tuning the steering linkage screwbolts should be removed from the vehicle Measure the desired length by unscrewing or screwing in After adjustment is complete re install them in the car Zero Toe aero Tog Toe in will be less reactive and cause the vehicle to Toe Out Toe In Toe Out Toeln 4 hia under steer the front wheels push straight on while k turning This can be advantageous for operators struggling to geta tight tire grips with driving the vehicle I I I 4 I Toe out will be more aggressive on the steering response especially on small steering inputs This will make the car want to over steer rear wheels slide on small steering inputs This is useful as a race tuning aid to gain extra steering Z
6. ear mesh between spur gear and pinion E The vehicle runs noisily 2 Check for stripped and or dirty gears 3 Clean and oil bushings or ball bearings i 8 Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com SAFETY INSTRUCTIONS WARNING e Do not operate your vehicle with an obstructed line of sight at night around crowds or near water e Keep moving R C vehicles away from pets young children the elderly and the disabled use good common sense when driving e Keep out of reach of children while assembling and or disassembling model comes with small parts e Do not run your vehicle on public roads or any area where you may encounter pedestrian or moving methods of transportation e When not in use especially for 30 days or more remove all batteries or batteries may leak and cause damage ENVIRONMENT FOR DRIVING e Avoid running into objects water or anything else that could damage your R C e Do not operate in snowy rainy or poor weather conditions SPARE PARTS LIST AVAILABLE AT WWW EXTREMERCBYRSI COM 2 Servo Cover Motor Guard 3 Front She ra Ste ond Chassis Side Plates A Servo Linkage Set 6 L nels Chassis Side 17 Front Shock Set 8 Rear Shock Set Plates B 9 Steering Servo Saver Assembly 410 Steering Hubs L 441 Front Hub Carriers L R 42 Wheel Hex 8 pcs Battery Door Block Lock Rear Hub pk 43 Spur Gear Diff Gears 44
7. ero toe will make the front wheels run straight and make the car very neutral Tire wear will also be reduced and the vehicle will feel easier to drive CAMBER ADJUSTMENT Camber can be adjusted on all 4 wheels of the car You can have negative camber or positive camber which will affect the contact patch of the tire both statically and while cornering Camber is mainly used to control the wear of the tire You should adjust the camber to equal the wear all across the surface of the tire Camber is adjusted by the upper linkage screwbolts ADJUSTINHERE TAL Note Before tuning the screwbolts should be removed from the vehicle Measure the a desired length bv unscrewing or screwing in After adjustment is complete re install REAR ea them in the car L a This is an example of positive camber The bottom of the wheel is closer to the center of the car compared to the top of the wheel Positive camber will give less contact area in the corner and less grip Excessive positive camber will cause less grip and uneven wear 4 4 1 1 4 Positive camber 1 4 4 1 1 4 4 This is an example of negative camber The top of the wheel is closer to the center of the car compared to the bottom of the wheel Negative camber will give more contact area in the corner and more grip Excessive negative Negati i MDT camber will cause less grip and uneven wear i 6 Distributed and serviced by Extreme RC by RSI Ferndale MI
8. forward to brake Pushing forward after the car has stopped will put the car in reverse C Battery Case Requires 3 AA batteries not included 1 Steering Trim Adjusts the center trim of the steering servo aligns wheels 2 Dual Rate Servo Throw Adjusts the center trim of the throttle steering servo distance Fine tunes the R C steering wheel 3 Throttle Trim Adjusts the center trim of the throttle forward and backward and sets idle speed 4 Steering Reverse Electronically switches the direction of servo travel reversing the backward left forward right relationship of the steering wheel to a forward right backward left relationship 5 Throttle Reverse Electronically switches motor operation reversing the pull forward push reverse relationship of the throttle to a pull reverse push forward relationship 6 Power Indicator Light Stays solid red when the R C is turned on R C batteries need to be changed when both Power and Battery Indicator Lights are flashing 7 Battery Indicator Light Stays solid green when batteries are fully charged The light starts flashing when battery power is low Batteries need to be changed when both Power and Battery Indicator Lights are flashing BATTERY INSTALLATION ITEMM 1 Slide back the batterv cover as shown and following the polaritv illustratons insert three AA batteries 8 Power switch Turns the remote controller on and off Use batteries of
9. num Suspension Mount 78 Ball Bearings 79 Ball Bearings 80 Brushless Motor 2 pcs 8 12 3 5mm 6 pcs 5 8 2 5mm 6 pcs 2848KV3800 PARTS SERVICE REPAIRS Toll Free 888 221 8851 Tel 586 757 1336 x 1 E mail Service extremercbyrsi com Website www extremercbyrsi com OPEN Mon Fri 9 AM to 6 PN Sat 10 AM to 3 PM EST FE CEQOBSE 7 1 2 Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com
10. rews 3 5 4 5 3 4 6mm 12 pcs NM NI 61 Round Head Self Tapping Screws 2 6 18mm 12 pcs 65 Flange Head Self Tapping Screws 2 3 8mm 12 pcs 46 Screws 2 6 8mm 12 pcs Round Head Self Tapping Ga Gee fae Gem G Gee fae am 50 Countersunk Self Tappin Screws 2 6 6mm 12 a NIN NI 54 Round Head Self Tapping Screws 2 6mm 12 pcs 58 Flange Head Self Tappin Screws 2 6 8mm 12 see 62 Flange Head Self Tapping Screws 2 6mm 12 pcs Pgo kk a 66 Steering Hub Step Screws 8 pcs 47 Screws 2 6 8mm 12 pcs Countersunk Self Tapping 54 Countersunk Screws 3 10mm 12 pcs NM NI 55 Round Head Screws 2 5 8mm 12 pcs NM MI 59 Round Head Self Tapping Screws 2 6 12mm 12 pcs 63 Cap Head Screws 2 12mm 12 pcs 67 UL Charger 48 Round Head Self Tapping Screws 2 6 10mm 12 pcs MM MI 52 Round Head Self Tapping Screws 3 6mm 12 pcs NM TIM 56 Countersunk Self Tapping Screws 2 6 10mm 12 pcs TIM IN 60 Countersunk Self Tapping Screws 2 6 18mm 12 pcs NIN MI 64 Round Head Self Tapping Screws 2 3 16mm 12 pcs 68 Charger Balancer Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com 1 1 a UPGRADE 69 Front Axles Ferric 70 Rear Axles Ferric 71 Front Aluminium Shock Set lt 73 Aluminum Chassis Side 74 Aluminum Chassis Side 75 Aluminum Servo Cover Plates A Plates B 77 Alumi
11. rmance Inspect your car for any obvious damage Check the gears for wear debris or broken slipping teeth Check the wheels and tighten the wheel screws as needed Check for loose screws in the chassis Check the wiring for frayed or damaged wires or connectors Check the steering servo which will wear out over time replace when neccessary Check all batteries Keep the chassis clean and free of sand dust and moisture Remove and clean the motor if necessary Never attempt to re assemble the motor you will damage it and void the warranty Clean the car body with a soft lint free cloth Remove all batteries when not in use TROUBLESHOOTING 1 Check to see if both transmitter and car are on a Tewenice dace 2 Charge battery pack not work at all 3 Check to see if there are damaged parts 1 Replace or charge the battery pack and or the R C batteries 2 Make sure the vehicle is geared properly and pinion spur ears are tightened B The vehicle runs slowly 9 3 Clean all bushings or ball bearings 4 Check for stripped or dirty gears 1 Check if the servo feels jammed try centering it by hand C The throttle works but not the steering 2 Check the whole steering system 1 Check to see if there are damaegd parts D It steers but throttle is uncontrollable 2 Replace or charge the battery pack and or the radio batteries 1 Check g
12. the car or in the packaging Make sure the vehicle s batteries have a sufficient charge before driving insufficient charge may result in a loss of control The radio controller requires 3 x AA batteries not included in the packaging Always remove batteries from the vehicle and the radio controller when notin use e For better performance some adjustments may be necessary Take care and do not cut yourself while using tools to adjust or upgrade your vehicle e Only use Extreme RC manufactured parts to upgrade your car If you perform a drivetrain upgrade replace the entire system such as motor ESC receiver unit ie so that all components are properly matched Any malfunction incurred by custom modification will void your warranty ii 2 Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com GETTING FAMILIAR WITH YOUR 2 4GHZ RADIO SYSTEM TAKE IT TO THE EXTREME EXTREME 2 GHz DIGITAL PROPORTIONAL SVSTEM ST TRIM ST D R TH TRIM REMOTE CONTROL REMOTE CONTROL INTERFACE 1 Steering trim 5 Throttle reverse 2 Dual rate servo throw 6 Power indicator light 3 Throttle trim 7 Battery indicator light 4 Steering reverse 8 Power switch A Steering wheel B Trigger C Battery case REMOTE CONTROL A Steering Wheel Turns the model left and right B Trigger Controls acceleration and braking Pull to accelerate release to decelerate and push
13. thers This product is not a toy IT IS AUTHENTIC HOBBV GRADE It is not suitable for users under 14 years old unless they are supervised by adults Carefully read and follow all instructions in this manual Failure to follow the instructions will be considered abuse and or neglect and may void the 60 day warranty e Before driving your unit please read this manual completely and examine your vehicle and radio control for any defects Radio waves are subject to interference Radio interference can cause loss of control of your vehicle This product is fully assembled at the factory We do not take any responsibility for damage and or accidents that occur as the result of custom modifications and or incorrect operation e Your vehicle is designed to run on uneven or rough terrain However dust sand water and carpet fiber can lodge in the working parts of your cars and can damage your vehicle if not removed promptly We do not warranty your vehicle from damage due to outside elements including sand dirt or water The user is responsible for the maintenance and safe operation of this vehicle Never attempt to re assemble any electronic components These have been carefully calibrated at the factory e f your vehicle becomes stuck release the throttle then retrieve it by hand Do not continue to apply the throttle or you may damage the motor and or the ESC receiver unit e This vehicle requires one battery pack included in
14. y Meanwhile tune the steering trim to allow the front wheels to be aligned G TO TUNE THE THROTTLE TRIM THROTTLE TRIM Throttle trim is used to set vour idle speed Q TO TUNE THE STEERING DUAL RATE CONTROL DIAL Decrease Increase STEERING D R This dial adjusts the overall travel of the steering servo Turn the dial towards right for maximum steering Turn the dial to left to reduce the steering level O STEERING THROTTLE REVERSE Steering Reverse This switch will reverse the normal RC to car steering wheel relationship Normally turning the steering wheel forward will turn the car to the right and turning it back toward you will turn it to the left The Steering Reverse switch will cause the car to turn right when you turn the wheel back toward you and left when you turn it away N Normal R Reverse Throttle Reverse This switch will reverse the normal RC to car accelerator trigger relationship Normally pulling the accelerator trigger backward will cause the car to go faster and reverse the N Normal car The Throttle Reverse switch will cause the car to slow stop and reverse when you pull the trigger and to go forward faster when you push the trigger away from you R Reverse Distributed and serviced by Extreme RC by RSI Ferndale MI 48220 P 586 757 1336 E Service extremercbyrsi com 5 Mi ADJUSTING TOE ANGLE AND CAMBER ANGLE Your model can be customized to enhance speed and performance Simple a
Download Pdf Manuals
Related Search