RS3 50 Naked Owner Manual
Contents
1. everyday adventure RIEJU Categoria Veicolo RS3 NAKED 50 5 everyday adventure IDENTIFICATION OF THE MOPED right side 1 Air filter 2 Fuel tank cap 3 Front brake reservoir 4 Front brake Lever 5 Radiator 6 Transmission oil filling cap 7 Rear brake lever 8 Rear brake reservoir 6 RS3 NAKED 50 IDENTIFICATION OF THE MOPED everyday adventure IDENTIFICATION OF THE MOPED left side 1 Instruments and indicators 2 Ignition switch 3 Seat lock 4 Battery 5 Fuse 6 Dil tank 7 Stand 8 Geor change pedal 9 Horn 10 Clutch lever IDENTIFICATION OF THE MOPED RS3 NAKED 50 _ everyday adventure INSTRUMENTS AND CONTROLS 1 Light Dip Switch 2 Digital Instrument Dashboard 3 Ignition Barrel 4 Digital Display MPH Programming page 38 5 Front Brake Fluid Reservoir 6 Front Brake Lever 7 Throttle Grip 8 Starter Button 9 Indicators 10 Choke Cold start 11 Clutch Lever 12 Horn RS3 NAKED 50 LONTROLS AND INSTRUMENTS everyday adventure INSTRUMENTS AND INDICATORS IGNITION LOCK The ignition lock is located in the middle of the top yoke set of keys are given for the ignition blocking the steering petrol tank and seat lock Steering Lock switches off lights and system elect2. everyday adventure BRAKE CONTROL FRONT AND REAR If the brake pads are worn they must be replaced Minimum thickness of pads to be 2 mm CAUTION Replacing brake pads should be carried out by an official RIEJU dealer RS3 NAKED 50 MAINTENANCE everyday adventure SPARKPLUG CHECKING AND REPLACING THE SPARKPLUG The spark plug is an important component of the engine and Is easy to inspect Periodically remove and inspect the spark plug because heating slowly deteriorates the plug and leaves carbon deposit If the electrode is excessively eroded or if soot or other deposits are excessive change the spark plug with the type and degree heat Recommended NGK BR 9 ES Before mounting any spark plug measure the distance between electrodes A with a feeler gauge and adjust to specifications The electrode gap is 0 6 0 7 mm When installing the spark plug clean the surface of the washer seat B thereby preventing debris falling into the combustion chamber Replace Spark plug by hand gently twisting then gently finishing by tightening between 1 8 and 1 4 turn with the wrench in the tool kit MAINTENANCE RS3 NAKED 50 65 mmm everyday adventure BATTERY CHECKING THE BATTERY If you see rust on the terminals and the ends of the terminals they should be cleaned with a wire brush If so remove the cables and scrub the terminals After cleaning reconnect the terminals and
3. d RS 3 NAKED 50 OWNER S MANUAL 41 O for everyday adventure Bienvenu welcome Bienvenido GARANTIE CONSTRUCTEUR DE 2 ANS PIECES ET MAIN D OEUVRE TWO YEARS OF WARRANTY PARTS AND MANPOWER DOS ANOS DE GARANTIA M 0 Y PIEZAS OPERATORS MANUAL RS3 NAKED 50 RIEJU S A is very grateful for the trust you have placed in our company and congratulate you on your excellent choice RIEJU SA collaborates in the conservation of the environment The owner s manual is written in basic format that explains the basics of your new RS3 NAKED 50 gt gt lie B for everyday adventure everyday adventure RIEJU SA is grateful for the confidence you have put in their company amp would like to congratulate you on your choice of motorbike The RS3 NAKED 50 model is the result of the Long experience of RIEJU SA for developing generations of quality mopeds This owner s manual provides essential data and instruction on the correct use and maintenance of this moped you should read thoroughly the instructions and information contained within this operators manual Please note that the life of the motorbike depends upon its use and the maintenance that you provide it Maintaining it in perfect condition will reduce future repair costs This manual should be considered as part of the motorbike and should remain with the vehicles basic tools just in case of change of ownership For a
4. everyday adventure TOWN SANT SADURNI D ANOIA SEGOVIA SEVILLA SORIA SANTA COLOMA DE GRAMANET TALAVERA DE LA REINA Toledo TARRAGONA TARREGA Lleida TERRASSA Barcelona ALCANIZ Teruel ROQUETES Tarragona VALENCIA VALLADOLID VALLS Tarragona VERA DE BIDASOA Navarra Pamplona VIGO Pontevedra VILAFRANCA DEL PENED S Barcelona OFFICIAL DISTRIBUTORS DOVIMOTORS 3000 S L MOTO RULAR COMERCIAL DOMLEZ MOTOS MIGUEL MOTOS JARAMA BERMUDEZ E HIJOS MOTOS TARRAGONA SPRINT MOTOS MOTOS BAR MOTOCROSSCENTER FABREGUES MOTORSPORTS S L IBEM AUTOMOCI N RIEJU MOTOR VALLADOLID MOTOS JAUME JOAN MOTO TRAIL HNOS OSES ANCA SIVILL VENTURA ADDRESS Jacint Verdaguer 13 15 Gobernador Fern ndez Jim nez 22 Torneo 80 5105 28 Avda Ban s Baja 10 14 Avda de Portugal 74 Avda Estanislao Figueres 35 Bombers 1 Manyer i Flaquer 20 C Salvador 7 Poligono LA RAVALETA Parc 1 Filipinas 21 23 Plata 7 Pol San Cristobal Passeig de L Estaci 36 baixos Barrio Aguerra local 8 Seara 62 Apdo 5013 Sant Pere 32 36 TELEPHONE 93 8183302 921 426315 95 4903776 95 4905576 975 214688 93 3850818 93 3866068 925 801757 971 216244 973 312911 93 7854312 978 834236 977 500100 96 3414999 983 308417 977 601323 948 630807 986 232601 93 8900594 OFFICIAL DISTRIBUTOR LIST RS3 NAKED 50 c NE everyday adventure d T
5. When you test the moped ensure that all caps are replaced MAINTENANCE RS3 NAKED 50 73 mum everyday adventure CLEANING AND STORAGE CLEANING Frequent and thorough cleaning of your motorbike will not only improve its performance and lengthen The useful life of its compo nents but also emphasise the appearance of the motorbike Order of cleaning 1 Cover the exhaust pipe outlet inlet to prevent water entering the system 2 Check that the spark plug and all caps are firmly in place 3 If the engine is very dirty apply a degreaser ATTENTION DO NOT apply degreaser to the wheel axle chain or brake discs 4 Remove the degreasing agent along with the dirt using a low pressure water source such as a hosepipe ATTENTION Rieju accepts no responsibility for the use of degreasing agents which stain and or cause deterioration to the motorbikes components Rieju accepts no responsibility for any possible damage resulting from the use of pressurised water to clean the motor bike EN 7 NAKED 50 CLEANING AND STORAGE everyday adventure 5 After all dirt has been washed off the surfaces should be washed with warm water and mild detergent soap 6 Remove any soap and with cold water and dry all surfaces Clean the seat with vinyl upholstery cleaner 7 Once cleaned start the engine and allow it to idle for a few minutes this will completely dry all the components and at the same tim
6. 3 Tighten the screw to the end 4 Push the wheel so the chain 0 becomes Loose 5 Release the chain D 6 Remove the wheel axle to release the spacer 0 7 Remove the wheel and the brake disc will exit the brake caliper NAKED 50 MAINTENANCE ATTENTION Pay close attention to the position of the spacer b located on the Left side W ADVICE Never operate the brake lever during this operation W ADVICE Please remember that these operations should be carried out by an official RIEJU service centre REAR WHEEL ASSEMBLY ATTENTION Make sure to insert the broke disc into the pad Make sure the chain is slack before replacing the wheel to its position See section TRANSMISSION CHAIN MAINTENANCE RS3 NAKED 50 57 mmm everyday adventure CHAIN ADJUSTMENT AND TENSION CONTROL AND REGULATION The moped must be positioned vertically with its wheels on the firmly on the ground For the adjustment of the chain you must adjust both sides of the rear axle at the same time The chain must be adjusted to have a tolerance of 30 to 40 mm At the midpoint between the output gear and the rear sprocket see picture ATTENTION The chain should be kept in perfect cleanliness and be properly lubricated each week ATTENTION To adjust to the correct tension YOU must perform these steps on both sides of the wheel EN 5 NAKED 50 MAINTENANCE
7. 40 with a total capacity of 820 cc The oil in the sump is drained through the drain screw located at the bottom right of the engine IF the oil Level indicator lights up check oil and replace Periodically check the level as follows CAUTION Place the moped on a flat and firm surface before attempting this operation MAINTENANCE RS3 NAKED 50 i everyday adventure Then proceed as follows 1 Place a container under the pan to prevent oil dripping on the fairing and ground 2 Remove the screw A level Para un correcto nivel deber salir lentamente un poco de aceite por el orificio del tornillo A ADVICE It is recommended to change the engine oil when the engine is hot or warm as the old oil will be more fluid and drain more effectively CAUTION As the engine is hot or warm be very careful not 10 burn yourself when performing this operation RS3 NAKED 50 MAINTENANCE everyday adventure ENGINE OIL REPLACEMENT CAUTION Place the moped on a flat and firm surface before performing this operation Then he proceeds as follows 1 Remove the drain screw make sure its drained completely empty 2 Once empty set screw back into its housing and tighten 3 Remove the cap from the fill hole C until the oil exit hole A level or the amount of 750 cc because if the motor has not been stripped and rebuilt there is normally 50 to 70 cc left in inside ATTENTION
8. 50 everyday adventure 9 Fuel Indicator ry The fuel indicator lights up yellow when the fuel level is below the reserve fill up as soon as possible to prevent running out of fuel 10 Temperature indicator E Indicator lights up red when there is an excessive temperature increase due to insufficient ventilation or low coolant levels in the radiator 1 Direction Indicators m Indicator flashes green when indicator lights are operated 12 Neutral Indicator N The indicator will light up green when The gear change pedal has selected neutral RS3 NAKED 50 TABLE OF INSTRUMENTS AND WARNING everyday adventure MAIN ELEMENTS OF THE MOPED LIGHT SWITCH The light switch has two positions Low main beam 1 ML High Beam 2 CAUTION Only use the high beam if there are no vehicles or people in front or use in quick bursts to signify danger or emergency INDICATOR SWITCH Indicator switch with three positions Intermittent Left 1 Position at rest 2 Intermittent rights 3 Set the switch to right or left and press the button to cancel MAIN ELEMENTS OF THE MOPED RS3 NAKED 50 23 mmm E everyday adventure HORN SWITCH Press the button 1 to sound the horn CAUTION Remember that is forbidden use the horn near to hospital and only you can use ilin danger o emergency situations CHOKE CONTROL Press the lever 1 to the
9. Maintenance chart 50 CLUTCH LEVER 51 everyday adventure Control and clutch lever adjustment 51 GEAR CHANGE PEDAL Control and adjustment of the gear pedal 52 FRONT WHEEL 53 FRONT WHEEL Removing the front wheel 54 Front wheel assembly 55 REAR WHEEL Removing the rear wheel 56 Rear wheel assembly 57 CHAIN ADJUSTMENT AND TENSION Control y regulaci n 58 FRONT BRAKE SYSTEM Front brake disc 60 Front brake lever adjustent 60 Checking and topping up front brake fluid level 61 REAR BRAE SYSTEM Rear brake disc 62 everyday adventure Adjusting the rear brake lever 62 Fill level control and rear brake fluid 63 BRAKE CONTROL FRONT AND REAR 64 SPARKPLUG Checking and replacing the sparkplug 65 BATTERY Checking the battery 66 Battery replacement 67 FUSE Check and replacing the fuse 68 AIR FILTER Cleaning and replacing the air filter 69 COOLING SYSTEM Checking and filling the coolant level 70 MOTOR OIL Checking and filling the engine oil Level T Engine oil replacement 7 everyday adventure CLEANING AND STORAGE CLEANING 14 LONG TIME STORAGE 75 76 TECHNICAL DATA 81 OFFICIAL LISOFFICIAL DISTRIBUTOR LIST everyday adventure DESCRIPTION OF THE MOPED This moped incorporates a MINARELLI NG New Generation engine with single cylinder two stroke liquid cooled manual gear box
10. NAVARRO HNOS Camino de Ronda 103 958 208142 GRANOLLERS MOTOS GRANOLLERS Crtra Montmel 102 Circuit de cata 93 5689075 GUADALAJARA DOMARCO Virgen del Amparo 34 949 224239 HOSPITALET LLOBREGAT Barcelona DRUG MOTO Enric Prat de la Riba 166 93 3373112 HUELVA CASTRO JARANA HUELVA Avda Alemania 56 959 245100 HUESCA MOTOS AQUILU Avda de los Danzantes 6 8 Bajos 974 223947 IGUALADA Barcelona ANOIA MOTOS Avda Laresmar 54 baixos 93 8053938 JAEN MOTOCICLETAS ORIHUELA Avda Madrid 44 46 953 252864 RS3 NAKED 50 OFFICIAL DISTRIBUTOR LIST TOWN JEREZ DE LA FRONTERA Cadiz LA CORUNA LEIDA VIZCAYA LEON LEON LLEIDA LOGRO O La Rioja LUGO MADRID MALAGA MALAGA CialNavarro Hnos MANRESA Barcelona MARTORELL Barcelona MATAR Barcelona MOLINS DE REI Barcelona MONDO EDO Lugo MURCIA OFFICIAL DISTRIBUTORS EL MOTORISTA MOTOR 7 MOTOCICLETAS MENDIVIL MOTO DEPORTE LEON MOTOS SEVILLA MOTOS PI EIRO SCRATCH MOTOS VAREA MOTOS MONTOUTO SOAL MOTOS EL MOTORISTA MALAGA S L EUROMOTOR ANDALUCIA SA BRUL MOTORS PELNA MOTO MOTOS JAB MOTOS CORREDOR MOTOS CHAO JADE MOTOR everyday adventure ADDRESS Avda de Europa 58 Apdo 700 Posse 7 bajo Autonomia 15 Duque de Rivas 20 De la Facultad 61 Avda de les Garrigues 78 80 82 Fundici n 12 Alexandre Boveda 24 Avd Ciudad de Barcelona 216 P Euadalhorce Ctra Azucarera Intelhorce 82 Avda Ortega y basset 258
11. a firm Level surface to support the moped fully ATTENTION Do not let go of the moped until your sure that is firmly on the Stand MAIN ELEMENTS OF THE MOPED RS3 NAKED 50 E everyday adventure CHECKS TO BE CARRIED OUT BEFORE OPERATING Table of checks to be done heck the following before using your moped RS3 NAKED 50 COMPONENT CHECK ACTION IF NECESSARY Dil Tank The level Refill Throttle Grip The free play Adjust and lubricate as necessary Tyres The pressure wear and general condition Inflate or replace Clutch Check free play and operation Adjust to 1 mm free play hain Tension condition and lubrication Lubricate or replace Battery The charge Charge il Steering Check the steering is smooth Check free play Check there are no gaps Headlight everyday adventure COMPONENT CHECK ACTION IF NECESSARY Headlights Check bulb Replace Brake Light Check bulb Replace Uirection Indicators Check bulb Replace Instrument Panel Check bulb Replace Fuel Level heck level Refill Motor Oil Check oil level Refill Brake discs Check if there damaged or dirty corroded Replace amp or Clean Brakes Check the operation of rear brake pedal Check the play in the front brake Lever Adjust Check brake fluid levels Refill These checks should be carried out each time the motorbike is used a full check over requires no more than a few minutes If dur
12. tighten the adjuster nut to set the position ATTENTION Normal clutch clearance is 25 mm measured at the opening of the tip of the Lever MAINTENANCE RS3 NAKED 50 everyday adventure GEAR CHANGE PEDAL CONTROL AND ADJUSTMENT OF THE GEAR PEDAL To adjust the position of the shifter follow these steps 1 Loosen the nuts A 2 Remove the 2 screws B holding the shift lever assembly 3 Rotate the assembly support the rod for height adjustments in either direction 4 heck if the desired height has been achieved for easy use 5 Re tighten the 2 screws B 6 Set the position by Locking nuts Al gt NAKED 50 MAINTENANCE everyday adventure FRONT WHEEL Check the condition of the wheels A simple test to detect if the wheels are ready to roll Balance the wheel as shown in the picture look down both sides check the wheel isn t touching any other components and also check to see if the wheel has any free play side To side CAUTION If you detect any of the wheels have free play please contact an official RIEJU dealer to get it reviewed MAINTENANCE RS3 NAKED 50 E E everyday adventure FRONT WHEEL REMOVING THE FRONT WHEEL CAUTION Place the motorcycle on a flat and firm before attempting to remove the wheel ATTENTION Suspend the moped from the front 10 ensure the front wheel is off the ground W ADVICE Place a wood
13. ECKS BEFORE DRIVING everyday adventure 3 THE TIRE CIRCUMFERENCE SETTING FOR CHANGING DIFFERENT SIZE TIRE In main screen press down both Adjust amp Select buttons X 3 seconds to enter the tire cir cumference setting EX The tire circumference is 1 960 mm In setting screen press the Adjust button to move to the number you want to set Now the 115 flashing NOTE The tire circumference setting range 1000 mm 2 500mm Adjust unit 1 mm Press the Select button to choose the number you want to set Now the number you are setting is flashing CHECKS BEFORE DRIVING RS3 NAKED 50 E everyday adventure Press the Adjust button 5 times to return to the main screen EX The setting is changed from 1 930 mm to 1960mm NOTE When you leave the screen the setting is saved You could define The valve as the starting point and the terminal point to measure the wheel circumfe rence with a measuring Tape RS3 NAKED 50 CHECKS BEFORE DRIVING everyday adventure 4 SPEED UNIT SETTING In main screen press down both Adjust amp Select buttons X 3 seconds to enter the tire cir cumference setting In the setting screen press the Adjust button for 4 times and then you will enter the speed unit setting Press the Select button to choose the speed unit you need EX The original setting is km h Now the unit is flashing NOTE You could choo
14. GER SEAT To Open the passenger seat you must open the main seat once the main seat is out 1 Push the lever A to the bottom 2 Pull out the passenger seat by the front side To close the passenger sent 3 Put the central guide outside of the support 0 4 Go down the front side of the seat and check that is correctly close MAIN ELEMENTS OF THE MOPED RS3 NAKED 50 27 mm everyday adventure THROTTLE GRIP Turn the throttle grip to accelerate Check for correct operation by rotating the grip and verifying correct free play The grip should firmly return when the accelerator is released CLUTCH LEVER The clutch is located on the lett hand side of the handlebar To engage the clutch the lever should be pressed towards the grip or handlebar RS3 NAKED 50 MAIN ELEMENTS OF THE MOPED everyday adventure FRONT BRAKE The front brake is operated by a lever on the right handlebar When activated the rear brake light is illuminated CAUTION Use the brake lever gently and gradually to prevent front wheel from locking up REAR BRAKE The rear brake is operated by a foot lever on the lower right of the engine When activated the rear brake light is illuminated CAUTION Use the foot pedal gently and gradually to prevent rear wheel from locking up MAIN ELEMENTS OF THE MOPED RS3 NAKED 50 29 mm E everyday adventure GEAR CHANGE PEDAL This
15. ILA BADAJOZ BARCELONA BARCELONA BARCELONA BENAVENTE Zamora BIN FAR Huesca BURGOS CACERES CARTAGENA Murcia CIUDAD REAL OFFICIAL DISTRIBUTORS MOTOCICLETAS GONZALEZ SL MOTOLYLLES SA FERRIZ AUTOMOCI N LA MOTO MOTOS CANALES FERMOTO MOTOS VERDI MOTOS RACING BOFARULL 51 MARIN URRUTIA MOTOS S L MOTO YUS MOTOS PERERA MOTOBOX MOTO CARLOS HERNANDEZ JADE MOTOR CAMARENA MOTOS everyday adventure ADDRESS TELEPHONE C Juan de Toledo 8 967 219337 Ctra Madrid 31 96 5229535 Santos Z rate 10 12 Apdo 9 950 231902 C Jaume Borrell 8 93 7957151 Avda Portugal 49 920 213667 Avda Carolina Coronado 1 924 254672 Napoles 327 tienda 93 4573378 Valencia 109 93 4513277 alcala de Guadaira 19 93 2664182 Avda Luis Moran 29 980 636302 C Gerona 7 974 428649 J R Jimenez s n Pol Pentasa 3 Nave 189 947 265541 Argentina 7 bajos Apdo 278 927 221365 Ctra Nac 301 Km 431 968 310 118 Ronda de Santa Maria 8 926 225254 OFFICIAL DISTRIBUTOR LIST RS3 NAKED 50 EE everyday adventure TOWN OFFICIAL DISTRIBUTORS ADDRESS TELEPHONE CORDOBA EL MOTORISTA CORDOBA S L Pol Chinales Avd Arnold Joseph Toymbee 53 957 102 634 CUENCA MOTOS DIONISIO S L Paseo San Antonio 8 969 212012 El VENDRELL Tarragona ESTEVE C Teixidors 32 35 Pollnd La Cometa 977 661312 FIGUERES Girona TECNIMOTO Tapis 83 85 972 510218 GIRONA MOTOS CASADEMONT Figuerola 49 972 205315 GRANADA CIAL
16. Llum 20 Pere Puig 109 Foneria 13 Avda Barcelona 85 Avda de Buenos Airess n Pintor Pedro Flores 31 TELEPHONE 956 358502 981 175000 94 4630721 987 235473 987 202458 973 213500 941 234081 982 245875 914 335 460 95 2240934 952 337400 93 8750797 93 7753636 93 7961326 93 6682683 982 521951 968 352 594 OFFICIAL DISTRIBUTOR LIST 3 E everyday adventure TOWN OFFICIAL DISTRIBUTORS ADDRESS TELEPHONE MURCIA SALVADOR RUBIO Cartagena 34 902 021862 ORENSE TALLERES NOVOA Avda de Santiago 56 Bajo 988 211497 PALENCIA MOTOS TATO S L Avda Casado del Alisal 47 979 712468 PAMPLONA Navarra REMOBI Bernardino Tirapu 29 948 128157 PIERA Barcelona MOTOS ISART Avda de la Carretera 83 93 7760035 PINEDA DE MAR Barcelona CICLOS ORTEGA Anselm Clave 2 93 7670679 PREMIA DE MAR Barcelonal MOTOS RUBIO Jaume Balmes 54 93 7523617 REUS Tarragona MOTOBIKE Avda President Macia 6 977 753137 RUB Barcelonal MOTO CISCAR S L Crtra de Terrassa 70 72 93 6994847 SABADELL XTREM MOTO Paco Mutllo 141 93 7166794 SALAMANCA DAKAR BIKES Paseo de Canalejas 123 923 210730 SAN SEBASTIAN Guip zcoa COMERCIAL VELOMOTO Nueva 1 Apdo 3055 943 287819 SANT ADRI DE BESOS MOTOS SAN ADRIAN C Santa Caterina 26 28 93 3817183 SANTANDER Cantabria MOTOS TITIN Cisneros 87 942 376458 SANT BO DE LLOBREGAT Barcelona B F N MOTOR S C P Crist for Colom43 93 6303415 EN 6 NAKED 50 OFFICIAL DISTRIBUTOR LIST
17. NICAL DATA RS3 NAKED 50 everyday adventure Chassis Dual triangular steel tube double cradle Electrical Equipment Ignition 12 v 120 w Generator 12 pin Moric Ignition advance 20th 1 4 mm before P M S Battery 12 v 3 Ah Fuse 10 Ah Transmission oil Type SAE 10W 40 Quantity 820 Oil tank injection system Type CASTROL TTS Injection System Quantity 1 075 L Brake Discs Front 300mm disc Dual piston caliper Rear 220 disc 6 NAKED 50 TECHNICAL DATA everyday adventure Air filter Paper Fuel Type Unleaded petrol 95 Tank Capacity 12 L Carburettor Dell Orto PHBN 16 Spark plug Type NGK BR 9 ES Electrode CLearance 06 0 7 mm Clutch type Multi disc oil immersed Primary drive Clutch ring Pinion Transmission ratio Secondary transmission Motor output sprocket Drag plate Transmission ratio Chain TECHNICAL DATA R53 NAKED 50 E everyday adventure Voltage and power bulbs Headlight 12V 35 35W Light position 12V 5W Taillight Leds Uashboard Leds Indicators 12V 10W GEAR SHIFT Main shaft Output shaft Gear ratio Output Ratio Z TZ 26 1 300 1 45 50 RES Z 33 1 2 06 193126 Leo 19279 153 1877 Lez 123 18 62 Le 104 15 80 Lezo 096 14 56 RS3 NAKED 50 TECHNICAL DATA OFFICIAL DISTRIBUTOR LIST TOWN ALBACETE ALICANTE ALMERIA ARENYS DE MAR AV
18. OWN OFFICIAL DISTRIBUTORS ADDRESS TELEPHONE VILANOVA LA GELTR Barcelona TALLERES PUJANTE Rambla Ventosa 29 93 8154186 VILLAVICIOSA Asturias Oviedo RENDUELES MOTOS Pedro Pidal Arroyo 9 98 5891105 VITORIA lava MM RACING Arana 28 bajos 945 254564 ZAMORA M ARG ELLO BRU A C Cuesta de la Morana 11 980 528331 ZARAGOZA SOROA MOTOS Avila 9 976 350563 ZARAGOZA AGRIMOTO S L Juan Pablo Bonet 20 976 274109 ISLAS BALEARES EIVISSA RONSANA Avda lgnacio Wallis 44 Apdo 863 971 315219 MAO Menorca MOTOS JERONIMO Cami de Ses Vinyes 68 70 971 365122 MANACOR JAUME MASCARO BARTOLOME Avda Baix D es Cos 74 971 550248 ISLAS CANARIAS LA LAGUNA Tenerife DAGARA Calvo Sotelo 73 Apdo 280 922 250008 LAS PALMAS Gran Canaria MOTO SERVICIO OSCAR BOLA OS C Aguadulce 36 928 246111 ANDORRA ESCALDES ENGORDANY TOYOTA MOTORS Avda Fiter i Rossell 4 00376824413 OFFICIAL DISTRIBUTOR LIST E RIEJU Tor everyday adventure T RIEJU for everyday adventure www riejumoto com C RIEJUSA Borrass 41 PO 9 17600 FIGUERES GIRONA SPAIN T 34 972 500 850 34 972 506 950 rieju riejumoto com VOUS BENEFICIEZ D UNE GARANTIE CONSTRUCTEUR DE 2 ANS PIECES ET MAIN D OEUVRE TWO YEARS OF TOTAL WARRANTY IN OUR PRODUCTS PARTS AND MANPOWER DOS A OS DE GARANTIA M O Y PIEZAS
19. R The good performance and durability of engine parts connecting rod piston piston rings crankshaft Bearings and the cylinder depends the condition of the oil and the air filter To access the filter box you will need to remove the driver seat See section REMOVE PILOT SEAT then Remove the 2 screws A 2 Remove the cap by pulling back 3 Remove the filter L The air filter should be cleaned in the periods shown in the maintenance table ATTENTION If you drive a moped in dusty areas you should increase cleaning frequency This will prolong the life of the moped and its engine parts MAINTENANCE RS3 NAKED 50 69 mmm E everyday adventure COOLING SYSTEM CHECKING AND FILLING THE COOLANT LEVEL CAUTION Never open the radiator tank cap with the engine hot fluid can splash out due To pressure TO CHECK THE LEVEL 1 Remove the cap A with a cold engine releasing the pressure 2 Check the coolant level when engine is cold because if varies depending on engine temperature The coolant level should cover the radiator panel and not must go beyond Lip B 3 If the level is Lower add coolant amp Replace fhe cap Coolant Type CASTROL ANTIFREEZE EM 70 RS3 NAKED 50 MAINTENANCE everyday adventure MOTOR OIL CHECKING AND FILLING THE ENGINE OIL LEVEL The clutch and gear lubrication is by oil which is located inside the housing We recommend Castrol 10W
20. X The current setting is 4 pulses Now the 4 is flashing The setting range 1 6 pulses Setting unit 1 pulse rri Press the Adjust button 2 Times to return to the main screen EX The RPM pulse setting is changed from 4 to 3 NOTE When you leave The screen the setting is saved EM NAKED 50 CHECKS BEFORE DRIVING everyday adventure SAFETY WARNINGS AND PRECAUTIONS It is very important that you know your moped and how it operates PRECAUTION Remember do not leave the engine running in an enclosed space as the exhaust gases may be toxic and may result in serious health consequences STARTING THE ENGINE If the motor is cold use the choke control Located on the bike s lower left handlebar Turn the key clockwise check that the engine is in neutral release the accelerator and press the electric start Remember not to press the electric start switch for more than five seconds at a time A few seconds after the engine has started up the choke should be returned to its original position Then press the clutch and engage first gear progressively releasing the clutch lever as the accelerator is smoothly operated Do not fully accelerate or operate the engine at a high rev count until it is sufficiently heated up ATTENTION Before moving off you should always allow the engine sufficient time to warm up and never accelerate hard when the engine is cold This will guarantee longer engi
21. apply grease on the ends of the wires and the terminals Make sure the connections are correct otherwise you will damage the battery Remember that you should pay particular attention to the handling and treatment of the battery as if contains sulfuric acid and therefore run the risk of burning skin eyes and clothing Also keep away from flames sparks When changing the battery change 11 with the same specification battery see Data section RS3 NAKED 50 MAINTENANCE everyday adventure BATTERY REPLACEMENT To access the battery you must remove the passenger seat See section REMOVE PASSENGER SEAT 1 Disconnect the two cables Negative Al Positive B 2 Remove the rubber strap C and then remove the battery ATTENTION If you replace the battery be sure that the new standard 12V 3Ah capacity which allows up to 6A is fitted MAINTENANCE R53 NAKED 50 o E everyday adventure FUSE CHECK AND REPLACING THE FUSE The fuse 10 is located next to the battery under the seat pas senger If the fuse blows turn off the engine and replace it by a new one of the Same rating Reconnect and see if the electrical system works ATTENTION Never use fuses of higher amperage than recommended H could damage or even burn the electrical system correct 6 RS3 NAKED 50 MAINTENANCE everyday adventure AIR FILTER CLEANING AND REPLACING THE AIR FILTE
22. can be found on the left side of the motorbike it s operated by the foot through its full range of travel and letting it return to its rest po sition before changing gear again To engage first gear the pedal should be pressed down with the foot the other 5 gears are achieved by raising the pedal by placing The foot underneath the pedal and lifting Neutral gear is between first and second gear BATTERY The battery is placed under the passenger seat See section OPEN AND CLOSE PASSENGER SEAT heck that the terminals 1 are cleaned and correctly secure The battery of the model RS3 NAKED 50 dont need maintenance EN gt MAIN ELEMENTS OF THE MOPED R53 NAKED 50 everyday adventure FUSE The fuse is placed under the passenger seat See section OPEN AND CLOSE PASSENGER SEAT The fuse 1 is 10 Amps and is located next to the battery MAIN ELEMENTS OF THE MOPED RS3 NAKED 50 E E everyday adventure FUEL TANK To remove the fuel tank cap you need to use one of the ignition keys To do this follow these steps 1 Lift the flap A 2 Insert the key into the Lock B 3 Turn the key 90 degrees clockwise 4 Pull the cap back W ADVICE The fuel tank includes a drain C to avoid fuel spilling over the reservoir ATTENTION Always wipe dry any splashing or spills from the bikes plastics The tank capacity is 12 litres Remember to always use unlea
23. ded petrol 95 EM 32 R53 NAKED 50 MAIN ELEMENTS OF THE MOPED everyday adventure OIL TANK The oil filler cap is located underneath the pillion passenger seat ATTENTION Never let the oil reach empty or it will be necessary to purge the oil pump in order to remove all the air If this happens the motor will immediately seize causing expensive repairs ATTENTION When filled or checked make sure that the filler cap is shut securely ATTENTION Rieju recommends the use of TTS Castrol Oil System Injection The tank capacity 1075 litres MAIN ELEMENTS OF THE MOPED R53 NAKED 50 a everyday adventure TYRES The tire pressure directly affects the stability Moped comfort and bra king distance correct pressures are essential for safe use therefore you Should check the inflation pressure often W ADVICE Do not overload the moped as well as losing stability it increa ses the tyre wear ADVICE When the tyre pressure is too high it fails to absorb the impact of the road surface this can have adverse effects on stability and comfort dimensions bar Front 100 80 17 19 kg cm Rear 190 70 17 2 2 kg cm gt RS3 NAKED 50 MAIN ELEMENTS OF THE MOPED everyday adventure STAND The stand 1 is located under the gear lever on To deploy the stand use the foot lever 2 ADVICE 72 When using the stand make sure that it is placed on
24. e leave all connections moisture free LONG TIME STORAGE For prolonged storage of the motorbike it is advised that all cleaning procedures above are adhered to prevent any likelihood of deterioration Once the motorbike has been thoroughly cleaned it can be readied for storage as follows 1 Drain all fuel from the tank pipes and the carburettor 2 Lubricate all control cables 3 Seal the exhaust pipe to prevent the entry of any moisture 4 Remove the battery and charge at least once a month be careful to ensure the battery is stored in the correct conditions CLEANING AND STORAGE RS3 NAKED 50 7 E everyday adventure TECHNICAL DATA Suspension Front Hydraulic inverted fork 41mm SHOWA oil capacity 210c c per leg Rear MONO SHOLK absorber Brake Discs Front 300 mm Rear 220 mm Tyres Front 100 80 17 Tubeless 19 kg cm2 Rear 130 70 17 Tubeless 2 2 kg cm2 6 RS3 NAKED 50 CLEANING AND STORAGE everyday adventure Dimensions Total length 2 020 mm Overall width 770 mm Overall height 1090 mm Seat height 845 mm Wheelbase 1375 mm Ground clearance 250 mm Dry weight 119 kg Motor Type 2 stroke Number of Gears 6 speed Brand NG Minarelli 50c c Model AM 6 EU2 Lylinders arrangement Single inclined Displacement 30 Bore x Stroke 40 3 x 39 mm Starting System Electrical Lubrication system Autolube Dil type 2 stroke injection TECH
25. en block between the end of the fork and the ground to make it easier to replace the tyre This way makes it easier 10 line the holes up in the wheel and the forks 05 well To remove the front wheel follow these steps 1 Remove the nut A 2 Loosen the screw B 3 Remove the spindle L to release the spacer D and the wheel 4 Remove the wheel EN gt RS3 NAKED 50 MAINTENANCE everyday adventure ATTENTION Pay close attention to the correct position of the spacer U located on the right side ADVICE Never operate the brake lever during this operation ADVICE These operations can be somewhat complicated bo to an offi cial RIEJU dealer to ensure proper procedure is taken gt FRONT WHEEL ASSEMBLY ATTENTION Make sure you insert the brake disc between the brake pads on the caliper MAINTENANCE RS3 NAKED 50 55 mmm everyday adventure REAR WHEEL REMOVING THE REAR WHEEL CAUTION Place the motorcycle on a flat and firm surface before attempting to remove the rear wheel ATTENTION Suspend the moped from the rear fo ensure the rear tyre is off the ground ADVICE W Place a wooden block between the rear swing arm and the ground to make it easier to realign the rear tyre with the holes To remove the rear wheel follow these steps Loosen the nut A that secures the rear wheel axle 2 Loosen the lock nuts of the chain tension
26. end position to start the engine when the bike IS COOL With the lever press push the start button Once the engine is running take off the choke control an turn the throttle ATTENTION When the engine is on the correct running temperature dont push the choke control use in this situation can produce the incorrect function of the engine EM 24 RS3 NAKED 50 MAIN ELEMENTS OF THE MOPED everyday adventure IGNITION SWITCH Use this switch to starth the engine To start the engine push the switch 1 once the engine in on turn a litte the throttle grip 2 W CAUTION Check the engine is in neutral position ATTENTION When the engine is On take off the ignition switch ATTENTION Dont use the ignition switch when the engine is running use the switch in this situation can produce damages on the star engine with grew technical and economics problems for the costumer MAIN ELEMENTS OF THE MOPED RS3 NAKED 50 E everyday adventure OPEN AND CLOSE DRIVER SEAT To open the seat 1 Put the key on the keyhole 2 Turn 45 to right position 3 Take out the key of the hole 4 Pull out the seat by the rear side To close the seat Put the central guide under the support 0 2 down the rear side of the seat and check that is correctly close E RS3 NAKED 50 MAIN ELEMENTS OF THE MOPED everyday adventure OPEN AND CLOSE PASSEN
27. everyday adventure To do this follow these steps 1 Set The gearbox in neutral 2 Loosen the nut that secures the rear wheel axle 3 Loosen the 2 nuts B 4 Using the bolts C adjust the chain tension ensuring it is always the same distance on both sides of the axle To do so use the rule marks on of the swing arm 5 Set the position using the 2 nuts 6 Tighten the nut A that secures the rear wheel axle MAINTENANCE RS3 NAKED 50 E everyday adventure FRONT BRAKE SYSTEM FRONT BRAKE DISC The front brake has a 300 mm diameter brake disc operated by a lever and a hydraulic pump The braking surface must be free of grease and dirt 10 ensure perfect operation FRONT BRAKE LEVER ADJUSTENT To increase or decrease The tension of the front brake Loosen the nut A 2 With Allen key No 4 increase or decrease the action of front brake through the threaded shaft B 3 Set the position by re tightening nut A ATTENTION The adjustment of the front brake Lever is between 1mm to 3mm of clearance measured at the end ning of The lever MAINTENANCE EN R53 NAKED 50 everyday adventure CHECKING AND TOPPING UP FRONT BRAKE FLUID LEVEL ADVICE Place the motorcycle so that the tank is parallel to the ground If for any reason you have to fill the brake fluid proceed as follows Remove the cap from the brake re
28. f the most important components of the engine as it results in good engine performance when working correctly The Carburettor is where petrol and dir are mixed poor carburettor operation means poor engine performance which in turn could result in damaged engine parts It is therefore recommended that its adjustment and settings are checked and corrected at an authorised RIEJU dealer SAFETY amp PRECAUTIONS R53 NAKED 50 o E everyday adventure MAINTENANCE MAINTENANCE OPERATIONS ua NEN en ne Brake system checks Transmission oil Level checks Exchange Exchange Chain tension and wear checks Suspension Checks Check adjust and lubricate controls and cables leaning and greasing of air filter Inspect and adjust carburettors Inspect and adjust the sparkplug or replace it Inspect All nuts and bolts for the chassis and plastics Check the electrical System Inspect segment wear Inspect radiator water levels Inspect exhaust system Check terminals and battery condition Check oil pump operation e Perform specified operation gt RS3 NAKED 50 MAINTENANCE everyday adventure mE CLUTCH LEVER CONTROL AND CLUTCH LEVER ADJUSTMENT To increase or decrease the tension on the clutch lever 1 Remove the rubber A 2 Loosen the adjuster nut B 3 Move the wheel C to load or unload the cable 4 Re
29. ing these checks you find a problem it should rectified before the bike is used again BEFORE OPERATION CHECKS RS3 NAKED 50 E everyday adventure INDICADOR DIGITAL 1 Veloc metro El velocimetro indica la velocidad en Km h o MPH 2 Kms Millas Indicador de los Kms o Millas total recorridos Indica tambi n 105 Kms o Millas parciales 3 Reloj Indicador de la hora y minutos MARK MEANING PRESS NOTE You could get the installation details from the information behind the mark PRESS THE BUTTON Some processes must be followed to avoid the affection caused by wrong installation 3 SECONDS gt RS3 NAKED 50 BEFORE OPERATION HELKS everyday adventure 2 THE CLOCK SETTING Press the Select button x 3 seconds in main screen to enter the clock adjust screen Press the select button to choose the number you want to set Ex Now the Time is 0 00 Now the hour number is flashing NOTE The clock is 24 H Press the Adjust button to enter the minute setting EX Now the hour is changed from o to 13 CHECKS BEFORE DRIVING RS3 NAKED 50 E everyday adventure Press the Select button to choose the number you want to set Now the minute number is flashing ADF Press the Select button again to return to the main screen EX Now the minute is changed from o to 1 NOTE When you leave the screen the setting is saved 0 RS3 NAKED 50 CH
30. ne life CHECKS BEFORE DRIVING RS3 NAKED 50 everyday adventure EQUIPMENT ADVICE Choose a good quality helmet for use with the motorcycle Use comfortable clothing that will not get caught anywhere in the motorcycle when riding STARTING YOUR ENGINE FOR THE FIRST TIME RUNNINGIN The most important time of your motorbikes life is between 0 and 500 Kms For this reason 11 15 strongly recommended that you carefully read the following instructions During the first 500 Kms you shouldnt overload the motorbike because the motor is new and the different parts are wearing and polishing against each other until they work perfectly together During this period of time prolonged use at high revolutions should be avoided along with conditions which could lead to excessive engine heating and shorter life span ACCELERATION The speed is adjusted by opening or closing the throttle Rotating the throttle backwards will increase the speed where as rotating forwards will reduce the speed RS3 NAKED 50 SAFETY amp PRECAUTIONS everyday adventure BRAKING lose the accelerator and progressively operate both the front and rear brakes progressively WARNING Sharp Braking can cause skids or bouncing STOPPING Llose the accelerator operate both brakes simultaneously When speed has been reduced fully depress the clutch lever Turn the engine off by removing the ignition key CARBURETTOR This is one o
31. nt WARNINGS Explain the importance of warning Labels to ensure a long life of the moped KEYS deliver the full set and recommend making a note of the key item reference FIRST SERVICE explain the importance of the service at 500 km 310 miles and the ongoing service schedule PERIODIC MAINTENANCE Explain the need of the periodic maintenance DELIVERY OF THE MOPED R53 NAKED 50 E E everyday adventure IDENTIFICATION OF CHASSIS NUMBER The chassis number is located on the main steering head This identification of chassis number is important to confirm the charac teristics of your machine registration etc and it should be quoted when requesting spare parts ENGINE IDENTIFICATION NUMBER The engine serial number is located on the top left side under the carburettor The engine number will serve as a reference when requesting spare parts from the dealership EM 1 RS3 NAKED 50 INDENTIFICATION NUMBER IDENTIFILATION LABEL Under directive 97 24 EC an ID Label containing the main components of the moped is Located on the left front section of the swing arm This label confirms the original components as detailed below 1 Air filter 2 Carburettor 3 Inlet manifold 4 Cylinder cc 5 Cylinder Head 6 Engine crankcase ID 7 Exhaust header 8 Exhaust silencer 9 Drive sprocket 10 Rear sprocket 11 EDI Ignition system 12 IDENTIFICATION LABEL
32. ny eventuality please consult a RIEJU dealer who will assist you at all times or alternatively access our website wwwriejumoto com Remember for the proper functioning of the motorbike you should always use genuine original RIEJU parts everyday adventure CONTENTS DESCRIPTION OF THE MOPED 12 DELIVERY OF THE MOPED 13 IDENTIFICATION OF CHASSIS NUMBER 14 ENGINE IDENTIFICATION NUMBER 14 IDENTIFICATION LABEL 15 IDENTIFICATION OF THE MOPED right side 16 IDENTIFICATION OF THE MOPED Left side 17 INSTRUMENTS AND CONTROLS 18 INSTRUMENTS AND INDICATORS 19 Ignition Lock 19 Steering Lock 19 Dashboard instruments 20 everyday adventure MAIN ELEMENTS OF THE MOPED Light switch 23 Indicator switch 23 Horn switch 24 Choke control 25 Ignition switch 25 Open and close driver seat 26 Open and close passenger seat 27 Throttle grip 28 Clutch lever 28 Front brake 29 Rear brake 29 Gear change pedal 30 Battery 30 Fuse 31 Fuel tank cafuel cap 32 Oil tank 33 Tyres 34 everyday adventure Stand 35 CHECKS TO CARRIED OUT BEFORE OPERATING Table of checks to be done 36 Indicador digital 38 SAFETY WARNINGS AND PRECAUTIONS Starting the engine 47 Equipment 48 Starting your engine for the first time runningin 48 Acceleration 48 Braking 49 Stopping 49 Carburettor 49 MAINTENANCE
33. rics 2 Turns off system electrics 3 Electrical system is activated and start up 4 Activates the electrical system and low beam lights and start up STEERING LOCK To lock the steering follow these steps Turn the handlebars far over to the left 2 Place the key in this position 29 3 Press the key and turn to the Lock position ff 4 Remove key TABLE OF INSTRUMENTS AND WARNING RS3 NAKED 50 _ everyday adventure DASHBOARD INSTRUMENTS 1 Tachometer Indicates the number of engine revolutions per minute 2 Tachometer Warning Light Flashes red when engine revolutions reach 10 000 per minute 3 Speedometer The speedometer indicates speed in KM H or 4 Odometer Indicates total kilometres miles travelled and also partial kilometres miles travelled 5 Clock Indicates the time in hours and minutes 0 RS3 NAKED 50 TABLE OF INSTRUMENTS AND WARNING everyday adventure 6 Battery Indicator Red indicator light flashes when the battery needs charging 7 Beam indicator Blue indicator lights up when the headlamps are on 8 Oil Reserve Indicator The red indicator lights up when the level of motor oil is low Le When it reaches the reserve level It is vital when the light comes on you fill up the oil tank as soon as possible If the tank is not filled the engine could be Seriously damaged TABLE OF INSTRUMENTS AND WARNING RS3 NAKED
34. se between km h amp MPH The odometer and trip meter will changetogether with the speed unit setting ela e CHECKS BEFORE DRIVING RS3 NAKED 50 0 EE everyday adventure Presione el bot n Adjust 3 veces para volver a la pantalla principal NOTE Cuando abandone la pantalla el ajuste se guardar 5 AJUSTE EL SENSOR DE PULSO En La pantalla principal presione hacia abajo ambos botones Ajdust y Select durante 3 segun dos para entrar el ajuste de la circunferencia del neum tico En la pantalla de ajuste presione el bot n Adjust 5 veces y luego entre el ajuste del sensor de pulso EN 6 NAKED 50 CHECKS BEFORE DRIVING everyday adventure Press the Select button to choose the number you want to set EX The current setting is 5 pulses Now the 5 is flashing The setti e 112 pulses ng rang puls Setting unit 1 pulses Press the Adjust button 2 times to return to the main screen EX The sensor pulses is changed from 5 to 6 NOTE When you leave the screen the setting is saved 6 THE RPM PULSE SETTING In main screen press down both Adjust amp Select buttons X 3 seconds to enter the fire cir cumference setting CHECKS BEFORE DRIVING RS3 NAKED 50 _ everyday adventure In the setting screen press the for Adjust button 6 times and then you will enter the RPM pulse setting Press the Select button to choose the number you want to set E
35. servoir A 2 Remove the rubber seal 3 Fill until the liquid exceeds the MIN mark on the viewing port C Recommended fluid DOT 4 ADVICE Ensure the rubber seal is replaced before refitting cap CAUTION To completely replace the fluid braking system please contact your official RIEJU dealer MAINTENANCE RS3 NAKED 50 61 mu E everyday adventure REAR BRAKE SYSTEM REAR BRAKE DISC The front brake has a 220 mm diameter brake disc the brakes are ope rated by a foot lever and a hydraulic pump The braking surface must be free of grease and dirt to ensure perfect operation and avoid skidding AUJUSTING THE REAR BRAKE LEVER To increase or decrease the tension of the rear brake Loosen the nut A 2 Adjust the pressure through the rod B 3 Set the position with the nut A EM 62 RS3 NAKED 50 MAINTENANCE everyday adventure FILL LEVEL CONTROL AND REAR BRAKE FLUID If for any reason you need to fill the brake fluid Proceed as follows 1 Remove the pump cover A 2 Remove the rubber seal see picture section and fill level control front brake fluid 3 Fill until the liquid exceeds the MIN mark on the viewing port Recommended fluid DOT 4 ADVICE Ensure the rubber seal is replaced before refitting cap CAUTION To completely replace the fluid braking system please contact your official RIEJU dealer MAINTENANCE RS3 NAKED 50 o E
36. with electric start 115 displacement is 50 cubic centimetres with a diameter of 40 3 mm bore and a stroke of 39 mm The ignition is carried out through an electronic generator 120 W 12 volt AT coil Clutch is multiple disc of steel and friction with springs of constant pressure submerged in oil bath The engine is housed in a dual perimeter chassis of triangular section to provide great strength and handling with conical type bearings Headlights are dual poliepsoidal beam Speedometer amp instrument panel is digital The front suspension consists of a hydraulic inverted fork with 41 mm in diameter The rear suspension consists of a Mono Shock damper The front disc brake is 300 mm diameter with a double piston caliper The rear brake is 220 mm in diameter Wheels are aluminium 17 inch RS3 NAKED 50 DESCRIPTION OF THE MOPED everyday adventure DELIVERY OF THE MOPED PRE DELIVERY INSPECTION amp HANDOVER EXUSER MANUAL very important this explains in detail the essential functions of the moped safe use and important maintenance practices OPERATION Explain the functions amp correct handling of the moped ADJUSTMENT of mirrors Set to the correct position for the user ADJUSTMENT CLUTCH LEVER Adjust to suit REAR BRAKE LEVER ADJUSTMENT Adjust to the correct height for the user GEAR LEVER adjustment Adjust to the correct height for the user TOOL KIT Indicate the Location and check the conte
Download Pdf Manuals
Related Search