GV65Lite User Manual - Rainbow wireless. Quectel, Queclink, Maestro
Contents
1. 11 222 012 nnne ener rne 7 TABLE 2 TERMS AND 5 7 TABLE 3 ALI DD T 9 TABLE 4 DESCRIPTION OF 10 PIN CONNECTION S 10 TABLE 5 GV65LITE USER CABLE COLOUR DEFINITION 10 TABLE 6 GPS ANTENNA SPECIFICATION 13 TABLE 7 ELECTRICAL CHARACTERISTICS OF IGNITION DETECTION 13 TABLE 8 ELECTRICAL CHARACTERISTICS OF THE DIGITAL INPUTS 14 TABLE 9 ELECTRICAL CHARACTERISTICS OF DDIGITAL OUTPUTS 16 TABLE 10 DEFINITION OF DEVICE STATUS AND LED 18 TRACGVOSLiteUMOOI 4 GV65Lite User Manual gt L SOLUTIONS FIGURE 1 FIGURE 2 FIGURE 3 FIGURE 4 FIGURE 5 FIGURE 6 FIGURE 7 FIGURE 8 FIGURE 9 FIGURE 10 FIGURE 11 FIGURE 12 FIGURE 13 FIGURE 14 Figure Index APPEARANCE OF GV 65LITE 8 THE 10 PIN CONNECTOR ON THE GV65LITE 9 S hI dC o M 11 ISO SUNG hi CASE 1 85 4 eee 112. Figure 10 Typical Digital Input Connection 3 9 Digital Outputs There are two digital outputs on GV65Lite All are of open drain type and the maximum drain current is 150mA Each output has the built in over current and recovery PTC fuse TRACGV65LiteUM001 15 GV65Lite User Manual SOLUTIONS Gate 1 ee source 2 Figure 11 Digital Output Internal Drive Circuit Table 9 Electrical Characteristics of Ddigital Outputs Logical State Electrical Characteristics Enable 1 5V 150mA Disable Open drain Figure 12 Typical Connection with Relay TRACGVOSLiteUMOOI 16 IRELESB SOLUTIONS GV65Lite User Manual LED Resistor or 8 32 Figure 13 Typical Connection with LED Note 1 OUT1 will latch the output state during reset 2 All outputs are internally without pulled up to PWR pin by a diode So an external flyback diode is needed when the output is connected to an inductive load 3 10 Device Status LED i fi 2 CEL LED uw e GPS LED PWR LED Figure 14 GV65Lite LED on the Case GV65Lite has three status led that CEL GPS PWR led TRACGVOSLiteUMOOI 7 GV65Lite User Manual Table 10 Definition of Device status and LED Device is searching GSM network Fast flashing Device has registered to GSM network Slow flashing Note4 SIM card needs pin code to unlock ON GPS chip is powere
3. ARDIN 12 THE EXTERNAL GPS ANTENNA OF GV65LITE 12 itu dur 13 TYPICALIGNITION DETECTION 14 TYPICAL DIGITALINPUT CONNECTION 15 TYPICAL DIGITAL INPUT CONNECTION 15 DIGITAL OUTPUT INTERNAL DRIVE CIRCUIT 16 TYPICAL CONNECTION WITH RELAY 50 77 16 TYPICAL CONNECTION WITH I4 amp D 17 GVOSLITE LED ON THE CASE 9 45 Nee nnn 17 TRACGVOSLiteUMOOI 5 GV65Lite User Manua 5 SOLUTIONS 0 Revision History 2013 12 2 Richard Deng Initial TRACGVOSLiteUMOOI 6 GV65Lite User Manua gt 5 SOLUTIONS 1 Introduction The GV65Lite is a powerful GPS locator designed for vehicle or asset tracking It has superior receiver sensitivity fast TTFF Time to First Fix and supports Quad Band GSM frequencies 850 900 1800 1900 its location can be monitored in real time or be periodically tracked by a backend server or other specified terminals The GV65Lite has multiple input output interfaces that can be used for monitoring or controlling external devices Based on the integrated Track protocol the GV65Lite can communicate with a backend server through the GPRS GS
4. 2 Queciink WIRELESS SOLUTIONS GSM GPRS GPS Tracker GV65LIte User Manual TRACGV65BLIiteUMOO1 Revision 1 01 GV65 Lite Designed by Queclink 3286020000239 http www queclink com sales queclink com GV65Lite User _ SOLUTIONS Document Title GV65Lite User Manual Document Control ID TRACGV65LiteUMO001 General Notes Queclink offers this information as a service to its customers to support application and engineering efforts that use the products designed by Queclink The information provided is based upon requirements specifically provided to Queclink by the customers Queclink has not undertaken any independent search for additional relevant information including any information that may be in the customer s possession Furthermore system validation of this product designed by Queclink within a larger electronic system remains the responsibility of the customer or the customer s system integrator All specifications supplied herein are subject to change Copyright This document contains proprietary technical information which is the property of Queclink Limited copying of this document and giving it to others and the using or communication of the contents thereof are forbidden without express authority Offenders are liable to the payment of damages All rights reserved in the event of grant of a patent or the registration of a utility model or design All specification sup
5. 3V or Open TRACGV65LiteUM001 13 GV65Lite User 2 Vehicle tanitian e c position Ruma posltlon Accesores 2nd position OM 151 lt DC Figure 8 Typical Ignition Detection IGN Pin9 is used for ignition detection It is strongly recommended to connect this pin to ignition key RUN position as shown up An alternative to connecting to the ignition switch is to find a non permanent power source that is only available when the vehicle is running For example the power source for the FM radio IGN signal can be configured to start transmitting information to backend server when ignition is on and enter power saving mode when ignition is off 3 7 Digital Inputs There are two general purpose digital inputs on GV65Lite They are all negative trigger Table 8 Electrical Characteristics of the digital inputs Logical State Electrical Characteristics Active OV to 0 8V Inactive The following diagram shows the recommended connection of two digital inputs TRACGVOSLiteUMOOI 14 GV65Lite User Manual Panic button M Panic button Figure9 Typical Digital Input Connection 3 8 Analog Inputs There is one analog input on GV65Lite the analog input voltage range could be selectable it includes 0 12 0 30 and the default range is from O to 30V The following diagram shows the recommended connection ADC INPUT GND
6. M network to transfer reports of Emergency geo fence boundary crossings scheduled GPS position as well as many other useful functions Users can also use GV65Lite to monitor the status of a vehicle and control the vehicle by its external relay output System Integrators can easily setup their tracking systems based on the full featured OG Track protocol 1 1 Reference Table 1 GV65Lite Protocol Reference GV65Lite 9 Track Air Interface Protocol The air protocol interface between GV65Lite and backend server 1 2 Terms and Abbreviations Table 2 Terms and Abbreviations Abbreviation Description AGND Analog Ground Digital Input DOUT Digital Output Ground Receive Data AIN DIN Microphone Transmit Data SPKN Speaker Negative SPKP Speaker Positive TRACGVOSLiteUMOOI 7 GV65Lite User Manua 2 SOLUTIONS 2 Product Overview 2 1 Check Part List Before starting check all the following items have been included with your GV65Lite If anything is missing please contact your supplier GVG5 Lite uncis Figure 1 Appearance of GV65Lite TRACGVOSLiteUMOOI 8 GV65Lite User manual 222222222200 SOLUTIONS 2 2 Parts List Table 3 Part List Name Picture GV65Lite Locator 73mm 54mm 22 7mm User Cable GPS Antenna Optional DATA_CABLE_M Optional 2 3 Interface Definition The GV65Lite has a 10 PIN interface connector It contains the connections for pow
7. d off GPS sends no data or data format error Slow flashing GPS chip is searching GPS info Fast flashing GPS chip has gotten GPS info PWR No external power and internal battery voltage is OFF note 2 lower than 3 35V No external power internal battery voltage is Slow flashing External power in and internal battery is charging Fast flashing External power in and internal battery is fully ON charged Note 1 GSM LED cannot be configured 2 GPS LED and PWR LED can be configured to turn off after a period of time using the configuration tool Fast flashing is about 605 ON 780ms OFF 4 Slow flashing is about 605 19405 OFF TRACGVOSLiteUMOOI 18
8. er I O etc The sequence and definition of the 10PIN connector are shown in following figure Figure 2 The 10 PIN connector on the GV65Lite TRACGVOSLiteUMOOI 9 GV65Lite User manual 2 N MN A q R Q Nh TWTWmwettss SOLUTIONS Table 4 Description of 10 PIN Connections Description Comment External DC power input 8 32V 2 GND GND Open drain 150 max Fuel ADC input OUT1 Open drain 150mA max with latch circuit 1 wire data bus Digital input negative trigger Digital input negative trigger Ignition input positive trigger 1 wire device power output 2 4 GV65Lite User Cable Colour Table 5 GV65Lite User Cable Colour definition Definition PIN Definition Colour Cable Colour NO aom DATA_1W White Black TRACGVOSLiteUMOOI 10 GV65Lite User Manual Que Chink WIRELESS SOLUTIONS 3 Getting Started 3 1 Opening the Case 3 Designed by Liste null ade M gt are i amp AE Puni 12 eee GV65 Lite Figure 3 Opening the Case Insert the triangular pry opener into the gap on both sides of the case as shown above push the opener up until the case unsnapped 3 2 Closing the Case Figure 4 Closing the Case Place the cover on the bottom in the position as shown in the above figure Press the front case and the back case until it snapped TRACGV65LiteUM001 11 GV65Lite Us
9. er Manual SOLUTIONS 3 3 Installing a SIM Card Open the case and ensure the unit is not powered unplug the 10Pin cable Slide the holder right to open the SIM card Insert the SIM card into the holder as shown below with the gold colored contact area facing down taking care to align the cut mark Close the SIM card holder Close the case Figure 5 SIM Card Installation 3 4 Installing the External GPS Antenna Optional There is a SMA GPS antenna connector on GV65Lite The GV65Lite will automatically detect and use an external antenna when connected Figure 6 External GPS Antenna of GV65Lite TRACGVOSLiteUMOOI 12 GV65Lite User Manual 3 4 1 GPS Antenna Specification Table 6 GPS Antenna Specification GPS antenna Frequency 1575 42MHz Bandwidth gt 5MHz Beam width gt 120 deg Supply voltage 2 7V 3 3V Polarization RHCP Gain Passive OdBi min Active 15dB Impedance 500 VSWR lt 2 Noise figure lt 3 3 5 Power Connection VIN 1 GND PIN2 are the power input pins The input voltage range for this device is from 8V to 32V The device is designed to be installed in vehicles that operate on 12V or 24V systems without the need for external transformers GND DC Figure 7 Typical Power Connection 3 6 Ignition Detection Table 7 Electrical Characteristics of Ignition Detection Logical State Electrical State Active 5 0V to 32V Inactive OV to
10. plied herein are subject to change without notice at any time Copyright Queclink Wireless Solutions Co Ltd 2013 TRACGVOSLiteUMOOI 2 GV65Lite User Manual Contents eu Mr D Season PIS O Dy oe 1 2 Terms and Abbrevlitations Z Progucp ONEIN se De E AUR Z1 Che 22 E E 2 3 Interface Definition LI pert en etta 2 4 GV65Late User Cable Colour WTC MIMO ill 3 L Opening the 3 2 Closins ihe 3 3 Installing a SIM Card M A9 3 4 Installing the External GPS Antenna Optional 3 5 Power Connection Ne eene 3 6 Ignition Detection 8 99 9 Reese 3 7 Digital DEus 3 8 Analog We u m 3 99Die1tal 38lD Device Status BDD Nene Ea TRACGVOSLiteUMOOI ELESS SOLUTIONS GV65Lite User Manual NIECE SS SOLUTIONS Table Index TABLE 1 GV65LITE PROTOCOL
Download Pdf Manuals
Related Search