FGSH-450 Owner`s Manual
Contents
1. N CAUTION Prior to removing the straps of the sling from the carry bar be sure to check that the individual being lifted is securely supported in the final desired position DO NOT lock the rear casters when lifting the individual LOCKED Rear casters during the lifting will increases the risk of the lift tilt over Step 8 Pull the patient lift away from the bed and push from behind the lift with both hands Lower the carry bar sufficiently to allow the straps of the sling to be easily removed from the carry bar Take care not to let the carry bar come in contact with the individual in the sling The straps from the sling can now be removed from the carry bar The lift should then be moved away from the immediate area so that it will not interfere with the removal of the sling from the client Step 9 The sling can now be gently removed from the individual It should then be stored in a safe place for future use Step 10 The lift can now be moved to a safe location until further use or relocated to its original location 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 19 General Care Inspection and Maintenance The Prism Medical Patient Lift is designed to provide a maximum of safe efficient and satisfactory service with minimum care and maintenance All parts of the Prism Medical Lift are made of best grades of steel but metal to metal contact will wear after considerable use There is no adjustment or maintenance2. as shown in Figure 16 Figure 14 Figure 15 Figure 16 Base Shifter Handle Thumb Screw eun Cam Lock Assembly 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 10 Assembly Instructions continued CARRY BAR ATTACHMENT WITH MOUNTING BRACKET 1 Insert the carry bar pin and washers up through the swivel bar pad 2 Align the hole of carry bar pin with the hole of mounting bracket and secure with shoulder bolt and nut provided as shown in Figure 14 Figure 14 i Figure 16 NOTE Make sure that carry bar pin and washers are completely pushed up through the Carry Bar Pad The carry bar has hooks at both ends to attach the sling straps that supports the patient during the lift The carry bar pad should remain in place during normal use After assembly check to ensure that The mast is fully locked into the tube of base assembly Hydraulic pump actuator is moving up and down using the pump handle Control valve is working properly Leg spreading is working properly using the shifter handle Rear wheel brakes works properly 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 11 Operation A Caution Visually inspect the floor lift before using for any unusual wear and tear Should anything look unusual then contact your local representative prior to use Failure to comply with this caution could result in serious injury to the operator the individual being lifted and or damage to
3. refer to the instructions included with the sling 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 3 Technical Specifications FGSH 450 A Dimensions and Weight FGSH 450 lift Rear 5 127 mm w brake Shipping Storage Conditions Normal Operating Conditions Temperature 40 to 70 C Temperature 10 to 70 C Relative Humidity 10 to 100 RH Relative Humidity 30 to 75 RH Atmospheric Pressure 500 to 1060 hPa Atmospheric Pressure 700 to 1060 hPa 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 4 CAUTIONS e Check all parts for shipping damage before using the F SH 450 Hydraulic Steel Floor Lift In case of damage DO NOT use the lift Contact your dealer for further instructions e FGSH 450 Hydraulic Steel Floor Lift is NOT a transport device The FGSH 450 Hydraulic Steel Floor Lift and associated sling s are intended only for lifting and transferring of a person from one resting surface to another such as from bed to wheel chair Moving a person suspended in a sling over any distance is NOT RECOMMENDED Prism Medical will not be responsible for any damage caused by the misuse neglect or purposeful destruction of the lift and or its associated components e Under no circumstance should the FGSH 450 Hydraulic Steel Floor Lift and sling s be put in control of a person who has not been properly trained in the use and care of this equipment Failure to adhere to this warning may result in serious
4. the lift Leg Spreading The legs of FGSH 450 lift are mechanically adjustable for opening and closing base width The Shift er Handle is used to open legs of the base for stability when lifting a patient The legs can be opened to enable access around arm chairs or wheel chairs 1 Grasp the shifter handle in one hand and place the opposite hand on the push handle of the mast for balance as shown in Figure 17 2 Push the shifter handle to your RIGHT to release the lock pin from its mounting hole as shown in Figure 18 3 Turn the handle CLOCKWISE until you are able to secure the lock pin into the opposite mounting hole to fully open the legs of the base as shown in Figure 19 Figure 17 Figure 18 Figure 19 he lock pin MUST be inserted into its mounting hole in the socket assembly to lock he legs n the full open position The shifter handle will be in vertical position parallel ith the mast assembly as shown in Figure 20 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 12 Operation continued Leg Spreading Figure 20 tw s A Figure 21 Figure 22 Lock Pin must be locked in this hole after closing and opening of leg Caution The lock pin is not seated in the socket assembly if the shifter handle is not vertical DO NOT use the patient lift until the lock pin is properly seated and LOCKED in place Failure to comply with this caution could result in serious injury to the in
5. 5 The individual may now be raised by pumping the lift handle of hydraulic actuator While lifting is in progress the height required in order for the transfer to be completed safely should be closely observed A Caution When elevated few inches off the bed and before moving the patient check that sling straps are properly attached If any attachments are not properly in place lower the individual back onto the bed and correct the attachment Adjustments for safety and comfort should be made before moving the individual Patient s arms should be inside of the sling straps Prism Medical Slings and hardware are made specifically for use with Prism Medical Patient Lifts For the safety of the patient DO NOT intermix slings and patient lifts of different manu facturers 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 18 Basics in transferring an individual continued Step 6 When individual is clear of the bed surface swing their feet off the bed Using push handle move the patient lift away from the bed When moving the patient lift away from the bed turn individual so that he she faces attendant operating the patient lift Step 7 Slowly open the control valve to lower the individual so that his her feet rest on or over the base of the lift straddling the mast Close control valve NOTE The lower center of gravity provides stability making the individual feel more secure and the lift is easier to pull or push
6. FGSH 450 py Prism Medical Tali gete Ufc e g ieeeeeee enna eenreet aiao 2 VT IG enaena ances teeta AE 2 Components of the Floor Lift ceecceeesaeeeeeeeeeee 3 SPSCHICAMIONS serseri ra EE EEES 4 CO ON a eee ase eee ee cece eins 5 Shipping amp Transportation Instruction ccceceeee 6 Assembly Instruction cccccceeseesseeseeseeeeseeeenees 7 Operation Leg Spreading ccccceceeceeceeseeseeeeeenessersses 12 Raising and Lowering BOOM scceeeeeeeeees 14 Forward MOveMeM cccceeeeseeeeeeeeeeeeeeaeeees 15 TED scoccenttcouan encase E natal 15 Casters and Braking cccccecceeceeeeeseeeeeeseeees 17 Basics in transferring an individual esceeeees 17 General care inspection and maintenance 20 Points of Attachment Checklist ccceeeeeee eens 24 Service record NiStOry cccceeceeceeeceeeeenessesaeeaeeees 25 WV AH GUY joncnincete vanes RE EARR RARI EEEREN 29 Owner s Manual PRISM MEDICAL Use and Can 45 Progress Parkway Maryland Heights MO 63043 USA T 1 866 891 6502 314 692 9135 Trouble Shooting F 314 692 7858 Warranty Information CAUTION DO NOT ATTEMPT TO USE THIS EQUIPMENT WITHOUT FIRST UNDERSTANDING THE CONTENTS OF THIS MANUAL Introduction Before using this equipment and to ensure the safe operation of your FGSH 450 Hydraulic Steel Floor Lift carefully read this e
7. Keep fingers away from the end of the mast when inserting into the base tube Heavier items may need two people for assembly 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 7 Assembly Instructions continued 4 Turn the mast assembly to make sure that the notch is locked on the TABS of the tube of base assembly as shown in Figure 6 NOTE If the mast does not turn then the mast is centered and locked in place Figure 6 5 Insert the mast locking Screw into the bottom hole of the base assembly and securely tighten as shown in Figure 7 and 8 Mast Locking Screw Figure 7 Figure 8 Warning The mast may be removed from the base assembly for storage or transpor tation Each time the mast is removed and returned to the socket of the base and the mast must be locked into the tube of base assembly as per as sembly instructions on page no 6 and 7 of User Manual 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 8 Assembly Instructions continued 6 Remove the bolt and nut from the top of the mounting bracket of the mast assembly 7 Align the holes of the boom assembly and mast assembly mounting bracket as shown in Figure 9 Insert the shoulder bolt completely through the holes of mast assembly mounting bracket and the boom assembly as shown in Figure 10 and 11 Tighten the bolt and nut using the 3 16 Allen key and 1 2 wrench as shown in Figure 12 and 13 NOTE Be sure that the bolt i
8. agent person or entity which purchased the equipment from Prism Medical In no event shall Prism Medical incur liability for any consequential or unforeseeable losses If you have any questions about the manufacture or operation of this equipment please contact Waverley Glen or your local authorized dealer PRISM MEDICAL 45 Progress Parkway Maryland Heights MO 63043 USA Phone 314 692 9135 Fax 314 692 7858 Toll Free 1 866 891 6502 www prismmedicalltd com This document conforms to EN ISO 10535 requirements T Trade mark of Corven Health Care Inc Used under licence E amp O E 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 29
9. ain boxes containers and packing material for use in storing the lift until use of the Patient Lift is required Inspection Examine exterior of the patient lift for nicks dents scratches or damages Inspect all components Storage 1 Store the repackaged Patient Lift in a dry area 2 DO NOT place any other objects on top of the repackaged Patient Lift Detail A Apply stretch wrap 5 to 6 p Apply stretch wrap 5 to 6 times times around mast LF around mast Mast with pump K Ref A AA Screw Lit KON oo Po a LA Le ae nei See Detail A et ee ee 280490 FGSH 450 Owner s Manual Angle Swivel Bar Re A Cai a ae Oy ee DAN a Tape Ref SA 7 Tape Hex Key Here S Tape Ref GA ta k Tape Ref Rev 03 25 13 Swivel Bar Tape Hex Key Here Tape Ref Page 6 Assembly Instructions BASE MAST and BOOM ASSEMBLY 1 Lift the FGSH 450 Base assembly carefully from the carton and place on the floor as shown in Figure 1 Lock the rear casters Remove the mast locking screw from the base assembly as shown in Figure 2 Figure 2 Mast Locking Screw Figure 1 2 The Bottom of mast assembly have a notch Figure 3 and match these notch at the bottom of mast assem bly with the tabs inside the tube of base assembly Figure 4 as shown in Figure 5 3 Insert the mast assembly into the tube of base assembly and onto the TABS Figure 3 Figure 5 Caution Possible finger trap
10. and carry bar 1 Isopropyl Alcohol 2 Accelerated Hydrogen Peroxide Virox 3 Quaternary Disinfectant Cleaner 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 21 General Care Inspection and Maintenance continued A Each Use To be completed by User e Hydraulic Pump and Leg Spreading are operational B Semi Annually To be completed at least every 6 months Should any of the items as per check list on next page fail the inspection do not use the lift Contact Prism Medical Systems or your local qualified service technician for service e Complete the inspection as per check list on next page e Check and lubrication at every six months to all pivot points as listed on previous page C Annually To be completed at least every 12 months e Complete the inspection as noted in the Semi Annually section above Also check the following e A light grease water proof auto lubricant may be applied to the ball bearing swivel of the casters once a year e Perform a working load test of one 1 lifting cycle with the maximum load This is in accord ance to the periodic inspection requirements of ISO10535 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 22 General Care Inspection and Maintenance Check List INSTITUTIONAL IN HOME IN HOME INSPECT INSPECT INSPECT Meee alien ADJUST ADJUST ADJUST EVERY MONTHLY MONTHLY SIX MONTHS CASTER BASE ASSEMBLY Inspect for missing hardware Lift Base op
11. di vidual being lifted and or damage to the lift 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 13 Operation continued Raising and Lowering the Boom The up and down movement of boom on FGSH 450 lift 1s achieved by a Hydraulic Pump Actuator which is controlled by Pump Handle and Control Valve as shown in Figure 25 Raising the Boom The control valve must be in the CLOSED position control valve positioned towards pump handle to move the pump handle up and down to raise elevate the boom and the patient as shown in Figure 23 Lowering the Boom The control valve must be in the OPEN position control valve positioned away from pump handle to lower the boom and the patient as shown in Figure 24 The rate of descent can be controlled by vary ing opening of control valve Figure 25 Figure 24 Caution Full opening of control valve may drop the boom suddenly or completely could result in serious injury to the individual being lifted and or damage to the lift Open the control valve slowly to lower the individual being lifted 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 14 Operation continued Forward Movement To move the lift forward hold onto the handle bar and push forward Alternatively the caregiver can also place one foot on the base tube and push forward with their foot PUSH HANDLE BASE TUBE Turning When turning the lift stand on along one side With one hand pull gen
12. en 280490 FGSH 450 Owner s Manual Complete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 03 25 13 Page 27 Service Record History Service Type o Periodic Inspection oc Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken 280490 FGSH 450 Owner s Manual Comp
13. ens closes with ease Inspect roll pin to ensure secure base Inspect casters and axle bolts for tightness Inspect casters for smooth swivel and roll Apply a light grease to caster ball bearings SHIFTER HANDLE Operates smoothly Locks adjustable base whenever engaged Check roll pin for wear MAST Mast should lock securely when assembled Inspect for bends or deflections BOOM Check all hardware and carry bar supports Inspect for bends or deflections Inspect bolted joints of boom for wear Inspect to ensure that the boom is centered between the legs CARRY BAR Check the hooks for wear or damaged Check the sling hooks for wear or deflection HYDRAULIC PUMP ACTUATOR Check for leakage Inspect hardware on mast and boom Check for wear or deflection of piston rod 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 23 Floor Lift Points of Attachment Use the described tools to tighten the bolts on a monthly basis in the areas shown 1 2 Wrench 3 16 Allen Key 1 2 Wrench 3 16 Allen Key Boom mounting bracket Hydraulic Pump mounting 1 2 Wrench 3 16 Allen Key Carry bar mount Mast locking screw Shifter Handle locking screw 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 24 Service Record History Initial Information Complete the following section on Purchase and Service Information as soon as this equipment is purchased Use the service record history to record
14. g pages 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 16 Basics in transferring an individual A Caution The following steps are intended to generally illustrate the procedure involved in the lifting and transferring of an individual from one resting surface to another such as from bed to wheel chair using the patient lift The manual for the sling that was purchased with the lift should be reviewed in detail prior to attempt ing these steps as the sling illustrated here may not be the same as the one that was purchased Contact your local authorized Prism Medical Representatives if you have any questions or concerns Step 1 Using the Push Handle push the patient lift underneath of the bed Caution Always use extreme care when moving the lift from one surface to another Watch out for and avoid any obstructions that may cause injury to the individual in the sling or damage to the lift Step 2 Prepare the individual being transferred with the appropriate sling Refer to the instructions supplied with the sling that was purchased on how to properly outfit an individual with a sling A Caution Always make sure that the sling is correctly fitted and adjusted on each side of the individual so that maximum comfort and safety are achieved prior to lifting Step 3 Once the individual has been outfitted with the sling move the lift so that it 1s positioned directly over the individual and utilize leg opening funct
15. injury to the operator and or the individual being lifted transferred The FGSH 450 Hydraulic Steel Floor Lift and sling s are not toys Do not use it for unsafe practices Do not allow children to play with the Hydraulic Steel Floor lift or any of its components e The manufacturer s warranty is voided if persons unauthorized by Prism Medical Ltd will perform work on the FGSH 450 Hydraulic Steel Floor Lift There are no user serviceable parts inside the Hydraulic Pump Do not remove cover screws or open the Hydraulic Pump as this will VOID THE WARRANTY In facilities where more than one operator will be responsible for using the FGSH 450 Hydraulic Steel Floor Lift and sling s it is imperative that all such members are to be trained in its proper use A training program should be established by the facility to acquaint new operators with this equipment e During transfer with patient suspended in a sling attached to the lift DO NOT roll caster base over objects such as carpets raised carpet bindings door frame or any uneven surfaces or obstacles that would create an unbalance of the patient lift and could cause the patient lift to tip over Use of push handles on the mast at ALL times to push or pull the patient lift e Never expose the FGSH 450 Hydraulic Steel Floor Lift directly to water Warranty does not cover any misuse or abuse of the floor lift system e To maintain optimum function th FGSH 450 Hydraulic Steel Fl
16. ion Lower the carry bar to a height so that the straps of the sling can be easily attached to the carry bar AS Caution Always check to ensure that the rear wheels are not locked and legs must be locked in the open position for optimum stability and safety AS Caution Always check to ensure that the lift is correctly positioned directly above the per son to be lifted Caution Check to ensure that the carry bar has no cuts dents or sharp edges that may come in contact with the straps of the sling and cause damage to them Report any concerns to your local authorized representative 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 17 Basics in transferring an individual continued Step 4 Attach the straps of the sling to the sling hooks of the carry bar The straps on each side of the sling are generally attached to the corresponding side of the carry bar Be sure to double check to ensure that the straps are properly attached to the carry bar and that the individual being lifted 1s properly positioned in the sling pri or to lifting A Caution Prior to lifting an individual make sure that the straps of the sling are securely placed on the sling hooks of the carry bar Chain Hooks l A Caution Attach sling straps to the sling hooks only Do not attach sling straps to chain hooks Failure to comply with this caution could result in serious injury to the individual being lifted and or damage to the lift Step
17. lete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 03 25 13 Page 28 Warranty This Warranty does not affect or in any way limit your Statutory Rights 1 Prism Medical guarantees all equipment supplied as new against failure within the period of 1 year from date of purchase by virtue of defects in material or workmanship 2 This warranty does not apply to failure attributable to normal wear and tear damage by natural forces user neglect or misuse or to deliberate destruction or to batteries more than 90 days after original purchase 3 This equipment warranty shall be void if the equipment is not serviced by Prism Medical or its authorized service agents in accordance with the manufacturer s recommendations or 1f any unauthorized person carries out works on the equipment 4 The liability of Prism Medical under the terms of this guarantee shall be limited to the replacement of defective part s to the sales distributor dealer
18. ng swivel of the casters once a year Apply more frequently if the casters are exposed to extreme moist conditions The connection between the mast and the base should be cleaned and coated with petroleum jelly prior to assembly N CAUTION Take great care to ensure that no liquids get inside the lift This lift is not drip proof or water tight Failure to protect the lift from liquids may result in damage to the lift and or may cause personal injury 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 20 General Care Inspection and Maintenance continued Lubricate following pivot points Wipe all excess lubricant from lift surface 1 Swivel Bar at mounting Bracket 2 Boom Mounting Bracket 3 Boom to Mast Bracket 4 Mast Mounting Bracket 5 Base to Mast Mount 6 Rear Casters 7 Front Casters WEAR AND DAMAGE It is important to inspect all stressed parts such as slings carry bar and any pivot for slings for signs of crack ing fraying deformation or deterioration Replace any defective parts immediately and ensure that the lift is not used until repairs are made Check that all labels are present and legible Replace the labels if necessary CLEANING The lift can be cleaned with a non abrasive cleaners Auto wax or furniture polish will help to maintain the sparkling finish over a long period of time DISINFECTION OF LIFT AND CARRY BAR Following products to be used only for disinfecting the lift exterior case
19. nsfer takes place The sling is generally supplied with the floor lift at the initial time of purchase Please refer to any user guides supplied with the sling and ref erence them while reviewing this manual The FGSH 450 Hydraulic Steel Floor Lift has the ability to lift an individual up from one resting surface such as bed then transfer the individual to another resting surface such as chair The functions of lifting up or down is accomplished by moving the pump handle up and down The function of opening and closing the legs on the lift is accomplished by turning the shifter handle MOVING A PERSON SUSPENDED IN A SLING OVER ANY DISTANCE IS NOT RECOMMENDED Please familiarize yourself with the components of the F6SH 450 Hydraulic Steel Floor Lift by referring to the diagram on the next page Model Table for FGSH 450 Hydraulic Steel Floor Lift Product Code Product Description 280490 FGSH 450 Hydraulic Steel Floor Lift 450 Ibs 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 2 Components of the FGSH 450 Hydraulic Steel Push Handle d l Pump Hydraulic Actuator Shifter Handle for Pump Handle Leg Spreading TIS l Rear Caster w Brake Front Caster Leg Component List The following components are included with your new FGSH 450 Hydraulic Steel Floor Lift system e FGSH 450 Hydraulic Steel Floor Lift e Owner s Manual SLINGS If a sling has been supplied with floor lift then
20. ntire manual especially the section on Cautions The FGSH 450 is designed to be used in conjunction with Prism Medical accessories and slings Please refer to any user guides supplied with these components and refer to them while reviewing this manual Should any questions arise from reviewing this manual contact your local authorized Prism Medical Repre sentative Failure to comply with warnings in this manual may result in injury to either the operator or the in dividual being lifted transferred Damage to the floor lift and or related components may also occur Be sure that the contents of this manual are completely understood prior to using this floor lift Store this manual with the documents included with the floor lift and sling s Contents of this manual are subject to change without prior written notice Overview of FGSH 450 Hydraulic Steel Floor Lift The FGSH 450 Hydraulic Steel Floor Lift is a lifting aid used by health care professionals to transfer cli ents The floor lift makes it possible to transfer mobility impaired individuals with minimal strain or risk to the caregiver while providing complete safety dignity and comfort for the client The FGSH 450 Hydraulic Steel Floor Lift is one of two components that make up this technology The oth er component the sling 1s a specially designed fabric accessory that attaches to the floor lift by means of a car ry bar and straps and holds an individual while the lift or tra
21. of either the casters or brakes other than cleaning lubrication and checking axle and swivel bolts for tightness Remove all debris etc from the wheel and swivel bearings If any parts are worn replace these parts immediately If you have any questions regarding the safety of any part of the lift contact your dealer immediately HYDRAULIC PUMP All parts of the Hydraulic Pump are precision machined then carefully assembled and tested to ensure relia ble service The pump assembly is completely enclosed and sealed with Neoprene rings to prevent leakage of hydraulic oil A small amount of oil about a drop will accumulate around the piston from time to time and should be removed with a facial tissue WARNING The Hydraulic Pump 1s sealed at the factory Hydraulic Pump must be returned to the factory for repair if any service 1s required Do not attempt to open the hydraulic pump or obtain local service This will void the warranty ant might result in damage and costly repairs Contact your dealer for information LUBRICATION The Prism Medical Patient Lift is designed for minimum maintenance however a check and lubrication at every six months should ensure continued safety and reliability Keep lift and slings clean and in good working order Any defect should be noted and reported to your dealer immediately The casters must swivel and roll smoothly A light grease water proof auto lubricant may be applied to the ball beari
22. oor Lift should be inspected and maintained on a regular basis See the section titled General care Inspection and Mainte nance e Any accessories used with the FGSH 450 Hydraulic Steel Floor Lift including sling s should be checked to ensure that they are in good working order Check for signs of wear or fraying prior to use Report any unusual wear or damage immediately to your local authorized Prism Medical Service Provider e In any circumstances do not exceed the maximum allowable load of this lift Refer to the Specifications section of this manual and or the labels on the side of the lift e Ensure that a clear space is maintained around the lift Move any obstacles out of the way before opereating the floor lift 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 5 Shipping and Transportation Instructions If the Patient Lift is to be reshipped by common carrier it should be packed in the same carton as shown in Figure below Unpacking 1 Check for any obvious damage to the carton or its contents If damage is evident notify Carrier Prism Medical Dealer 2 Place the Carton Packaging box in a clear working area open carefully and remove loose packing materi al and following items and place on the floor taking care to protect the finish from damage e FGSH 450 Base Assembly e FGSH 450 Mast and Boom Assembly with carry bar e User Manual NOTE Unless the patient Lift is to be used immediately ret
23. rinted Name Company Remarks amp Action Taken 280490 FGSH 450 Owner s Manual Complete this section after each service repair inspection and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Rev 03 25 13 Page 26 Service Record History Service Type o Periodic Inspection oc Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Tak
24. s completely through the holes of the mast assembly mounting bracket and boom assembly and they are not riding on the shoulder of the bolt Figure 10 Mast Assembly Mounting Bracket LL Note To check for tightness of nut and bolt Raise the boom assembly Push the control handle away from the pump assembly If the boom assembly pivots easily then the nut and bolt are not too tight If the boom assembly does not pivot easily or does not pivot at all then the nut and bolt are Figure 13 not aligned properly A Caution The Boom and Mast when assembled must pivot easily NOTE Once the shoulder bolt and nut tightened completely then the boom assembly will pivot easily if the mounting hardware is aligned properly To check for correct alignment of the hardware use the Allen key and turn the shoulder bolt by hand The shoulder bolt should rotate without a lot of force being applied If excessive force is required to rotate then the bolt is not aligned properly Disassemble and repeat the assembly procedure until the proper alignment is achieved 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 9 Assembly Instructions continued BASE SHIFTER HANDLE ASSEMBLY 1 Align the hole of Shifter Handle and Cam Lock assembly as shown in Figure 14 Insert the Base Shifter Handle into the Cam lock Assembly at the rear of the base as shown in Figure 15 2 Tighten the thumb screw to secure the shifter handle in place
25. tly on the push handle and with the other hand push gently away on the lifting arm In this way the lift will rotate around its own axis This movement is performed with a smooth slow action to avoid swinging the patient unnecessarily A Warning 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 15 Operation continued Casters and Braking The FGSH 450 lift has two rear casters with brake The rear casters can be braked for rotation lateral move ment and parking To apply the brake press the brake pedal down with your foot To release the brake press the raised pedal towards the wheel During the lifting the rear wheels should remain unlocked so that the lift will move to the patient s centre of gravity AN Warning Locked wheels during lifting will increase the risk of the lift tilting over Application If the lift is used incorrectly any warranty or product liability might cease to be valid The FGSH 450 lift must only be used for person lifting and only for persons who including the sling do not weigh more than the stated max weight load If the load exceeds the stated weight limit and 1f the lift is used for lifting anything but persons then any product liability that Prism Medical might have in connection with insurance warranty maintenance etc will cease to be valid To avoid possible accidents and injury to persons being lifted the floor lifts must only be operated as de scribed in the precedin
26. to any completed service and repairs Ensure that the service record is signed and dated each time it 1s used Be sure to have this piece of equipment serviced on a regular basis as described in the General Inspection and Maintenance Section PURCHASE INFORMATION Product Name FGSH 450 Hydraulic Steel Floor Lift Serial Date of Purchase Purchased From local authorized Prism Medical Representative Address City Postal Code Telephone No Comments SERVICE INFORMATION Contact the following company for service Company local authorized Prism Medical Representative Address City Postal Code Telephone No Comments 280490 FGSH 450 Owner s Manual Rev 03 25 13 Page 25 Service Record History Service Type o Periodic Inspection oc Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection Completed By P
Download Pdf Manuals
Related Search