333 Manual - Liberty Electric Bikes
Contents
1. Battery Precautions Do not touch the two poles of the battery with your hands when the battery is removed for charging Also the two battery poles should not be touched with any metal or other material that conducts electricity While charging put the battery in a secure place where children can t reach Do not use any charger other than the one that came with your Liberty Electric Bike If you need another charger contact your local dealer Do not attempt to open or repair your charger The electronics contain high pressure circuits so don t dismantle by yourself ePrevent liquids metal and metal filings from permeating the charger and be careful to not drop or hit the charger which could cause damage Do not put anything on top of the charger while charging It must be well ventilated to allow all the heat generated to dissipate When charging if there is a peculiar smell or the temperature is too high please stop charging immediately eTo prevent premature failure of your battery and for your warranty to remain in effect on your battery YOU MUST CHARGE AND DISCHARGE THE BATTERY AT LEAST ONCE PER MONTH Do NOT use in the battery in a very low state The charger will produce heat up to 185 F 85 C in the course of using so keep it away from flammable articles while using eIt is normal that the mileage capacity will reduce as a result of low temperatures While carrying the charger DO NOT bump drop or damage o2. so you don t shorten the battery life To prevent premature failure of your battery and for your warranty to remain in effect on your battery YOU MUST CHARGE AND DISCHARGE THE BATTERY AT LEAST ONCE PER MONTH A Always turn off the motor and remove the key from the ignition before and during charging to prevent serious damage to the controller and to the batteries This electric bicycle can be used in the rain however the motor and other electrical parts must not be submerged in water The controller motor and other electrical devices may be short circuited causing damage which is NOT covered by warranty and creating possible dangerous situations A DO NOT use chargers or other components other than that which has been approved and tested by this company This company is not responsible for damages caused by the use of other products not specifically designed and tested for use with this electric bike Battery chargers contain sensitive electronics Improper use dropping or sudden jolts can damage the charger and its internal electronics which is NOT covered by warranty Do not leave the charger on for more than 10 hours Check all nuts bolts screws and spokes to make sure they are tight before riding If any screws nuts or bolts are loose put some thread lock on the threads and then tighten A When riding down hill you MUST have the key on even if you are NOT using the throttle and even if the battery is not in the bike The m
3. each use The normal full cycle battery life if it is continuously discharged and recharged is between 300 1000 cycles depending on which battery came with your bike after which the storage capacity of the battery will gradually decline CAUTION Fully charge the batteries before the first use Failure to do this can result in decreased battery performance for the life of the bike Fully charge the battery each time you use the bike Battery performance is affected by the temperature and is generally better in warm temperatures When the temperature is below 32 F 0 C the battery current may decrease by a third Consequently the travel range on a full charge in cold environments is much less but will return to normal when the temperature is back to room temperature Frequent stopping and starting riding uphill traveling against a strong wind starting from a standstill riding on rough or muddy roads and carrying more than one person or heavy loads will consume extra battery power and shorten the range A few tips to prolong the battery life during these conditions is as follows Frequent braking try to look ahead and coast rather than frequently stopping and starting Riding uphill or against a stiff wind pedal to supplement the battery power When starting from a standstill use the pedals to help bring you up to speed When the battery meter indicates the voltage is low switch to manual power and avoid using the battery
4. our responsibility You too have a part to play With proper care maintenance and attention to bicycle safety rules your ebike will give you years of enjoyment Please read the instructions carefully before using your ebike Do not ride this bicycle until you have read and thoroughly understand the owner s manual It contains information critical to your safety If you have questions about the operation of this electric bicycle consult your authorized dealer It is extremely important that you follow the safety guidelines contained in this manual in order to ensure your maximum safety If you loan your bike to anyone make sure they also know how to operate it safely When using the load should not be greater than the maximum capacity and please pay attention to increase the braking distance during rainy or snowy days This ebike can operate in the rain and snow but it CANNOT be submerged in water When the motor is submerged in water it may short circuit and fail which is NOT covered by the warranty P Please don t dismantle and repair the spare parts by yourself but go to the local dealer Please take time to record the following information Recording Your Ebike Info Serial Number Model Color Date of Purchase o A Sin Dealer s Ph Serial Number Location Dealer s Name Dealer s Email Important Instructions Safeguard your battery to insure continued high performance It should be recharged after
5. sure your brake cables are free of obstacles and are adjusted and working properly Batteries Fuses Your batteries are in a protective case with a handle to enable you to easily take these on and off your bike There is a locking key to lock the batteries on your bike to discourage theft Do not attempt to open your battery box without first contacting your dealer This WILL void your warranty If you suspect your battery is not working properly you can test 1t with an inexpensive voltage meter If you get a zero voltage reading then check and replace your fuse Check the pages of this manual that are specific for your battery If this doesn t fix the issue then contact your local dealer Chain Lubricate the chain with oil every three months to ensure it stays free of rust as well as every time that it is ridden in wet weather 10 Troubleshooting 1 Your controller needs to be replaced or 2 Your motor needs to be replaced A You turn the power on the indicator lights are all on but with throttle or pedal assist the ebike doesn t work B You turn the power on the indicator lights are all on bike works with throttle but not with pedal assist 1 Your controller needs to be replaced or 2 Your pedal assist module needs to be replaced or 3 Your motor needs to be replaced C You turn the power on the indicator lights are all on bike works with pedal assist but not with throttle D You turn the power o
6. voltage on the charger then it needs to be replaced If zero voltage from the battery then check the fuse If all above mentioned situations are normal then there is some other problem Please call your local Liberty ebike dealer Warranty With normal care and recommended maintenance this electric bicycle is warranted to be free of defects in materials and workmanship for the following period of time 3 months electronic controller charger and throttle 6 months hub motor and battery l year frame We will repair or replace at our option any product or part that is defective in material or workmanship without charge if the product is presented to us at our authorized Liberty Electric Bike Service Center at 1 800 806 7109 with dated proof of purchase inside of warranty period Shipping charges are not covered under this warranty This limited warranty does not cover the normal wear of items such as tires brakes chains and other items All implied warranties are limited to the stated time period Liberty Seamless Enterprises Inc Liberty Electric Bike Company and any of its subsidiaries will not be liable for any incidental or consequential damages This limited warranty gives you specific legal rights and you may have other rights from state to state This warranty applies to normal consumer use of the product Use in a rental fleet commercial setting or government fleet will void this warrant
7. Liberty 333 Liberty 50v Trike User Manual Thank you for your decision to buy this product Please use this product according to the instructions Please keep the instructions in a handy place Liberty 333 Electric Trike 36 Volt 10 ah Li ion Introduction Dear Customer Wow You are excited You have just received your brand new ebike We too are excited because as designers and developers of our bikes we love to make you happy and we believe your new ebike will give you lots of fun I know you want to get this bike on the road immediately but please STOP Why Well first of all you need to charge your batteries fully before using them So while your ebike is charging take the time to read this manual We have worked hard to make it as readable as possible This manual will help prevent injury and teach you how to care for your new ebike It is the owner s responsibility to carefully read all of the contents of this manual and to comply with all laws pertaining to the operation of bicycles and or electric bicycles in your local jurisdiction If you have any questions please consult with the laws web page on www iloveEbikes com or consult your local department of motor vehicles for clarification These electric bikes are not classified as motor vehicles however to drive them on the roads various states have differing laws We have worked hard to provide you a quality well designed product without defects That is
8. can then keep turning the key until it is in the ON position In the ON position the electric of your trike will operate To REMOVE your battery you need to turn the key all the way counterclockwise and then you can slide the battery out of its home position Light Switch On the right handlebar is a red button This toggles the headlight in the ON and OFF position When the light is ON it will drain the battery quicker than in the OFF position Swing Control This control is also on the right handlebar It will release the frame when shifted to the swing position so that the front of the bike can lean into corners In the FIX position the frame cannot lean This is good for when you are sitting on your trike or at very slow speeds Please be careful in learning to ride your trike with this function At cruising speeds it is important to release the frame with the SWING function Throttle The throttle is a twist throttle on the right handlebar grip If turned the bike will operate with the electric motor built into the front wheel hub Turn gradually to get started Release to stop motor Using the brakes on the hand brakes will also cut the power to the motor for safety Battery Indicator There is a LED battery indicator on the front handlebars It operates when the key is on If all lights are lit up then you have a full charge on your battery As charge lessens the lights will gradually lessen on the indicator There is also an ind
9. d be careful at intersections and when starting from a stopped position e When cleaning your electric bike do not use a steady direct stream of water from a hose Use a cloth to avoid short circuiting any electrical components Your electric bike has a durable finish and does not need to be waxed Clean with a mild detergent and buff to restore its original shine e Please wear a safety helmet and glasses for your own protection whenever riding e Wear bright clothing to help make you visible to other motor vehicles e Do not wear loose clothing that can become caught on the bicycle e Do not leave the charger connected to the battery for more than 10 hours General Operating Instructions BEFORE YOU RIDE 1 Charge your battery until the green indicator light on the charger comes on but do not allow if to charge more than 10 hours 2 Check the air pressure of the tires Make sure they are at the recommended psi embossed on the sidewall of the tire 3 Check the front and back brakes and the condition of the front and back wheels handlebar and saddle Make sure they are tight and fastened Make sure all quick releases are locked and secure and that all parts are in good working order Inspect your bike completely 4 If it was removed install the charged battery in the battery seat of bike and lock it 5 Raise the kickstand 6 Sit on the bike and turn the bike on The power lights meter should show your battery capacity 7 Pedali
10. icator on the top of the battery If key switch is ON you can press the button on top of the battery to see if you have charge Battery Meter Three LED lights will light up if you have full charge USING YOUR LITHIUM ION BATTERY To remove the battery lift the lever under the seat and tip the seat as shown on the right Turn the key counterclockwise so that the battery locking pin will release the battery Lift up on the handle to remove the battery To place the battery back into its home position slide the battery down the battery slide and turn key to lock the pin into the slide at the rear of the battery box PPP eines To charge the battery you can leave the battery in the bike or remove it if needed A cover is over the charging port First plug your charger into the battery port as shown in the picture and then plug in the charger to the outlet Follow instructions with charger When charging a red light will light When the battery is fully charged 1t will turn green and stop charging The charger can detect the voltage of the battery pack SEAT POSITION Your seat can be raised and lowered like any regular bicycle seat It has a hand lever to help you tighten the seat Adjust to the proper height and then tighten securely BRAKE SYSTEM Your trike has front caliper brakes that are adjusted like a normal bicycle brakes The front brakes are adjustable with the cable at the front There is a nut that turns that tightens
11. mmediately have the wheel trued by a bicycle mechanic DO NOT RIDE WITH LOOSE SPOKES Riding with loose spokes may cause the wheel to fail Tires Inflate your tires to the pressure embossed on the sidewall Every time you ride make sure the tires are properly inflated Improper tire pressure will make riding more difficult cause excessive wear and cause premature failure of the tires The tires should be properly seated in the rim and the fitting of the tire beads and rim beads should be checked If the tube 1s pinched between the rim and the tire it will fail when inflated Make sure that the tires are not cracked or worn unevenly Check for bulges Check and make sure that the valve stem 1s straight in the rim Irregular tires should be replaced immediately Handlebar and Display We have created the handlebar display so that you can easily see it while riding To straighten the handlebars turn the stem binder bolt to loosen it and straighten the handlebars so they are aligned properly with the front wheel and tighten Loose or damaged grips on your handlebars are dangerous If your grip comes off you could lose control of your bicycle Replace as needed Brakes Riding with brakes that are worn or damaged or with worn cables or wheels in poor condition may result in losing control of your bicycle Wet weather may hinder the brake performance You need more distance to safely stop in the rain or on a wet or icy street Before each ride check to make
12. n then twist the throttle but the ebike doesn t work 1 Your controller needs to be replaced or 2 Your throttle needs to be replaced or 3 Your motor needs to be replaced 1 Check your battery to see if it needs to be charged or 2 Your fuse needs to be replaced or 3 Your controller needs to be replaced or 4 Your motor needs to be replaced E The switch is turned on and the Check whether the throttle is stuck in the on position re off without using the D Lubricate or replace the throttle if it is faulty F After stopping the ebike doesn t 1 Check whether the brake handles are fully released start when the throttle is twisted D Check A B and C above G The speed is unusually slow Make sure throttle is operating correctly Check to see if the battery is fully charged Make sure speed limiter is not connected H You connect the power to the Check whether there is electricity to the charger charger but the indicator light If you have a voltage meter you can check to see if the does not come on charger produces the correct current I You plug in the charger to the Check to see if the batteries are fully charged ebike and the outlet and the Check whether the charger is plugged in properly to 8 plugs properly green light comes on instead of the red light This means it isn t both the battery and the outlet charging Check the voltage of the charger and battery 4 If zero
13. ng or using the throttle on the right hand will begin to accelerate the bike ATTENTION After the power is on if the rider twists the throttle the bike will lurch forward Do not turn the power on until you are ready to go The hand brake will automatically cut the power to the motor as also will releasing the throttle While starting or climbing a hill pedal as much as possible so that the electric power will not be drained too much At the same time 1t can lengthen the life of the battery and motor ATTENTION When riding down hills do not turn off the power otherwise the controller and motor will be easily damaged which is NOT covered under warranty While running if the battery power is getting low the battery meter will lessen At this time you should pedal your ebike like a regular bike and charge the battery as soon as you get to an electrical outlet Turn off the power and remove the key while parking If you decide to push your bike for any reason make sure to turn the power off so you don t accidentally turn the throttle making the electric bicycle start suddenly and cause an accident To help get the best distance out of your electric bike refrain from a lot of braking and coast as much as possible TRIKE CONTROLS Key Switch on Battery To operate your bike you need to turn the key switch on the top of the battery This is used to move the locking pin from the battery into the back slide rail Once it is locked in you
14. otor will generate enough electricity to RUIN your controller which is NOT covered by warranty Table of Contents A adhd a acu 2 Important MISTHUCHONS AA 3 Table OL Contes 4 Bee ad UC CALI CLO Sy cts CC o NO 5 General Operatic Asu CONS aa 6 Tk COMO tdo 7 A A tae 9 ES A ERE UE Pee ne 10 A A A A 11 RR O 12 Federal Electric BIKE Lai 13 Safety Precautions e Before operating your bicycle inspect it carefully to avoid accidents or damage e Do not drive close to other vehicles e ALWAYS keep the power switched OFF until you are seated on the bike and ready to ride Turning the power on and then accidentally twisting the throttle can result in the bike lurching forward and may cause an accident damage or injury e NEVER attempt to disassemble the motor battery controller or throttle This can result in injury fire or damage to the bike e ONLY use the charger supplied with your bike to charge the battery Using the improper charger can result in fire or explosion e KEEP the batteries out of the reach of children e Obey all traffic laws relevant to the operation of bicycles and electric bicycles e Use the turn signals if equipped or hand signals at all times when making turns e KEEP both hands on the handlebars at all times e DO NOT hang objects on or under the handlebars e DO NOT brake suddenly in the rain or on slippery wet surfaces e USE extreme caution when riding near other vehicles Assume they do not see you an
15. the holder of the cable Release the nut and turn the holder of the cable for fine tuning They can also be adjusted at the clamp at the end of the cable for major adjustments The rear brake is adjusted with the rear cable It is a band brake that tightens a band around a drum When the cable is tightened the band will slow down the brake HANDLEBARS When your trike arrives the handlebars are turned down Turn them so that they are at the angle that is most comfortable Tighten the clamp to secure the handlebars You should also make sure that the locking nut at the handlebar stem is tight It is tightened with a 20mm wrench or with and adjustable wrench Tighten firmly ASSEMBLY Assembly on your trike is minimal Out of the box you need to adjust the handlebars as mentioned above and check all brakes adjust brakes and charge up your battery Check your air pressure in your tires and adjust to the pressure listed on the side of each tire Be sure to charge up your battery overnight the first time you charge it for optimum life of your lithium ion battery Installing the Pedals _ Note the left and right of the pedal E left R right are stamped on the threaded end of the pedal _ Attach the L pedal to the L crank then R pedal to R crank Screw the pedals in and tighten them fully A The L pedal has left hand threads and the R pedal has right hand threads Misapplication is not covered under the warranty
16. therwise it may result in failure eAvoid any contact with water when charging your battery If a plug or socket gets wet dry it completely before using Do not leave the charger connected to the battery and the outlet for more than 10 hours eAlways use the charger according to the instructions MAINTENANCE Wheels Wheels should be properly placed in the fork or dropouts If you hear any irregular noise from the wheels or brakes they should be checked and adjusted The wheels should rotate smoothly without wobbling from side to side Check the bearing play of the hubs regularly by lifting the bicycle and spinning the wheel It should continue to spin for several turns after you stop spinning the wheel The motorized wheel will NOT spin as freely as the non motorized wheel To check the play of the hubs try to move the rim from side to side between the forks No substantial play should exist If you detect play or if the wheel is difficult to turn please contact your local dealer or your local bike shop to have it serviced Rims The rims should be smooth and without cracks breaks or bulges Spokes If your bike has spokes check their tension regularly About the same tension should be on all the spokes If there is some minor loosening of the spokes you may tighten the nipples but it is recommended that you take it to a bicycle mechanic for proper adjustment If there 1s a loose spoke or if the rim has side play of more than 1 8 4mm i
17. vel surface when powered solely by such a motor while ridden by an operator who weighs 170 pounds is less than 20 mph c To further protect the safety of consumers who ride low speed electric bicycles the Commission may promulgate new or amended requirements applicable to such vehicles as necessary and appropriate d This section shall supersede any State law or requirement with respect to low speed electric bicycles to the extent that such State law or requirement is more stringent than the Federal law or requirements referred to in subsection a We recommend you laminate this sheet and keep with you when riding J
18. y Inappropriate use such as trick riding abusive riding or offroad riding will void the warranty as well as violating the instructions in this manual Electric Bicycle Regulations Federal law says that an electrically driven bicycle is considered a bicycle and the laws of bicycles apply if o Electrically driven bicycle has less than 750 watt motor o Functional pedals o Max speed is less than 20mph The Federal law shall supersede any State law or requirement with respect to low speed electric bicycles The state must regulate the electric bicycle as a bicycle Federal definition of a bicycle o Sec 1512 2 Amended 2 Amend Sec 1512 2 to revise paragraph a to read as follows a Bicycle means Federal Electric Bicycle Law HR 727 at AT SECTION 1 CONSUMER PRODUCT SAFETY ACT The Consumer product Safety Act 15 U S C 2051 et sea is amended by added at the end of the following LOW SPEED ELECTRIC BICYCLES SEC 38 a Notwithstanding any other provision of law low speed electric bicycles are consumer products within the meaning of section 3 a 1 and shall be subject to the Commission regulations published at section 1500 18 a 12 and part 1512 of title 16 Code of Federal Regulations b For the purpose of this section the term low speed electric bicycle means a two or three wheeled vehicle with fully operable pedals and an electric motor of less than 750 watts 1 h p whose maximum speed on a paved le
Download Pdf Manuals
Related Search