User Manual Transmitter Module PTM 33x / PTM 33xC
Contents
1. RYE REPARARE ERRARE ANEREN ENA 4 2 GENERAL DESCRIPTION reu nutu va une 4 2 1 Basic Functionality RARE RARE ATRKRKR ER RARE E Reda 4 2 2 Technical Data eerte rr x RR on RC DH GR I D YER EEEE EO RH Dea 4 2 3 Physical DitnensiOns i eic EX ER EENERERCRERENYAREK RE EREEREAR ERE EEEE a 5 2 4 Environmental Conditions Rex RERO RR ERE tte DOR AERE Fea 6 2 5 Ordering Information sirri brinar rir ranana mense seen 6 3 FUNCTIONAL DESCRIPTION betreiben rtu Obr vias Y E ME E 2E TRY 7 3 1 Block diagram es nes 7 352 E 7 3 3 Pin Description and operational characteristics 4 8 3 4 Configuration Interface ex ree vit exa cu xu EY eeu Fe Ya ERU X ne 9 3 5 Absolute maximum ratings non operating 9 3 6 Maximum Ratings 10 3 7 Radio telegram Eres 11 3 7 1 Normal operation cor mter tee NVATA SE TENE EA 11 3 7 2 User defined Op ration sa cesse kenne kae nn n daa KE ER RA Ka Ra 12 3 8 Transmit CUMING iex Rake E RUN aborde 12 4 APPLICATIONS2. 2 2 ente entente 13 4 1 How to connect an energy harvester 13 4 2 How to generate an equivalent energy pulse 13 4S ANteNNE receded S 14 4 4 Layout recommendations eene 15 4 5 Soldering information 332 332 00 0 16 4 6 Transmission FANGS case rinri eve mews evene alee cede oe denote xn a Re rx xe ces ced Fax 17 5 AGENCY 5 10 18 51 rei anin o P acte Pe RR D date 18 5 2 FCC United States Certification 0 emnes 19 5 2 1 330C and 332C LIMITED MODULAR APPROVAL 19 5 2 2 330C and 332C FCC Grant 21 5 2 3 PTM 330U FCC APPROVAL mt net ER E eU E UO RT A Ce RR o KO 22 5 2 4 PTM 330U FCC Giant eh EA NE ae Een 23 5 2 5 FCC Regulatory Statements ne en PR ern ERROR na PR a Roe 24 5 3 IC Industry Canada Certification sisi 25 5 3 1 PTM 330C and PTM 332C Industry Canada Technical Approval Certificate 26 5 3 2 3300 Industry Canada Technical Approval Certificate 27 5 3 3 Industry Canada Regulatory Statements A 28 2013 EnOcean www enocean com 33x PTM 33xC
3. E ELE gt RSS 210 EE 11 December 2010 SS eo CN OATS 3461C i Sreet Address Moggast Boelwiese 8 GY Ebermannstact SE omy oxo Kartheinz Kraft Tel 0040 0104 2016 E mail kkra emocde Fax 00400194 8125 Certification of equipment means only that the equipment has specification Licence location of operation reer nie ere issued on radio the holder complies and will continue to comply with the requirements and procedures issued by Industry Canada The e in compliance with the above noted specification DATE 21 June 2013 rr rus ans aa i FI pel Satisfait aux exigencies de la norme indiqu e c dessus Les demandes de licences n cessaires pour l utilisation du mat riel procedures pr sent certificat est d livr ne doit pas tre fabriqu import distribue loue mis en vente ou vendu moins d tre conforme aux proc dures et aux sp cifications techniques applicables publi es par Industrie Canada J atteste par la pr sente que le mat riel a fait l objet d essai et jug conforme a lasp cffication ci dessus Mas Page Certification Officer Stcertofer Berg 1 15 81364 Unterienletter Germany EMCCert DR GmbH Tel 449 0104 72279 01 Fax 40 0194 7227006 2013 EnOcean www enocean com E mail eme cert emec de gt Web www emcc de PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 27 28 USER MANUAL Green Smart
4. 4 3 Antenna 315 MHz Option 1 150 mm wire connect to RF_WHIP Option 2 A 50 antenna can be connected to RF 50 In this case the limited modular FCC IC approval is not valid An FCC IC approval is then needed for the end device 868 MHz Option 1 86 mm wire connect to RF WHIP Option 2 A 50 Q antenna can be connected to RF 50 902 MHz 64 mm wire connect to RF WHIP NEN 20 8 tinned bared twisted and tinned Cu wire LiY according to VDE 0812 or 0245 CI 5 or 6 Insulation PVC mixture TI2 according to VDE 0207 4 orange 1 330 1 Specification of the whip antenna L2 150 mm 315 MHz L 86 mm 868 MHz L 64 mm 902 MHz 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 14 28 USER MANUAL Green Smart Wireless enocean 4 4 Layout recommendations PTM330 C _ENU 26 20 mm Proposal for foot print on host PCB XX QU NN QQ MN 20 60 mm ANM MANNA ASASASS 8800080808080 0 05 00000000096 A Q M Q OXY Keep out area on host PCB No copper surface area allowed 0 2013 EnOcean www enocean com 33x PTM 33xC PTM 330U 3
5. 330U 33xU User Manual V1 1 Page 3 28 USER MANUAL Green Smart Wireless enocean 1 RELATED DOCUMENTS In addition to this document additional information is available on our web site Proposal for mechanical integration with ECO 200 in 2D and 3D format Footprint with positions of pads available in Protel and Gerber format AN102 Antenna Basics Basic antenna design considerations for EnOcean based prod ucts 2 GENERAL DESCRIPTION 2 1 Basic Functionality The radio transmitter module PTM 330 from EnOcean en ables the implementation of wireless sensors and switches without batteries Key applications are handheld remote controls or industrial switches Functional Principle When an energy pulse is supplied e g by ECO 200 from EnOcean an RF telegram is transmitted including a unique 32 bit module ID the polarity of the energy pulse and the operating status of 4 digital in puts The RPS telegram content can be configured if other content is needed PTM 330 can be connected to ECO 200 via a contact spring There are two meander struc tures on the PCB which allow usage of a rubber pad to set the level of two digital inputs Alternatively PTM 330 can be mounted as an SMD component onto a host PCB In this case energy supply pins and digital input pins are accessible via contact pads Product variants m PTM 330 868 MHz variant pre installed whip antenna delivery in card board box PTM 332
6. OLE Nid P1009 OEE Wid 2 401d13 137 5920215 pax20 q uo 1 004 192 sjusuoduoo sjuauoduo2 20 9201115 powoo q vazuasbuo 1199 uo 514 uauugy 91191708 91191708 Jnj 2490S 9196 20 105 20 109 196 j20 u02 3u201410 03p 09 apis 1 0 91195101 EE e 2 170 592020215 194402 10 920019101 1703 UauNyyNsyssaydny 20 1002910 Daso papoys jou ww 9 46194 juouoduoo 4219298 191191100498 97 94049 19 08 c 177 ju5raq juavodans 77 ayoya 1aynog y Sri 1 60 0 28 92114 2104 10 9200910 6171 G0 O ZP pub1sqosbuniuog 20 zuDsajo C OF 61712 9 23025 10 24029 0 C OF SLIZ apuoyzyiy any 2002910 6 151591 jep os puo sujod 0 20 03 55944214 0101 p00q Jd 20190 8 91 pun uauyogsay 1a 9 0 9 191 914035913 0291194 20 2 9 59104 PIQUE 197 nz 59104 91025 uabunsyog nz u3 0d oj P1tq2 19 nz 9juoX 0 4 o abpa paj jiu uabunsyog nz ejuoxs01j juaueop dsip 230819 X Ej 4 apis gt 3 1959 19 104 33x PTM 33xC PTM 3300 33xU User Manual V1 1 Page 5 28 2013 EnOcean www enocean com USER MANUAL Green Smart Wireless enoce
7. USER MANUAL Green Smart Wireless enocean June 21 2013 Observe precautions Electrostatic sensitive devices Patent protected WO98 36395 DE 100 25 561 DE 101 50 128 WO 2004 051591 DE 103 01 678 A1 DE 10309334 WO 04 109236 WO 05 096482 WO 02 095707 US 6 747 573 US 7 019 241 EnOcean GmbH Phone 49 89 67 34 689 0 Subject to modifications 0 Kolpingring 18a Fax 49 89 67 34 689 50 33x 33xC PTM 3300 User Manual 82041 Oberhaching info enocean com V1 4 Germany WWW enocean com June 21 2013 USER MANUAL Green Smart Wireless enocean PIM 33 RIME SXR SAU REVISION HISTORY The following major modifications and improvements have been made to the first version of this document No Major Changes 0 81 CFG Pin For test purposes only 0 85 Antenna length 868 MHz changed to 86 mm upper limit of operating temperature reduced to 65 C 0 90 Equivalent energy pulse definition added 1 00 Max supply voltage for programming interface added in 2 4 Digital input parame ters added in 2 3 FCC IC grants added in 4 2 and 4 3 1 01 TX power increased to 3 dBm at antenna input Chapter Related Documents add ed misleading table removed in 3 3 1 02 Figure corrected 3 4 1 03 13 4 modified 1 1 Meander structures increased PTM 330U added Published by EnOcean GmbH Kolpingring 18a 82041 Oberhaching Germany www enocean com
8. This device complies with part 15 of the FCC rules Operation is subject to the following two conditions 1 This device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired opera tion Any changes or modifications not expressly approved by manufacturer could void the user s authority to operate the equipment IMPORTANT Any changes or modifications not expressly approved by the party responsible for compliance could void the user s authority to operate this equipment NOTE This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to part 15 of the FCC Rules These limits are designed to provide reasonable protection against harmful interference in a residential installation This equip ment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communica tions However there is no guarantee that interference will not occur in a particular instal lation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures Reorient or relocate the receiving antenna Increase the separation between the equipment and receiver
9. Connect the equipment into an outlet on a circuit different from that to which the receiver is connected Consult the dealer or an experienced radio TV technician for help 0 2013 EnOcean www enocean com 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 24 28 USER MANUAL Green Smart Wireless enocean 5 3 IC Industry Canada Certification In order to use EnOcean s IC number the OEM must ensure that the following conditions are met Labeling requirements for Industry Canada are similar to those required by the FCC The Original Equipment Manufacturer OEM must ensure that IC labeling requirements are met clearly visible label on the outside of a non removable part of the final prod uct must include the following text PTM 330C PTM 332C Contains IC 5713A PTM33XC PTM 3300 Contains IC 5713A PTM330U OEM wishing to use PTM 330C 332C under limited modular approval conditions must sign the OEM Limited Modular Approval Agreement with EnOcean Pour utiliser le num ro IC EnOcean le OEM doit s assurer que les conditions suivantes sont remplies Les exigences d tiquetage pour Industrie Canada sont similaires a ceux exig s par la FCC Le fabricant d quipement d origine OEM doit s assurer que les exigences en mati re d tiquetage IC sont r unies Une tiquette clairement visible a l ext rieur d une partie non amovible du produit final doit contenir le texte suivant PTM 330C PT
10. for example The packet contains one or more control signals that is are intended to control some thing at the receiving end The packet may also contain data Depending on how much en ergy is available from the energy source subsequent manual triggers can initiate the transmission of additional control signals This may be necessary if prior packet s was were lost to fading or interference Subsequent triggers can also be initiated as a pre caution if any doubt exists that the first packet didn t arrive at the receiver Each packet that is transmitted regardless of whether it was the first one or a subsequent one will only be transmitted if enough energy is available from the energy source Automatic Activation The radio module also can be configured to transmit a short packetized control signal if triggered automatically Again the packet contains a control signal that is intended to control something at the receiving end and may also contain data As above it is possible for the packet to get lost and never reach the receiver However if enough energy is avail able from the energy source and the module has been configured to do so then another packet or packets containing the control signal may be transmitted at a later time OEM Requirements In order to use EnOcean s FCC ID number the OEM must ensure that the following condi tions are met m End users of products which contain the module must not have the ability to alter
11. an energy harvester PTM 330 can be connected to ECO 200 without soldering ECO 200 provides contact springs which can directly be connected to contact pads of PTM 330 The contact pads on the bottom of the PCB are shown below left second orientation where PTM 330 is rotated 180 with respect to ECO 200 is also possi ble as shown with dashed lines 4 2 How to generate an equivalent energy pulse PTM330 can also be operated from an external equivalent energy pulse As the source impedance is not known a procedure is defined how to find the needed dura tion of the pulse The pulse must provide a voltage between 5 V and 6 V for maximum 10 ms time storage capacitor The length of this supply pulse needs to be defined by measuring the remaining voltage on the storage capacitor after the 3rd subtelegram according to the following procedure 1 Discharge the storage capacitor see photo completely 2 Apply a short pulse voltage between 5 V to 6 V which charges the capacitor 3 Measure the voltage drop at the storage capacitor to ground between pin 13 and pin 12 while the sub telegrams are being transmitted with an oscilloscope 4 The remaining voltage shortly after the 3rd sub telegram should be 2 5 to 3 0 V 2 5 3 0V 2013 EnOcean www enocean com 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 13 28 USER MANUAL Green Smart Wireless enocean
12. has been proven and the according docu mentation has been deposited at EnOcean The modules can be operated without notifica tion and free of charge in the area of the European Union and in Switzerland The following provisos apply e EnOcean RF modules must not be modified or used outside their specification limits e EnOcean RF modules may only be used to transfer digital or digitized data Analog speech and or music are not permitted e The final product incorporating EnOcean RF modules must itself meet the es sential requirement of the R amp TTE Directive and a CE marking must be affixed on the final product and on the sales packaging each Operating instructions containing a Declaration of Conformity has to be attached e If the transmitter is used according to the regulations of the 868 3 MHz band a so called Duty Cycle of 1 per hour must not be exceeded Permanent transmitters such as radio earphones are not allowed e The module must be used with only the following approved antenna s Type Parameter Value Wire Monopole at RF WHIP Maximum gain 1 0 dBi External antenna at RF 50 Antenna type Passive Impedance 50 Ohm Maximum gain lt 0 dBd 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 18 28 USER MANUAL Green Smart Wireless enocean PIM 33 PIM s3xe PIM SAU 5 2 FCC United States Certification 5 2 1 PTM 330C and PTM
13. info enocean com phone 49 89 6734 6890 EnOcean GmbH All Rights Reserved Important This information describes the type of component and shall not be considered as assured characteristics No responsibility is assumed for possible omissions or inaccuracies Circuitry and specifications are subject to change without notice For the latest product specifica tions refer to the EnOcean website http www enocean com As far as patents or other rights of third parties are concerned liability is only assumed for modules not for the described applications processes and circuits EnOcean does not assume responsibility for use of modules described and limits its liability to the replacement of modules determined to be defective due to workmanship Devices or systems containing RF components must meet the essential requirements of the local legal authorities The modules must not be used in any relation with equipment that supports directly or indirectly human health or life or with applications that can result in danger for people animals or real value Components of the modules are considered and should be disposed of as hazardous waste Local government regulations are to be observed Packing Please use the recycling operators known to you 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 2 28 USER MANUAL Green Smart Wireless enocean TABLE OF CONTENT 1 RELATED
14. the firmware that governs the operation of the module The agency grant is valid only when the module is incorporated into a final product by OEM integrators m The end user must not be provided with instructions to remove adjust or install the module 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 19 28 USER MANUAL Green Smart Wireless enocean PIM 33 PIM s3xe PIM SAU m The Original Equipment Manufacturer OEM must ensure that FCC labeling require ments are met This includes a clearly visible label on the outside of the final product Attaching a label to a removable portion of the final product such as a battery cover is not permitted The label must include the following text PTM330C PTM332C Contains FCC ID SZV PTM33XC The enclosed device complies with Part 15 of the FCC Rules Operation is subject to the following two conditions i this device may not cause harmful interference and ii this device must accept any interference received including interference that may cause undesired operation When the device is so small or for such use that it is not practicable to place the state ment above on it the information required by this paragraph shall be placed in a promi nent location in the instruction manual or pamphlet supplied to the user or alternative ly shall be placed on the container in which the device is marketed However the FCC identifier or t
15. 15 15 AC2 1477 GND 9 Ve T4 T3 B 1289 GND B 11 50 2 5 1077 GND T7 T9 ACT D exo RF 2013 EnOcean www enocean com On back side of PCB PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 7 28 USER MANUAL Green Smart Wireless enocean PIM 33 RIME SXR SAU 3 3 Description and operational characteristics Symbol Function Characteristics Ground connection Hust be connected to GNP _ be connected to GND sm For test purposes onl Do not connect S O Genet ca ol pull up EM B1 Internal pull up EM LLLI ZEE Digital input leave open or connect to GND Internal pull up I Button Rocker A Digital input leave open or connect to GND Al Internal pull up ECO 200 or equivalent energy pulse RF_ 50 RF output 50 Ohm output for external antenna not avail TE for PTM 330U Configuration Interface lSee3 4 3 4 2013 EnOcean www enocean com 33x PTM 33xC 3300 33xU User Manual V1 1 Page 8 28 USER MANUAL Green Smart Wireless enocean PIM 33 PIM s3xe SAU 3 4 Configuration Interface Via the programming interface the telegram content can be modified The interface is shown in the figure below Rest PTM 330 PROG EN USB lt gt SPI ADIO7 interface SCSEDIOO SCLKDIO1 WSDADIO2 RSDADIO3 Dolphin Studio or EOPx EnOcean
16. 3 or 4 buttons 4 not possible 5 not possible 6 not possible 7 not possible PO 1 bit Polarity see table below Reserved 4 bit STATUS 7 0 Reserved T21 NU RP COUNTER Reserved 2 bit For future use T21 1 bit 1 NU 1 bit NU 0 gt U message RP_COUNTER 4 bit Repeater level 0 is original message not repeated The polarity PO is defined as follows AC1 SE PO 1 0 3 7 2 User defined operation Via the configuration interface it is possible to define different content of DATA_BYTE3 and define if a N message or U message shall be sent This allows for example to transmit other RORG F6 telegrams e g Mechanical handle as described in the EnOcean Equip ment Profiles defined by EnOcean Alliance For details please refer to the EnOcean Equipment Profiles 2 5 specification 3 8 Transmit timing The setup of the transmission timing allows avoiding possible collisions with data packages of other EnOcean transmitters as well as disturbances from the environment With each transmission cycle 3 identical subtelegrams are transmitted within 40 ms The transmis sion of a subtelegram lasts approximately 0 7 ms The delay between the three transmis sion bursts is affected at random 2013 EnOcean www enocean com 33x PTM 33xC 3300 33xU User Manual V1 1 Page 12 28 USER MANUAL Green Smart Wireless enocean 4 APPLICATIONS INFORMATION 4 1 How to connect
17. 332C LIMITED MODULAR APPROVAL This is an RF module approved for Limited Modular use operating as an intentional trans mitting device with respect to 47 CFR 15 231 a c and is limited to OEM installation The module is optimized to operate using small amounts of energy and may be powered by a battery The module transmits short radio packets comprised of control signals in some cases the control signal may be accompanied with data such as those used with alarm sys tems door openers remote switches and the like The module does not support continu ous streaming of voice video or any other forms of streaming data it sends only short packets containing control signals and possibly data The module is designed to comply with has been tested according to 15 231 a c and has been found to comply with each requirement Thus a finished device containing the PTM 330C PTM 332C PTM 330U radio module can be operated in the United States without additional Part 15 FCC approval ap proval s for unintentional radiators may be required for the OEM s finished product under EnOcean s FCC ID number This greatly simplifies and shortens the design cycle and devel opment costs for OEM integrators The module can be triggered manually or automatically which cases are described below Manual Activation The radio module can be configured to transmit a short packetized control signal if trig gered manually The module can be triggered by pressing a switch
18. 33XC New Family Certification Limited Modular Approval EnOcean GmbH Kolpingring 18a 82041 Oberhaching Germany Transmitter Module EnOcean PTM330C PTM332C 315MHz 315KA1D Wire Antenna 15cm Center for Quality Engineering SGS Germany GmbH HoffmannstraBe 50 81379 M nchen Germany RSS 210 Issue 7 RSS GEN Issue 2 RSS 102 Issue 4 Cen cason of equipment means only fat he equipment has met the requirements of the above noted sped cason License app casons where applicable to use equipmenm are acted on accordingly by the issuing otce and will depend on t e ex 3ng rado environment service and locason of operation This cerifeate is issued on condition that the holder complies and will continus to comply with the require ments of e radio stan dacs speciicaions and procedures issued by Department La certification du matre signifo seulement que le mat ro asatis ait aux exigences do norme indiqu e ci dessus Los demandes de n cessaires pour l utilisation du mat re corti sont trait es an cons quence par le bureau do G l vrance au ana 2 seca eae d exploitation Le pr sent certificat d livr la condition que le t u aire continue de satisfaire aux exigences aux proc dures 2 industry Canada Labelling of Certified Radio Equipment Equipment that has received certification but is not labelled with the applicant
19. 3xU User Manual V1 1 Page 15 28 USER MANUAL Green Smart Wireless enocean 4 5 Soldering information PTM 332 332C PTM 332 has to be soldered according to IPC JEDEC J STD 020C standard Profile Feature Pb Free Assembly Average Ramp Up Rate TSmax to Tp Preheat Temperature Min TSmin 150 C Temperature Max 75 200 C Time ts to tSmax 60 180 seconds Time maintained above Temperature T 217 Time 4 60 150 seconds Peak Classification Temperature Tp 260 C Time within 5 C of actual Peak Temperature tp Ramp Down Rate 3 C second max 2 Preheat t 25 C to Peak Time gt IPC 020c 5 1 PTM 332 shall be handled according to Moisture Sensitivity Level MSL4 which means a floor time of 72 h PTM 332 may be soldered only once since one time is already consumed at production of the module itself Once the dry pack bag is opened the desired quantity of units should be removed and the bag resealed within two hours If the bag is left open longer than 30 minutes the desiccant should be replaced with dry desiccant If devices have exceeded the specified floor life time of 72 h they may be baked according IPC JEDEC J STD 033B Devices packaged in moisture proof packaging should be stored in ambient conditions not exceeding temperatures of 40 or humidity levels of 90 r h PTM 332 modules have to be soldered wit
20. 868 MHz variant no pre installed antenna delivery as tape amp reel PTM 330C 315 MHz variant pre installed whip antenna delivery in card board box PTM 332C 315 MHz variant no pre installed antenna delivery as tape amp reel PTM 330U 902 MHz variant pre installed whip antenna delivery in card board box 2 2 Technical Data Power supply ECO 200 or equivalent energy pulse Antenna pre installed whip antenna PTM 330 330C 330U external 50 Ohm or whip antenna PTM 332 332C Frequency 868 3 MHz iz 333 315 0 MHz PTM 33xC 902 875 MHz PTM 330U Transmission power typ 3 dBm PTM 33x PTM 1 33xC 1dBm PTM 33xU at antenna base Data ra rate Modulation type _ 125 kbps ASK 315MHz 868MHz FSK 902MHz Telegram type RPS of type 2 allows interpretation of f operating two buttons simultaneously Digital inputs _ mu u _ 24 Transmission range up to 200 m free field up to 30 m indoor 0 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 4 28 USER MANUAL E g as c 5 e D ions 2 3 Physical Dimens 26 2x 21 15 x 3 5 mm imensions PCB d
21. M 332C Contains IC 5713A PTM33XC Contient le module d mission IC 5713A PTM33XC PTM 330U Contains IC 5713A PTM330U Contient le module d mission IC 5713A PTM330U L OEM doit signer l accord OEM limit e Approbation modulaire avec EnOcean pour utiliser PTM 330C 332C 2013 EnOcean www enocean com 33x PTM 33xC 3300 33xU User Manual V1 1 Page 25 28 USER MANUAL Green Smart Wireless enocean 5 3 1 PTM 330C and PTM 332C Industry Canada Technical Approval Certificate TECHNICAL APPROVAL CERTIFICATE besed on the Agreement on Mutua Recognition between the European Community and Canada CERTIFICATE NUMBER NUMERO DE CERTIFICAT CERTIFICATION NUMBER NUMERO DE CERTIFICATION TYPE OF SERVICE TYPE DE SERVICE CERTIFICATE HOLDER TITULAIRE DU CERTIFICAT TYPE OF EQUIPMENT GENRE DE MATERIEL TRADE NAME AND MODEL NUMBER MARQUE ET NUMERO DE MODELE FREQUENCY RANGE BANDE DE FREQUENCES EMISSION DESIGNATION TRC 43 DESIGNATION D MISSION CRT 43 R F POWER RATING WATT PUISSANCE NOMINALE WATT ANTENNA INFORMATION INFORMATION D ANTENNE CONTACT INFORMATION OF TESTING LABORATORY COORDONN ES DU LABORATOIRE DESSAI CERTIFIED TO SPECIFICATION ISSUE CERTIFI SELONLE CAHIER DES CHARGES DITION fea TESTLAB CERTIFICAT D APPROBATION TECHNIQUE en ss basant l accord de reconnaissance mutuelle entre la Communaut Europ enne et le Canada 10 111340 IC 5713A PTM
22. Transmitter Notes 315 MHz Transmitter Modular Type Limited Single Sm M t Frequency Emission Tolerance Designator Wh FCC Rule Parts 15 231 33x 33xC 3300 33xU User Manual V1 1 Page 21 28 USER MANUAL Green Smart Wireless enocean 5 2 3 PTM 330U FCC APPROVAL This device complies with part 15 of the FCC rules Operation is subject to the following two conditions 1 This device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired opera tion IMPORTANT Any changes or modifications not expressly approved by the party responsible for compliance could void the user s authority to operate this equipment The Original Equipment Manufacturer OEM must ensure that FCC labeling requirements are met This includes a clearly visible label on the outside of the final product Attaching a label to a removable portion of the final product such as a battery cover is not permitted The label must include the following text PTM 330U Contains FCC ID SZV PTM330U The enclosed device complies with Part 15 of the FCC Rules Operation is subject to the following two conditions i this device may not cause harmful interference and ii this device must accept any interference received including interference that may cause undesired operation When the device is so small or for such u
23. Wireless enocean 5 3 3 Industry Canada Regulatory Statements This device complies with Industry Canada licence exempt RSS standard s Operation is subject to the following two conditions 1 this device may not cause interference and 2 this device must accept any interference including interference that may cause undesired operation of the device Le pr sent appareil est conforme aux CNR d Industrie Canada applicables aux appareils radio exempts de licence L exploitation est autoris e aux deux conditions suivantes 1 l appareil ne doit pas produire de brouillage et 2 l utilisateur de l appareil doit accepter tout brouillage radio lectrique subi meme si le brouillage est susceptible d en compromettre le fonctionnement IMPORTANT Tous les changements ou modifications pas express ment approuv s par la partie responsable de la conformit ont pu vider l autorit de l utilisateur pour actioner cet quipment This Class B digital apparatus complies with Canadian ICES 003 Cet appareil num rique de la classe B est conforme la norme NMB 003 du Canada 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 28 28
24. an PTM 33X PTM 33XC PTM 330U 33XU 2 4 Environmental Conditions Operating temperature 25 65 C Storage temperature 40 85 C Storage temperature in Tape amp Reel 20 C 50 C Humidity 0 93 r h non condensing 2 5 Ordering Information Type Ordering Code Frequency Note PTM 330 3001 A330 868 3 MHz Whip antenna mounted Card board box PTM 332 3001 A332 868 3 MHz No antenna mounted Tape amp Reel 330C S3031 A330 315 0 MHz Whip antenna mounted Card board box 332C S3031 A332 315 0 MHz No antenna mounted Tape amp Reel 3300 S3051 A330 902 875 MHz Whip antenna mounted Card board box 2013 EnOcean www enocean com 33x PTM 33xC PTM 3300 33xU User Manual V1 1 Page 6 28 USER MANUAL Green Smart Wireless enocean 3 FUNCTIONAL DESCRIPTION 3 1 Block diagram At power up by an energy pulse at AC1 AC2 a DC voltage is provided to the internal micro controller The microcontroller reads the polarity of the supply voltage pulse and the status of the digital inputs AO A1 BO B1 After that 3 identical radio telegrams calculated from the status of these inputs are transmitted CFG AO 1 BO B1 GND AC1 AC2 3 2 Pin out PTM33x WHIP GND RF 50 Polarity EE Detection Power Converter GND 1 CFG BO GND B1 A0 GND A1 O QC A 16 AC1 1 2
25. he unique identifier as appropriate must be displayed on the device The user manual for the end product must also contain the text given above m Changes or modifications not expressly approved by EnOcean could void the user s au thority to operate the equipment m The module must be used with only the following approved antenna s Part Number Type Gain Wire Monopole 1 0 dBi m The OEM must ensure that timing requirements according to 47 CFR 15 231 a c are met The OEM must sign the OEM Limited Modular Approval Agreement with EnOcean 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 20 28 USER MANUAL Green Smart Wireless enocean 5 2 2 PTM 330C and PTM 332C FCC Grant TCB EnOcean GmbH Kolpingring 18 Oberhaching 82041 Germany OR AUTHORIZATION TCB Certification Issued Under the Authority of the Federal Communications Commission Attention Armin Anders Director Product Marketing Grant Notes 2013 EnOcean www enocean com By PHOENIX TESTLAB GmbH Koenigswinkel 10 Date of Grant 07 22 2010 D 32825 Blomberg Germany 1 Application Dated 07 22 2010 NOT TRANSFERABLE EQUIPMENT AUTHORIZATION is hereby issued to the named GRANT EE and is VALID ONLY for the equipment identified hereon for use under the Commission s Rules and Reguistions listed below FCC IDENTIFIER Name of Grantee Equipment Class Part 15 Security Remote Control
26. hin 6 months after delivery 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 16 28 USER MANUAL Green Smart Wireless enocean PIM 33 PIM s3xe PIM SAU 4 6 Transmission range The main factors that influence the system transmission range are type and location of the antennas of the receiver and the transmitter type of terrain and degree of obstruction of the link path sources of interference affecting the receiver and Dead spots caused by signal reflections from nearby conductive objects Since the expected transmission range strongly depends on this system conditions range tests should categorically be performed before notification of a particular range that will be attainable by a certain application The following figures for expected transmission range are considered by using a PTM a STM or a TCM radio transmitter device and the TCM radio receiver device with preinstalled whip antenna and may be used as a rough guide only Line of sight connections Typically 30 m range in corridors up to 100 m in halls Plasterboard walls dry wood Typically 30 m range through max 5 walls Line of sight connections Typically 30 m range in corridors up to 100 m in halls Ferroconcrete walls ceilings Typically 10 m range through max 1 ceiling Fire safety walls elevator shafts staircases and supply areas should be considered as screening The angle at which the transmitted s
27. ignal hits the wall is very important The effective wall thickness and with it the signal attenuation varies according to this angle Signals should be transmitted as directly as possible through the wall Wall niches should be avoid ed Other factors restricting transmission range Switch mounted on metal surfaces up to 30 loss of transmission range Hollow lightweight walls filled with insulating wool on metal foil False ceilings with panels of metal or carbon fiber Lead glass or glass with metal coating steel furniture The distance between EnOcean receivers and other transmitting devices such as comput ers audio and video equipment that also emit high frequency signals should be at least 0 5 m A summarized application note to determine the transmission range within buildings is available as download from www enocean com 2013 EnOcean www enocean com 33x PTM 33xC 330U 33xU User Manual V1 1 Page 17 28 USER MANUAL Green Smart Wireless enocean PIM 33 PIM s3xe PIM SAU 5 AGENCY CERTIFICATIONS The modules have been tested to fulfil the approval requirements for CE PTM 33x and FCC IC PTM 33xC PTM 330U based on the built in firmware 5 1 CE approval The modules bear the EC conformity marking CE and conform to the R amp TTE EU directive on radio equipment The assembly conforms to the European and national requirements of electromagnetic compatibility The conformity
28. provides EOPx EnOcean Programmer a command line program and Dolphin Studio Windows application for chip configuration programming and testing and the USB SPI programmer device as part of the EDK 300 350 developer s kits In order to con tact PTM 330 programming and testing points a needle bed adapter is needed Symbol Function Characteristics RESET Interface to programmer internal pull down ADIO7 Interface to programmer HIGH programming mode active LOW operating mode Internal pull down PROG EN Enable programming mode 3 5 Absolute maximum ratings non operating Symbol Parameter Min Max Units Supply voltage od y AC2 GND Ground connection 0 0 V 0 0 V A1 NS BO Voltage digital input pins B1 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 9 28 USER MANUAL 3 6 Maximum Ratings operating Green Smart Wireless enocean Symbol Parameter Min Units Supply voltage 0 6 8 y AC2 GND Ground connection 0 0 V 0 0 V A1 M Voltage digital input pins B1 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 10 28 USER MANUAL 3 7 Radio telegram 3 7 1 Normal operation Green Smart Wireless enocean In default configuration PTM 33x transmits the same telegrams as a PTM 210 radio switch Telegram t
29. s name model number and the certification number as outlined above is not considered certified uetage du mat riel radio homolog es requ rant num ro de mod le et num ro Certification Body Code DE0003 Blomberg 23 July 2010 recognised by Lud RENE w Le mat riel pour ur t t une certification a t obtenue pas tiquet conform ment aux exigences certification n est pas consid r comme certifi Ses by Signataire Uwe Dollitz Foreign Certification Body FCB BNetzA CAB 0422 53 PHOENIX TESTLAB GmbH K nigswinke 10 D 32825 Somberg Germany Phone 49 0 5235 8500 0 Fax 49 0 5235 8500 10 Nod phoenix testab de 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 26 28 USER MANUAL Green Smart Wireless enocean 5 3 2 PTM 330U Industry Canada Technical Approval Certificate FCB under the Canada EC MRA TCB under the USA EC MRA RFCAB under the MRA Notified Body EMC Directive 2004 108 EC DR RASEK No CA001351D TECHNICAL ACCEPTANCE CERTIFICAT D ACCEPTABILIT CERTIFICATE TECHNIQUE CANADA CANADA gt ARMED rn EnOcean GmbH Greet Adcress Kopngig Ba GY Oberhaching ro cose s2041 Dll el gt Remote Control Device gt Transmitter Module PTM 3300 BANDEDEPREGUENCES C0288 00286MH GENE DEMSS gt 20K7FIDAN RIDENS gt mmdumom
30. se that it is not practicable to place the statement above on it the information required by this paragraph shall be placed in a prominent loca tion in the instruction manual or pamphlet supplied to the user or alternatively shall be placed on the container in which the device is marketed However the FCC identifier or the unique identifier as appropriate must be displayed on the device 0 2013 EnOcean www enocean com 33x PTM 33xC 330U 33xU User Manual V1 1 Page 22 28 Green Smart Wireless USER MANUAL 5 2 4 PTM 330U FCC Grant TCB TCB Issued Under the Authority of the TET By n e Date of Grant 06 20 2013 ae Application Dated 06 20 2013 EnOcean GmbH Kolpingring 18a Oberhaching 82041 Germany Attention Armin Anders Director Product Marketing NOT TRANSFERABLE EQUIPMENT AUTHORIZATION is hereby issued to the named GRANTEE and is VALID ONLY for the equipment identified hereon for use under the Commission s Rules and below FCC IDENTIFIER Name of Grantee Part 15 Security Remote Control Transmitter 902 875MHz transmitter Grant Notes FCC Rule Parts Designator 15 231 5 Wr SSS SSS PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 23 28 2013 EnOcean www enocean com USER MANUAL Green Smart Wireless enocean 5 2 5 FCC Regulatory Statements
31. ype RPS There are two message types depending on how many buttons A0 A1 B1 have been pressed connected to GND o N message Only one or two buttons have been pressed o U message No pushbutton was pressed when activating the energy genera tor or more than two pushbuttons have been pressed Unique factory programmed 32 bit ID BYTE2 DATA BYTE1 DATA_BYTEO 0 and STATUS as follows N message DATA BYTE3 7 0 RID UD PR SRID SUD SA RID 2 bit Rocker ID 0 B 1 UD 1 bit UD 1 gt O button UD 0 gt I button PO 1 bit Polarity see table below SRID 2 bit Second Rocker ID SUD 1 bit Second SUD 1 gt O button SUD 0 gt I button SA 1 bit SA 1 gt Second action 2 buttons pressed simultaneously SA 0 gt No second action STATUS 7 0 Reserved T21 NU RP COUNTER Reserved 2 bit For future use T21 1 bit 1 NU 1 bit NU 1 N message COUNTER 4 bit Repeater level 0 is original message not repeated 2013 EnOcean www enocean com PTM 33x PTM 33xC PTM 330U 33xU User Manual V1 1 Page 11 28 USER MANUAL Green Smart Wireless enocean PIM 33 PIM s3xe PIM SAU U message DATA BYTE3 7 0 BUTTONS PR Reserved BUTTONS 3 bit Number of simultaneously pressed buttons as following 0 0 Button 1 not possible 2 not possible 3
Download Pdf Manuals
Related Search