Ergolift Wall Lift User Manual
Contents
1. l SLINGS PIVOTING EXTENSION PRODUCT A4580 26 ERGOLIFT WL USER MANUAL LOG BOOK Product Name ERGOLIF T WL Product Serial Number Date of purchase Warrantv Period Distributed By Owner Checklist LOG BOOK Ensure the lift is serviced regularly as the maintenance inspection checklist on page 23 Contact an authorized BHM Medical Distributor Service Agent immediatly if there are any problems with the operation of the device Ensure the log book is completed and signed Record any repairs required Withdraw the patient lifter from service if inspection reveals that user safety is jeopardized in any way from use of the patient lifter TO BE COMPLETE AFTER EACH SERVICE OR INSPECTION Service Type Condition report Action taken Service Type Condition report Action taken Pre delivery Periodic inspection Inspected by Printed Pre delivery Periodic inspection Inspected by Printed ERGOLIFT WL USER MANUAL Signature Signature 21 Service Tvpe Condition report Action taken Service Tvpe Condition report Action taken Service Tvpe Condition report Action taken Service Tvpe Condition report Action Pre deliverv Pre deliverv Pre2. 18 Alwavs use the same color loop on o the rear shoulder straps for both sides of the sling Use the same color loop on the hip straps for both sides of the sling 3 Ensure the patients arms are inside the sling and that it is not caught on anv obstructions eg Wheelchair brake or handle 4 See Lift Instructions for next step User Instructions for Hygienic Sling This sling is excellent for changing incontinence pads or to transfer onto a toilet as it provides an open area from the middle of the back to the middle of the thigh The padding wraps around the patient s midsection and under each leg In order to use this sling the patient must have ood muscle tone in their shoulders and upper body Available in sizes S M amp L The weight capacity is 250 kg 550 Ib Do not use Hygienic sling on a patient who does not have good muscle tone in their shoulders and neck Check with the patient s physician nurse or medical specialist before using this sling SLING SIZES AND PRODUCT NUMBERS SMALL MEDIUM LARGE _ 27 35 35 42 42 49 COLOR Yellow Green CODE 1 Sling has two sides the white fabric indicates the side that is intended to be next to the patient and the label and colored ERGOLIFT WL USER MANUAL SLINGS handles are on the outside The bottom of the sling has two long straps and the inside of the sling has a padded section with a belt Whenever pos
3. Slings should be stored awav from direct sunlight stress pressure excessive heat or humiditv The sling should be kept awav from contact with sharp objects corrosives or other possible damaging material Dailv Checklist 1 Check for any sign of wear on sling straps as described above and at the strap sling junction Buckles should be checked to ensure that the locking unlocking mechanism opens and closes easilv and is secure when locked Pw 4 Y gt S U X Loose threads in stitched area Noticable discoloration by having a lighter color strap than the double thickness stitched area JA e wear Middle wear 2 Check for any sign of deterioration of the sling material Check for general external wear local abrasions cuts holes or burns in the webbing and for chemical attack 3 Look at stitched areas for broken worn pulled or unravelled stitches 4 Sling should be cleaned as indicated on the tag 5 If there is any sign of wear or deterioration as indicated above or other visual defect the sling should be changed immediately By continuing to use the lift without changing the sling caregiver and patient safety is greatly compromised Take note of inspection results in the log book at the end of this manual MAINTENANCE ALWAYS CARRY OUT THE DAILY CHECKLIST BEFORE EACH LIFT USE ERGOLIFT WL and accessories must be inspected ANNUALLY by a cer
4. USER MANUAL Revision 1 September 2002 IMPORTANT Read these instructions before installing operating or servicing this svstem ERGOLIFT WL WALL LIFT DO NOT DESTROV KEEP MANUAL WITH THE LIFT AT ALL TIMES BHM MEDICAL INC 2001 TANGUAY STREET MAGOG QUEBEC CANADA JIX 5Y5 Instruction manual Part 001 04525 ERGOLIFT WL USER MANUAL 1 B H M Medical Inc designs and manufactures quality engineered patient lifting equipment for the care of the disabled in hospitals nursing homes and home care Please take the time to read the entire manual including the section on Safety Instructions and Warnings It contains important information that will allow you to take advantage of all the characteristics of your BHM patient lift BHM Medical Inc Credentials FDA Registration 9681684 CE mark European Union Listing Global Operations for in warranty and out of warranty service support for all patient lifts Each finished ERGOLIFT WL is individually tested in our laboratory Lifting Capacity is 350 Ib 160 kg Engineering safety factors exceed European Standards Complete range of patient lift slings and supports designed and manufactured by BHM Medical Inc using medical quality materials and fabrics e ISO 9001 APPROVALS CSA 601 1 UL 2601 1 EN 60601 1 EN ISO 10535 Lifting device SGS UK Test Report DUR22107 AC OO Note BHM Medical is constantly improving its products For this reason it ma
5. motor until the boom is no longer being lifted or pressed upward This will ensure that the motor stops if the boom is unknowingiv being lowered onto an object or patient To check this feature press the button on the handset or control box then lift up the boom The motor should stop Stretching the Boom To extend the boom unclip the locking clip from the clevis pin Remove the clevis pin from the boom Extend the boom to the length desired Make sure not force or extend the boom bevond its reach It can be hazard to the patient ERGOLIFT WL USER MANUAL INSTALLATION OPERATION Align the hole of the boom and the extension d DU Insert the clevis pin back in into the boom Be sure that the locking clip it properlv installed on the clevis pin before using it Failure to do so mav cause serious injuries to the patient 11 BHM ERGOFIT SLING Every patient has different needs It is very important to choose the right sling based on the needs of the patient to be transferred as well as their phvsical abilitv and size All BHM slings are made from a Polyester Nylon material which is soft and pliable easy to care for and install All slings are machine wash and dry in medium temperature BHM slings are covered by a one year warranty FOLLOWING BEFORE USING A BHM MEDICAL ERGOFIT SLING gt ALWAYS CARRY OUT THE DAILY CHECKLIST BEFORE EACH LIFT USE gt BHM MEDICAL WALL LIFT IS SP
6. numbers if any as described above along with a full description of damaged parts Key to Symbols The following symbols are used on lifters attachment labels CE This symbol is required to be displayed on regulated products for sale in the European Market It indicates that the product complies with applicable European Directives related to health safety environment and consumer protection SWL Safe Working Load represents the maximum load the lifter is rated for safe operation The following symbols are used on sling labels and related to washing instructions 60 c Maximum washing temperature is 60 C 140 F for permanent cycle Do not use bleach 7S Lx Do not dry clean Tumble dry low temperature lt Do not iron Please refer to individual sling labels for complete instructions regarding washing and drying SAFETV INSTRUCTIONS AND WARNINGS SAFETV INSTRUCTIONS AND WARNINGS A GENERAL gt IMPORTANT READ CAREFULLY THESE INSTRUCTIONS OR SERIOUS INJURIES MAY RESULT gt KEEP THESE INSTRUCTIONS WITH THE LIFT AT ALL TIMES gt READ OPERATING MAINTENANCE INSTRUCTIONS IN THIS MANUAL BEFORE INSTALLING OPERATING OR SERVICING THIS EQUIPMENT gt YOUR LIFT is for transferring patients only Do not use the lift for any other purpose gt ALWAYS carry out the daily check list before using the lift gt BHM Medical ERGOLIFT WL is specifically designed for BHM Medical slings and accessories
7. stitching of the sling handle at the center to make sure that it is in line with the patients spine and bring the patient against the back of the chair or wheelchair 6 Kneel in front of the patient so that your back is straight and so you are at eye level with your patient Grab the end of the sling with the white fabric and make sure there are no twists in the sling Make sure the white fabric is facing the patient s leg Place one hand on the patient s knee to hold it in place and gently pull the sling forward with the other hand until the edge of the sling is approximately even with the patient s knee 7 Place the patient s foot on your thigh and slide the white section of the sling under the leg 7 Repeat steps 5 amp 6 for the other leg ERGOLIFT WL USER MANUAL SLINGS Sling Attachment Options Option Opilon2 Option 3 Option 1 Bridge The most recommended a Take the two straps between the legs these are the short loops and thread one loop through the other to cross them a hk a bina b Now take the long strap on the outside of each leg and string it through the inside strap By crossing the straps as you see here form a bridge above the patient s legs and protect them from any pinching or pressure as well as keep the knees and hips in line Finally place the patient s hands inside the sling 14 SLINGS OPTION 2 Leg Separation Using this method of sling pl
8. 1 Make sure that all straps are attached to the carry bar 2 Make sure the patient is comfortable 3 Make sure the sling is not caught on any obstruction wheelchair brake or arm of chair If any of the above occurs Lower the patient immediately and correct the problem Lift until the patient s buttocks clear the arm supports or the top of the bath or bed before moving the patient Guide the legs past any obstacle THE BHM ERGOLIFT WL IS NOT INTENDED TO BE A TRANSPORT DEVICE DO NOT MANOEUVRE THE LIFT BY PULLING ON THE MAST BOOM ACTUATOR OR PATIENT ATTEMPT TO 10 When the patient is located above the desired point of transfer and readv to be lowered press the button Make sure wheels are locked on the bed or wheelchair For a transfer into a seated position use the handles on the back of the sling to position the patient when transferring into a chair Hold the handles firmly as the sling lowers and the sling will tilt back to position the patient As the boom lowers guide the lift away from the patient approx 6 in 15 cm Once the patient is properly seated and the straps are loose remove the sling from the lift Push the lift away from the patient Sling can be removed from around the patient Anti crush feature To prevent damage or injury the motor on the lift has a limit switch that recognizes when the boom is being lifted or pressed upward This limit switch will stop the
9. E TRE atada ao cid ad 11 STRETCHING THE BOO Munimadrid da EA 11 BAM ERG OFM SUING i ii a otto ta 12 HAMMOCK e BI A acid 12 SLING PLACEMENT FROM CHAIR OR WHEELCHAIR ccececececececccaccccecenecececececetececececeneneneneneneneners 13 SLING ATTACHMENT OPTIONS i a i ak A a an a 14 EE E e E E tt aa A a 17 YS SUING i a at tl at E 19 SLING INSPECTION AND CARE a a cist anran nu rnunana naL AACE u CA aa bit 20 MAINTENANCE 0 a eet sees cee a et 21 BARBAS e AA A O a taa 21 INSPECTION AND CLEANING cusco added 21 HANDLING AND STORA GE susi rd a ad ii tada 21 BOOM ACTUATOR REPLACEMEN Tos da ini 21 GARRY BAR REPLACEMENT a dadas 22 ANNUAL INSPECTION sai cios 22 MAINTENANCE INSPECTION CHECKLIST dcccocococococococonononononononncncncncnonononanonanonancnancnanananananana 23 TROUBLESHOOTING k i i rt 25 AGCGESSORIE Sii iii i aia 26 LOG BOOK ii a ta o da ih 27 WARRANTY A 29 ERGOLIF T WL USER MANUAL 3 INTRODUCTION How to Use this Manual DO NOT ATTEMPT TO USE THIS EQUIPMENT WITHOUT UNDER STANDING THIS MANUAL To ensure safe operation read carefuliv the entire manual especiallv the section on Safety Instructions and Warnings before installing operating or servicing this equipment If anything is not completely understood please contact your supplier for more details Failure to comply with warnings in this manual may result in injuries Keep this manual with the lift and refer to it as required Contents of this manua
10. ECIFICALLY DESIGNED FOR BHM MEDICAL SLINGS AND ACCES SORIES SLINGS AND ACCESSORIES DESIGNED BY ANY OTHER MANUFACTURERS ARE PROHIBITED AND WILL VOID BHM MEDICAL S WARRANTY USE ONLY BHM MEDICAL SLINGS AND ACCESSORIES TO MAINTAIN PATIENT SAFETY AND PRODUCT UTILITY PATIENT TO BE TRANSFERRED MUST BE ASSESSED BY A QUALIFIED PROFESSIONAL BEFORE ATTEMPTING TO TRANSFER Observe a trained expert to perform the transfer procedures and then practice them several times with a capable individual acting as_ patient before attempting a transfer with a patient with limited capabilities gt READ CAREFULLY ALL INSTRUCTIONS BELOW BEFORE ATTEMPTING TO INSTALL A SLING IF YOU HAVE ANY DOUBTS PLEASE CONTACT YOUR LOCAL REPRESENTATIVE Before transferring a patient from a stationary object wheelchair bath or bed slightly raise the patient off the stationary object and check that all sling attachments are secure If any attachment is not correct lower the patient and correct the problem then raise the patient and check again gt USE A SLING RECOMMENDED BY ERGOLIFT WL USER MANUAL 1 PLEASE READ CAREFULLY THE SLINGS THE PATIENTS PHYSICIAN NURSE OR MEDICAL SPECIALIST AS AP PROPRIATE FOR THE PATIENT S ABILITV AND NEEDS DO NOT use any kind of plastic backed incontinence pad or seating cushion between the patient and sling material That mav cause the patient to slide out of the sling during a transfer DO NOT exce
11. ERGOLIF T WL wall lift is an excellent option for those situations where the ceiling lift or the floor lift is not quite the right solution The wall lift can be mounted on a secure post next to a wall or next to a pool or hot tub With its ability to rotate it allows access to a wide range and since the lift can be mounted at any height the lift can be installed at just the right height for you Extra wall brackets are available so you can use the lift in more than one location Portable Built in control box Weight movable part 13 5 kg 30 Ib Lifting capacity 160 kg 350 Ib Soft start amp stop movement 360 degrees patient rotation capability even at maximum height Universal carry bar Unit rotates 180 degrees Actuator with anti crush mechanism Water resistant control handset Water resistant electronics and circuit board Padded swivel carry bar Vertical displacement speed 1 75 cm sec 7 in sec Meets CSA 601 1 CE and UL 2601 1 requirements DIMENSIONS DESCRIPTION OF EQUIPMENT PARTS DESCRIPTION Wall plate Boo A Locking clip e Y Telescopic o AN boom a Actuator U PS a kai Control EF A Sg AT NU i Carrv bar Handset Mo Pivoting E mast Power cord CAPACITY A KG LBS CMAN 160 350 30 12 41 16 53 21 75 29 84 33 30 12 79 35 ERGOLIFT WL USER MANUAL INSTALLATION How
12. Slings and accessories designed by any other manufacturer are prohibited and will void BHM Medical s warranty Use only BHM Medical slings and accessories to maintain patient safety and product utility gt BHM Medical ERGOLIFT WL is intended to be used for patients within the specified weight limit indicated for the lift Do not attempt to lift more than the weight limit indicated gt BEFORE attempting to transfer the patient must be assessed by a qualified professional gt BHM Medical ERGOLIFT WL must be used by a caregiver with proper training to work with the patient to be transferred v ONLY trained and qualified caregivers should transfer a patient DO NOT attempt to use the lift if you have not been properly trained to do so ALWAYS be prepared before attempting to transfer a patient DO NOT use a sling that is not recommended for the lift NEVER use a damaged torn or frayed sling ALWAYS place the sling around the patient according to the instructions enclosed FOLLOW lifting procedures outlined in this manual Y Y VV V WV USE all controls and safety features only according to the rules specified in this manual Never attempt to force a control or button on the lift v IMPORTANT Keep all components of the lift clean and dry and have electrical and mechanical safety checkpoints done as instructed in the Maintenance section of this manual gt REPLACE any precautionary or instruction labels that cannot be eas
13. acement will pull the patient s legs apart Check with the patient s physician nurse or medical specialist before attempting this method a Thread the long strap through the short strap OPTION 3 Amputee Do not use this method of sling placement for a patient who is agitated or spastic b Each short strap should be attached to the a Slide the sling end with the white fabric so long strap on the same leg that it is all the way under both legs One sling strap will be on top of the other a d la c Place the hands inside the sling See sling placement for leg separation as installed below b Thread the long strap through the short strap that is next to it The photo on the next shows clearly an example without a patient In it ERGOLIFT WL USER MANUAL 15 SLINGS c When installed there should not be anv sling material between the patient s legs Place the hands inside the sling Sling Placement from a Iving position 1 Fold the sling in half lengthwise with the white part of the sling on the inside of the fold and place next to the patient to be transferred hai 3 Lower the patient down on top of the sling Roll the patient the opposite direction to pull the sling out the other side When transferring a patient from a bed have people on each side of it or raise the bed rails to ensure the patient does not roll off the a bed 4 Place the straps in t
14. ct In the event that you do not receive satisfactory warranty service please contact BHM Medical see contact information in Table of Contents Do not return products to our factory without prior authorisation BHM Medical will issue a Return Merchandise Authorisation RMA Number C O D shipments will be refused all shipments to BHM Medical must be prepaid For this warranty to be valid the purchaser must present its original proof of purchase at the moment of the claim The defective unit assembly or part must be returned to BHM Medical for inspection The part or components repaired or replaced are guaranteed for the remaining period of the initial warranty Limitations and Exclusions The warranty above does not apply to serial numbered products if the serial number has been removed or defaced No warranty claim shall apply where the product or any other part thereof has been altered varied modified or damaged either accidentally or through improper or negligent use and storage Warranty does not apply to products modified without BHM Medical express written consent including but not limited to products modified with unauthorised parts or attachments products damaged by reason of repairs made to any component without the specific consent of BHM Medical or to products damaged by circumstances beyond BHM Medical control BHM Medical will solely determine evaluation of warranty claim The warranty does not apply to problems arisin
15. deliverv Pre deliverv ERGOLIF T WL USER MANUAL Periodic inspection Inspected bv Printed Periodic inspection Inspected bv Printed Periodic inspection Inspected bv Printed Periodic inspection Inspected bv Printed LOG BOOK Signature Signature Signature Signature 28 WARRANTV WARRANTY This warranty is extended only to the original purchaser user of BHM products BHM Medical Inc warrants its products to be free from defects in material under normal use and service within the periods stated below from the date of purchase If within such warranty period any such product shall be proven to be defective such product shall be repaired or replaced at BHM Medical option This warranty does not include any labour or shipping charges incurred in replacement part installation or repair of any such product BHM Medical sole obligation and your exclusive remedy under this warranty shall be limited to such repair and or replacement Patient Lifter 1 year Tracks and installation Life time warranty Weighing Devices 1 year Accessories on Lifter 1 year Slings 1 year Batteries Voyager Portable 3 months Batteries All other lifts 1 year Easytrack System 1 year For warranty service please contact the dealer from whom you purchased the BHM Medical produ
16. ed the maximum weight limitation of the sling gt WHENEVER POSSIBLE HAVE SOMEONE ASSIST YOU TO ENSURE THE PATIENT S SAFETY AT ALL TIMES Laundry instructions for all slings The following symbols are used on sling labels and related to washing instructions 60 C Maximum washing temperature is 60 C 140 F for permanent cycle AS Do not use bleach Do not dry clean Do not iron OJ Tumble drv low temperature X User instructions for Hammock Sling Inspect each sling for wear tears or loose stitching after each wash Hammock Sling THA S M amp L Our most universal sling the Hammock sling is a mesh type material that dries quickly but is soft and pliable The sling has an incorporated head support and a unique strap system that keeps the patient secure in the sling A special polyester fabric in the seat area helps to reduce friction and makes the sling easy to place around a patient in a chair without lifting or remove the patient The patient may be transferred in a seated semi reclined or fully reclined position Best choice for most situations including bathing Fits to all BHM ceiling lift models as well as Ergolift Lift models Available in sizes S M amp L The weight capacity is 250 kg 550 Ib 12 Hammock 6 Strap Sling THA6 S M amp L Almost identical to the Hammock sling above this sling provides extra security and a tighter fit for patients who are low tone or w
17. et on unistruts and affix it bv screwing bolts into strut nuts lt A SS a Sl 3 ES E gt gt SS Kea EC SQ gt WS SS Sy Re lt QQ A BA s a3 E Ba lt 2 x 4 O 16 CC AW 7 SS ABBA al NS SS A G M SAAS Da lt SW l View of the installation from the side HILTI STRUT NUT 3 8 M10 wE A A l A A L GR NA M10 X 25mm HEX a a LOCKWASHER 3 8 M10 A on ii j 3 LAG BOLT 3 8 X 4 10 X 100mm Y Af FLAT WASHER 3 8 M10 Pa 2 X 4 0 16 cc Check with your BHM representative or dealer to obtain all A the hardware specified in these installation instructions Check the strength of the installation NX before using it Actuator Installation Insert the upper part of the actuator between the mid boom brackets Insert the clevis pin and block it by inserting a split ring into the clevis pin Insert the lower part of the actuator between the mid mast brackets Insert the clevis pin and block it by inserting a split ring into the clevis pin Be sure that the split ring is completely inserted into the clevis pin ERGOLIFT WL USER MANUAL INSTALLATION 8 OPERATION Boom Installation To install the boom insert the upper part into the wall plate hole san Then insert the lower part of the mast into the metal pivot Plug the actuator and the handset p
18. etter suited for the black loops on both the shoulder and leg straps ERGOLIFT WL USER MANUAL SLINGS Always use the same color loop on the shoulder straps for both sides of the sling Use the same color loop on the leg straps for both sides of the sling 3 Ensure the patient s arms are over top of the sling and that it is not caught on any obstructions eg Wheelchair brake or handle 4 See Lift Instructions for next step Sling Inspection and Care For maximum patient safety and hygiene read the following instructions Chemical Attack Oil grease creosote or paint stains are harmless but other forms of chemical attack of a sufficient degree may lead to deterioration or extreme softening of the webbing which would lead to the fibres being rubbed off almost as powder in extreme cases It is best to avoid fumes spray or mists of acid and alkalis or organic solvents If contamination is suspected wash out well in warm water Avoid contact with excessive heat which is likely to affect the product Cleaning Certain chemical substances mentioned above may be removed by a heavy duty cleaner diluted in warm water Ensure that any cleaning agents are removed by rinsing throughly in warm water at a maximum temperature of60 C 140 F and allowed to dry naturally away from any source of direct heat For normal washing and cleaning follow the care instructions on the label of the product 20 Storage
19. g from normal wear or failure to adhere to the instructions in this manual BHM Medical Inc slings are void of warranty if not laundered as per instructions on the Sling Label BHM Medical Inc shall not be liable for damages losses or inconveniences caused by a carrier This warranty replaces any other warranty expressed or implicit and constitutes BHM Medical Inc only obligation towards the purchaser BHM Medical shall not be liable for any consequential or incidental damages whatsoever Valid only if BHM Medical did the original installation Warranty will be void if tracks or and installation have been modified ERGOLIFT WL USER MANUAL 29
20. hat it is in line with the patient s spine and bring the patient against the back of the chair Kneel in front of the patient so that vour back is straight and so vou are at eve level with your patient Grab the end of the sling with the white fabric and make sure there are no twists in the sling The white fabric should be facing the patient s leg Place one hand on the patients knee to hold it in place and gentiv pull the sling forward with the other hand until the edge of the sling is approximatelv even with the patient s knee F ti kja 1 z nil 5 MAN ne A ej kk kol pa A ai ma a A y E 5 Place the patient s foot on your thigh and slide the white section of the sling under the leg Take the two straps between the legs There is a small loop on each strap right next to the sling Thread one strap through the other to cross them ERGOLIFT WL USER MANUAL SLINGS By crossing the straps as you see here we keep knees and hips in line Place the patient s hands inside the sling before attaching it to the lift Sling attachment to Carry Bar ili Ensure the sling is properly placed around the patient according to the instructions above Choose the color of the loop you will need for the position that the patient be placed in If transferring to a seated position use the loops indicated for a seated position
21. he same way as shown o eu p gt s 8 D SP oles H i8 E fa la ee MINT f from a seated position for the hammock 2 With someone there to assist you carefully sling roll the patient onto one side Now place the fold of the sling at the center of the bed or where the spine of the patient will be The top of the U shaped in the sling should be at the base of the spine or coccyx The top of the sling should be next to the head Lift the top fold and tuck next to the patient ERGOLIFT WL USER MANUAL 16 Sling attachment to Carrv Bar 1 Ensure the sling is properly placed around the patient according to the instructions above 2 Choose the color of the loop you will need for the position that the patient will be placed in If transferring to a seated position use the loops indicating it Always use the same color loop on the rear shoulder straps for both sides of the sling Use the same color loop on the leg straps for both sides of the sling Use the same color loop on the hip straps for both sides of the Hammock 6 straps sling 3 Ensure the patients arms are inside the sling and that it is not caught on any obstructions eg wheelchair brake or handle 4 See Lift Instructions for next step ERGOLIFT WL USER MANUAL SLINGS User Instructions for Quick Fit Sling Specially designed for patients who are stocky or obese especially in the midsection padding around the buttock
22. ho would prefer a more secure feeling The head support is tighter and the extra straps on the side provide more lateral support The patient may be transferred in a seated semi reclined or fully reclined position Available in sizes S M amp L The weight capacity is 250 kg 550 Ib SLING SIZES AND PRODUCT NUMBERS SMALLI MEDIUM LARGE NO Approximate 20 46 kg 46 95 kg weight 45 100 100 210 Ib Ib Ib Approximate 120 150 151 180 cm 181 cm height cm 4 5 5 11 411 95 250 kg 210 550 ColorCode Red Yellow Green Product H Product Sling Placement from Chair or Wheelchair 1 Sling has two sides the white fabric indicates the side that is intended to be next to the patient and the label and colored handles are on the outside The top of the sling is slightly rounded and the bottom has a U shaped design ERGOLIFT WL USER MANUAL SLINGS U shaped and white fabric 2 Lean the patient forward in the chair and make sure that the patient is supported Whenever someone assist vou to ensure the patient s safetv at all times possible have 3 With the white fabric of the sling facing the patient grab the sling at the top of the U shaped and slide the sling down to the base of the spine or coccvx 4 Tuck the sling down on each side to make sure that it is just slightly under the patient s buttocks Check for the
23. ified technician ERGOLIFT WL and AN accessories must be serviced everv 12 months as a minimum requirement Do not attempt to do the inspection unless vou are certified to do so As part of the annual inspection an annual load test with the safe working load must be performed on the ERGOLIF T WL as required for CE MARK MAINTENANCE After annual inspection have the log book signed by the certified technician 22 MAINTENANCE INSPECTION CHECKLIST Maintenance Inspection Checklist TO BE INSPECTED BY USER INITIALLY BEFORE EVERY 2 EVERY 4 EVERY EVERY MONTHS MONTHS YEAR LIFT DEVICE pomon XX IX Dverainspecionbyauorzederomet TT TL ES SLINGS AND HARDWARE SS AS E TT reat sing master O a TT pwason OA rector any deer oricose reads in esteros TX TTT THE MAST ST babe TX TX TTT herra eres XIX L L THE BOOM Pa mamma XX E repeat ordeteioss RO A X X Inspect bolted joints of boom for wear THE SWIVEL BAR Check the bolt for wear or damage X X ELECTRIC ACTUATOR ASSEMBLY Check for wear or deterioration IF DAMAGED RETURN TO X X FACTORY X X AE E Cycle to ensure smooth quiet operation XK A complete inspection of the actuator must be done by a certified X technician CLEANING For individual home use a full inspection is required prior to each new user Regular cleaning will reveal loose or worn parts enhance smooth operation and extend the life expectancv of the l
24. ift If applicable do an annual load test maximum load of Safe Working Load Load is required for CE Mark Maintenance LA note of inspection results in the log book at the end of this manual ERGOLIFT WL USER MANUAL 23 MAINTENANCE INSPECTION CHECKLIST MINOR SERVICE ITEM di BEFORE EVERY 2 ee EVERY EVERY ser YEAR MONTH f Inspect surfaces for Inspect surfaces for scatohes ohips 10000 ea surfaces with mild soap and water and remove A G adhesive tape marks with WD40 or other degreasing agent Arrange repair replacement of anv Arrange repair replacement of any faulty parts parts e for signs or fatigue or cracks on the wall lift MO joints and stress points Retard rusting by applying with spray paint BHM touch Up Paint Product reference P6111 Check boom carry bar hanger Keep a record of servicing along with signature of authorized service agent Check all electrical components Inspect the welding aspect on the mast and the boom to detect ja cracks Inspect connecting joints for proper attachment Load test with the SWL maximum working capacity Service motor A major service undertaken by an authorized service agent every 12 months is a minimum requirement Maintenance inspection points are suggested by the manufacturer and are a minimum requirement By continuing to use the lift without replacing the listed parts in this maintenance inspection checklist caregiver and patient safe
25. ily read gt DO NOT attempt to manoeuvre the lift by pushing on the mast motor shaft boom or patient gt ALWAYS manoeuvre the lift with the handset provided gt DO NOT use an electric lift in a shower SHOCK PREVENTION AVOID violent shock during transportation DO NOT touch or use a lift with bare conductors or a damaged power cord Electrically live equipment can electrocute a patient If the lift has any exposed or damaged wires contact your local dealer immediately DO NOT cut or remove the round grounding prong from any plug All BHM lifts are equipped with three prong plugs to protect from shock hazard or electrocution Any two prong electrical outlet must be replaced with a properly grounded three prong outlet ERGOLIFT WL USER MANUAL 5 SAFETV INSTRUCTIONS AND WARNINGS B SHOCK PREVENTION according to the National Electrical Code and local codes It is the responsibility of the customer to have the work done by a qualified electrician gt DO NOT splash or expose electric parts of the device to water or moisture gt CHECK nameplate for voltage and cycle requirements These requirements differ by country Do not attempt to use the lift in an area that has a different voltage and cycle C EQUIPMENT WARNING LABELS gt Inspect all precautionary labels on the equipment Order and replace all labels that cannot be easily read ERGOLIFT WL USER MANUAL 6 DESCRIPTION OF EQUIPMENT ERGOLIFT WL The
26. l are subject to change without prior notice to users Throughout this manual the following symbols may appear Pay particular attention to the information provided under these headings These special annotations are easily recognized as follows WARNING this symbol is intended to alert the user to hazards or unsafe practices which could result in serious bodilv harm CAUTION this svmbol is intended to alert the user of the presence of important operating and maintenance instructions which could prevent product damage or possible personal injuries y NOTE this symbol offers helpful information concerning certain operating procedures You can purchase additional copies of this manual by contacting your supplier Include the User ERGOLIFT WL USER MANUAL INTRODUCTION Manual product number and equipment identification numbers Equipment Identification The unit s identification number specification model and serial number appears on a silver nameplate attached to the back of base Receipt of Equipment Upon receipt of the equipment verifv it against the packing list to ensure it is complete and inspect the equipment for possible damage due to shipping lf there is anv damage DO NOT use the equipment Notify the carrier immediately to file a claim Provide complete information concerning damage claims or shipping errors to your supplier Include all equipment identification numbers and group part
27. lugs into the control box Plug the control box power cord into an electrical outlet Carrv bar installation To install vour carrv bar remove the clevis pin and the split ring from the end of the boom Insert the carrv bar between the two brackets Reinsert the clevis pin and the split ring Be sure that the split ring is completelv inserted into the clevis pin OPERATION How to use the Ergolift WL READ THE SAFETV INSTRUCTIONS AND WARNINGS SECTION BEFORE ATTEMPTING TO USE CAREFULLY THE LIFT Alwavs carrv out the dailv checklist before each lift use Plug the lift into the electrical outlet Install the patient sling see Sling section Raise lower the boom using the e buttons on the handset so the carry bar is approximately to chest height of the patient ERGOLIFT WL USER MANUAL INSTALLATION 8 OPERATION Move the lift over to the patient so the end of the boom is approximately 15 cm 6 inches away from the patient For a patient in a lying position lower the lift so the carry bar is near the thorax then install the straps HAVE SOMEONE ASSIST YOU WHEN ATTEMPTING TO TRANSFER A PATIENT Attach the straps of the sling as described in the sling instruction section of the manual Make sure that all straps are secure on the carry bar Carefully observe the patient s safety as you lift the patient slightly by pressing the control button BEFORE LIFTING THE PATIENT
28. ndling and Storage Avoid violent shock during transportation Boom Actuator Replacement 1 Unplug the lift from the electrical outlet 2 Unplug the actuator and the handset plugs from the control box 21 3 4 O 6 T 8 Remove the boom from the wall plate and place it on a table Remove the split ring with a flat head screwdriver and the clevis pin from the upper part of the actuator Remove the boom from the actuator Repeat step 4 but for the lower part and remove it from the lower bracket Replace the actuator with a new one Insert the clevis pins and the split rings back into the upper and lower part of the actuator Be sure that the split rings are completely inserted into clevis pins ERGOLIFT WL USER MANUAL MAINTENANCE 9 Place the boom back into the wall plate Follow instructions in the Boom Installation section 10 Plug the actuator plug and the handset plug back into the control box and plug the lift in the outlet 11 To check if the actuator is functional press the handset buttons Carry Bar Replacement 1 To replace a carry bar remove the split ring with a flat head screwdriver and the clevis pin from the end of the boom 2 Replace the carry bar with a new one 3 Reinsert the clevis pin and the split ring Make sure that the split ring is completely inserted Annual Inspection The ERGOLIFT WL and accessories must be inspected annually by a cert
29. s and leg area helps to provide extra support Upper portion of the sling is a mesh type material that dries quickly but is soft and pliable This sling does not provide head support The patient may be lifted in a seated semi reclined or fully reclined position Available in sizes S M 8 L The weight capacity is 250 kg 550 Ib Do not use the Quick Fit sling on a AN patient who cannot support his own head SLING SIZES AND PRODUCT NUMBERS SMALL MEDIUM LARGE Approximate 20 46 kg146 95 kgf95 250 kg Ib Ib Ib rane emi 151 180 181 cm height cm 4 cm 5 411 511 Color Code__ Red____ Yellow_ Green Sling Placement from a Chair or a Wheelchair Whenever possible have someone assist you to ensure the patient s safety at all times 1 The sling has two sides the white fabric indicates the side that is intended to be next to the patient and the label and colored handles are on the outside The top of the sling is straight and the bottom of the sling has a U shaped design 2 Lean patient forward in the chair and make sure the patient is supported With the white fabric of the sling facing the patient grab the sling at the top of the U shaped and slide it down to the base of the spine or coccyx Tuck the sling down on each side to make sure that it is just slightiv under the patient s buttock Check the seam for the sling handle at the center to make sure t
30. sible have someone assist you to ensure the patient s safety at all times 2 Lean patient forward in the chair and make sure the patient is supported 3 With the white fabric of the sling facing the patient place it approximately halfwav down the back or so the sling is below the shoulder blades Lean the patient against the back of the chair 4 Fold the padded fabric waist band with the belt attached across the mid section of the patient and clip the belt to close it Make sure the belt is secure 5 Tighten the belt until snug by pulling gently on the end of the belt 6 Kneel in front of the patient so that your back is straight and so you are at eye level with the patient Grab the end of the sling with the white fabric and make sure there are no twists in the sling Make sure the white fabric is facing the patient s leg Place the patient s foot on your thigh and slide the white section of the sling under the leg h il k L E 7 The hygienic straps need not cross to allow better access to the toileting area With the hygienic sling the arms of the patient are always over top of the sling Sling attachment to Carry Bar 1 Ensure the sling is properly placed around the patient according to the instructions above 2 Choose the color of the loop for the position that is best suited for the patient For a larger patient choose blue for both the leg and shoulder straps A smaller patient may be b
31. tified ERGOLIFT WL USER MANUAL MAINTENANCE technician in addition to the daily and other periodic visual checks done by the user specified in this section Preventive maintenance specified in this manual can prevent accidents and reduce repair costs Note all services or repairs to the ERGOLIFT WL or its accessories in the log book at the back of this manual Have the document signed by a certified technician Daily Checklist THE FOLLOWING PROCEDURE MUST BE FOLLOWED BEFORE EACH USE e Inspect the lift for any damage If there are any cracks or other damage on the lift or any parts are missing DO NOT USE IT Contact your local representative to have the lift serviced e Inspect the carry bar for any signs of cracking or damage and that it rotates freely e Inspect the actuator on the lift to ensure it is securely attached to the lift and has no visible damage e Inspect the sling for tears frayed straps or loose stitches If the sling has any of the above damage DO NOT USE IT Contact your local representative to have the sling replaced or repaired Inspection and Cleaning Clean the lift with a soft dry cloth or a soft cloth lightly moistened with a mild detergent solution Do not use any type of solvent that may damage the finish DO NOT submerge the lift under water To touch up scratches or chipped paint and prevent rust apply white spray paint BHM touch up paint product P6111 Ha
32. to install the Ergolift WL Before installing vour wall bracket determine Where it will be positioned and what kind of structure vou have wood concrete Regardless of the type of structure you must install the wall bracket at approximatelv 36 in 91 44 cm from the ground For all tvpe of structures put the plate against the wall and mark bolts position with a lead pencil Remove the plate and drill holes Bracket installation Tvpe of walls a Wood structure Fix the plate against the wall and screw lag bolts with a 9 16 socket FIXE VERY FIRMLY TO THE UPPER PART OF THE WALL EQUAL LEG ANGLES PULL OUT CAPACITY DN MUST BE 1000 LBS MIN oo 2 4 u 1 jed u RAX 3 8 BOLT x 5 1 2 HEX HEAD b Concrete structure Insert 6 concrete anchors 3 8 with a hammer into the concrete structure Place the plate against the wall and screw bolts into the anchors CONCRETE ANCHOR HDI 3 8 ERGOLIF T WL USER MANUAL INSTALLATION OPERATION c Installation between beams lf your plate is positioned between two wooden beams vou must install 3 unistruts to fix the plate Be sure to align the unistrut with holes previously drilled Fix unistruts into beams with lag bolts 3 8 and flat washers Insert 2 strut nuts on each unistrut and align them with holes then do a quarter turn to lock the nut Be sure that all strut nuts are aligned Put the wall brack
33. ty is greatly compromised ERGOLIFT WL USER MANUAL 24 MAINTENANCE TROUBLESHOOTING Only a certified technician is authorized to open the ERGOLIFT WL Alterations made to the ERGOLIFT WL by someone other than a certified technician may cause serious injury PROBLEMS TO CHECK The lift does not work when you press je Make sure the lift is plugged into an electrical outlet the up or down buttons on theje Make sure the handset is plugged correctly into the unit handset e If there is still a problem change the handset The unit starts and stops repetitively e f the load is more than the safe working load the unit will not work due to an overload protection on the motor Patient lift feels loose e Check to ensure the locking clip is on e Check to ensure all split rings are completely inserted e Check if the mast is still affixed to the pivot of the wall plate Unusual noise from actuator Actuator e Refer to BOOM ACTUATOR REPLACEMENT in the is worn or damaged or sprindle is bent MAINTENANCE section of this manual Medical Technical Service department A If problems are not resolved by the suggested means please contact your dealer or BHM ERGOLIFT WL USER MANUAL 25 ACCESSORIES ACCESSORIES B10 3mm Pa 800mm 31 57 7 3557 885mm 134 87 ERGOSCALE PRODUCT ERGOSCALE T2 o 400mm 15 757 ja FIXATION PLATE PRODUCT A4560 TA KOR
34. y be possible to encounter a modification of product without revision of this manual Thank you for trusting your BHM Medical Partners ce GG How to contact us BHM Medical Inc 2001 Tanguay Street Magog Quebec Canada J1X 5Y5 Phone 819 868 0441 Service calls during business hours extension 109 8 00 12 00 and 1 00 5 00 p m E S T Service calls outside regular business hours Extension 6199 you must press the pound key Fax 819 868 2249 Web site www bhm medical com Email bhm bhm medical com ERGOLIFT WL USER MANUAL 2 TABLE OF CONTENTS INTRODUC TION i Ta ata 4 HOW TOUSE THIS MANU A E cee ai mad ra i St e A E AREA 4 EQUIPMENT IDEN TE CAN o g an tat 4 RECEIPT OF eS e 4 KE TO SV MBOES a ene a Nate incida 4 SAFETY INSTRUCTIONS AND WARNINGS uuu cc ccecec ec eceececececececececececececececeseenceeueueneueneueeeanananas 5 DESCRIPTION OF EQUIPMENT cccccscececececececeeeeeecesececeneneeeeeeeaueuneneneneneneneaeaeauauaneueueneunnaeanes 7 ERGOLIFETE WA EEEE ee cece rca a ccc eae a An aj 7 PAR RS DESCRIP THO IN i has ce aie cece ta A tt ad tan 7 DIMENSIONU ia a es eee e Sues healt ade 7 INSTALA TON 5 o o A iv 8 HOW TO INSTALL THE ERG OLIETE WI l ciar ei 8 ACTUATOR INSTALLATION acacia as 9 BOOMINSTA TA TON oa ore ne e edo dee nd ia g ata ae sa eco ia al 9 GARRYABAR INSTALLATION toa at ds ice e be oca que ideo eds 10 OPERATION outs ia 10 HOWTO USE THE ERGOLIET WE cn A s 10 ANTECRUS EE
Download Pdf Manuals
Related Search