User Manual - Barissima 2015 - 300dpi
Contents
1. 5 2 1 PIN Clearance uan BAKISSIMA The Customer menu is protected by a PIN Personal Identification Number For access to this PIN protected level 1122 must be entered Seite 26 User Manual BARISSIMA V 1 00 02 2015 English 5 2 2 PIN Clearance in SB mode In SB mode the bottom row of buttons is automatically hidden To make them visible again the model emblem on the display has to be pressed for 5 seconds If the SB mode is enabled the bottom row of buttons will disappear 15 seconds after the last input 5 2 3 Cleaning 25 RARISSIMA Menu gt Cleaning Scroll to the last display page Here the cleaning program can be started Note er The milk lines must be filled at the start of operation in order for you to have milk products available Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 27 Seite 28 5 2 4 Counter Menu gt Counter gt System counter The operating hours are listed here Milchschaum S Z hler wurde nie zur ckgesetzt Milchschaum M Z hler wurde nie zur ckgesetzt k Menu gt Counter gt Product counter The used amount per product is listed here Individual counter reset Press the respective product counter and confirm with Yas Reset all counters Press the Reset button and confirm with Yes 5 2 5 Date and Time Menu gt Settings gt Date and Time 5 2 6 Language The language is preset by the service techni2. Therefore monitoring and test procedures must be established and enforced With proper installation maintenance care and cleaning of the milk foamer it meets the requirements mentioned above If the care and cleaning of the milk foamer is not performed correctly the output of dairy beverages can be a danger point in terms of food hygiene Therefore note of the following points Daily sterilize the milk system Never top up milk Always remove milk residues Clean the milk container before filling it with fresh milk Observe the cleaning instructions Daily Cleaning for the milk system in this manual This ensures that the system contains a minimum of bacteria at the beginning of operation Always use a freshly opened refrigerated milk pack at the start of operation Original packaged milk is usually free of harmful germs Only use pasteurized or UHT milk Do not use raw milk The milk must be homogenized Due to dirty hands or tools germs may reach the milk when opening it Pay attention on absolute cleanliness when you open the milk pack Keep the milk always cool Always keep a refrigerated milk pack ready If not cooled during operation the milk must be consumed very quickly within 3 hours With lower milk consumption the milk must continually be cooled during operation For this purpose an auxiliary cooler is recommended User Manual BARISSIMA V 1 00 02 2015 English 7 6 Cleaning Plan 4 N Important Refer
3. Foreign bodies may damage the grinder This damage is excluded from the warranty 3 4 1 Fill the milk without milk cooler Insert the milk hose with the suction nipple in a milk carton 3 4 2 Fill the milk with milk cooler Remove the milk container and fill it with pre cooled milk Put the milk container back into the milk cooler Put the milk hose into the milk container Close the milk cooler Important Please refer to chapter 7 Cleaning Care HACCP hygiene self control 3 4 3 Switching on the machine Important Ensure that the milk suction line is connected Connect the milk suction line Switch on the main switch Machine heats up automatically The display shows the released buttons and you can select products 3 4 4 Settings The authorized service technicians configures the milk foamer to your needs Please refer to the chapter 5 Setting 3 5 Acceptance 3 9 1 Acceptance criteria The milk foamer must be in perfect condition The products are configured for the needs of the customer The staff has been trained Acceptance protocol is completed and signed by the instructed persons Schooling protocol is completed and signed by the instructed persons 3 5 2 Implementation An authorized service technician installs the milk foamer and checks all settings Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 21 4 Seite 22 Operation 4 1 Safety O
4. Manual BARISSIMA V 1 00 02 2015 English 2 2 1 Supply Interfaces Connections The site preparatory work for the electrical connection water connection and the sewer connection must be commissioned by the operator All preparatory work must be carried out by authorized professionals in accordance with the general national and local regulations The specifications for the electrical connection of the milk foamer apply for the states of the EU It may be necessary to note additional country specific regulations Outside the EU countries acceptance of the standards quoted must be checked by the marketer Electrical connection e The power supply for the milk foamer must always be accessible for repair and maintenance work e The milk foamer must always be connected pluggable e Defective or damaged power cables must be replaced by an authorized service technician to avoid hazards e The milk foamer must be fused separately e For the accessories additional outlets are needed e All built in milk foamer parts are preset and may only be changed by an authorized service technician e The milk foamer must be volt free before it is opened e The power supply and plug must be replaced only by an authorized service technician Important Interruptions in the neutral or PE conductor can destroy the controller Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 15 2 2 2 Environment Ambient temperature 10 C to 40
5. Seite 45 12 Seite 46 Change Index Version V1 00 Valid from Changes User Manual BARISSIMA V 1 00 02 2015 English
6. of persons and overseen by trained personnel The milk foamer must not be exposed to direct sunlight The milk foamer must not stand in the open When replacing the milk foamer the old hose sets may no longer be used The manufacturer is not liable for damages caused by improper installation Note er Please refer to the detailed description in chapter 3 Initial operation Protection of the electronics For maintenance or repair work a control plug under voltage must never be plugged in or out The manufacturer is not liable for damages caused by improper reparation All parts in the milk foamer are calibrated and may only be changed by an authorized service technician The milk foamer must be volt free before it is opened The power supply and plug must be replaced by an authorized service technician only Warning Risk of death by defects in the power cord Seite 12 Defects in the power cord can lead to life threatening electrical shocks Protect the power cord from damage Do not rip bend clamp or squeeze the power cord Protect the power cord from sharp edges moisture heat or oil Do not connect the machine if the power cord is damaged Do not attempt to repair a damaged power cable by yourself A damaged power cord must only be replaced by an authorized service technician User Manual BARISSIMA V 1 00 02 2015 English 2 1 4 EC Declaration of Conformity Der Hersteller VERON Austria GmbH Untere Sparc
7. steam and hot liquids The outlet head as well as the outlets are very hot during operation and can cause burns at contact Hot beverages and escaping steam can scald you e Do not touch the outlet head the outlets or directly adjacent Surfaces of your milk foamer e Avoid contact with the hot steam and be careful with hot beverage e Allow the machine to cool down before cleaning or removing or adding any accessories Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 7 Seite 8 Caution Possible health hazard If the milk unit is not cleaned properly or other food or materials that the ones intended for the machine are used you can affect your health Clean the machine regularly according to the instructions in the chapter 7 Cleaning Care Use only milk in the milk system of your milk foamer Caution Possible health hazard by detergents Detergents are irritating and can get very hot during the cleaning process Detergents can affect your health Detergents can damage plastic parts and other materials such as textiles Avoid contact with cleaning agents Hold the detergents away from children Take in no detergents or mix them with other detergents or other chemicals Wash your hands and face after cleaning your milk foamer even if you interrupt the cleaning Do not eat or drink during the cleaning process Make sure you have proper ventilation during the cleaning process Use only
8. the outlets or directly adjacent Surfaces of your milk foamer e Avoid contact with the hot steam and be careful with hot beverage e Allow the machine to cool down before cleaning or removing or adding any accessories Caution Possible health hazard If the milk unit is not cleaned properly or other food or materials that the ones intended for the machine are used you can affect your health e Clean the machine regularly according to the instructions in the chapter 7 Cleaning Care e Fillthe milk container only with cooled mil e Use only milk in the milk system of your milk foamer User Manual BARISSIMA V 1 00 02 2015 English 4 1 1 Demand on the executive staff e All persons who work on the machine must read the user manual or be taught by trained staff e This machine is not intended for use by persons including Children with reduced intellectual sensory and physical abilities or lack of experience and knowledge unless they are supervised by a person responsible for their safety e Prevent access for children or contact with domestic animals plants or insects This also applies to the packaging material small parts and detergents 4 2 Setup Settings Connect the milk suction line Plug in the power cord 4 3 Filling of the Container Important Fill the milk container only with cooled milk Never fill freeze dried or powdered milk in the milk container Make sure that no foreign bodies get into th
9. 015 Deutsch Seite 41 9 3 Order Form Copy the order form Fill it out and fax it to Fax 48 0 5372 22496 10 E Mail info veron austria com Your billing address Your shipping address Dale are SHAE ene arene ee re cane ere ee Seite 42 User Manual BARISSIMA V 1 00 02 2015 English 10 Decommissioning Storage 10 1 Safety directions for Decommissioning Storage e The disassembly of the machine must be carried out by an authorized service technician e Never disassemble the machine by yourself e The machine may only be opened maintained and repaired by an authorized service technician Otherwise there is danger to life and equipment e External surfaces are cleaned with a damp cloth Do not use a water hose or aggressive cleaning agents Hold the detergents away from children Detergents must be kept under lock and may only be used by authorized personnel Read instructions on the packaging carefully Use only original manufacturer approved detergents To avoid frost damage or danger of freezing the unit must be drained by an authorized service technician Store the machine frost proof in the original packaging e For accidents or damage caused due to non observance of these Safety regulations neither the supplier nor the manufacturer is liable Caution Burning hazard Keep in mind that after switching off the machine several outlet parts may still be hot 10 2 Storage Conditions 10 2 1 Storage Crit
10. BARISSIMA User Manual V 1 00 02 2015 English Table of Contents 1 General 4 1 1 Identification 4 1 2 Modification of Products 4 1 3 Important Information about the User Manual 4 1 4 Safety related information 5 2 Product description 11 2 1 Important notes on the product 11 2 2 Product data technical data 14 2 3 Features 16 3 Initial Operation 17 3 1 Safety notes for first time Operation 17 3 2 Positioning 17 3 3 Assembly Installation 18 3 4 First Start up 21 3 5 Acceptance 21 4 Operation 22 4 1 Safety Operation 22 4 2 Setup Settings 23 4 3 Filling of the Container 23 4 4 Switching on the milk foamer 23 4 5 Operating Menu Display 24 4 6 Filling the milk lines 25 4 7 Obtaining milk of milk foam 25 4 8 Turning of the milk foamer 25 5 Adjustment 26 5 1 Manual Adjustment 26 5 2 Customer menu settings 26 6 Troubles Messages and Notes 33 6 1 Troubleshooting 33 6 2 System messages 33 6 3 Error Messages 33 7 Cleaning Care 34 7 1 Safety Cleaning Care 34 7 2 Detergents 34 7 3 Overview Cleaning Intervals 35 7 4 Care and Cleaning Work 35 7 5 HACCP Cleaning Concept 38 7 6 Clening Plan 39 8 Maintenence Service 40 8 1 Introduction 40 8 2 Safety directions for Maintenance Service 40 8 3 Maintenance Intervals 41 9 Detergents and Spare parts 41 9 1 Detergent 41 9 2 Spare parts catalog 41 9 3 Order Form 42 10 Decommissioning Storage 43 10 1 Safety directions for Decommissioning Storage 43 10 2 Storage Condit
11. C Humidity max 80 Use only indoors Operate only in frost proof environment Protect the milk foamer from direct sunlight 2 2 3 Emissions The noise level is below 70dB 2 3 Features VERON BARISSIMA Milk foam heater OPTIONAL 2 line milk foam heater Accounting system Milk empty message SB mode etc 2 3 1 Supplied standard accessories e Milk cleaner e Milk connection set e Manual EN 2 3 2 Special accessories Optional accessories may at any time be subsequently integrated into your milk foamer by an authorized service technician e Milk Cooler e Milk empty message e Billing System e SB mode Note C Keep the packing material including the rigid foam for transportation and eventual returns to avoid shipping damage Seite 16 User Manual BARISSIMA V 1 00 02 2015 English 3 Initial Operation 3 1 Safety notes for first time Operation Always follow the exact instructions Pay particular attention to the safety instructions and warnings The user manual must always be available near the milk foamer All persons who work on the milk foamer must read the user manual or be taught by trained staff All built in milk foamer parts are preset and may only be changed by an authorized service technician For trouble free operation of the milk foamer a room temperature of 10 C to 40 C and a maximum relative humidity of 80 is required For accidents or damage caused due to non observance of these
12. RIVA ee gt PB NO OO Menu gt Machine Configuration gt System Information 1 Serial number machine 2 Serial number boards 3 Software version 4 Machine options Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 31 5 2 11 Reset to customer settings Wiederherstellen Applikationseinstellungen Vv Abbrechen Menu gt Machine Configuration gt Save Load Settings gt Customer Settings The service technician configures the milk foamer to your needs The customer setting is saved here and can be restored at any time The green marked fields will be loaded onto the machine Fields marked in red will not be loaded onto the machine Each database can be selected and deselected individually Only the green entries will be loaded 5 2 12 Activate Standby Mode manually 25 RARISSIMA Menu gt Standby Mode Seite 32 User Manual BARISSIMA V 1 00 02 2015 English 6 Troubles Messages and Notes 6 1 Troubleshooting If the milk foamer is turned on but you cannot get any products check the following points e Check if a warning or error message is shown on the display Check if the milk container is filled Check if the outlet head is properly connected Check if the filter membrane is dirty If you still have not found a solution for the problem contact your service partner for assistance 6 2 System Messages 6 2 1 General System messages appear on the display T
13. Safety regulations neither the supplier nor the manufacturer is liable Important The installation and initial operation of the machine must be performed by an authorized service technician 3 2 Positioning 3 2 1 Positioning Operating place Maintain a distance of 10cm from the wall and other objects Keep in mind that condensation water or steam can always escape from the machine The milk foamer must only be operated indoors Do not use the milk foamer outdoors Set up the milk foamer so it is protected against splashing water The milk foamer must only be operated in a frost proof environment Protect the milk foamer from direct sunlight Important Possible damage to sensitive mounting surfaces Due to leakage of hot steam or water sensitive surfaces can be damaged The installation and commissioning of the machine may only be carried out by an authorized service technician Place the milk foamer on an absolutely water resistant and heat resistant surface Make sure that the installation area is dry The installation surface must be level and able to bear the weight of the milk foamer 3 2 2 Unpacking The packing material inside the box contains accessories Do not throw them away Check whether the milk foamer is intact Keep the packing material for transportation and eventual returns to avoid shipping damage Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 17 3 3 Assembly Installation 3 3 1 In
14. VERON Austria GmbH agrees to take back the old devices These are recycled and returned to the materials cycle 11 1 Safety information Disposal e The disassembly of the machine must be carried out by an authorized service technician e Never disassemble the machine by yourself e Before decommissioning of the machine a main cleaning must be done and the grounds container must be emptied To avoid frost damage or danger of freezing the boiler must be emptied by an authorized service technician e For accidents or damage caused due to non observance of these Safety regulations neither the supplier nor the manufacturer is liable 11 2 Packaging Ship or transport the machine always in the original packaging including the rigid foam 11 3 Disassembly Important The disassembly of the machine must be carried out by an authorized service technician Perform the main cleaning Please refer to chapter 7 Cleaning Care Switch off the milk foamer and disconnect the power cord Empty and clean the drip tray and milk container before transporting To avoid frost damage or danger of freezing the milk system must be emptied by an authorized service technician 11 4 Return to Manufacturer Name and address of the manufacturer VERON Austria GmbH Untere Sparchen 25 6330 Kufstein Austria Tel 43 0 5372 22496 Fax 443 0 5372 22496 10 E Mail info veron austria com Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch
15. appointment for maintenance or repair with our VERON customer service VERON is constantly striving to provide good service VERON Customer Service VERON Austria GmbH E Mail technik veron austria com Name and Address of the Warrantor VERON Austria GmbH Untere Sparchen 25 6330 Kufstein Austria Tel 43 0 5372 22496 Fax 43 0 5372 22496 10 E Mail info veron austria com User Manual BARISSIMA V 1 00 02 2015 English 2 Product description 2 1 Important notes on the product 2 1 1 Overall view Unit design BARISSiMe 3s Z 1 Touch screen 2 Product outlet 3 Drip tray Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 11 2 1 2 Intended use This milk foamer is manufactured for commercial use This milk foamer is not suitable for home use This milk foamer is not intended for use by persons including Children with reduced intellectual sensory and physical abilities or lack of experience and knowledge unless they are supervised by a person responsible for their safety 2 1 3 Precautions Installation note For trouble free operation of the machine a room temperature of 10 C to 40 C and a maximum relative humidity of 80 is required The installation and initial operation of the machine must be performed by an authorized service technician The installation surface must be level and able to bear the weight of the milk foamer The milk foamer must be placed outside the direct movement
16. azard and risk of death by defects in the power cord or wrong line voltage The wrong line voltage or defects in the power cord can lead to life threatening electrical shocks e Protect the power cord from damage e Do not rip bend clamp or squeeze the power cord e Never lift or pull the machine by the power cord e Never pull out the plug by pulling on the power cord e Never touch cables and plugs with wet hands e Protect the power cord from sharp edges moisture heat and oil e Do not connect the machine if the power cord is damaged e Do not attempt to repair a damaged power cable by yourself e A damaged power cord must only be replaced by an authorized service technician 3 3 6 Protection Devices e The protection devices must not be manipulated e The integrated component tested safety devices prevent unwanted pressure and temperature increase in the hot water boiler If the safety valve opens the machine must be switched off immediately at the main switch and the main shutoff valve to the drinking water supply must be closed If there are troubles switch off the machine and call an authorized service technician Do not turn the machine on until the error is corrected User Manual BARISSIMA V 1 00 02 2015 English 3 4 First Start up Important Fill the milk container only with cooled milk Never fill freeze dried or powdered milk in the milk container Make sure that no foreign bodies get into the milk pump
17. cian User Manual BARISSIMA V 1 00 02 2015 English 5 2 Product amount Filling quantity le a a N Be ds ple cn a wy T Milchschaum S Milchschaum M 1 ez Menu gt Settings gt Product Settings Select the product you want to adjust Specify the product amount in ml Enter the desired amount of product with the arrow buttons Place a cup under the outlet for the product Test the product with the Test button Confirm the setting with Apply If you want to exit without confirmation press the button Back 5 2 8 Boiler Temperature Menu gt Settings gt Service Settings gt General Parameters Recommended Boiler temperature 62 C to 70 C Enter the desired temperature using the arrow buttons Confirm the setting with Apply f you want to exit without confirmation press the button Back Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 29 5 2 9 Change display mode OPTIONAL To activate the self service mode go to the third page of the operating menu Press the button Self Service Mode and then enter your PIN 1122 Now the machine is in the self service mode To activate the waiter mode go to the last page of the operating menu Press the button Waiter Mode and then enter your PIN 1122 Now the machine is in waiter mode Seite 30 User Manual BARISSIMA V 1 00 02 2015 English 5 2 10 System Information AN
18. e Wipe the cabinet with a soft damp cloth Clean the control panel with a soft damp cloth 7 4 5 Cleaning the drip tray and grid Switch off the machine Loosen the drip tray with the knurled screw Remove and empty the drip tray Rinse the drip tray and grid thoroughly with warm water Clean with a damp cloth Clean collection container with a damp cloth Place back the drip tray and tighten the knurled screw Seite 36 User Manual BARISSIMA V 1 00 02 2015 English 7 4 6 Weekly cleaning of the outlet head 0 Switch off the machine Pull out the outlet head Disassemble the outlet head Rinse under warm clear water Clean all parts of the outlet head with a soft damp cloth Reassemble the outlet head Insert the outlet head back into the system 7 4 7 Cleaning the milk container Switch off the machine Remove and empty milk container Wash out milk container well Rinse with clean water and dry with a clean cloth Insert and fill up the milk container Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 37 Seite 38 7 5 HACCP Cleaning Concept You are legally obligated to make sure that your guests are not exposed to health hazards by consuming your food A HACCP concept for risk identification and assessment is demanded You should carry out a risk analysis on your premises The aim is to recognize danger points for food hygiene and eliminate them
19. e milk pump e Foreign bodies may damage the grinder This damage is excluded from the warranty Fill the milk without milk cooler Insert the milk hose with the suction nipple in a milk carton Fill the milk with milk cooler Open the milk cooler Remove the milk container and fill it with pre cooled milk Put the milk container back into the milk cooler Put the milk hose into the milk container Close the milk cooler Important Please refer to chapter 7 Cleaning Care HACCP hygiene self control 4 4 Switching on the milk foamer Connect the milk suction line Switch on the main switch Machine heats up automatically The display shows the released buttons and you can select products Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 23 Caution Burning hazard Keep in mind that after switching off the machine several outlet parts still may be hot Caution Possible health hazard If the milk unit is not cleaned properly or other food or materials that the ones intended for the machine are used you can affect your health e Clean the machine regularly according to the instructions in the chapter 7 Cleaning Care 4 5 Operating Menu Display 24 02 15 vr A 2 SS fivi ce as BARISSIMA asx BARISSIMA Page 1 beverage buttons Last page Cleaning Filling programs Standby mode Arrow button Switch between pages Warning on error messages Additional q
20. echnician e Use the machine only if it is in perfect condition e The milk foamer may only be opened maintained and repaired by authorized service technicians Otherwise there is danger to life and equipment e All parts in the milk foamer are calibrated and may only be changed by an authorized service technician e The power supply and plug must be replaced by an authorized service technician only e Nochanges alterations or attempts at repair especially using tools may be carried out on or in the appliance e Use only replacement parts that are listed in the parts catalog e The integrated component tested safety devices prevent unwanted pressure and temperature increase in the hot water boiler If the safety valve opens the machine must be switched off immediately at the main switch and the main shutoff valve to the drinking water supply must be closed If there are troubles switch off the machine and call an authorized service technician Do not turn the machine on until the error is fixed e The hot water and steam boiler went through a water pressure test e The operator is responsible for the regular overview of safety by an expert Therefore perform an inspection and maintenance once a year by an authorized service technician e The operator must ensure that the electrical systems and equipment are in a proper condition e For trouble free operation of the machine a room temperature of 10 C to 40 C and a maximum relative h
21. eria Store the machine in the original packaging Never store the machine outdoors The storage area must be free of moisture and humidity The storage location must be frost proof 10 3 Decommissioning 10 3 1 Cleaning Perform the main cleaning Please refer to chapter 7 Cleaning Care Switch off the milk foamer and disconnect the power cord Empty and clean the drip tray the grounds container bean container and chocolate container before transporting To avoid frost damage or danger of freezing the boiler must be emptied by an authorized service technician 10 3 2 Packing Use only the original packaging For bearing damage due to non observance neither the supplier nor the manufacturer is liable 10 3 3 Marking Protect from moisture frost and direct sunlight Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 43 10 4 Maintenance during storage There is no maintenance necessary during the storage 10 5 Commissioning after storage Important The installation and connection after the storage of the machine may only be carried out by an authorized service technician After a long pause in operation we recommend that before recommissioning the machine perform the full cleaning cycle at least twice Note Please refer to chapter 3 Initial operation Please refer to chapter 7 Cleaning Care Seite 44 User Manual BARISSIMA V 1 00 02 2015 English 11 Disposal
22. foamer cannot be interrupted If during the cleaning the electric power supply is cut off a new cleaning cycle will be enforced at the next startup of the machine e A cleaning cycle will also be enforced after 24 hours if the machine is not cleaned daily During the cleaning process no products can be made for security reasons Hold the detergents away from children Detergents must be kept under lock and may only be used by authorized personnel Read instructions on the packaging carefully Use only original manufacturer approved detergents The manufacturer is not responsible for misuse For accidents or damage caused due to non observance of these Safety regulations neither the supplier nor the manufacturer is liable Caution Possible health hazard If the milk unit is not cleaned properly or other food or materials that the ones intended for the machine are used you can affect your health e Clean the machine regularly e Pay attention to the HACCP hygiene control 7 2 Detergents e Read instructions on the packaging carefully e Use only original manufacturer approved detergents e The manufacturer is not responsible for misuse Caution Possible health hazard by detergents Detergents are irritating and can get very hot during the cleaning process Detergents can affect your health Detergents can damage plastic parts and other materials such as textiles e Avoid contact with cleaning agents e Hold the deter
23. gents away from children e Take in no detergents or mix them with other detergents or other chemicals e Wash your hands and face after cleaning your milk foamer even if you interrupt the cleaning Do not eat or drink during the cleaning process e Make sure you have proper ventilation during the cleaning process e Use only recommended VERON detergents Seite 34 User Manual BARISSIMA V 1 00 02 2015 English 7 3 Overview Cleaning Intervals 7 3 1 Daily clenaing Milk system with milk cleaner Milk cooler optional Outlet head Machine housing and control panel Drip tray and grid 7 3 2 Weekly cleaning Complete disassembly and thorough cleaning of the outlet head 7 4 Care and Cleaning Work Daily cleaning and care of the milk foamer is very important lt guarantees you a longer life of the milk foamer and consistent taste of all products Important There is a risk that during the cleaning scratches form e Do not use scouring powders or sharp objects to clean e Do not use harsh cleaners e Use only a soft cloth for cleaning 7 4 1 Whole cleaning program 25 RARISSIMA Gesamt Reinigung Bitte 500ml frisches Wasser ohne Milchreiniger in eine te un m Beh lter bereitstellen und ilchschlauch einlegen Bitte dr cken Sie die Start Taste um The milk cleaning program is started using the corresponding button in the menu A wizard will guide you step by step through the various sub programs T
24. he milk cleaning program consists of the following Cleaning the milk system with milk cleaner Take the milk hose out of the milk container Mix detergent and fresh water in a container instructions on the packaging must be Strictly observed Put the milk hose into the container with the detergent and the water Start program Wash out and fill the cleaning container with fresh water Continue program The Program is completed Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 35 Note En At low milk flow rate and or using unrefrigerated milk after 4 hours of operating time cleaning is essential The milk hose and the milk container must be cleaned daily 7 4 2 Cleaning the milk cooler optional Switch off the machine after cleaning the milk system Remove the milk container from the milk cooler Mix detergent and fresh water in a container instructions on the packaging must be strictly observed Clean the milk container with the cleaning solution Rinse with clean water and dry with a clean cloth Wipe the refrigerator interior with the cleaning solution and dry it with a clean cloth Put the milk container back into the milk cooler Wipe the housing with a soft damp cloth 7 4 3 Cleaning the outlet head Switch off the machine Clean the outlet head with clear warm water and a soft cloth 7 4 4 Cleaning the machine housing and control panel Switch off the machin
25. hen 25 6330 Kufstein Austria Tel 43 0 5372 22496 erklart hiermit dass folgendes Produkt Produktbezeichnung BARISSIMA Baujahr 2015 allen einschl gigen Bestimmungen der Richtlinie Maschinen 2006 42 EG entspricht Folgende harmonisierte Normen wurden angewandt EN ISO 12100 1 Sicherheit von Maschinen Grundbegriffe allgemeine Gestaltungsleits tze Teil 1 Grunds tzliche Terminologie Methodik EN ISO 12100 2 Sicherheit von Maschinen Grundbegriffe allgemeine Gestaltungsleits tze Teil 2 Technische Leits tze und Spezifikationen Die Maschine entspricht weiterhin allen Bestimmungen der Richtlinien Elektrische Betriebsmittel 2006 95 EG Elektromagnetische Vertr glichkeit 2004 108 EG und Beschr nkung gef hrlicher Stoffe in Elektro und Elektronikger ten 2011 65 EU Folgende harmonisierte Normen wurden angewandt EN 60335 1 Sicherheit elektrischer Ger te f r den Hausgebrauch und hnliche Zwecke Teil 1 Allgemeine Anforderungen EN 60335 2 75 Sicherheit elektrischer Ger te f r den Hausgebrauch und hnliche Zwecke Teil 2 75 Besondere Anforderungen f r Ausgabeger te und Warenautomaten f r den gewerblichen Gebrauch EN 55014 1 Elektromagnetische Vertr glichkeit Anforderungen an Haushaltger te Elektrowerkzeuge und hnliche Elektroger te Teil 1 St raussendung EN 55014 2 Elektromagnetische Vertr glichkeit Anforderungen an Haushaltger te Elektrowerkzeuge und hnliche Elektroger te Te
26. hey inform about the current state of the milk foamer Read the messages and perform the necessary steps 6 2 2 Milk level too low only with milk cooler with sensor Milk empty in the reservoir Fill the container with pre cooled milk See Chapter 4 Operation 6 2 3 Outlet head removed Outlet head is removed or not inserted correctly Insert the outlet head 6 2 4 Cleaning process not finished Cleaning was started and not finished refill fresh water Restart the cleaning program 6 3 Error Messages 6 3 1 Boiler Temperature to high Heating sensor defective or the cable is broken Call a service technician Important The integrated component tested safety devices prevent unwanted pressure and temperature increase in the hot water boiler If the safety valve opens the machine must be switched off immediately at the main switch and the main shutoff valve to the drinking water supply must be closed If there are troubles switch off the machine and call an authorized service technician Do not turn the machine on until the error is fixed Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 33 7 Cleaning Care 7 1 Safety Cleaning Care e The milk foamer must be cleaned daily at the end of shift e External surfaces are cleaned with a damp cloth Do not use a water hose or aggressive cleaning agents e Milk container is emptied and washed daily ate the end of shift e The cleaning process of the milk
27. il 2 St rfestigkeit Produktfamiliennorm EN 61000 3 2 Elektromagnetische Vertr glichkeit EMV Teil 3 2 Grenzwerte Grenzwerte Grenzwerte f r Oderschwingungsstr me Ger te Eingangsstrom lt 16 A je Leiter EN 61000 3 3 Elektromagnetische Vertr glichkeit EMV Teil 3 3 Grenzwerte Begrenzung von Spannungs nderungen Spannungsschwankungen und Klicker in ffentlichen Niederspannungs Versorgungsnetzen f r Ger te mit einem Bemessungsstrom lt 16 A je Leiter die keiner Sonderanschlussbedingung unterliegen Weitere angewandte Normen DIN 10531 Lebensmittelhygiene Herstellung und Abgabe von Hei getr nken aus Hei getr nkebereitern Hygieneanforderungen Migrationspr fung Name des Dokumentationsbevollm chtigten Leonhard Embacher Adresse des Dokumentationsbevollm chtigten siehe Adresse des Herstellers Kufstein am 04 02 2015 A Leonhard Embacher Gesch ftsf hrer Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 13 2 1 5 Labeling of the product On your milk foamer a nameplate is attached Transfer the data from your nameplate in the field below so you have the data always ready at hand VERON Austria GmbH Untere Sparchen 25 6330 Kufstein Austria Tel 43 0 5372 22496 Serial Nr 2 2 Product data technical data aris Boiler input 2 6 kW 220 240 V AC Electrical connection 13A 50 60 Hz 400 V AC Electrical connection 3x16 A 50 60 Hz Seite 14 User
28. ions 43 10 3 Decommissioning 43 Seite 2 User Manual BARISSIMA V 1 00 02 2015 English 10 4 10 5 11 11 1 11 2 11 3 11 4 12 Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Maintenance during storage Commissioning after storage Disposal Safety information Disposal Packaging Disassembly Return to Manufacturer Change Index Seite 3 1 General 1 1 Identification User Manual BARISSIMA Language EN Edition 2015 Revision 02 2015 Product This manual refers to the milk foamer BARISSIMA The identification of the milk foamer can be found on the machines name plate You can find the exact description of the machine on the requirements benefits and features in chapter 2 Product Description 1 2 Modification of Products e All built in milk foamer parts are preset and may only be changed by an authorized service technician e There must be no modifications to the product carried out by the customer e Incase of non compliance the warranty by the customer service or the Manufacturer is not covered 1 3 Important Information about the User Manual e The User Manual must always be available near the milk foamer e All persons who work on the machine must read the User Manual or be taught by trained staff e The User Manual contain important information for safe operation e The User Manual makes it easier for you to learn and use all applications of this machine e Compliance with the Use
29. k foamer is state of the art and constructed under recognized safety regulations still hazards may arise Operate the machine only in perfect condition and in compliance with the User Manual Warning Risk of death by electric shock Water or other liquids reaching the electronics of your milk foamer can lead to life threatening electrical shocks e Do not clean your milk foamer and the installation area with running water steam cleaners or steam jet cleaners e Protect the milk foamer from dampness or the influence of weather frost sunlight and do not use the milk foamer outdoors e Do not open the casing of your milk foamer e Do not reach into the inside of your milk foamer and do not use any tools on the machine Warning Risk of death by defects in the power cord Defects in the power cord can lead to life threatening electrical shocks e Protect the power cord from damage e Do not rip bend clamp or squeeze the power cord e Never lift or pull the machine by the power cord e Never pull out the plug by pulling on the power cord e Never touch cables and plugs with wet hands e Protect the power cord from sharp edges moisture heat and oil e Do not connect the machine if the power cord is damaged e Do not attempt to repair a damaged power cable by yourself e A damaged power cord must only be replaced by an authorized service technician Caution Possible burn or scalding hazard from hot components
30. nd equipment All built in coffee maker parts are preset and may only be changed by an authorized service technician There must be no tampering with the product Only replacement parts may be used that are listed in the parts catalog The integrated component tested safety devices prevent unwanted pressure and temperature increase in the hot water boiler If the safety valve opens the machine must be switched off immediately at the main switch and the main shutoff valve to the drinking water supply must be closed If there are troubles switch off the machine and call an authorized service technician Do not turn the machine on until the error is fixed The operator is responsible for the regular review of safety by an expert Therefore perform at least an inspection and maintenance once a year by an authorized service technician For accidents or damage caused due to non observance of the Safety regulations or service intervals neither the supplier nor the manufacturer is liable User Manual BARISSIMA V 1 00 02 2015 English 8 3 Maintenance Intervals 8 3 1 Service level 1 Prompted by the display message 8 3 2 Service level 2 Prompted by the display message 8 3 3 Service level 3 Prompted by the display message 9 Detergents and Spare parts 9 1 Detergent Milk Cleaner 98200 2e looo S 9 2 Spare parts catalog All the spare parts are listed in the supplied service book Betriebsanleitung BARISSIMA V 1 00 02 2
31. peration e Observe the applicable country specific hygiene rules for coffee lactic and instant products Use only refrigerated milk that is not warmer than 5 C Use only milk of the highest quality Store milk in a cool place Do not leave the milk in the open Close milk container immediately after filling Do not fill the milk container before longer breaks Use the assistance of an authorized service technician to get an optimal result of the milk products e After longer breaks it is crucial to clean the milk foamer in order to maintain the milk foam quality e Atthe start of operation the milk foamer must be filled up Warning Risk of death by electric shock Water or other liquids reaching the electronics of your milk foamer can lead to life threatening electrical shocks e Do not clean your milk foamer and the installation area with running water steam cleaners or steam jet cleaners e Protect the milk foamer from dampness or the influence of weather frost sunlight and do not use the milk foamer outdoors e Do not open the casing of your milk foamer e Do not reach into the inside of your milk foamer and do not use any tools on the machine Caution Possible burn or scalding hazard from hot components steam and hot liquids The outlet head as well as the outlets are very hot during operation and can cause burns at contact Hot beverages and escaping steam can scald you e Do not touch the outlet head
32. r Manual will help you to avoid dangers and unnecessary repairs and downtime e The milk foamer will thank you for your care with increased reliability and durability Seite 4 User Manual BARISSIMA V 1 00 02 2015 English 1 4 Safety related information 1 4 1 Symbols used in these User Manual Warning Safety related information Texts with this symbol or signal word indicate a hazard with a medium risk which if not avoided can result in death or serious injuries Electric Shock Caution Protection against personal injury Texts with this symbol or signal word indicate a hazard with a low level of risk which if not avoided can result in minor or moderate injuries Hot Steam Hot Surface Toxic or corrosive Substances Crushing hazard PPE PE Important Notes on property damage For the milk foamer For the installation location Always follow the user manual N T oy Note Texts with this symbol or signal word contain additional important information on dealing with the milk foamer Yl Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 5 1 4 2 Safety Note 7 Read the instruction manual carefully Keep the User Manual always at hand e This manual must always be kept near the milk foamer e All persons who work on the machine must read the user manual or be taught by trained staff e The installation and initial operation of the machine must be performed by an authorized service t
33. recommended VERON detergents Important Possible damage to sensitive mounting surfaces Due to leakage of hot steam or water sensitive surfaces can be damaged The installation and commissioning of the machine may only be carried out by an authorized service technician Place the milk foamer on an absolutely water resistant and heat resistant surface Make sure that the installation area is dry The installation surface must be level and able to bear the weight of the milk foamer Important Possible damage to property caused by damage to the water supply line Damage to the water supply may result in water damage to the entire working area Always make sure that the shut off valve at the water supply line is closed and the main power is switched off or the power cord is unplugged at the end of work The milk foamer must not be left unattended when operational User Manual BARISSIMA V 1 00 02 2015 English 1 4 4 Obligation of the operator The milk foamer VERON BARISSIMA is only suitable for heating and frothing milk The milk foamer VERON BARISSIMA is designated for gastronomic use The intended use contains e That you carefully read understand and follow the User Manual e That you pay particular attention to the safety instructions e That you use the VERON BARISSIMA within the operating conditions that are described in this manual e That you are not using the milk foamer under any circumstances to heat up or pu
34. s listed below e On any parts subject to natural wear and tear e g seals valves motors etc e For defects caused by weathering deposition of scale in the boiler chemical physical electrochemical or electrical influences provided these are not the faults of VERON e For faults resulting from not following the instructions on maintenance and cleaning according to the instruction manual e For defects from the failure to use original spare parts from VERON or faulty installation by the purchaser or third parties e For defects caused by faulty or negligent treatment e For defects occurring due to improper or incorrect use For results by improper use and without consent of VERON carried out modifications or repairs undertaken by the purchaser or third parties 1 4 8 Disclaimer VERON Austria GmbH reserves the right to change technical data colors Materials and similar things or cancel the production of a particular model without prior notice and without giving any reason The spare parts shown and described reflect in terms of Appearance scope of delivery and dimensions the state of the art at the time of printing Interim innovations taking place due to new technical regulations statutory provisions and amendments in the sense of technical progress are reserved by VERON Austria GmbH We accept no liability for printing errors 1 4 9 Service and Address You have questions on how to operate your milk foamer or you need an
35. stallation schematic BARISSIMA Front view Top view Seite 18 User Manual BARISSIMA V 1 00 02 2015 English 3 3 2 Drip tray Insert the drip tray with inlaid drip grid 3 3 3 Connect milk without milk cooler Insert the milk hose with the suction nipple into the milk container 3 3 4 Connect milk with milk cooler The milk cooler is available as special accessory The milk cooler has an empty signal sensor Connect the sensor cable of the milk cooler with the sensor cable of the milk foamer Remove the suction nipple from the milk hose The milk hose is inserted through an opening in the side panel of the milk cooler Connect the suction nipple to the milk hose Fill the container in the cooler with milk Note The milk hose and the milk system must be cleaned daily See chapter 7 Cleaning Care Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 19 Seite 20 3 3 9 Energy supply The electrical connection must comply with the applicable regulations and the regulations of the respective country The Voltage on the type plate must correspond to the line voltage at the installation site BARISSIMA 1 line Plug the power cord into a grounded electrical outlet with a voltage of 230 V AC anda guaranteed minimum of 13 A BARISSIMA 2 line Plug the power cord into a grounded electrical outlet with a voltage of 400 V AC anda guaranteed minimum of 3x16 A Warning Fire h
36. t out any other liquids than milk Improper use is when you use the VERON BARISSIMA differently than described in this manual Note Ce The manufacturer or the customer service is not liable for damages if there are signs for improper use 1 4 5 Obligations of the operator e The operator is responsible for the regular review of safety by an expert Therefore perform at least an inspection and maintenance once a year by an authorized service technician e The milk foamer must be installed so that the care and maintenance is easily possible e The operator must ensure that the electrical systems and equipment are in a proper condition e All persons who work on the machine must read the user manual or be taught by trained staff e Hygiene regulations must be followed e Use only original VERON cleaners and spare parts e The manufacturer s specifications regarding maintenance cycles and frequency of maintenance must be followed 1 4 6 Warranty e The buyer is entitled to the statutory warranty rights First the vendor should always be given the opportunity to amend within a reasonable time e Any further claims in particular claims for damages for consequential damages are as far as legally permissible excluded e Defects must be reported in writing to the seller immediately Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 9 Seite 10 1 4 7 No Warranty The manufacturer accepts no liability in the case
37. to chapter 7 2 Detergents u u e Copy HACCP schedule and keep it close to the machine e Confirm every cleaning with time and signature Month 2 2222222 Year 20 Cleaning carried out Time and Signature Only original and manufacturer approved cleaning detergent may be used Date Daily Cleaning te Machine Milk System Milk Cooler Outlet Head 10 11 12 13 14 15 16 17 18 19 4 23 24 25 26 29 30 31 Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Signature Seite 39 8 Seite 40 Maintenance Service 8 1 Introduction This milk foamer is a professional industrial milk foamer which needs regular maintenance by an authorized service technician We recommend you make a service contract with an authorized service company to ensure proper maintenance Regular maintenance extends the life of the milk foamer Our service professionals will check the milk foamer every time to ensure quality and function The maintenance schedule is based on the utilization of the machine and is reported on the display Contact our customer service 8 2 Safety directions for Maintenance Service When requested perform the maintenance as soon as possible to ensure the reliability and avoid consequential damage to the milk foamer The machine may only be opened maintained and repaired by an authorized service technician Otherwise there is danger to life a
38. uantity of milk adjustment for each bottom Menu button Note er The beverage buttons of the operating menu on page 1 will be configured for you by a service technician OU POD Seite 24 User Manual BARISSIMA V 1 00 02 2015 English 4 6 Filling the milk lines 425 RARISSIMA The milk lines must be filled at the start of operation in order for you to have milk products available Scroll to the last display page Press the Milk filling button on the display 4 7 Obtaining milk or milk foam gt BAKISSIMA Place a cup or glass under the outlet head Press the Milk or Milk foam button Button flashes read process can be stopped until the filling level is reached 4 8 Turning of the milk foamer Before turning off the milk foamer the daily cleaning must be carried out Refer to chapter 7 Cleaning Care Switch off the main switch 4 8 1 Cleaning by operating personnel The cleaning during operation is the responsibility of the operating personnel Note chapter 7 Cleaning Care Betriebsanleitung BARISSIMA V 1 00 02 2015 Deutsch Seite 25 5 Adjustment 5 1 Manual Adjustment 5 1 1 Milk froth regulation Menu Product settings Here the foam quality of the fresh milk can be adjusted The setting is valid for the respective milk beverage Denser foam Increase the speed of the air pump Lighter foam Decrease the speed of the air pump 5 2 Customer menu settings
39. umidity of 80 is required e This machine is not intended for use by persons including Children with reduced intellectual sensory and physical abilities or lack of experience and knowledge unless they are supervised by a person responsible for their safety e Prevent access for children or contact with domestic animals plants or insects This also applies to the packaging material small parts and detergents e Keep in mind that after switching off the machine several outlet parts still may be hot e NEVER spray into the machine with a spray CFC and HFC free Propellants are often highly flammable EXPLOSION HAZARD e During unattended shutdowns the machine must be turned off and the tap must be turned off For water and electricity damage due to not following this instruction any liability is rejected e Use only original VERON cleaners and spare parts For damages that are caused by the use of other cleaning products and spare parts any liability is rejected e For accidents or damage caused due to non observance of these Safety regulations neither the supplier nor the manufacturer is liable Seite 6 User Manual BARISSIMA V 1 00 02 2015 English 1 4 3 Warning Notes Despite all precautions every machine contains a potential safety risk when handled improper For this reason we have for your own safety summarized the hazards for you Note these hints when operating your milk foamer to avoid injury and health hazards The mil
Download Pdf Manuals
Related Search