Owner`s Manual OUTDOOR FIRE PIT ITEM # 61611
Contents
1. NOTE Whenever gas connections are loosened or removed you must perform a complete leak test Complete installation 10 OPERATION INSTRUCTIONS amp WARNING Very hot while in a operation DANGER e CARBON MONOXIDE HAZARD Never lean over the fire pit while in use Do not touch surfaces while the fire pit is in operation wait until the fire pit has cooled down after use Failure to comply with these instructions may result in serious bodily injury e For outdoor use only Never use inside house or other unventilated or enclosed areas This fire pit consumes air oxygen Do not use in unventilated or enclosed areas to avoid endangering your life Caution Do not attempt to operate until you have read and understand all General Safety Information in this manual and all assembly is complete and leak tests have been performed Before Turning Gas Supply ON 1 Your fire pit was designed and approved for outdoor use only Do NOT use it inside a building garage or any other enclosed area 2 Make sure surrounding areas are free of combustible materials gasoline and other flammable vapors or liquids 3 Ensure that there is no obstruction to air ventilation Be sure all gas connections are tight and there are no leaks 4 Be sure the cylinder cover is clear of debris Be sure any component removed during assembly or servicing is replaced and fastened prior to starting Before Lighting 1 Fire pit should be thoro2. OUTDOOR FIRE PIT ITEM 61611 Lombok 5 Piece Chat Group with Fire Pit Po tae fe gi gt Fa E a A L Lt CAN Y A N i M ih _ _ _ _ __ as a ATTACH YOUR RECEIPT HERE Serial Number Purchase Date SIGN Sy D d e e SE e eRT MED Va a US ANS 221 97 2010 Outdoor Decorative Gas Appliances CGA CR 97 003 Outdoor Gas Fireplaces Questions problems missing parts Before returning to your retailer call our customer service hotline at 1 866 985 7877 9 a m 6 p m EST Monday Friday or email at cservice welltraveled net PACKAGE CONTENTS z o XOAN OOO 0 9 DESCRIPTION Burner Cover Burner Table Top Burner Bracket Protective Fire Pit Cover QUANTITY LOCATED IN CARTON 1 boxes N HARDWARE CONTENTS a D A A ry Q us S p y Stud 8 30 Washer M8 Spring washer M8 Nut M8 Qty 4 Qty 4 Qty 4 Qty 4 Wrench Qty 1 Screwdriver Qty 1 SAFETY INFORMATION SAFETY INFORMATION Please read and understand this entire manual before attempting to assemble operate or install this appliance If you have any questions regarding the product please call customer service 1 866 985 7877 9 a m 6 p m EST Monday Friday This appliance has been tested to and complies with the ANS Z21 97 2010 Outdoor Decorative Gas Appliances CGA CR 97 003 Outdoor Gas Fireplaces The installation must conform to local codes or in th
3. rusted or damaged propane cylinder may be hazardous and should be checked by your cylinder supplier Never use a propane cylinder with a damaged valve connection The propane cylinder must be constructed and marked in accordance with the specifications for LP gas cylinders of the U S Department of Transportation DOT or the standard for cylinders spheres and tubes for transportation of dangerous goods and commission CAN CSA B339 The cylinder must have a listed overfilling prevention device The cylinder must have a connection device compatible with the connection for the appliance The cylinder used must include a collar to protect the cylinder valve Never connect an unregulated propane cylinder to the appliance KKK 600000000000 Attach regulator to cylinder Complete attachment Install cylinder Secure the propane cylinder with the cylinder screw by tightening the screw until it comes in contact with the cylinder Do not store a spare LP gas cylinder under or near this appliance Never fill the cylinder beyond 80 percent full Place the dust cap on the cylinder valve outlet whenever the cylinder is not in use Only install the type of dust cap on the cylinder valve that is provided with the cylinder valve Other type of caps or plugs may result in leakage of propane ATTENTION THIS PRODUCT IS NOT FOR COMMERCIAL USE INTENDED FOR RESIDENTIAL USE ONLY Do not sit or stand on this table Keep children away durin
4. California Proposition 65 Combustion by products produced when using this product contain chemicals known to the State of California to cause cancer birth defects and other reproductive harm amp WARNING BURN HAZARD e Never leave fire pit unattended when hot or in use e Keep out of reach of children amp WARNING Certain materials or items when stored under the fire pit will be subjected to radiant heat and could be seriously damaged CAUTION SERVICE SAFETY e Keep all connections and fittings clean Make sure propane cylinder valve outlet is clean e During set up check all connections and fittings for leaks using soapy water Never use a flame e Use as a heating appliance only Never alter in any way or use with any device CAUTION CAUTION indicates an imminently hazardous situation which if not avoided may result in minor or moderate personal injury or property damage WARNING e This product is fueled by propane gas Propane gas is invisible odorless and flammable An odorant is normally added to help detect leaks and can be described as a rotten egg smell The odorant can fade over time so leaking gas is not always detectable by smell alone e Propane gas is heavier than air and leaking propane will sink to the lowest level possible It can ignite by ignition sources including matches lighters sparks or open flames of any kind many feet away from the original leak Use only propane g
5. burn asphyxiation and or carbon monoxide poisoning Only persons who can understand and follow the instructions should use or service this fire pit Solid fuels shall not be burned with this appliance SAFETY INFORMATION DANGER e EXPLOSION FIRE HAZARD e Keep solid combustibles such as building materials paper or cardboard a safe distance away from the fire pit as recommended by the instructions e Provide adequate clearances around air openings into the combustion chamber e Never use the fire pit in spaces which do or may contain volatile or airborne combustibles or products such as gasoline solvents paint thinner dust particles or unknown chemicals e During operation this product can be a source of ignition Keep fire pit area clear and free from combustible materials gasoline paint thinner cleaning solvents and other flammable vapors and liquids Do not use fire pit in areas with high dust content Minimum fire pit clearances from combustible materials two 2 feet from the sides amp two 2 feet from the rear six 6 feet from ceiling DANGER e EXPLOSION FIRE HAZARD e Never store propane near high heat open flames pilot lights direct sunlight other ignition sources or where temperatures exceed 120 degrees F 49 C e Propane vapors are heavier than air and can accumulate in low places If you smell gas leave the area immediately e Never install or remove propane cylinder while fire
6. pit is lighted near flame pilot lights other ignition sources or while fire pit is hot to touch e This fire pit is red hot during use and can ignite flammables too close to the burner Keep flammables at least 2 feet from sides amp 2 feet from rear 6 feet from ceiling Keep gasoline and other flammable liquids and vapors well away from fire pit e Store the propane cylinder outdoors in a well ventilated space out of reach of children Never store the propane cylinder in an enclosed area house garage etc If fire pit is to be stored indoors disconnect the propane cylinder for outdoor storage amp WARNING We cannot foresee every use which may be made of our fire pit Check with your local fire safety authority if you have questions about fire pit use Other standards govern the use of fuel gases and heat producing products for specific uses Your local authorities can advise you about these If no local codes exist follow National Fuel Gas Code ANSI Z223 1 In Canada installation must conform to local codes If no local codes exist follow the current National standards of CANADA CAN CGA B 149 2 DANGER e CARBON MONOXIDE HAZARD e This fire pit is a combustion appliance All combustion appliances produce carbon monoxide CO during the combustion process This product is designed to produce extremely minute non hazardous amounts of CO if used and maintained in accordance with all warnings and instructions Do
7. DO NOT PUT THE SOR PROTECTIVE FIRE PIT COVER ON A HOT FIRE PIT SRR AN 5 Connect the hose and regulator to the cylinder The propane gas and cylinder are sold separately Use a standard 20 Ib propane cylinder only Use this fire pit only with a propane vapor withdrawal supply system See Chapter 5 of the standard for storage and handling of liquefied petroleum gas ANSI NFPA 58 Your local library or fire department should have this book Storage of an appliance indoors is permissible only if the cylinder is disconnected and removed from the appliance A cylinder must be stored outdoors in a well ventilated area out of reach of children A disconnected cylinder must have dust caps tightly installed and must not be stored in a building garage or any other enclosed area The maximum inlet gas supply pressure 250 psi The minimum inlet gas supply pressure 5 psi The minimum hourly of 10000 Btu is required input rating for a fire pit for automatic operation at rating less than full input rating The pressure regulator and hose assembly supplied with the appliance must be used The installation must conform with local codes or in the absence of local codes with national fuel gas code ANSI Z2223 1 NFPA54 natural gas and propane Installation Code CSA B149 1 or propane storage and handling code B149 2 Use the LPG Tank Cover Q to cover the LPG tank prior to placing the LPG tank under the assembled Fire Pit ASSEMBLY dented
8. OR AGENTS BE LIABLE TO THE PURCHASER OR ANY THIRD PARTY WHETHER IN CONTRACT IN TORT OR ON ANY OTHER BASIS FOR ANY INDIRECT SPECIAL PUNITIVE EXEMPLARY CONSEQUENTIAL OR INCIDENTAL LOSS COST OR DAMAGE ARISING OUT OF OR IN CONNECTION WITH THE SALE MAINTENANCE USE OR INABILITY TO USE THE PRODUCT EVEN IF WELL TRAVELED LIVING OR ITS DIRECTORS OFFICERS OR AGENTS HAVE BEEN ADVISED OF THE POSSIBILITY OF SUCH LOSSES COSTS OR DAMAGES OR IF SUCH LOSSES COSTS OR DAMAGES ARE FORESEEABLE IN NO EVENT WILL WELL TRAVELED LIVING OR ITS OFFICERS DIRECTORS OR AGENTS BE LIABLE FOR ANY DIRECT LOSSES COSTS OR DAMAGES THAT EXCEED THE PURCHASE PRICE OF THE PRODUCT SOME JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO THE PURCHASER This limited warranty gives you specific legal rights and you may also have other rights which vary from jurisdiction to jurisdiction The provisions of the United Nations Convention on Contracts for the Sales of Goods shall not apply to this limited warranty or the sale of products covered by this limited warranty 1MIPORTANT NOTICE Do NOT return to place of purchase For customer service and warranty issues contact our Customer Service Center at 866 985 7877 OR Email cservice welltraveled net Customer Service Hours Mon Fri 9 00 a m 6 00 p m EST Fire Sense Mojave Sun and Well Traveled Livi
9. ance activities on a regular basis Keep exterior surfaces clean 1 Use warm soapy water for cleaning Never use flammable or corrosive cleaning agents 2 While cleaning your unit be sure to keep the area around the burner dry at all times Do not submerge the control valve assembly If the gas control is submerged in water do NOT use it It must be replaced a Keep the appliance area clear and free from combustible materials gasoline and other flammable vapors and liquids b Do not obstruct the flow of combustion and ventilation air c Keep the ventilation opening s of the cylinder enclosure free and clear from debris 3 Air flow must be unobstructed Keep controls burner and circulating air passageways clean Signs of possible blockage include 12 CARE AND MAINTENANCE e Gas odor with extreme yellow tipping of flame e Fire pit does NOT reach the desired temperature e Fire pit glow is excessively uneven eFire pit makes popping noises e Spiders and insects can nest in burner or orifices This dangerous condition can damage fire pit and render it unsafe for use Clean burner holes by using a heavy duty pipe cleaner Compressed air may help clear away smaller particles eCarbon deposits may create a fire hazard Clean burner with warm soapy water if any carbon deposits develop Note In a salt air environment such as near an ocean corrosion occurs more quickly than normal Frequently check for corroded areas and
10. as set up for vapor withdrawal e Store or use propane gas in compliance with local ordinances and codes or with ANSI NFPA 58 Turn off propane when not in use WARNING e Alert children and adults to the hazards of high surface temperatures Stay away from these surfaces to avoid burning skin or igniting clothing e Carefully supervise young children when in the vicinity of the fire pit e Do not hang clothing or any other flammable materials from the fire pit or place on or near the fire pit e Replace any guard or protective device removed for servicing the appliance prior to placing back in service e Installation and repair should be done by a qualified service person The fire pit should be inspected before use and annually by a qualified service person More frequent cleaning may be required as necessary It is imperative that the control compartment burners and circulating air passageway of the appliance be kept clean OPERATION CHECKLIST Operation Checklist For a safe and pleasurable heating experience perform this check before each use Before Operating 1 am familiar with entire owners manual and understand all precautions noted 2 All components are properly assembled intact and operable 3 No alterations have been made 4 All gas connections are secure and do not leak 5 Wind velocity is below 10 mph 6 Unit will operate at reduced efficiency below 40 F 4 44 C 7 Fire pit is outdoors out
11. d or replaced at no charge to the customer Any returns sent back to Well Traveled Living must be sent via prepaid freight and in the original retail packaging For warranty service contact Well Traveled Living at the address phone numbers or internet site and email listed in this owner s manual Be sure to have your sales receipt date of purchase and catalogue model numbers available when calling All warranty service will be coordinated by the Well Traveled Living s Amelia Island Florida service center This warranty is extended only to the original purchaser Proof of purchase will be required before warranty service is rendered The sales receipt is the only valid proof of purchase This warranty only covers failures due to defects in materials or workmanship which occur during normal use Failures and or damage which result from accident negligence misuse abuse neglect mishandling alteration or modification failure to maintain improper assembly or maintenance service by unauthorized agency or use of unauthorized components or damage that is attributable to acts of God are NOT covered THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED ABOVE PURCHASER ASSUMES ALL RISKS IN THE ASSEMBLY AND OPERATION OF THIS UNIT FAILURE TO FOLLOW WARNINGS AND OPERATIONAL INSTRUCTIONS CONTAINED IN THIS MANUAL CAN RESULT IN SEVERE PROPERTY DAMAGE AND OR PERSONAL INJURY IN NO EVENT WILL WELL TRAVELED LIVING OR ITS DIRECTORS OFFICERS
12. e absence of local codes to the National Fuel Gas Code ANSIZ223 1 This manual contains important information about the assembly operation and maintenance of this patio heater General safety information is presented in the first few pages and is also located throughout this manual Keep this manual for future reference and to educate new users of this appliance This manual should be read in conjunction with the labeling on the appliance Safety precautions are essential when any mechanical or propane fueled equipment is involved These precautions are necessary when using storing and servicing Using this appliance with the respect and caution demanded will reduce the possibilities of personal injury or property damage The following symbols shown below are used extensively throughout this manual Always heed these precautions as they are essential when using any mechanical or propane fueled equipment A DANGER FOR YOUR SAFETY If you smell gas A DANGER DANGER indicates an imminently hazardous situation which is not avoided will result in death or serious injury 1 Shut off gas to the appliance 2 Extinguish any open flame 3 If odor continues keep away from the appliance and immediately call your gas supplier or fire department A DANGER Failure to comply with the precautions and instructions provided with this heater can result in death serious bodily injury and property loss or damage from hazards of fire explosion
13. g assembly as this item contains small parts which can be swallowed by children Do not use indoors or inside any enclosure Retain the assembly instructions for future reference Installer Please leave these instructions with the owner OPERATION INSTRUCTIONS Leak Test amp WARNING e Perform all leak tests outdoors e Extinguish all open flames e NEVER leak test when smoking e Do not use the fire pit until all connections have been leak tested and do not leak Ve Hose Regulator Regulator Cylinder connection connection 1 Make 2 3 oz of leak test solution one part liquid dishwashing detergent and three parts water 2 Apply several drops of solution where hose attaches to regulator 3 Apply several drops of solution where regulator connects to cylinder 4 Make sure all fire pit and light valves are OFF 5 Turn cylinder valve ON If bubbles appear at any connection there is a leak 1 Turn cylinder valve OFF 2 If leak is at hose regulator connection tighten connection and perform another leak test If bubbles continue appearing the hose should be returned to the place of purchase 3 If leak is at regulator cylinder valve connection disconnect reconnect and perform another leak check If you continue to see bubbles after several attempts cylinder valve is defective and should be returned to cylinder s place of purchase If NO bubbles appear at any connection the connections are secure
14. ght N d usn HIGH lt A O G N T usn HIGH e 19 A O N un Figure B Figure C Normal Abnormal 11 OPERATION INSTRUCTIONS amp WARNING FOR YOUR SAFETY Be careful when attempting to manually ignite this fire pit Holding in the control knob for more than 10 seconds before igniting the gas will cause a ball of flame upon ignition When fire pit is ON Burner will display tongues of blue and yellow flame These flames should not be yellow or produce thick black smoke which would indicate an obstruction of airflow through the burners The flame should be blue with straight yellow tops If excessive yellow flame is detected turn off fire pit and consult Troubleshooting on page 14 Re lighting 1 Turn control knob to OFF 2 Repeat the Lighting steps on prior page amp WARNING FOR YOUR SAFETY Fire pit will be hot after use Handle with extreme care Shut Down 1 To extinguish burner depress control knob and continue to turn it clockwise to OFF 2 Turn cylinder valve clockwise to OFF and disconnect regulator when fire pit is not in use CARE AND MAINTENANCE amp WARNING FOR YOUR SAFETY e Do NOT touch or move fire pit for at least 45 minutes after use e Fire Pit is hot to the touch e Allow Fire Pit to cool before touching To enjoy years of outstanding performance from your fire pit make sure you perform the following mainten
15. lf you have any questions regarding this product please call our customer service hotline at 1 866 985 7877 9 a m 6 p m EST Monday Friday or email us at cservice welltraveled net 13 TROUBLESHOOTING PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION Propane cylinder is empty Replace propane cylinder Burner won t light Blockage in orifice Clear blockage Control knob is not in ON position Turn control knob to ON Turn cylinder valve OFF and fill the Gas pressure is low cylinder Burner flame is low Outdoor temperature is less than 40 F and tank is less than 1 4 full Use a full cylinder Control knob fully ON Check burner and orifices for blockage Carbon build up Dirt or film on burner Clean burner Thick black smoke Blockage in burner Remove blockage and clean burner inside and outside 14 Distributed By Well Traveled Living 716 S 8 Street Amelia Island FL 32034 Toll Free 866 WTL SUPP Web www wtliving com Email cservice welltraveled net 1 YEAR LIMITED WARRANTY Customers in the Continental US All components are warranted for a period of 1 year after date of purchase by the original owner against defects in materials and workmanship under normal use This warranty does NOT cover normal wear and weathering assembly and or maintenance OR use in a commercial application if model is not designated as a commercial model At Well Traveled Living s sole discretion products under warranty will be repaired an
16. ng are registered trademarks of Well Traveled Imports Inc All assembly instruction presentations are the property of Well Traveled Imports Inc and are protected by U S copyrights and trademarks All rights reserved 15
17. not block air flow into or out of the fire pit e Carbon Monoxide CO poisoning produces flu like symptoms watery eyes headaches dizziness fatigue and possibly death You can t see it and you can t smell it It s an invisible killer If these symptoms are present during operation of this product get fresh air immediately e For outdoor use only e Never use inside house or other unventilated or enclosed areas e This fire pit consumes air oxygen Do not use in unventilated or enclosed areas to avoid endangering your life amp WARNING WARNING indicates an imminently hazardous situation which if not avoided will result in death or serious injury amp WARNING Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance PIN WARN N e For Outdoor Use Only CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide which has no odor Using it in an enclosed space can kill you Never use this appliance in an enclosed space such as a camper tent or home amp WARNING Improper installation adjustment alteration service or maintenance can cause property damage injury or death Read the installation operation and maintenance instructions thoroughly before installing or servicing this equipment SAFETY INFORMATION amp WARNING
18. repair them promptly Storage Between uses e Turn Control Knob OFF e Disconnect LP source e Store fire pit in an area sheltered from direct contact with inclement weather such as rain sleet hail snow dust and debris e Cover fire pit to protect exterior surfaces and to help prevent build up in air passages with the Protective Fire Pit Cover provided Note Wait until fire pit is completely cooled before covering During periods of extended inactivity or when transporting e Turn Control Knob OFF e Disconnect LP source and move to a secure well ventilated location outdoors e Store fire pit upright in an area sheltered from direct contact with inclement weather such as rain sleet hail snow dust and debris e If desired cover fire pit to protect exterior surfaces and to help prevent build up in air passages Never leave LP cylinder exposed to direct sunlight or excessive heat Note Wait until fire pit is completely cool before covering with the Protective Fire Pit Cover provided Make sure to properly locate the gas hose by keeping it out of pathways where people may trip over it or in an area where the hose may be subject to accidental damage Always inspect the hose for evidence of excessive abrasion cuts or wear prior to use and make sure to leak test Service Only a qualified service person should repair gas passages and associated components Caution Always allow fire pit to cool before attempting service
19. side any enclosure 8 There is adequate fresh air ventilation Do not use this appliance if any part has been under water Immediately call a a qualified service technician to inspect the appliance and to replace any part of the control system and gas control which has been under water 9 Fire pit is away from gasoline or other flammable liquids or vapors 10 Fire pit is away from windows air intake openings sprinklers and other water sources 11 Fire pit is at least 24 in on rear and at least 24 in on sides from combustible materials 12 Fire pit is on a hard and level surface 13 There are no signs of spider or insect nests 14 All burner passages are clear 15 All air circulation passages are clear 16 Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition 17 Young children should be carefully supervised when they are in the area of the fire pit 18 Clothing or other protective material should not be hung from the fire pit or placed on or near the fire pit 19 Any guard or other protective device removed for servicing the fire pit must be replaced prior to operating the fire pit 20 Installation and repair should be done by a qualified service person The fire pit should be inspected before use and at least annually by a qualified service person 21 More frequent cleaning may be required as necessary It is imperative that control compar
20. tment burner and circulating air passageways of the fire pit be kept clean After Operation 1 Gas control is in OFF position 2 Gas Tank valve is OFF 3 Disconnect Gas line 4 After each use replace cap on gas tank PREPARATION Before beginning assembly of product make sure all parts are present Compare parts with package contents list and hardware contents above If any part is missing or damaged do not attempt to assemble the product Contact customer service for replacement parts Estimated Assembly Time 60 minutes Required for Assembly not included Leak Test Solution see page 10 ASSEMBLY 1 Fix the Table Top C onto the pre assembled Side Panels E Pedestal H using Stud J Washer K Spring Washer L and Nut M Hardware Used 4 x J Stud 8 30 4 x K Washer M8 4 x L Spring Washer M8 4 x M Nut M8 e J K L M 2 Place the Burner B into the Burner Bracket D Pour the Glass Beads R around the Burner B 3 Attach the Door F to the assembled Side Panels Pedestal ic mean 0 0 0 0 0 A 0 0 0 0 0 69999 9 0 0 0 000000 0 0 0 0 0 9 0 0 0 0 0 0 0 9 0 0 0 0 0 0 00 0 0 9 0 0 0 0 0 0 0 009 0 0 0 0 0 0 0 0 0 0 0 9 0 0 0 0 0 0 000900 000 0 KASS 000000000000 ASSEMBLY 4 Place the Burner Cover on the Burner B When the Fire Pit is NOT in use or after use when the Fire Pit has cooled COMPLETELY Se cover it with the Protective Fire Pit Cover P
21. ughly inspected before each use and by a qualified service person at least annually If relighting a hot fire pit always wait at least 5 minutes 2 Inspect the hose assembly for evidence of excessive abrasion cuts or wear Suspected areas should be leak tested If the hose leaks it must be replaced prior to operation Only use the replacement hose assembly specified by manufacturer The burner must be replaced prior to the appliance being put into operations if it is evident that the burner is damaged The replacement burner should be specified by manufacturer Lighting 1 Turn the control knob to the OFF position Figure A 2 Fully open LP cylinder valve Note For initial start or after any cylinder change hold Control Knob IN for 2 minutes to purge air from gas lines before proceeding 3 Push in gas control knob and turn counterclockwise to IGNITE Figure B to light the fire pit If needed keep depressing and turning control knob counterclockwise until the fire pit lights you should hear a clicking sound 4 After fire pit lights release control knob Push in and turn the control knob counterclockwise to the HIGH position then release control Knob lf you want a lower temperature push in the control knob and turn counterclockwise to the LOW position Figure Note If burner fails to remain lit all valves should be closed and a waiting period of at least 5 minutes should pass before attempting to li
Download Pdf Manuals
Related Search