Home

USER MANUAL-Leon

1. Item Inspection Content Is the joystick loose and or making noise Can the joystick be turned left and right smoothly Can the speed buttons be adjusted freely and do they function well Joystick Does the wheelchair stop when the joystick is Controller released completely Does it light up when the power is ON Is there enough power for your trip Does the horn work well Is there any abnormal noise Motor Does the electromagnetic brake work properly Freewheel Do the freewheel levers work properly Mode Driver s Seat Does the driver s seat recline if applicable 41 Do the seat angle adjustment knobs or buttons work properly Does the surface of the seat remain or break Are there any cracks or other damage to the tires Check the tire tread depth and air pressure Is there any abnormal motor noise Except the joystick control panel can be operate by the occupant other operations should be carried out by an assistant Anything wheelchair related that requires tools should be done by your authorized Karma service provider Visit or contact a KARMA dealer for inspection and maintenance if you find anything abnormal 7 2 Regular Maintenance Record To make sure your wheelchair is in good condition visit your KARMA wheelchair dealer regularly for maintenance and keep records accordingly every six months after purchasing A maintenance service fee may apply
2. 2 6 Rain This product is not guaranteed to be water resistant Please do not drive In the rain through puddles or spray water to clean this product Figure 2 1 2 7 While Driving Please carry out daily inspections Refer to Section 7 1 DAILY CHECK 2 8 General Warning Do not lean over the side of the wheelchair as such an action may cause you to lose balance and fall Be careful not to have your clothing get tangled with the wheels 2 9 Railroad Crossing Before crossing the tracks please stop completely and look both ways Cross the tracks perpendicular to avoid your wheels getting stuck Do not drive at full soeed over railroad tracks 2 10 Circumstances to Avoid 2 10 1 Avoid roads with heavy traffic mud excessive gravel or bumps snow and ice These conditions may damage your wheelchair 2 10 2 Avoid roads that are too narrow or by a canal waterway without any fence hedge 2 10 3 Also avoid places where your wheels might get stuck slip or not have traction 2 10 4 Do not drive in a gale at night or in rainy snowy foggy misty weather These conditions may cause your wheelchair to rust Figure 2 2 2 10 5 Do not drive in a S curve do doughnuts or make sudden turns 2 10 6 Do not take an escalator 2 11 Mobile Phones and Other Electric Equipment 2 11 1 Do not use a mobile phone or other wireless communication devices while driving See Section 3 EMI RFI 2 11 2 Do not charge the mobile phone or other electric d
3. Is the battery indicator light not on My wheelchair Charge the batteries does not start Is the charger plugged into the wheelchair Unplug the charger and put It away Is the seat release lever to be locked Unlocked the seat release lever 47 If you cannot solve the problem by yourself contact your KARMA wheelchair dealer for help 9 1 VRII Controller Battery amp Diagnostics Indicator The following table indicates what the gauge will display for any given state The battery needs Check the connections to dena charging or there isa the battery If the bad connection to the connections are good try battery charging the battery a a eifhand mea has a bad connection the left hand motor The left hand motor Connect your service sa has a short circuit to a agent battery connection ots Dan Welsh mag has a bad connection the left hand motor The left hand motor Connect your service 5 signals has a short circuit to a agent battery connection The wheelchair Is Please remove the charger caon peng prevented from driving by an external signal 7 cignals A joystick fault is Make sure that the joystick indicated is in the center position A joystick fault is Make sure that all e 8 Signals indicated connections are secure The parking brakes Check the parking brake have a bad and motor connections and connection make sure all connections
4. Figure 5 1 2 Always ensure that the wheelchair is in Drive Mode before using the wheelchair i e Before turning on the controller When the wheelchair is in Freewheel Mode make sure that there s an attendent that can offer assistance 5 2 14 Tires The rear wheels and the casters are pneumatic tires Please refer to the tires pressure specified on the tire walls to maintain the tires at the correct pressure Do not let anyone touch the wheels when the wheelchair is in motion to avoid pinch injury 5 3 How to Adjust Your Wheelchair 5 3 1 Swing Away and Detach Footrest To swing away and detach the footrests pull the swing away lever Figure 5 2 1 then you can swing away and or detach the footrests Figure 5 2 2 It can make transferring in and out of the wheelchair 19 easier The Leon series can also be mounted with other types of KARMA footrests ww Figure 5 2 1 Figure 5 2 2 5 3 2 Footrest Adjustment in Longitudinal Fore Aft Position Please use the 4 Allen Key Wrench included in your KARMA Tool Kit to make this adjustment Remove the screws under the seat Figure 5 3 1 then adjust the footrest to accommodate the user s leg position and flexibility Figure 5 3 2 Re tighten the screws Figure 5 3 1 Figure 5 3 2 5 3 3 Footplates Adjustment The footplate length should be adjusted according to the user s calf length Go to your service provider for adjustment or follow below Instr
5. are secure 90 e An excessive voltage Check the battery e 10 signals has been applied to connections 48 _ thecontrolsystem A communication fault Make sure that joystick 7signals i is indicated cable is securely connected and not damaged An actuator trip Is If more than one actuator is 8 signals indicated fitted check which actuator A is not working correctly Check the actuator wiring 49 10 SPECIFICATIONS 1 cm 0 5 kg ate tal Sling Seat with pelvic belt Captain Seat with pelvic belt Saane zs o e 170mm 240mm Armrest Height the range of adjustable height 240mm n 270mm 3 is 70mm positions 7 Leg rest Length 390mm 510mm 390mm 520mm Manual Powered Tilt Powered Tilt 5 25 Optional Manual Tilt Manual Tilt Recline Powered Recline 0 32 0 65 0 45 Motor Nominal saith ANA DC 450W 4P Optional 300W 2P Output Max Output MaxsafeSlope Maximum Obstacle 60mm Climbing Ability Turning Radius Width Height with the headrest headrest Max User Weight 140 kg Weight W O Batteries 78 kg 70kg Total Weight W io l ii 108 kg 100 kg Batteries 50 10 1 The Leon Series Static Stability Test Result The degree tolerance Is 0 1 degree The test condition size of test dummy used 140 kg E eau een Leon Sling Seat Leon Captain Seat With Locked 9 5 11 3 gt 15 5 Rear Wheels Static Stability l With Uphill
6. 7 4 5 Please use a soft and dry cloth to keep your wheelchair clean Use moderate or mild detergent to clean the wheelchair if necessary CE SUGGESTION Do not directly spray water on your wheelchair to wash it as this could lead to a malfunction in the electric system Do not use gasoline solvents or other abrasive solutions the casing may become deformed or damaged Before performing any maintenance be sure to turn the power OFF and unplug the charger if connected DO NOT over tighten any hardware This could cause damage to the frame and hardware G WARNING After ANY adjustments repair or service and BEFORE use make sure that all hardware is tightened securely otherwise injury or damage may occur 7 5 Suggested Maintenance Procedures 7 5 1 Before using the powered wheelchair make sure all nuts and bolts are tight 7 5 2 Check all parts for damage or wear and have a qualified technician replace it if necessary 7 5 3 Check all parts for proper adjustment 7 5 4 Ensure that the batteries are properly maintained and charged as required 7 5 5 Inspect brake for proper operation 7 5 6 The wheels and tires should be checked periodically for cracks and wear and should be replaced by a qualified technician 7 5 7 Regularly check for loose nuts and or bolts in the front and rear wheels If loose have them adjusted by a qualified technician 7 5 8 Clean dirt dust and grease from exposed components
7. A Better Wheelchair A Better Fit Powered Wheelchair Owner s Manual Leon Series LEN Sling Seat LEN Captain Seat CE ISO 9001 IMPORTANT Do not attempt to use the wheelchair before a qualified person has explained to your satisfaction how to operate it without risk to yourself or others WARNING Do not operate this powered wheelchair before first reading and understanding this owner s manual If you are unable to understand the warnings cautions suggestions and technical instructions please contact a dealer healthcare professional or applicable personnel before attempting to use this powered wheelchair otherwise injury or damage may occur If any procedure other than those described in this owner s manual it must be oerformed by a qualified technician THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO CHANGE WITHOUT NOTICE BY KARMA WARNING Asa manufacturer of powered wheelchairs KARMA endeavors to supply a wide variety of powered wheelchairs to meet the many needs of the user However the responsibility of final selection of the type of powered wheelchair to be used by an individual rests solely with the user and his her healthcare professional capable of making such a selection KARMA strongly recommends consulting a certified rehab technology supplier or assistive technology professional Operating Information Performance adjustments should ONLY be made by professionals of
8. e leaving the chair in moist areas such as bathrooms Direct exposure to rain or dampness could cause the powered wheelchair to malfunction electrically and mechanically and may cause the powered wheelchair to prematurely rust Salt water can be particularly damaging to Figure 1 the wheelchair components and electrical circuits causing rust or damage Do not use the chair if the joystick rubber boot is damaged in any way as moisture can damage the control system Should your chair should get wet please dry it as soon as possible to help avoid any damage STAIRWAYS DO NOT attempt to move an occupied powered wheelchair between floors using a stairway See Figure 1 Use an elevator to move an occupied powered wheelchair between floors When it s necessary to mov the chair between floors by means of a stairway the occupant MUST be moved and transported independently of the powered wheelchair Extreme caution Is advised when it is necessary to move an UNOCCUPIED powered wheelchair up or down stairs Karma recommends disassembling the wheelchair and transporting the components independently up or down stairs Make sure to use ONLY secure non detachable parts on each component for hand hold supports DO NOT attempt to lift a powered wheelchair by any removable detachable parts Lifting by means of removable detachable parts may result in injury to the user or assistants or damage to the wheelchair ESCALATOR DO NOT
9. 12 5 6 Driving in places where the vehicle should not normally be driven or used 12 5 7 Damage or surface corrosion from environmental factors such as airborne fallout chemicals tree sap et cetera stones hail windstorms lighting floods and so on 12 5 8 Change of any material or component parts not authorized by KARMA Don t carry objects that may lead to the wheelchair being unbalanced 12 5 9 The wheelchair shall not be pulled or pushed by another vehicle when there is a person on the wheelchair or the rear wheels are not set to the freewheel mode and having its structure inspected 12 5 10 Do not drive a wheelchair that is older than 10 years without having its structure inspected 12 6 The Responsibilities of the User The following items are the responsibility of the user 12 6 1 Proper use of the vehicle in accordance with this Owner s Manual 12 6 2 Performance of the daily inspections 12 6 3 Performance of the regular maintenance recommended by KARMA and 12 6 4 Keep a record of vehicle inspection and maintenance in the back of 55 this Owner s Manual 12 7 Warranty Effectiveness The warranty form must be completely filled out and stamped by the KARMA dealership where the wheelchair was purchased 12 8 Transfer of Warranty Rights If you purchase a second hand KARMA wheelchair while it is still with in the warranty period bring the Owner s Manual and the vehicle to the dealership where the wheelchair was
10. CE SUGGESTION Even if you don t use the wheelchair for a long time the wheelchair should still be maintained regularly You should clean your wheelchair inside and out regularly to keep it beautiful and safe 42 I Inspection A Adjustment A Repair 3 Replacement T Tightening L Add Oil 1 6 12 18 24 30 Item Period mth mth mth mth mth mth Moving Parts Refer to Section 7 7 ee Electromagnetic Brakes Motor J a Connection to the Electrical System ae Loose or Corroded Terminals ae Battery Connection to the Electrical ae System Damage to the Electrical Cord Cable ae 7 i E I A I L I L Recline Function if Seat applicable Tires Cracks Surface Damage I 3 Tread Depth n Abnormal Wear Pattern a Tightness of Bolts and Nuts i I 3 I 3 I 3 I 3 I 3 I 3 I 3 Wheel cf et fe et fe ef fe DRE Charging Function and LED i i EET Light Charger Socket Plug and Cords a Pr fo J rt Fan Functions Properly if applicable Driver s vo m 13 B nijn n n m Tt 43 1 6 12 18 24 30 Item Period mth mth mth mth mth mth Rim Wear or Deformation l 3 l 3 Around Tires 7 3 Tires 7 3 1 The condition of the tires is affected by the way you drive and use your wheelchair 7 3 2 Inspecting Tire Tread please check the tread depth regularly 7 3 3Replace the tires when the tread depth is less than 0 5 mm 7 3 4The tires could be pneumatic or PU tires
11. With Actuators j N ii EP 1 JAN M N Leon Control Panel Figure 5 2 9 Right Turn Signal Button 10 Hazards Indicator 11 Hazards Button 12 Speed Decrease Button 13 Left Turn Signal Indicator 14 Left Turn Signal Button 15 Seat Function Button 16 Tilt and Recline Indicators 5 2 1 Power ON OFF Press the power button Be sure not to touch the Joystick while turning on the controller Your battery amp diagnostics indicator should light up See Figure 5 1 and Figure5 2 5 2 2 Locking Unlocking the Wheelchair The VR2 control system can be locked to prevent unauthorized use The locking method is via a sequence of key presses and joystick movements as detailed below 5 2 2 1 To lock the wheelchair 5 2 2 1 1While the control system is switched on depress and hold the on off button 5 2 2 1 2 After one second the control system will beep Now release the on off button 5 2 2 1 3 Deflect the joystick forwards until the control system beeps 5 2 2 1 4 Deflect the joystick in reverse until the control system beeps 5 2 2 1 5 Release the Joystick there will be a long beep 5 2 2 1 6T he wheelchair is now locked 5 2 2 2 To unlock the wheelchair 5 2 2 2 1 Use the on off button to switch the control system on The maximum speed profile indicator will be rippling up and down 5 2 2 2 2 Deflect the joystick forwards until the control system beeps 5 2 2 2 3 Deflect the joystick
12. warnine Do not set the wheelchair in freewheel mode when on an incline or decline If you breakdown on railroad tracks first check for an oncoming train Ifa train is coming get out of its way immediately If no train is coming set to freewheel mode and push the wheelchair off the tracks 2 13 Maximum User Weight Limit 2 13 1 Refer to Max User Weight in Section 10 SPECIFICATIONS 2 13 2 Loading exceeding maximum capacity can damage your wheelchair and cause malfunctions yielding a safety hazard The warranty does not cover damage caused by improper operation of the wheelchair Caution Figure 2 2 Figure 2 3 Caution Figure 2 4 Figure 2 5 Figure 2 6 2 14 The Leon Series Labeling Please carefully read all the labeling on the wheelchair before driving it Do not remove them Protect them for future reference Labeling Location Circuit Breaker ba i If this circuit breaker A eat operates reset it by NX Switch pushing the button Finger Pinch Avoid it when flip back the armrest Wiring Diagram Do not change the wiring Freewheel Lever Follow the label to engage or release it DO NOT TOUCH d Karma T k am Karma Mobility Ltd ec Unit Target Park Shawbank Road Redditch BS N Tel 0845 630 3436 Fax 0845 630 3736 Karma Medical Products Co Ltd ual No 2363 Sec 2 Univers ty Rd Min Hsiung Shiang Chia i Hsien Taiwan ROC MED A WARNING USE ONLY ON STABLE
13. 5 23 Figure 5 23 5 3 12 19 Use part G and H to fasten the seat plate on the seat frame Figure 5 24 Part G Figure 5 24 5 3 12 20 Reinstall new version of parameters of the controller 5 3 12 21 Drive the wheelchair when the seat is reclined to the lowermost position If the wheelchair is inhibited from driving please adjust the switch Figure 5 25 In some situations it could be not safe to recline or tilt the seat when driving on a slope For safety the switch is used to inhibit the user from reclining or tilting the seat when driving on the slope 32 Loosen screws and adjust the switch upwards Figure 5 25 WARNING After completing this installation do operate the wheelchair to assure it works without malfunctions 5 3 13 Transportation The wheelchair is not suitable to use as a seat in vehicles KARMA always recommend that the user transfers to the vehicle seating The wheelchair cannot be used as seats in any vehicles That is KARMA recommends that users are NOT transported in any vehicle while seated in the wheelchair In the case of accident or a sudden stop the user could be thrown from the wheelchair and get injured The suggested solution is to transfer the user from the wheelchair into a normal seat of the vehicle and to securely stow the wheelchair in a separate compartment 6 BATTERIES AND CHARGER Except the joystick control panel can be operate by the occupan
14. in a narrow space Speed equivalent to a brisk walk Driving In an open space On an incline 3A Equivalent to walking at a normal speed Driving outdoors on flat ground 5 2 9 To Stop Release the joystick and the electromagnetic brake will stop the wheelchair Make sure that the wheelchair has come to a complete stop before turning the power OFF The stopping distance will vary with your forward reverse speed Therefore please gradually slow down and come to a complete stop well before any obstacles or danger To park the wheelchair be sure to park on flat ground and then turn the power to OFF NEVER use the freewheel mode when going down an incline The electromagnetic brake won t function in freewheel mode 5 2 6 Turn Signal Indicator Light The signal light will flash if you press the right or left signal button Turn off the signal light by pressing the button again 5 2 7 Headlights Taillights To turn the Headlight Taillight on press the Headlight Taillight Button Press the Headlight Button again to turn the headlight taillight off 5 2 8 Warning Signal Hazards Light To turn the Hazards Indicator on press the Hazards Button Press the Hazards Button again to turn the hazards function off AN Turn off the lights when not in use to save battery power 5 2 9 Horn Button The horn will sound for as long as the button is pressed 5 2 10 Battery Gauge The Battery Gauge is used to indi
15. in reverse until the control system beeps 5 2 2 2 4 Release the joystick there will be a long beep 5 2 2 2 5 The wheelchair is now unlocked 5 2 3 Adjusting the Driving Speed The user can adjust the wheelchair s top speed to suit their preferences and environment The currently selected top speed is shown on the Speedometer and can be adjusted using the Increase Speed and Decrease Speed buttons In the 5 speed mode pressing the Increase Speed and Decrease Speed buttons steps between one of five top speeds 20 to 100 In the fine adjusting mode pressing and holding the Increase Speed Decrease Speed Button ramps the top Speed up down in fine steps Please slow down before you get used to control your powered wheelchair Please slow down your speed when using it indoor The controller unit is set to ensure that the chair can give its best performacne Shoud the setting be adjusted due to medical needs the adjustment should be made by KARMA dealers Do not change or adjust the wiring layout of the chair for your safety Please slow down your speed when using it indoor 5 2 4 Driving Speed You can choose between 1 to 5 orange dots In the speed Indicator with 5 being the maximum speed Please refer to Max Speed in Section 10 SPECIFICATIONS Speed Scale Speed Equivalencies and Recommended Circumstances Speed equivalent to walking slowly on foot On an decline Driving indoors or
16. oil film DO NOT make sharp turns in forward or reverse at excessive speeds DO NOT attempt to lift the powered wheelchair by its casings and seat DO NOT attempt to lift the powered wheelchair by any detachable parts Lifting by means of any detachable parts of a powered wheelchair may result in injury to the user or damage to the powered wheelchair Please hold onto the frame when lifting your wheelchair DO NOT operate the powered wheelchair until you have checked that the surroundings are clear and that the area is safe for travel Please pay attention to the environment and to keep away from the hazard of external flame in spite of the seat having passed EN 1021 1 2 test and battery terminal caps having passed V O UL94 test When the user Is smoking pay attention to safety and make sure to extinguish the fire when finished Be alert to the environment when someone nearby is smoking or using a cigarette lighter keep away from the hazard and use fire proof cloth DO NOT use parts accessories or adapters other than those authorized by Karma Before attempting to sit in or exit the powered wheelchair turn the power OFF This will ensure that the powered wheelchair will not drive Turn the power OFF while the wheelchair is not in use Otherwise injury and or damage to the wheelchair and surrounding property may occur DO NOT connect any medical device i e a ventilator life support machine et cetera to the battery T
17. or KARMA supplier dealer to handle them Place the powered wheelchair in a well ventilated area where work can be performed without risking damage to carpeting or floor covering Failure to use the correct battery size and or voltage may cause damage to the powered wheelchair and give unsatisfactory performance For replacement of batteries please contact your local KARMA supplier dealer in order to ensure that the new batteries are correctly be used NEVER allow any of your tools and or battery cables to contact BOTH terminal posts at the same time An electrical short may occur and injury or damage may occur When tightening the clamps always use a box or crescent wrench Pliers will round off strip the nuts NEVER wiggle the terminal when tightening as the battery may be damaged CE SUGGESTION Charge batteries daily It is critical not to let them run low at any time Do not use the battery to charge telecom equipment or other items Battery capacity will vary with outside conditions the maximum drive range will decrease in the winter If the vehicle is not going to be used for a long time please remember to charge the batteries at least once every two weeks Karma recommends that both batteries be replaced if one battery is defective 6 6 Cleaning the Batteries If a battery is contaminated by dirty water battery acid dust or other soil the battery will discharge quickly Therefore please follow t
18. purchased for registration Warranty Form You may photocopy this from w o aas Dealer s Data Name of the Store Phone Number and Address If you have any suggestions on how to improve our products please don t hesitate contacting your local dealer to let us know what you think of your wheelchair Thank you and enjoy 56 National agent Sold and serviced by KARMA MEDICAL PRODUCTS CO LTD Http www KarmaMedical com E mail globalsales karma com tw KARMA reserves the right to modify information herein without further notice Karma reserves the right to modify information herein without further notice 104 45057 Rev 02 2015 01
19. symbols Improper use could lead the user to severe injury K WARNING or death i Improper use could lead the user to severe injury and or damage to your wheelchair Follow these instructions to keep the wheelchair in CE SUGGESTION N good condition 1 3 This manual includes the repair and maintenance chart as well as the Warranty Please keep it in a safe place or with the wheelchair 1 4 If someone else uses the wheelchair make sure that you give him or her this owner s manual for his or her reference 1 5 As designs change some illustrations and pictures in this manual may not correspond to the vehicle that you purchased We reserve the right to make design modifications without further notice 2 SAFETY 2 1 Before Driving 2 1 1 The user must be familiar with the use and operation of this wheelchair before driving 2 1 2 Therefore please always keep these safety guidelines in mind 2 1 3 For a visually impaired people be sure someone accompanies you in case you need assistance 2 1 4 The occupant shall have sufficient ability functional capability visual ability and cognizance to operate the wheelchair safely in its intended environment If not do not drive it 2 1 5 Do not let anyone touch the wheels actuator and armrest when they are in motion or being operated to avoid pinch injury 2 2 Traffic Rules 2 2 1 Pedestrian traffic rules apply to this wheelchair therefore please follow the rules 2 2 2 D
20. the healthcare field or persons fully conversant with this process and the driver s capabilities Incorrect settings could cause injury to the driver or bystanders and damage to the powered wheelchair and surrounding property To determine and establish your particular safety limits practice bending reaching mounting and dismounting activities in several combinations In the presence of a qualified healthcare professional BEFORE attempting active use of the powered wheelchair For individuals with balance problems practice mounting and dismounting activities WITH AN ASSISTANT in the presence of a qualified healthcare professional If anti tippers are standard equipment DO NOT operate the wheelchair without anti tippers being installed Anti tippers MUST BE attached at all times DO NOT attempt to reach objects if you have to move forward in the seat or pick them up from the floor by reaching down between your knees as this may cause loss of balance DO NOT lean over the back of the chair to reach objects behind you as this may cause the powered wheelchair to tip over DO NOT shift your weight or sitting position toward the direction you are reaching as the powered wheelchair may tip over DO NOT use an escalator to move a powered wheelchair between floors Serious bodily injury may occur DO NOT operate in car lanes on roads streets highways etc DO NOT attempt to move up or down an incline with water ice or
21. 5 12 6 Figure 5 12 7 e 5 12 4 Figure 5 12 5 24 Figure 5 12 6 Figure 5 12 7 5 3 9 Transferring In the Powered Wheelchair 5 3 9 1 Engage the freewheel levers and make sure that the controller is turned off 5 3 9 2 Flip up the footplates and swing the footrest to the side 5 3 9 3 Lower the user into the seat and use the armrest for support 5 3 9 4 Swing back the footrest and flip down the footplates so that the user can place his feet upon them 5 3 9 5 Turn on the controller 5 3 10 Transferring Ouf of the Powered Wheelchair 5 3 10 1 Make sure that the chair is as close as possible to the place you re transferring to 5 3 10 2 Engage the freewheel levers and make sure that the controller is turned off 5 3 10 3 Flip up the footplates and swing the footrests to the side 5 3 10 4 Shift your body weight out of the wheelchair to the place you re transferring to 5 3 11 Starting and Driving 5 3 11 1Make sure the wheelchair is turned off 5 3 11 2Make sure the freewheel level is engaged 5 3 11 3 Make sure the driver s seat is installed properly 5 3 11 4Make sure the armrests have been returned to the proper position 5 3 11 5 Turn the power ON If necessary turn on the headlights and taillights 25 5 3 11 6 Check the battery indicator and make sure there is enough power for your trip s If you have any doubt about the remaining power please charge the battery before you depart 5 3 11 57Set the speed dial to the pr
22. 7 5 9 A qualified technician can be found with an authorized distributor 45 ee a dealer 7 6 Transporting and Storing 7 6 1 Please refer to Section 5 3 7 Backrest Angle Adjustment to fold the backrest and detach the footrests 7 6 2 Carry the body of the wheelchair by the front and back frame using two people Do not lift the lower body by the casing or any detachable parts 7 6 3 Please store the wheelchair in a location where it is out of direct sunlight rain and dew 7 6 4 When stored for a long time please charge the batteries to full and then disconnect the battery terminals Please ask Karma dealer for the details When loading or moving the wheelchair in a vehicle be sure that every part that have been detached from the wheelchair is placed properly to prevent them from moving It could damage the vehicle or the wheelchair DO not detach any wiring or the steel wire 8 OPTIONAL ACCESSORIES The available optional accessories may be modified Please contact your dealer for more details 8 1 Leon Sling Seat 1 Parallel swing 2 Hand Bar 3 Lighting away controller 46 8 2 Leon Captain Seat L 1 Hand Bar 2 Lighting 9 TROUBLESHOOTING Trouble or Problems with Your Wheelchair You can inspect the following before taking your wheelchair to a KARMA wheelchair dealer Checking Points and Corrective Action Is the power turned OFF Turn ON the power Do the batteries still have power
23. E N OORT 3 AGENTA a E S 3 ZO RAMEOAC CTOS SINO aa a E a E ees 3 21O ircum tances tOO Oeae a a a a 3 2 11 Mobile Phones and Other Electric EQUIPMENT ccceeseseseseseseesesescscsesesesssseseseeeseseseeeees 4 Z LZ RAMOS y CIN SAna RODS Sirga a a S Gees 4 2 AS Wax tia SOP Wegnt OMN riscan mnechshadidvsiaabanbesabedaladenacaiens 5 24A Te COW SESS aS ING cancers nese A E a eter eee at ee 6 PEMER E D eee A eects mccain eee 7 3 1 Electromagnetic Interference From Radio Wave SOULCES cccssssessssesessssesessesessesesesseseseeseaeees 7 3 2 The Sources of Radiated EMI Can Be Broadly Classified into Three Types uu 8 3 3 Powered Vehicle Electromagnetic Interference EMI csessesessssesessesesessesessesssessesesceseseees 8 SANNAA OS og dessa astnc ta cae se ze pedacen fe OE 9 APART Senie cee nc seca E ces Secs tached AEREN AE 10 Ay AGO WAKE Ca Ota Seaton restncdsaytinacasteeseethe vec avanvesaslanlensdastewnaudbeteorss 10 la EOR WIU N aea ee OO ene Tea en ren co vor Tere eT re rr 12 OPE PhO Ne erara E Sesssecencacettintepdesencues socom E A eect ae dete 13 DE COMMONne PCa Ble Me LOCATON ste co sexsescosecs ices tvencyotiasd a io N a a RE 13 5 2 How to Operate Your Wheel cal ccceesesessesesessssesessssesesesesscsesescssesesesessesesesessesesesssaeseseeneaeeeeees 14 Do OW TO AGUS VOUT WW ING CLCIGIN ana T O AA 19 5 3 12 Installing the Seat Assembly on the Chassis cccscscsscsesessssesescssssesescssesesesesesseseecseeeaee 26 Os BAT ERIE
24. It depends on the specification of the wheelchair If they are pneumatic tires please refer to the tires pressure specified on the tire walls to maintain the tires at the correct pressure Do not let anyone touch the wheels when the wheelchair is in motion to avoid pinch injury When the tread depth is below 1 mm the tire does not have good traction This may lead to vehicle slippage and makes braking distances much longer Thus go to your Karma dealer to replace the tire as soon as possible if it has less than a 1 mm tread depth The tire pressure of all the front casters and the rear wheels must be kept at 35 40 PSI approx 2 46 2 81 kg cm or 2 415 2 76 bar 241 276 kPa for the best drive range maximum distance travelled per charge and usage handling Please refer to the tire pressure specified on the tire walls to maintain the tires at the correct pressure 7 4 General Maintenance 7 4 1 You must maintain the vehicle more frequently if you drive on grass sand or gravel roads often 7 4 2 Do not use water oil or other chemical solutions to clean your wheelchair Be sure NOT to spray the vehicle with water as not to damage the electronic components and PCB circuit board 7 4 3 Please clean the vehicle by wiping it with either a dry or moist cloth 7 4 4 Please take the vehicle to an authorized KARMA wheelchair dealer for 44 repairs and adjustments Improper adjustments could lead to wheelchair malfunction or an accident
25. Leon Series Static Stability Test RESUIt parsone anair 51 ST CSTE PA TSG GV EIN asc eeccer seats aN tedctates macs aattetcdatanenticeaie 52 OE Mi Mla UNH seeaeass caressa seata nasser E A E oa tuesemstees tata E A tae de 52 112 POS CONSUME RECY GINA renien AN 52 NARRANT a E T E eer er eer eee 53 dl Psy E 9 9 e E e E EE et E ATA E ee eens EEE E E T 53 TDD Contents or Waa N orrena qasaudetaning is tomaeead muuntanomnd uae 54 12 3 Warranty Duration and Parts Covered by the Warranty u ccccscsessesesesssesesesseseseseeteseeee 54 t24 teme NOU COV Cie pretest sccs sacs cecsses ces ecteesss acces AA 54 TZ SPO EMIS INCU CO CNC ON rears wes eit eee eee E 55 126 Fine Respons iDNES Orte USE fonrenn AE E E E A 55 127 Warnan y EMECUVENESS doioro nn AN 56 128 Iancter ot Waranty RIORTS aerieni aE E TEE 56 1 PREFACE Please carefully read this owner s manual before using the wheelchair Improper use of the wheelchair could result in harm injury or traffic accidents Therefore for safe and enjoyable use of the wheelchair please read this owner s manual 1 1 This owner s manual includes operation instructions for the aspects of the wheelchair assembly instructions and instructions on how to deal with possible accidents This owner s manual is written for Karma powered wheelchair s the Leon series LEN Sling Seat and LEN Captain Seat 1 2 The symbols used in this manual are explained below Pay special attention to the parts marked with these
26. SAIN DD CHARGER arisen nn E AS 33 6 LCnarging the BAM CII CS sessir nn E N O eta de eee 33 6 2 Charge the Batteries If Any of the Following Conditions OCCUIS sssssessesssessssssssesssesseen 34 6 3 Be Sure to Precisely Follow the Procedures Listed BelOW cccccsceesessssesesceteseseseeteseseeees 34 a EES We E E E EE A E AE EEE A EE N O E T AA 35 Ce Ban NO a E E aceite aes ea gaaetede tes eetat aes 36 6 CIS ANIA ELV B ALESIS S onines rn a red lev e E ET N NEE 37 G7 RED IACI LING BAL GINS S viana A A A 38 Je INSPECHON AND MAINTENANCE etcetera eaten crs tated tac esesett rs atria ae 41 FUSED AMI GUNS CG E E N E E EE E E D EE E E E REE 41 Aa Regular Maintenanca RECON oreas E A EE 42 7 Fo a oc a E E E E E E E ee ee 44 JA General Mantenan E att cassis cee ace a cs cence casahcde eds omtesbacacatneeceyetet slated 44 7 5 Suggested Maintenance Procedures 0 ccccccscsssessssesesessssesesessssesescesssesescssssesesessesesesesseseseeseseseeeees 45 1 6 Trans poring and StONNO eases ene ee terete renter ee tenon net R eer ate ent erent ur env 46 S OPTIONAL AGCE SS ORI 5 aprang T 46 CH iis SIAO A cts E eo tet sesesans eee stoi EE E ONA 46 BZ EON Capa SCAU tek scexin sete ecncncure tele dete a S 47 ORO UB EE Ss IOC TUNG eyes teeters etree die eens ate ea eee ti ese th ace 47 9 1 VRII Controller Battery amp Diagnostics Indicator ec ececesesessesesessesesescsssesesessseseseeseseseasees 48 TOS PETEA TON eer eter Pe Pe a nee ere 50 10 1 The
27. SURFACES Model Leon MAXIMUM USER WEIGHT 3 EMI RFI This section provides the user with basic information about the problems with EMI known sources of EMI and protective measures either to reduce the possibility of exposure or to minimize the degree of exposure This section also shows some conditions in which unexpected or erratic wheelchair movements may occur It is very important that you read this information regarding the possible effects of electromagnetic interference on your powered KARMA wheelchair 3 1 Electromagnetic Interference From Radio Wave Sources 3 1 1 Powered vehicles may be susceptible to electromagnetic interference EMI which is interfering electromagnetic energy EM emitted from sources such as radio stations Radio Frequency Interference TV stations amateur radio HAM transmitters two way radios and cellular phones The interference from radio wave sources can cause the powered vehicle to release its brakes move by itself or move in unintended directions It can also permanently damage the powered vehicle s control system The intensity of the interfering EM energy can be measured in volts per meter V m Each powered vehicle can resist EMI up to a certain intensity This amount of resistance is called its immunity level The higher the immunity level the greater the protection At this time current technology is capable of achieving at least a 20 V m immunity level whi
28. Un Locked 9 5 15 8 gt 21 7 Rear Wheels The Leon Series is equipped with powered tilt seatrest function Range the maximum driving distance per complete charge is estimated based on the following conditions 20 C 68 F an 80 kg driver brand new fully charged batteries and a constant driving speed of 10 km hr Karma s Quality Control team sets the parameters of your central relay box controller for optimum performance within the regulations of EN 12184 These parameters were double checked by the QC team before your scooter left our factory These parameters may be changed to suit certain individuals specific needs and requirements If you need the parameters changed please contact your dealer who will put you in contact with our agent They will know how to use the programmer properly to dial in your scooter for your optimum usage The programmer s effect on the performance quality can been seen in the above chart 51 Always keep the backrest of your seat in an upright position before driving up a slope That is when the backrest is tilted do not drive it on a slope Avoid turning suddenly and never try to climb and descend a ramp diagonally 11 CLEANING amp RECYCLING 11 1 Cleaning 11 1 1 In order to lengthen the life of your wheelchair it is suggested that you clean the wheelchair periodically if not daily especially after using it in the rain or snow 11 1 2 We suggest that you don t use your
29. ar Battery 6 7 1 9 Unfasten the battery strap Figure 6 11 6 7 1 10 Disconnect both wire terminals of the battery Figure 6 12 6 7 1 11 Hold the rear battery and slightly pull it out Figure 6 13 6 7 1 12 Place the rear battery on the ground Put aside the wires detached from the rear battery and keep them away from touching the terminals of the batteries to avoid any short circuit Figure 6 14 6 7 2 Load the Rear Battery 6 7 2 1 Load the rear battery back into the battery box Figure 6 15 Connect the red wire with the positive terminal the RED end Connect the black wire with the negative terminal the BLACK end Make sure the terminals are properly connected 6 7 2 2 Before placing the battery inside the battery box connect the battery cable to the power cable connectors Figure 6 15 39 6 7 2 3 Fixate the wires and the battery by pulling firmly on the battery strap Figure 6 16 Figure 6 15 Figure 6 16 Figure 6 17 6 7 3 Load the Front Battery 6 7 3 1 Load the battery back into the battery box Connect the red wire with the positive terminal the RED end Connect the black wire with the negative terminal the BLACK ena 6 7 3 2 Before placing the battery inside the battery box connect the battery cable to the power cable connectors Figure 6 17 6 7 3 3 Adjust the strap first to so that the remaining end of the strap is not protruding out of the battery box 6 7 3 4 Fixate the wires and the battery by pulling fir
30. ator shows only three or fewer signals After charging or replacing new batteries drive the wheelchair for 2 3 minutes to make sure the batteries are fully charged before going on a long journey In wintertime the batteries may respond slowly and the drive range may also be reduced You must store your wheelchair indoors above freezing temperatures When driving on an incline the battery indicator light might move up and down This is normal Even if the batteries are used properly their capacity will decay over time thereby reducing the drive range maximum distance traveled per full charge Thus when the drive range becomes about 50 of what brand new batteries would offer it s time to replace them with new batteries Otherwise the batteries may die unexpectedly leaving you in a possibly precarious situation The drive range will be shortened when driving frequently on slopes or uneven ground or over curb as this consumes more batter 5 2 13 Freewheel Lever The Leon series is supplied with a freewheel lever device to allow manual pushing of the powered wheelchair if required The freewheel lever is at the axle of the rear wheels 5 2 13 1 Freewheel Mode Turn the lever up to the upmost position The wheelchair will now roll freely Figure 5 1 1 5 2 13 2 Drive Mode Turn the lever downwards to the lowest position The wheelchair can be driven by motor power Ensure the lever is at the drive mode positon Figure 5 1 2
31. cate power on and provides an estimate of the remaining battery capacity Any green LEDs lit indicate well charged batteries If only amber and red LEDs are lit the batteries are moderately charged Recharge before undertaking a long trip If only red LEDs are lit the batteries are running out of charge Recharge as soon as possible 5 2 11 Tilt and Reclining Operation 5 2 11 1 Leon Captain Seat Manual Reclining 5 2 11 2 Leon Sling Seat Powered Tilt Powered Reclining 5 2 12 Tilt Operation 5 2 12 1 Turn the power on 5 2 12 2 Press the Seat Function Button once to toggle the control unit from Drive mode to Seat mode Powered tilt or recline function will be active as the Tilt Indicators or Recline Indicators are on 5 2 12 3 Moving the joystick backward to tilt or recline the seat The maximum tilting angle is 20 5 2 12 4 Moving the joystick forward will tilt or recline the seat towards the upright position Q WARNING DO NOT tilt the wheelchair on inclines or wet slipery icy or oily surfaces Only tilt the wheelchair on flat surfaces otherwise it might cause injury to the user The speed will be reduced to half while the seat is tilted at around 7 The powered wheelchair can not be driven while the seat is tilted over 15 Do not put fingers or clothes under the seat or backrest while seat functions are operated CE SUGGESTION It is recommended that you charge the batteries immediately when the battery indic
32. ch would provide useful protection from the more common sources of radiated EMI This powered vehicle model with no further modification has an immunity level of 20 V m without any accessories 3 1 2 There are a number of sources of relatively intense electromagnetic fields in our everyday environment Some of these sources are obvious 7 and easy to avoid Others are not apparent and exposure could be unavoidable However we believe that by following the warnings listed below your risk to EMI can be greatly minimized 3 2 The Sources of Radiated EMI Can Be Broadly Classified into Three Types 3 2 1 Hand held portable transceivers transmitter receivers with the antenna mounted directly on the transmitting unit such as citizens band CB radios walkie talkies security and fire or police transceivers cellular teleohones and other personal communication devices NOTE Some cellular telephones or similar devices transmit signals while they are ON even though they are not in use 3 2 2 Medium range mobile transceivers used in police cars fire trucks ambulances and taxis usually having the antenna mounted on the outside of the vehicle and 3 2 3 Long range transmitters and transceivers such as commercial broadcast transmitters radio and TV broadcast antenna towers and amateur HAM radios NOTE Other types of hand held devices cordless phones laptop computers AM FM radios TV sets CD players cassette pla
33. cket screw lock spring washer and flat washer to fix the seat 3 from the front of the seat Figure 5 13 3 5 3 12 4 Ensure the seat that is properly fastened on the chassis You can lift the seat up to test if it s loose If yes please tighten all bolts 26 5 3 12 5 Connect the controller joystick connector under the seat 2 Figure 5 13 2 Hair Pin Cotter Clevis Pin 60L M8 16L Screw Spring Washer Flat Washer M6 20L Screw Cup Washer M6 40L Screw Cup Washer M8 35LScrew M8 Nut 2 5 3 12 7 Take the seat assembly out of the package Figure 5 14 1 5 3 12 8 Erect the backrest to the upright position in order to make it easier to install the recline actuator Figure 5 14 2 Figure 5 14 1 Figure 5 14 2 5 3 12 9Insert part A into the bottom hole of the recline actuator Insert part B into the hole of part A in order to fix the recline actuator on the backrest frame Figure 5 15 Figure 5 15 5 3 12 9 Use part C to tighten the cable of recline actuator on the Aluminum tube Figure 5 16 Make sure the cable is properly routed to prevent it from being damaged or pulled when the actuator is operated between the uppermost position and the lowermost positon 28 Figure 5 16 5 3 12 10 Take the tilt actuator and the fixing bracket out of the package Insert part D into the hole on the rod of the tilt actuator Insert part B into the hole of part D in order to fix the tilt actuat
34. ding Instructions DO NOT under any circumstances cut or remove the round grounding prong from any plug Some devices are equipped with three prong grounding plugs for protection against possible shock hazards Where a two prong wall receptacle is encountered it is the personal responsibility and obligation of the customer to contact a qualified electrician and have the two prong receptacle replaced with a properly grounded three prong wall receptacle outlet in accordance with the National Electrical Code and local laws Do not use an extension cord when charging your batteries A risk of fire and or electric shock could be encountered BATTERIES The warranty and performance specifications contained in this manual are based on the use of deep cycle sealed lead acid batteries KARMA strongly recommends their use as the power source for this unit Refer to chapter 6 Carefully read the battery and charger information prior to installing servicing or operating your wheelchair RAIN TEST KARMA has tested its powered wheelchair in accordance with ISO 7176 Part 9 Rain Test This test provides the end user or his her attendant sufficient time to remove his her powered wheelchair from a rainstorm and retain operation However the Leon series is not designed for usage in rain or storms or under other circumstances where it may be exposed to high levels of moisture such as e deep pools of water e pressure washing of the chair
35. evices from your wheelchair s batteries 2 12 Ramps Inclines and Drops 2 12 1 Do not drive onto a steep ramp Refer to Safe Slope in Section 10 SPECIFICATIONS for your wheelchair s maximum climbing angle 2 12 2 When climbing up to an inclined road please set the speed higher than the medium speed and drive carefully Figure 2 3 2 12 3 When going down an inclined road set the speed to 1 and never use reverse 2 12 4 Do not drive on a road with many bumps and holes close to each other such as potholes or washboard roads Figure 2 4 2 12 5 Do not make sudden turns when driving on gravel roads or ramps 2 12 6 The maximum obstacle climbing ability is 6 cm for the Leon series Exceeding this obstacle height will damage your wheelchair and void your warranty Figure 2 5 2 12 7 When negotiating an obstacle please slow down Put your seat into the full upright position and approach it head on perpendicular 2 12 8 Just before the obstacle speed up until the entire wheelchair has conquered the obstacle Negotiating an obstacle at an angle may cause your wheelchair to tip over Don t do it 2 12 9 When climbing down a curb slow down just before you get to it and only speed up after the entire wheelchair has lowered to the road 2 12 10 Again descending obstacles should be done perpendicularly Figure 2 6 2 12 11 Karma does not design wheelchairs to take jumps over or off obstacles Doing so will void your warranty
36. formance Check the warranty section of this manual to find out what Karma guarantees and the maintenance service and parts that are not covered by the warranty Karma does not have an official list of service providers at this time Please contact your dealer for service If you cannot contact your dealer please contact another authorized Karma dealer for service If all else fails contact Karma directly via our website or give us a call and we can refer you to your new service provider CLASSIFICATION amp INTENDED USE Karma Leon series are classified as a class B mobility product for indoor and VI outdoor use It is designed for an individual with mobility disabilities This wheelchair is suitable for one single user up to 140 kg in weight It also has an extremely durable aluminum and iron frame with safe accessories that provides consistant performance even in dramatic extremes of temperature neither the user nor the attendant need to touch any metal parts In normal use Check with your local government as to legislation pertaining to mobility vehicles to assure your legal requirements to drive on public roads have been met i e a pelvic belt lighting registration or licensing CE MARKING This powered wheelchair complies with the requirements of the Medical Devices Directive 93 42 EEC Before purchasing and using Karma wheelchairs please consult qualified professionals so as to ensure that you choose su
37. fortunate individuals and protect our planet for future generations 11 2 5 If you do not have access to the world wide web please use your local phone directory ask for operator assistance or go to your local government center for more information 11 2 6 Various parts of this wheelchair should be recycled to the collection and recycling location nearest to you Earth Day Is every day Check with your local recycling center on where and how to recycle used batteries as this information varies from region to region 12 WARRANTY 12 1 Serial Number To ensure after sale service and warranty please record and fill in the vehicle identification number The serial number can be found on the steering column below the control panel Mott 53 12 2 Contents of Warranty 12 2 1 Repair will be provided free of charge if the problems are due to manufacturing or defective components within the warranty period a repair of this kind will hereafter be called warranty repair 12 2 2 The warranty repair can be performed by authorized KARMA wheelchair dealers only 12 2 3 KARMA is not responsible for the transportation costs for repair and replacement 12 2 4 Replaced parts will be the property of KARMA 12 3 Warranty Duration and Parts Covered by the Warranty Please contact your local dealer 12 4 Items Not Covered The items listed below are not covered 12 4 1 Consumable parts such as brake shoes or pads clutch shoe and li
38. he following steps to clean the battery 6 6 1 Turn the power OFF 6 6 2 Use a clean cloth to wipe off the soiled part of the wheelchair around the battery 6 6 3 Clean the terminals and inside of the battery clamps by using a battery cleaning tool wire brush or medium grade sandpaper Upon completion these areas should be shiny not dull 6 6 4 Examine the battery clamps terminals for corrosion if the terminal is covered by white powder please stop using the battery due to it indicates that there s possible leakage of the battery Please replace the batteries 6 6 5 Carefully dust off all metal particles 37 6 7 Replacing the Batteries Karma strongly recommends that bettery replacement and installation always be done by a qualified technician To replace the batteries please refer to the photo below of the batteries equipped on the Leon series and follow the below instructions to remove and load the batteries The weight of one battery could be more than 10 kg Please handle it with care WARNING Do turn off the power of the wheelchair before replacing or loading the batteries Do NOT allow conductive material such as a wrench to contact BOTH battery terminals at the same time This will result in a short that can cause burns to you and damage the battery Most batteries are not sold with instructions However warnings are frequently noted on top of the batteries Read them carefully Do NOT allow the liquid i
39. he occupant other operations should be carried out by an assistant Anything wheelchair related that requires tools should be done by your authorized Karma service provider 5 1 Controller Cable Tie Location 5 1 1 The controller for the Leon series is packaged in the carton after opening the carton the controller needs to be equipped to the correct position by fastening two screws 5 1 2 In the case that the controller cable ties becomes loose please refer to the below figure for the locations to fasten the cable ties and follow the instructions 5 1 2 1 At Section A see the figure below loosen the cable and leave some of the cable hanging because it facilitates the armrest height adjustment 5 1 2 2 At Section B see the figure below cross the cable tie around the screw It provides better fixation and keeps the cable tie from sliding out of place 5 1 2 3 The other areas circled also indicates the cable tie locations Controller Cable Tie Locations The controller cable must be fixed as instructed above otherwise the cable could be damaged and cause malfunction of the wheelchair 5 2 How to Operate Your Wheelchair Control Panel With Lighting Control No Actuator Leon Control Panel Figure 5 1 1 Battery Gauge 2 ON OFF Button 3 Headlight Taillight Indicator 4 Horn Button 5 Headlight Taillight Button 6 Speed Indicator 7 Speed Increase Button 8 Right Turn Signal Indicator
40. his could cause unexpected failure of the device and the powered wheelchair KARMA specifically disclaims responsibility to all personal injury and property damage that may occur during use which does not comply with applicable federal state and local laws and ordinances DO NOT stand on the footplates of the powered wheelchair DO NOT use the wheelchair when the back is folded This alters the centre of gravity and may cause the wheelchair to tip backwards The back should only be folded for storage or transport of the wheelchair DO NOT hang anything on the backjoints that could cause the backrest folding suddenly and may cause injury DO NOT be towed by other vehicles cars motorcycles or bicycles etc Only use freewheel mode on flat surfaces since your electromagnetic brakes are not engaged in this mode without these brakes it will roll down a hill causing injury or damage Never drive under the influence of alcohol or medication DO NOT sit in the powered wheelchair within a moving vehicle unless it has been affixed the labels of hook mark The wheelchair cannot be used as seats in any vehicles That is KARMA recommends that users are NOT transported in any vehicle while seated in the wheelchair In the case of accident or a sudden stop the user could be thrown from the wheelchair and get injured The suggested solution is to transfer the user from the wheelchair into a normal seat of the vehicle and to securely s
41. itable products and use them correctly as well For safety reasons if there is any risk due to the user s movement in the wheelchair or other environmental factors that might cause the wheelchair to tip or the person on the wheelchair to fall off Karma recommends that you install anti tippers pelvic belt or other additional safety accessories WARNING When prescribing wheelchairs for use by full or partial amputees above or below knee single or double or other conditions that affects the user s natural centre of gravity and might cause the wheelchair to tip or the person on the wheelchair to fall off we suggest contacting your therapist or dealer as well as attaching anti tippers pelvic belt safety belt or other additional safety accessories When using the wheelchair ALWAYS follow the Highway Code or your local traffic regulations when outdoors and the guidelines written in this manual VIII TABLE OF CONTENTS Se Pe ace ae see ete pect cae eee ease tec eaten E E kace A poses E teed ae 1 ORGS 2 Gl cdl i Geren re ore Re mee eran earner ee ee meer eae ae Een ee Ser oe eae ee en eee ee eee ae 2 EBETE DIVIN n E E E E ernie ever 2 2 LERO a A E EOR 2 BP E O DIN e ee er ee ne er ene er ete ee ee 2 ZENON Senge ea sencte cet capstan see setee acest saatnetag cscs mrnssts arena aataie ash pee oarets Soeece ia tamee tee edieteces 3 29 NO FAUNA Heavy GO OS aeren rn A eons dc hake E N aes 3 ZORI e E E el E 3 ZI NN WS DUVA Cte an A A
42. leted The battery life will be seriously shortened or decayed if the batteries are repeatedly used without being fully charged Therefore be sure to always charge the batteries fully Always complete the charging when the LED light turns green NEVER stop charging before it is completed When finished charging disconnect the charger plug from the charging socket as soon as possible Even when the charger is turned OFF the electric power will slowly discharge if the cord is not disconnected DO NOT leave the charger ON connected to the wheelchair for more than 12 hours Charging time depends on the surrounding temperature it takes longer in the winter Please follow the guidelines below to avoid accidents while charging Be sure to only use a KARMA approved battery charger and charge the battery completely every time The battery can be damaged if a non genuine charger is used Never disassemble or modify the charger This will void the warranty Please charge in a well ventilated area where the battery is not directly exposed to sunlight Do not charge the battery under rainfall in morning dew or in an area where the humidity is high Do not cover the wheelchair with any waterproof cloth or other objects while charging Don t charge in temperatures lower than 10 C 14 F or higher than 50 C 122 F as the charger may not work well and the battery may become damaged The charger is not guaranteed to be water resis
43. loosen the two bolts under the seat Remove the bolts on the other side Figure 5 8 1 5 3 5 2 There are two evenly spaced holes for incremental adjustments which is in increments of 25 4 mm 1 The total range of adjustment is 50 mm Figure 5 8 2 5 3 5 3 Move the seat forward or backward to the desired position 5 3 5 4 Re tighten the bolts Figure 5 8 1 A 7 a 4 r F r f e A m_i mh A a K ry a f i hee fen e y oe N J 9 ie n 9 EN z k 20 O AN if Y aai i y is i As gt i ks i i AF kan om 4 1 Ps at i Hii SK 09 2 2 2 SSSA 5 A rs i k M fr ae l 2 F r Bij is fia A k a a W a a al x nO pes i i a in a i F hy 7 i J gt d J Ta L os Ll k ee a he f _ i coe li i hy i 2 i ne e m r r E a My 7 T e L te eg LE r a tq gee pr R e r 1 F F i a Figure 5 8 2 5 3 6 Seat Angle Adjustment Leon Sling Seat with Tilting Function 5 3 6 1 The initial seat angle is set at 2 22 5 3 6 2 If the desired seat angle can be 5 pull out the hair pin cotter and clevis pin from the lower hole Figure 5 9 1 and insert them in the Figure 5 9 1 Figure 5 9 2 Leon Sling Seat without Tilting Function The initial seat angle is set at 2 If the desired seat angle can be 5 Lossen the screws at both the left side and right side from the lower hole Fig
44. lower or higher voltage position it will cause damage to the charger and change the 115V lt gt 230V 35 switch settings only when charger is disconnected from AC line voltage WARNING The fan inside the charger will start to work when you turn on the charger for 8A charger will start to work as the temperature reaches higher than 50 C and stop running when the temperature is lower than 50 C If you find that the fan does not function properly DO NOT use the charger Otherwise the charger may overheat and start a fire 6 5 Batteries 6 5 1 Do not expose the batteries to temperatures below 10 C 14 F or above 50 C 122 F when charging or storing the vehicle 6 5 2 Exceeding the specified temperature range can lead to either freezing or overheating of the batteries This will damage the batteries and shorten their lives 6 5 3 The batteries used on your wheelchair are maintenance free sealed lead acid batteries Thus it is not necessary to change or refill the battery liquid Q WARNING Do not open the battery seal cap at any time After ANY adjustments repair or service and BEFORE use make sure that all hardware is tightened securely Otherwise injury or damage may occur When removing installing batteries keep all foreign objects especially metal away from battery terminals When the batteries fail to function for environmental and safety concerns please contact any local recycle unit
45. mly on the battery strap Fasten the strap firmly Figure 6 18 6 7 3 5 Re tighten the screws on the battery casing Figure 6 19 Figure 6 18 Figure 6 19 WARNING There are many risks involved with improper disposal of batteries whether damaged or not Batteries may contain heavy metals and be considered hazardous waste Many regions around the world now strictly enforce laws to help protect our environment By not disposing of batteries properly you may be liable for fines from your local through national government By not recycling batteries they end up in landfills where lead and other chemicals may leach into streams and rivers destroying ecosystems and poisoning local water resources Improper disposal of batteries may also cause injury to unsuspecting others that come in contact with them If you come in contact with fluids or corroded powder from a battery rinse with water and contact a physician if necessary If contact with eyes occurs rinse for 15 minutes and then visit a physician DO NOT incinerate or burn the battery It will cause it to explode Please see the end of Section 11 Cleaning amp Recycling for more information from your KARMA wheelchair dealer for cleaning and replacing the batteries 7 INSPECTION AND MAINTENANCE 7 1 Daily Check Check the following items before driving If you find anything abnormal visit your KARMA wheelchair dealer for further inspection before using it
46. n the battery to come in contact with skin clothes or other items It is a form of acid and may cause harmful or damaging burns Should the liquid come into contact with skin rinse the area immediately and thoroughly with cool water If liquid comes into contact with eyes flush eyes immediately and seek medical attention as soon as possible The use of rubber gloves and chemical goggles are recommended when working with batteries NEVER smoke or strike a match near the batteries Replace the batteries IMMEDIATELY if there are any cracks or leaks 6 7 1 Remove the Batteries Remove the Front Battery 6 7 1 1 Remove the two screws on the battery casing in the front of the wheelchair Figure 6 3 6 7 1 2 Remove the battery casing Figure 6 4 6 7 1 3 Unfasten the battery strap Figure 6 5 6 7 1 4 Place the front casing aside and pull the lighting connectors and the battery connectors out Figure 6 6 6 7 1 5 Unplug the lighting connectors Figure 6 7 6 7 1 6 Disconnect both wire terminals of the battery Cap the wire terminals to avoid any short circuit Figure 6 8 6 7 1 7 Hold the front battery and slightly pull it out Figure 6 9 6 7 1 8 Place the front battery on the ground Put aside the wires detached 38 from the front battery and keep them away from touching the terminals of the batteries to avoid any short circuit Figure 6 10 Figure 6 9 aa Figure 6 11 l Figure 6 12 Figure 6 13 Figure 6 14 Remove the Re
47. ning light bulbs fuses upholstery and seating brake cable oil seal packing and gasket screws bolts and washers lubricant oil and grease carbon brush inside the motor battery liquid footrest carpet et cetera 12 4 2 Those that do not affect the quality and functioning of the wheelchair such as noise or vibration 12 4 3 Wear and tear resulting from usage as well as conditions resulting from lapse of time e g normal aging and deterioration of paint electroplating plastic parts etc 12 4 4 Damage due to a lack of maintenance or improper operation and storage 12 4 5 Fees for routine inspections adjustments adding oil cleaning and other maintenance 12 4 6 Fees for regular inspections and maintenance and 12 4 7 Any fees incurred as a result of warranty repair loss or compensation because of the unavailability of the wheelchair telephone use shipping car rental travel costs et cetera 54 12 5 Problems Not Covered Problems caused by the following reasons are not covered 12 5 1 Failure to carry out the regular inspection and maintenance recommended by this owner s manual 12 5 2 Improper storage 12 5 3 Tampering by changing or adding components to the vehicle which are not approved by KARMA 12 5 4 Damage caused by using non KARMA genuine parts or other parts not recommended by KARMA 12 5 5 Abuse or misuse of the vehicle such as driving over curbs and overloading the wheelchair with passengers or goods
48. oper level 5 3 11 8 Be sure the controller is in good condition 5 3 11 9 Make sure the electromagnetic brake is in good working order 5 3 11 10Always make sure that your surroundings are safe to operate the wheelchair Do not turn the power OFF while driving as this will lead to an abrupt stop and possible injury Do not set the speed dial on high while driving indoors Do not adjust the speed dial while driving A sudden change to the highest speed may endanger you and cause failure to your wheelchair Do not place magnetic devices near the controller as this may affect the operation of your wheelchair Be careful while driving in heavy traffic and crowded areas While reversing the vehicle be aware of the people and objects behind you If anti tippers are standard equipped DO NOT operate the wheelchair without anti tippers being installed Anti tippers MUST BE attached at all times 5 3 12 Installing the Seat Assembly on the Chassis warnine For your own security read and obey all the instructions before proceeding the installation If the seat assembly and the chassis are packed in different package when delivered follow the following steps to install the seat Captain Seat 5 3 12 1 Put the captain seat on the chassis 1 and move it forwards 2 Figure 5 13 1 5 3 12 2 Ensure the bolt on the chassis to slide into the slot under the seat 1 Figure 5 13 2 5 3 12 3 Use one M10 35L button head hex so
49. or on the fixing bracket Figure 5 17 Part D shall be inserted into to the lower hole A Do not insert part D into to the upper hole Figure 5 17 29 5 3 12 11 Cut the tie which is used to fasten the seat frame and the fixing base before installing the fixing bracket in the fixing base Figure 5 18 5 3 12 12 Use part E to fasten fixing bracket on the seat frame There are four sets of screws and nuts Two sets are used for either side Figure 5 19 Figure 5 19 5 3 12 13 Insert part A into the hole on the base of the tilt actuator Insert part B into the hole of part A in order to fix the tilt actuator on the seat frame Figure 5 20 1 5 3 12 14 Connect the connector of the tilt actuator to the connector fixed p on the right side of the seat frame Figure 5 20 2 Figure 5 20 1 Figure 5 20 2 30 5 3 12 15 Put the rear part of the seat assembly on the interface plate Figure 5 21 1 Figure 5 21 1 Figure 5 22 2 5 3 12 16 Push the seat backwards and ensure the fixing pins on the interface plate are properly seated in the slots under the seat frame Figure 5 21 2 5 3 12 17 Use part F to fix seat frame Make sure the two screws are properly tightened Figure 5 22 O S fde s Figure 5 22 5 3 12 18 Connect cables of tilt actuator recline actuator speed limitation angle limitation and the controller which are under the seat Figure
50. owered vehicle OFF as soon as it Is safe Some stores may have automatic sensor doors and alarm systems set at certain frequencies that might affect your powered wheelchair 3 4 4 Be aware that adding accessories components or modifying the powered vehicle may make it more susceptible to EMI There is no easy way to evaluate their effect on the overall immunity of the powered vehicle 3 4 5 Report all incidents of unintended movement or brake release to your powered vehicle dealer or KARMA and note whether there was a source of EMI nearby 4 PARTS 4 1 Leon with Captain Seat a A y KNEES QS jos OF ia A 10 Footrest Y U Ln 1 Headrest 11 Calf Support 12 Footplate S U D Y gt O L E O U LO 2 Captain Seat 7 Pelvic Belt Backrest 3 Armrest 8 Charger Socket 9 Captain Seat 4 Rear Wheel 10 1 Front Tiedown 4 Rear Tiedown 7 Tail Light optional 2 Head Light optional 5 Anti tipper 8 Turning Signal optional 3 Freewheel Lever 6 Battery Casing Standard equipments are subject to change without notice 4 2 Leon with Sling Seat 1 Headrest optional 5 Rear Wheel 9 Charger Socket 2 Sling Seat Backrest 6 Caster 10 Sling Seat 3 Armrest 7 Controller JJoystick 11 Footrest 12 Footplate 4 Pelvic Belt 8 Side Panel 5 OPERATION Except the joystick control panel can be operate by t
51. rive only on pedestrian areas such as the sidewalk Never drive the wheelchair on the highway 2 2 3 Be aware of other vehicles when crossing all roads 2 2 4 Be extremely cautious when driving your wheelchair in heavy traffic or the shopping mall 2 2 5 DO NOT drive your wheelchair when you feel tired or consume alcohol 2 2 6 Please do not drive your wheelchair at night 2 2 7 Please follow pedestrian traffic lights and comply with the traffic regulation 2 3 Practice Driving 2 3 1 Before you are familiar with the operation of your wheelchair please practice in a wide and open area like a park When you drive the wheelchair for the first time do not set out alone and make sure that you have assistance close by if you need help 2 3 2 To avoid falling off your wheelchair please practice all kinds of driving 2 motions such as accelerating stopping turning reversing and going up and down ramps 2 3 3 Please set the soeed to medium when you first start practicing 2 3 4 Be sure you are able to control and operate your wheelchair easily and confidently before you set the speed higher 2 4 No Passengers KARMA wheelchair Is limited to only one single driver Do not carry passengers including children on your wheelchair 2 5 No Hauling Heavy Goods Do not use this wheelchair to carry or haul heavy goods The maximum weight that can be carried including goods is stated beside Max User Weight in Section 10 SPECIFICATIONS
52. t other operations should be carried out by an assistant Anything wheelchair related that requires tools should be done by your authorized Karma service provider 6 1 Charging the Batteries Before you attempt charging ensure you read and understand the instruction manual supplied with the battery charger and you choose the correct input voltage for battery charger 33 6 2 Charge the Batteries If Any of the Following Conditions Occurs 6 2 1 You have used your wheelchair for more than an hour continuously 6 2 2 You ve used more than one quarter of the total charge 6 2 3 When you haven t used the wheelchair for more than two weeks 6 2 4 If the current charge is not enough to reach your final destination 6 3 Be Sure to Precisely Follow the Procedures Listed Below 6 3 1 Turn the wheelchair OFF 6 3 2 Connect the charger s cord to a power outlet 6 3 3 Then connect the charger s round plug Figure 6 1 to the charging socket Figure 6 2 6 3 4 The orange LED will light up as soon as the charging starts The charging time is at least 8 hours but it could be as long as 12 hours depending on the status of the batteries and the temperature 6 3 5 The orange LED will change to green when the charging is completed 6 3 6 Turn off the charger disconnect the cord and pull out the round plug from the charging socket Figure 6 1 Figure 6 2 CE SUGGESTION Do not disconnect the charger cord if the charging is not comp
53. tant Valve Regulated Lead Acid batteries do not have a memory function like cell phone batteries have Please get in the habit of recharging your VRLA batteries frequently New batteries MUST be fully charged prior to initial use of the powered wheelchair Always charge new batteries before initial use or battery life will be reduced As a general rule recharge batteries as frequently as possible to assure the longest possible life and to minimize required charging time Plan to recharge them when use of the powered wheelchair is not anticipated WARNING Keep your wheelchair away from flammable objects while charging as it may lead to fire or explosion of the battery When the batteryies are charged they may produce hydrogen Therefore do not smoke while charging and charge in a well ventilated area Never connect or disconnect the plug cord with wet hands or if the plug cord is wet to avoid possible electric shock Never attempt to recharge the batteries by attaching cables directly to the battery terminals or clamps DO NOT jump start your wheelchair Do NOT attempt to recharge the batteries while the powered wheelchair is in operation 6 4 Charger The battery charger supplied by Karma is for indoor use only it must be protected from moisture and external heat source Before charging make sure to set the 115V lt 5230V switch to match the local AC voltage If the switch is improperly set to a
54. tow the wheelchair in a separate compartment DO NOT touch the surface of motors It could be hot Store your chair in a clean dry area If you fail to do so parts may rust or corrode The product meets all the requirements of ISO 7176 14 The force necessary to operate the freewheel lever is less than 60N We estimate a life expectancy of five years for the product provide it is used strict accordance with the intended use as set out in this document and all maintenance and service requirements are met The estimated life expectancy can be exceeded if the products is carefully used and properly maintained The life expectancy can be reduced by extreme or incorrect usage RAMPS DO NOT climb go up or down ramps or traverse slopes greater than the safe climbing angle for your model specified in Section 10 Specifications When negotiating ramps if the joystick is released while moving forward the powered wheelchair will roll backwards approximately one foot before the brake engages If the joystick is released while in reverse the powered wheelchair will roll backwards approximately two and a half feet before the brake engages Be sure to reduce your speed when driving on curved roads or making a turn do not drive at full soeed Please drive at a slower speed so you have complete control of the wheelchair ELECTRICAL Check to ensure that all electrical connections are secure at all times IV Groun
55. uctions 5 3 3 1 Use the 13 box end Wrench from KARMA Tool Kit to loosen the bolt at the side of the footplate Figure 5 5 1 5 3 3 2 Adjust the footplate height Figure 5 5 2 and re tighten the bolt Figure 5 5 3 20 Figure 5 5 1 Figure 5 5 2 Figure 5 5 3 When adjusting the footrest or the footplates the user s legs should be supported or kept safe from possible injury 5 3 4 Armrest Height Adjustment 5 3 4 1 Leon with Captain Seat In order to position the user s arms and shoulders correctly there are three evenly spaced holes for incremental adjustments which is in increments of 30mm Use the 5 Allen Key Wrench from KARMA Tool Kit to loosen the height adjustment bolts under the armrest pad Figure 5 6 1 Adjust the armrest to the proper height Figure 5 6 2 Finally re tighten the bolts Figure 5 6 3 Figure 5 6 1 Figure 5 6 2 Figure 5 6 3 5 3 4 2 Leon with Sling Seat In order to position the user s arms and shoulders correctly the armrests are adjustable in height by 7 cm from 18 cm above the seat rail to 25 cm Use the 5 Allen Key Wrench from KARMA Tool Kit to loosen the height adjustment bolts under the armrest pad Figure 5 7 1 Adjust the armrest to the proper height Finally re tighten the bolts Figure 5 7 2 21 i Karma Figure 5 7 1 Figure 5 7 2 5 3 5 Seat Forward or Backward Adjustment Seat Depth Leon with Sling Seat 5 3 5 1 Use the 13 box end Wrench from KARMA Tool Kit to
56. ure 5 9 2 and insert them in the upper hole 5 3 7 Backrest Angle Adjustment Leon with Captain Seat 5 3 7 1 The level for adjusting the backrest angle is at the left side in the lower back of the backrest Figure 5 10 1 5 3 7 2 Hold the backrest frame with one hand and adjust the backrest angle to your desired angle See Figure 5 10 2 5 3 7 3 Release the level when the desired angle is reached If the seat width is 18 the angle can be adusted from 0 65 If the seat width is 20 the angle can be adusted from 0 45 Figure 5 10 1 Figure 5 10 2 Leon with Sling Seat Manual Recline 5 3 7 4 Behind the backrest there is an adjusting knob for at eat side of it Figure 5 11 1 Hold the backrest and use a 13mm open end wrench to 23 remove knobs and nuts Adjust the backrst to the desired angle Figire 5 11 2 Retighten knobs to fasten the backrest The range of adjustable angle is between 1 11 Figure 5 11 1 Fiouie 5 11 2 5 3 8 Headrest Adjustment Leon with Captain Seat Press the button below the headrest and adjust the location of headrest Figure 5 12 1 and 5 12 2 Figure 5 12 1 Figure 5 12 2 Figure 5 5 12 3 Leon with Sling Seat Use the 4 Allen Key Wrench to loose the screw below the headrest There are four evenly spaced holes for incremental adjustments The total range of adjustment is 50 mm Figure 5 12 3 Adjust the headrest to the desired position Figure 5 12 4 Figure 5 12 5 Figure
57. use an escalator to move a powered wheelchair between floors Serious bodily injury and damage to the wheelchair may occur VI YOU AND YOUR KARMA SERVICE PROVIDER No tools are required for assembly Your wheelchair should be assembled by your authorized Karma dealer Your authorized Karma dealer is also your service provider Unauthorized repairs upgrades and add ons will void your warranty Anything wheelchair related that requires tools should be done by your authorized Karma service provider Your Karma service provider has the necessary service manual for your wheelchair If you have any defective parts or lose any parts please contact your dealer for repair and or replacement Please only use parts authorized by karma Use of parts that are not authorized by Karma will void your warranty Part numbers are listed on our bill of materials explosion drawings which we give to our authorized dealers and service providers Customers should order parts through their dealer as well as all repairs and scheduled maintenance Customers should go to their dealership for all service needs to guarantee their warranty is not void Always go to an authorized service provider Unauthorized repairs will void your warranty Procedures other than those described in this manual must be performed by a qualified technician They also have the service manual with a complete list of maintenance required to keep your Karma wheelchair in top per
58. wheelchair in the rain or snow 11 1 3 If you are traveling and get caught in the rain we suggest you try to find a shelter and turn OFF your wheelchair while waiting it out 11 1 4 If you can t find shelter proceed to your destination However we do not recommend you do this often as it may shorten the life of your wheelchair or cause damage 11 1 5 Driver s seat upholstery use soapy water Wring out the sponge cloth before scrubbing Do not use the wheelchair until it is dry 11 1 6 Frame wipe with a damp cloth but be sure not to splash spray the wheelchair with water as doing so may damage the motor electrical wiring and battery 11 1 7 If compressed air is available you can use the compressed air to clean your wheelchair do not exceed 7K and keep the nozzle at least 10 cm away from your wheelchair 11 1 8 Casing wipe with a damp cloth After it is dry coat the casing with a light layer of wax if desired 11 2 Post Consumer Recycling 11 2 1 A post consumer recycling plan should follow the Environmental Protection Administration s regulations 11 2 2 The items listed below are for reference only as local law and 52 regulation may vary Aluminum alloy Recyclable 11 2 3 There are many organizations in many countries you can find on the internet that will accept used goods for charity or disassemble electronic equipment and batteries to recycle them 11 2 4 Please search the information highway to help less
59. yers and small appliances such as electric shavers and hair dryers et cetera so far as we know are not likely to cause EMI problems 3 3 Powered Vehicle Electromagnetic Interference EMI Because EM energy rapidly becomes more intense as one moves closer to the transmitting antenna source the EM fields from hand held radio wave sources transceivers are of special concern It is possible to unintentionally bring high levels of EM energy too close to the powered vehicle s control system while using these devices This can affect your powered vehicle s movement and braking Therefore the warnings listed below are recommended to prevent possible interference with the control system of 8 the powered vehicle 3 4 Warnings Electromagnetic interference EMI from sources such as radio and TV stations amateur radio HAM transmitters two way radios and cellular phones can affect powered vehicles and motorized wheelchairs Following the warnings listed below should reduce the chance of unintended brake release or powered vehicle movement which could result In serious Injury 3 4 1 Do not operate hand held transcelivers receivers such as citizens band CB radios or turn ON personal communication devices such as cellular phones while the powered vehicle is turned ON 3 4 2 Be aware of nearby transmitters such as radio or TV stations and try to stay away from them 3 4 3 If unintended movement or brake release occurs turn the p

USER MANUAL-Leon

Contents

Download Pdf Manuals

Related Search

Related Contents